Technical Service Bulletins (TSBs) for the 2021 Wrangler are official communications between Jeep & their dealerships that describe processes for troubleshooting or fixing certain common problems.
All vehicle manufacturers are required by U.S. law to make their TSBs available to the public.
ELECTRIC HYDRAULIC POWER STEERING PUMP Prior to replacing this component for damage at the pump electrical connection, please contact FCA redacted content. If no response in 15 minutes, proceed with repair. Read More »
UAQ and UCQ Radio Enhancements Customers may experience one or more of the following: ? **Wi-Fi hotspot connection failure. ? Speaker popping, crackle noise during Voice Recognition (VR) response and navigation guidance. Read More »
Noise In Steering Column Tailshaft When Turning Steering Wheel This bulletin involves inspecting and replacing the steering column if necessary. Read More »
Noise In Steering Column Tailshaft When Turning Steering Wheel This bulletin involves inspecting and replacing the steering column if necessary. Read More »
Noise In Steering Column Tailshaft When Turning Steering Wheel This bulletin involves inspecting and replacing the steering column if necessary. Read More »
Noise In Steering Column Tailshaft When Turning Steering Wheel This bulletin involves inspecting and replacing the steering column if necessary. Read More »
LIFTER, Hydraulic Roller Deactivating Please do not replace MDS lifters because the disconnecting pin is not lined up, this is normal and not a defect. Read More »
SHOCK ABSORBER KIT, Suspension, Front/Rear For concern of shock oil leak, please contact FCA Redacted Content prior to replacing this part. If no response in 15 minutes, proceed with the repair. Read More »
SHOCK ABSORBER KIT, Suspension, Front/Rear For concern of shock oil leak, please contact FCA Redacted Content prior to replacing this part. If no response in 15 minutes, proceed with the repair. Read More »
SHOCK ABSORBER KIT, Suspension, Front/Rear For concern of shock oil leak, please contact FCA Redacted Content prior to replacing this part. If no response in 15 minutes, proceed with the repair. Read More »
Flash: Powertrain Control Module (PCM) Updates This bulletin involves reprogramming the PCM with the latest available software. Customers may experience a Malfunction Indicator Lamp (MIL) illumination. Read More »
SHOCK ABSORBER KIT, Suspension, Front/Rear For concern of shock oil leak, please contact FCA Redacted Content prior to replacing this part. If no response in 15 minutes, proceed with the repair. Read More »
Flash: Hybrid Control Processor (HCP) and Auxiliary Hybrid Control Processor (AHCP) Updates This bulletin involves reprogramming the HCP and AHCP or also known as Power Inverter Module (PIM) with the latest available software. Read More »
PUMP, Vacuum For DTC Code P258B - ELECTRONIC VACUUM PUMP PERFORMANCE. Due to brake vacuum pumps returned with trouble not found, please follow the proper diagnostics outline in the service library this also includes checking all ... Read More »
Engine When replacing a GMET4 long block from a 2021 JL or older, you will need to carry over the injector wiring harness from the original engine, and the Fuel pressure sensor should be replaced with part number: 68212572AB. Read More »
PUMP, Washer, Windshield Windshield washer pump is inop or low pressure If customer comes in with the issue described above, please contact the following individuals prior to servicing the vehicle. Read More »
PUMP, Washer, Windshield Windshield washer pump is inop or low pressure If customer comes in with the issue described above, please contact the following individuals prior to servicing the vehicle. Read More »
PUMP, Washer, Windshield Windshield washer pump is inop or low pressure If customer comes in with the issue described above, please contact the following individuals prior to servicing the vehicle. Read More »
PUMP, Washer, Windshield Windshield washer pump is inop or low pressure If customer comes in with the issue described above, please contact the following individuals prior to servicing the vehicle. Read More »
MASTER CYLINDER, Brake Prior to replacing the master cylinder please call Paul Kuehl at (248) 535-7013FCA Redacted Content. If no response in 15 minutes, proceed with repair. Read More »
Rear Caliper Adapter Bolts Are Loose Or Missing This bulletin includes replacing all four rear caliper adapter bolts if loose or missing. Customers may comment on one or more of the following:Click or clunk from the rear of the vehicle. Read More »
Flash: Powertrain Control Module (PCM) Updates This bulletin involves reprogramming the PCM with the latest available software. Customers may experience a Malfunction Indicator Lamp (MIL) illumination. Read More »
Battery Kit, Hybrid NOTE 1 of 2: Beginning April 1, 2022, a $5,000 penalty will be assessed to dealers who return any visually damaged battery to the supplier. Read More »
Flash: Powertrain Control Module (PCM) Updates This bulletin involves reprogramming the PCM with the latest available software. Customers may experience a Malfunction Indicator Lamp (MIL) illumination. Read More »
VALVE, HIGH PRESSURE EGR If you are replacing the high pressure EGR valve (68490212A$) due to DTC P0407 or P0408 please refer to all published service information regarding proper diagnosis before proceeding. Read More »
PUMP, Vacuum For DTC Code P258B - ELECTRONIC VACUUM PUMP PERFORMANCE. Due to brake vacuum pumps returned with trouble not found, please follow the proper diagnostics outline in the service library this also includes checking all ... Read More »
12V Battery Low Charge This bulletin involves testing and possibly replacing the 12V battery. Technicians or customers may experience a Malfunction Indicator Lamp MIL illumination. Read More »
SENSOR, Wheel Speed Please call FCA Redacted Content prior to replacing a rear wheel speed sensor for one of the following fault codes: C003A-1D and or 2F (right rear wss circuit current out of range or signal erratic) C0037-1D and or 2F ... Read More »
Rear Caliper Adapter Bolts Are Loose Or Missing This bulletin includes replacing all four rear caliper adapter bolts if loose or missing. Customers may comment on one or more of the following:Click or clunk from the rear of the vehicle. Read More »
Valve Cover Gasket If you are experiencing a right valve cover leak and plan on replacing only the gasket, the customer may later return for an oil leak. Engineering has updated the skirt height of the valve cover to address oil leaks. Read More »
Flash: Powertrain Control Module (PCM) Updates This bulletin involves reprogramming the PCM with the latest available software. Customers may experience a Malfunction Indicator Lamp (MIL) illumination. Read More »
Intermittent Fails To Crank Or Start This bulletin includes replacing two starter mounting studs. Customers may comment on the following: Vehicle intermittently fails to crank/start. Read More »
3.6L Pentastar Upgrade Spark Plug Internal Crack This bulletin involves replacing all six spark plugs. Customers may experience a Malfunction Indicator Lamp (MIL) illumination. Read More »
3.6L Pentastar Upgrade Spark Plug Internal Crack This bulletin involves replacing all six spark plugs. Customers may experience a Malfunction Indicator Lamp (MIL) illumination. Read More »
Check engine lamp on. Fault code P0244- TURBOCHARGER/SUPERCHARGER WASTEGATE SOLENOID "A" RANGE/PERFORMANCE is set in the Powertrain Control Module (PCM a.k.a. ECM) after the turbocharger assembly has been replaced. Read More »
PUMP Water For 2016-2024MY 3.6L Pentastar Upgrade with suspected coolant leak. PRIOR TO PERFORMING ANY WATER PUMP REPLACEMENT, PROCEED WITH INSPECTION INSTRUCTIONS FROM THE LATEST VERSION OF STAR ONLINE PUBLICATION S2307000002. Read More »
PUMP Water For 2016-2024MY 3.6L Pentastar Upgrade with suspected coolant leak. PRIOR TO PERFORMING ANY WATER PUMP REPLACEMENT, PROCEED WITH INSPECTION INSTRUCTIONS FROM THE LATEST VERSION OF STAR ONLINE PUBLICATION S2307000002. Read More »
ADAPTER, Engine Oil Filter (Pentastar V6) For all 2014MY replace the Oil Filter Adapter (OFA). For any other MY review and follow instructions from the latest STAR Online S1809000007 available on Dealer Connect. Read More »
ADAPTER, Engine Oil Filter (Pentastar V6) For all 2014MY replace the Oil Filter Adapter (OFA). For any other MY review and follow instructions from the latest STAR Online S1809000007 available on Dealer Connect. Read More »
ADAPTER, Engine Oil Filter (Pentastar V6) For all 2014MY replace the Oil Filter Adapter (OFA). For any other MY (with mileage above 30,000) review and follow instructions from STAR Online S1809000007 REV. C available on Dealer Connect. Read More »
Engine When replacing a GMET4 long block from a 2021 JL or older, you will need to carry over the injector wiring harness from the original engine, and the Fuel pressure sensor should be replaced with part number: 68212572AB. Read More »
Battery Heater If you are looking for the Electronic Coolant Heater (ECH) for DTC P0E15 please order the latest level part number 68443445A$. Read More »
Valve - Coolant JL PHEV Hoses to 3-Way valve coolant hoses misroute causes P0E80-00. Check hose routing as outlined in Star Online Publication S2208000205 or on a known good vehicle before replacing valve. Read More »
The coolant inlet tube fasteners on about 90,811 of the above vehicles may become loose and allow a coolant weep that may propagate into a drip. Read More »
Spark Knock/Engine Symptoms This bulletin involves cleaning the piston heads and cylinder head combustion chambersto resolve a spark knock condition being caused by oil intrusion through the PCV system. Read More »
water pump For concern of leak at water pump, please check and re-torque water pump inlet tube fasteners as described in Service Bulletin 07-001-22 before replacing the water pump. Read More »
Battery Kit, Hybrid NOTE 1 of 2: Beginning April 1, 2022, a $5,000 penalty will be assessed to dealers who return any visually damaged battery to the supplier. Read More »
Water Pump For concern of leak at water pump, please check and re-torque water pump inlet tube fasteners as described in Service Bulletin 07-001-22 before replacing the water pump. Read More »
Valve Cover Gasket It is advised to replace the full valve cover assembly if you are experiencing a valve cover leak Engineering has updated the skirt height of the valve cover to address oil leaks. Read More »
Valve Cover Gasket If you are experiencing a right valve cover leak and plan on replacing only the gasket, the customer may later return for an oil leak. Engineering has updated the skirt height of the valve cover to address oil leaks. Read More »
PUMP, Auxiliary Coolant Customer experiences Check Engine Light with DTC/ P026 E, P023 A, or P023 B all related to Coolant Pump performance. Dealers are replacing Auxiliary Coolant Pump Part #68290300AA. Read More »
Water Pump Inlet Tube Fastener Torque This bulletin involves checking the torque on the water pump inlet tube fasteners to possibly eliminate coolant leak at this location. Read More »
If a Mopar oil filter is not available, use a filter that meets or exceeds USCAR36 specification and is compatible with semi and full synthetic oils. Read More »
Water Pump Inlet Tube Fastener Torque This bulletin involves checking the torque on the water pump inlet tube fastenersto possibly eliminate coolant leak at this location. Read More »
Water Pump Inlet Tube Fastener Torque This bulletin involves checking the torque on the water pump inlet tube fastenersto possibly eliminate coolant leak at this location. Read More »
Water Pump Inlet Tube Fastener Torque This bulletin involves checking the torque on the water pump inlet tube fastenersto possibly eliminate coolant leak at this location. Read More »
Water Pump Inlet Tube Fastener Torque This bulletin involves checking the torque on the water pump inlet tube fastenersto possibly eliminate coolant leak at this location. Read More »
Water Pump Inlet Tube Fastener Torque This bulletin involves checking the torque on the water pump inlet tube fasteners to possibly eliminate coolant leak at this location. Read More »
COVER, Engine 2021 JL / JT Engine Cover Removal - Dealer notification for removal of cover. Please note that the Aesthetic Engine Cover (05281562AC) has been removed on ALL JL/JT 3.6L Vehicle Configurations. Read More »
SPRING, Valve For conern of misfire or misfire related DTCs and diagnosis leads to a broken valve spring, please replace all valve springs and contact FCA Redacted Content to FasTrak all replaced parts to QEC for further analysis. Read More »
Pentastar Upgrade Oil Fill Level after an Oil Change This bulletin involves rechecking the oil fill level after filling the engine to the correct specifications. Read More »
Customer?s complaint may include a MIL-on with one or more of the following DTCs (Active, Pending, or Stored) in the PCM: P0133, P0137, P0171, P0300, P2096. Read More »
Issue involves overheating, running hot, coolant leaks and related symptoms after a Mopar replacement engine has been installed in the vehicle. Read More »
Issue involves overheating, running hot, coolant leaks and related symptoms after a Mopar replacement engine has been installed in the vehicle. Read More »
3.6L Check Engine Light and Rough Running Engine This bulletin involves cutting off a wiring harness eyelet and splicing in a pigtail to the engine ground harness. Customers may experience a Malfunction Indicator Lamp (MIL) illumination. Read More »
3.6L Check Engine Light and Rough Running Engine This bulletin involves cutting off a wiring harness eyelet and splicing in a pigtail to the engine ground harness. Customers may experience a Malfunction Indicator Lamp (MIL) illumination. Read More »
12V Battery Low Charge This bulletin involves testing and possibly replacing the 12V battery. Technicians or customers may experience a Malfunction Indicator Lamp MIL illumination. Read More »
Customer?s complaint may include a MIL-on with one or more of the following DTCs (Active, Pending, or Stored) in the PCM: P0133, P0137, P0171, P0300, P2096. Read More »
Intermittent Fails To Crank Or Start This bulletin includes replacing two starter mounting studs. Customers may comment on the following: Vehicle intermittently fails to crank/start. Read More »
Customer complains of a MIL-on condition. Upon further inspection, there is a Diagnostic Trouble Code (DTC) P0128 Coolant Thermostat (Coolant Temperature Below Thermostat Regulating Temperature) set in the PCM. Read More »
Customer complains of a MIL-on condition. Upon further inspection, there is a Diagnostic Trouble Code (DTC) P0128 Coolant Thermostat (Coolant Temperature Below Thermostat Regulating Temperature) set in the PCM. Read More »
Customer complains of a MIL-on condition. Upon further inspection, there is a Diagnostic Trouble Code (DTC) P0128 Coolant Thermostat (Coolant Temperature Below Thermostat Regulating Temperature) set in the PCM. Read More »
Customer complains of a MIL-on condition. Upon further inspection, there is a Diagnostic Trouble Code (DTC) P0128 Coolant Thermostat (Coolant Temperature Below Thermostat Regulating Temperature) set in the PCM. Read More »
ADAPTER, Engine Oil Filter (Pentastar V6) All vehicles equipped with a 3.2L or 3.6L except for model year 2014 vehicles with leak concern: 1) Ensure the Oil Filter Adapter (OFA) Cap O-ring is seated in the proper groove in the cap and ... Read More »
ENGINE, Complete If you are replacing the 3.0L Diesel engine assembly due to internal failure, the Diesel Engineering team is requesting more information regarding the repair. Read More »
ENGINE, Complete If you are replacing the 3.0L Diesel engine assembly due to internal failure, the Diesel Engineering team is requesting more information regarding the repair. Read More »
COOLER, EGR If you are replacing the high pressure EGR cooler (p/n 68490113A$) for a suspected internal coolant leak that was detected by wetness in the EGR pipe or valve, please perform proper cooling system pressure test first to ... Read More »
COOLER, EGR If you are replacing the high pressure EGR cooler (p/n 68490113A$) for a suspected internal coolant leak that was detected by wetness in the EGR pipe or valve, please perform proper cooling system pressure test first to ... Read More »
ADAPTER, Engine Oil Filter If you are replacing the oil cooler/filter housing for an oil leak that appears to be between the cooler, and the engine block, please refer to all published service information regarding proper diagnosis of ... Read More »
ADAPTER, Engine Oil Filter If you are replacing the oil cooler/filter housing for an oil leak that appears to be between the cooler, and the engine block, please refer to all published service information regarding proper diagnosis of ... Read More »
ADAPTER, Engine Oil Filter If you are replacing the oil cooler/filter housing for an oil leak that appears to be between the cooler, and the engine block, please refer to all published service information regarding proper diagnosis of ... Read More »
(Revision A) Engine Restarting On Stop/Start Event Without Releasing The Brake Pedal, EVIC Displays Shift To P Then Desired Gear, D on PRNDL Flashing Read More »
ENGINE AND ENGINE COOLING:ENGINE:GASOLINE:TURBO/SUPERCHARGER
PHEV Ready Telltale This bulletin is to communicate that a customer may report the vehicle does not start with any warning indicators. A technician can not confirm any faults even if they can duplicate the reported concern. Read More »
Check engine lamp on. Fault code P0244- TURBOCHARGER/SUPERCHARGER WASTEGATE SOLENOID "A" RANGE/PERFORMANCE is set in the Powertrain Control Module (PCM a.k.a. ECM) after the turbocharger assembly has been replaced. Read More »
(Rev. A) Malfunction Indicator Light (MIL) Illuminated. Service Diesel Exhaust Fluid (DEF) System ? See Dealer Soon Message on Electronic Vehicle Information Center (EVIC) Along With Possible Diagnostic Trouble Code (DTC) P241D - SCR ... Read More »
water pump For concern of leak at water pump, please check and re-torque water pump inlet tube fasteners as described in Service Bulletin 07-001-22 before replacing the water pump. Read More »
PSU right intake camshaft Case 1) If you are to flash the PSU (Pentastar Upgrade Engine) PCM due to P0300 code presence, only AB or previous LEVEL PSU right intake camshaft PN 05047913AA or AB (old version) should be replaced. Read More »
Water Pump For concern of leak at water pump, please check and re-torque water pump inlet tube fasteners as described in Service Bulletin 07-001-22 before replacing the water pump. Read More »
PUMP Water For 2016-2024MY 3.6L Pentastar Upgrade with suspected coolant leak. PRIOR TO PERFORMING ANY WATER PUMP REPLACEMENT, PROCEED WITH INSPECTION INSTRUCTIONS FROM THE LATEST VERSION OF STAR ONLINE PUBLICATION S2307000002. Read More »
PUMP, Vacuum Prior to replacing the vacuum pumps, please contact or email FCA Redacted Content. If no response in 15 minutes, proceed with repair. Read More »
(Rev. A) Malfunction Indicator Light (MIL) Illuminated. Service Diesel Exhaust Fluid (DEF) System ? See Dealer Soon Message on Electronic Vehicle Information Center (EVIC) Along With Possible Diagnostic Trouble Code (DTC) P241D - SCR ... Read More »
ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL
VALVE, HIGH PRESSURE EGR If you are replacing the high pressure EGR valve (68490212A$) due to DTC P0407 or P0408 please refer to all published service information regarding proper diagnosis before proceeding. Read More »
COOLER, EGR If you are replacing the high pressure EGR cooler (p/n 68490113A$) for a suspected internal coolant leak that was detected by wetness in the EGR pipe or valve, please perform proper cooling system pressure test first to ... Read More »
ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:MANIFOLD/HEADER/MUFFLER/TAIL PIPE
Engine When replacing a GMET4 long block from a 2021 JL or older, you will need to carry over the injector wiring harness from the original engine, and the Fuel pressure sensor should be replaced with part number: 68212572AB. Read More »
Valve - Coolant JL PHEV Hoses to 3-Way valve coolant hoses misroute causes P0E80-00. Check hose routing as outlined in Star Online Publication S2208000205 or on a known good vehicle before replacing valve. Read More »
Updated Fuel Filler Cap This bulletin involves updating the fuel filler cap with improved version. Customers may experience a Malfunction Indicator Lamp (MIL) illumination. Read More »
Updated Fuel Filler Cap This bulletin involves updating the fuel filler cap with improved version. Customers may experience a Malfunction Indicator Lamp (MIL) illumination. Read More »
Updated Fuel Filler Cap This bulletin involves updating the fuel filler cap with improved version. Customers may experience a Malfunction Indicator Lamp (MIL) illumination. Read More »
Battery Kit, Hybrid NOTE 1 of 2: Beginning April 1, 2022, a $5,000 penalty will be assessed to dealers who return any visually damaged battery to the supplier. Read More »
Water Pump For concern of leak at water pump, please check and re-torque water pump inlet tube fasteners as described in Service Bulletin 07-001-22 before replacing the water pump. Read More »
6.4L Fuel Injector High Flow Misfire This bulletin involves inspecting the Julian date on the fuel rails, fuel injectorsand possibly replacing fuel injectors. Customers may experience a Malfunction Indicator Lamp (MIL) illumination. Read More »
Water Pump Inlet Tube Fastener Torque This bulletin involves checking the torque on the water pump inlet tube fasteners to possibly eliminate coolant leak at this location. Read More »
Updated Fuel Filler Cap and Fuel Filler Tube This bulletin involves updating the upper fuel filler tube and cap with improved versions. Customers may experience a Malfunction Indicator Lamp (MIL) illumination. Read More »
Updated Fuel Filler Cap and Fuel Filler Tube This bulletin involves updating the upper fuel filler tube and cap with improved versions. Customers may experience a Malfunction Indicator Lamp (MIL) illumination. Read More »
Updated Fuel Filler Cap and Fuel Filler Tube This bulletin involves updating the upper fuel filler tube and cap with improved versions. Customers may experience a Malfunction Indicator Lamp (MIL) illumination. Read More »
Updated Fuel Filler Cap and Fuel Filler Tube This bulletin involves updating the upper fuel filler tube and cap with improved versions. Customers may experience a Malfunction Indicator Lamp (MIL) illumination. Read More »
Water Pump Inlet Tube Fastener Torque This bulletin involves checking the torque on the water pump inlet tube fastenersto possibly eliminate coolant leak at this location. Read More »
Water Pump Inlet Tube Fastener Torque This bulletin involves checking the torque on the water pump inlet tube fastenersto possibly eliminate coolant leak at this location. Read More »
Water Pump Inlet Tube Fastener Torque This bulletin involves checking the torque on the water pump inlet tube fastenersto possibly eliminate coolant leak at this location. Read More »
Water Pump Inlet Tube Fastener Torque This bulletin involves checking the torque on the water pump inlet tube fastenersto possibly eliminate coolant leak at this location. Read More »
PUMP, Washer, Windshield Windshield washer pump is inop or low pressure If customer comes in with the issue described above, please contact the following individuals prior to servicing the vehicle. Read More »
PUMP, Washer, Windshield Windshield washer pump is inop or low pressure If customer comes in with the issue described above, please contact the following individuals prior to servicing the vehicle. Read More »
PUMP, Washer, Windshield Windshield washer pump is inop or low pressure If customer comes in with the issue described above, please contact the following individuals prior to servicing the vehicle. Read More »
PUMP, Washer, Windshield Windshield washer pump is inop or low pressure If customer comes in with the issue described above, please contact the following individuals prior to servicing the vehicle. Read More »
Flash: Powertrain Control Module (PCM) Updates This bulletin involves reprogramming the PCM with the latest available software. Customers may experience a Malfunction Indicator Lamp (MIL) illumination. Read More »
Water Pump Inlet Tube Fastener Torque This bulletin involves checking the torque on the water pump inlet tube fasteners to possibly eliminate coolant leak at this location. Read More »
Customer complaint includes a Mil-on condition. Upon further investigation, one or more of the following fault codes may be set in the PCM: P0456 - EVAP System Small Leak P0455 - EVAP System Large Leak P04EC - EVAP System Large Leak - ... Read More »
Customer complaint includes a Mil-on condition. Upon further investigation, one or more of the following fault codes may be set in the PCM: P0456 - EVAP System Small Leak P0455 - EVAP System Large Leak P04EC - EVAP System Large Leak - ... Read More »
Transmission Oil Cooler Lines Not Fully Engaged This bulletin involves visually inspecting both driver and passenger, upper and lower transmission oil cooler line quick connect attachments to the transmission and if not engaged, pushing ... Read More »
Incorrect Fuel Delivery Module This bulletin involves replacing the fuel pump module. Customers may experience a Malfunction Indicator Lamp (MIL) illumination. Read More »
Incorrect Fuel Delivery Module This bulletin involves replacing the fuel pump module. Customers may experience a Malfunction Indicator Lamp (MIL) illumination. Read More »
Incorrect Fuel Delivery Module This bulletin involves replacing the fuel pump module. Customers may experience a Malfunction Indicator Lamp (MIL) illumination. Read More »
Flash: Powertrain Control Module (PCM) Updates This bulletin involves reprogramming the PCM with the latest available software. Customers may experience a Malfunction Indicator Lamp (MIL) illumination. Read More »
Flash: Powertrain Control Module (PCM) Updates This bulletin involves reprogramming the PCM with the latest available software. Customers may experience a Malfunction Indicator Lamp (MIL) illumination. Read More »
Flash: Powertrain Control Module (PCM) Updates This bulletin involves reprogramming the PCM with the latest available software. Customers may experience a Malfunction Indicator Lamp (MIL) illumination. Read More »
(Rev. A) Malfunction Indicator Light (MIL) Illuminated. Service Diesel Exhaust Fluid (DEF) System ? See Dealer Soon Message on Electronic Vehicle Information Center (EVIC) Along With Possible Diagnostic Trouble Code (DTC) P241D - SCR ... Read More »
Updated Fuel Filler Cap This bulletin involves updating the fuel filler cap with improved version. Customers may experience a Malfunction Indicator Lamp (MIL) illumination. Read More »
Flash: Powertrain Control Module (PCM) Updates This bulletin involves reprogramming the PCM with the latest available software. Customers may experience a Malfunction Indicator Lamp (MIL) illumination. Read More »
Flash: Powertrain Control Module (PCM) Updates This bulletin involves reprogramming the PCM with the latest available software. Customers may experience a Malfunction Indicator Lamp (MIL) illumination. Read More »
(Rev. A) Malfunction Indicator Light (MIL) Illuminated. Service Diesel Exhaust Fluid (DEF) System ? See Dealer Soon Message on Electronic Vehicle Information Center (EVIC) Along With Possible Diagnostic Trouble Code (DTC) P241D - SCR ... Read More »
(Rev. A) Malfunction Indicator Light (MIL) Illuminated. Service Diesel Exhaust Fluid (DEF) System ? See Dealer Soon Message on Electronic Vehicle Information Center (EVIC) Along With Possible Diagnostic Trouble Code (DTC) P241D - SCR ... Read More »
(Rev. A) Malfunction Indicator Light (MIL) Illuminated. Service Diesel Exhaust Fluid (DEF) System ? See Dealer Soon Message on Electronic Vehicle Information Center (EVIC) Along With Possible Diagnostic Trouble Code (DTC) P241D - SCR ... Read More »
Service Hybrid Electric Vehicle System Message Displayed In The IPC. Vehicle Shakes During A Cold Start And Noise Is Heard Near The P2 Motor. DTC?s U0287-00 And B273C-00 Read More »
PUMP, Vacuum Prior to replacing the vacuum pumps, please contact or email FCA Redacted Content. If no response in 15 minutes, proceed with repair. Read More »
Possible Water Intrusion at the P1 and P2 High Voltage (HV) Connectors This bulletin involves inspecting and if necessary replacement of the orange seal(s) for the P1&P2 electrical connectors. Read More »
Axle Assembly Do not replace the Axle for Axle Locker Sensor failure. The parts kit (SENSOR KIT, Axle: 68544629A$) must be used to repair the Axle Locker Sensor on JL/JT equipped with the M210 and M220 Tru-Lok axles (DSE). Read More »
FILTER KIT, Transmission Oil For leak concerns that have been isolated to a transmission pan gasket, please replace ONLY the gasket. Pan/filter replacement are not required. Read More »
FILTER KIT, Transmission Oil For leak concerns that have been isolated to a transmission pan gasket, please replace ONLY the gasket. Pan/filter replacement are not required. Read More »
Flash: Battery Pack Control Module (BPCM) Diagnostic and System Updates Customers may experience a false Malfunction Indicator Lamp (MIL) illumination related to PHEV battery: ? P1A21-00 - HV Battery Contactor Control Sequence Incorrect. Read More »
Flash: Battery Pack Control Module (BPCM) Diagnostic and System Updates Customers may experience a false Malfunction Indicator Lamp (MIL) illumination related to PHEV battery: ? P1A21-00 - HV Battery Contactor Control Sequence Incorrect. Read More »
Flash: Hybrid Control Processor (HCP) and Auxiliary Hybrid Control Processor (AHCP) Updates Customers may experience a Malfunction Indicator Lamp (MIL) illumination. Read More »
Flash: Powertrain Control Module (PCM) Updates Customers may experience a Malfunction Indicator Lamp (MIL) illumination. Upon further investigation the technician may find one or more of the following Diagnostic Trouble Code (DTC). Read More »
Flash: Powertrain Control Module (PCM) Updates Customers may experience a Malfunction Indicator Lamp (MIL) illumination. Upon further investigation the technician may find one or more of the following Diagnostic Trouble Code (DTC). Read More »
Flash: Transmission Control Module (TCM) Updates This bulletin involves reprogramming the TCM with the latest available software. Customers may experience a Malfunction Indicator Lamp (MIL) illumination. Read More »
Flash: Hybrid Control Processor (HCP) and Auxiliary Hybrid Control Processor (AHCP) Updates This bulletin involves reprogramming the HCP and AHCP or also known as Power Inverter Module (PIM) with the latest available software. Read More »
Flash: Battery Pack Control Module (BPCM) Diagnostic and System Updates This bulletin involves updating the BPCM with the latest available software. Read More »
Flash: Powertrain Control Module (PCM) Updates This bulletin involves reprogramming the PCM with the latest available software. Customers may experience a Malfunction Indicator Lamp (MIL) illumination. Read More »
Flash: Powertrain Control Module (PCM) Updates This bulletin involves reprogramming the PCM with the latest available software. Customers may experience a Malfunction Indicator Lamp (MIL) illumination. Read More »
Flash: Hybrid Control Processor (HCP) and Auxiliary Hybrid Control Processor (AHCP) Updates This bulletin involves reprogramming the HCP and AHCP or also known as Power Inverter Module (PIM) with the latest available software. Read More »
Flash: Powertrain Control Module (PCM) Updates This bulletin involves reprogramming the PCM with the latest available software. Customers may experience a Malfunction Indicator Lamp (MIL) illumination. Read More »
Flash: Battery Pack Control Module (BPCM) Diagnostic and System Updates This bulletin involves updating the BPCM with the latest available software. Read More »
Flash: Hybrid Control Processor (HCP) and Auxiliary Hybrid Control Processor (AHCP) Updates This bulletin involves reprogramming the HCP and AHCP or also known as Power Inverter Module (PIM) with the latest available software. Read More »
Flash: Powertrain Control Module (PCM) Updates This bulletin involves reprogramming the PCM with the latest available software. Customers may experience a Malfunction Indicator Lamp (MIL) illumination. Read More »
Flash: Battery Pack Control Module (BPCM) Diagnostic and System Updates This bulletin involves updating the BPCM with the latest available software. Read More »
Flash: Powertrain Control Module (PCM) Updates This bulletin involves reprogramming the PCM with the latest available software. Customers may experience a Malfunction Indicator Lamp (MIL) illumination. Read More »
Flash: Hybrid Control Processor (HCP) and Auxiliary Hybrid Control Processor (AHCP) Updates This bulletin involves reprogramming the HCP and AHCP or also known as Power Inverter Module (PIM) with the latest available software. Read More »
Flash: Powertrain Control Module (PCM) Updates This bulletin involves reprogramming the PCM with the latest available software. Customers may experience a Malfunction Indicator Lamp (MIL) illumination. Read More »
Flash: Transmission Control Module (TCM) Updates This bulletin involves reprogramming the TCM with the latest available software. Customers may experience a Malfunction Indicator Lamp (MIL) illumination. Read More »
Flash: Battery Pack Control Module (BPCM) Diagnostic and System Updates This bulletin involves updating the BPCM with the latest available software. Read More »
Flash: Powertrain Control Module (PCM) Updates This bulletin involves reprogramming the PCM with the latest available software. Customers may experience a Malfunction Indicator Lamp (MIL) illumination. Read More »
Transmission Oil Cooler Lines Not Fully Engaged This bulletin involves visually inspecting both driver and passenger, upper and lower transmission oil cooler line quick connect attachments to the transmission and if not engaged, pushing ... Read More »
Radio Enhancements This bulletin involves updating the radio software level to 2036.06. Customers may experience the following:Product plan UUID is not correct in Carplay?. Carplay audio does not always resume. Battery save vs. Read More »
Warranty Bulletin D-20-23 Part Order Restriction Program - 48V Power Pack Unit (PPU) - Select 2018 - 2021 Jeep Wrangler (JL) and 2019 - 2021 RAM (DT) (Rev. A) Read More »
Warranty Bulletin D-20-23 Part Order Restriction Program - 48V Power Pack Unit (PPU) - Select 2018 - 2021 Jeep Wrangler (JL) and 2019 - 2021 RAM (DT) (Rev. A) Read More »
Warranty Bulletin D-20-23 Part Order Restriction Program - 48V Power Pack Unit (PPU) - Select 2018 - 2021 Jeep Wrangler (JL) and 2019 - 2021 RAM (DT) (Rev. A) Read More »
Warranty Bulletin D-20-23 Part Order Restriction Program - 48V Power Pack Unit (PPU) - Select 2018 - 2021 Jeep Wrangler (JL) and 2019 - 2021 RAM (DT) (Rev. A) Read More »
Detailed Proper PHEV Engine Operation This bulletin is to communicate that when the combustion engine starts for the first time within a key-cycle (either when the vehicle is first operational at the key crank, or while driving), the ... Read More »
Transmission Kit with Torque Converter 1. All Promaster (VF) 3.6L/62TE equipped vehicles. If the transmission bracket to the transmission case fasteners are removed during servicing, the fasteners (Part Number 06511385A$) are one-time ... Read More »
Flash: Powertrain Control Module (PCM) Updates This bulletin involves reprogramming the PCM with the latest available software. Customers may experience a Malfunction Indicator Lamp (MIL) illumination. Read More »
Warranty Bulletin D-21-01 Fast Feedback Program? Transmission, Front and Rear Axles/Prop Shafts, Front-End Accessory Drive (FEAD), Catalytic Converters and Exhaust Components, Cooling, Fuel and EVAP System Components and Electrical and ... Read More »
Flash: Hybrid Control Processor (HCP) and Auxiliary Hybrid Control Processor (AHCP) Updates This bulletin involves reprogramming the HCP and AHCP or also known as Power Inverter Module (PIM) with the latest available software. Read More »
BEV/Hybrid - Showroom and Display Vehicle Battery Maintenance This information only bulletin discusses procedures that must be followed for BEV/Hybrid vehicles that are on display at dealership showrooms. Read More »
PHEV Ready Telltale This bulletin is to communicate that a customer may report the vehicle does not start with any warning indicators. A technician can not confirm any faults even if they can duplicate the reported concern. Read More »
Detailed Proper PHEV Engine Operation This bulletin is to communicate that when the combustion engine starts for the first time within a key-cycle (either when the vehicle is first operational at the key crank, or while driving), the ... Read More »
Flash: Powertrain Control Module (PCM) Updates This bulletin involves reprogramming the PCM with the latest available software. Customers may experience a Malfunction Indicator Lamp (MIL) illumination. Read More »
Flash: Powertrain Control Module (PCM) Updates This bulletin involves reprogramming the PCM with the latest available software. Customers may experience a Malfunction Indicator Lamp (MIL) illumination. Read More »
Customer complaint includes a Mil-on condition. Upon further investigation, one or more of the following fault codes may be set in the PCM: Read More »
Customer complaint includes a Mil-on condition. Upon further investigation, one or more of the following fault codes may be set in the PCM: Read More »
Check engine lamp on. Fault code P0244- TURBOCHARGER/SUPERCHARGER WASTEGATE SOLENOID "A" RANGE/PERFORMANCE is set in the Powertrain Control Module (PCM a.k.a. ECM) after the turbocharger assembly has been replaced. Read More »
Check engine lamp on. Fault code P0244- TURBOCHARGER/SUPERCHARGER WASTEGATE SOLENOID "A" RANGE/PERFORMANCE is set in the Powertrain Control Module (PCM a.k.a. ECM) after the turbocharger assembly has been replaced. Read More »
Flash: Powertrain Control Module (PCM) Updates This bulletin involves reprogramming the PCM with the latest available software. Customers may experience a Malfunction Indicator Lamp (MIL) illumination. Read More »
POWER TRAIN:AUTOMATIC TRANSMISSION:FLUID/LUBRICANT
Transmission Oil Cooler Lines Not Fully Engaged This bulletin involves visually inspecting both driver and passenger, upper and lower transmission oil cooler line quick connect attachments to the transmission and if not engaged, pushing ... Read More »
POWER TRAIN:AUTOMATIC TRANSMISSION:COOLER/RADIATOR:HOSES AND FITTINGS
Water Pump For concern of leak at water pump, please check and re-torque water pump inlet tube fasteners as described in Service Bulletin 07-001-22 before replacing the water pump. Read More »
Warranty Bulletin D-20-23 Part Order Restriction Program - 48V Power Pack Unit (PPU) - Select 2018 - 2021 Jeep Wrangler (JL) and 2019 - 2021 RAM (DT) (Rev. A) Read More »
Axle Assembly A parts kit (SENSOR KIT, Axle: 68544629A$) is available to repair the Axle Locker Sensor on JL/JT equipped with the M210 and M220 Tru-Lok axles (DSE). This parts kit must be used when only the Axle Locker Sensor fails. Read More »
Axle Assembly A parts kit (SENSOR KIT, Axle: 68544629A$) is available to repair the Axle Locker Sensor on JL/JT equipped with the M210 and M220 Tru-Lok axles (DSE). This parts kit must be used when only the Axle Locker Sensor fails. Read More »
Axle Assembly A parts kit (SENSOR KIT, Axle: 68544629A$) is available to repair the Axle Locker Sensor on JL/JT equipped with the M210 and M220 Tru-Lok axles (DSE). This parts kit must be used when only the Axle Locker Sensor fails. Read More »
Connector kit Before ordering this connector repair kit 68018957A$, check it in the Mopar Connector Repair Kit Website to confirm part number and applicability. Read More »
PUMP Water For 2016-2024MY 3.6L Pentastar Upgrade with suspected coolant leak. PRIOR TO PERFORMING ANY WATER PUMP REPLACEMENT, PROCEED WITH INSPECTION INSTRUCTIONS FROM THE LATEST VERSION OF STAR ONLINE PUBLICATION S2307000002. Read More »
PUMP Water For 2016-2024MY 3.6L Pentastar Upgrade with suspected coolant leak. PRIOR TO PERFORMING ANY WATER PUMP REPLACEMENT, PROCEED WITH INSPECTION INSTRUCTIONS FROM THE LATEST VERSION OF STAR ONLINE PUBLICATION S2307000002. Read More »
Switch-Mirror Before replacing this Switch, please follow the service procedures to properly diagnose it 1) Remove the switch 2) Please check the continuity on each pin of the switch based on the table found in the service Procedures. Read More »
Switch-Mirror Before replacing this Switch, please follow the service procedures to properly diagnose it 1) Remove the switch 2) Please check the continuity on each pin of the switch based on the table found in the service Procedures. Read More »
Rear Defroster Inoperative Customer may experience the following: ? Rear window is not defrosting ? The rear window glass left or right side defrost solder terminal is detached from the defrost grid. Read More »
ELECTRIC HYDRAULIC POWER STEERING PUMP Prior to replacing this component for damage at the pump electrical connection, please contact FCA redacted content. If no response in 15 minutes, proceed with repair. Read More »
PUMP, Vacuum For DTC Code P258B - ELECTRONIC VACUUM PUMP PERFORMANCE. Due to brake vacuum pumps returned with trouble not found, please follow the proper diagnostics outline in the service library this also includes checking all ... Read More »
Flash: Battery Pack Control Module (BPCM) Diagnostic and System Updates Customers may experience a false Malfunction Indicator Lamp (MIL) illumination related to PHEV battery: ? P0A80-00 - Contactor Wear Counter Limit Reached. Read More »
Radio Over The Air Updating to QR40.12 Software Version Mobile Wi-Fi inoperative upon start up. ? Hotspot gives 9No Internet9 connection message on phone, when trying to connect to a device. Read More »
Start Stop Charging Warning Lamp Illuminated On, Intelligent Battery Sensor (IBS) State of Charge (SOC) Inaccurate, Battery Charging Message, Presence of IBS related Diagnostic Trouble Codes (DTCs), or Battery Warning Lamp ... Read More »
Flash: Battery Pack Control Module (BPCM) Diagnostic and System Updates Customers may experience a false Malfunction Indicator Lamp (MIL) illumination related to PHEV battery: ? P1A21-00 - HV Battery Contactor Control Sequence Incorrect. Read More »
Flash: Battery Pack Control Module (BPCM) Diagnostic and System Updates Customers may experience a false Malfunction Indicator Lamp (MIL) illumination related to PHEV battery: ? P1A21-00 - HV Battery Contactor Control Sequence Incorrect. Read More »
Flash: Hybrid Control Processor (HCP) and Auxiliary Hybrid Control Processor (AHCP) Updates Customers may experience a Malfunction Indicator Lamp (MIL) illumination. Read More »
Flash: Powertrain Control Module (PCM) Updates Customers may experience a Malfunction Indicator Lamp (MIL) illumination. Upon further investigation the technician may find one or more of the following Diagnostic Trouble Code (DTC). Read More »
Flash: Powertrain Control Module (PCM) Updates Customers may experience a Malfunction Indicator Lamp (MIL) illumination. Upon further investigation the technician may find one or more of the following Diagnostic Trouble Code (DTC). Read More »
Integrated Dual Charging Module Before replacing the IDCM part please follow the appropriate service procedure for DTC P0D27, ensure to clear the codes and perform a charging test. Read More »
Cluster Message ?Electric Mode Unavailable Cabin Heating or Cooling? or ?Electric Mode Temporarily Unavailable?, Vehicle Engine Runs All the Time Does Not Enter Electric Vehicle (EV) Mode Read More »
Battery Kit, Hybrid NOTE 1 of 2: Beginning April 1, 2022, a $5,000 penalty will be assessed to dealers who return any visually damaged battery to the supplier. Read More »
Flash: Battery Pack Control Module (BPCM) Diagnostic and System Updates This bulletin involves updating the BPCM with the latest available software. Read More »
Flash: Battery Pack Control Module (BPCM) Diagnostic and System Updates This bulletin involves updating the BPCM with the latest available software. Read More »
Flash: Battery Pack Control Module (BPCM) Diagnostic and System Updates This bulletin involves updating the BPCM with the latest available software. Read More »
Flash: Integrated Dual Charging Module (IDCM) Enhancements This bulletin involves reprogramming the IDCM with the latest software available or replacing the IDCM if required. Read More »
Flash: Transmission Control Module (TCM) Updates This bulletin involves reprogramming the TCM with the latest available software. Customers may experience a Malfunction Indicator Lamp (MIL) illumination. Read More »
Flash: Integrated Dual Charging Module (IDCM) Enhancements This bulletin involves reprogramming the IDCM with the latest software available or replacing the IDCM if required. Read More »
Flash: Hybrid Control Processor (HCP) and Auxiliary Hybrid Control Processor (AHCP) Updates This bulletin involves reprogramming the HCP and AHCP or also known as Power Inverter Module (PIM) with the latest available software. Read More »
Flash: Battery Pack Control Module (BPCM) Diagnostic and System Updates This bulletin involves updating the BPCM with the latest available software. Read More »
Flash: Powertrain Control Module (PCM) Updates This bulletin involves reprogramming the PCM with the latest available software. Customers may experience a Malfunction Indicator Lamp (MIL) illumination. Read More »
Flash: Anti-Lock Brake System (ABS) Module Updates This bulletin involves reprogramming the ABS module with the latest available software. Customers may experience a Malfunction Indicator Lamp (MIL) illumination. Read More »
Flash: Anti-Lock Brake System (ABS) Module Updates This bulletin involves reprogramming the ABS module with the latest available software. Customers may experience a Malfunction Indicator Lamp (MIL) illumination. Read More »
Flash: Anti-Lock Brake System (ABS) Module Updates This bulletin involves reprogramming the ABS module with the latest available software. Customers may experience a Malfunction Indicator Lamp (MIL) illumination. Read More »
Flash: Anti-Lock Brake System (ABS) Module Updates This bulletin involves reprogramming the ABS module with the latest available software. Customers may experience a Malfunction Indicator Lamp (MIL) illumination. Read More »
Flash: Powertrain Control Module (PCM) Updates This bulletin involves reprogramming the PCM with the latest available software. Customers may experience a Malfunction Indicator Lamp (MIL) illumination. Read More »
Flash: Powertrain Control Module (PCM) Updates This bulletin involves reprogramming the PCM with the latest available software. Customers may experience a Malfunction Indicator Lamp (MIL) illumination. Read More »
Flash: Powertrain Control Module (PCM) Updates This bulletin involves reprogramming the PCM with the latest available software. Customers may experience a Malfunction Indicator Lamp (MIL) illumination. Read More »
Flash: Powertrain Control Module (PCM) Updates This bulletin involves reprogramming the PCM with the latest available software. Customers may experience a Malfunction Indicator Lamp (MIL) illumination. Read More »
Flash: Hybrid Control Processor (HCP) and Auxiliary Hybrid Control Processor (AHCP) Updates This bulletin involves reprogramming the HCP and AHCP or also known as Power Inverter Module (PIM) with the latest available software. Read More »
Flash: Integrated Dual Charging Module (IDCM) Enhancements This bulletin involves reprogramming the IDCM with the latest software available or replacing the IDCM if required. Read More »
Flash: Powertrain Control Module (PCM) Updates This bulletin involves reprogramming the PCM with the latest available software. Customers may experience a Malfunction Indicator Lamp (MIL) illumination. Read More »
Flash: Battery Pack Control Module (BPCM) Diagnostic and System Updates This bulletin involves updating the BPCM with the latest available software. Read More »
Flash: Hybrid Control Processor (HCP) and Auxiliary Hybrid Control Processor (AHCP) Updates This bulletin involves reprogramming the HCP and AHCP or also known as Power Inverter Module (PIM) with the latest available software. Read More »
Flash: Integrated Dual Charging Module (IDCM) Enhancements This bulletin involves reprogramming the IDCM with the latest software available or replacing the IDCM if required. Read More »
Flash: Powertrain Control Module (PCM) Updates This bulletin involves reprogramming the PCM with the latest available software. Customers may experience a Malfunction Indicator Lamp (MIL) illumination. Read More »
Flash: Battery Pack Control Module (BPCM) Diagnostic and System Updates This bulletin involves updating the BPCM with the latest available software. Read More »
Flash: Hybrid Control Processor (HCP) and Auxiliary Hybrid Control Processor (AHCP) Updates This bulletin involves reprogramming the HCP and AHCP or also known as Power Inverter Module (PIM) with the latest available software. Read More »
Flash: Integrated Dual Charging Module (IDCM) Enhancements This bulletin involves reprogramming the IDCM with the latest software available or replacing the IDCM if required. Read More »
Flash: Battery Pack Control Module (BPCM) Diagnostic and System Updates This bulletin involves updating the BPCM with the latest available software. Read More »
Flash: Hybrid Control Processor (HCP) and Auxiliary Hybrid Control Processor (AHCP) Updates This bulletin involves reprogramming the HCP and AHCP or also known as Power Inverter Module (PIM) with the latest available software. Read More »
Flash: Integrated Dual Charging Module (IDCM) Enhancements This bulletin involves reprogramming the IDCM with the latest software available or replacing the IDCM if required. Read More »
Flash: Powertrain Control Module (PCM) Updates This bulletin involves reprogramming the PCM with the latest available software. Customers may experience a Malfunction Indicator Lamp (MIL) illumination. Read More »
Flash: Battery Pack Control Module (BPCM) Diagnostic and System Updates This bulletin involves updating the BPCM with the latest available software. Read More »
Flash: Amplifier (AMP) Diagnostic and System Updates This bulletin involves reprogramming the AMP with the latest available software. Customers may experience a Malfunction Indicator Lamp (MIL) illumination. Read More »
Flash: Powertrain Control Module (PCM) Updates This bulletin involves reprogramming the PCM with the latest available software. Customers may experience a Malfunction Indicator Lamp (MIL) illumination. Read More »
BEV/Hybrid - Showroom and Display Vehicle Battery Maintenance This information only bulletin discusses procedures that must be followed for BEV/Hybrid vehicles that are on display at dealership showrooms. Read More »
Flash: Instrument Panel Cluster (IPC) Updates This bulletin involves reprogramming the IPC with the latest available software. Customers may comment on the following:Vehicle doesn't switch to EV mode. Read More »
Flash: Integrated Dual Charging Module (IDCM) Enhancements This bulletin involves reprogramming the IDCM with the latest software available or replacing the IDCM if required. . Read More »
Flash: Hybrid Control Processor (HCP) and Auxiliary Hybrid Control Processor (AHCP) Updates This bulletin involves reprogramming the HCP and AHCP or also known as Power Inverter Module (PIM) with the latest available software. Read More »
Flash: Battery Pack Control Module (BPCM) Diagnostic and System Updates This bulletin involves updating the BPCM with the latest available software. Read More »
Possible Water Intrusion at the P1 and P2 High Voltage (HV) Connectors This bulletin involves inspecting and if necessary replacement of the orange seal(s) for the P1&P2 electrical connectors. Read More »
UAQ UCQ UAV, UCX, UAX and UCV Radio Over The Air Software Version Updates This bulletin provides information regarding the latest Flash Over The Air (FOTA) update and provides the service technician an overview of the steps a customer ... Read More »
UAQ UCQ UAV, UCX, UAX and UCV Radio Over The Air Software Version Updates This bulletin provides information regarding the latest Flash Over The Air (FOTA) update and provides the service technician an overview of the steps a customer ... Read More »
UAQ UCQ UAV, UCX, UAX and UCV Radio Over The Air Software Version Updates This bulletin provides information regarding the latest Flash Over The Air (FOTA) update and provides the service technician an overview of the steps a customer ... Read More »
3.6L Check Engine Light and Rough Running Engine This bulletin involves cutting off a wiring harness eyelet and splicing in a pigtail to the engine ground harness. Customers may experience a Malfunction Indicator Lamp (MIL) illumination. Read More »
12V Battery Low Charge This bulletin involves testing and possibly replacing the 12V battery. Technicians or customers may experience a Malfunction Indicator Lamp MIL illumination. Read More »
12V Battery Low Charge This bulletin involves testing and possibly replacing the 12V battery. Technicians or customers may experience a Malfunction Indicator Lamp (MIL) illumination. Read More »
12V Battery Low Charge This bulletin involves testing and possibly replacing the 12V battery. Technicians or customers may experience a Malfunction Indicator Lamp MIL illumination. Read More »
12V Battery Low Charge This bulletin involves testing and possibly replacing the 12V battery. Technicians or customers may experience a Malfunction Indicator Lamp (MIL) illumination. Read More »
Clunk or Scrape Noise From The Front Right Side of Vehicle This bulletin includes replacing the right front coil spring and lower shock bolt only. Read More »
Intermittent Fails To Crank Or Start This bulletin includes replacing two starter mounting studs. Customers may comment on the following: Vehicle intermittently fails to crank/start. Read More »
Intermittent Fails To Crank Or Start This bulletin includes replacing two starter mounting studs. Customers may comment on the following: Vehicle intermittently fails to crank/start. Read More »
Electric A/C Compressor EAC System Noise During Warmup and Under Load This bulletin serves as awareness for the operation of the electric A/C Compressor pump noise. Read More »
Apple CarPlay Malfunctioning, Does Not Launch Or Is Cutting In An Out On Wired And Wireless Connection, Radio Stuck When IPhone Is Connected Read More »
UGA and UGG Radio Enhancements This bulletin involves inspecting and if required updating the radio software to 2036.08. Customers may experience one or more of the following: Screen flickering. Carplay audio does not always resume. Read More »
Radio Enhancements This bulletin involves updating the radio software level to 2036.06. Customers may experience the following:Product plan UUID is not correct in Carplay?. Carplay audio does not always resume. Battery save vs. Read More »
Radio Enhancements This bulletin involves updating the radio software level to 2036.06. Customers may experience the following:Product plan UUID is not correct in Carplay?. Carplay audio does not always resume. Battery save vs. Read More »
Incorrect Fuel Delivery Module This bulletin involves replacing the fuel pump module. Customers may experience a Malfunction Indicator Lamp (MIL) illumination. Read More »
Incorrect Fuel Delivery Module This bulletin involves replacing the fuel pump module. Customers may experience a Malfunction Indicator Lamp (MIL) illumination. Read More »
PHEV Ready Telltale This bulletin is to communicate that a customer may report the vehicle does not start with any warning indicators. A technician can not confirm any faults even if they can duplicate the reported concern. Read More »
Flash: Powertrain Control Module (PCM) Updates This bulletin involves reprogramming the PCM with the latest available software. Customers may experience a Malfunction Indicator Lamp (MIL) illumination. Read More »
Flash: Powertrain Control Module (PCM) Updates This bulletin involves reprogramming the PCM with the latest available software. Customers may experience a Malfunction Indicator Lamp (MIL) illumination. Read More »
Flash: Powertrain Control Module (PCM) Updates This bulletin involves reprogramming the PCM with the latest available software. Customers may experience a Malfunction Indicator Lamp (MIL) illumination. Read More »
Flash: Powertrain Control Module (PCM) Updates This bulletin involves reprogramming the PCM with the latest available software. Customers may experience a Malfunction Indicator Lamp (MIL) illumination. Read More »
Wiring Harness Contacts Drivers Catalytic Converter. Check Engine Light (CEL), Anti-Lock Brake System (ABS), Traction Control System (TCS), Service 4WD Lamp On Read More »
Wiring Harness Contacts Drivers Catalytic Converter. Check Engine Light (CEL), Anti-Lock Brake System (ABS), Traction Control System (TCS), Service 4WD Lamp On Read More »
Flash: Body Control Module (BCM) Updates This bulletin involves reprogramming the BCM with the latest available software. Customer will notice that the rear wiper blade will not return to the park position when the wiper are turned off. Read More »
Flash: Body Control Module (BCM) Updates This bulletin involves reprogramming the BCM with the latest available software. Customer will notice that the rear wiper blade will not return to the park position when the wiper are turned off. Read More »
Warranty Bulletin D-21-01 Fast Feedback Program? Transmission, Front and Rear Axles/Prop Shafts, Front-End Accessory Drive (FEAD), Catalytic Converters and Exhaust Components, Cooling, Fuel and EVAP System Components and Electrical and ... Read More »
Telematic Box Module (TBM) Enhancements This bulletin involves updating the Telematic Box Module (TBM) latest available software. Customers may experience the following:CarPlay? audio does not mute during an active Ecall. Read More »
3.6L Pentastar Upgrade Spark Plug Internal Crack This bulletin involves replacing all six spark plugs. Customers may experience a Malfunction Indicator Lamp (MIL) illumination. Read More »
3.6L Pentastar Upgrade Spark Plug Internal Crack This bulletin involves replacing all six spark plugs. Customers may experience a Malfunction Indicator Lamp (MIL) illumination. Read More »
(Rev. A) Malfunction Indicator Light (MIL) Illuminated. Service Diesel Exhaust Fluid (DEF) System ? See Dealer Soon Message on Electronic Vehicle Information Center (EVIC) Along With Possible Diagnostic Trouble Code (DTC) P241D - SCR ... Read More »
Check engine lamp on. Fault code P0244- TURBOCHARGER/SUPERCHARGER WASTEGATE SOLENOID "A" RANGE/PERFORMANCE is set in the Powertrain Control Module (PCM a.k.a. ECM) after the turbocharger assembly has been replaced. Read More »
Check engine lamp on. Fault code P0244- TURBOCHARGER/SUPERCHARGER WASTEGATE SOLENOID "A" RANGE/PERFORMANCE is set in the Powertrain Control Module (PCM a.k.a. ECM) after the turbocharger assembly has been replaced. Read More »
Check engine lamp on. Fault code P0244- TURBOCHARGER/SUPERCHARGER WASTEGATE SOLENOID "A" RANGE/PERFORMANCE is set in the Powertrain Control Module (PCM a.k.a. ECM) after the turbocharger assembly has been replaced. Read More »
Malfunction Indicator Lamp (MIL) Illumination. Diagnostic Trouble Codes P0407 ? EGR Sensor B Circuit Low, or P0408 ? EGR Sensor B Circuit High Set Read More »
complete wiring harness Before replacing this harness, please check for an available connector repair kit at the following: http://connectors.dcctools.com/home. Read More »
Start Stop Charging Warning Lamp Illuminated On, Intelligent Battery Sensor (IBS) State of Charge (SOC) Inaccurate, Battery Charging Message, Presence of IBS related Diagnostic Trouble Codes (DTCs), or Battery Warning Lamp ... Read More »
Battery Kit, Hybrid NOTE 1 of 2: Beginning April 1, 2022, a $5,000 penalty will be assessed to dealers who return any visually damaged battery to the supplier. Read More »
Battery Kit, Hybrid NOTE 1 of 2: Beginning April 1, 2022, a $5,000 penalty will be assessed to dealers who return any visually damaged battery to the supplier. Read More »
Flash: Battery Pack Control Module (BPCM) Diagnostic and System Updates This bulletin involves updating the BPCM with the latest available software. Read More »
12V Battery Low Charge This bulletin involves testing and possibly replacing the 12V battery. Technicians or customers may experience a Malfunction Indicator Lamp MIL illumination. Read More »
Connector kit Before ordering this connector repair kit 68018957A$, check it in the Mopar Connector Repair Kit Website to confirm part number and applicability. Read More »
Floor Console USB Inoperative Customers may comment on the following: ? Customer states the Apple Carplay/Android Auto? does not work or is intermittently working when their device is plugged into the center console bin USB port. Read More »
Switch-Mirror Before replacing this Switch, please follow the service procedures to properly diagnose it 1) Remove the switch 2) Please check the continuity on each pin of the switch based on the table found in the service Procedures. Read More »
Key FOBIK Shortage and Restriction This bulletin is to inform customers, technicians and sales staff that vehicles are being delivered with only one key FOBIK due to a temporary semi conductor shortage. Read More »
3.6L Pentastar Upgrade Spark Plug Internal Crack This bulletin involves replacing all six spark plugs. Customers may experience a Malfunction Indicator Lamp (MIL) illumination. Read More »
Flash: Instrument Panel Cluster (IPC) Updates This bulletin involves reprogramming the IPC with the latest available software. Customers may comment on the following:Vehicle doesn't switch to EV mode. Read More »
Radio Over The Air Update from QR39.82F to QR40.12 Software Version Customer may experience one or more of the following: ? Mobile Wi-Fi inoperative upon start up. Read More »
Radio Over The Air Update from QR39.5 to QR40.11 Software Version Customer may experience one or more of the following: ? Mobile Wi-Fi inoperative upon start up. Read More »
Radio Over The Air Updating to QR40.12 Software Version Customers may experience one or more of the following: ? Mobile Wi-Fi inoperative upon start up. Read More »
Radio Over The Air Update to Q339.3 to QR39.62 Software Version Customers may experience one or more of the following: ? Mobile Wi-Fi inoperative upon start up. Read More »
Radio Over The Air Updating to QR40.12 Software Version ? Mobile Wi-Fi inoperative upon start up. ? Hotspot gives "No Internet" connection message on phone, when trying to connect to a device. Read More »
UAQ UCQ UAV, UCX, UAX and UCV Radio Over The Air Software Version Updates This bulletin provides information regarding the latest Flash Over The Air (FOTA) update and provides the service technician an overview of the steps a customer ... Read More »
UAQ and UCQ Radio Enhancements This bulletin involves inspecting and if required, updating the radio software level to: 39.6.The repair procedure must be followed step by step. Read More »
UAQ UCQ UAV and UCV Radio Over The Air Software Version Updates This bulletin provides information regarding the latest Flash Over The Air FOTA update and provides the service technician an overview of the steps a customer will need to ... Read More »
Radio Enhancements This bulletin involves updating the radio software level to 2036.06. Customers may experience the following: Ghost Touch, features, modes and App?s changing without drivers input. Read More »
UGQ Radio Enhancements This bulletin involves inspecting and if required updating the radio software to: 39.3 Customers may experience the following:CarPlay? audio does not mute during an active Ecall. Read More »
Flash: Battery Pack Control Module (BPCM) Diagnostic and System Updates This bulletin involves updating the BPCM with the latest available software. Read More »
PUMP, Vacuum Prior to replacing the vacuum pumps, please contact or email FCA Redacted Content. If no response in 15 minutes, proceed with repair. Read More »
Service Hybrid Electric Vehicle System Message Displayed In The IPC. Vehicle Shakes During A Cold Start And Noise Is Heard Near The P2 Motor. DTC?s U0287-00 And B273C-00 Read More »
Battery Kit, Hybrid NOTE 1 of 2: Beginning April 1, 2022, a $5,000 penalty will be assessed to dealers who return any visually damaged battery to the supplier. Read More »
ELECTRICAL SYSTEM:PROPULSION SYSTEM:HYBRID MANAGEMENT:POWER CONTROL UNIT/MODULE (HPCU)
Flash: Hybrid Control Processor (HCP) and Auxiliary Hybrid Control Processor (AHCP) Updates This bulletin involves reprogramming the HCP and AHCP or also known as Power Inverter Module (PIM) with the latest available software. Read More »
Flash: Battery Pack Control Module (BPCM) Diagnostic and System Update Customers may experience a Malfunction Indicator Lamp (MIL) illumination. Read More »
Flash: Battery Pack Control Module (BPCM) Diagnostic and System Updates Customers may experience a false Malfunction Indicator Lamp (MIL) illumination related to PHEV battery: ? P1A21-00 - HV Battery Contactor Control Sequence Incorrect. Read More »
Flash: Battery Pack Control Module (BPCM) Diagnostic and System Updates Customers may experience a false Malfunction Indicator Lamp (MIL) illumination related to PHEV battery: ? P1A21-00 - HV Battery Contactor Control Sequence Incorrect. Read More »
Flash: Hybrid Control Processor (HCP) and Auxiliary Hybrid Control Processor (AHCP) Updates Customers may experience a Malfunction Indicator Lamp (MIL) illumination. Read More »
Flash: Powertrain Control Module (PCM) Updates Customers may experience a Malfunction Indicator Lamp (MIL) illumination. Upon further investigation the technician may find one or more of the following Diagnostic Trouble Code (DTC). Read More »
Flash: Powertrain Control Module (PCM) Updates Customers may experience a Malfunction Indicator Lamp (MIL) illumination. Upon further investigation the technician may find one or more of the following Diagnostic Trouble Code (DTC). Read More »
Updated Fuel Filler Cap This bulletin involves updating the fuel filler cap with improved version. Customers may experience a Malfunction Indicator Lamp (MIL) illumination. Read More »
6.4L Fuel Injector High Flow Misfire This bulletin involves inspecting the Julian date on the fuel rails, fuel injectorsand possibly replacing fuel injectors. Customers may experience a Malfunction Indicator Lamp (MIL) illumination. Read More »
Flash: Anti-Lock Brake System (ABS) Module Updates This bulletin involves reprogramming the ABS module with the latest available software. Customers may experience a Malfunction Indicator Lamp (MIL) illumination. Read More »
Flash: Anti-Lock Brake System (ABS) Module Updates This bulletin involves reprogramming the ABS module with the latest available software. Customers may experience a Malfunction Indicator Lamp (MIL) illumination. Read More »
Flash: Anti-Lock Brake System (ABS) Module Updates This bulletin involves reprogramming the ABS module with the latest available software. Customers may experience a Malfunction Indicator Lamp (MIL) illumination. Read More »
Flash: Anti-Lock Brake System (ABS) Module Updates This bulletin involves reprogramming the ABS module with the latest available software. Customers may experience a Malfunction Indicator Lamp (MIL) illumination. Read More »
Updated Fuel Filler Cap and Fuel Filler Tube This bulletin involves updating the upper fuel filler tube and cap with improved versions. Customers may experience a Malfunction Indicator Lamp (MIL) illumination. Read More »
Updated Fuel Filler Cap and Fuel Filler Tube This bulletin involves updating the upper fuel filler tube and cap with improved versions. Customers may experience a Malfunction Indicator Lamp (MIL) illumination. Read More »
Updated Fuel Filler Cap and Fuel Filler Tube This bulletin involves updating the upper fuel filler tube and cap with improved versions. Customers may experience a Malfunction Indicator Lamp (MIL) illumination. Read More »
Updated Fuel Filler Cap and Fuel Filler Tube This bulletin involves updating the upper fuel filler tube and cap with improved versions. Customers may experience a Malfunction Indicator Lamp (MIL) illumination. Read More »
Flash: Powertrain Control Module (PCM) Updates This bulletin involves reprogramming the PCM with the latest available software. Customers may experience a Malfunction Indicator Lamp (MIL) illumination. Read More »
Flash: Powertrain Control Module (PCM) Updates This bulletin involves reprogramming the PCM with the latest available software. Customers may experience a Malfunction Indicator Lamp (MIL) illumination. Read More »
Flash: Powertrain Control Module (PCM) Updates This bulletin involves reprogramming the PCM with the latest available software. Customers may experience a Malfunction Indicator Lamp (MIL) illumination. Read More »
Flash: Hybrid Control Processor (HCP) and Auxiliary Hybrid Control Processor (AHCP) Updates This bulletin involves reprogramming the HCP and AHCP or also known as Power Inverter Module (PIM) with the latest available software. Read More »
Flash: Powertrain Control Module (PCM) Updates This bulletin involves reprogramming the PCM with the latest available software. Customers may experience a Malfunction Indicator Lamp (MIL) illumination. Read More »
Flash: Battery Pack Control Module (BPCM) Diagnostic and System Updates This bulletin involves updating the BPCM with the latest available software. Read More »
Flash: Powertrain Control Module (PCM) Updates This bulletin involves reprogramming the PCM with the latest available software. Customers may experience a Malfunction Indicator Lamp (MIL) illumination. Read More »
Flash: Amplifier (AMP) Diagnostic and System Updates This bulletin involves reprogramming the AMP with the latest available software. Customers may experience a Malfunction Indicator Lamp (MIL) illumination. Read More »
Flash: Powertrain Control Module (PCM) Updates This bulletin involves reprogramming the PCM with the latest available software. Customers may experience a Malfunction Indicator Lamp (MIL) illumination. Read More »
Incorrect Fuel Delivery Module This bulletin involves replacing the fuel pump module. Customers may experience a Malfunction Indicator Lamp (MIL) illumination. Read More »
Flash: Powertrain Control Module (PCM) Updates This bulletin involves reprogramming the PCM with the latest available software. Customers may experience a Malfunction Indicator Lamp (MIL) illumination. Read More »
Flash: Powertrain Control Module (PCM) Updates This bulletin involves reprogramming the PCM with the latest available software. Customers may experience a Malfunction Indicator Lamp (MIL) illumination. Read More »
Flash: Powertrain Control Module (PCM) Updates This bulletin involves reprogramming the PCM with the latest available software. Customers may experience a Malfunction Indicator Lamp (MIL) illumination. Read More »
(Rev. A) Malfunction Indicator Light (MIL) Illuminated. Service Diesel Exhaust Fluid (DEF) System ? See Dealer Soon Message on Electronic Vehicle Information Center (EVIC) Along With Possible Diagnostic Trouble Code (DTC) P241D - SCR ... Read More »
Headlamp Condensation Clearing Procedure Some customers may report that on occasion, vehicle exterior head lamp assemblies are fogged with a light layer of condensation on the inside of the lenses. Read More »
Headlamp Condensation Clearing Procedure Some customers may report that on occasion, vehicle exterior head lamp assemblies are fogged with a light layer of condensation on the inside of the lenses (Fig. 1) . Read More »
Headlamp Condensation Clearing Procedure Some customers may report that on occasion, vehicle exterior head lamp assemblies are fogged with a light layer of condensation on the inside of the lenses (Fig. 1) . Read More »
Flash: Body Control Module (BCM) Updates This bulletin involves reprogramming the BCM with the latest available software. Customer will notice that the rear wiper blade will not return to the park position when the wiper are turned off. Read More »
WINDSHIELD Windshield cracked or blemish. When customer comes in for a cracked windshield, please note the location of crack and take pictures before repair. Read More »
WINDSHIELD Windshield cracked or blemish. When customer comes in for a cracked windshield, please note the location of crack and take pictures before repair. Read More »
Sky One Power Top Rattle This bulletin involves checking the torque values on the Sky One-Touch power top screws andreplacing all 16 screws if one is found with an incorrect torque value. Read More »
Switch-Mirror Before replacing this Switch, please follow the service procedures to properly diagnose it 1) Remove the switch 2) Please check the continuity on each pin of the switch based on the table found in the service Procedures. Read More »
CAMERA, Rear View For concerns of back up camera flicker/blank/blue/black screen or camera inop, please ensure Radio is at latest software level. After update, system requires three sleep cycles to function properly. Read More »
Cluster Message ?Electric Mode Unavailable Cabin Heating or Cooling? or ?Electric Mode Temporarily Unavailable?, Vehicle Engine Runs All -the Time Does Not Enter Electric Vehicle (EV) Mode, Diagnostic Trouble Codes (DTCs) P0E15, ... Read More »
HVAC Blower Motor For concerns of intermittent or inoperative blower fan operation please contact FCA Redacted Content prior to replacement as returns have come back no trouble found. If no response in 15 minutes, proceed with repair. Read More »
Electric A/C Compressor (EAC) System Noise During Warmup and Under Load This bulletin serves as awareness for the operation of the electric A/C Compressor pump noise. Read More »
Rear Defroster Inoperative Customer may experience the following: ? Rear window is not defrosting ? The rear window glass left or right side defrost solder terminal is detached from the defrost grid. Read More »
Electric A/C Compressor EAC System Noise During Warmup and Under Load This bulletin serves as awareness for the operation of the electric A/C Compressor pump noise. Read More »
VISIBILITY:DEFROSTER/DEFOGGER/HVAC SYSTEM:AIR HANDLER/CHAMBER, DUCTS, AND VALVES
Possible Water Intrusion at the P1 and P2 High Voltage (HV) Connectors This bulletin involves inspecting and if necessary replacement of the orange seal(s) for the P1&P2 electrical connectors. Read More »
Transmission Oil Cooler Lines Not Fully Engaged This bulletin involves visually inspecting both driver and passenger, upper and lower transmission oil cooler line quick connect attachments to the transmission and if not engaged, pushing ... Read More »
(Rev. A) Malfunction Indicator Light (MIL) Illuminated. Service Diesel Exhaust Fluid (DEF) System ? See Dealer Soon Message on Electronic Vehicle Information Center (EVIC) Along With Possible Diagnostic Trouble Code (DTC) P241D - SCR ... Read More »
Front Seat Will Not Unfold and Lock Into Position This bulletin involves replacing the Easy Entry release cable and both front seattrack seat position returns. Read More »
Aluminum Body Panel Corrosion Repair Aluminum corrosion or bubbling along the leading edge of hood, hinges or other exterior surface areas of the hinges, doors, fenders, swing gates or liftgates. Read More »
Aluminum Body Panel Corrosion Repair Aluminum corrosion or bubbling along the leading edge of hood, hinges or other exterior surface areas of the hinges, doors, fenders, swing gates or liftgates. Read More »
Aluminum Body Panel Corrosion Repair Aluminum corrosion or bubbling along the leading edge of hood, hinges or other exterior surface areas of the hinges, doors, fenders, swing gates or liftgates. Read More »
Approved Use of Weld Through Primers This bulletin documents the FCA US LLC position regarding the use of weld through primer when using Squeeze Type Resistance Spot Welding (STRSW) and Gas Metal Arc Welding (GMAW) processes when ... Read More »
Approved Use of Weld Through Primers This bulletin documents the FCA US LLC position regarding the use of weld through primer when using Squeeze Type Resistance Spot Welding (STRSW) and Gas Metal Arc Welding (GMAW) processes when ... Read More »
Approved Use of Weld Through Primers This bulletin documents the FCA US LLC position regarding the use of weld through primer when using Squeeze Type Resistance Spot Welding (STRSW) and Gas Metal Arc Welding (GMAW) processes when ... Read More »
Lithium Ion Batteries Beginning April 1, 2022, a $5,000 penalty will be assessed to dealers who return any visually damaged battery to the supplier. Read More »
Lithium Ion Batteries Beginning April 1, 2022, a $5,000 penalty will be assessed to dealers who return any visually damaged battery to the supplier. Read More »
Driver Side Freedom Panel Squeaks This bulletin includes removing the left Freedom Panel, drilling out the receiver bracket hole and applying grease in the bracket hole for a squeak condition. Read More »
Clunk or Scrape Noise From The Front Right Side of Vehicle This bulletin includes replacing the right front coil spring and lower shock bolt only. Read More »
Soft Top Wear Due To Contact With Number Two Bow Side Frame Link This bulletin includes inspecting the soft top in the closed position for wear or holes and applying anti-wear tape. Read More »
Soft Top Wear Due To Contact With Number Two Bow Side Frame Link This bulletin includes inspecting the soft top in the closed position for wear or holes and applying anti-wear tape. Read More »
Flash: Body Control Module (BCM) Updates This bulletin involves reprogramming the BCM with the latest available software. Customer will notice that the rear wiper blade will not return to the park position when the wiper are turned off. Read More »
Soft Top Wear Due To Contact With Number Two Bow Side Frame Link This bulletin includes inspecting the soft top in the closed position for wear or holes and applying anti-wear tape. Read More »
Approved Use of Weld Through Primers This bulletin documents the FCA US LLC position regarding the use of weld through primer when using Squeeze Type Resistance Spot Welding (STRSW) and Gas Metal Arc Welding (GMAW) processes when ... Read More »
FRT DOOR HINGE - DOOR CHECK If the front door check strap physically breaks or cracks, please call FCA Redacted Content. If no response in 15 minutes, proceed with repair. Read More »
Corrosion on Door, Hood And/or Swing Gate Hinges Corrosion found on the door, hood and/or swing gate hinge(s). This bulletin involves inspecting and replacing any hinge exhibiting corrosion. Read More »
Corrosion on Door, Hood And/or Swing Gate Hinges Corrosion found on the door, hood and/or swing gate hinge(s). This bulletin involves inspecting and replacing any hinge exhibiting corrosion. Read More »
Corrosion on Door hood Swing Gate Hinges Corrosion found on the door, hood and/or swing gate hinge(s). This bulletin involves inspecting and replacing any hinge exhibiting corrosion. The replacement hinge is equipped with a Zinc shim. Read More »
Corrosion on Door hood Swing Gate Hinges Corrosion found on the door, hood and/or swing gate hinge(s). This bulletin involves inspecting and replacing any hinge exhibiting corrosion. The replacement hinge is equipped with a Zinc shim. Read More »
Axle Assembly Do not replace the Axle for Axle Locker Sensor failure. The parts kit (SENSOR KIT, Axle: 68544629A$) must be used to repair the Axle Locker Sensor on JL/JT equipped with the M210 and M220 Tru-Lok axles (DSE). Read More »
Axle Assembly A parts kit (SENSOR KIT, Axle: 68544629A$) is available to repair the Axle Locker Sensor on JL/JT equipped with the M210 and M220 Tru-Lok axles (DSE). This parts kit must be used when only the Axle Locker Sensor fails. Read More »
Red Rust On Rear Bumper Bolts This bulletin includes replacing all four bumper bolts. Customers may comment on the following: Red rust is present on the rear bumper bolts equipped with steel bumpers Read More »
AXLE, Service Rear A new parts kit (SENSOR KIT, Axle: 68544629AA) is available to repair the Axle Locker Sensor on the 2018 - 2022 JL/JT equipped with the M210 and M220 Tru-Lok axles (DSE). Read More »
Rear Caliper Adapter Bolts Are Loose Or Missing This bulletin includes replacing all four rear caliper adapter bolts if loose or missing. Customers may comment on one or more of the following:Click or clunk from the rear of the vehicle. Read More »
12V Battery Low Charge This bulletin involves testing and possibly replacing the 12V battery. Technicians or customers may experience a Malfunction Indicator Lamp MIL illumination. Read More »
SENSOR, Wheel Speed Please call FCA Redacted Content prior to replacing a rear wheel speed sensor for one of the following fault codes: C003A-1D and or 2F (right rear wss circuit current out of range or signal erratic) C0037-1D and or 2F ... Read More »
SENSOR, Wheel Speed Please call FCA Redacted Content prior to replacing a rear wheel speed sensor for one of the following fault codes: C003A-1D and or 2F (right rear wss circuit current out of range or signal erratic) C0037-1D and or 2F ... Read More »
Driver Side Freedom Panel Squeaks This bulletin includes removing the left Freedom Panel, drilling out the receiver bracket hole and applying grease in the bracket hole for a squeak condition. Read More »
Front Seat Will Not Unfold and Lock Into Position This bulletin involves replacing the Easy Entry release cable and both front seattrack seat position returns. Read More »
Front Passenger Outer Seat Bolster Foam is Collapsed This bulletin includes repositioning the passenger outer seat bolster and installing a strap and push pin to help prevent this concern from happening again. Read More »
Front Passenger Outer Seat Bolster Foam is Collapsed This bulletin includes repositioning the passenger outer seat bolster and installing a strap and push pin to help prevent this concern from happening again. Read More »
Flash: Powertrain Control Module (PCM) Updates This bulletin involves reprogramming the PCM with the latest available software. Customers may experience a Malfunction Indicator Lamp (MIL) illumination. Read More »
PHEV Ready Telltale This bulletin is to communicate that a customer may report the vehicle does not start with any warning indicators. A technician can not confirm any faults even if they can duplicate the reported concern. Read More »
PHEV Ready Telltale This bulletin is to communicate that a customer may report the vehicle does not start with any warning indicators. A technician can not confirm any faults even if they can duplicate the reported concern. Read More »
ROCKER ARM ASSY - ROLLER ROCKER Case 1.- Before replacing the intake or exhaust rocker arms due to an abnormal ticking noise, please check that the INTAKE Hydraulic Lash Adjusters are not "collapsed". Read More »
ADAPTER, Engine Oil Filter (Pentastar V6) For all 2014MY replace the Oil Filter Adapter (OFA). For any other MY (with mileage above 30,000) review and follow instructions from STAR Online S1809000007 REV. C available on Dealer Connect. Read More »
Engine When replacing a GMET4 long block from a 2021 JL or older, you will need to carry over the injector wiring harness from the original engine, and the Fuel pressure sensor should be replaced with part number: 68212572AB. Read More »
Flash: Battery Pack Control Module (BPCM) Diagnostic and System Updates Customers may experience a false Malfunction Indicator Lamp (MIL) illumination related to PHEV battery: ? P1A21-00 - HV Battery Contactor Control Sequence Incorrect. Read More »
Flash: Battery Pack Control Module (BPCM) Diagnostic and System Updates Customers may experience a false Malfunction Indicator Lamp (MIL) illumination related to PHEV battery: ? P1A21-00 - HV Battery Contactor Control Sequence Incorrect. Read More »
Flash: Hybrid Control Processor (HCP) and Auxiliary Hybrid Control Processor (AHCP) Updates Customers may experience a Malfunction Indicator Lamp (MIL) illumination. Read More »
UAQ and UCQ Radio Enhancements Customers may experience one or more of the following: ? **Wi-Fi hotspot connection failure. ? Speaker popping, crackle noise during Voice Recognition (VR) response and navigation guidance. Read More »
Service Hybrid Electric Vehicle System Message Displayed In The IPC. Vehicle Shakes During A Cold Start And Noise Is Heard Near The P2 Motor. DTC?s U0287-00 And B273C-00 Read More »
Axle Assembly A parts kit (SENSOR KIT, Axle: 68544629A$) is available to repair the Axle Locker Sensor on JL/JT equipped with the M210 and M220 Tru-Lok axles (DSE). This parts kit must be used when only the Axle Locker Sensor fails. Read More »
Red Rust On Rear Bumper Bolts This bulletin includes replacing all four bumper bolts. Customers may comment on the following: Red rust is present on the rear bumper bolts equipped with steel bumpers Read More »
Flash: Hybrid Control Processor (HCP) and Auxiliary Hybrid Control Processor (AHCP) Updates This bulletin involves reprogramming the HCP and AHCP or also known as Power Inverter Module (PIM) with the latest available software. Read More »
Flash: Battery Pack Control Module (BPCM) Diagnostic and System Updates This bulletin involves updating the BPCM with the latest available software. Read More »
Flash: Amplifier (AMP) Diagnostic and System Updates This bulletin involves reprogramming the AMP with the latest available software. Customers may experience a Malfunction Indicator Lamp (MIL) illumination. Read More »
AXLE, Service Rear A new parts kit (SENSOR KIT, Axle: 68544629AA) is available to repair the Axle Locker Sensor on the 2018 - 2022 JL/JT equipped with the M210 and M220 Tru-Lok axles (DSE). Read More »
Flash: Powertrain Control Module (PCM) Updates This bulletin involves reprogramming the PCM with the latest available software. Customers may experience a Malfunction Indicator Lamp (MIL) illumination. Read More »
Customer?s complaint may include a MIL-on with one or more of the following DTCs (Active, Pending, or Stored) in the PCM: P0133, P0137, P0171, P0300, P2096. Read More »
UAQ UCQ UAV, UCX, UAX and UCV Radio Over The Air Software Version Updates This bulletin provides information regarding the latest Flash Over The Air (FOTA) update and provides the service technician an overview of the steps a customer ... Read More »
Clunk or Scrape Noise From The Front Right Side of Vehicle This bulletin includes replacing the right front coil spring and lower shock bolt only. Read More »
Customer?s complaint may include a MIL-on with one or more of the following DTCs Active, Pending, or Stored in the PCM: P0133, P0137, P0171, P0300, P2096. Read More »
RADIO, MULTI Media (ASSY) The customers may have concerns of backup camera missing gridlines or showing black screen with "check entire surroundings" message while in Reverse mode. It is a backup camera initialization timing issue. Read More »
RADIO, MULTI Media (ASSY) The customers may have concerns of backup camera missing gridlines or showing black screen with "check entire surroundings" message while in Reverse mode. It is a backup camera initialization timing issue. Read More »
RADIO, MULTI Media (ASSY) The customers may have concerns of backup camera missing gridlines or showing black screen with "check entire surroundings" message while in Reverse mode. It is a backup camera initialization timing issue. Read More »
RADIO, MULTI Media (ASSY) The customers may have concerns of backup camera missing gridlines or showing black screen with "check entire surroundings" message while in Reverse mode. It is a backup camera initialization timing issue. Read More »
Flash: Powertrain Control Module (PCM) Updates This bulletin involves reprogramming the PCM with the latest available software. Customers may experience a Malfunction Indicator Lamp (MIL) illumination. Read More »
CAMERA, Rear View For concerns of back up camera flicker/blank/blue/black screen or camera inop, please ensure Radio is at latest software level. After update, system requires three sleep cycles to function properly. Read More »
CAMERA, Rear View For concerns of back up camera flicker/blank/blue/black screen or camera inop, please ensure Radio is at latest software level. After update, system requires three sleep cycles to function properly. Read More »
Radio Over The Air Updating to QR40.12 Software Version Mobile Wi-Fi inoperative upon start up. ? Hotspot gives 9No Internet9 connection message on phone, when trying to connect to a device. Read More »
Radio Over The Air Updating to 40.12 Software Version Mobile Wi-Fi inoperative upon start up. Hotspot gives 9No Internet9 connection message on phone when trying to connect to a device. Read More »
UKG Radio Enhancements This bulletin involves updating the radio software level to 2036.07. Customers may experience one or more of the following:Screen flickering. Carplay audio does not always resume. Read More »
UGA and UGG Radio Enhancements This bulletin involves inspecting and if required updating the radio software to 2036.08. Customers may experience one or more of the following: Screen flickering. Carplay audio does not always resume. Read More »
Floor Console USB Inoperative Customers may comment on the following: ? Customer states the Apple Carplay/Android Auto? does not work or is intermittently working when their device is plugged into the center console bin USB port. Read More »
Spring Front Upr - Isolator Before replacing this part. Please contact FCA REDACTED CONTENT. ~ If no response in 15 minutes, proceed with repair. Read More »
Radio Over The Air Updating to QR40.12 Software Version Mobile Wi-Fi inoperative upon start up. ? Hotspot gives 9No Internet9 connection message on phone, when trying to connect to a device. Read More »
Battery Kit, Hybrid NOTE 1 of 2: Beginning April 1, 2022, a $5,000 penalty will be assessed to dealers who return any visually damaged battery to the supplier. Read More »
If a Mopar oil filter is not available, use a filter that meets or exceeds USCAR36 specification and is compatible with semi and full synthetic oils. Read More »
Flash: Hybrid Control Processor (HCP) and Auxiliary Hybrid Control Processor (AHCP) Updates This bulletin involves reprogramming the HCP and AHCP or also known as Power Inverter Module (PIM) with the latest available software. Read More »
Flash: Integrated Dual Charging Module (IDCM) Enhancements This bulletin involves reprogramming the IDCM with the latest software available or replacing the IDCM if required. Read More »
Flash: Powertrain Control Module (PCM) Updates This bulletin involves reprogramming the PCM with the latest available software. Customers may experience a Malfunction Indicator Lamp (MIL) illumination. Read More »
Flash: Battery Pack Control Module (BPCM) Diagnostic and System Updates This bulletin involves updating the BPCM with the latest available software. Read More »
SHOCK ABSORBER KIT, Suspension, Front/Rear For concern of shock oil leak, please contact FCA Redacted Content prior to replacing this part. If no response in 15 minutes, proceed with the repair. Read More »
UAQ UCQ UAV, UCX, UAX and UCV Radio Over The Air Software Version Updates This bulletin provides information regarding the latest Flash Over The Air (FOTA) update and provides the service technician an overview of the steps a customer ... Read More »
UAQ UCQ UAV, UCX, UAX and UCV Radio Over The Air Software Version Updates This bulletin provides information regarding the latest Flash Over The Air (FOTA) update and provides the service technician an overview of the steps a customer ... Read More »
12V Battery Low Charge This bulletin involves testing and possibly replacing the 12V battery. Technicians or customers may experience a Malfunction Indicator Lamp MIL illumination. Read More »
Front Passenger Outer Seat Bolster Foam is Collapsed This bulletin includes repositioning the passenger outer seat bolster and installing a strap and push pin to help prevent this concern from happening again. Read More »
Apple CarPlay Malfunctioning, Does Not Launch Or Is Cutting In An Out On Wired And Wireless Connection, Radio Stuck When IPhone Is Connected Read More »
PUMP, Vacuum Prior to replacing the vacuum pumps, please contact or email FCA Redacted Content. If no response in 15 minutes, proceed with repair. Read More »
UKG Radio Enhancements This bulletin involves updating the radio software level to 2036.07. Customers may experience one or more of the following:Screen flickering. Carplay audio does not always resume. Read More »
UGA and UGG Radio Enhancements This bulletin involves inspecting and if required updating the radio software to 2036.08. Customers may experience one or more of the following: Screen flickering. Carplay audio does not always resume. Read More »
Radio Enhancements This bulletin involves updating the radio software level to 2036.06. Customers may experience the following:Product plan UUID is not correct in Carplay?. Carplay audio does not always resume. Battery save vs. Read More »
Radio Enhancements This bulletin involves updating the radio software level to 2036.06. Customers may experience the following:Product plan UUID is not correct in Carplay?. Carplay audio does not always resume. Battery save vs. Read More »
Key FOBIK Shortage and Restriction This bulletin is to inform customers, technicians and sales staff that vehicles are being delivered with only one key FOBIK due to a temporary semi conductor shortage. Read More »
VALVE, HIGH PRESSURE EGR If you are replacing the high pressure EGR valve (68490212A$) due to DTC P0407 or P0408 please refer to all published service information regarding proper diagnosis before proceeding. Read More »
COOLER, EGR If you are replacing the high pressure EGR cooler (p/n 68490113A$) for a suspected internal coolant leak that was detected by wetness in the EGR pipe or valve, please perform proper cooling system pressure test first to ... Read More »
WINDSHIELD Windshield cracked or blemish. When customer comes in for a cracked windshield, please note the location of crack and take pictures before repair. Read More »
3.6L Pentastar Upgrade Spark Plug Internal Crack This bulletin involves replacing all six spark plugs. Customers may experience a Malfunction Indicator Lamp (MIL) illumination. Read More »
3.6L Pentastar Upgrade Spark Plug Internal Crack This bulletin involves replacing all six spark plugs. Customers may experience a Malfunction Indicator Lamp (MIL) illumination. Read More »
ADAPTER, Engine Oil Filter If you are replacing the oil cooler/filter housing for an oil leak that appears to be between the cooler, and the engine block, please refer to all published service information regarding proper diagnosis of ... Read More »
(Rev. A) Malfunction Indicator Light (MIL) Illuminated. Service Diesel Exhaust Fluid (DEF) System ? See Dealer Soon Message on Electronic Vehicle Information Center (EVIC) Along With Possible Diagnostic Trouble Code (DTC) P241D - SCR ... Read More »
USB PORT, Media Hub For Android Auto and Apple Carplay issues, do not replace this part. Android Auto and Apple Carplay applications may not operate with the vehicle if an aftermarket cable is being used. Read More »
DIPAP Requirements - Addition of Jeep Wrangler (JL/JK) and Jeep Gladiator (JT) Hard Top and Targa Top Panel Replacements - All Dealers (Rev. A) Read More »
Thermostat Assy For 2022-2024MY 3.6L Pentastar Upgrade with P0128 failure code. PRIOR TO PERFORMING ANY THERMOSTAT REPLACEMENT, PROCEED WITH INSPECTION INSTRUCTIONS FROM THE LATEST VERSION OF STAR ONLINE PUBLICATION ... Read More »
Lithium Ion Batteries Beginning April 1, 2022, a $5,000 penalty will be assessed to dealers who return any visually damaged battery to the supplier. Read More »
Lithium Ion Batteries Beginning April 1, 2022, a $5,000 penalty will be assessed to dealers who return any visually damaged battery to the supplier. Read More »
Lithium Ion Batteries Beginning April 1, 2022, a $5,000 penalty will be assessed to dealers who return any visually damaged battery to the supplier. Read More »
Lithium Ion Batteries Beginning April 1, 2022, a $5,000 penalty will be assessed to dealers who return any visually damaged battery to the supplier. Read More »
UAQ and UCQ Radio Enhancements This bulletin involves inspecting and if required, updating the radio software level to: 39.6.The repair procedure must be followed step by step. Read More »
Apple CarPlay Malfunctioning, Does Not Launch Or Is Cutting In An Out On Wired And Wireless Connection, Radio Stuck When IPhone Is Connected Read More »
UKG Radio Enhancements This bulletin involves updating the radio software level to 2036.07. Customers may experience one or more of the following:Screen flickering. Carplay audio does not always resume. Read More »
UGA and UGG Radio Enhancements This bulletin involves inspecting and if required updating the radio software to 2036.08. Customers may experience one or more of the following: Screen flickering. Carplay audio does not always resume. Read More »
UGA and UGG Radio Enhancements This bulletin involves inspecting and if required updating the radio software to 2036.08. Customers may experience one or more of the following: Screen flickering. Carplay audio does not always resume. Read More »
UGA and UGG Radio Enhancements This bulletin involves inspecting and if required updating the radio software to 2036.08. Customers may experience one or more of the following: Screen flickering. Carplay audio does not always resume. Read More »
Key FOBIK Shortage and Restriction This bulletin is to inform customers, FOBIKs will be on restriction due to a temporary semi conductor shortage. Read More »
USB PORT, Media Hub For Android Auto and Apple Carplay issues, do not replace this part. Android Auto and Apple Carplay applications may not operate with the vehicle if an aftermarket cable is being used. Read More »
Radio Over The Air Update to Q339.3 to QR39.62 Software Version Customers may experience one or more of the following: ? Mobile Wi-Fi inoperative upon start up. Read More »
Radio Over The Air Updating From QR39.6 to QR40.12 Software Version Customers may experience one or more of the following symptoms: ? Mobile Wi-Fi inoperative upon start up. Read More »
Radio Over The Air Updating to QR40.12 Software Version ? Mobile Wi-Fi inoperative upon start up. ? Hotspot gives "No Internet" connection message on phone, when trying to connect to a device. Read More »
UAQ UCQ UAV, UCX, UAX and UCV Radio Over The Air Software Version Updates This bulletin provides information regarding the latest Flash Over The Air (FOTA) update and provides the service technician an overview of the steps a customer ... Read More »
UAQ UCQ UAV, UCX, UAX and UCV Radio Over The Air Software Version Updates This bulletin provides information regarding the latest Flash Over The Air (FOTA) update and provides the service technician an overview of the steps a customer ... Read More »
UAQ UCQ UAV and UCV Radio Over The Air Software Version Updates This bulletin provides information regarding the latest Flash Over The Air (FOTA) update and provides the service technician an overview of the steps a customer will need ... Read More »
Radio Enhancements This bulletin involves updating the radio software level to 2036.06. Customers may experience the following: Ghost Touch, features, modes and App?s changing without drivers input. Read More »
Radio Enhancements This bulletin involves updating the radio software level to 2036.06. Customers may experience the following: Ghost Touch, features, modes and App?s changing without drivers input. Read More »
Apple CarPlay Malfunctioning, Does Not Launch Or Is Cutting In An Out On Wired And Wireless Connection, Radio Stuck When IPhone Is Connected Read More »
UKG Radio Enhancements This bulletin involves updating the radio software level to 2036.07. Customers may experience one or more of the following:Screen flickering. Carplay audio does not always resume. Read More »
UKG Radio Enhancements This bulletin involves updating the radio software level to 2036.07. Customers may experience one or more of the following:Screen flickering. Carplay audio does not always resume. Read More »
UGA and UGG Radio Enhancements This bulletin involves inspecting and if required updating the radio software to 2036.08. Customers may experience one or more of the following: Screen flickering. Carplay audio does not always resume. Read More »
Radio Enhancements This bulletin involves updating the radio software level to 2036.06. Customers may experience the following:Product plan UUID is not correct in Carplay?. Carplay audio does not always resume. Battery save vs. Read More »
UGQ Radio Enhancements This bulletin involves inspecting and if required updating the radio software to: 39.3 Customers may experience the following:CarPlay? audio does not mute during an active Ecall. Read More »
Navigation (NAV) Reboot When MOTA Fails The customer may describe one of more of the following: ? Radio navigation continues to reboot after a Map Update (MOTA). ? Navigation regularly cuts out and back on again. Read More »
UAQ and UCQ Radio Enhancements Customers may experience one or more of the following: ? **Wi-Fi hotspot connection failure. ? Speaker popping, crackle noise during Voice Recognition (VR) response and navigation guidance. Read More »
RADIO, MULTI Media (ASSY) The customers may have concerns of backup camera missing gridlines or showing black screen with "check entire surroundings" message while in Reverse mode. It is a backup camera initialization timing issue. Read More »
USB PORT, Media Hub For Android Auto and Apple Carplay issues, do not replace this part. Android Auto and Apple Carplay applications may not operate with the vehicle if an aftermarket cable is being used. Read More »
UAQ UCQ UAV, UCX, UAX and UCV Radio Over The Air Software Version Updates This bulletin provides information regarding the latest Flash Over The Air (FOTA) update and provides the service technician an overview of the steps a customer ... Read More »
Water Pump For concern of leak at water pump, please check and re-torque water pump inlet tube fasteners as described in Service Bulletin 07-001-22 before replacing the water pump. Read More »
Lubrication and Maintenance Fluids If MOPAR fluids and chemicals are not readily available, please review Service Library for specifications so a suitable alternative can be used Read More »
Key FOBIK Shortage and Restriction This bulletin is to inform customers, FOBIKs will be on restriction due to a temporary semi conductor shortage. Read More »
complete wiring harness Before replacing this harness, please check for an available connector repair kit at the following: http://connectors.dcctools.com/home. Read More »
Flash: Transmission Control Module (TCM) Updates This bulletin involves reprogramming the TCM with the latest available software. Customers may experience a Malfunction Indicator Lamp (MIL) illumination. Read More »
Flash: Integrated Dual Charging Module (IDCM) Enhancements This bulletin involves reprogramming the IDCM with the latest software available or replacing the IDCM if required. Read More »
Flash: Hybrid Control Processor (HCP) and Auxiliary Hybrid Control Processor (AHCP) Updates This bulletin involves reprogramming the HCP and AHCP or also known as Power Inverter Module (PIM) with the latest available software. Read More »
Flash: Battery Pack Control Module (BPCM) Diagnostic and System Updates This bulletin involves updating the BPCM with the latest available software. Read More »
Flash: Powertrain Control Module (PCM) Updates This bulletin involves reprogramming the PCM with the latest available software. Customers may experience a Malfunction Indicator Lamp (MIL) illumination. Read More »
12V Battery Low Charge This bulletin involves testing and possibly replacing the 12V battery. Technicians or customers may experience a Malfunction Indicator Lamp MIL illumination. Read More »
VALVE, HIGH PRESSURE EGR If you are replacing the high pressure EGR valve (68490212A$) due to DTC P0407 or P0408 please refer to all published service information regarding proper diagnosis before proceeding. Read More »
COOLER, EGR If you are replacing the high pressure EGR cooler (p/n 68490113A$) for a suspected internal coolant leak that was detected by wetness in the EGR pipe or valve, please perform proper cooling system pressure test first to ... Read More »
Noise In Steering Column Tailshaft When Turning Steering Wheel This bulletin involves inspecting and replacing the steering column if necessary. Read More »
Radio Enhancements This bulletin involves updating the radio software level to 2036.06. Customers may experience the following:Product plan UUID is not correct in Carplay?. Carplay audio does not always resume. Battery save vs. Read More »
Radio Over The Air Update to Q339.3 to QR39.62 Software Version Customers may experience one or more of the following: ? Mobile Wi-Fi inoperative upon start up. Read More »
Radio Over The Air Updating From QR39.6 to QR40.12 Software Version Customers may experience one or more of the following symptoms: ? Mobile Wi-Fi inoperative upon start up. Read More »
Approved Use of Weld Through Primers This bulletin documents the FCA US LLC position regarding the use of weld through primer when using Squeeze Type Resistance Spot Welding (STRSW) and Gas Metal Arc Welding (GMAW) processes when ... Read More »
Key FOBIK Shortage and Restriction This bulletin is to inform customers, FOBIKs will be on restriction due to a temporary semi conductor shortage. Read More »
