Technical Service Bulletins (TSBs) for the 2019 2500 are official communications between Ram & their dealerships that describe processes for troubleshooting or fixing certain common problems.
All vehicle manufacturers are required by U.S. law to make their TSBs available to the public.
UAV and UCV Radio Enhancements Customers may experience one or more of the following: ? **Wi-Fi hotspot connection failure. ? Speaker popping, crackle noise during Voice Recognition (VR) response and navigation guidance. Read More »
UAV and UCV Radio Enhancements This bulletin involves inspecting and if required, updating the radio software level to: 39.6.The repair procedure must be followed step by step. Read More »
6.7L Cummins Engine High Pressure Fuel Injection Pump Identification Differences This bulletin provides information regarding the identification differences in the high pressure fuel injection pumps between the new style Symetrical Cam ... Read More »
Pro Comp Performance Suspension has found instances on the 2019 Ram 2500 4WD that the drag link cannot be adjusted short enough to center the steering wheel. Read More »
If replacing the steering linkage or drag link inner tie rod assembly at the pitman arm on a vehicle built before Febuary 14 th, 2008, verify that the pitman arm part number is 68039930AA. The part number is embossed on the pitman arm. Read More »
GASKET, Timing Case Cover, Rear Gear Housing For 2017-2020 model years only. If you are replacing the timing housing gasket due to an oil leak, please take detailed pictures of the leak, and submit them to the Star Center. Read More »
LIFTER, Hydraulic Roller Deactivating Please do not replace MDS lifters because the disconnecting pin is not lined up, this is normal and not a defect. Read More »
Flash: Air Suspension Control Module (ASCM) Updates This bulletin involves reprogramming the ASCM with the latest available software. Customers may experience a Malfunction Indicator Lamp (MIL) illumination. Read More »
Flash: Air Suspension Control Module (ASCM) Updates This bulletin involves reprogramming the ASCM with the latest available software. Customers may experience a Malfunction Indicator Lamp (MIL) illumination. Read More »
MODULE, Air Suspension, [SEB] For replacement of Air Suspension Control Module (ASCM) due to the following DTCs, please contact FCA Redacted Content to aid in root-cause prior to repair at FCA Redacted Content or FCA Redacted Content ... Read More »
DJ D2 Air Suspension Related Components For an air suspension light or any air suspension concern on 2019 or 2020 MY DJ D2, please call Phil Cataldo at (248) 220-0559 or Yussimil Libera at (248) 550-6086. Read More »
MODULE, Air Suspension, [SEB] For replacement of Air Suspension Control Module (ASCM) due to the following DTCs, please contact Santiago De La Rosa to aid in root-cause prior to repair at (248) 635-0819 or santiago.delarosa@fcagroup. Read More »
Pro Comp Performance Suspension has found instances on the 2019 Ram 2500 4WD that the drag link cannot be adjusted short enough to center the steering wheel. Read More »
Flash: Air Suspension Control Module (ASCM) Updates This bulletin involves reprogramming the ASCM with the latest available software. Customers may experience a Malfunction Indicator Lamp (MIL) illumination. Read More »
If replacing the steering linkage or drag link inner tie rod assembly at the pitman arm on a vehicle built before Febuary 14 th, 2008, verify that the pitman arm part number is 68039930AA. The part number is embossed on the pitman arm. Read More »
Flash: Air Suspension Control Module (ASCM) Updates This bulletin involves reprogramming the ASCM with the latest available software. Customers may experience a Malfunction Indicator Lamp (MIL) illumination. Read More »
Flash: Air Suspension Control Module (ASCM) Updates This bulletin involves reprogramming the ASCM with the latest available software. Customers may experience a Malfunction Indicator Lamp (MIL) illumination. Read More »
Noise From Rear of Cab Area While Driving Over Rough Roads or Bumps This bulletin involves inspecting and replacing the C-Pillar body mounts if needed. Read More »
Flash: Air Suspension Control Module (ASCM) Updates This bulletin involves reprogramming the ASCM with the latest available software. Customers may experience a Malfunction Indicator Lamp (MIL) illumination. Read More »
Flash: Air Suspension Control Module (ASCM) Updates This bulletin involves reprogramming the ASCM with the latest available software. Customers may experience a Malfunction Indicator Lamp (MIL) illumination. Read More »
PUMP, Vacuum For DTC Code P258B - ELECTRONIC VACUUM PUMP PERFORMANCE. Due to brake vacuum pumps returned with trouble not found, please follow the proper diagnostics outline in the service library this also includes checking all ... Read More »
HUB AND BEARING, Brake, Front For issues with front wheel Hub/Bearing growling or humming noise, appearing to leak grease, or with excessive play, please contact FCA Redacted Content before replacing. Read More »
PLATE - CLUTCH PRESSURE For 68RFE trans use selective fit pressure plates between the overdrive and reverse clutch packs and hence use all three 52119929A$, 52119930A$, 04799116A$ maintain clearance For 65RFE & 66RFE no selectives for ... Read More »
PLATE - CLUTCH PRESSURE For 68RFE trans use selective fit pressure plates between the overdrive and reverse clutch packs and hence use all three 52119929A$, 52119930A$, 04799116A$ maintain clearance For 65RFE & 66RFE no selectives for ... Read More »
Flash: Powertrain Control Module (PCM) Updates This bulletin involves reprogramming the Engine Control Module (ECM) / Powertrain Control Module (PCM) with the latest available software. Read More »
Uneven Front Brake Pad Wear This bulletin involves inspecting the front brake pads for uneven wear and it involvesre-torquing front brake fasteners and checking for proper caliper slide action. Read More »
Uneven Front Brake Pad Wear This bulletin involves inspecting the front brake pads for uneven wear and it involvesre-torquing front brake fasteners and checking for proper caliper slide action. Read More »
Customer may complain of a MIL lamp on. Upon further investigation there could be a fault code in the PCM for P1524 ? Oil Pressure Out of Range ? Camshaft Advance/Retard Disabled. Read More »
6.7L Cummins Engine High Pressure Fuel Injection Pump Identification Differences This bulletin provides information regarding the identification differences in the high pressure fuel injection pumps between the new style Symetrical Cam ... Read More »
Flash: Powertrain Control Module (PCM) Updates This bulletin involves reprogramming the Engine Control Module (ECM) / PowertrainControl Module (PCM) with the latest available software. Read More »
Flash: Powertrain Control Module (PCM) Updates This bulletin involves reprogramming the Engine Control Module (ECM) / Powertrain Control Module (PCM) with the latest available software. Read More »
PUMP, Vacuum For DTC Code P258B - ELECTRONIC VACUUM PUMP PERFORMANCE. Due to brake vacuum pumps returned with trouble not found, please follow the proper diagnostics outline in the service library this also includes checking all ... Read More »
SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DISC
Flash: Anti-lock Brake System (ABS) Enhancements This bulletin involves reprogramming the ABS module with the latest software available. Customers may experience a Malfunction Indicator Lamp (MIL) illumination. Read More »
Flash: Anti-lock Brake System (ABS) Enhancements This bulletin involves reprogramming the ABS module with the latest software available. Customers may experience a Malfunction Indicator Lamp (MIL) illumination. Read More »
UAV and UCV Radio Enhancements Customers may experience one or more of the following: ? **Wi-Fi hotspot connection failure. ? Speaker popping, crackle noise during Voice Recognition (VR) response and navigation guidance. Read More »
SWITCH, Ignition, Push Button (Keyless Ignition Node) Prior to replacing parts for a B1A7D-2A Diagnostic trouble code on heavy duty trucks.Please call FCA Redacted Content , please email a scan and config report to FCA Redacted Content. Read More »
Gasket, Timing Gear Housing For 2019, and 2020 Model Year Only. If you are replacing the timing housing gasket due to an oil leak, please take detailed pictures of the leak, and submit them to the Star Center. Read More »
WINDSHIELD For concern of rear view mirror loose or fell off, inspect mirror button. If the mirror button detatched from the winshield, please follow the normal repair process and take pictures of the button and the winshield trademark ... Read More »
6.7L Cummins Engine High Pressure Fuel Injection Pump Identification Differences This bulletin provides information regarding the identification differences between the CP4 style high-pressure fuel injection pump, and the new CP3. Read More »
Customer complaints may include abnormal engine noise, rough idle, lack of power, misfire. When performing diagnosis, an internal engine concern may be suspected. Read More »
Customer complaints may include abnormal engine noise, rough idle, lack of power, misfire. When performing diagnosis, an internal engine concern may be suspected. Read More »
Customer complaints may include abnormal engine noise, rough idle, lack of power, misfire. When performing diagnosis, an internal engine concern may be suspected. Read More »
6.7L Cummins Engine High Pressure Fuel Injection Pump Identification Differences This bulletin provides information regarding the identification differences in the high pressure fuel injection pumps between the new style Symetrical Cam ... Read More »
6.7L Cummins Engine High Pressure Fuel Injection Pump Identification Differences This bulletin provides information regarding the identification differences in the high pressure fuel injection pumps between the new style Symetrical Cam ... Read More »
RETAINER, Crankshaft Rear Oil Seal Oil leak from rear engine seal retainer or windage tray/gasket Check for other sources of leaks using dye such as gallery plugs, camshaft cup plug at rear of engine, rear of engine valley for ... Read More »
SEAL, Crankshaft Oil, Front Front crankshaft oil seal leak: For concern of front crankshaft seal leak please send an email to brenton.swank@fcagroup. Read More »
ADAPTER, Engine Oil Filter (Pentastar V6) Engineering is seeking information regarding OFA leaks. Questions/info can be directed to: Bob Jackson (248) 944-0466 - bob.jackson@fcagroup.com Ron Dallison (248-292-9510) ron. Read More »
6.7L New Oil Usage Information Incorrect oil used. This bulletin provides information regarding the correct oil grade to use on the 6.7L Cummins used in the 2023 to 2013 HD Trucks. Read More »
UAV and UCV Radio Enhancements Customers may experience one or more of the following: ? **Wi-Fi hotspot connection failure. ? Speaker popping, crackle noise during Voice Recognition (VR) response and navigation guidance. Read More »
Flash: Powertrain Control Module (PCM) Updates This bulletin involves reprogramming the Engine Control Module (ECM) / PowertrainControl Module (PCM) with the latest available software. Read More »
Flash: Powertrain Control Module (PCM) Updates This bulletin involves reprogramming the Engine Control Module (ECM) / PowertrainControl Module (PCM) with the latest available software. Read More »
FILTER, Air Filter (Cummins Engine) For all 2019 MY and newer 6.7L Cummins equipped vehicles, please use filter pn# 53034051A$ For all 2018 MY and older 6.7L Cummins equipped vehicles, and 2019 MY and newer non 6. Read More »
Flash: Powertrain Control Module (PCM) Updates This bulletin involves reprogramming the Engine Control Module (ECM) / Powertrain Control Module (PCM) with the latest available software. Read More »
If a Mopar oil filter is not available, use a filter that meets or exceeds USCAR36 specification and is compatible with semi and full synthetic oils. Read More »
Customer complaints may include abnormal engine noise, rough idle, lack of power, misfire. When performing diagnosis, an internal engine concern may be suspected. Read More »
Issue involves overheating, running hot, coolant leaks and related symptoms after a Mopar replacement engine has been installed in the vehicle. Read More »
Issue involves overheating, running hot, coolant leaks and related symptoms after a Mopar replacement engine has been installed in the vehicle. Read More »
P203E and P203F Additional Diagnostic Information This bulletin provides additional information regarding diagnosing Diesel Exhaust Fluid (DEF) issue in extreme cold weather. Read More »
Flash: Powertrain Control Module (PCM) Updates This bulletin involves reprogramming the Engine Control Module (ECM) / Powertrain Control Module (PCM) with the latest available software. Read More »
Customer may complain of a MIL lamp on. Upon further investigation there could be a fault code in the PCM for P1524 ? Oil Pressure Out of Range ? Camshaft Advance/Retard Disabled. Read More »
Customer complaints may include abnormal engine noise, rough idle, lack of power, misfire. Upon investigation, it may be found that there is excessive camshaft lobe wear/lifter wear (roller failure) on one or more cam lobes and that ... Read More »
Flash: Drivetrain Control Module (DTCM) Update This bulletin involves reprogramming the DTCM with the latest available software. The customer may experience a Malfunction Indicator Lamp (MIL) illumination. Read More »
Flash: Powertrain Control Module (PCM) Updates This bulletin involves reprogramming the Engine Control Module (ECM) / Powertrain Control Module (PCM) with the latest available software. Read More »
6.7L New Oil Usage Information This bulletin provides information regarding the correct oil grade to use on the 6.7L Cummins used in the 2019 and newer HD Trucks. The following information is intended to eliminate confusion. Read More »
Inspect Throttle Body Assembly This bulletin involves inspecting the Julian date on the throttle body and possibly replacing it. Customers may experience a Malfunction Indicator Lamp (MIL) illumination. Read More »
GASKET, Timing Case Cover, Rear Gear Housing For 2017-2020 model years only. If you are replacing the timing housing gasket due to an oil leak, please take detailed pictures of the leak, and submit them to the Star Center. Read More »
Gasket, Timing Gear Housing For 2019, and 2020 Model Year Only. If you are replacing the timing housing gasket due to an oil leak, please take detailed pictures of the leak, and submit them to the Star Center. Read More »
Inspect Throttle Body Assembly This bulletin involves inspecting the Julian date on the throttle body and possibly replacing it. Customers may experience a Malfunction Indicator Lamp (MIL) illumination. Read More »
Inspect Throttle Body Assembly This bulletin involves inspecting the Julian date on the throttle body and possibly replacing it. Customers may experience a Malfunction Indicator Lamp (MIL) illumination. Read More »
Inspect Throttle Body Assembly This bulletin involves inspecting the Julian date on the throttle body and possibly replacing it. Customers may experience a Malfunction Indicator Lamp (MIL) illumination. Read More »
Inspect Throttle Body Assembly This bulletin involves inspecting the Julian date on the throttle body and possibly replacing it. Customers may experience a Malfunction Indicator Lamp (MIL) illumination. Read More »
Inspect Throttle Body Assembly This bulletin involves inspecting the Julian date on the throttle body and possibly replacing it. Customers may experience a Malfunction Indicator Lamp (MIL) illumination. Read More »
Inspect Throttle Body Assembly This bulletin involves inspecting the Julian date on the throttle body and possibly replacing it. Customers may experience a Malfunction Indicator Lamp (MIL) illumination. Read More »
MASTER CYLINDER, Brake Prior to replacing master cylinder, please call Paul Kuehl at (248) 535 -7013 and/or Tim Parks at (248) 202-0919. If no response in 15 minutes, proceed with repair. Read More »
RETAINER, Crankshaft Rear Oil Seal Oil leak from rear engine seal retainer or windage tray/gasket Check for other sources of leaks using dye such as gallery plugs, camshaft cup plug at rear of engine, rear of engine valley for ... Read More »
ENGINE AND ENGINE COOLING:ENGINE:GASOLINE:TURBO/SUPERCHARGER
Customer complaints may include abnormal engine noise, rough idle, lack of power, misfire. When performing diagnosis, an internal engine concern may be suspected. Read More »
Flash: Powertrain Control Module (PCM) Updates This bulletin involves reprogramming the Engine Control Module (ECM) / PowertrainControl Module (PCM) with the latest available software. Read More »
Seal, Crankshaft Oil, Rear,Retainer, Crankshaft Oil Seal US dealers only: If you are replacing the rear main seal due to an oil leak, do NOT remove the seal from the retainer. Read More »
Seal, Crankshaft Oil, Rear,Retainer, Crankshaft Oil Seal US dealers only: If you are replacing the rear main seal due to an oil leak, do NOT remove the seal from the retainer. Read More »
Seal, Crankshaft Oil, Rear,Retainer, Crankshaft Oil Seal US dealers only: If you are replacing the rear main seal due to an oil leak, do NOT remove the seal from the retainer. Read More »
Customer complaints may include abnormal engine noise, rough idle, lack of power, misfire. Upon investigation, it may be found that there is excessive camshaft lobe wear/lifter wear (roller failure) on one or more cam lobes and that ... Read More »
DRIVE, Fan If a heavy duty diesel vehicle comes in with reports of loud fan noise or fan always on, please call FCA Redacted Content. If no response within 15 minutes, proceed with repair Read More »
Flash: Powertrain Control Module (PCM) Updates This bulletin involves reprogramming the Engine Control Module (ECM) / PowertrainControl Module (PCM) with the latest available software. Read More »
Flash: Powertrain Control Module (PCM) Updates This bulletin involves reprogramming the Engine Control Module (ECM) / PowertrainControl Module (PCM) with the latest available software. Read More »
Check Engine Light and/or Service Air Suspension, Service Diesel Exhaust System or Multiple Cluster Warning Lamps Illuminated With Electronic Vehicle Information Center (EVIC) Messages Read More »
Flash: Powertrain Control Module (PCM) Updates This bulletin involves reprogramming the Engine Control Module (ECM) / Powertrain Control Module (PCM) with the latest available software. Read More »
P203E and P203F Additional Diagnostic Information This bulletin provides additional information regarding diagnosing Diesel Exhaust Fluid (DEF) issue in extreme cold weather. Read More »
P203E and P203F Additional Diagnostic Information This bulletin provides additional information regarding diagnosing Diesel Exhaust Fluid (DEF) issue in extreme cold weather. Read More »
Flash: Powertrain Control Module (PCM) Updates This bulletin involves reprogramming the Engine Control Module (ECM) / Powertrain Control Module (PCM) with the latest available software. Read More »
6.7L Cummins Engine High Pressure Fuel Injection Pump Identification Differences This bulletin provides information regarding the identification differences in the high pressure fuel injection pumps between the new style Symetrical Cam ... Read More »
6.7L Cummins Engine High Pressure Fuel Injection Pump Identification Differences This bulletin provides information regarding the identification differences in the high pressure fuel injection pumps between the new style Symetrical Cam ... Read More »
6.7L Cummins Engine High Pressure Fuel Injection Pump Identification Differences This bulletin provides information regarding the identification differences in the high pressure fuel injection pumps between the new style Symetrical Cam ... Read More »
A/C LINES RAM HD/CC. For AC Refrigerant Low pressure, AC blows warm, Not Cold, not cold enough, there is an investigation for a low charge on the HVAC diagnosis. Read More »
SEAL, Input If looking to replace stubshaft due to ATX fluid leaking, do not replace PTU seals. None of the seals from the PTU side will need to be replaced whenever the ATX stubshaft is replaced, even though V-seal (68408748A$) is in ... Read More »
6.7L Cummins Engine High Pressure Fuel Injection Pump Identification Differences This bulletin provides information regarding the identification differences between the CP4 style high-pressure fuel injection pump, and the new CP3. Read More »
6.7L Cummins Engine High Pressure Fuel Injection Pump Identification Differences This bulletin provides information regarding the identification differences in the high pressure fuel injection pumps between the new style Symetrical Cam ... Read More »
Flash: Powertrain Control Module (PCM) Updates This bulletin involves reprogramming the Engine Control Module (ECM) / PowertrainControl Module (PCM) with the latest available software. Read More »
Flash: Powertrain Control Module (PCM) Updates This bulletin involves reprogramming the Engine Control Module (ECM) / PowertrainControl Module (PCM) with the latest available software. Read More »
Check Engine Light and/or Service Air Suspension, Service Diesel Exhaust System or Multiple Cluster Warning Lamps Illuminated With Electronic Vehicle Information Center (EVIC) Messages Read More »
Flash: Powertrain Control Module (PCM) Updates This bulletin involves reprogramming the Engine Control Module (ECM) / Powertrain Control Module (PCM) with the latest available software. Read More »
DRIVE, Fan If a heavy duty diesel vehicle comes in with reports of loud fan noise or fan always on, please call FCA Redacted Content. If no response within 15 minutes, proceed with repair Read More »
P203E and P203F Additional Diagnostic Information This bulletin provides additional information regarding diagnosing Diesel Exhaust Fluid (DEF) issue in extreme cold weather. Read More »
Diesel Fuel Pump Failure and System Contamination This bulletin involves inspecting for fuel pump failure and fuel system contamination. Also fuel system cleaning and fuel system kit replacement. Read More »
P203E and P203F Additional Diagnostic Information This bulletin provides additional information regarding diagnosing Diesel Exhaust Fluid (DEF) issue in extreme cold weather. Read More »
P203E and P203F Additional Diagnostic Information This bulletin provides additional information regarding diagnosing Diesel Exhaust Fluid (DEF) issue in extreme cold weather. Read More »
Flash: Powertrain Control Module (PCM) Updates This bulletin involves reprogramming the Engine Control Module (ECM) / Powertrain Control Module (PCM) with the latest available software. Read More »
Diesel Fuel Pump Failure and System Contamination This bulletin involves inspecting for fuel pump failure and fuel system contamination. Also fuel system cleaning and fuel system kit replacement. Read More »
Diesel Fuel Pump Failure and System Contamination This bulletin involves inspecting for fuel pump failure and fuel system contamination. Also fuel system cleaning and fuel system kit replacement. Read More »
Diesel Fuel Pump Failure and System Contamination This bulletin involves inspecting for fuel pump failure and fuel system contamination. Also fuel system cleaning and fuel system kit replacement. Read More »
Flash: Powertrain Control Module (PCM) Updates This bulletin involves reprogramming the Engine Control Module (ECM) / Powertrain Control Module (PCM) with the latest available software. Read More »
Transmission Kit with Torque Converter 1. All Promaster (VF) 3.6L/62TE equipped vehicles. If the transmission bracket to the transmission case fasteners are removed during servicing, the fasteners (Part Number 06511385A$) are one-time ... Read More »
Flash: Powertrain Control Module (PCM) Updates This bulletin involves reprogramming the Engine Control Module (ECM) / Powertrain Control Module (PCM) with the latest available software. Read More »
Flash: Powertrain Control Module (PCM) Updates This bulletin involves reprogramming the Engine Control Module (ECM) / Powertrain Control Module (PCM) with the latest available software. Read More »
Flash: Powertrain Control Module (PCM) Updates This bulletin involves reprogramming the Engine Control Module (ECM) / Powertrain Control Module (PCM) with the latest available software. Read More »
Flash: Powertrain Control Module (PCM) Updates This bulletin involves reprogramming the Engine Control Module (ECM) / Powertrain Control Module (PCM) with the latest available software. Read More »
Sunroof Water Leak This bulletin involves testing the sunroof for leaks and replacing the power sunroof glass, if necessary. The customer may describe a water leak from A-pillar grab handle or headliner microphone. Read More »
Inspect Throttle Body Assembly This bulletin involves inspecting the Julian date on the throttle body and possibly replacing it. Customers may experience a Malfunction Indicator Lamp (MIL) illumination. Read More »
Flash: Transmission Control Module (TCM) Updates This bulletin involves reprogramming the TCM with the latest available software. Customers may experience a Malfunction Indicator Lamp (MIL) illumination. Read More »
Flash: Transmission Control Module (TCM) Updates This bulletin involves reprogramming the TCM with the latest available software. Customers may experience a Malfunction Indicator Lamp (MIL) illumination. Read More »
MODULE, Air Suspension, [SEB] For replacement of Air Suspension Control Module (ASCM) due to the following DTCs, please contact FCA Redacted Content to aid in root-cause prior to repair at FCA Redacted Content or FCA Redacted Content ... Read More »
BRACKET, Gearshift For concern of shifter stuck in Park, please call Zach Luetzen at (832) 372-6116 prior to replair. If no response in 15 minutes, proceed with repair. Read More »
SEAL, Input If looking to replace stubshaft due to ATX fluid leaking, do not replace PTU seals. None of the seals from the PTU side will need to be replaced whenever the ATX stubshaft is replaced, even though V-seal (68408748A$) is in ... Read More »
Flash: Transmission Control Module (TCM) Updates This bulletin involves reprogramming the TCM with the latest available software. The following software enhancements are available:Coast-down downshift improvements for 4-3 and 3-2. Read More »
Inspect Throttle Body Assembly This bulletin involves inspecting the Julian date on the throttle body and possibly replacing it. Customers may experience a Malfunction Indicator Lamp (MIL) illumination. Read More »
Flash: Transmission Control Module (TCM) Updates This bulletin involves reprogramming the TCM with the latest available software. Customers may experience a Malfunction Indicator Lamp (MIL) illumination. Read More »
POWER TRAIN:AUTOMATIC TRANSMISSION:CONTROL MODULE (TCM/PCM/TECM)
Flash: Powertrain Control Module (PCM) Updates This bulletin involves reprogramming the Engine Control Module (ECM) / PowertrainControl Module (PCM) with the latest available software. Read More »
Flash: Powertrain Control Module (PCM) Updates This bulletin involves reprogramming the Engine Control Module (ECM) / PowertrainControl Module (PCM) with the latest available software. Read More »
Flash: Powertrain Control Module (PCM) Updates This bulletin involves reprogramming the Engine Control Module (ECM) / Powertrain Control Module (PCM) with the latest available software. Read More »
Flash: Powertrain Control Module (PCM) Updates This bulletin involves reprogramming the Engine Control Module (ECM) / Powertrain Control Module (PCM) with the latest available software. Read More »
Flash: Powertrain Control Module (PCM) Updates This bulletin involves reprogramming the Engine Control Module/Powertrain Control Module (ECM/PCM) with the latest available software. Read More »
Flash: Powertrain Control Module (PCM) Updates This bulletin involves reprogramming the Engine Control Module (ECM) / Powertrain Control Module (PCM) with the latest available software. Read More »
Flash: Powertrain Control Module (PCM) Updates This bulletin involves reprogramming the Engine Control Module/Powertrain Control Module (ECM/PCM) with the latest available software. Read More »
Flash: Powertrain Control Module (PCM) Updates This bulletin involves reprogramming the PCM with the latest available software. The customer may experience a Malfunction Indicator Lamp (MIL) illumination. Read More »
Flash: Drivetrain Control Module (DTCM) Update This bulletin involves reprogramming the DTCM with the latest available software. The customer may experience a Malfunction Indicator Lamp (MIL) illumination. Read More »
Connector kit Before ordering this connector repair kit 68018957A$, check it in the Mopar Connector Repair Kit Website to confirm part number and applicability. Read More »
PUMP, Vacuum For DTC Code P258B - ELECTRONIC VACUUM PUMP PERFORMANCE. Due to brake vacuum pumps returned with trouble not found, please follow the proper diagnostics outline in the service library this also includes checking all ... Read More »
Ambient Air Temperature Missing, Malfunction Indicator Lamp (MIL) Lamp On, Diagnostic Trouble Code (DTC) P0070-15 Ambient Air Temperature Sensor Circuit-Circuit Short to Battery or Open, P0073 Ambient Air Temperature Sensor Circuit ... Read More »
Start Stop Charging Warning Lamp Illuminated On, Intelligent Battery Sensor (IBS) State of Charge (SOC) Inaccurate, Battery Charging Message, Presence of IBS related Diagnostic Trouble Codes (DTCs), or Battery Warning Lamp ... Read More »
UAV and UCV Radio Enhancements Customers may experience one or more of the following: ? **Wi-Fi hotspot connection failure. ? Speaker popping, crackle noise during Voice Recognition (VR) response and navigation guidance. Read More »
Flash: Powertrain Control Module (PCM) Updates This bulletin involves reprogramming the Engine Control Module (ECM) / PowertrainControl Module (PCM) with the latest available software. Read More »
Flash: Powertrain Control Module (PCM) Updates This bulletin involves reprogramming the Engine Control Module (ECM) / PowertrainControl Module (PCM) with the latest available software. Read More »
Flash: Powertrain Control Module (PCM) Updates This bulletin involves reprogramming the Engine Control Module (ECM) / PowertrainControl Module (PCM) with the latest available software. Read More »
Flash: Powertrain Control Module (PCM) Updates This bulletin involves reprogramming the Engine Control Module (ECM) / Powertrain Control Module (PCM) with the latest available software. Read More »
UAX, UCX, UAV and UCV Radio Over the Air Software Version Updates This bulletin provides information regarding the latest Flash Over The Air (FOTA) update and provides the service technician an overview of the steps a customer will need ... Read More »
Flash: Air Suspension Control Module (ASCM) Updates This bulletin involves reprogramming the ASCM with the latest available software. Customers may experience a Malfunction Indicator Lamp (MIL) illumination. Read More »
UAX, UCX, UAV and UCV Radio Over the Air Software Version Updates This bulletin provides information regarding the latest Flash Over The Air (FOTA) update and provides the service technician an overview of the steps a customer will need ... Read More »
CAMERA (surround view - digital) When vehicle is equipped with surround view system (XAK sales code) and rear camera is not functioning - If rear camera is not functioning we would expect to see these Diagnostic Trouble Code (DTCs) set ... Read More »
CAMERA (surround view - digital) When vehicle is equipped with surround view system (XAK sales code) and rear camera is not functioning - If rear camera is not functioning we would expect to see these Diagnostic Trouble Code (DTCs) set ... Read More »
Flash: Powertrain Control Module (PCM) Updates This bulletin involves reprogramming the Engine Control Module (ECM) / Powertrain Control Module (PCM) with the latest available software. Read More »
Flash: Powertrain Control Module (PCM) Updates This bulletin involves reprogramming the Engine Control Module (ECM) / Powertrain Control Module (PCM) with the latest available software. Read More »
Flash: Powertrain Control Module (PCM) Updates This bulletin involves reprogramming the Engine Control Module/Powertrain Control Module (ECM/PCM) with the latest available software. Read More »
Radio and Back-up Camera Enhancements This bulletin involves updating the radio software level to 1848.34. Customers may experience one or more of the following:Radio display screen flickers. Read More »
Radio and Back-up Camera Enhancements This bulletin involves updating the radio software level to 1848.34. Customers may experience one or more of the following:Radio display screen flickers. Read More »
Flash: Drivetrain Control Module (DTCM) Update This bulletin involves reprogramming the DTCM with the latest available software. The customer may experience a Malfunction Indicator Lamp (MIL) illumination. Read More »
Flash: Drivetrain Control Module (DTCM) Update This bulletin involves reprogramming the DTCM with the latest available software. The customer may experience a Malfunction Indicator Lamp (MIL) illumination. Read More »
UAX, UCX, UAV and UCV Radio Over the Air Software Version Updates This bulletin provides information regarding the latest Flash Over The Air (FOTA) update and provides the service technician an overview of the steps a customer will need ... Read More »
Flash: Air Suspension Control Module (ASCM) Updates This bulletin involves reprogramming the ASCM with the latest available software. Customers may experience a Malfunction Indicator Lamp (MIL) illumination. Read More »
Flash: Air Suspension Control Module (ASCM) Updates This bulletin involves reprogramming the ASCM with the latest available software. Customers may experience a Malfunction Indicator Lamp (MIL) illumination. Read More »
6.7L Cummins Engine High Pressure Fuel Injection Pump Identification Differences This bulletin provides information regarding the identification differences in the high pressure fuel injection pumps between the new style Symetrical Cam ... Read More »
Flash: Powertrain Control Module (PCM) Updates This bulletin involves reprogramming the Engine Control Module (ECM) / Powertrain Control Module (PCM) with the latest available software. Read More »
Inspect Throttle Body Assembly This bulletin involves inspecting the Julian date on the throttle body and possibly replacing it. Customers may experience a Malfunction Indicator Lamp (MIL) illumination. Read More »
SWITCH, Ignition, Push Button (Keyless Ignition Node) Prior to replacing parts for a B1A7D-2A Diagnostic trouble code on heavy duty trucks.Please call FCA Redacted Content , please email a scan and config report to FCA Redacted Content. Read More »
Charging System, Battery Diagnostic Tools and Warranty This information only bulletin discusses using the correct test equipment for testing batteries and charging systems, and also warranty reimbursement when battery replacements are ... Read More »
UAX, UCX, UAV and UCV Radio Over the Air Software Version Updates This bulletin provides information regarding the latest Flash Over The Air (FOTA) update and provides the service technician an overview of the steps a customer will need ... Read More »
Flash: Transmission Control Module (TCM) Updates This bulletin involves reprogramming the TCM with the latest available software. Customers may experience a Malfunction Indicator Lamp (MIL) illumination. Read More »
Flash: Transmission Control Module (TCM) Updates This bulletin involves reprogramming the TCM with the latest available software. Customers may experience a Malfunction Indicator Lamp (MIL) illumination. Read More »
Body Control Module (BCM) Reconfigure for Enabling the Auto-On Comfort Settings This bulletin involves reconfiguring the BCM and possibly a radio reset, to enable the auto-on comfort settings. Read More »
MODULE, Air Suspension, [SEB] For replacement of Air Suspension Control Module (ASCM) due to the following DTCs, please contact FCA Redacted Content to aid in root-cause prior to repair at FCA Redacted Content or FCA Redacted Content ... Read More »
MODULE, Air Suspension, [SEB] For replacement of Air Suspension Control Module (ASCM) due to the following DTCs, please contact Santiago De La Rosa to aid in root-cause prior to repair at (248) 635-0819 or santiago.delarosa@fcagroup. Read More »
Flash: Powertrain Control Module (PCM) Updates This bulletin involves reprogramming the PCM with the latest available software. The customer may experience a Malfunction Indicator Lamp (MIL) illumination. Read More »
CAMERA, Forward Facing, [XAK] / Video Control Processor For DTC B2286-00 - Calibration not learned/Lost calibration set by the Central Vision Processing Module (CVPM), DO NOT try to run a service calibration routine before replacing the ... Read More »
CENTER STACK, Upper (Disassociated Display 8.4" with ICS Bezel) For concern of a "Yellow Band" on the center stack display, swapping the radio or display will NOT resolve the issue. Read More »
Flash: Transmission Control Module (TCM) Updates This bulletin involves reprogramming the TCM with the latest available software. The following software enhancements are available:Coast-down downshift improvements for 4-3 and 3-2. Read More »
Flash: Active Noise Cancellation (ANC) Module Enhancements This bulletin involves updating the ANC system with the latest available software. Read More »
Start Stop Charging Warning Lamp Illuminated On, Intelligent Battery Sensor (IBS) State of Charge (SOC) Inaccurate, Battery Charging Message, Presence of IBS related Diagnostic Trouble Codes (DTCs), or Battery Warning Lamp ... Read More »
Connector kit Before ordering this connector repair kit 68018957A$, check it in the Mopar Connector Repair Kit Website to confirm part number and applicability. Read More »
CONNECTOR/WIRING, Trailer Tow If the connector or wiring is physically damaged, burned, melted or corroded, prior to replacing the part, please contact FCA Redacted Content If no response in 15 minutes, proceed with repair. Read More »
CONNECTOR/WIRING, Trailer Tow If the connector or wiring is physically damaged, burned, melted or corroded, prior to replacing the part, please contact FCA Redacted Content If no response in 15 minutes, proceed with repair. Read More »
WIRING, Body Before replacing this harness, please contact FCA Redacted Content to see if a repair kit is available for your application. If no response in 15 minutes, proceed with repair. Read More »
CONNECTOR Trailer Tow,WIRING Trailer Tow,CONNECTOR 7 Way,WIRING Rear Bumper If the connector or wiring is physically damaged, burned, melted or corroded, prior to replacing the part, please contact FCA Redacted Content If no response in ... Read More »
ELECTRICAL SYSTEM:WIRING:CONNECTORS/PLUGS:ACCESORY POWER OUTLET/JACK/PORT/USB/SAE/CIGARETTE LIGHTER
Squeak, Rattle, Or Metallic Tapping Sound From Under The Instrument Panel This bulletin involves Inspecting and replacing the AMP bracket fastener. Read More »
Radio Over The Air Software Version Update to 22.66 This bulletin provides information regarding the latest Firmware Over The Air (FOTA) update and provides the service technician an overview of the steps a customer will need to take to ... Read More »
UAV and UCV Radio Enhancements This bulletin involves inspecting and if required, updating the radio software level to: 39.6.The repair procedure must be followed step by step. Read More »
6.7L Cummins Engine High Pressure Fuel Injection Pump Identification Differences This bulletin provides information regarding the identification differences in the high pressure fuel injection pumps between the new style Symetrical Cam ... Read More »
Flash: Anti-lock Brake System (ABS) Enhancements This bulletin involves reprogramming the ABS module with the latest software available. Customers may experience a Malfunction Indicator Lamp (MIL) illumination. Read More »
Flash: Transmission Control Module (TCM) Updates This bulletin involves reprogramming the TCM with the latest available software. Customers may experience a Malfunction Indicator Lamp (MIL) illumination. Read More »
Flash: Powertrain Control Module (PCM) Updates This bulletin involves reprogramming the Engine Control Module/Powertrain Control Module (ECM/PCM) with the latest available software. Read More »
Flash: Powertrain Control Module (PCM) Updates This bulletin involves reprogramming the Engine Control Module (ECM) / PowertrainControl Module (PCM) with the latest available software. Read More »
Flash: Powertrain Control Module (PCM) Updates This bulletin involves reprogramming the Engine Control Module (ECM) / Powertrain Control Module (PCM) with the latest available software. Read More »
Diesel Fuel Pump Failure and System Contamination This bulletin involves inspecting for fuel pump failure and fuel system contamination. Also fuel system cleaning and fuel system kit replacement. Read More »
Flash: Powertrain Control Module (PCM) Updates This bulletin involves reprogramming the Engine Control Module (ECM) / Powertrain Control Module (PCM) with the latest available software. Read More »
Flash: Powertrain Control Module (PCM) Updates This bulletin involves reprogramming the Engine Control Module/Powertrain Control Module (ECM/PCM) with the latest available software. Read More »
Flash: Drivetrain Control Module (DTCM) Update This bulletin involves reprogramming the DTCM with the latest available software. The customer may experience a Malfunction Indicator Lamp (MIL) illumination. Read More »
Inspect Throttle Body Assembly This bulletin involves inspecting the Julian date on the throttle body and possibly replacing it. Customers may experience a Malfunction Indicator Lamp (MIL) illumination. Read More »
Inspect Throttle Body Assembly This bulletin involves inspecting the Julian date on the throttle body and possibly replacing it. Customers may experience a Malfunction Indicator Lamp (MIL) illumination. Read More »
Inspect Throttle Body Assembly This bulletin involves inspecting the Julian date on the throttle body and possibly replacing it. Customers may experience a Malfunction Indicator Lamp (MIL) illumination. Read More »
LAMP, Center High Mounted Stop (CHMSL - Cargo lamp) For concern of water leak intrusion at CHMSL lamp: Before CHMSL lamp removal, please check for proper CHMSL installation. Read More »
Loose Wiper Arms This bulletin involves checking and or re-torquing the windshield wiper arm nuts. The customer may describe one or both of the windshield wiper arm are loose and may stop moving at times. Read More »
Sunroof Water Leak This bulletin involves testing the sunroof for leaks and replacing the power sunroof glass, if necessary. The customer may describe a water leak from A-pillar grab handle or headliner microphone. Read More »
LAMP, Center High Mounted Stop (CHMSL - Cargo lamp) For concern of water leak intrusion at CHMSL lamp: Before CHMSL lamp removal, please check for proper CHMSL installation. Read More »
Handle, Swivel Release and Grommet, Pivot Joint The box bed divider swivel release handle and pivot joint grommet are intended for DS only, and not to be used on DJ or DT. Read More »
Authentic Mopar? Glass Replacement This bulletin involves discussing FCA US LLC position with regard to collision repair industry awareness regarding the recommended usage of Authentic Mopar? Glass. Read More »
Authentic Mopar? Glass Replacement This bulletin involves discussing FCA US LLC position with regard to collision repair industry awareness regarding the recommended usage of Authentic Mopar? Glass. Read More »
WINDSHIELD For concern of rear view mirror loose or fell off, inspect mirror button. If the mirror button detatched from the winshield, please follow the normal repair process and take pictures of the button and the winshield trademark ... Read More »
WINDSHIELD For concern of rear view mirror loose or fell off, inspect mirror button. If the mirror button detatched from the winshield, please follow the normal repair process and take pictures of the button and the winshield trademark ... Read More »
PUMP, Washer, Windshield For pump leak concerns, if a leak is verified from the pump, without removing the pump, please contact the following to send the complete assembly back: Alan Leon at (248) 245-8049 or Kevin Murphree (248) ... Read More »
Loose Wiper Arms This bulletin involves checking and or re-torquing the windshield wiper arm nuts. The customer may describe one or both of the windshield wiper arm are loose and may stop moving at times. Read More »
Check Engine Lamp (CEL) on Diagnostic Trouble Codes (DTC?s) P0073 Ambient Air Temperature Sensor Circuit High, U113D-00 Lost Communication with Master Power Window Switch Read More »
Sunroof Water Leak This bulletin involves testing the sunroof for leaks and replacing the power sunroof glass, if necessary. The customer may describe a water leak from A-pillar grab handle or headliner microphone. Read More »
Sunroof Water Leak This bulletin involves testing the sunroof for leaks and replacing the power sunroof glass if necessary. The customer may describe a water leak from A-pillar grab handle or headliner microphone. Read More »
CAMERA, Rear View For concerns of back up camera flicker/blank/blue/black screen or camera inop, please ensure Radio is at latest software level. After update, system requires three sleep cycles to function properly. Read More »
Loose Wiper Arms This bulletin involves checking and or re-torquing the windshield wiper arm nuts. The customer may describe one or both of the windshield wiper arm are loose and may stop moving at times. Read More »
Check Engine Light and/or Service Air Suspension, Service Diesel Exhaust System or Multiple Cluster Warning Lamps Illuminated With Electronic Vehicle Information Center (EVIC) Messages Read More »
SEAT BELT, Front (RT / LT) Prior to replacing this part take pictures of the conector area at the harness and send to carmen.gonzalez@fcagroup.com. Read More »
Aluminum Body Panel Corrosion Repair Aluminum corrosion or bubbling along the leading edge of hood, hinges or other exterior surface areas of the hinges, doors, fenders, swing gates or liftgates. Read More »
Approved Use of Weld Through Primers This bulletin documents the FCA US LLC position regarding the use of weld through primer when using Squeeze Type Resistance Spot Welding (STRSW) and Gas Metal Arc Welding (GMAW) processes when ... Read More »
Approved Use of Weld Through Primers This bulletin documents the FCA US LLC position regarding the use of weld through primer when using Squeeze Type Resistance Spot Welding (STRSW) and Gas Metal Arc Welding (GMAW) processes when ... Read More »
Approved Use of Weld Through Primers This bulletin documents the FCA US LLC position regarding the use of weld through primer when using Squeeze Type Resistance Spot Welding (STRSW) and Gas Metal Arc Welding (GMAW) processes when ... Read More »
Noise From Rear of Cab Area While Driving Over Rough Roads or Bumps This bulletin involves inspecting and replacing the C-Pillar body mounts if needed. Read More »
Noise From Rear of Cab Area While Driving Over Rough Roads or Bumps This bulletin involves inspecting and replacing the C-Pillar body mounts if needed. Read More »
Inspect Throttle Body Assembly This bulletin involves inspecting the Julian date on the throttle body and possibly replacing it. Customers may experience a Malfunction Indicator Lamp (MIL) illumination. Read More »
Inspect Throttle Body Assembly This bulletin involves inspecting the Julian date on the throttle body and possibly replacing it. Customers may experience a Malfunction Indicator Lamp (MIL) illumination. Read More »
Inspect Throttle Body Assembly This bulletin involves inspecting the Julian date on the throttle body and possibly replacing it. Customers may experience a Malfunction Indicator Lamp (MIL) illumination. Read More »
LATCH, Tailgate Striker position also affects closing effort. Prior to ordering this part for a customer stating the Tailgate will not auto release when the tailgate is closed or is hard to close, first try adjusting the tailgate ... Read More »
Noise From A-Pillar or Floor Area During Turns or Body Movement This bulletin involves inspecting and replacing the A-Pillar body mounts if needed. Read More »
Noise From A-Pillar or Floor Area During Turns or Body Movement This bulletin involves inspecting and replacing the A-Pillar body mounts if needed. Read More »
Use of Aftermarket Parts This bulletin involves discussing FCA US LLC position with regard to collision repair industry awareness regarding the use of aftermarket parts. Read More »
Repair Parts Used For Structural Repairs This bulletin involves discussing FCA US LLC position with regard to structural repair parts usage. Read More »
Use of Aftermarket Parts This bulletin involves discussing FCA US LLC position with regard to collision repair industry awareness regarding the use of aftermarket parts. Read More »
Use of Salvage/Recycled Parts This bulletin involves discussing FCA US LLC position with regard to collision repair industry awareness regarding the use of recycled or salvage parts. Read More »
RamBox Applique Separation/Delamination This bulletin involves inspecting and possibly removing, installing new tape and re-installing one or both of the RamBox appliques. Read More »
Noise From A-Pillar or Floor Area During Turns or Body Movement This bulletin involves inspecting and replacing the A-Pillar body mounts if needed. Read More »
Inspect Throttle Body Assembly This bulletin involves inspecting the Julian date on the throttle body and possibly replacing it. Customers may experience a Malfunction Indicator Lamp (MIL) illumination. Read More »
CONNECTOR Trailer Tow,WIRING Trailer Tow,CONNECTOR 7 Way,WIRING Rear Bumper If the connector or wiring is physically damaged, burned, melted or corroded, prior to replacing the part, please contact FCA Redacted Content If no response in ... Read More »
Tailgate Cable Has Excessive Slack or is Loose This bulletin involves replacing one of the tailgate cables with a new tailgate service cable. Read More »
Tailgate Cable Has Excessive Slack or is Loose This bulletin involves replacing one of the tailgate cables with a new tailgate service cable. Read More »
Sunroof Water Leak This bulletin involves testing the sunroof for leaks and replacing the power sunroof glass, if necessary. The customer may describe a water leak from A-pillar grab handle or headliner microphone. Read More »
Approved Use of Weld Through Primers This bulletin documents the FCA US LLC position regarding the use of weld through primer when using Squeeze Type Resistance Spot Welding (STRSW) and Gas Metal Arc Welding (GMAW) processes when ... Read More »
LATCH, Tailgate Striker position also affects closing effort. Prior to ordering this part for a customer stating the Tailgate will not auto release when the tailgate is closed or is hard to close, first try adjusting the tailgate ... Read More »
CUPHOLDER, Center Console Please note: If the customer complains of the center console cupholder not latching or stuck closed, please follow the instructions below prior to replacing the part. Read More »
Sunroof Water Leak This bulletin involves testing the sunroof for leaks and replacing the power sunroof glass, if necessary. The customer may describe a water leak from A-pillar grab handle or headliner microphone. Read More »
LATCH, Tailgate Striker position also affects closing effort. Prior to ordering this part for a customer stating the Tailgate will not auto release when the tailgate is closed or is hard to close, first try adjusting the tailgate ... Read More »
PEDAL, Accelerator (APPS) Before replacing accelerator pedal for P061B, make sure all PCM software service bulletins and recalls are up to date, if applicable. Read More »
Enable Tire Fill Alert This bulletin involves a vehicle reconfiguration for proper operation of the Tire Fill Assist feature. The customer may notice:Tire Fill Alert or Selectable Tire Fill Alert does not work. Read More »
Enable Tire Fill Alert This bulletin involves a vehicle reconfiguration for proper operation of the Tire Fill Assist feature. The customer may notice:Tire Fill Alert or Selectable Tire Fill Alert does not work. Read More »
Enable Tire Fill Alert This bulletin involves a vehicle reconfiguration for proper operation of the Tire Fill Assist feature. The customer may notice:Tire Fill Alert or Selectable Tire Fill Alert does not work. Read More »
Enable Tire Fill Alert This bulletin involves a vehicle reconfiguration for proper operation of the Tire Fill Assist feature. The customer may notice:Tire Fill Alert or Selectable Tire Fill Alert does not work. Read More »
UAV and UCV Radio Enhancements Customers may experience one or more of the following: ? **Wi-Fi hotspot connection failure. ? Speaker popping, crackle noise during Voice Recognition (VR) response and navigation guidance. Read More »
UAV and UCV Radio Enhancements This bulletin involves inspecting and if required, updating the radio software level to: 39.6.The repair procedure must be followed step by step. Read More »
CONNECTOR Trailer Tow,WIRING Trailer Tow,CONNECTOR 7 Way,WIRING Rear Bumper If the connector or wiring is physically damaged, burned, melted or corroded, prior to replacing the part, please contact FCA Redacted Content If no response in ... Read More »
CONNECTOR/WIRING, Trailer Tow If the connector or wiring is physically damaged, burned, melted or corroded, prior to replacing the part, please contact FCA Redacted Content If no response in 15 minutes, proceed with repair. Read More »
CONNECTOR/WIRING, Trailer Tow If the connector or wiring is physically damaged, burned, melted or corroded, prior to replacing the part, please contact FCA Redacted Content If no response in 15 minutes, proceed with repair. Read More »
CONNECTOR/WIRING, Trailer Tow If the connector or wiring is physically damaged, burned, melted or corroded, prior to replacing the part, please contact FCA Redacted Content If no response in 15 minutes, proceed with repair. Read More »
MODULE, Trailer Tow (Integrated Trailer Brake Module For concern of error message ?Park Assist System Disabled? displayed on the Cluster with DTC U0137 stored or active, please review the communication path between the ITBM and PTS ... Read More »
HVAC Housing Service This bulletin informing the Technician about an HVAC housing redesign with components that need to be serviced together when servicing the HVAC housing. Read More »
CUPHOLDER, Center Console Please note: If the customer complains of the center console cupholder not latching or stuck closed, please follow the instructions below prior to replacing the part. Read More »
LATCH, Tailgate Striker position also affects closing effort. Prior to ordering this part for a customer stating the Tailgate will not auto release when the tailgate is closed or is hard to close, first try adjusting the tailgate ... Read More »
Body Control Module (BCM) Reconfigure for Enabling the Auto-On Comfort Settings This bulletin involves reconfiguring the BCM and possibly a radio reset, to enable the auto-on comfort settings. Read More »
Flash: Powertrain Control Module (PCM) Updates This bulletin involves reprogramming the Engine Control Module (ECM) / PowertrainControl Module (PCM) with the latest available software. Read More »
Flash: Powertrain Control Module (PCM) Updates This bulletin involves reprogramming the Engine Control Module (ECM) / PowertrainControl Module (PCM) with the latest available software. Read More »
Flash: Air Suspension Control Module (ASCM) Updates This bulletin involves reprogramming the ASCM with the latest available software. Customers may experience a Malfunction Indicator Lamp (MIL) illumination. Read More »
LATCH, Tailgate Striker position also affects closing effort. Prior to ordering this part for a customer stating the Tailgate will not auto release when the tailgate is closed or is hard to close, first try adjusting the tailgate ... Read More »
MODULE, Air Suspension, [SEB] For replacement of Air Suspension Control Module (ASCM) due to the following DTCs, please contact FCA Redacted Content to aid in root-cause prior to repair at FCA Redacted Content or FCA Redacted Content ... Read More »
Check Engine Light and/or Service Air Suspension, Service Diesel Exhaust System or Multiple Cluster Warning Lamps Illuminated With Electronic Vehicle Information Center (EVIC) Messages Read More »
UAV and UCV Radio Enhancements Customers may experience one or more of the following: ? **Wi-Fi hotspot connection failure. ? Speaker popping, crackle noise during Voice Recognition (VR) response and navigation guidance. Read More »
Flash: Powertrain Control Module (PCM) Updates This bulletin involves reprogramming the Engine Control Module (ECM) / PowertrainControl Module (PCM) with the latest available software. Read More »
Flash: Powertrain Control Module (PCM) Updates This bulletin involves reprogramming the Engine Control Module (ECM) / Powertrain Control Module (PCM) with the latest available software. Read More »
P203E and P203F Additional Diagnostic Information This bulletin provides additional information regarding diagnosing Diesel Exhaust Fluid (DEF) issue in extreme cold weather. Read More »
UAV and UCV Radio Enhancements This bulletin involves inspecting and if required, updating the radio software level to: 39.6.The repair procedure must be followed step by step. Read More »
CAMERA (surround view - digital) When vehicle is equipped with surround view system (XAK sales code) and rear camera is not functioning - If rear camera is not functioning we would expect to see these Diagnostic Trouble Code (DTCs) set ... Read More »
CAMERA (surround view - digital) When vehicle is equipped with surround view system (XAK sales code) and rear camera is not functioning - If rear camera is not functioning we would expect to see these Diagnostic Trouble Code (DTCs) set ... Read More »
P203E and P203F Additional Diagnostic Information This bulletin provides additional information regarding diagnosing Diesel Exhaust Fluid (DEF) issue in extreme cold weather. Read More »
CAMERA, Rear View For concerns of back up camera flicker/blank/blue/black screen or camera inop, please ensure Radio is at latest software level. After update, system requires three sleep cycles to function properly. Read More »
CAMERA, Rear View For concerns of back up camera flicker/blank/blue/black screen or camera inop, please ensure Radio is at latest software level. After update, system requires three sleep cycles to function properly. Read More »
Flash: Powertrain Control Module (PCM) Updates This bulletin involves reprogramming the Engine Control Module (ECM) / Powertrain Control Module (PCM) with the latest available software. Read More »
Radio and Back-up Camera Enhancements This bulletin involves updating the radio software level to 1848.34. Customers may experience one or more of the following:Radio display screen flickers. Read More »
Radio and Back-up Camera Enhancements This bulletin involves updating the radio software level to 1848.34. Customers may experience one or more of the following:Radio display screen flickers. Read More »
Uneven Front Brake Pad Wear This bulletin involves inspecting the front brake pads for uneven wear and it involvesre-torquing front brake fasteners and checking for proper caliper slide action. Read More »
6.7L Cummins Engine High Pressure Fuel Injection Pump Identification Differences This bulletin provides information regarding the identification differences in the high pressure fuel injection pumps between the new style Symetrical Cam ... Read More »
WINDSHIELD For concern of rear view mirror loose or fell off, inspect mirror button. If the mirror button detatched from the winshield, please follow the normal repair process and take pictures of the button and the winshield trademark ... Read More »
WINDSHIELD For concern of rear view mirror loose or fell off, inspect mirror button. If the mirror button detatched from the winshield, please follow the normal repair process and take pictures of the button and the winshield trademark ... Read More »
CAMERA, Forward Facing, [XAK] / Video Control Processor For DTC B2286-00 - Calibration not learned/Lost calibration set by the Central Vision Processing Module (CVPM), DO NOT try to run a service calibration routine before replacing the ... Read More »
Radio Over The Air JR34.3 Updating to JR34.32.Software Version Customers may experience one or more of the following: Not be able to use Mobile Wi-Fi upon start up. Read More »
Diesel Fuel Pump Failure and System Contamination This bulletin involves inspecting for fuel pump failure and fuel system contamination. Also fuel system cleaning and fuel system kit replacement. Read More »
If a Mopar oil filter is not available, use a filter that meets or exceeds USCAR36 specification and is compatible with semi and full synthetic oils. Read More »
UAX, UCX, UAV and UCV Radio Over the Air Software Version Updates This bulletin provides information regarding the latest Flash Over The Air (FOTA) update and provides the service technician an overview of the steps a customer will need ... Read More »
Diesel Fuel Pump Failure and System Contamination This bulletin involves inspecting for fuel pump failure and fuel system contamination. Also fuel system cleaning and fuel system kit replacement. Read More »
PLATE - CLUTCH PRESSURE For 68RFE trans use selective fit pressure plates between the overdrive and reverse clutch packs and hence use all three 52119929A$, 52119930A$, 04799116A$ maintain clearance For 65RFE & 66RFE no selectives for ... Read More »
Tailgate Cable Has Excessive Slack or is Loose This bulletin involves replacing one of the tailgate cables with a new tailgate service cable. Read More »
HVAC Housing Service This bulletin informing the Technician about an HVAC housing redesign with components that need to be serviced together when servicing the HVAC housing. Read More »
Noise From Rear of Cab Area While Driving Over Rough Roads or Bumps This bulletin involves inspecting and replacing the C-Pillar body mounts if needed. Read More »
6.7L Cummins Engine High Pressure Fuel Injection Pump Identification Differences This bulletin provides information regarding the identification differences in the high pressure fuel injection pumps between the new style Symetrical Cam ... Read More »
Flash: Drivetrain Control Module (DTCM) Update This bulletin involves reprogramming the DTCM with the latest available software. The customer may experience a Malfunction Indicator Lamp (MIL) illumination. Read More »
UAX, UCX, UAV and UCV Radio Over the Air Software Version Updates This bulletin provides information regarding the latest Flash Over The Air (FOTA) update and provides the service technician an overview of the steps a customer will need ... Read More »
USB PORT, Media Hub For Android Auto and Apple Carplay issues, do not replace this part. Android Auto and Apple Carplay applications may not operate with the vehicle if an aftermarket cable is being used. Read More »
Loose Wiper Arms This bulletin involves checking and or re-torquing the windshield wiper arm nuts. The customer may describe one or both of the windshield wiper arm are loose and may stop moving at times. Read More »
CUPHOLDER, Center Console Please note: If the customer complains of the center console cupholder not latching or stuck closed, please follow the instructions below prior to replacing the part. Read More »
Charging System, Battery Diagnostic Tools and Warranty This information only bulletin discusses using the correct test equipment for testing batteries and charging systems, and also warranty reimbursement when battery replacements are ... Read More »
APPLIQUE, Storage Bin (Rambox) For concern of Rambox applique fading, do not replace the applique. This is due to wax or other chemical substance being used on a grain in molded color part. Read More »
Inspect Throttle Body Assembly This bulletin involves inspecting the Julian date on the throttle body and possibly replacing it. Customers may experience a Malfunction Indicator Lamp (MIL) illumination. Read More »
Use of Aftermarket Parts This bulletin involves discussing FCA US LLC position with regard to collision repair industry awareness regarding the use of aftermarket parts. Read More »
Repair Parts Used For Structural Repairs This bulletin involves discussing FCA US LLC position with regard to structural repair parts usage. Read More »
Enable Tire Fill Alert This bulletin involves a vehicle reconfiguration for proper operation of the Tire Fill Assist feature. The customer may notice:Tire Fill Alert or Selectable Tire Fill Alert does not work. Read More »
Enable Tire Fill Alert This bulletin involves a vehicle reconfiguration for proper operation of the Tire Fill Assist feature. The customer may notice:Tire Fill Alert or Selectable Tire Fill Alert does not work. Read More »
WINDSHIELD For concern of rear view mirror loose or fell off, inspect mirror button. If the mirror button detatched from the winshield, please follow the normal repair process and take pictures of the button and the winshield trademark ... Read More »
Flash: Powertrain Control Module (PCM) Updates This bulletin involves reprogramming the Engine Control Module/Powertrain Control Module (ECM/PCM) with the latest available software. Read More »
CENTER STACK, Upper (Disassociated Display 8.4" with ICS Bezel) For concern of a "Yellow Band" on the center stack display, swapping the radio or display will NOT resolve the issue. Read More »
RamBox Applique Separation/Delamination This bulletin involves inspecting and possibly removing, installing new tape and re-installing one or both of the RamBox appliques. Read More »
RADIO [RES] - New and/or Service Exchange For RES radio concerns. Use the wiTECH 2.0 and inspect the radio part number and serial number under the Radio/ECU Details tab. Read More »
ADAPTER, Engine Oil Filter (Pentastar V6) Engineering is seeking information regarding OFA leaks. Questions/info can be directed to: Bob Jackson (248) 944-0466 - bob.jackson@fcagroup.com Ron Dallison (248-292-9510) ron. Read More »
Flash: Active Noise Cancellation (ANC) Module Enhancements This bulletin involves updating the ANC system with the latest available software. Read More »
UAX, UCX, UAV and UCV Radio Over the Air Software Version Updates This bulletin provides information regarding the latest Flash Over The Air (FOTA) update and provides the service technician an overview of the steps a customer will need ... Read More »
USB PORT, Media Hub For Android Auto and Apple Carplay issues, do not replace this part. Android Auto and Apple Carplay applications may not operate with the vehicle if an aftermarket cable is being used. Read More »
LAMP, Center High Mounted Stop (CHMSL - Cargo lamp) For concern of water leak intrusion at CHMSL lamp: Before CHMSL lamp removal, please check for proper CHMSL installation. Read More »
A/C LINES RAM HD/CC. For AC Refrigerant Low pressure, AC blows warm, Not Cold, not cold enough, there is an investigation for a low charge on the HVAC diagnosis. Read More »
Flash: Active Noise Cancellation (ANC) Module Enhancements This bulletin involves updating the ANC system with the latest available software. Read More »
Radio Over The Air Software Version Update to 22.66 This bulletin provides information regarding the latest Firmware Over The Air (FOTA) update and provides the service technician an overview of the steps a customer will need to take to ... Read More »
UAX, UCX, UAV and UCV Radio Over the Air Software Version Updates This bulletin provides information regarding the latest Flash Over The Air (FOTA) update and provides the service technician an overview of the steps a customer will need ... Read More »
UAX, UCX, UAV and UCV Radio Over the Air Software Version Updates This bulletin provides information regarding the latest Flash Over The Air (FOTA) update and provides the service technician an overview of the steps a customer will need ... Read More »
RADIO [RES] - New and/or Service Exchange For RES radio concerns. Use the wiTECH 2.0 and inspect the radio part number and serial number under the Radio/ECU Details tab. Read More »
USB PORT, Media Hub For Android Auto and Apple Carplay issues, do not replace this part. Android Auto and Apple Carplay applications may not operate with the vehicle if an aftermarket cable is being used. Read More »
Lubrication and Maintenance Fluids If MOPAR fluids and chemicals are not readily available, please review Service Library for specifications so a suitable alternative can be used Read More »
6.7L New Oil Usage Information This bulletin provides information regarding the correct oil grade to use on the 6.7L Cummins used in the 2019 and newer HD Trucks. The following information is intended to eliminate confusion. Read More »
6.7L New Oil Usage Information This bulletin provides information regarding the correct oil grade to use on the 6.7L Cummins used in the 2019 and newer HD Trucks. The following information is intended to eliminate confusion. Read More »
LAMP, Center High Mounted Stop (CHMSL - Cargo lamp) For concern of water leak intrusion at CHMSL lamp: Before CHMSL lamp removal, please check for proper CHMSL installation. Read More »
PLATE - CLUTCH PRESSURE For 68RFE trans use selective fit pressure plates between the overdrive and reverse clutch packs and hence use all three 52119929A$, 52119930A$, 04799116A$ maintain clearance For 65RFE & 66RFE no selectives for ... Read More »
HVAC Housing Service This bulletin informing the Technician about an HVAC housing redesign with components that need to be serviced together when servicing the HVAC housing. Read More »
Noise From Rear of Cab Area While Driving Over Rough Roads or Bumps This bulletin involves inspecting and replacing the C-Pillar body mounts if needed. Read More »
Noise From Rear of Cab Area While Driving Over Rough Roads or Bumps This bulletin involves inspecting and replacing the C-Pillar body mounts if needed. Read More »
6.7L Cummins Engine High Pressure Fuel Injection Pump Identification Differences This bulletin provides information regarding the identification differences in the high pressure fuel injection pumps between the new style Symetrical Cam ... Read More »
Loose Wiper Arms This bulletin involves checking and or re-torquing the windshield wiper arm nuts. The customer may describe one or both of the windshield wiper arm are loose and may stop moving at times. Read More »
Inspect Throttle Body Assembly This bulletin involves inspecting the Julian date on the throttle body and possibly replacing it. Customers may experience a Malfunction Indicator Lamp (MIL) illumination. Read More »
WINDSHIELD For concern of rear view mirror loose or fell off, inspect mirror button. If the mirror button detatched from the winshield, please follow the normal repair process and take pictures of the button and the winshield trademark ... Read More »
HVAC Housing Service This bulletin informing the Technician about an HVAC housing redesign with components that need to be serviced together when servicing the HVAC housing. Read More »
HVAC Housing Service This bulletin informing the Technician about an HVAC housing redesign with components that need to be serviced together when servicing the HVAC housing. Read More »
A/C LINES RAM HD/CC. For AC Refrigerant Low pressure, AC blows warm, Not Cold, not cold enough, there is an investigation for a low charge on the HVAC diagnosis. Read More »
Approved Use of Weld Through Primers This bulletin documents the FCA US LLC position regarding the use of weld through primer when using Squeeze Type Resistance Spot Welding (STRSW) and Gas Metal Arc Welding (GMAW) processes when ... Read More »
Seal, Crankshaft Oil, Rear,Retainer, Crankshaft Oil Seal US dealers only: If you are replacing the rear main seal due to an oil leak, do NOT remove the seal from the retainer. Read More »
Customer complaints may include abnormal engine noise, rough idle, lack of power, misfire. When performing diagnosis, an internal engine concern may be suspected. Read More »
6.7L New Oil Usage Information This bulletin provides information regarding the correct oil grade to use on the 6.7L Cummins used in the 2019 and newer HD Trucks. The following information is intended to eliminate confusion. Read More »
