Technical Service Bulletins (TSBs) for the 2011 Corolla are official communications between Toyota & their dealerships that describe processes for troubleshooting or fixing certain common problems.
All vehicle manufacturers are required by U.S. law to make their TSBs available to the public.
Some customers have experienced amber colored oil like substance found on floor mats. Further investigation reveals the electric power steering column showing signs of the oiling substance leaking Read More »
Some customers have experienced amber colored oil like substance found on floor mats. Further investigation reveals the electric power steering column showing signs of the oiling substance leaking Read More »
TOYOTA: OVER TIME, A PERCEPTIBLE, BUT SLIGHT INCREASE IN BRAKE PEDAL TRAVEL AND WILL NOT EFFECT BRAKING PERFORMANCE, BUT TO ADDRESS THIS CONDITION, AN IMPROVED REAR DRUM BRAKE ADJUSTERS WAS DEVELOPED. MODELS 2009-2013 COROLLA. Read More »
TOYOTA: NEW, REAR DRUM BRAKE ADJUSTERS WAS DEVELOPED TO PREVENT PERCEPTIBLE INCREASE IN BRAKE PEDAL TRAVEL CONDITION BUT NOT EFFECTING BRAKE PERFORMANCE. MODEL 2009-2011 COROLLA. Read More »
TOYOTA: OVER TIME, A PERCEPTIBLE, BUT SLIGHT INCREASE IN BRAKE PEDAL TRAVEL AND WILL NOT EFFECT BRAKING PERFORMANCE, BUT TO ADDRESS THIS CONDITION, AN IMPROVED REAR DRUM BRAKE ADJUSTERS WAS DEVELOPED. MODELS 2009-2013 COROLLA. Read More »
TOYOTA: NEW, REAR DRUM BRAKE ADJUSTERS WAS DEVELOPED TO PREVENT PERCEPTIBLE INCREASE IN BRAKE PEDAL TRAVEL CONDITION BUT NOT EFFECTING BRAKE PERFORMANCE. MODEL 2009-2011 COROLLA. Read More »
"WPB: THE ENGINE IS COVERED UNDER THE TOYOTA NEW VEHICLE LIMITED WARRANTY FOR 5 YEARS FROM THE DATE OF FIRST USE OR 60,000 MILES (WHICHEVER OCCURS FIRST). Read More »
"WPB: THE ENGINE IS COVERED UNDER THE TOYOTA NEW VEHICLE LIMITED WARRANTY FOR 5 YEARS FROM THE DATE OF FIRST USE OR 60,000 MILES (WHICHEVER OCCURS FIRST). Read More »
DD: IN LIMITED CASES VEHICLES BEING SERVICED FOR ZE7 WILL REQUIRE A REPLACEMENT SHORT BLOCK. DEALERS WILL NEED TO INSTALL THE DOWEL PINS BETWEEN THE SHORT BLOCK AND LOWER CRANKCASE WHEN PERFORMING THIS REPAIR. Read More »
"TT: BASED ON CURRENT PART ORDER ALLOCATION, SOME PISTON TYPES HAVE BEEN INCORRECTLY IDENTIFIED WHILE UNDERGOING THE ZE7 2AZ OIL CONSUMPTION REPAIR PROCEDURE. Read More »
"TSB: SOME 2006 ? 2013 MODEL YEAR VEHICLES EQUIPPED WITH THE 2AZ ENGINE MAY EXHIBIT ENGINE OIL CONSUMPTION. THE PISTON ASSEMBLY HAS BEEN CHANGED TO MINIMIZE OIL CONSUMPTION. USE THE FOLLOWING REPAIR PROCEDURE TO ADDRESS THIS CONDITION. Read More »
TT: THERE HAS BEEN SOME CONCERN WITH 3 PIECE RING INSTALLATIONS FOR 2AZ-FE AND 2AZ-FXE ENGINES. THIS TECH TIP CONTAINS THE ACCEPTED INSTALLATION METHOD REQUIRED FOR TOYOTA VEHICLES. Read More »
TT: THE VEHICLE MAY BE DIFFICULT TO START OR HAVE AN ABNORMALLY LOW OR ROUGH IDLE AFTER THE BATTERY HAS BEEN DISCONNECTED OR POWER TO THE ENGINE ECM HAS BEEN INTERRUPTED. Read More »
TT: THERE HAS BEEN SOME CONCERN WITH 3 PIECE RING INSTALLATIONS FOR 2AZ-FE AND 2AZ-FXE ENGINES. THIS TECH TIP CONTAINS THE ACCEPTED INSTALLATION METHOD REQUIRED FOR TOYOTA VEHICLES. Read More »
TT: BASED ON CURRENT PART ORDER ALLOCATION, SOME PISTON TYPES HAVE BEEN INCORRECTLY IDENTIFIED WHILE UNDERGOING THE ZE7 2AZ OIL CONSUMPTION REPAIR PROCEDURE. Read More »
WPB: TOYOTA HAS RECEIVED SOME REPORTS WHERE VEHICLES MAY EXHIBIT EXCESSIVE ENGINE OIL CONSUMPTION. TOYOTA IS NOW ANNOUNCING THE PART REPLACEMENT PHASE OF WARRANTY ENHANCEMENT PROGRAM ZE7 FOR VEHICLES EXHIBITING EXCESSIVE ENGINE OIL ... Read More »
"TSB: FLASH REPROGRAMMING ALLOWS THE ECU SOFTWARE TO BE UPDATED WITHOUT REPLACING THE ECU. FLASH CALIBRATION UPDATES FOR SPECIFIC VEHICLE MODELS/ECUS ARE RELEASED AS FIELD-FIX PROCEDURES DESCRIBED IN INDIVIDUAL SERVICE BULLETINS. Read More »
TOYOTA: AS A RESULT OF FUEL CUT LOGIC, SOME VEHICLES MAY EXHIBIT ONE OR BOTH CONDITIONS LISTED-ENGINE RPM DECREASE (300-700 RPM) WHILE CRUISING AT 40 MPH; RELEASING ACCELERATOR PEDAL AT HIGHWAY SPEEDS, SLIGHT DELAYED/REDUCED ENGINE ... Read More »
TOYOTA: SEE DOCUMENT SEARCH BUTTON FOR OWNER LETTER. CERTAIN VEHICLES FAILED TO HAVE THE POSITIVE TEMPERATURE COEFFICIENT (PTC) HEATER RELAYS INSTALLED AT TIME OF MANUFACTURED. MODELS 2011-2012 COROLLA. Read More »
FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY:FILLER PIPE AND CAP
TOYOTA: WATER INTRUSION INTO CHARCOAL CANISTER. SOME VEHICLES MAY EXHIBIT A MIL 'ON' CONDITION. TO ADDRESS THE CONDITION , THE FUEL PIPE PROTECTOR HAS BEEN UPDATED. *JS Read More »
TT: THE VEHICLE MAY BE DIFFICULT TO START OR HAVE AN ABNORMALLY LOW OR ROUGH IDLE AFTER THE BATTERY HAS BEEN DISCONNECTED OR POWER TO THE ENGINE ECM HAS BEEN INTERRUPTED. Read More »
"TSB: FLASH REPROGRAMMING ALLOWS THE ECU SOFTWARE TO BE UPDATED WITHOUT REPLACING THE ECU. FLASH CALIBRATION UPDATES FOR SPECIFIC VEHICLE MODELS/ECUS ARE RELEASED AS FIELD-FIX PROCEDURES DESCRIBED IN INDIVIDUAL SERVICE BULLETINS. Read More »
TOYOTA: ACCELERATOR PEDAL SENSOR ASSEMBLY INFORMATION REGARDING THE INSPECTION, REMOVAL, AND INSTALLATION, IF LUBRICATION OR OIL, IS APPLIED. *PE Read More »
"TT: SOME CUSTOMERS MAY ENCOUNTER BLUETOOTH CONNECTIVITY CONCERNS SUCH AS: ? DIFFICULTY PAIRING THE PHONE. ? INTERMITTENT BLUETOOTH FAILURE TO CONNECT WHEN FIRST TURNING ON THE VEHICLE. Read More »
"WPB: THE ENGINE IS COVERED UNDER THE TOYOTA NEW VEHICLE LIMITED WARRANTY FOR 5 YEARS FROM THE DATE OF FIRST USE OR 60,000 MILES (WHICHEVER OCCURS FIRST). Read More »
"WPB: THE ENGINE IS COVERED UNDER THE TOYOTA NEW VEHICLE LIMITED WARRANTY FOR 5 YEARS FROM THE DATE OF FIRST USE OR 60,000 MILES (WHICHEVER OCCURS FIRST). Read More »
DD: IN LIMITED CASES VEHICLES BEING SERVICED FOR ZE7 WILL REQUIRE A REPLACEMENT SHORT BLOCK. DEALERS WILL NEED TO INSTALL THE DOWEL PINS BETWEEN THE SHORT BLOCK AND LOWER CRANKCASE WHEN PERFORMING THIS REPAIR. Read More »
TT: CUSTOMERS MAY EXPERIENCE CONNECTIVITY ISSUES WHEN THE FOLLOWING CONDITIONS ARE MET: THE CUSTOMER'S IPHONE IS OPERATING ON IOS9 FIRMWARE. THE CUSTOMER'S IPHONE IS CONNECTED TO THE VEHICLE VIA BLUETOOTH. Read More »
TOYOTA: ON SOME MODEL VEHICLES, THE POSITIVE TEMPERATURE COEFFICIENT (PTC) HEATER RELAYS WERE NOT INSTALLED AT TIME OF MANUFACTURED. MODELS 2011-2012 COROLLA. *PE Read More »
TT: CUSTOMERS MAY EXPERIENCE CONNECTIVITY ISSUES WHEN THE FOLLOWING CONDITIONS ARE MET: THE CUSTOMER'S IPHONE IS OPERATING ON IOS9 FIRMWARE. THE CUSTOMER'S IPHONE IS CONNECTED TO THE VEHICLE VIA BLUETOOTH. Read More »
WARRANTY POLICY BULLETIN (POL14-12): ADDED THE SHORT BLOCK RELEASE AUTHORIZATION FLOW CHART. TOYOTA HAS RECEIVED SOME REPORTS WHERE VEHICLES MAY EXHIBIT EXCESSIVE ENGINE OIL CONSUMPTION. Read More »
TOYOTA: FLOOR MAT INSTALLATION DURING PDS. VEHICLES EQUIPPED WITH DRIVER'S SIDE FLOOR MAT RETAINING CLIPS TO SECURE THE FLOOR MAT IN CORRECT POSITION. *PE Read More »
