Technical Service Bulletins (TSBs) for the 2015 Transit are official communications between Ford & their dealerships that describe processes for troubleshooting or fixing certain common problems.
All vehicle manufacturers are required by U.S. law to make their TSBs available to the public.
SOME 2010-2016 EPAS EQUIPPED VEHICLES MAY EXHIBIT STEERING RELATED NOISES. THE WORKSHOP MANUAL (WSM) DIAGNOSTIC PROCEDURES HAVE BEEN UPDATED IN SECTION 211-02. WHEN DIAGNOSING AND REPAIRING EPAS STEERING NOISES USE THE UPDATED PROCEDURES. Read More »
2015 FORD TRANSIT: BULLETIN INFORMATION INVOLVING TRANSIT VEHICLES EXPERIENCING A REAR CLUNK, SQUEAK, RATTLE NOISE, WHILE TURNING OVER BUMPS. *LJ Read More »
SOME 2008-2017 FORD/MERCURY/LINCOLN VEHICLES EQUIPPED WITH SYNC MAY GENERATE A VHR THAT IDENTIFIES A CONCERN WITH THE BRAKES AND SUSPENSION CATEGORY INDICATING SERVICE IS REQUIRED DUE TO A BRAKE SYSTEM WARNING LAMP BEING ILLUMINATED. Read More »
SOME 2008-2017 FORD/MERCURY/LINCOLN VEHICLES EQUIPPED WITH SYNC MAY GENERATE A VHR THAT IDENTIFIES A CONCERN WITH THE BRAKES AND SUSPENSION CATEGORY INDICATING SERVICE IS REQUIRED DUE TO A BRAKE SYSTEM WARNING LAMP BEING ILLUMINATED. Read More »
SOME 2015-2017 TRANSIT VEHICLES BUILT ON OR BEFORE 17-OCT-2016, EQUIPPED WITH A 3.2L ENGINE, AND WITH LOW TIME IN SERVICE (LESS THAN 8,000 KM (5,000 MILES)) MAY EXHIBIT AN OIL LEAK FROM AREAS SUCH AS THE CRANKSHAFT FRONT SEAL, CRANKSHAFT ... Read More »
SOME 2015-2017 TRANSIT VEHICLES MAY HAVE UNIQUE ACCESSORY DRIVE NOISE CHARACTERISTICS. ENGINEERING REVIEW OF WARRANTY RETURNED BELT TENSIONERS HAS NOT IDENTIFIED AN OUT OF SPECIFICATION PART, NOR HAVE ABNORMAL SOUNDS BEEN RECREATED DURING ... Read More »
SOME 2015 TRANSIT VEHICLES BUILT ON OR BEFORE 30-MAR-2015 MAY EXHIBIT VARIOUS DRIVABILITY CONCERNS INCLUDING DIFFICULTY STARTING, MISFIRES AND/OR AN ILLUMINATED MALFUNCTION INDICATOR LAMP (MIL) WITH DIAGNOSTIC TROUBLE CODE (DTC) P00BD, ... Read More »
SOME 2015 TRANSIT VEHICLES EQUIPPED WITH A 3.5L OR 3.7L ENGINE MAY EXHIBIT AN ILLUMINATED MALFUNCTION INDICATOR LAMP (MIL) WITH DIAGNOSTIC TROUBLE CODE (DTC) P0627 (FUEL PUMP A CONTROL CIRCUIT/OPEN) STORED IN POWERTRAIN CONTROL MODULE ... Read More »
TO HELP DIFFERENTIATE ENGINE OIL LEAKS FROM OTHER POSSIBLE SOURCES, A NEW WHITE-COLORED FLUORESCENT ENGINE OIL DYE IS AVAILABLE. WORKSHOP MANUAL (WSM), SECTION 303-00 HAS BEEN REVISED TO REFERENCE THE NEW WHITE-COLORED DYE. Read More »
SOME 2015-2017 TRANSIT VEHICLES EQUIPPED WITH A 3.2L DIESEL ENGINE AND BUILT ON OR BEFORE 12-SEP-2016 MAY EXHIBIT AN ILLUMINATED MIL WITH DTC P040D - EXHAUST GAS RECIRCULATION TEMPERATURE EGRT SENSOR A CIRCUIT HIGH. Read More »
SOME 2015-2016 F-150, C-MAX, EDGE, MKS, TAURUS, AND FLEX AND 2016 EXPEDITION, EXPLORER, ESCAPE, FUSION, MUSTANG, MKZ, MKX, NAVIGATOR, TRANSIT AND TRANSIT CONNECT VEHICLES EQUIPPED WITH A 2.0L, 2.5L, 3.5L OR 3. Read More »
2015-2017 - F-SUPER DUTY, F-650/750 WITH 6.7L DIESEL AND 2015-2017 TRANSIT - 3.2L DIESEL EQUIPPED VEHICLES USE A SELECTIVE CATALYTIC REDUCTION (SCR) SYSTEM DESIGNED TO REDUCE THE VEHICLES EXHAUST EMISSIONS. Read More »
SOME 2015-2016 TRANSIT VEHICLES EQUIPPED WITH A 3.2L DIESEL ENGINE WITH LESS THAN 10,500 KM (6,500 MILES) AND BUILT ON 5/11/2015 AND THROUGH 2/8/2016 MAY EXHIBIT A CRANK NO START CONDITION AND/OR MALFUNCTION INDICATOR LAMP (MIL) ... Read More »
FORD 2015 TRANSIT: BULLETIN INFORMATION INVOLVING TRANSIT VEHICLES BUILT BEFORE 3/30/2015 MAY HAVE DRIVING AND/OR CHECK ENGINE ILLUMINATED LIGHT CONCERNS. *LJ Read More »
FORD 2015 TRANSIT: BULLETIN INFORMATION INVOLVING CERTAIN TRANSIT VEHICLES BUILT BEFORE 3/30/2015 MAY HAVE VARIOUS DRIVEABILITY AND CHECK ENGINE LAMP CONCERNS WITH TROUBLE CODES STORED IN THE POWER CONTROL MODULE. Read More »
FORD 2015 TRANSIT: INFORMATION INVOLVING 3.2L DURATORQ-TDCI: VEHICLES EQUIPPED WITH 3.2L DURATORQ ENGINES BUILT ON OR AFTER 3/6/2015 MAY SET LOW PRESSURE FUEL SYSTEM SENSOR CIRCUIT WHEN THE KEY ON ENGINE OFF SELF TEST PERFORMED. Read More »
FORD 2015 TRANSIT 3.2L: BULLETIN INFORMATION INVOLVING ENGINE LIGHT FOR REDUCTANT PUMP AND REDUCTANT LINE HEATER, AND INCONSISTENT WIRE INSULATION. *LJ Read More »
SOME 2015-2017 TRANSIT VEHICLES EQUIPPED WITH A 3.2L PUMA DIESEL ENGINE MAY EXHIBIT AN OVERHEAT CONDITION DUE TO COOLANT LOSS WITHOUT ANY EXTERNAL COOLANT LEAKS. Read More »
SOME 2015 TRANSIT VEHICLES EQUIPPED WITH A 3.5L OR 3.7L ENGINE MAY EXHIBIT AN ILLUMINATED MALFUNCTION INDICATOR LAMP (MIL) WITH DIAGNOSTIC TROUBLE CODE (DTC) P0627 (FUEL PUMP A CONTROL CIRCUIT/OPEN) STORED IN POWERTRAIN CONTROL MODULE ... Read More »
SOME 2015-2016 TRANSIT VEHICLES EQUIPPED WITH A 3.2L DIESEL ENGINE WITH LESS THAN 10,500 KM (6,500 MILES) AND BUILT ON 5/11/2015 AND THROUGH 2/8/2016 MAY EXHIBIT A CRANK NO START CONDITION AND/OR MALFUNCTION INDICATOR LAMP (MIL) ... Read More »
SOME 2015 TRANSIT VEHICLES BUILT ON OR BEFORE 30-MAR-2015 MAY EXHIBIT VARIOUS DRIVABILITY CONCERNS INCLUDING DIFFICULTY STARTING, MISFIRES AND/OR AN ILLUMINATED MALFUNCTION INDICATOR LAMP (MIL) WITH DIAGNOSTIC TROUBLE CODE (DTC) P00BD, ... Read More »
FORD: LOW LEVEL INSTRUMENT CLUSTERS FAILS TO DISPLAY TRANSPORT MODE STATUS, WHEN ITS TO PREVENT REMOTE KEYLESS ENTRY (RKE) AND INTERIOR LIGHT(S) FROM FUNCTIONING WHEN IGNITION KEY IS OFF BUT ENGINE RUNNING. MODEL 2015 TRANSIT. Read More »
FORD: NO SERVICE ACTION IS RECOMMENDED FOR THIS CONDITION. PLEASE USE AT YOUR DISCRETION. VARIOUS 2010-2015 VEHICLES MAY EXPERIENCE A TURBULENCE NOISE, SIMILAR TO AN HELICOPTER NOISE, AT HIGHWAY SPEEDS WHEN THE REAR DOOR WINDOW(S) OR ... Read More »
FORD: SOME VEHICLES FRONT SEAT BELTS ARE MAKING NOISE AND FAILS TO RETRACT OR EXTEND PROPERLY DUE TO A POSSIBLE MODIFICATION OF VEHICLE AND BULKHEAD PARTITION. MODEL 2015 TRANSIT. *PE Read More »
FORD: SOME VEHICLES FRONT SEAT BELTS ARE MAKING NOISE AND FAILS TO RETRACT OR EXTEND PROPERLY DUE TO A POSSIBLE MODIFICATION OF VEHICLE AND BULKHEAD PARTITION. MODEL 2015 TRANSIT. *PE Read More »
SOME 2015-2017 TRANSIT VEHICLES MAY EXHIBIT TRIM ISSUES THAT ARE NOT WARRANTABLE BY FORD. TRANSIT VEHICLES ARE EQUIPPED WITH INTERIOR AND EXTERIOR TRIM WHICH ARE NOT PAINTED AND HAVE A GRAINED APPEARANCE. Read More »
SOME 2015-2016 TRANSIT VEHICLES BUILT ON 8/1/2015 AND THROUGH 2/1/2016 MAY EXHIBIT A FRONT DOOR THAT DOES NOT OPEN WHEN USING THE OUTSIDE HANDLE AND REQUIRES A SECOND ATTEMPT. Read More »
BROKEN INTERIOR SLIDING DOOR HANDLE - BUILT ON OR BEFORE 1/4/2016 ISSUE Some 2015-2016 Transit vehicles built on or before 1/4/2016 may experience a broken interior sliding door handle due to the sliding door lower roller assembly. Read More »
SOME 2015-2016 TRANSIT VEHICLES BUILT ON 8/1/2015 AND THROUGH 2/1/2016 MAY EXHIBIT A FRONT DOOR THAT DOES NOT OPEN WHEN USING THE OUTSIDE HANDLE AND REQUIRES A SECOND ATTEMPT. Read More »
FORD 2015 POLICE INTERCEPTOR SEDAN VEHICLES: CUSTOMER SATISFACTION PROGRAM REGARDING ENABLE POLICE MODE TRUNK RELEASE. THE PROGRAM WILL BE IN EFFECT THROUGH MAY 31, 2016. *LJ Read More »
FORD 2015 TRANSIT HIGH ROOF BUS/WAGON : SERVICE INFORMATION REGARDING VEHICLES HEADLINER THEAT DOES NOT STAY SEATED AT THE C AND HALF PILLAR TRIM. *LJ Read More »
FORD: WHEN THEY SHOULD BE OFF, SOME VEHICLES, WITH HIGH LED INTERIOR INTENSITY, ARE EXPERIENCING LED CARGO LAMPS, WITH A LOW GLOW AND NEED NOT BE REPLACED. MODEL 2015 TRANSIT. *PE Read More »
REPLACING THE ORIGINAL EQUIPMENT SYNC/NAVIGATION SYSTEM WITH EITHER AN AFTERMARKET SYNC/NAVIGATION KIT OR MODIFYING ORIGINAL SYNC/NAVIGATION PARTS TO PROVIDE ADDITIONAL FEATURES IS NOT RECOMMENDED NOR SUPPORTED ON ANY FORD, MERCURY OR ... Read More »
2015-2017 TRANSIT VEHICLES ORDERED WITH A KEYLESS ENTRY KEYPAD WILL HAVE THE FORD ACCESSORY KEYPAD INSTALLED ON THE VEHICLE AND PROGRAMMED AT THE ASSEMBLY PLANT. Read More »
SOME 2015-2017 LOW ROOF TRANSIT VEHICLES BUILT ON OR BEFORE 30-SEP-2016 AND UPFITTED WITH A ROOF RACK MAY EXHIBIT INTERIOR ROOF BOW BRACKET TO SIDE PANEL SEPARATION. Read More »
SOME 2015-2017 TRANSIT HIGH ROOF WAGON VEHICLES BUILT ON OR AFTER 2-JUN-2015 MAY HAVE BEEN SHIPPED WITH A HEADLINER PANEL THAT WAS NOT PROPERLY SEATED, CAUSING A GAP AT THE C AND/OR C 1/2 PILLAR(S). Read More »
FORD: 2015 TRANSIT BUS/WAGON WITH A HIGH ROOF, WILL EXPERIENCE A GAP OR LOOSE HEADLINER BETWEEN 3-5 MM BETWEEN SIDE TRIM PANEL AT C AND/OR C 1/2 PILLARS AND HEADLINER *CN Read More »
2015 TRANSIT: VEHICLES EQUIPPED WITH DIESEL MAY SHOW THE MALFUNCTION INDICATOR LIGHT ILLUMINATED WITH DTC P204F PRESENT IN REDUCTANT DOSING CONTROL MODULE *CN Read More »
2015-2017 TRANSIT VEHICLES EQUIPPED WITH DUAL REAR WHEELS (DRWS) HAVE A HIGH MOUNT REAR MARKER LAMP THAT DOES NOT ILLUMINATE WITH THE STOP LAMPS. Read More »
FORD: LOW LEVEL INSTRUMENT CLUSTERS FAILS TO DISPLAY TRANSPORT MODE STATUS, WHEN ITS TO PREVENT REMOTE KEYLESS ENTRY (RKE) AND INTERIOR LIGHT(S) FROM FUNCTIONING WHEN IGNITION KEY IS OFF BUT ENGINE RUNNING. MODEL 2015 TRANSIT. Read More »
