Technical Service Bulletins (TSBs) for the 2015 Transit are official communications between Ford & their dealerships that describe processes for troubleshooting or fixing certain common problems.
All vehicle manufacturers are required by U.S. law to make their TSBs available to the public.
Some 2015-2019 Transit vehicles may exhibit uneven steering effort. This may be due to the steering column slider length. To correct the condition, follow the Service Procedure to adjust the steering column slider length. Read More »
Some 2015-2019 Transit vehicles may exhibit a power steering fluid leak at the steering pump or gear. This may be due to a cut or damaged O-ring on the power steering line connection. Read More »
SOME 2010-2016 EPAS EQUIPPED VEHICLES MAY EXHIBIT STEERING RELATED NOISES. THE WORKSHOP MANUAL (WSM) DIAGNOSTIC PROCEDURES HAVE BEEN UPDATED IN SECTION 211-02. WHEN DIAGNOSING AND REPAIRING EPAS STEERING NOISES USE THE UPDATED PROCEDURES. Read More »
Some 2015-2019 Transit vehicles may exhibit a front wheel bearing type noise or DTCs C0031 and/or C0034 in the anti-lock brake system (ABS) module. Read More »
2015 FORD TRANSIT: BULLETIN INFORMATION INVOLVING TRANSIT VEHICLES EXPERIENCING A REAR CLUNK, SQUEAK, RATTLE NOISE, WHILE TURNING OVER BUMPS. *LJ Read More »
SOME 2008-2017 FORD/MERCURY/LINCOLN VEHICLES EQUIPPED WITH SYNC MAY GENERATE A VHR THAT IDENTIFIES A CONCERN WITH THE BRAKES AND SUSPENSION CATEGORY INDICATING SERVICE IS REQUIRED DUE TO A BRAKE SYSTEM WARNING LAMP BEING ILLUMINATED. Read More »
SOME 2008-2017 FORD/MERCURY/LINCOLN VEHICLES EQUIPPED WITH SYNC MAY GENERATE A VHR THAT IDENTIFIES A CONCERN WITH THE BRAKES AND SUSPENSION CATEGORY INDICATING SERVICE IS REQUIRED DUE TO A BRAKE SYSTEM WARNING LAMP BEING ILLUMINATED. Read More »
SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP:WHEEL SPEED SENSOR
Some 2015-2019 Transit vehicles may exhibit a front wheel bearing type noise or DTCs C0031 and/or C0034 in the anti-lock brake system (ABS) module. Read More »
SSM 47948 - 2010-2019 Various Vehicles - Turbocharged Engines - Oil Supply Filter Replacement When Replacing The Turbocharger Or The Turbocharger Oil Supply Tube For 2010-2019 vehicles equipped with turbocharged engines, when diagnosing ... Read More »
Some 2015-2018 Transit vehicles built on or before 24-Jul-2018 may exhibit various drivability concerns including difficulty starting, misfires and/or an illuminated MIL with diagnostic trouble codes (DTCs) P00BD, P1247, P1548, P061B, ... Read More »
Some 2015-2019 Transit vehicles equipped with a 3.2L diesel engine may exhibit Drive To Clean maintenance messages and/or an illuminated malfunction indicator lamp (MIL) with diagnostic trouble codes (DTCs) P2459, P2463, and/or P246C. Read More »
Some 2015 Transit vehicles equipped with a 3.2L engine may exhibit an illuminated MIL with DTCs P24A0 and/or P26A0 stored in the powertrain control module (PCM). Follow the Service Procedure steps to correct the condition. Read More »
Some 2015-2018 Transit vehicles built on or before 24-Jul-2018 may exhibit various drivability concerns including difficulty starting, misfires and/or an illuminated MIL with diagnostic trouble codes (DTCs) P00BD, P1247, P1548, P061B, ... Read More »
Some 2013-2018 F-150, 2015-2018 Transit/Expedition, and 2015-2017 Navigator vehicles equipped with a 3.5L EcoBoost engine with greater than 20,000 miles may exhibit a tick type noise from the cylinder block area. Read More »
Some 2015-2017 Transit vehicles equipped with a 3.5L or 3.7l gasoline engine may exhibit an engine overheat condition or poor A/C cooling due to one or more of the 3 cooling fan fuses being open. Read More »
When replacing a 2015-2018 Transit 3.2L Duratorq-TDCi engine assembly or block, two new transmission locator dowel pins (W703519 or W718670) must be installed. This information is available in Workshop Manual, Section 303-01C. Read More »
Some 2015-2018 Transit vehicles may have unique accessory drive noise characteristics. Engineering review of warranty returned belt tensioners has not identified an out of specification part, nor have abnormal sounds been recreated during ... Read More »
Some 2013-2017 F-Super Duty/2015-2017 Transit/2016-2017 F650-750 vehicles equipped with a diesel engine may exhibit DTC P207F and/or P20EE (Reductant Quality Performance) in the powertrain control module (PCM). Read More »
Some 2013-2016 F-Super Duty/2015-2017 Transit/2016-2017 F650-750 vehicles equipped with a diesel engine may exhibit DTC P207F and/or P20EE (Reductant Quality Performance) in the powertrain control module (PCM). Read More »
SOME 2015-2017 TRANSIT VEHICLES BUILT ON OR BEFORE 17-OCT-2016, EQUIPPED WITH A 3.2L ENGINE, AND WITH LOW TIME IN SERVICE (LESS THAN 8,000 KM (5,000 MILES)) MAY EXHIBIT AN OIL LEAK FROM AREAS SUCH AS THE CRANKSHAFT FRONT SEAL, CRANKSHAFT ... Read More »
SOME 2015-2017 TRANSIT VEHICLES MAY HAVE UNIQUE ACCESSORY DRIVE NOISE CHARACTERISTICS. ENGINEERING REVIEW OF WARRANTY RETURNED BELT TENSIONERS HAS NOT IDENTIFIED AN OUT OF SPECIFICATION PART, NOR HAVE ABNORMAL SOUNDS BEEN RECREATED DURING ... Read More »
SOME 2015 TRANSIT VEHICLES BUILT ON OR BEFORE 30-MAR-2015 MAY EXHIBIT VARIOUS DRIVABILITY CONCERNS INCLUDING DIFFICULTY STARTING, MISFIRES AND/OR AN ILLUMINATED MALFUNCTION INDICATOR LAMP (MIL) WITH DIAGNOSTIC TROUBLE CODE (DTC) P00BD, ... Read More »
SOME 2015 TRANSIT VEHICLES EQUIPPED WITH A 3.5L OR 3.7L ENGINE MAY EXHIBIT AN ILLUMINATED MALFUNCTION INDICATOR LAMP (MIL) WITH DIAGNOSTIC TROUBLE CODE (DTC) P0627 (FUEL PUMP A CONTROL CIRCUIT/OPEN) STORED IN POWERTRAIN CONTROL MODULE ... Read More »
TO HELP DIFFERENTIATE ENGINE OIL LEAKS FROM OTHER POSSIBLE SOURCES, A NEW WHITE-COLORED FLUORESCENT ENGINE OIL DYE IS AVAILABLE. WORKSHOP MANUAL (WSM), SECTION 303-00 HAS BEEN REVISED TO REFERENCE THE NEW WHITE-COLORED DYE. Read More »
SOME 2015-2017 TRANSIT VEHICLES EQUIPPED WITH A 3.2L DIESEL ENGINE AND BUILT ON OR BEFORE 12-SEP-2016 MAY EXHIBIT AN ILLUMINATED MIL WITH DTC P040D - EXHAUST GAS RECIRCULATION TEMPERATURE EGRT SENSOR A CIRCUIT HIGH. Read More »
SOME 2015-2016 F-150, C-MAX, EDGE, MKS, TAURUS, AND FLEX AND 2016 EXPEDITION, EXPLORER, ESCAPE, FUSION, MUSTANG, MKZ, MKX, NAVIGATOR, TRANSIT AND TRANSIT CONNECT VEHICLES EQUIPPED WITH A 2.0L, 2.5L, 3.5L OR 3. Read More »
The Powertrain Control/Emissions Diagnosis (PC/ED) manual has been revised for diagnosing electronic throttle bodies (ETBs). The ETC_ACT and ETC_DSD PIDs should not used to diagnose possible ETB concerns. Read More »
2015-2017 - F-SUPER DUTY, F-650/750 WITH 6.7L DIESEL AND 2015-2017 TRANSIT - 3.2L DIESEL EQUIPPED VEHICLES USE A SELECTIVE CATALYTIC REDUCTION (SCR) SYSTEM DESIGNED TO REDUCE THE VEHICLES EXHAUST EMISSIONS. Read More »
SOME 2015-2016 TRANSIT VEHICLES EQUIPPED WITH A 3.2L DIESEL ENGINE WITH LESS THAN 10,500 KM (6,500 MILES) AND BUILT ON 5/11/2015 AND THROUGH 2/8/2016 MAY EXHIBIT A CRANK NO START CONDITION AND/OR MALFUNCTION INDICATOR LAMP (MIL) ... Read More »
49 CFR Part 579.5 Monthly Communications - March 2016 Air bag warning light illuminated with diagnostic trouble code (DTC) B141B and/or B141C Read More »
FORD 2015 TRANSIT: BULLETIN INFORMATION INVOLVING TRANSIT VEHICLES BUILT BEFORE 3/30/2015 MAY HAVE DRIVING AND/OR CHECK ENGINE ILLUMINATED LIGHT CONCERNS. *LJ Read More »
FORD 2015 TRANSIT: BULLETIN INFORMATION INVOLVING CERTAIN TRANSIT VEHICLES BUILT BEFORE 3/30/2015 MAY HAVE VARIOUS DRIVEABILITY AND CHECK ENGINE LAMP CONCERNS WITH TROUBLE CODES STORED IN THE POWER CONTROL MODULE. Read More »
FORD 2015 TRANSIT: INFORMATION INVOLVING 3.2L DURATORQ-TDCI: VEHICLES EQUIPPED WITH 3.2L DURATORQ ENGINES BUILT ON OR AFTER 3/6/2015 MAY SET LOW PRESSURE FUEL SYSTEM SENSOR CIRCUIT WHEN THE KEY ON ENGINE OFF SELF TEST PERFORMED. Read More »
For 2015-2024 Ford and Lincoln vehicles equipped with turbocharged engines and customer concern of an engine oil leak, refer to Workshop Manual (WSM), Section 303-00 for oil leak inspection and testing methods. Read More »
Certain 2015-2019 Model Year Transit Vehicles with 3.2L Diesel Engine - Crankcase Ventilation Hose Assembly Replacement and Powertrain Control Module Software Update Read More »
Some 2015 Transit vehicles equipped with a 3.2L Duratorq-TDCi engine built on or after 06-Mar-2015 may set diagnostic trouble code (DTC) P2539 during a KOEO self-test. Read More »
Some 2017-2022 F-Super Duty and 2016-2022 F-650/F-750 with 6.7L diesel engines, 2015-2019 Transit with 3.2L diesel engines and 2018-2021 F-150 with 3. Read More »
Some 2015-2019 Transit vehicles equipped with a 3.7L engine and block heater may exhibit a repeat coolant leak from a deteriorated O-ring and/or intake manifold thermostat housing. Read More »
Certain 2015-2019 Model Year Transit Vehicles with a 3.2L Diesel Engine EGR Cooler Replacement n some of the affected vehicles, the EGR cooler may crack and allow coolant to enter the combustion chamber when EGR is enabled. Read More »
Some 2017-2020 Super Duty vehicles equipped with a 6.7L engine built on or after 13-May-2017, 2015-2019 Transit vehicles equipped with a 3.2L engine and 2018-2020 F-150 vehicles equipped with a 3. Read More »
This program extends the coverage of the front nitrogen oxides (NOx) sensor for twelve months of service, beginning on the date the powertrain control module (PCM) is reprogrammed under emissions recall 21E01. Read More »
This program extends the warranty coverage of the rear nitrogen oxides (NOx) sensor for twelve months of service, beginning on the date the powertrain control module (PCM) is reprogrammed under Emissions Recall 21 E01. Read More »
This program extends the warranty coverage of the catalytic converter portion of the selective catalyst reduction (SCR) system for twelve months of service, beginning on the date the powertrain control module (PCM) is reprogrammed under ... Read More »
Some 2015-2021 Ford and Lincoln vehicles may exhibit an illuminated MIL with diagnostic trouble codes (DTC) P0011, P0012, P0014, P0015, P0016, P0017, P0018, P0019, P0021, P0022, P0024 and/or P0025. Read More »
Some 2011-2021 vehicles equipped with a diesel engine may have engine oil in the exhaust after turbocharger replacement for various reasons. Read More »
Some 2009-2020 Ford and Lincoln vehicles equipped with turbochargers may exhibit an oil leak from the turbocharger oil supply or return tubes, O-rings or 6.7L pedestal gasket. Read More »
Some 2015-2019 Transit vehicles equipped with a 3.2L engine, 2018-2020 F-150 vehicles equipped with a 3.0L engine, 2017-2020 Super Duty vehicles equipped with a 6. Read More »
Some 2015-2019 Transit vehicles equipped with a 3.2L engine, 2018-2019 F150 vehicles equipped with a 3.0L engine, 2017-2019 Super Duty vehicles equipped with a 6. Read More »
Some 2015-2019 Transit vehicles equipped with a 3.5L or 3.7L engine may exhibit a lack of heat or uneven heat from side to side. This condition may be due to deposits from the engine coolant becoming trapped in the heater core. Read More »
This program extends the warranty coverage of the reductant heater and sender assembly to 11 years of service or 120,000 miles from the warranty start date of the vehicle, whichever occurs first. Read More »
SSM 48543 - 2015-2019 Transit - 3.2L Diesel - Overheat Due To Coolant Loss Without An External Coolant Leak Some 2015-2019 Transit vehicles equipped with a 3. Read More »
Some 2015-2019 Transit vehicles equipped with a 3.5L or 3.7L engine may exhibit a lack of heat or uneven heat from side to side. This condition may be due to deposits from the engine coolant becoming trapped in the heater core. Read More »
Some 2015-2018 Transit vehicles equipped with a 3.5L or 3.7L engine may exhibit a lack of heat or uneven heat from side to side. This condition may be due to deposits from the engine coolant trapped in the heater core. Read More »
Some 2015-2019 Transit vehicles may have unique accessory drive noise characteristics. Engineering review of warranty returned belt tensioners has not identified an out of specification part, nor have abnormal sounds been recreated during ... Read More »
Some 2013-2018 F-150, 2015-2018 Transit/Expedition, and 2015-2017 Navigator vehicles equipped with a 3.5L EcoBoost engine with greater than 20,000 miles may exhibit a tick type noise from the cylinder block area. Read More »
Some 2015-2018 Transit vehicles equipped with a 3.5L or 3.7L engine may exhibit a lack of heat or uneven heat from side to side. This condition may be due to deposits from the engine coolant trapped in the heater core. Read More »
The Powertrain Control/Emissions Diagnosis (PC/ED) manual has been revised for diagnosing electronic throttle bodies (ETBs). The ETC_ACT and ETC_DSD PIDs should not used to diagnose possible ETB concerns. Read More »
The Powertrain Control/Emissions Diagnosis (PC/ED) manual has been revised for diagnosing electronic throttle bodies (ETBs). The ETC_ACT and ETC_DSD PIDs should not used to diagnose possible ETB concerns. Read More »
The Powertrain Control/Emissions Diagnosis (PC/ED) manual has been revised for diagnosing electronic throttle bodies (ETBs). The ETC_ACT and ETC_DSD PIDs should not used to diagnose possible ETB concerns. Read More »
ENGINE AND ENGINE COOLING:ENGINE:GASOLINE:BELTS AND ASSOCIATED PULLEYS
The Powertrain Control/Emissions Diagnosis (PC/ED) manual has been revised for diagnosing electronic throttle bodies (ETBs). The ETC_ACT and ETC_DSD PIDs should not used to diagnose possible ETB concerns. Read More »
ENGINE AND ENGINE COOLING:ENGINE:GASOLINE:TURBO/SUPERCHARGER
For 2010-2019 vehicles equipped with turbocharged engines, when diagnosing and/or replacing turbo related concerns, all steps within the Workshop Manual (WSM) procedure must be followed including replacement of all mandatory discarded ... Read More »
The Powertrain Control/Emissions Diagnosis (PC/ED) manual has been revised for diagnosing electronic throttle bodies (ETBs). The ETC_ACT and ETC_DSD PIDs should not used to diagnose possible ETB concerns. Read More »
Some 2017-2019 F-Super Duty and 2016-2019 F650-750 with 6.7L diesel engines, 2015-2019 Transit with 3.2L diesel engines and 2018-2019 F-150 with 3. Read More »
The Powertrain Control/Emissions Diagnosis (PC/ED) manual has been revised for diagnosing electronic throttle bodies (ETBs). The ETC_ACT and ETC_DSD PIDs should not used to diagnose possible ETB concerns. Read More »
ENGINE AND ENGINE COOLING:ENGINE:OTHER FUEL TYPES:TURBO/SUPERCHARGER
Some 2011-2021 vehicles equipped with a diesel engine may have engine oil in the exhaust after turbocharger replacement for various reasons. Read More »
The Powertrain Control/Emissions Diagnosis (PC/ED) manual has been revised for diagnosing electronic throttle bodies (ETBs). The ETC_ACT and ETC_DSD PIDs should not used to diagnose possible ETB concerns. Read More »
The Powertrain Control/Emissions Diagnosis (PC/ED) manual has been revised for diagnosing electronic throttle bodies (ETBs). The ETC_ACT and ETC_DSD PIDs should not used to diagnose possible ETB concerns. Read More »
ENGINE AND ENGINE COOLING:COOLING SYSTEM:RADIATOR ASSEMBLY
Some 2015-2019 Transit vehicles built on or before 31-Dec-2018 and some 2017-2018 E-450 vehicles equipped with a 6.8L engine built on or before 16-Jul-2018 using the Motorcraft Orange coolant may exhibit an engine overheat concern. Read More »
The Powertrain Control/Emissions Diagnosis (PC/ED) manual has been revised for diagnosing electronic throttle bodies (ETBs). The ETC_ACT and ETC_DSD PIDs should not used to diagnose possible ETB concerns. Read More »
The Powertrain Control/Emissions Diagnosis (PC/ED) manual has been revised for diagnosing electronic throttle bodies (ETBs). The ETC_ACT and ETC_DSD PIDs should not used to diagnose possible ETB concerns. Read More »
ENGINE AND ENGINE COOLING:COOLING SYSTEM:HOSES/LINES/PIPING/FITTINGS
The Powertrain Control/Emissions Diagnosis (PC/ED) manual has been revised for diagnosing electronic throttle bodies (ETBs). The ETC_ACT and ETC_DSD PIDs should not used to diagnose possible ETB concerns. Read More »
FORD 2015 TRANSIT 3.2L: BULLETIN INFORMATION INVOLVING ENGINE LIGHT FOR REDUCTANT PUMP AND REDUCTANT LINE HEATER, AND INCONSISTENT WIRE INSULATION. *LJ Read More »
Some 2011-2021 vehicles equipped with a diesel engine may have engine oil in the exhaust after turbocharger replacement for various reasons. Read More »
Some 2017-2018 F-Super Duty/2016-2018 F650-750 with 6.7L diesel engines and 2015-2018 Transit with 3.2L diesel engines may exhibit a MIL on with diagnostic trouble code (DTC) P206C in the powertrain control module (PCM). Read More »
Some 2017 F-Super Duty, 2016-2017 F650-750 equipped with 6.7L diesel engines and 2015-2017 Transit equipped with 3.2L diesel engines may exhibit a MIL on with diagnostic trouble code (DTC) P206C stored in powertrain control module(PCM). Read More »
The Powertrain Control/Emissions Diagnosis (PC/ED) manual has been revised for diagnosing electronic throttle bodies (ETBs). The ETC_ACT and ETC_DSD PIDs should not used to diagnose possible ETB concerns. Read More »
Some 2017-2019 F-Super Duty and 2016-2019 F650-750 with 6.7L diesel engines, 2015-2019 Transit with 3.2L diesel engines and 2018-2019 F-150 with 3. Read More »
The Powertrain Control/Emissions Diagnosis (PC/ED) manual has been revised for diagnosing electronic throttle bodies (ETBs). The ETC_ACT and ETC_DSD PIDs should not used to diagnose possible ETB concerns. Read More »
ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL:CRANKCASE (PCV)
The Powertrain Control/Emissions Diagnosis (PC/ED) manual has been revised for diagnosing electronic throttle bodies (ETBs). The ETC_ACT and ETC_DSD PIDs should not used to diagnose possible ETB concerns. Read More »
ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL:GAS RECIRCULATION VALVE (EGR VALVE)
Some 2015-2018 Transit vehicles equipped with a 3.2L diesel engine may exhibit "Drive To Clean" maintenance messages and/or an illuminated malfunction indicator lamp (MIL) on with DTC P2459, P2463, and/or P246C. Read More »
Some 2015-2018 Transit vehicles equipped with a 3.2L diesel engine may exhibit "Drive To Clean" maintenance messages and/or an illuminated malfunction indicator lamp (MIL) on with DTC P2459, P2463, and/or P246C. Read More »
SOME 2015-2017 TRANSIT VEHICLES EQUIPPED WITH A 3.2L PUMA DIESEL ENGINE MAY EXHIBIT AN OVERHEAT CONDITION DUE TO COOLANT LOSS WITHOUT ANY EXTERNAL COOLANT LEAKS. Read More »
The Powertrain Control/Emissions Diagnosis (PC/ED) manual has been revised for diagnosing electronic throttle bodies (ETBs). The ETC_ACT and ETC_DSD PIDs should not used to diagnose possible ETB concerns. Read More »
ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL:CATALYTIC CONVERTOR
The Powertrain Control/Emissions Diagnosis (PC/ED) manual has been revised for diagnosing electronic throttle bodies (ETBs). The ETC_ACT and ETC_DSD PIDs should not used to diagnose possible ETB concerns. Read More »
ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:MANIFOLD/HEADER/MUFFLER/TAIL PIPE
The Powertrain Control/Emissions Diagnosis (PC/ED) manual has been revised for diagnosing electronic throttle bodies (ETBs). The ETC_ACT and ETC_DSD PIDs should not used to diagnose possible ETB concerns. Read More »
Some 2015 Transit vehicles equipped with a 3.2L engine may exhibit an illuminated MIL with DTCs P24A0 and/or P26A0 stored in the powertrain control module (PCM). Follow the Service Procedure steps to correct the condition. Read More »
SOME 2015 TRANSIT VEHICLES EQUIPPED WITH A 3.5L OR 3.7L ENGINE MAY EXHIBIT AN ILLUMINATED MALFUNCTION INDICATOR LAMP (MIL) WITH DIAGNOSTIC TROUBLE CODE (DTC) P0627 (FUEL PUMP A CONTROL CIRCUIT/OPEN) STORED IN POWERTRAIN CONTROL MODULE ... Read More »
Replacement engines may have a fuel injection pump sprocket that does not include a keyway slot. It is acceptable to utilize the original fuel injection pump if it has a keyway slot. Timing the injection pump is not necessary. Read More »
49 CFR Part 579.5 Monthly Communications - March 2016 Air bag warning light illuminated with diagnostic trouble code (DTC) B141B and/or B141C Read More »
Certain 2015-2019 Model Year Transit Vehicles with 3.2L Diesel Engine - Crankcase Ventilation Hose Assembly Replacement and Powertrain Control Module Software Update Read More »
SSM 48601 - 2015-2019 Transit - 3.2L Diesel - Loss Of Power During Driving Under Extreme Cold Weather Conditions Some 2015-2019 Transit vehicles equipped with a 3. Read More »
Some 2017-2019 F-Super Duty and 2016-2019 F650-750 with 6.7L diesel engines, 2015-2019 Transit with 3.2L diesel engines and 2018-2019 F-150 with 3. Read More »
Some 2015-2018 Transit vehicles equipped with a 3.2L diesel engine may exhibit "Drive To Clean" maintenance messages and/or an illuminated malfunction indicator lamp (MIL) on with DTC P2459, P2463, and/or P246C. Read More »
Some 2015-2018 Transit vehicles equipped with a 3.2L diesel engine may exhibit "Drive To Clean" maintenance messages and/or an illuminated malfunction indicator lamp (MIL) on with DTC P2459, P2463, and/or P246C. Read More »
Some 2011-2018 Super Duty and 2015-2018 Transit vehicles equipped with diesel engines may exhibit diagnostic trouble code (DTC) U0100 stored in various modules after running a continuous memory diagnostic trouble code (CMDTC) test or ... Read More »
Some 2017 F-Super Duty/2016-2017 F650-750 equipped with 6.7L diesel engines and 2015-2017 Transit equipped with 3.2L diesel engines may exhibit a MIL on with diagnostic trouble code (DTC) P206C stored in powertrain control module(PCM). Read More »
Replacement engines may have a fuel injection pump sprocket that does not include a keyway slot. It is acceptable to utilize the original fuel injection pump if it has a keyway slot. Timing the injection pump is not necessary. Read More »
This article supersedes TSB 22-2444 to add 2024 model year vehicles. Some 2015-2024 Transit vehicles equipped with rear wheel drive (RWD), single rear wheel (only), and U-joints at the transmission flange and rear driveshaft may ... Read More »
During service and repair requiring removal and replacement of a crankshaft bolt and/or crankshaft damper, achieving proper torque of the crankshaft pulley bolt is critical. Read More »
Certain 2015-2019 Model Year Transit Vehicles with 3.2L Diesel Engine - Crankcase Ventilation Hose Assembly Replacement and Powertrain Control Module Software Update Read More »
This article supersedes TSB 22-2271 to update the vehicle model years affected. Some 2015-2023 Transit vehicles equipped with rear wheel drive (RWD), single rear wheel (only), and U-joints at the transmission flange and rear driveshaft ... Read More »
This article supersedes TSB 22-2175 to update the Issue, Action, and Service Procedure. Some 2015-2022 Transit vehicles equipped with rear wheel drive (RWD), single rear wheel (only), and U-joints at the transmission flange and rear ... Read More »
Some 20152022 Transit vehicles equipped with rear wheel drive (RWD), single rear wheel only, and a U-joint at the transmission flange and rear driveshaft may experience a boom/hum/moan noise or vibration from the rear while driving. Read More »
Some 2015-2021 Transit vehicles equipped with rear wheel drive (RWD), single rear wheel only, and a U-joint at the transmission flange and rear driveshaft may experience a boom/hum/moan noise or vibration from the rear while driving. Read More »
Some 2015-2021 Transit vehicles equipped with rear wheel drive (RWD), single rear wheel (SRW), and a U-joint at the transmission flange and rear driveshaft may experience a boom/hum/moan noise or vibration from the rear while driving. Read More »
Some 2017-2021 F-Super Duty and 2016-2021 F650-750 with 6.7L diesel engines, 2015-2019 Transit with 3.2L diesel engines and 2018-2021 F-150 with 3. Read More »
Some 2015-2020 Transit vehicles equipped with rear wheel drive (RWD), single rear wheel (SRW) and a U-joint at the transmission flange and rear driveshaft may experience a boom/hum/moan noise or vibration from the rear while driving. Read More »
Some 2015-2020 Ford and Lincoln vehicles may exhibit an illuminated MIL with diagnostic trouble codes (DTCs) P0011, P0012, P0014, P0015, P0016, P0017, P0018, P0019, P0021, P0022, P0024 and/or P0025. Read More »
If a 2015-2017 Transit vehicle originally equipped with a rubber flexible coupling requires replacement of the driveshaft assembly and/or transmission output flange, refer to the parts catalog supersession information for a complete list ... Read More »
On vehicles equipped with an automatic transmission it is imperative that the converter pilot hub be greased with Motorcraft Multi-Purpose Grease Spray XL-5-A even if grease was not applied from the factory. Read More »
Some 2015-2018 Transit vehicles built on or before 24-Jul-2018 may exhibit various drivability concerns including difficulty starting, misfires and/or an illuminated MIL with diagnostic trouble codes (DTCs) P00BD, P1247, P1548, P061B, ... Read More »
Some 2015-2019 Transit vehicles equipped with a 3.2L diesel engine may exhibit Drive To Clean maintenance messages and/or an illuminated malfunction indicator lamp (MIL) with diagnostic trouble codes (DTCs) P2459, P2463, and/or P246C. Read More »
Some 2017 F-Super Duty, 2016-2017 F650-750 equipped with 6.7L diesel engines and 2015-2017 Transit equipped with 3.2L diesel engines may exhibit a MIL on with diagnostic trouble code (DTC) P206C stored in powertrain control module(PCM). Read More »
When replacing a 2015-2018 Transit 3.2L Duratorq-TDCi engine assembly or block, two new transmission locator dowel pins (W703519 or W718670) must be installed. This information is available in Workshop Manual, Section 303-01C. Read More »
49 CFR Part 579.5 Monthly Communications - March 2016 Air bag warning light illuminated with diagnostic trouble code (DTC) B141B and/or B141C Read More »
Some 2015-2021 Ford and Lincoln vehicles may exhibit an illuminated MIL with diagnostic trouble codes (DTC) P0011, P0012, P0014, P0015, P0016, P0017, P0018, P0019, P0021, P0022, P0024 and/or P0025. Read More »
POWER TRAIN:AUTOMATIC TRANSMISSION:CONTROL MODULE (TCM/PCM/TECM)
Some 2015 Transit vehicles equipped with a 3.2L engine may exhibit an illuminated MIL with DTCs P24A0 and/or P26A0 stored in the powertrain control module (PCM). Follow the Service Procedure steps to correct the condition. Read More »
Some 2015-2018 Transit vehicles built on or before 24-Jul-2018 may exhibit various drivability concerns including difficulty starting, misfires and/or an illuminated MIL with diagnostic trouble codes (DTCs) P00BD, P1247, P1548, P061B, ... Read More »
Some vehicles may exhibit a no start condition with an illuminated malfunction indicator lamp (MIL) and a DTC P161A after PCM replacement. This may be due to the parameter reset procedure not being properly completed. Read More »
Some 2017 F-Super Duty/2016-2017 F650-750 equipped with 6.7L diesel engines and 2015-2017 Transit equipped with 3.2L diesel engines may exhibit a MIL on with diagnostic trouble code (DTC) P206C stored in powertrain control module(PCM). Read More »
Some 2013-2017 F-Super Duty, 2015-2017 Transit and 2016-2017 F650-F750 vehicles equipped with a diesel engine may exhibit diagnostic trouble code (DTC) P2201 (NOX Sensor Circuit Range/Performance Bank 1 Sensor 1) in the powertrain control ... Read More »
This article supersedes TSB 22-2271 to update the vehicle model years affected. Some 2015-2023 Transit vehicles equipped with rear wheel drive (RWD), single rear wheel (only), and U-joints at the transmission flange and rear driveshaft ... Read More »
If a 2015-2017 Transit vehicle originally equipped with a rubber flexible coupling requires replacement of the driveshaft assembly and/or transmission output flange, refer to the parts catalog supersession information for a complete list ... Read More »
Technical Service Bulletin informing customers of XL Hybrid 130" wheel base Ford Transit vehicles that the front drive shaft of vehicles should be lubricated immediately with grease and then every 6,000 miles subsequently. Read More »
2015-2023 Transit vehicles equipped with DRW have a high mount rear marker lamp that does not illuminate with the stop lamps. This lamp assembly may appear to be a stop lamp but is intended to illuminate with the parking lamps only. Read More »
Some 2013-2023 Ford or Lincoln vehicles with modems activated through FordPass or LincolnWay may experience 12 volt battery drain symptoms when the customer uses non-Ford/Lincoln phone applications as an alternate channel to access ... Read More »
Some 2015-2021 Ford and Lincoln vehicles may exhibit an illuminated MIL with diagnostic trouble codes (DTC) P0011, P0012, P0014, P0015, P0016, P0017, P0018, P0019, P0021, P0022, P0024 and/or P0025. Read More »
Certain 2013-2016 Model Year F-Series Super Duty 6.7L Diesel and 2015-2019 Model Year Transit 3.2L Diesel Vehicles Selective Catalyst Reduction System Warranty Extension In all of the affected vehicles, the onboard diagnostic (OBD) ... Read More »
SSM 48619 - Various Vehicles - Perimeter Alarm Armed And Original Vehicle Keys Cannot Be Accessed to Enter Vehicle - CAN Protection Strategy Some 2013-2016 Model Year Vehicles may exhibit a concern in which the Perimeter Alarm is ... Read More »
SSM 48531 - 2015 Transit - Interior High Intensity LED Cargo Lamps May Emit A Low Glow When Off - Built On Or Before 22-Apr-2015 Some 2015 Transit vehicles built on or before 22-Apr-2015 and equipped with light emitting diode (LED) cargo ... Read More »
Some 2015-2019 Transit vehicles may exhibit inoperative power door locks and/or power windows due to water intrusion in the door to body harness connector C339 (left) or C340 (right). Read More »
Some 2013-2019 vehicles equipped with a EVDC air conditioning (A/C) compressor may exhibit poor A/C performance/improper climate function and/or a diagnostic trouble code (DTC) P06A0 in the powertrain control module (PCM). Read More »
Some 2015-2017 vehicles may experience a no crank concern due to a security access key table error. When attempting to program keys or perform a parameter reset, the procedure may fail and the Integrated Diagnostic System (IDS) scan tool ... Read More »
Some 2015-2017 vehicles may experience a no crank concern due to a security access key table error. When attempting to program keys or perform a parameter reset, the procedure may fail and the Integrated Diagnostic System (IDS) scan tool ... Read More »
Some 2015 Transit vehicles equipped with a 3.2L engine may exhibit an illuminated MIL with DTCs P24A0 and/or P26A0 stored in the powertrain control module (PCM). Follow the Service Procedure steps to correct the condition. Read More »
Some 2015 Transit vehicles equipped with a 3.2L engine may exhibit an illuminated MIL with DTCs P24A0 and/or P26A0 stored in the powertrain control module (PCM). Follow the Service Procedure steps to correct the condition. Read More »
For 2015-2019 Transit vehicles, multiple fuse assemblies for the high current battery junction box are available for service. Do not replace the high current battery junction box assembly/wire harness to service an open fuse. Read More »
Some 2015-2018 Transit vehicles built on or before 24-Jul-2018 may exhibit various drivability concerns including difficulty starting, misfires and/or an illuminated MIL with diagnostic trouble codes (DTCs) P00BD, P1247, P1548, P061B, ... Read More »
Some 2015-2018 Transit vehicles equipped with a 3.2L diesel engine may exhibit "Drive To Clean" maintenance messages and/or an illuminated malfunction indicator lamp (MIL) on with DTC P2459, P2463, and/or P246C. Read More »
As noted in FSA 17S34, loss of instrument cluster display can result from wiring corrosion and damage to the Trailer Relay Module on affected Transit vehicles. Read More »
Some 2015-2017 Transit vehicles may fail to program the BCM following replacement. To repair, follow BCM installation procedures in Workshop Manual (WSM), Section 419-10 using Integrated Diagnostic System (IDS) or Ford J2534 Diagnostic ... Read More »
Some 2015-2017 Transit vehicles may fail to program the BCM following replacement. To repair, follow BCM installation procedures in Workshop Manual (WSM), Section 419-10 using Integrated Diagnostic System (IDS) or Ford J2534 Diagnostic ... Read More »
Some 2015-2017 Transit vehicles equipped with a 3.5L or 3.7l gasoline engine may exhibit an engine overheat condition or poor A/C cooling due to one or more of the 3 cooling fan fuses being open. Read More »
Some vehicles may exhibit a no start condition with an illuminated malfunction indicator lamp (MIL) and a DTC P161A after PCM replacement. This may be due to the parameter reset procedure not being properly completed. Read More »
Some 2013-2017 F-Super Duty/2015-2017 Transit/2016-2017 F650-750 vehicles equipped with a diesel engine may exhibit DTC P207F and/or P20EE (Reductant Quality Performance) in the powertrain control module (PCM). Read More »
Some 2015-2018 Transits may exhibit a lack of airflow from the front climate control system cabin vents in fresh air mode. This concern can be due to improper installation of the hood vent air duct plug. Read More »
Some 2013-2017 F-Super Duty, 2015-2017 Transit and 2016-2017 F650-F750 vehicles equipped with a diesel engine may exhibit diagnostic trouble code (DTC) P2201 (NOX Sensor Circuit Range/Performance Bank 1 Sensor 1) in the powertrain control ... Read More »
SOME 2015-2016 TRANSIT VEHICLES EQUIPPED WITH A 3.2L DIESEL ENGINE WITH LESS THAN 10,500 KM (6,500 MILES) AND BUILT ON 5/11/2015 AND THROUGH 2/8/2016 MAY EXHIBIT A CRANK NO START CONDITION AND/OR MALFUNCTION INDICATOR LAMP (MIL) ... Read More »
In some of the affected vehicles, the front control/display interface module (FCDIM) may have been unintentionally programmed for the European market instead of the North American market Read More »
Online automotive service information system for April 2016-AM/FM/CD or sync with a 4.2 inch screen may exhibit a blank screen and no a;udio after a crank event. Read More »
Some 2015-2016 F-Super Duty Pickkup vehicles equipped with 6.7L engine and built on or before 9/9/2015 may exhibit MIL on with DTCs P259F, P0234 and/or P0236 stored in powertrain control module (PCM) memory. 3. Read More »
SOME 2015 TRANSIT VEHICLES BUILT ON OR BEFORE 30-MAR-2015 MAY EXHIBIT VARIOUS DRIVABILITY CONCERNS INCLUDING DIFFICULTY STARTING, MISFIRES AND/OR AN ILLUMINATED MALFUNCTION INDICATOR LAMP (MIL) WITH DIAGNOSTIC TROUBLE CODE (DTC) P00BD, ... Read More »
FORD: LOW LEVEL INSTRUMENT CLUSTERS FAILS TO DISPLAY TRANSPORT MODE STATUS, WHEN ITS TO PREVENT REMOTE KEYLESS ENTRY (RKE) AND INTERIOR LIGHT(S) FROM FUNCTIONING WHEN IGNITION KEY IS OFF BUT ENGINE RUNNING. MODEL 2015 TRANSIT. Read More »
Some 2015-2017 Transit vehicles may fail BCM installation programming when attempting to install a new BCM. The Technical Assistance Center and engineering teams are currently working to resolve this concern. Read More »
2015-2024 Transit and 2023-2024 Transit Trail vehicles equipped with DRW have a high mount rear marker lamp that does not illuminate with the stop lamps. Read More »
2015-2022 Transit vehicles equipped with DRW have a high mount rear marker lamp that does not illuminate with the stop lamps. This lamp assembly may appear to be a stop lamp but is intended to illuminate with the parking lamps only. Read More »
2015-2021 Transit vehicles equipped with dual rear wheels (DRW) have a high mount rear marker lamp that does not illuminate with the stop lamps. Read More »
2015-2019 Transit vehicles equipped with dual rear wheels (DRWs) have a high mount rear marker lamp that does not illuminate with the stop lamps. Read More »
2015-2019 Transit vehicles equipped with dual rear wheels (DRWs) have a high mount rear marker lamp that does not illuminate with the stop lamps. Read More »
Some 2015-2019 Transit vehicles may exhibit inoperative power door locks and/or power windows due to water intrusion in the door to body harness connector C339 (left) or C340 (right). Read More »
FORD: NO SERVICE ACTION IS RECOMMENDED FOR THIS CONDITION. PLEASE USE AT YOUR DISCRETION. VARIOUS 2010-2015 VEHICLES MAY EXPERIENCE A TURBULENCE NOISE, SIMILAR TO AN HELICOPTER NOISE, AT HIGHWAY SPEEDS WHEN THE REAR DOOR WINDOW(S) OR ... Read More »
49 CFR Part 579.5 Monthly Communications - March 2016 Air bag warning light illuminated with diagnostic trouble code (DTC) B141B and/or B141C Read More »
Some 2015-2023 Transit vehicles may exhibit front seat safety belts that do not extend or retract properly or may exhibit an abnormal noise. Read More »
Some 2015-2022 Transit vehicles may exhibit front seat safety belts that do not extend or retract properly or may exhibit an abnormal noise. Read More »
Some 2015-2021 Transit vehicles may exhibit front seat safety belts that do not extend or retract properly or may exhibit an abnormal noise. Read More »
Some 2015-2018 Transit vehicles may exhibit front seat safety belts that do not extend or retract properly or may exhibit an abnormal noise. Read More »
Some 2015-2018 Transit vehicles may exhibit front seat safety belts that do not extend or retract properly or may exhibit an abnormal noise. Read More »
Some vehicles may have a concern where the safety belt retractor webbing does not extract from the stowed position or exhibits excessive pressure on the occupant during use. Read More »
FORD: SOME VEHICLES FRONT SEAT BELTS ARE MAKING NOISE AND FAILS TO RETRACT OR EXTEND PROPERLY DUE TO A POSSIBLE MODIFICATION OF VEHICLE AND BULKHEAD PARTITION. MODEL 2015 TRANSIT. *PE Read More »
Some 2015-2019 Transit vehicles may exhibit front seat safety belts that do not extend or retract properly or may exhibit an abnormal noise. Read More »
Some 2015-2018 Transit vehicles may exhibit front seat safety belts that do not extend or retract properly or may exhibit an abnormal noise. Read More »
Some vehicles may have a concern where the safety belt retractor webbing does not extract from the stowed position or exhibits excessive pressure on the occupant during use. Read More »
FORD: SOME VEHICLES FRONT SEAT BELTS ARE MAKING NOISE AND FAILS TO RETRACT OR EXTEND PROPERLY DUE TO A POSSIBLE MODIFICATION OF VEHICLE AND BULKHEAD PARTITION. MODEL 2015 TRANSIT. *PE Read More »
Some 2015-2021 Transit vehicles may experience difficulty opening and/or closing the manual sliding door that will require sliding door adjustment. Read More »
Some 2015-2020 Transit high roof bus/passenger wagon vehicles may experience a loose or unseated headliner at the C and/or C 1/2 pillar(s) causing visible gaps. Read More »
Some 2015-2019 Transit High-Roof Bus/Passenger Wagon vehicles may experience a loose or unseated headliner at the C and/or C 1/2 pillar(s) causing visible gaps. Read More »
49 CFR Part 579.5 Monthly Communications - March 2016 Air bag warning light illuminated with diagnostic trouble code (DTC) B141B and/or B141C Read More »
SOME 2015-2017 TRANSIT VEHICLES MAY EXHIBIT TRIM ISSUES THAT ARE NOT WARRANTABLE BY FORD. TRANSIT VEHICLES ARE EQUIPPED WITH INTERIOR AND EXTERIOR TRIM WHICH ARE NOT PAINTED AND HAVE A GRAINED APPEARANCE. Read More »
Some 2015-2022 Transit vehicles may experience a snap, click and/or pop noise from the door check when opening/closing the front door(s). This may be due to a cracked/broken door check and/or fastener. Read More »
SOME 2015-2016 TRANSIT VEHICLES BUILT ON 8/1/2015 AND THROUGH 2/1/2016 MAY EXHIBIT A FRONT DOOR THAT DOES NOT OPEN WHEN USING THE OUTSIDE HANDLE AND REQUIRES A SECOND ATTEMPT. Read More »
BROKEN INTERIOR SLIDING DOOR HANDLE - BUILT ON OR BEFORE 1/4/2016 ISSUE Some 2015-2016 Transit vehicles built on or before 1/4/2016 may experience a broken interior sliding door handle due to the sliding door lower roller assembly. Read More »
SOME 2015-2016 TRANSIT VEHICLES BUILT ON 8/1/2015 AND THROUGH 2/1/2016 MAY EXHIBIT A FRONT DOOR THAT DOES NOT OPEN WHEN USING THE OUTSIDE HANDLE AND REQUIRES A SECOND ATTEMPT. Read More »
FORD 2015 POLICE INTERCEPTOR SEDAN VEHICLES: CUSTOMER SATISFACTION PROGRAM REGARDING ENABLE POLICE MODE TRUNK RELEASE. THE PROGRAM WILL BE IN EFFECT THROUGH MAY 31, 2016. *LJ Read More »
Some 2015-2019 Transit vehicles may exhibit a front wheel bearing type noise or DTCs C0031 and/or C0034 in the anti-lock brake system (ABS) module. Read More »
Some 2015-2017 Transit vehicles may exhibit front seat safety belts that do not extend or retract properly or may exhibit an abnormal noise. Read More »
FORD 2015 TRANSIT HIGH ROOF BUS/WAGON : SERVICE INFORMATION REGARDING VEHICLES HEADLINER THEAT DOES NOT STAY SEATED AT THE C AND HALF PILLAR TRIM. *LJ Read More »
SSM 48531 - 2015 Transit - Interior High Intensity LED Cargo Lamps May Emit A Low Glow When Off - Built On Or Before 22-Apr-2015 Some 2015 Transit vehicles built on or before 22-Apr-2015 and equipped with light emitting diode (LED) cargo ... Read More »
FORD: WHEN THEY SHOULD BE OFF, SOME VEHICLES, WITH HIGH LED INTERIOR INTENSITY, ARE EXPERIENCING LED CARGO LAMPS, WITH A LOW GLOW AND NEED NOT BE REPLACED. MODEL 2015 TRANSIT. *PE Read More »
All accessory stick-on keyless entry keypads come with a wallet card containing the master code. If the accessory keypad was factory installed, this card will be placed in the glove box and should be handed to the vehicles owner during ... Read More »
Some 2015-2022 Transit vehicles may experience a snap, click and/or pop noise from the door check when opening/closing the front door(s). This may be due to a cracked/broken door check and/or fastener. Read More »
Some 2015-2019 Transit vehicles equipped with a 3.7L engine and block heater may exhibit a repeat coolant leak from a deteriorated O-ring and/or intake manifold thermostat housing. Read More »
Some 2015-2021 Transit vehicles built with manual sliding door(s) may have an incorrectly adjusted ajar switch. To correct this condition, follow the service procedure to readjust the ajar switch. Read More »
Certain 2013-2016 Model Year F-Series Super Duty 6.7L Diesel and 2015-2019 Model Year Transit 3.2L Diesel Vehicles ??A?A? Front NOx Sensor Warranty Extension In all of the affected vehicles, the onboard diagnostic (OBD) system initially ... Read More »
Certain 2013-2016 Model Year F-Series Super Duty 6.7L Diesel and 2015-2019 Model Year Transit 3.2L Diesel Vehicles ??A?A? Rear NOx Sensor Warranty Extension In all of the affected vehicles, the onboard diagnostic (OBD) system initially ... Read More »
Some 2015-2020 Transit vehicles equipped with rear wheel drive (RWD), single rear wheel (SRW) and a U-joint at the transmission flange and rear driveshaft may experience a boom/hum/moan noise or vibration from the rear while driving. Read More »
Some 2015-2019 Transit High Roof Bus/Passenger Wagon vehicles may have a headliner that does not stay seated at the C and/or C and half pillar hard trim. Read More »
Some 2012-2019 Vehicles may require repairs to the Smartlink system. Smartlink is a Ford Licensed Accessory which has a warranty provided by the accessory manufacturer. Read More »
Replacement engines may have a fuel injection pump sprocket that does not include a keyway slot. It is acceptable to utilize the original fuel injection pump if it has a keyway slot. Timing the injection pump is not necessary. Read More »
Some 2015-2018 Transit vehicles equipped with a 3.2L diesel engine may exhibit "Drive To Clean" maintenance messages and/or an illuminated malfunction indicator lamp (MIL) on with DTC P2459, P2463, and/or P246C. Read More »
Some 2013-2018 F-150, 2015-2018 Transit/Expedition, and 2015-2017 Navigator vehicles equipped with a 3.5L EcoBoost engine with greater than 20,000 miles may exhibit a tick type noise from the cylinder block area. Read More »
Some 2013-2018 F-150, 2015-2018 Transit/Expedition, and 2015-2017 Navigator vehicles equipped with a 3.5L EcoBoost engine with greater than 20,000 miles may exhibit a tick type noise from the cylinder block area. Read More »
Replacing the original equipment SYNC/Navigation system with either an aftermarket SYNC/Navigation kit or modifying original SYNC/Navigation parts to provide additional features is not recommended nor supported on any Ford, Mercury or ... Read More »
When replacing a 2015-2018 Transit 3.2L Duratorq-TDCi engine assembly or block, two new transmission locator dowel pins (W703519 or W718670) must be installed. This information is available in Workshop Manual, Section 303-01C. Read More »
2015-2018 Transit vehicles equipped with dual rear wheels (DRWs) have a high mount rear marker lamp that does not illuminate with the stop lamps. Read More »
REPLACING THE ORIGINAL EQUIPMENT SYNC/NAVIGATION SYSTEM WITH EITHER AN AFTERMARKET SYNC/NAVIGATION KIT OR MODIFYING ORIGINAL SYNC/NAVIGATION PARTS TO PROVIDE ADDITIONAL FEATURES IS NOT RECOMMENDED NOR SUPPORTED ON ANY FORD, MERCURY OR ... Read More »
2015-2017 TRANSIT VEHICLES ORDERED WITH A KEYLESS ENTRY KEYPAD WILL HAVE THE FORD ACCESSORY KEYPAD INSTALLED ON THE VEHICLE AND PROGRAMMED AT THE ASSEMBLY PLANT. Read More »
SOME 2015-2017 LOW ROOF TRANSIT VEHICLES BUILT ON OR BEFORE 30-SEP-2016 AND UPFITTED WITH A ROOF RACK MAY EXHIBIT INTERIOR ROOF BOW BRACKET TO SIDE PANEL SEPARATION. Read More »
SOME 2015-2017 TRANSIT HIGH ROOF WAGON VEHICLES BUILT ON OR AFTER 2-JUN-2015 MAY HAVE BEEN SHIPPED WITH A HEADLINER PANEL THAT WAS NOT PROPERLY SEATED, CAUSING A GAP AT THE C AND/OR C 1/2 PILLAR(S). Read More »
Online automotive service information system for April 2016-AM/FM/CD or sync with a 4.2 inch screen may exhibit a blank screen and no a;udio after a crank event. Read More »
49 CFR Part 579.5 Monthly Communications - March 2016 Air bag warning light illuminated with diagnostic trouble code (DTC) B141B and/or B141C Read More »
FORD: 2015 TRANSIT BUS/WAGON WITH A HIGH ROOF, WILL EXPERIENCE A GAP OR LOOSE HEADLINER BETWEEN 3-5 MM BETWEEN SIDE TRIM PANEL AT C AND/OR C 1/2 PILLARS AND HEADLINER *CN Read More »
2015 TRANSIT: VEHICLES EQUIPPED WITH DIESEL MAY SHOW THE MALFUNCTION INDICATOR LIGHT ILLUMINATED WITH DTC P204F PRESENT IN REDUCTANT DOSING CONTROL MODULE *CN Read More »
The procedure to program keys on 2015-2018 Transit vehicles depends on if the vehicle is equipped with the Passive Anti-Theft System (PATS). Keys for PATS and non-PATS vehicles look the same, there is no visual difference. Read More »
2010-2018 various vehicles equipped with SYNC or SYNC 3 may not function when attempting to find or use the Spotify app via AppLink. As of an update released on 1/15/2018 Spotify will no longer be supporting their AppLink integration. Read More »
Some 2015-2018 Transit vehicles equipped with a 3.5L or 3.7L engine may exhibit a lack of heat or uneven heat from side to side. This condition may be due to deposits from the engine coolant trapped in the heater core. Read More »
2015-2017 TRANSIT VEHICLES EQUIPPED WITH DUAL REAR WHEELS (DRWS) HAVE A HIGH MOUNT REAR MARKER LAMP THAT DOES NOT ILLUMINATE WITH THE STOP LAMPS. Read More »
Some 2015-2019 Transit vehicles equipped with a 3.7L engine and block heater may exhibit a repeat coolant leak from a deteriorated O-ring and/or intake manifold thermostat housing. Read More »
FORD: LOW LEVEL INSTRUMENT CLUSTERS FAILS TO DISPLAY TRANSPORT MODE STATUS, WHEN ITS TO PREVENT REMOTE KEYLESS ENTRY (RKE) AND INTERIOR LIGHT(S) FROM FUNCTIONING WHEN IGNITION KEY IS OFF BUT ENGINE RUNNING. MODEL 2015 TRANSIT. Read More »
Some 2015-2019 Transit vehicles may exhibit poor air conditioning (A/C) performance. If the cause of this is found to be a refrigerant leak from the evaporator, this may be due to build up of contaminates inside the evaporator housing. Read More »
Some 2015-2019 Transit vehicles may exhibit poor air conditioning (A/C) performance. If the cause of this is found to be a refrigerant leak from the evaporator, it is recommended to replace only the evaporator case as opposed to the ... Read More »
Some 2013-2019 vehicles equipped with a EVDC air conditioning (A/C) compressor may exhibit poor A/C performance/improper climate function and/or a diagnostic trouble code (DTC) P06A0 in the powertrain control module (PCM). Read More »
Some 2015-2018 Transit vehicles equipped with the Auxiliary Heater / A/C Prep Package 62C are built specifically for A/C system modification. Read More »
Some 2015-2018 F-150, Mustang and Transit vehicles built on or before 01-Dec-2017 may have a concern of no airflow from the climate control vents. This may be caused by a seized or sticking A/C clutch. Read More »
Some 2015-2018 F-150, Mustang and Transit vehicles built on or before 01-Dec-2017 may have a concern of no airflow from the climate control vents. This may be caused by a seized or sticking A/C clutch. Read More »
This article supersedes TSB 22-2271 to update the vehicle model years affected. Some 2015-2023 Transit vehicles equipped with rear wheel drive (RWD), single rear wheel (only), and U-joints at the transmission flange and rear driveshaft ... Read More »
SSM 48619 - Various Vehicles - Perimeter Alarm Armed And Original Vehicle Keys Cannot Be Accessed to Enter Vehicle - CAN Protection Strategy Some 2013-2016 Model Year Vehicles may exhibit a concern in which the Perimeter Alarm is ... Read More »
