2005 Pontiac G6
145 Technical Service Bulletins (TSBs)
TSB List for the 2005 Pontiac G6
Technical Service Bulletins (TSBs) for the 2005 G6 are official communications between Pontiac & their dealerships that describe processes for troubleshooting or fixing certain common problems. All vehicle manufacturers are required by U.S. law to make their TSBs available to the public.
STEERING
-
TSB #14327
14327 - SPECIAL COVERAGE. SOME VEHICLES MAY HAVE BEEN BUILT WITHOUT A STEERING GEAR UMBRELLA SEAL. WITHOUT THE SEAL, WATER AND DIRT MAY ENTER THE SYSTEM AND COULD CAUSE THE RACK AND PINION PARTS TO CORRODE. Read More »
-
TSB #14327
GENERAL MOTORS : TSB CONTAINS AN OWNER NOTIFICATION LETTER. SELECT DOCUMENT SEARCH BUTTON BELOW. 2004-2005 CHEVROLET MALIBU, MALIBU MAXX , 2005 PONTIAC G6. LOSS OF STEERING DUE TO WATER INTRUSION (STEER GEAR UMBRELLA SEAL MISSING). Read More »
-
TSB #060232002
NORMAL OPERATING CHARACTERISTICS OF ELECTRIC POWER STEERING (EPS) SYSTEM DURING EXTENDED LOCK-TO-LOCK (MAXIMUM STEERING WHEEL ROTATION) USAGE. *TT UPDATED 3/30/11. *PE Read More »
-
TSB #060232007
CLUNK, KNOCK OR RATTLE NOISE FROM FRONT OF VEHICLE WHILE DRIVING OR TURNING OVER BUMPS AT LOW SPEEDS. Read More »
-
TSB #040235009
NOISY STEERING COLUMN, LACK OF POWER STEERING ASSIST, DIAGNOSTIC TROUBLE CODES C0460 AND C0545, STEERING WHEEL MOVES SLIGHTLY BY ITSELF. *MJ (REPLACE STEERING COLUMN) UPDATED 01/18/08. Read More »
-
TSB #050232001
INCREASED STEERING EFFORT. *TT UPDATE. *TT UPDATED 03-07-07. *KB Read More »
STEERING:COLUMN
-
TSB #07126
CHEVROLET\PONTIAC SERVICE CAMPAIGN: SEE DOCUMENT SEARCH BUTTON FOR OWNER LETTER. SPECIAL COVERAGE ADJUSTMENT - LOSS OF POWER STEERING ASSIST. *NJ Read More »
-
TSB #040235009
NOISY STEERING COLUMN, LACK OF POWER STEERING ASSIST, DIAGNOSTIC TROUBLE CODES C0460 AND C0545, STEERING WHEEL MOVES SLIGHTLY BY ITSELF. *MJ (REPLACE STEERING COLUMN) UPDATED 01/18/08. Read More »
-
TSB #050235001
STEERING COLUMN TILT/TELESCOPE WHEEL LEVER AVAILABLE FOR SERVICE USE. *TT Read More »
STEERING:GEAR BOX (OTHER THAN RACK AND PINION)
-
TSB #14327
THIS TSB COMNTAINS AN OWNER NOTIFICATION LETTER. GENERAL MOTORS 2004-2005 CHEVROLET MALIBU, MALIBU MAXX , PONTIAC G6: BULLETIN COVERAGE REGARDING LOSS OF STEERING DUE TO WATER INTRUSION VEHICLES MAY HAVE BEEN BUILT WITHOUT A ... Read More »
STEERING:ELECTRIC POWER ASSIST SYSTEM
-
TSB #SB-0000188787-A
SUMMARY TO BE PROVIDED ON A FUTURE DATE. Read More »
-
TSB #SB-10183
SATURN\PONTIAC\CHEVROLET SERVICE CAMPAIGN: SEE DOCUMENT SEARCH BUTTON FOR OWNER LETTER. SPECIAL COVERAGE ADJUSTMENT-POWER STEERING ASSIST. Read More »
-
TSB #060232002
NORMAL OPERATING CHARACTERISTICS OF ELECTRIC POWER STEERING (EPS) SYSTEM DURING EXTENDED LOCK-TO-LOCK (MAXIMUM STEERING WHEEL ROTATION) USAGE. *TT UPDATED 3/30/11. *PE Read More »
-
TSB #3797
INTERMITTENT STEERING WHEEL DITHER AFTER FRONT END ALIGNMENT WAS PERFORMED. *TT Read More »
-
TSB #3795
ELECTRIC STEERING IS INOPERATIVE WITH C0545. *AK Read More »
SUSPENSION
-
TSB #050307002
REVISED FRONT CAMBER AND FRONT CAMBER CROSS TOLERANCE SPECIFICATIONS. *TT Read More »
TRACTION CONTROL SYSTEM
-
TSB #SB-15-08-45-001
PONTIAC/SATURN/CHEVROLET: SOME VEHICLES ARE EXPERIENCING MULTIPLE ISSUES/SYMPTOMS CAUSED BY BODY HARNESS HARD CONTACT AGAINST FLOOR EDGE PANEL UNDER LEFT REAR SEAT CUSHION. MODEL 2004-12 MALIBU, MALIBU MAXX, 2007-09 AURA, 2005-10 G6. Read More »
SERVICE BRAKES, HYDRAULIC:PEDALS AND LINKAGES
-
TSB #PIC-4658
ADJUSTABLE PEDALS WILL NOT ADJUST INOPERATIVE. *NJ UPDATED 3/13/09. *PE UPDATED 8/1/11. *PE Read More »
-
TSB #PIC--4330B
CHEVROLET: UNABLE TO RELEARN THE BRAKE PEDAL POSITION (BPP) SENSOR. *PE Read More »
-
TSB #PIC-4330A
GMC: UNABLE TO RELEARN THE BRAKE PEDAL POSITION (BPP) SENSOR. HAVE DIFFICULTY PERFORMING THE BRAKE PEDAL POSITION (BPP) RELEARN. MODELS CHEVROLETS, PONTIACS AND SATURNS. *PE Read More »
ENGINE (PWS)
-
TSB #PIP5029G
THIS PRELIMINARY INFORMATION COMMUNICATION PROVIDES INFORMATION TO THE TECHNICIAN ABOUT VEHICLES THAT HAVE A MALFUNCTION INDICATOR LAMP ON OR ENGINE MISFIRE, ROUGH IDLE, EXTENDED CRANK, OR CRANK NO START IN SOME CASES. Read More »
-
TSB #PI1394A
THIS INFORMATIONAL BULLETIN PROVIDES ADDITIONAL INFORMATION ON HOW TO INSTALL PISTONS AND SUGGEST WHAT TOOLS TO USE. Read More »
-
TSB #030603004R
THIS INFORMATIONAL BULLETIN PROVIDES INFORMATION ON HOW TO TEST A BATTERY AND WHAT IS NEEDED TO WARRANTY A BATTERY. Read More »
-
TSB #000601012F
THIS INFORMATIONAL BULLETIN PROVIDES INFORMATION TO GM DEALERS ON THE CORRECT CLEANING METHODS WHEN CLEANING ENGINE GASKET SEALING SURFACES. Read More »
-
TSB #000601026I
THIS INFORMATIONAL BULLETINS PROVIDES INFORMATION ON THE INTAKE MANIFOLD INSPECTION/REPLACEMENT AFTER SERVERE INTERNAL ENGINE DAMAGE. Read More »
-
TSB #SB-15-08-45-001
PONTIAC/SATURN/CHEVROLET: SOME VEHICLES ARE EXPERIENCING MULTIPLE ISSUES/SYMPTOMS CAUSED BY BODY HARNESS HARD CONTACT AGAINST FLOOR EDGE PANEL UNDER LEFT REAR SEAT CUSHION. MODEL 2004-12 MALIBU, MALIBU MAXX, 2007-09 AURA, 2005-10 G6. Read More »
-
TSB #PIP-5064-B
BUICK/CHEVROLET/PONTIAC/SATURN: AFTER INSTALLING REMAN HVV6 ENGINE, WOULD BE CONCERN WITH ROUGH RUNNING OR MISFIRE ON ONE OR BOTH BANKS OF ENGINE OR IDLE SURGING. Read More »
ENGINE AND ENGINE COOLING
-
TSB #PIP4786C
THIS PRELIMINARY INFORMATION COMMUNICATION PROVIDES INFORMATION TO THE TECHNICIAN ABOUT VEHICLES THAT MAY HAVE LOW OIL PRESSURE MESSAGE. TECHNICIAN MAY ALSO FIND A DIAGNOSTIC TROUBLE CODE P0521 IN THE ENGINE CONTROL MODULE. Read More »
-
TSB #050601005A
WHISTLE TYPE NOISE COMING FROM ENGINE. *TT Read More »
-
TSB #050604004
INFORMATION TO AVOID SETTING DIAGNOSTIC TROUBLE CODE P0442 LARGE EVAP LEAK WHEN HOISTING VEHICLE. *EH Read More »
-
TSB #09292004
PCM TO CORRECT A SLIGHT ENGINE IDLE RPM FLAIR CONDITION. *EH Read More »
-
TSB #3135
PDI AND SERVICE GUIDE BULLETIN. *TC Read More »
ENGINE AND ENGINE COOLING:ENGINE
-
TSB #SB-09-06-04-007A
SATURN/PONTIAC/CHEVROLET: THE FUEL GAUGE DOES NOT RISE ABOVE THE 3/4 MARK AFTER A FILL UP OR THE FUEL GAUGE APPEARS STUCK. AN ILLUMINATION OF THE CHECK ENGINE LIGHT. Read More »
-
TSB #060604002
SERVICE ENGINE SOON (SES) LIGHT ILLUMINATED, MULTIPLE POWERTRAIN CONTROL MODULE (PCM) DIAGNOSTIC TROUBLE CODE (DTC) P1404 AND/OR P0404. 06-06-04-002 NOT YET RECEIVED. *TT UPDATED 04-27-07. *KB Read More »
-
TSB #060601014
L36, L67, L26, L32, LA1, LX9, MN7, M15. TICKING OR KNOCKING TYPE NOISE COMING FROM THE ENGINE OR TRANSMISSION AREA. *KB Read More »
-
TSB #05548A
PROGRAM BULLETIN (CUSTOMER SATISFACTION PROGRAM)-ENGINE HARMONIC BALANCER NOT SEATED. *SC Read More »
-
TSB #0804
OIL LIFE SYSTEM RESET PROCEDURES - CARS. *NM Read More »
-
TSB #3535A
CRANK NO START (LX9) ONLY. *SC Read More »
-
TSB #3399
ENGINE CRANKS BUT WILL NOT START. *SC Read More »
ENGINE AND ENGINE COOLING:ENGINE:DIESEL
-
TSB #030604017I
THIS INFORMATIONAL BULLETIN EXPLAINS THE USE OF DIESEL FUEL ADDITIVES IN AN ENGINE, ARE NOT REQUIRED UNLESS THE CUSTOMER DESIRES ADDITIVES TO PREVENT FUEL CONCERNS DEPENDING ON FUEL OR TEMPERATURE RELATED CONDITIONS. Read More »
ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL:GAS RECIRCULATION VALVE (EGR VALVE)
-
TSB #3332B
DIAGNOSTIC TROUBLE CODE P0404 EGR CONCERN. *TT Read More »
FUEL SYSTEM, OTHER
-
TSB #701
FUEL FILTER REPLACEMENT. GM TECH LINK. *TT Read More »
FUEL SYSTEM, OTHER:STORAGE:FUEL GAUGE SYSTEM
-
TSB #SB-15-08-45-001
PONTIAC/SATURN/CHEVROLET: SOME VEHICLES ARE EXPERIENCING MULTIPLE ISSUES/SYMPTOMS CAUSED BY BODY HARNESS HARD CONTACT AGAINST FLOOR EDGE PANEL UNDER LEFT REAR SEAT CUSHION. MODEL 2004-12 MALIBU, MALIBU MAXX, 2007-09 AURA, 2005-10 G6. Read More »
-
TSB #SB-09-06-04-007A
SATURN/PONTIAC/CHEVROLET: THE FUEL GAUGE DOES NOT RISE ABOVE THE 3/4 MARK AFTER A FILL UP OR THE FUEL GAUGE APPEARS STUCK. AN ILLUMINATION OF THE CHECK ENGINE LIGHT. Read More »
-
TSB #3088A
FUEL GAUGE NOT READING FULL AFTER A CUSTOMER FILL. *SC Read More »
POWER TRAIN
-
TSB #3441
4T40E/4T45E HARD TO SHIFT. *TT Read More »
POWER TRAIN:MANUAL TRANSMISSION
-
TSB #PIP-4674
CHEVROLET/PONTIAC/SATURN: BLOCKED SHIFT, GEAR HOP OUT 1ST, 3RD, 5TH GEAR OR DIFFICULTY SHIFTING. THE SHIFT LEVER ON THE MANUAL TRANSMISSIONS ROLL PIN CAN BACK OUT AND CONTACT THE SHIFT COVER DURING A SHIFT EVENT. Read More »
POWER TRAIN:AUTOMATIC TRANSMISSION
-
TSB #12106C
SUMMARY TO BE PROVIDED ON A FUTURE DATE. Read More »
-
TSB #070730025
INFORMATION ON 4T40-E (MN4) AND 4T45-E (MN5) FRONT WHEEL DRIVE AUTOMATIC TRANSMISSION VALVE BODY RECONDITIONING, DTC P0741, P0742, P0751, P0752, P0756, P0757, P1811, HARSH SHIFTS, SLIPS, NO DRIVE, NO REVERSE. Read More »
POWER TRAIN:AUTOMATIC TRANSMISSION:CONTROL MODULE (TCM/PCM/TECM)
-
TSB #05539
PRODUCT EMISSION RECALL TO REPLACE THE POWERTRAIN/ENGINE CONTROL MODULE (PCM/ECM). THE POWERTRAIN/ENGINE CONTROL MODULE (PCM/ECM) MAY HAVE BEEN MANUFACTURED WITH DAMAGED INTERNAL IC CHIPS, WHICH MAY AFFECT THE FUEL PUMP CONTROL AND EGR ... Read More »
-
TSB #040604069
ENGINE RPM FLARE (REPROGRAM PCM). GM SERVICE AND PARTS OPERATIONS. *NM THIS INFORMATION PERTAINS TO ADVANCED SERVICE BULLETIN 04-06-04-069 PCM REPROGRAM. *TT ACTUAL SERVICE BULLETIN. *TT Read More »
POWER TRAIN:AUTOMATIC TRANSMISSION:GEAR POSITION INDICATION (PRNDL)
-
TSB #SB-12106
SUMMARY TO BE PROVIDED ON A FUTURE DATE. Read More »
-
TSB #SB-08-05-22-009A
CHEVROLET/PONTIAC/SATURN: INTERMITTENTLY BRAKE LIGHTS (STOP LAMPS) DO NOT FUNCTION CORRECTLY, EXTENDED TRAVEL TO SHIFT OUT OF PARK, CRUISE CONTROL INOPERATIVE, DTCS C0161/C0277 SET (PERFORM REPAIR AS OUTLINED). *PE UPDATED 5/11/11. Read More »
POWER TRAIN:AUTOMATIC TRANSMISSION:LEVER AND LINKAGE:COLUMN SHIFT
-
TSB #SB-0000164892-A
SUMMARY TO BE PROVIDED ON A FUTURE DATE. Read More »
-
TSB #SB-0000157297-A
SUMMARY TO BE PROVIDED ON A FUTURE DATE. Read More »
-
TSB #RB-12106
SUMMARY TO BE PROVIDED ON A FUTURE DATE. Read More »
POWER TRAIN:AUTOMATIC TRANSMISSION:LEVER AND LINKAGE:FLOOR SHIFT
-
TSB #SB-0000164892-A
SUMMARY TO BE PROVIDED ON A FUTURE DATE. Read More »
-
TSB #SB-0000157297-A
SUMMARY TO BE PROVIDED ON A FUTURE DATE. Read More »
ELECTRICAL SYSTEM
-
TSB #PIT5074J
THIS PRELIMINARY INFORMATION COMMUNICATION PROVIDES INFORMATION TO THE TECHNICIAN ABOUT THE USE OF J-35616-64B TERMINAL TEST PROBE, REPLACEMENT TERMINALS, AND TERMINATED LEADS. Read More »
-
TSB #PIP5094A
THIS PRELIMINARY INFORMATION COMMUNICATION ADVISES THE TECHNICIAN THAT ,WHEN TESTING ANY CIRCUIT FOR OPEN OR RESISTANCE, IT IS IMPERATIVE THAT ALL RELATED TERMINAL PIN FIT AND TENSION BE CHECKED WHEN THE TEST STEPS REQUIRE DISCONNECTION ... Read More »
-
TSB #PIT5485B
THIS PRELIMINARY INFORMATION COMMUNICATION ADVISES THE TECHNICIAN IF UNABLE TO PLACE AN ONSTAR CALL IN THE IGNITION ON MODE AFTER THE ONSTAR CANADA UPGRADE, TO CONTACT THE GM TECHNICAL ASSISTANCE CENTER ONSTAR GROUP FOR FURTHER ASSISTANCE. Read More »
-
TSB #PIC-5050-A
THIS PRELIMINARY INFORMATION COMMUNICATION ADVISES THE TECHNICIAN THE STEPS ON REPAIRING THE CONCERN. A CUSTOMER MAY IDENTIFY A CONCERN OF UNABLE TO REACTIVATE A VEHICLE'S ONSTAR THAT HAS BEEN PREVIOUSLY DISABLED BY ONSTAR. Read More »
-
TSB #PIC-4935-E
THIS PRELIMINARY INFORMATION COMMUNICATION PROVIDES INFORMATION TO HELP THE DEALERSHIP TECHNICIANS PERFORM A PARASITIC DRAIN TEST FOR THE ONSTAR MODULE. Read More »
-
TSB #PIC4935E
THIS PRELIMINARY INFORMATION COMMUNICATION PROVIDES INFORMATION TO HELP THE DEALERSHIP TECHNICIANS PERFORM A PARASITIC DRAIN TEST FOR THE ONSTAR MODULE. Read More »
-
TSB #PIT5485A
THIS PRELIMINARY INFORMATION COMMUNICATION ADVISES THE TECHNICIAN, IF UNABLE TO PLACE AN ONSTAR CALL IN THE IGNITION ON MODE AFTER THE ONSTAR CANADA UPGRADE TO CONTACT THE GM TECHNICAL ASSISTANCE CENTER ONSTAR GROUP FOR FURTHER ASSISTANCE. Read More »
-
TSB #PIC-5260-A
THIS PRELIMINARY INFORMATION COMMUNICATION ADVISES THE TECHNICIAN THE STEPS ON DIAGNOSING THE CONCERN. VEHICLE'S SUNROOF OPERATION INTERMITTENT, BIND, NOISE, AUTO-REVERSE, AND/OR WATER LEAKS. Read More »
-
TSB #PIT5074F
GM: J-35616-64B TERMINAL TEST PROBE AND REPLACEMENT TERMINAL. ALSO INCLUDED MODELS VERANO, REGAL, LACROSSE, CTS, SRX, VOLT, SONIC, MALIBU, IMPALA, EQUINOX, CRUZE, AVALANCHE, TAHOE SUBURBAN, SILVERADO, SIERRA, YUKON, AND TERRAIN FOR ... Read More »
-
TSB #08089-B
GENERAL MOTORS CORP: SPECIAL COVERAGE ADJUSTMENT; ANALOG ONSTAR DEACTIVATION. *PE UPDATED 2/17/09. *PE Read More »
-
TSB #3170
SERVICE ENGINE SOON LIGHT ON AND OR VARIOUS ELECTRICAL CONCERNS. *EH UPDATED 1/29/08. *NJ Read More »
-
TSB #03112005
THE REMOTE START NO LONGER WORKS. *EH Read More »
-
TSB #03092005
REPROGRAMMING THE BCM. *EH Read More »
-
TSB #612
SIR LAMP BEING DISPLAY AND CODES B0012 AND B0013 WITH SYMPTOM CODE 0E. GM TECH LINK. *TT Read More »
-
TSB #3159C
SIR LIGHT ON WITH CODES B0012.0E AND B0013.0E. *TT Read More »
-
TSB #3261B
(RETAINED ACCESSORY POWER) RAP DEACTIVATES FROM DRIVERS DOOR ONLY. *TT Read More »
ELECTRICAL SYSTEM:12V/24V/48V BATTERY
-
TSB #030603004R
THIS INFORMATIONAL BULLETIN PROVIDES INFORMATION ON HOW TO TEST A BATTERY AND WHAT IS NEEDED TO WARRANTY A BATTERY. Read More »
-
TSB #PIC-4935-E
THIS PRELIMINARY INFORMATION COMMUNICATION PROVIDES INFORMATION TO HELP THE DEALERSHIP TECHNICIANS PERFORM A PARASITIC DRAIN TEST FOR THE ONSTAR MODULE. Read More »
-
TSB #3349A
BATTERY DRAW ADDITIONAL INFO. *TT Read More »
ELECTRICAL SYSTEM:STARTER ASSEMBLY
-
TSB #3649
INTERMITTENT LONG CRANK BUT WILL NOT START OR INTERMITTENT NO CRANK. *TT Read More »
-
TSB #3550
STARTER STAYS ENGAGED AFTER ENGINE STARTS. *AK Read More »
ELECTRICAL SYSTEM:WIRING:FUSES AND CIRCUIT BREAKERS
-
TSB #PIC3385
REPEATED PARK LPS FUSE OPEN. *KB (ADDITIONAL INFORMATION) UPDATED 4/1/08. *NJ Read More »
-
TSB #3976
INTERMITTENT PARK LAMP FUSE GOES OPEN. *TT Read More »
-
TSB #3385A
REPEATED PARK LPS FUSE OPEN (ADDITIONAL INFORMATION). *TT Read More »
ELECTRICAL SYSTEM:IGNITION:SWITCH
-
TSB #3480
INTERMITTENTLY THE IGNITION KEY WILL NOT COME OUT OF IGNITION LOCK CYLINDER. SERVICE VME. *TT Read More »
ELECTRICAL SYSTEM: INSTRUMENT CLUSTER/PANEL
-
TSB #060849016
INSTRUMENT PANEL CLUSTER (IPC) BACKLIGHTING INOPERATIVE DURING DAYLIGHT HOURS. *KB Read More »
ELECTRICAL SYSTEM:SOFTWARE
-
TSB #08089-B
GENERAL MOTORS CORP: SPECIAL COVERAGE ADJUSTMENT; ANALOG ONSTAR DEACTIVATION. *PE UPDATED 2/17/09. *PE Read More »
EXTERIOR LIGHTING
-
TSB #3393A
BACKLIGHTING IS INOP DURING DAYLIGHT CONDITIONS (HEADLIGHT SWITCH TURNED ON MANUALLY) *SC Read More »
-
TSB #3393
BACKLIGHTING IS INOPERATIVE DURING DAYLIGHT CONDITIONS (HEADLIGHT SWITCH TURNED ON MANUALLY). *TT Read More »
EXTERIOR LIGHTING:HEADLIGHTS
-
TSB #3159
SIR LIGHT ON WITH CODES B00120E AND B00130E. *EH Read More »
EXTERIOR LIGHTING:BRAKE LIGHTS
-
TSB #SB-0000191931-A
SUMMARY TO BE PROVIDED ON A FUTURE DATE. Read More »
-
TSB #SB-08-05-22-009A
CHEVROLET/PONTIAC/SATURN: INTERMITTENTLY BRAKE LIGHTS (STOP LAMPS) DO NOT FUNCTION CORRECTLY, EXTENDED TRAVEL TO SHIFT OUT OF PARK, CRUISE CONTROL INOPERATIVE, DTCS C0161/C0277 SET (PERFORM REPAIR AS OUTLINED). *PE UPDATED 5/11/11. Read More »
EXTERIOR LIGHTING:BRAKE LIGHTS:SWITCH
-
TSB #SB-08-05-22-009A
CHEVROLET/PONTIAC/SATURN: INTERMITTENTLY BRAKE LIGHTS (STOP LAMPS) DO NOT FUNCTION CORRECTLY, EXTENDED TRAVEL TO SHIFT OUT OF PARK, CRUISE CONTROL INOPERATIVE, DTCS C0161/C0277 SET (PERFORM REPAIR AS OUTLINED). *PE UPDATED 5/11/11. Read More »
VISIBILITY
-
TSB #PIC5260A
THIS PRELIMINARY INFORMATION COMMUNICATION ADVISES THE TECHNICIAN THE STEPS ON DIAGNOSING THE CONCERN. VEHICLE'S SUNROOF OPERATION INTERMITTENT, BIND, NOISE, AUTO-REVERSE, AND/OR WATER LEAKS. Read More »
VISIBILITY:SUN/MOON ROOF ASSEMBLY
-
TSB #PIC-5260-A
THIS PRELIMINARY INFORMATION COMMUNICATION ADVISES THE TECHNICIAN THE STEPS ON DIAGNOSING THE CONCERN. VEHICLE'S SUNROOF OPERATION INTERMITTENT, BIND, NOISE, AUTO-REVERSE, AND/OR WATER LEAKS. Read More »
-
TSB #3472
PANORAMIC SUNROOF WIND RUSH NOISE. *TT Read More »
VISIBILITY:REARVIEW MIRRORS/DEVICES
-
TSB #PI0373A
THIS PRELIMINARY INFORMATIONAL BULLETIN PROVIDES A PROCEDURE FOR RELEARNING THE POWER FOLDING MIRRIORS AND ROAD TESTIN TO VERIFY THEY CORRECT A CONDTION OF THE POWER FOLDING MIRRIORS GLASS SHAKES, FLUTTERS AT NORMAL DRIVING CONDITIONS. Read More »
VISIBILITY:WINDSHIELD WIPER/WASHER
-
TSB #701
PULSE WIPER OPERATION. *TT Read More »
-
TSB #3057
SPEED SENSITIVE WIPERS. *TT Read More »
VISIBILITY:WINDSHIELD WIPER/WASHER:MOTOR
-
TSB #3057A
SPEED SINSITIVE WIPERS. *TC Read More »
VISIBILITY:DEFROSTER/DEFOGGER/HVAC SYSTEM
-
TSB #3726A
REAR DEFOG IS INOPERATIVE. *TT Read More »
VISIBILITY:DEFROSTER/DEFOGGER/HVAC SYSTEM:REAR WINDOW
-
TSB #3205
REAR DEFOGGER INOPERATIVE AFTER PERFORMING REMOTE VEHICLE START. *EH Read More »
AIR BAGS
-
TSB #SB-08-09-41-002C
GENERAL MOTORS: DIAGNOSTIC INFORMATION FOR INTERMITTENT RESTRAINTS, AIR BAG (SIR) INDICATOR/LAMP ON WITH DTC(S) B0012, B0013, B0016, B0016, B0019, B0020, B0022, B0023, B0026, B0033, B0040, B0042 OR B0044 SET. Read More »
SEAT BELTS
-
TSB #09-09-40-001A
GM: THERE ARE SEAT BELT PROBLEMS: DIFFICULTY LATCHING AND UNLATCHING BUCKLE. BUCKLE RELEASE BUTTON IS STICKING. SEAT BELT WARNING LIGHT ILLUMINATED. LIKELY CAUSED BY STICKY BEVERAGES THAT ARE SPILLED INTO THE BUCKLE ASSEMBLY. Read More »
SEAT BELTS:FRONT
-
TSB #3588
SEVERAL RIGHT FRONT SEAT BELT ASSEMBLIES HAVE BEEN RETURNED THROUGH THE 100% LAUNCH PART RETURN PROCESS WITH A CUSTOMER COMPLAINT OF SEAT BELT DIFFICULT TO LOWER PAST STITCHING ON SEAT BELT WEBBING. Read More »
SEAT BELTS:FRONT:WEBBING
-
TSB #05-09-40-002E
GM: SERVICE BULLETIN EXPLAINING WHEN THE SAFETY BELTS ARE SUPPOSED TO LOCK. *RM UPDATED 12/6/11. *PE Read More »
SEAT BELTS:FRONT:RETRACTOR
-
TSB #05-09-40-002E
GM: SERVICE BULLETIN EXPLAINING WHEN THE SAFETY BELTS ARE SUPPOSED TO LOCK. *RM UPDATED 12/6/11. *PE Read More »
SEAT BELTS:FRONT:BUCKLE ASSEMBLY
-
TSB #050940003
PASSENGER SEAT BELT BUCKLE HARD TO MOVE PAST STITCHING AND/OR FINISH KNOT IS FRAYING. *TT Read More »
SEAT BELTS:FRONT:WARNING LIGHT/DEVICES
-
TSB #09-09-40-001A
GM: THERE ARE SEAT BELT PROBLEMS: DIFFICULTY LATCHING AND UNLATCHING BUCKLE. BUCKLE RELEASE BUTTON IS STICKING. SEAT BELT WARNING LIGHT ILLUMINATED. LIKELY CAUSED BY STICKY BEVERAGES THAT ARE SPILLED INTO THE BUCKLE ASSEMBLY. Read More »
STRUCTURE
-
TSB #PI0373A
THIS PRELIMINARY INFORMATIONAL BULLETIN PROVIDES A PROCEDURE FOR RELEARNING THE POWER FOLDING MIRRIORS AND ROAD TESTIN TO VERIFY THEY CORRECT A CONDTION OF THE POWER FOLDING MIRRIORS GLASS SHAKES, FLUTTERS AT NORMAL DRIVING CONDITIONS. Read More »
STRUCTURE:BODY
-
TSB #PIC-5260-A
THIS PRELIMINARY INFORMATION COMMUNICATION ADVISES THE TECHNICIAN THE STEPS ON DIAGNOSING THE CONCERN. VEHICLE'S SUNROOF OPERATION INTERMITTENT, BIND, NOISE, AUTO-REVERSE, AND/OR WATER LEAKS. Read More »
-
TSB #0508110005
SUNSHADE MIRROR COVER BREAKS OFF AT THE HINGE PINS. *TT Read More »
-
TSB #02282005
FRONT FLOOR CARPET WET. THIS INCLUDES GM AND PONTIAC MODELS. *EH Read More »
-
TSB #040862002
REAR FASCIA BOWS OUT WHERE TAILLAMP AND REAR QUARTER PANEL MEET. *TT Read More »
STRUCTURE:BODY:DOOR
-
TSB #PIC-5169
PONTIAC/CHEVROLET/SATURN: THE REAR DOOR WILL NOT OPEN FROM EITHER THE INSIDE OR OUTSIDE HANDLE (DOOR UNLOCKED). Read More »
-
TSB #04088
DRIVER DOOR WATER INTRUSION. *SC Read More »
STRUCTURE:BODY:ROOF AND PILLARS
-
TSB #040867005
WIND NOISE FROM SUNROOF. *TT UPDATED *EH Read More »
LATCHES/LOCKS/LINKAGES
-
TSB #040864021
UNINTENDED DOOR LOCK AND TRUNK OPERATION DUE TO POSSIBLE MOISTURE INTRUSION. ADVANCED SERVICE INFORMATION BULLETIN. *TT ACTUAL SERVICE BULLETIN. *TT UPDATED *EH Read More »
LATCHES/LOCKS/LINKAGES:DOORS:LATCH
-
TSB #PIC-5169
PONTIAC/CHEVROLET/SATURN: THE REAR DOOR WILL NOT OPEN FROM EITHER THE INSIDE OR OUTSIDE HANDLE (DOOR UNLOCKED). Read More »
VEHICLE SPEED CONTROL:ACCELERATOR PEDAL
-
TSB #PIC-4658
ADJUSTABLE PEDALS WILL NOT ADJUST INOPERATIVE. *NJ UPDATED 3/13/09. *PE UPDATED 8/1/11. *PE Read More »
VEHICLE SPEED CONTROL:CRUISE CONTROL
-
TSB #SB-08-05-22-009A
CHEVROLET/PONTIAC/SATURN: INTERMITTENTLY BRAKE LIGHTS (STOP LAMPS) DO NOT FUNCTION CORRECTLY, EXTENDED TRAVEL TO SHIFT OUT OF PARK, CRUISE CONTROL INOPERATIVE, DTCS C0161/C0277 SET (PERFORM REPAIR AS OUTLINED). *PE UPDATED 5/11/11. Read More »
TIRES
-
TSB #03072005
VEHICLES WILL BE SHIPPED OUT FROM ASSEMBLY PLANT WITH INCREASED TIRE PRESSURE. *EH Read More »
-
TSB #11122004
HIGH PERFORMANCE 17 INCH CONTINENTAL TIRES SUSCEPTIBLE TO TEMPORARY FLAT SPOTTING. *TT Read More »
TIRES:PRESSURE MONITORING AND REGULATING SYSTEMS
-
TSB #SB-15-08-45-001
PONTIAC/SATURN/CHEVROLET: SOME VEHICLES ARE EXPERIENCING MULTIPLE ISSUES/SYMPTOMS CAUSED BY BODY HARNESS HARD CONTACT AGAINST FLOOR EDGE PANEL UNDER LEFT REAR SEAT CUSHION. MODEL 2004-12 MALIBU, MALIBU MAXX, 2007-09 AURA, 2005-10 G6. Read More »
SEATS:FRONT ASSEMBLY:RECLINER
-
TSB #050850014
ADDITION OF FRONT SEAT TRACK SYNCHRONIZATION PROCEDURE. *AK Read More »
SEATS:FRONT ASSEMBLY:SEAT HEATER/COOLER
-
TSB #SB-15-08-45-001
PONTIAC/SATURN/CHEVROLET: SOME VEHICLES ARE EXPERIENCING MULTIPLE ISSUES/SYMPTOMS CAUSED BY BODY HARNESS HARD CONTACT AGAINST FLOOR EDGE PANEL UNDER LEFT REAR SEAT CUSHION. MODEL 2004-12 MALIBU, MALIBU MAXX, 2007-09 AURA, 2005-10 G6. Read More »
EQUIPMENT
-
TSB #PIC5260A
THIS PRELIMINARY INFORMATION COMMUNICATION ADVISES THE TECHNICIAN THE STEPS ON DIAGNOSING THE CONCERN. VEHICLE'S SUNROOF OPERATION INTERMITTENT, BIND, NOISE, AUTO-REVERSE, AND/OR WATER LEAKS. Read More »
-
TSB #PIP5226A
THIS PRELIMINARY INFORMATION COMMUNICATION PROVIDES INFORMATION TO THE TECHNICIAN ABOUT FINDING NEEDLE BEARINGS DURING AN OIL CHANGE. TECHNICIAN WILL GAIN ACCESS TO THE ROLLER ROCKERS TO INSPECT THEM. Read More »
-
TSB #PI0373A
THIS PRELIMINARY INFORMATIONAL BULLETIN PROVIDES A PROCEDURE FOR RELEARNING THE POWER FOLDING MIRRIORS AND ROAD TESTIN TO VERIFY THEY CORRECT A CONDTION OF THE POWER FOLDING MIRRIORS GLASS SHAKES, FLUTTERS AT NORMAL DRIVING CONDITIONS. Read More »
-
TSB #050846006A
INFORMATION ON UPGRADING CERTAIN ONSTAR GENERATION 5 ANALOG/DIGITAL-READY SYSTEMS TO ONSTAR GENERATION 6 DUAL-MODE (ANALOG/DIGITAL). *TT Read More »
-
TSB #3157
PHANTOM REMOTE START INTERMITTENTLY. *TC Read More »
-
TSB #3133
REMOTE KEYLESS ENTRY INOPERATIVE. *TC Read More »
EQUIPMENT:ELECTRICAL
-
TSB #PIC5050A
THIS PRELIMINARY INFORMATION COMMUNICATION ADVISES THE TECHNICIAN THE STEPS ON REPAIRING THE CONCERN. A CUSTOMER MAY IDENTIFY A CONCERN OF UNABLE TO REACTIVATE A VEHICLE'S ONSTAR THAT HAS BEEN PREVIOUSLY DISABLED BY ONSTAR. Read More »
-
TSB #08-089
BUICK\CADILLAC\CHEVROLET\GMC\HUMMER\OLDSMOBILE\PONTIAC\SAAB\SATURN SERVICE CAMPAIGN: SEE DOCUMENT SEARCH BUTTON FOR OWNER LETTER. SPECIAL COVERAGE ADJUSTMENT-ANALOG ONSTAR DEACTIVATION. Read More »
-
TSB #3111
UNABLE TO PROGRAM KEYLESS ENTRY SYSTEM. ALSO INCLUDED 2005 MAXX. *SC Read More »
EQUIPMENT:ELECTRICAL:RADIO/TAPE DECK/CD ETC.
-
TSB #16NA260
THIS TECHNICAL BULLETIN PROVIDES A PROCEDURE TO REPROGRAM THE MEDIA DISC PLAYER WITH THE LATEST CALIBRATIONS TO CORRECT A CONDITION OF THE REAR ENTERTAINMENT SYSTEM NOT OPERATING AS INTENDED IN COLDER AMBIENT TEMPERATURE AREAS DUE TO ... Read More »
-
TSB #PIC5088F
THIS PRELIMINARY INFORMATION COMMUNICATION ADVISES THE TECHNICIAN ON THE STEPS TO DIAGNOSE AND REPAIR THE CONCERN. THE VEHICLE'S XM RADIO ONLY HAS XM PREVEIW CHANNELS. Read More »
-
TSB #SB-15-08-45-001
PONTIAC/SATURN/CHEVROLET: SOME VEHICLES ARE EXPERIENCING MULTIPLE ISSUES/SYMPTOMS CAUSED BY BODY HARNESS HARD CONTACT AGAINST FLOOR EDGE PANEL UNDER LEFT REAR SEAT CUSHION. MODEL 2004-12 MALIBU, MALIBU MAXX, 2007-09 AURA, 2005-10 G6. Read More »
EQUIPMENT:ELECTRICAL:NAVIGATIONAL SYSTEM(GLOBAL POSITIONING SYSTEM)
-
TSB #PIT5485B
THIS PRELIMINARY INFORMATION COMMUNICATION ADVISES THE TECHNICIAN IF UNABLE TO PLACE AN ONSTAR CALL IN THE IGNITION ON MODE AFTER THE ONSTAR CANADA UPGRADE, TO CONTACT THE GM TECHNICAL ASSISTANCE CENTER ONSTAR GROUP FOR FURTHER ASSISTANCE. Read More »
-
TSB #PIT5389A
THIS PRELIMINARY INFORMATION COMMUNICATION ADVISES THE TECHNICIAN ON THE STEPS FOR DIAGNOSING THE CONCERN. THE VEHICLE MAY BE UNABLE TO CONNECT TO ONSTAR USING THE WHITE, BLUE OR RED ONSTAR BUTTONS. Read More »
-
TSB #PIT5485A
THIS PRELIMINARY INFORMATION COMMUNICATION ADVISES THE TECHNICIAN, IF UNABLE TO PLACE AN ONSTAR CALL IN THE IGNITION ON MODE AFTER THE ONSTAR CANADA UPGRADE TO CONTACT THE GM TECHNICAL ASSISTANCE CENTER ONSTAR GROUP FOR FURTHER ASSISTANCE. Read More »
-
TSB #08089-B
GENERAL MOTORS CORP: SPECIAL COVERAGE ADJUSTMENT; ANALOG ONSTAR DEACTIVATION. *PE UPDATED 2/17/09. *PE Read More »
EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL
-
TSB #09072004
TECHNICAL ASSISTANCE ACTION CENTER ANNOUNCEMENT. *EH Read More »
EQUIPMENT:APPLIANCE:AIR CONDITIONER
-
TSB #050138013
REVISED AIR TEMPERATURE ACTUATOR REPLACEMENT AND MODE ACTUATOR REPLACEMENT PROCEDURES. *TT Read More »
-
TSB #03072005
CLICKING TICKING CRACKING TYPE NOISE FROM THE TOP AREA OF THE IP DASH PANEL. *EH Read More »
UNKNOWN OR OTHER
-
TSB #040089038
PDI AND SERVICE GUIDE. *TT Read More »
-
TSB #3161
OUTSIDE AIR TEMPERATURE DISPLAY INACCURATE AT TIMES. *TT Read More »