Technical Service Bulletins (TSBs) for the 2016 Challenger are official communications between Dodge & their dealerships that describe processes for troubleshooting or fixing certain common problems.
All vehicle manufacturers are required by U.S. law to make their TSBs available to the public.
Electric Power Steering Gear If any of the following DTCs exist, it is okay to replace the steering gear: C2217-00, C15C1-00 (EPS Mechanical Performance) or C15DB-00 (Latch Active) otherwise perform the following; 1) Electrical, ... Read More »
Electric Power Steering Gear If any of the following DTCs exist, it is okay to replace the steering gear: C2217-00, C15C1-00 (EPS Mechanical Performance) or C15DB-00 (Latch Active) otherwise perform the following; 1) Electrical, ... Read More »
Electric Power Steering Gear For LA, LD and LX Models ONLY; Before this part is replaced for: A) Electrical, Communication or DTC issue please contact: Terry Gavit @ cell (248) 882-6108 terry.gavit@fcagroup. Read More »
Electric Power Steering Gear For LA, LD and LX Models ONLY; Before this part is replaced for: A) Electrical, Communication or DTC issue please contact: Terry Gavit @ cell (248) 882-6108 terry.gavit@fcagroup. Read More »
Flash: Heated Steering Wheel Temperature Enhancement Depending on vehicle architecture: This bulletin involves updating the Comfort Seat and Wheel Module (CSWM) software for the KL/UF vehicles or the Heated Seat Module (HSM) software ... Read More »
Flash: Heated Steering Wheel Temperature Enhancement Depending on vehicle architecture: This bulletin involves updating the Comfort Seat and Wheel Module (CSWM) software for the KL/UF vehicles or the Heated Seat Module (HSM) software ... Read More »
Flash: Heated Steering Wheel Temperature Enhancement Depending on vehicle architecture: This bulletin involves updating the Comfort Seat and Wheel Module (CSWM) software for the KL/UF vehicles or the Heated Seat Module (HSM) software ... Read More »
LIFTER, Hydraulic Roller Deactivating Please do not replace MDS lifters because the disconnecting pin is not lined up, this is normal and not a defect. Read More »
Air Suspension Components Star Parts Catalog has been updated to show individual service parts for the compressor assembly. This will allow service technicians to repair the root cause without over repairing the system. Read More »
Lower Control Arm If replacing Lower Control Arm due to worn bushings, please note that replacement bushings are now available separate from the control arm. Read More »
Lower Control Arm If replacing Lower Control Arm due to worn bushings, please note that replacement bushings are now available separate from the control arm. Read More »
Rotor - Front 2 Piece For LA, LD SRT vehicles with the 2-piece Front Rotor (BR7 sales code), do NOT replace the rotor for a clicking noise occurring while turning at low parking lot speeds. Read More »
Vibration While Braking This bulletin involves resurfacing either front/rear or all rotors and if necessary, replacing either front/rear or all brake rotors due to inactivity on dealer lots. Read More »
Vibration While Braking This bulletin involves resurfacing either front/rear or all rotors and if necessary, replacing either front/rear or all brake rotors due to inactivity on dealer lots. Read More »
Anti-Lock Brake Module (ABS) Before replacing the ABS module, please call Fadi Korkis at cell (586) 722-4100. If you don't receive response within 15 minutes, please continue with normal repair procedure. Read More »
"ANTI-LOCK BRAKE MODULE (ABS) BEFORE REPLACING THE ABS MODULE, PLEASE CALL FADI KORKIS AT CELL (586) 722-4100. IF YOU DON'T RECEIVE RESPONSE WITHIN 15 MINUTES, PLEASE CONTINUE WITH NORMAL REPAIR PROCEDURE. Read More »
Anti-Lock Brake Module (ABS) Before replacing the ABS module, please call Fadi Korkis at cell (586) 722-4100. If you don't receive response within 15 minutes, please continue with normal repair procedure. Read More »
Door Panel Armrest Pull Cup Loose And/Or Audio Induced Buzz/Rattle This bulletin involves inspecting/replacing the armrest door pull cup fastener. Read More »
Customer complaints may include abnormal engine noise, rough idle, lack of power, misfire. Upon investigation, it may be found that there is excessive camshaft lobe wear/lifter wear (roller failure) on one or more cam lobes and that ... Read More »
Flash: Powertrain Control Module (PCM) Updates This bulletin involves reprogramming the PCM with updated software. Customers may experience a Malfunction Indicator Lamp (MIL) illumination. Read More »
Headlamp Air Intake Bypass Port Is Capped Off This bulletin involves the removal of the close out cover inside the driver?s headlamp assembly. The customer may describe less than expected engine performance. Read More »
ADAPTER, Engine Oil Filter (Pentastar V6) For all 2014MY replace the Oil Filter Adapter (OFA). For any other MY review and follow instructions from the latest STAR Online S1809000007 available on Dealer Connect. Read More »
ADAPTER, Engine Oil Filter (Pentastar V6) For all 2014MY replace the Oil Filter Adapter (OFA). For any other MY review and follow instructions from the latest STAR Online S1809000007 available on Dealer Connect. Read More »
ADAPTER, Engine Oil Filter (Pentastar V6) For all 2014MY replace the Oil Filter Adapter (OFA). For any other MY (with mileage above 30,000) review and follow instructions from STAR Online S1809000007 REV. C available on Dealer Connect. Read More »
If a Mopar oil filter is not available, use a filter that meets or exceeds USCAR36 specification and is compatible with semi and full synthetic oils. Read More »
Customer complaints may include abnormal engine noise, rough idle, lack of power, misfire. Upon investigation, it may be found that there is excessive camshaft lobe wear/lifter wear (roller failure) on one or more cam lobes and that ... Read More »
Issue involves overheating, running hot, coolant leaks and related symptoms after a Mopar replacement engine has been installed in the vehicle. Read More »
Issue involves overheating, running hot, coolant leaks and related symptoms after a Mopar replacement engine has been installed in the vehicle. Read More »
Customer complaints may include abnormal engine noise, rough idle, lack of power, misfire. Upon investigation, it may be found that there is excessive camshaft lobe wear/lifter wear (roller failure) on one or more cam lobes and that ... Read More »
Transmission Oil Pan, Heater (TMU), Tube or O-ring Applies to vehicles equipped with 8 speed transmissions only; if you have a leak that appears to be at the pan the use of proper leak detection is recommended. Read More »
Transmission Oil Pan, Heater (TMU), Tube or O-ring Applies to vehicles equipped with 8 speed transmissions only; if you have a leak that appears to be at the pan the use of proper leak detection is recommended. Read More »
CORE, Heater (with tubes) When replacing the heater core for LA, LX, and LD vehicles, make sure to return not only the heater core but also the connecting tubes, seals and retainers. For any questions contact FCA Redacted Content. Read More »
Trans Oil Pan, Heater Tube or O-ring, Heater Applies to vehicles equipped with 8 speed transmissions only; If you have a leak that appears to be at the pan the use of proper leak detection is recommended. Read More »
Rotor - Front 2 Piece For LA, LD SRT vehicles with the 2-piece Front Rotor (BR7 sales code), do NOT replace the rotor for a clicking noise occurring while turning at low parking lot speeds. Read More »
Pentastar Oil Filter Adapter All vehicles equipped with a 3.2L or 3.6L engine; If replacing the Oil Filter Adapter (OFA) due to a leak detected between OFA and block, an O-ring kit (68191356AA) is now available to repair OFA/Block ... Read More »
Pentastar Oil Filter Adapter All vehicles equipped with a 3.2L or 3.6L engine; If replacing the Oil Filter Adapter (OFA) due to a leak detected between OFA and block, an O-ring kit (68191356AA) is now available to repair OFA/Block ... Read More »
Trans Pan or Gasket If your repair requires replacing one of the two part numbers for a leak, prior to the repair please call Enzo Piazza at cell (248) 467-9163. If you cannot reach Enzo within 15 minutes proceed with the repair. Read More »
Oil Pump Assembly If error code P06DD present on any Pentastar V6 application, please inspect oil pump for relief valve failure. See photo attached. If valve is found out of place please call Bob Jackson (248) 944-0466 bob. Read More »
Flash: Powertrain Diagnostic And System Improvements This bulletin involves reprogramming of the Powertrain Control Module (PCM) with the latest software. Customers may experience a Malfunction Indicator Lamp (MIL) illumination. Read More »
Intake Manifold Gasket Intake Manifold Gaskets on Pentastar Upgrade (Sales Code ERC/ERF) are reusable provided they are not cut, torn or melted. Read More »
Flash: Diagnostic And System Improvements This bulletin involves reprogramming the Powertrain Control Module (PCM) with updated software. Customers may experience a Malfunction Indicator Lamp (MIL) illumination. Read More »
Tighten Generator Mounting Bolts This bulletin involves torquing the generator mounting bolts to proper specifications. The customer may hear a noise coming from the generator or possibly experience loss of charging. Read More »
Flash: Powertrain Diagnostic And System Improvements This bulletin involves reprogramming of the Powertrain Control Module (PCM) with the latest software. Customers may experience a Malfunction Indicator Lamp (MIL) illumination. Read More »
Flash: 6.4L Powertrain Diagnostic And System Improvements This bulletin involves reprogramming of the Powertrain Control Module (PCM) with the latest software. Read More »
NAG1 (5A580) Valve Body As per Warranty Bulletin D-13-22, please use R2108213A$ valve body for all Warranty (W), Mopar (M) and Mopar Vehicle Protection (F) claims.~ Assembly also includes Filter (52108325AA) and Gasket (52108332AA). Read More »
Customer complaints may include abnormal engine noise, rough idle, lack of power, misfire. Upon investigation, it may be found that there is excessive camshaft lobe wear/lifter wear (roller failure) on one or more cam lobes and that ... Read More »
Customer complaints may include abnormal engine noise, rough idle, lack of power, misfire. Upon investigation, it may be found that there is excessive camshaft lobe wear/lifter wear (roller failure) on one or more cam lobes and that ... Read More »
5.7L Cold End Exhaust RH Side (Resonator & Muffler) Engineering is currently investigating an issue where the back-end exhaust system (resonator and muffler right hand assembly) cracks at or around the weld near the muffler with Model ... Read More »
ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL
Fuel Pump Connector Replacement The technician may experience a crank/no start after the fuel pump module was replaced. This bulletin involves replacing the fuel pump connector harness (pigtail) when replacing the fuel pump module. Read More »
Transmission Oil Pan, Heater (TMU), Tube or O-ring Applies to vehicles equipped with 8 speed transmissions only; if you have a leak that appears to be at the pan the use of proper leak detection is recommended. Read More »
Oil Pump Assembly If error code P06DD present on any Pentastar V6 application, please inspect oil pump for relief valve failure. See photo attached. If valve is found out of place please call Bob Jackson (248) 944-0466 bob. Read More »
Transmission Kit with Torque Converter 1. All Promaster (VF) 3.6L/62TE equipped vehicles. If the transmission bracket to the transmission case fasteners are removed during servicing, the fasteners (Part Number 06511385A$) are one-time ... Read More »
Flash: Powertrain Control Module (PCM) Updates This bulletin involves reprogramming the PCM with updated software. Customers may experience a Malfunction Indicator Lamp (MIL) illumination. Read More »
Transmission Oil Pan, Heater (TMU), Tube or O-ring Applies to vehicles equipped with 8 speed transmissions only; if you have a leak that appears to be at the pan the use of proper leak detection is recommended. Read More »
Transmission Oil Pan, Heater (TMU), Tube or O-ring Applies to vehicles equipped with 8 speed transmissions only; if you have a leak that appears to be at the pan the use of proper leak detection is recommended. Read More »
Transmission Oil Pan, Heater (TMU), Tube or O-ring Applies to vehicles equipped with 8 speed transmissions only; if you have a leak that appears to be at the pan the use of proper leak detection is recommended. Read More »
Trans Oil Pan, Heater Tube or O-ring, Heater Applies to vehicles equipped with 8 speed transmissions only; If you have a leak that appears to be at the pan the use of proper leak detection is recommended. Read More »
Flash: Powertrain Diagnostic and System Improvements This bulletin involves reprogramming of the Powertrain Control Module (PCM) with the latest software. Customers may experience a Malfunction Indicator Lamp (MIL) illumination. Read More »
Flash: Transmission Diagnostic and Shift Enhancements This bulletin involves reprogramming the Transmission Control Module (TCM) with the latest available software. Read More »
Flash: Powertrain Diagnostic and System Enhancements This bulletin involves reprogramming the Powertrain Control Module (PCM) with thelatest available software. Customers may experience a Malfunction Indicator Lamp (MIL) illumination. Read More »
Flash: Powertrain Diagnostic and System Improvements This bulletin involves reprogramming of the Powertrain Control Module (PCM) with the latest software. Customers may experience a Malfunction Indicator Lamp (MIL) illumination. Read More »
Flash: Powertrain Diagnostic and System Improvements This bulletin involves reprogramming of the Powertrain Control Module (PCM) with the latest software. Customers may experience a Malfunction Indicator Lamp (MIL) illumination. Read More »
Electric Power Steering Gear If any of the following DTCs exist, it is okay to replace the steering gear: C2217-00, C15C1-00 (EPS Mechanical Performance) or C15DB-00 (Latch Active) otherwise perform the following; 1) Electrical, ... Read More »
Rear Axle Assembly If replacing Limited Spin Differential (LSD)/Anti-Spin Differential rear axles for any reason, the Mopar replacement axle will need the oil drained and re-filled with oil PN: 68083381AA (which contains updated ... Read More »
Flash: Transmission Shift And Drivability Enhancements This bulletin involves reprogramming the Transmission Control Module (TCM) with the latest available software. Read More »
Electric Power Steering Gear For LA, LD and LX Models ONLY; Before this part is replaced for: A) Electrical, Communication or DTC issue please contact: Terry Gavit @ cell (248) 882-6108 terry.gavit@fcagroup. Read More »
Flash: Powertrain Diagnostic And System Improvements This bulletin involves reprogramming of the Powertrain Control Module (PCM) with the latest software. Customers may experience a Malfunction Indicator Lamp (MIL) illumination. Read More »
Flash: Transmission Shift And Drivability Enhancements This bulletin involves reprogramming the Transmission Control Module (TCM) with the latest available software. Read More »
Inspect And Replace Propeller Shaft This bulletin involves inspecting and replacing the propeller shaft due to a whining noise at high speeds. Read More »
"FLASH: DIAGNOSTIC AND SYSTEM IMPROVEMENTS THIS BULLETIN INVOLVES REPROGRAMMING THE POWERTRAIN CONTROL MODULE (PCM) WITH UPDATED SOFTWARE. CUSTOMERS MAY EXPERIENCE A MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATION. Read More »
Flash: 3.6L Powertrain Diagnostic And System Enhancements. This bulletin involves reprogramming the Powertrain Control Module (PCM) with the latest available software. Read More »
Flash: Transmission Shift And Drivability Enhancements This bulletin involves reprogramming of the Transmission Control Module (TCM) with the latest available software. Read More »
Flash: Diagnostic And System Improvements This bulletin involves reprogramming the Powertrain Control Module (PCM) with updated software. Customers may experience a Malfunction Indicator Lamp (MIL) illumination. Read More »
Flash: Transmission Shift And Drivability Enhancements This bulletin involves reprogramming of the Transmission Control Module (TCM) with the latest available software. Read More »
9-spd Transmission: FOR NAFTA Market Only: If you are ordering this transmission please follow all wiTECH pop ups and Warranty Payment Guidelines. Read More »
9-spd Transmission: FOR NAFTA Market Only: If you are ordering this transmission please follow all wiTECH pop ups and Warranty Payment Guidelines. Read More »
9-spd Transmission: FOR NAFTA Market Only: If you are ordering this transmission please follow all wiTECH pop ups and Warranty Payment Guidelines. Read More »
Manual Transmission Shifter Noise This bulletin involves greasing or replacing the manual transmission rear shifter bushing. Customers may experience a clunk, squeak, or similar noise heard from center console area while shifting. Read More »
Manual Transmission Shifter Noise This bulletin involves greasing or replacing the manual transmission rear shifter bushing. Customers may experience a clunk, squeak, or similar noise heard from center console area while shifting. Read More »
Transmission If the customer concern is grinding or difficulties getting the transmission into 5th gear and you are working on any 15 MY Challenger, or 16 MY Challenger built before 4/25/2016 an engineering change has been made to the ... Read More »
Transmission If the customer concern is grinding or difficulties getting the transmission into 5th gear and you are working on any 15 MY Challenger, or 16 MY Challenger built before 4/25/2016 an engineering change has been made to the ... Read More »
Flash: 6.4L Powertrain Diagnostic And System Improvements This bulletin involves reprogramming of the Powertrain Control Module (PCM) with the latest software. Read More »
Flash: Transmission Shift And Drivability Enhancements This bulletin involves reprogramming of the Transmission Control Module (TCM) with the latest available software. Read More »
Flash: Transmission Shift And Drivability Enhancements This bulletin involves reprogramming the Transmission Control Module (TCM) with the latest available software. Read More »
6 Speed Manual Transmission Please contact Kevin Stepinski (586) 219-2438 prior to doing any repairs on this transmission if you have a broken input gear. Leave a message if Kevin does not answer within 15 minutes, proceed with the repair. Read More »
Manual Transmission Shifter Noise This bulletin involves greasing or replacing the manual transmission rear shifter bushing. Customers may experience a clunk, squeak, or similar noise heard from center console area while shifting. Read More »
POWER TRAIN:MANUAL TRANSMISSION:CONTROL MODULE (TCM/PCM/TECM)
"FLASH: TRANSMISSION SHIFT AND DRIVABILITY ENHANCEMENTS THIS BULLETIN INVOLVES REPROGRAMMING OF THE TRANSMISSION CONTROL MODULE (TCM) WITH THE LATEST AVAILABLE SOFTWARE. Read More »
Flash: Powertrain Control Module (PCM) Updates This bulletin involves reprogramming the PCM with updated software. Customers may experience a Malfunction Indicator Lamp (MIL) illumination. Read More »
Flash: Transmission Shift And Drivability Enhancements This bulletin involves reprogramming the Transmission Control Module (TCM) with the latest available software. Read More »
Flash: Powertrain Diagnostic And System Improvements This bulletin involves reprogramming of the Powertrain Control Module (PCM) with the latest software. Customers may experience a Malfunction Indicator Lamp (MIL) illumination. Read More »
"FLASH: 3.6L POWERTRAIN DIAGNOSTIC AND SYSTEM ENHANCEMENTS. THIS BULLETIN INVOLVES REPROGRAMMING THE POWERTRAIN CONTROL MODULE (PCM) WITH THE LATEST AVAILABLE SOFTWARE. Read More »
Flash: Powertrain Diagnostic And System Improvements This bulletin involves reprogramming of the Powertrain Control Module (PCM) with the latest software. Customers may experience a Malfunction Indicator Lamp (MIL) illumination. Read More »
Oil Filter If a Mopar Oil Filter is not available, use a filter that meets or exceeds USCAR36 specification and is compatible with semi and full synthetic oils. Read More »
"INSPECT AND REPLACE PROPELLER SHAFT THIS BULLETIN INVOLVES INSPECTING AND REPLACING THE PROPELLER SHAFT DUE TO A WHINING NOISE AT HIGH SPEEDS. Read More »
Rear Axle Assembly If replacing Limited Spin Differential (LSD)/Anti-Spin Differential rear axles for any reason, the Mopar replacement axle will need the oil drained and re-filled with oil PN: 68083381AA (which contains updated friction ... Read More »
Connector kit Before ordering this connector repair kit 68018957A$, check it in the Mopar Connector Repair Kit Website to confirm part number and applicability. Read More »
Fuel Pump Connector Replacement The technician may experience a crank/no start after the fuel pump module was replaced. This bulletin involves replacing the fuel pump connector harness (pigtail) when replacing the fuel pump module. Read More »
Start Stop Charging Warning Lamp Illuminated On, Intelligent Battery Sensor (IBS) State of Charge (SOC) Inaccurate, Battery Charging Message, Presence of IBS related Diagnostic Trouble Codes (DTCs), or Battery Warning Lamp ... Read More »
Flash: Powertrain Control Module (PCM) Updates This bulletin involves reprogramming the PCM with updated software. Customers may experience a Malfunction Indicator Lamp (MIL) illumination. Read More »
Flash: Powertrain Control Module (PCM) Updates This bulletin involves reprogramming the PCM with updated software. Customers may experience a Malfunction Indicator Lamp (MIL) illumination. Read More »
Driver Window Short Drop Feature Does Not Drop The Window When The Door Is Open, Window Short Up Feature Does Raise The Window When The Door Is Closed Read More »
Driver Window Short Drop Feature Does Not Drop The Window When The Door Is Open, Window Short Up Feature Does Raise The Window When The Door Is Closed Read More »
Charging System, Battery Diagnostic Tools and Warranty This information only bulletin discusses using the correct test equipment for testing batteries and charging systems, and also warranty reimbursement when battery replacements are ... Read More »
Flash Over The Air (FOTA) Software Update RA3 and RA4 Radio This bulletin provides information regarding the latest Flash Over The Air (FOTA) update and provides the service technician an overview of the steps a customer will need to ... Read More »
Motor, Windshield Wiper For Jeep Grand Cherokee, Dodge Durango, Chrysler 300, Dodge Charger, and Dodge Challenger that exhibit a non-functional Windshield Wiper Motor, replace the entire wiper module and contact FCA Current Production ... Read More »
Motor, Windshield Wiper For Jeep Grand Cherokee, Dodge Durango, Chrysler 300, Dodge Charger, and Dodge Challenger that exhibit a non-functional Windshield Wiper Motor, replace the entire wiper module and contact FCA Current Production ... Read More »
Flash: Powertrain Diagnostic and System Improvements This bulletin involves reprogramming of the Powertrain Control Module (PCM) with the latest software. Customers may experience a Malfunction Indicator Lamp (MIL) illumination. Read More »
Flash: Transmission Diagnostic and Shift Enhancements This bulletin involves reprogramming the Transmission Control Module (TCM) with the latest available software. Read More »
Flash: Transmission Shift And Drivability Enhancements This bulletin involves reprogramming the Transmission Control Module (TCM) with the latest available software. Read More »
Electric Power Steering Gear For LA, LD and LX Models ONLY; Before this part is replaced for: A) Electrical, Communication or DTC issue please contact: Terry Gavit @ cell (248) 882-6108 terry.gavit@fcagroup. Read More »
Electric Power Steering Gear For LA, LD and LX Models ONLY; Before this part is replaced for: A) Electrical, Communication or DTC issue please contact: Terry Gavit @ cell (248) 882-6108 terry.gavit@fcagroup. Read More »
Flash: Powertrain Diagnostic And System Improvements This bulletin involves reprogramming of the Powertrain Control Module (PCM) with the latest software. Customers may experience a Malfunction Indicator Lamp (MIL) illumination. Read More »
Flash: Transmission Shift And Drivability Enhancements This bulletin involves reprogramming the Transmission Control Module (TCM) with the latest available software. Read More »
Flash: Diagnostic And System Improvements This bulletin involves reprogramming the Powertrain Control Module (PCM) with updated software. Customers may experience a Malfunction Indicator Lamp (MIL) illumination. Read More »
Flash: 3.6L Powertrain Diagnostic And System Enhancements. This bulletin involves reprogramming the Powertrain Control Module (PCM) with the latest available software. Read More »
Flash: Transmission Shift And Drivability Enhancements This bulletin involves reprogramming of the Transmission Control Module (TCM) with the latest available software. Read More »
Flash: 3.6L Powertrain Diagnostic And System Enhancements. This bulletin involves reprogramming the Powertrain Control Module (PCM) with the latest available software. Read More »
Flash: Transmission Shift And Drivability Enhancements This bulletin involves reprogramming of the Transmission Control Module (TCM) with the latest available software. Read More »
Anti-Lock Brake Module (ABS) Before replacing the ABS module, please call Fadi Korkis at cell (586) 722-4100. If you don't receive response within 15 minutes, please continue with normal repair procedure. Read More »
Anti-Lock Brake Module (ABS) Before replacing the ABS module, please call Fadi Korkis at cell (586) 722-4100. If you don't receive response within 15 minutes, please continue with normal repair procedure. Read More »
Keyfob 2016 Vehicle Keyfobs with Passive Entry Keyless Go Feature - Engineering is investigating a keyfob unable to program or no function or low keyfob coin battery condition. Read More »
Integrated Center Stack If vehicle is found within 50 mile radius of the Detroit Metro area please hold vehicle and contact:~ Contact one of the following:~ Daniel Acciacca CELL (586) 709-1537~ Michael Savich CELL (248) 214-7270~ ... Read More »
RES / RHA / REB radio that supports Bluetooth and Hands-Free For issues with Bluetooth, Hands-Free Calling, and/or Voice Commands, DO NOT replace the radio. Diagnose the Hands-Free Module system (also called the Telematics Module). Read More »
RES / RHA / REB radio that supports Bluetooth and Hands-Free For issues with Bluetooth, Hands-Free Calling, and/or Voice Commands, DO NOT replace the radio. Diagnose the Hands-Free Module system (also called the Telematics Module). Read More »
RA3 RA4 Radio Enhancements This bulletin involves inspecting and, if required, updating the radio software. A small number of customers may experience one or more of the following: ? Navigation failed message is displayed. Read More »
Flash: Powertrain Diagnostic And System Improvements This bulletin involves reprogramming of the Powertrain Control Module (PCM) with the latest software. Customers may experience a Malfunction Indicator Lamp (MIL) illumination. Read More »
Flash: Heated Steering Wheel Temperature Enhancement Depending on vehicle architecture: This bulletin involves updating the Comfort Seat and Wheel Module (CSWM) software for the KL/UF vehicles or the Heated Seat Module (HSM) software ... Read More »
Flash: 6.4L Powertrain Diagnostic And System Improvements This bulletin involves reprogramming of the Powertrain Control Module (PCM) with the latest software. Read More »
Radio Software Enhancements This bulletin involves updating the radio's software. A customer may experience one or more of the following: ? Radio display screen intermittently may go blank. ? Radio display screen may lock up. Read More »
Hands Free Feature Inoperative This bulletin involves updating the Hands Free Module (HFM) software. The customer may notice that the hands free feature (Bluetooth) does not work. Read More »
Flash: Heated Steering Wheel Temperature Enhancement Depending on vehicle architecture: This bulletin involves updating the Comfort Seat and Wheel Module (CSWM) software for the KL/UF vehicles or the Heated Seat Module (HSM) software ... Read More »
Part Description: Central Body Controller (CBC) Issue Description: Prior to replacing the Central Body Controller (CBC) on a 2015 or 2016 Challenger, please contact Greg Meade on (cell) 248-770-5989. Read More »
Start Stop Charging Warning Lamp Illuminated On, Intelligent Battery Sensor (IBS) State of Charge (SOC) Inaccurate, Battery Charging Message, Presence of IBS related Diagnostic Trouble Codes (DTCs), or Battery Warning Lamp ... Read More »
Tighten Generator Mounting Bolts This bulletin involves torquing the generator mounting bolts to proper specifications. The customer may hear a noise coming from the generator or possibly experience loss of charging. Read More »
Variable Valve Timing (VVT) Solenoid, Variable Valve Timing (VVT) Phaser For a 2016/2017 MY 6.4L SRT with less than 12,000 miles that have either a P0016 CRANKSHAFT/CAMSHAFT TIMING MISALIGNMENT - BANK 1 SENSOR 1 or P000B BANK 1 ... Read More »
Connector kit Before ordering this connector repair kit 68018957A$, check it in the Mopar Connector Repair Kit Website to confirm part number and applicability. Read More »
WIRING, Body Before replacing this harness, please contact FCA Redacted Content to see if a repair kit is available for your application. If no response in 15 minutes, proceed with repair. Read More »
PANEL, Instrument Panel Please note when receiving a concern of the IP dash is foggy/cloudy in appearance, please first do the following before replacing the IP: 1) Using a clean lint free soft cloth, wet the cloth using MOPAR Total Clean. Read More »
Flash: HVAC System Enhancement This bulletin involves reprogramming the Heating Ventilation Air Conditioning (HVAC)Module with new software. Read More »
RA3 and RA4 Radio Over The Air Software Updates This bulletin provides information regarding the latest Flash Over The Air (FOTA) update and provides the service technician an overview of the steps a customer will need to take to ... Read More »
Flash: Powertrain Diagnostic and System Improvements This bulletin involves reprogramming of the Powertrain Control Module (PCM) with the latest software. Customers may experience a Malfunction Indicator Lamp (MIL) illumination. Read More »
Flash: Transmission Shift And Drivability Enhancements This bulletin involves reprogramming the Transmission Control Module (TCM) with the latest available software. Read More »
"FLASH: TRANSMISSION SHIFT AND DRIVABILITY ENHANCEMENTS THIS BULLETIN INVOLVES REPROGRAMMING OF THE TRANSMISSION CONTROL MODULE (TCM) WITH THE LATEST AVAILABLE SOFTWARE. Read More »
"FLASH: DIAGNOSTIC AND SYSTEM IMPROVEMENTS THIS BULLETIN INVOLVES REPROGRAMMING THE POWERTRAIN CONTROL MODULE (PCM) WITH UPDATED SOFTWARE. CUSTOMERS MAY EXPERIENCE A MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATION. Read More »
"FLASH: 3.6L POWERTRAIN DIAGNOSTIC AND SYSTEM ENHANCEMENTS. THIS BULLETIN INVOLVES REPROGRAMMING THE POWERTRAIN CONTROL MODULE (PCM) WITH THE LATEST AVAILABLE SOFTWARE. Read More »
Radio Software Enhancements This bulletin involves updating the radio's software. CAUTION: Confirm the correct radio flash file to the applicable model and family vehicle before flashing. Read More »
Radio Software Enhancements This bulletin involves updating the radio's software. CAUTION: Confirm the correct radio flash file to the applicable model and family vehicle before flashing. Read More »
Flash: Powertrain Diagnostic and System Improvements This bulletin involves reprogramming of the Powertrain Control Module (PCM) with the latest software. Customers may experience a Malfunction Indicator Lamp (MIL) illumination. Read More »
Flash: 3.6L Powertrain Diagnostic And System Enhancements. This bulletin involves reprogramming the Powertrain Control Module (PCM) with the latest available software. Read More »
Driver Window Short Drop Feature Does Not Drop The Window When The Door Is Open, Window Short Up Feature Does Raise The Window When The Door Is Closed Read More »
Authentic Mopar? Glass Replacement This bulletin involves discussing FCA US LLC position with regard to collision repair industry awareness regarding the recommended usage of Authentic Mopar? Glass. Read More »
Authentic Mopar? Glass Replacement This bulletin involves discussing FCA US LLC position with regard to collision repair industry awareness regarding the recommended usage of Authentic Mopar? Glass. Read More »
Motor, Windshield Wiper For Jeep Grand Cherokee, Dodge Durango, Chrysler 300, Dodge Charger, and Dodge Challenger that exhibit a non-functional Windshield Wiper Motor, replace the entire wiper module and contact FCA Current Production ... Read More »
Motor, Windshield Wiper For Jeep Grand Cherokee, Dodge Durango, Chrysler 300, Dodge Charger, and Dodge Challenger that exhibit a non-functional Windshield Wiper Motor, replace the entire wiper module and contact FCA Current Production ... Read More »
Washer Fluid Level Sensor Prior to replacing this part due to "Low Washer Fluid" tell tale light on the dash and the washer fluid bottle is full, please perform the this inspection. Read More »
Driver Window Short Drop Feature Does Not Drop The Window When The Door Is Open, Window Short Up Feature Does Raise The Window When The Door Is Closed Read More »
Driver Window Short Drop Feature Does Not Drop The Window When The Door Is Open, Window Short Up Feature Does Raise The Window When The Door Is Closed Read More »
Washer Fluid Level Sensor Prior to replacing this part due to "Low Washer Fluid" tell tale light on the dash and the washer fluid bottle is full, please perform this inspection: Check if float sensor is rotated off location from the ... Read More »
Washer Fluid Level Sensor Prior to replacing this part due to "Low Washer Fluid" tell tale light on the dash and the washer fluid bottle is full, please perform this inspection: Check if float sensor is rotated off location from the ... Read More »
Flash: HVAC System Enhancement This bulletin involves reprogramming the Heating Ventilation Air Conditioning (HVAC) Module with new software. Read More »
Transmission Oil Pan, Heater (TMU), Tube or O-ring Applies to vehicles equipped with 8 speed transmissions only; if you have a leak that appears to be at the pan the use of proper leak detection is recommended. Read More »
Flash: Powertrain Diagnostic and System Improvements This bulletin involves reprogramming of the Powertrain Control Module (PCM) with the latest software. Customers may experience a Malfunction Indicator Lamp (MIL) illumination. Read More »
Flash: Transmission Diagnostic and Shift Enhancements This bulletin involves reprogramming the Transmission Control Module (TCM) with the latest available software. Read More »
Flash: Powertrain Diagnostic and System Improvements This bulletin involves reprogramming of the Powertrain Control Module (PCM) with the latest software. Customers may experience a Malfunction Indicator Lamp (MIL) illumination. Read More »
Restraints Remove I-Sheet from packaging. Correct information sheet (I-Sheet) has been added to Star Parts. Print I-Sheet for technician use. Read More »
Aluminum Body Panel Corrosion Repair Aluminum corrosion or bubbling along the leading edge of hood, hinges or other exterior surface areas of the hinges, doors, fenders, swing gates or liftgates. Read More »
Aluminum Body Panel Corrosion Repair Aluminum corrosion or bubbling along the leading edge of hood, hinges or other exterior surface areas of the hinges, doors, fenders, swing gates or liftgates. Read More »
Aluminum Body Panel Corrosion Repair Aluminum corrosion or bubbling along the leading edge of hood, hinges or other exterior surface areas of the hinges, doors, fenders, swing gates or liftgates. Read More »
Approved Use of Weld Through Primers This bulletin documents the FCA US LLC position regarding the use of weld through primer when using Squeeze Type Resistance Spot Welding (STRSW) and Gas Metal Arc Welding (GMAW) processes when ... Read More »
Approved Use of Weld Through Primers This bulletin documents the FCA US LLC position regarding the use of weld through primer when using Squeeze Type Resistance Spot Welding (STRSW) and Gas Metal Arc Welding (GMAW) processes when ... Read More »
Approved Use of Weld Through Primers This bulletin documents the FCA US LLC position regarding the use of weld through primer when using Squeeze Type Resistance Spot Welding (STRSW) and Gas Metal Arc Welding (GMAW) processes when ... Read More »
Aluminum Body Panel Corrosion Repair This bulletin involves inspecting and if necessary removing corrosion and refinishingthe suspect aluminum panels on the vehicle, hood, door, fenders, hinges, swing gates or liftgate panels. Read More »
Aluminum Body Panel Corrosion Repair This bulletin involves inspecting and if necessary removing corrosion and refinishingthe suspect aluminum panels on the vehicle, hood, door, fenders, hinges, swing gates or liftgate panels. Read More »
Driver Window Short Drop Feature Does Not Drop The Window When The Door Is Open, Window Short Up Feature Does Raise The Window When The Door Is Closed Read More »
Repair Parts Used For Structural Repairs This bulletin involves discussing FCA US LLC position with regard to structural repair parts usage. Read More »
Use of Aftermarket Parts This bulletin involves discussing FCA US LLC position with regard to collision repair industry awareness regarding the use of aftermarket parts. Read More »
Repair Parts Used For Structural Repairs This bulletin involves discussing FCA US LLC position with regard to structural repair parts usage. Read More »
Use of Aftermarket Parts This bulletin involves discussing FCA US LLC position with regard to collision repair industry awareness regarding the use of aftermarket parts. Read More »
Use of Salvage/Recycled Parts This bulletin involves discussing FCA US LLC position with regard to collision repair industry awareness regarding the use of recycled or salvage parts. Read More »
Tighten Generator Mounting Bolts This bulletin involves torquing the generator mounting bolts to proper specifications. The customer may hear a noise coming from the generator or possibly experience loss of charging. Read More »
Door Hinge Assembly Side door hinge noisy. Only replace the door hinge with the integral check device. Do not replace the simple hinge if it is not damaged it is not the source of the noise. Replacing it unnecessary and is an over-repair. Read More »
Door Panel Armrest Pull Cup Loose And/Or Audio Induced Buzz/Rattle This bulletin involves inspecting/replacing the armrest door pull cup fastener. Read More »
Door Panel Armrest Pull Cup Loose And/Or Audio Induced Buzz/Rattle This bulletin involves inspecting/replacing the armrest door pull cup fastener. Read More »
Door Hinge Assembly Side door hinge noisy. Only replace the door hinge with the integral check device. Do not replace the simple hinge if it is not damaged it is not the source of the noise. Read More »
Hood Seal Torn or Deformed This bulletin involves replacing the hood seals due to damage and/or being torn. The customer may experience the hood seal drooping due to cracks and tears on the hood seal. Read More »
Hood Seal Torn or Deformed This bulletin involves replacing the hood seals due to damage and/or being torn. The customer may experience the hood seal drooping due to cracks and tears on the hood seal. Read More »
Approved Use of Weld Through Primers This bulletin documents the FCA US LLC position regarding the use of weld through primer when using Squeeze Type Resistance Spot Welding (STRSW) and Gas Metal Arc Welding (GMAW) processes when ... Read More »
Console Lid LA ONLY: If you are replacing the console lid because the latch is broken, please also replace the console base in addition to the console lid. Please call Mike Wicker on cell (248) 821-9350 prior to replacing the components. Read More »
Console Lid LA ONLY: If you are replacing the console lid because the latch is broken, please also replace the console base in addition to the console lid. Please call Mike Wicker on cell (248) 821-9350 prior to replacing the components. Read More »
Part Description: Accelerator Pedal Issue Description: Vehicle has accelerator pedal fault code. Before replacing accelerator pedal, be sure to follow fault code diagnostic procedures in service manual. Read More »
Door Panel Armrest Pull Cup Loose And/Or Audio Induced Buzz/Rattle This bulletin involves inspecting/replacing the armrest door pull cup fastener. Read More »
Accelerator Pedal Before replacing accelerator pedal, be sure to follow fault code diagnostic procedures in service manual. Make sure to check wiring and connectors. Read More »
Accelerator Pedal Before replacing accelerator pedal, be sure to follow fault code diagnostic procedures in service manual. Make sure to check wiring and connectors. Read More »
Part Description: Accelerator Pedal Issue Description: Vehicle has accelerator pedal fault code. Before replacing accelerator pedal, be sure to follow fault code diagnostic procedures in service manual. Read More »
Adaptive Cruise Control Sensor 1) If you are replacing this part due to the cluster displaying Clean Radar Sensor in Front of Vehicle or DTC C1266 ACC Sensor Blinded, please verify that there is no blockage in front of the sensor. Read More »
Rotor - Front 2 Piece For LA, LD SRT vehicles with the 2-piece Front Rotor (BR7 sales code), do NOT replace the rotor for a clicking noise occurring while turning at low parking lot speeds. Read More »
Trans Pan or Gasket If your repair requires replacing one of the two part numbers for a leak, prior to the repair please call Enzo Piazza at cell (248) 467-9163. If you cannot reach Enzo within 15 minutes proceed with the repair. Read More »
Rear Axle Assembly If replacing Limited Spin Differential (LSD)/Anti-Spin Differential rear axles for any reason, the Mopar replacement axle will need the oil drained and re-filled with oil PN: 68083381AA (which contains updated ... Read More »
Dynamic Sensor Prior to replacing this part, please ensure all the pre-diagnostic & diagnostic procedures have been completed with emphasis on wiring and connector integrity. Read More »
Transmission Oil Pan, Heater (TMU), Tube or O-ring Applies to vehicles equipped with 8 speed transmissions only; if you have a leak that appears to be at the pan the use of proper leak detection is recommended. Read More »
Console Lid LA ONLY: If you are replacing the console lid because the latch is broken, please also replace the console base in addition to the console lid. Please call Mike Wicker on cell (248) 821-9350 prior to replacing the components. Read More »
Console Lid LA ONLY: If you are replacing the console lid because the latch is broken, please also replace the console base in addition to the console lid. Please call Mike Wicker on cell (248) 821-9350 prior to replacing the components. Read More »
Flash: Heated Steering Wheel Temperature Enhancement Depending on vehicle architecture: This bulletin involves updating the Comfort Seat and Wheel Module (CSWM) software for the KL/UF vehicles or the Heated Seat Module (HSM) software ... Read More »
ADAPTER, Engine Oil Filter (Pentastar V6) For all 2014MY replace the Oil Filter Adapter (OFA). For any other MY (with mileage above 30,000) review and follow instructions from STAR Online S1809000007 REV. C available on Dealer Connect. Read More »
Transmission Oil Pan, Heater (TMU), Tube or O-ring Applies to vehicles equipped with 8 speed transmissions only; if you have a leak that appears to be at the pan the use of proper leak detection is recommended. Read More »
Flash: Powertrain Diagnostic and System Improvements This bulletin involves reprogramming of the Powertrain Control Module (PCM) with the latest software. Customers may experience a Malfunction Indicator Lamp (MIL) illumination. Read More »
Flash: Transmission Diagnostic and Shift Enhancements This bulletin involves reprogramming the Transmission Control Module (TCM) with the latest available software. Read More »
Rotor - Front 2 Piece For LA, LD SRT vehicles with the 2-piece Front Rotor (BR7 sales code), do NOT replace the rotor for a clicking noise occurring while turning at low parking lot speeds. Read More »
Electric Power Steering Gear If any of the following DTCs exist, it is okay to replace the steering gear: C2217-00, C15C1-00 (EPS Mechanical Performance) or C15DB-00 (Latch Active) otherwise perform the following; 1) Electrical, ... Read More »
Flash: Powertrain Diagnostic And System Improvements This bulletin involves reprogramming of the Powertrain Control Module (PCM) with the latest software. Customers may experience a Malfunction Indicator Lamp (MIL) illumination. Read More »
Inspect And Replace Propeller Shaft This bulletin involves inspecting and replacing the propeller shaft due to a whining noise at high speeds. Read More »
Flash: 3.6L Powertrain Diagnostic And System Enhancements. This bulletin involves reprogramming the Powertrain Control Module (PCM) with the latest available software. Read More »
Manual Transmission Shifter Noise This bulletin involves greasing or replacing the manual transmission rear shifter bushing. Customers may experience a clunk, squeak, or similar noise heard from center console area while shifting. Read More »
Dynamic Sensor Prior to replacing this part, please ensure all the pre-diagnostic & diagnostic procedures have been completed with emphasis on wiring and connector integrity. Read More »
If a Mopar oil filter is not available, use a filter that meets or exceeds USCAR36 specification and is compatible with semi and full synthetic oils. Read More »
Transmission Oil Pan, Heater (TMU), Tube or O-ring Applies to vehicles equipped with 8 speed transmissions only; if you have a leak that appears to be at the pan the use of proper leak detection is recommended. Read More »
Charging System, Battery Diagnostic Tools and Warranty This information only bulletin discusses using the correct test equipment for testing batteries and charging systems, and also warranty reimbursement when battery replacements are ... Read More »
CORE, Heater (with tubes) When replacing the heater core for LA, LX, and LD vehicles, make sure to return not only the heater core but also the connecting tubes, seals and retainers. For any questions contact FCA Redacted Content. Read More »
Use of Salvage/Recycled Parts This bulletin involves discussing FCA US LLC position with regard to collision repair industry awareness regarding the use of recycled or salvage parts. Read More »
Use of Aftermarket Parts This bulletin involves discussing FCA US LLC position with regard to collision repair industry awareness regarding the use of aftermarket parts. Read More »
Repair Parts Used For Structural Repairs This bulletin involves discussing FCA US LLC position with regard to structural repair parts usage. Read More »
RADIO, MULTI Media For RA3 and RA4 8.4? radio concern of reoccurring update request pop-up on each key cycle after a radio FOTA (Firmware Update Over the Air) has been completed, please DO NOT replace the radio. Read More »
Flash Over The Air (FOTA) Software Update RA3 and RA4 Radio This bulletin provides information regarding the latest Flash Over The Air (FOTA) update and provides the service technician an overview of the steps a customer will need to ... Read More »
RADIO [RES] - New and/or Service Exchange For RES radio concerns. Use the wiTECH 2.0 and inspect the radio part number and serial number under the Radio/ECU Details tab. Read More »
ACTUATOR, A/C and Heater Before replacing HVAC actuator, please contact either Thomas Conway (248) 635-7090 or Paul Aquino (248) 854-4819. Engineering is looking to gather infomation on fail mode and customer concern. Read More »
6 Speed Manual Transmission Please contact Kevin Stepinski (586) 219-2438 prior to doing any repairs on this transmission if you have a broken input gear. Leave a message if Kevin does not answer within 15 minutes, proceed with the repair. Read More »
Motor, Windshield Wiper For Jeep Grand Cherokee, Dodge Durango, Chrysler 300, Dodge Charger, and Dodge Challenger that exhibit a non-functional Windshield Wiper Motor, replace the entire wiper module and contact FCA Current Production ... Read More »
6 Speed Manual Transmission Please contact Kevin Stepinski (586) 219-2438 prior to doing any repairs on this transmission if you have a broken input gear. Read More »
RA3 and RA4 Radio Over The Air Software Updates This bulletin provides information regarding the latest Flash Over The Air (FOTA) update and provides the service technician an overview of the steps a customer will need to take to ... Read More »
RA3 And RA4 Radio Over The Air Software Updates This bulletin provides information regarding the latest Flash Over The Air update (FOTA) and provides a service technician an overview of the steps a customer will need to take to complete ... Read More »
Electric Power Steering Gear For LA, LD and LX Models ONLY; Before this part is replaced for: A) Electrical, Communication or DTC issue please contact: Terry Gavit @ cell (248) 882-6108 terry.gavit@fcagroup. Read More »
Flash: Powertrain Diagnostic And System Improvements This bulletin involves reprogramming of the Powertrain Control Module (PCM) with the latest software. Customers may experience a Malfunction Indicator Lamp (MIL) illumination. Read More »
Console Lid LA ONLY: If you are replacing the console lid because the latch is broken, please also replace the console base in addition to the console lid. Please call Mike Wicker on cell (248) 821-9350 prior to replacing the components. Read More »
Console Lid LA ONLY: If you are replacing the console lid because the latch is broken, please also replace the console base in addition to the console lid. Please call Mike Wicker on cell (248) 821-9350 prior to replacing the components. Read More »
Console Lid LA ONLY: If you are replacing the console lid because the latch is broken, please also replace the console base in addition to the console lid. Please call Mike Wicker on cell (248) 821-9350 prior to replacing the components. Read More »
Manual Transmission Shifter Noise This bulletin involves greasing or replacing the manual transmission rear shifter bushing. Customers may experience a clunk, squeak, or similar noise heard from center console area while shifting. Read More »
Manual Transmission Shifter Noise This bulletin involves greasing or replacing the manual transmission rear shifter bushing. Customers may experience a clunk, squeak, or similar noise heard from center console area while shifting. Read More »
Transmission If the customer concern is grinding or difficulties getting the transmission into 5th gear and you are working on any 15 MY Challenger, or 16 MY Challenger built before 4/25/2016 an engineering change has been made to the ... Read More »
RES / RHA / REB radio that supports Bluetooth and Hands-Free For issues with Bluetooth, Hands-Free Calling, and/or Voice Commands, DO NOT replace the radio. Diagnose the Hands-Free Module system (also called the Telematics Module). Read More »
RES / RHA / REB radio that supports Bluetooth and Hands-Free For issues with Bluetooth, Hands-Free Calling, and/or Voice Commands, DO NOT replace the radio. Diagnose the Hands-Free Module system (also called the Telematics Module). Read More »
RA3 RA4 Radio Enhancements This bulletin involves inspecting and, if required, updating the radio software. A small number of customers may experience one or more of the following: ? Navigation failed message is displayed. Read More »
Floor Center Console Panel & Lid This TechTip applies to 2016MY Challenger Scat Pack (LADX22) ONLY. Silver color stitching on floor center console panel and lid is no longer available for replacement. Read More »
Radio Software Enhancements This bulletin involves updating the radio's software. A customer may experience one or more of the following: ? Radio display screen intermittently may go blank. ? Radio display screen may lock up. Read More »
Radio Software Enhancements This bulletin involves updating the radio's software. CAUTION: Confirm the correct radio flash file to the applicable model and family vehicle before flashing. Read More »
Radio Software Enhancements This bulletin involves updating the radio's software. CAUTION: Confirm the correct radio flash file to the applicable model and family vehicle before flashing. Read More »
Door Panel Armrest Pull Cup Loose And/Or Audio Induced Buzz/Rattle This bulletin involves inspecting/replacing the armrest door pull cup fastener. Read More »
CORE, Heater (with tubes) When replacing the heater core for LA, LX, and LD vehicles, make sure to return not only the heater core but also the connecting tubes, seals and retainers. For any questions contact FCA Redacted Content. Read More »
This bulletin provides information regarding the latest Flash Over The Air update (FOTA) and provides a service technician an overview of the steps a customer will need to take to complete the update. Read More »
RES / RHA / REB radio that supports Bluetooth and Hands-Free For issues with Bluetooth, Hands-Free Calling, and/or Voice Commands, DO NOT replace the radio. Diagnose the Hands-Free Module system (also called the Telematics Module). Read More »
RES / RHA / REB radio that supports Bluetooth and Hands-Free For issues with Bluetooth, Hands-Free Calling, and/or Voice Commands, DO NOT replace the radio. Diagnose the Hands-Free Module system (also called the Telematics Module). Read More »
Flash: Heated Steering Wheel Temperature Enhancement Depending on vehicle architecture: This bulletin involves updating the Comfort Seat and Wheel Module (CSWM) software for the KL/UF vehicles or the Heated Seat Module (HSM) software ... Read More »
RADIO [RES] - New and/or Service Exchange For RES radio concerns. Use the wiTECH 2.0 and inspect the radio part number and serial number under the Radio/ECU Details tab. Read More »
RA3 and RA4 Radio Over The Air Software Updates This bulletin provides information regarding the latest Flash Over The Air (FOTA) update and provides the service technician an overview of the steps a customer will need to take to ... Read More »
RA3 and RA4 Radio Enhancements This bulletin involves inspecting and if required, updating the radio software. Customers may experience one or more of the following:?Navigation Failed? message is displayed. Read More »
RA3 and RA4 Radio Enhancements This bulletin involves inspecting and if required, updating the radio software. Customers may experience one or more of the following:?Navigation Failed? message is displayed. Read More »
RA3 And RA4 Radio Over The Air Software Updates This bulletin provides information regarding the latest Flash Over The Air update (FOTA) and provides a service technician an overview of the steps a customer will need to take to complete ... Read More »
RA3 And RA4 Radio Enhancements This bulletin involves inspecting and if required, updating the radio software. Customers may experience one or more of the following: Satellite radio reception improvements. Read More »
MY16 RA3 & RA4 Replacement Radios All MY16 RA3 and RA4 replacement radios must be ordered through the exchange process at United Radio. DO NOT order a NEW radio from Mopar. Go back and order a "Z" level part number. Read More »
RES / RHA / REB radio that supports Bluetooth and Hands-Free For issues with Bluetooth, Hands-Free Calling, and/or Voice Commands, DO NOT replace the radio. Diagnose the Hands-Free Module system (also called the Telematics Module). Read More »
RA3 RA4 Radio Enhancements This bulletin involves inspecting and, if required, updating the radio software. A small number of customers may experience one or more of the following: ? Navigation failed message is displayed. Read More »
Radio Software Enhancements This bulletin involves updating the radio's software. A customer may experience one or more of the following: ? Radio display screen intermittently may go blank. ? Radio display screen may lock up. Read More »
RES / RHA / REB radio that supports Bluetooth and Hands-Free For issues with Bluetooth, Hands-Free Calling, and/or Voice Commands, DO NOT replace the radio. Diagnose the Hands-Free Module system (also called the Telematics Module). Read More »
RA3 RA4 Radio Enhancements This bulletin involves inspecting and, if required, updating the radio software. A small number of customers may experience one or more of the following: ? Navigation failed message is displayed. Read More »
Lubrication and Maintenance Fluids If MOPAR fluids and chemicals are not readily available, please review Service Library for specifications so a suitable alternative can be used Read More »
82212076, 82203694 - Fabric Cleaner This "fabric cleaner" is not intended for sale in California, the otc states (Connecticut, Delaware, Massachusetts, Maine, New Hampshire, New Jersey, New York, Pennsylvania, Virginia, and Washington ... Read More »
Transmission Oil Pan, Heater (TMU), Tube or O-ring Applies to vehicles equipped with 8 speed transmissions only; if you have a leak that appears to be at the pan the use of proper leak detection is recommended. Read More »
Floor Center Console Panel & Lid This TechTip applies to 2016MY Challenger Scat Pack (LADX22) ONLY. Silver color stitching on floor center console panel and lid is no longer available for replacement. Read More »
Flash: HVAC System Enhancement This bulletin involves reprogramming the Heating Ventilation Air Conditioning (HVAC)Module with new software. Read More »
ACTUATOR, A/C and Heater Before replacing HVAC actuator, please contact either Thomas Conway (248) 635-7090 or Paul Aquino (248) 854-4819. Engineering is looking to gather infomation on fail mode and customer concern. Read More »
Flash: HVAC System Enhancement This bulletin involves reprogramming the Heating Ventilation Air Conditioning (HVAC) Module with new software. Read More »
Speakers: For 2016 speakers issues (all bodies), before replacing this part please contact one of the following people regarding this repair: Mahmoud (Mo) Touha at cell (248) 705-3934. Read More »
Speakers: For 2016 speakers issues (all bodies), before replacing this part please contact one of the following people regarding this repair: Mahmoud (Mo) Touha at cell (248) 705-3934. Read More »
Approved Use of Weld Through Primers This bulletin documents the FCA US LLC position regarding the use of weld through primer when using Squeeze Type Resistance Spot Welding (STRSW) and Gas Metal Arc Welding (GMAW) processes when ... Read More »
Customer complaints may include abnormal engine noise, rough idle, lack of power, misfire. Upon investigation, it may be found that there is excessive camshaft lobe wear/lifter wear (roller failure) on one or more cam lobes and that ... Read More »
