Technical Service Bulletins (TSBs) for the 2009 Malibu are official communications between Chevrolet & their dealerships that describe processes for troubleshooting or fixing certain common problems.
All vehicle manufacturers are required by U.S. law to make their TSBs available to the public.
BUICK/CADILLAC/CHEVROLET/GMC/PONTIAC/ SATURN: THERE IS FLUID LEAKING FROM POWER STEERING SYSTEM, ALONG A FLUID LEAK IN FRONT OF VEHICLE UNDERNEATH AND SHOULD BE INSPECTED, CLEANED AND IDENTIFIED BEFORE REPAIRING OR REPLACING. Read More »
BUICK/CADILLAC/CHEVROLET/GMC/PONTIAC/ SATURN: THERE IS FLUID LEAKING FROM POWER STEERING SYSTEM, ALONG A FLUID LEAK IN FRONT OF VEHICLE UNDERNEATH AND SHOULD BE INSPECTED, CLEANED AND IDENTIFIED BEFORE REPAIRING OR REPLACING. Read More »
"THIS TECHNICAL BULLETIN PROVIDES A PROCEDURE TO INSPECT THE STEERING GEAR FOR A NORMAL CONDITION OF GREASE OR SEALANT ON EXTERIOR CASE OF GEAR DUE TO THE MANUFACTURING PROCESS." Read More »
15356 - SPECIAL COVERAGE. ON SOME 2007-2012 MODEL YEAR CHEVROLET MALIBU, PONTIAC G6, AND SATURN AURA VEHICLES EQUIPPED WITH ELECTRIC POWER STEERING ASSIST (EPS), THE STEERING COLUMN TORQUE SENSOR OR THE EPS MOTOR/CONTROLLER MAY CAUSE THE ... Read More »
PONTIAC/SATURN/CHEVROLET: SOME VEHICLES ARE EXPERIENCING MULTIPLE ISSUES/SYMPTOMS CAUSED BY BODY HARNESS HARD CONTACT AGAINST FLOOR EDGE PANEL UNDER LEFT REAR SEAT CUSHION. MODEL 2004-12 MALIBU, MALIBU MAXX, 2007-09 AURA, 2005-10 G6. Read More »
PONTIAC/SATURN/CHEVROLET: A TRACTION CONTROL LIGHT COMES ON. AFTER FURTHER INVESTIGATION A C0561-71 CODE MAY BE THE ONLY CODE STORED IN THE EBCM. CHECK TO SEE IF THERE IS ANY OTHER CODES STORED ANYWHERE ELSE ON THE VEHICLE. Read More »
GMC: UNABLE TO RELEARN THE BRAKE PEDAL POSITION (BPP) SENSOR. HAVE DIFFICULTY PERFORMING THE BRAKE PEDAL POSITION (BPP) RELEARN. MODELS CHEVROLETS, PONTIACS AND SATURNS. *PE Read More »
SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP:ABS WARNING LIGHT
THIS PRELIMINARY INFORMATION COMMUNICATION PROVIDES INFORMATION TO THE TECHNICIAN ABOUT VEHICLES THAT HAVE A MALFUNCTION INDICATOR LAMP ON OR ENGINE MISFIRE, ROUGH IDLE, EXTENDED CRANK, OR CRANK NO START IN SOME CASES. Read More »
THIS INFORMATIONAL BULLETIN PROVIDES INFORMATION TO GM DEALERS ON THE CORRECT CLEANING METHODS WHEN CLEANING ENGINE GASKET SEALING SURFACES. Read More »
THIS PRELIMINARY INFORMATION COMMUNICATION ADVISES THE TECHNICIAN WHAT TO INSPECT IF CODES P0016 AND/OR P0017 ARE SETTING ON A PROPERLY TIMED ENGINE OR A CONDITION OF THE VEHICLE CRANKS BUT WILL NOT START. Read More »
THIS TECHNICAL BULLETIN PROVIDES A PROCEDURE TO PERFORM VARIOUS CHECKS AND REPAIRS TO CORRECT A CUSTOMER OF MALFUNCTION INDICATOR LAMP ON AND DTCS SET. Read More »
THIS PRELIMINARY INFORMATION COMMUNICATION ADVISES THE TECHNICIAN THAT SOME VEHICLES MAY HAVE A SERVICE ENGINE SOON THAT COMES ON. TECHNICIAN MAY FIND A DIAGNOSTIC TROUBLE CODE U0101 CURRENT OR STORED HISTORY. Read More »
If a vehicle comes into the dealership with a knock noise, seized engine, lower end squeak or squeal or any condition that you suspect a rod or main bearing failure. Read More »
PONTIAC/SATURN/CHEVROLET: SOME VEHICLES ARE EXPERIENCING MULTIPLE ISSUES/SYMPTOMS CAUSED BY BODY HARNESS HARD CONTACT AGAINST FLOOR EDGE PANEL UNDER LEFT REAR SEAT CUSHION. MODEL 2004-12 MALIBU, MALIBU MAXX, 2007-09 AURA, 2005-10 G6. Read More »
14404 - SPECIAL COVERAGE. SOME VEHICLES IDENTIFIED ABOVE AND, EQUIPPED WITH A 6T70 OR 6T75 - 6 SPEED FWD AUTOMATIC TRANSMISSION ?? MAY EXPERIENCE A CRACKED OR FRACTURED WAVE PLATE, RESULTING IN A LOSS OF 3RD, 5TH AND REVERSE GEARS. Read More »
GM: SOME VEHICLES REQUIRE REPLACEMENTS FOR HIGH FEATURE V6 TIMING CHAIN KITS AND GUIDE REPLACEMENTS. ALSO INCLUDED CHEVROLET CAPTIVA. MODEL YEARS 2007-2013. *JS UPDATED 7/18/14. *PE Read More »
GM: SOME DTC CODES MAY BE SET, P0016, P0017, P0018, P0019, P0008, OR P0009. 3.6 LY7 WITH CAM ACTUATOR DTC.THE RELUCTOR FOR THE CRANKSHAFT SENSOR PRESSED ON THE CRANKSHAFT MAY HAVE MOVED. ALSO INCLUDED BUICK ALLURE MODEL YEAR 2005. Read More »
CADILLAC/BUICK/SATURN/PONTIAC/CHEVROLET/ GMC: DUE TO AN ABNORMAL ENGINE NOISE OR INTERNAL BY AN OIL FILTER MISAPPLICATION, FILTER DEBRIS MAY BE TRANSFERRED THROUGHOUT ENGINE AND MAY RESULT IN ENGINE DAMAGE. Read More »
BUICK/CHEVROLET/PONTIAC/SATURN: AFTER INSTALLING REMAN HVV6 ENGINE, WOULD BE CONCERN WITH ROUGH RUNNING OR MISFIRE ON ONE OR BOTH BANKS OF ENGINE OR IDLE SURGING. Read More »
THIS PRELIMINARY INFORMATION COMMUNICATION PROVIDES INFORMATION TO THE TECHNICIAN ABOUT VEHICLES THAT MAY HAVE LOW OIL PRESSURE MESSAGE. TECHNICIAN MAY ALSO FIND A DIAGNOSTIC TROUBLE CODE P0521 IN THE ENGINE CONTROL MODULE. Read More »
BUICK/CADILLAC/CHEVROLET/GMC/PONTIAC/SATURN: THERE MAY BE AN INTERMITTENT ENGINE HESITATION OR FLUTTER. THE CAMSHAFT SENSOR TERMINALS LIKELY HAVE POOR CONNECTIONS. *RM UPDATED 8/1/11. *PE UPDATED 4/16/12. Read More »
GM: THERE MAY BE A SHORT RATTLE NOISE FROM THE FRONT OF THE ENGINE WHEN IT IS STARTED. IT COULD BE A PROBLEM WITH CAM PHASERS OR THE ENGINE BELT. *RM Read More »
GMC: MALFUNCTION INDICATOR LAMP ON-CHECK ENGINE LIGHT; ENGINE CRANKS, DO NOT START, HARSH OR NO TRANSMISSION SHIFTS, INSTRUMENT CLUSTER OPERATION ERRATIC OR INOPERATIVE. *PE UPDATED 8/12/09. Read More »
SATURN/PONTIAC/CHEVROLET: THE FUEL GAUGE DOES NOT RISE ABOVE THE 3/4 MARK AFTER A FILL UP OR THE FUEL GAUGE APPEARS STUCK. AN ILLUMINATION OF THE CHECK ENGINE LIGHT. Read More »
GENERAL MOTORS: NO CRANK/NO COMM WITH U2106, U2108, U2109 (LE5 ONLY). THIS CONDITION HAS BEEN IDENTIFIED AS A LOOSE GROUND G105 BEHIND THE A/C COMPRESSOR. *PE Read More »
THIS INFORMATIONAL BULLETIN EXPLAINS THE USE OF DIESEL FUEL ADDITIVES IN AN ENGINE, ARE NOT REQUIRED UNLESS THE CUSTOMER DESIRES ADDITIVES TO PREVENT FUEL CONCERNS DEPENDING ON FUEL OR TEMPERATURE RELATED CONDITIONS. Read More »
GENERAL MOTORS: ON SOME OF THESE VEHICLES, TRANSIENT VOLTAGE SURGES FROM THE ENGINE COOLING FANS MAY BE TRANSMITTED THROUGH THE ENGINE WIRING HARNESS. Read More »
PONTIAC/SATURN/CHEVROLET: DTC P0011 (INTAKE CAMSHAFT POSITION (CMP) SYSTEM PERFORMANCE) AND/OR P0014 (EXHAUST CAMSHAFT POSITION (CMP) SYSTEM PERFORMANCE). THEY MAY HAVE FOLLOWED ESI DIAGNOSTICS AND/OR THE CODE(S) RETURNED. Read More »
ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:MANIFOLD/HEADER/MUFFLER/TAIL PIPE
BUICK/CADILLAC/CHEVROLET/SATURN/GMC: THERE ARE INJECTOR CODES ON VEHICLE IF EXHIBITING MISFIRE AND SES LIGHT IS ON. *PE UPDATED 6/18/12. *PE Read More »
GM: MALFUNCTION LIGHT IS ON AND THERE IS A MISFIRE. THERE MAY BE THREE TROUBLE CODES AND COULD BE A RESULT OF WIRING PROBLEMS AT THE FUEL INJECTOR. *RM Read More »
PONTIAC/SATURN/CHEVROLET: SOME VEHICLES ARE EXPERIENCING MULTIPLE ISSUES/SYMPTOMS CAUSED BY BODY HARNESS HARD CONTACT AGAINST FLOOR EDGE PANEL UNDER LEFT REAR SEAT CUSHION. MODEL 2004-12 MALIBU, MALIBU MAXX, 2007-09 AURA, 2005-10 G6. Read More »
SATURN/PONTIAC/CHEVROLET: THE FUEL GAUGE DOES NOT RISE ABOVE THE 3/4 MARK AFTER A FILL UP OR THE FUEL GAUGE APPEARS STUCK. AN ILLUMINATION OF THE CHECK ENGINE LIGHT. Read More »
THIS PRELIMINARY INFORMATIONAL BULLETIN PROVIDES A PROCEDURE FOR THE REPLACEMENT OF THE CAMSHAFT COVER FOR CONCERNS RELATING TO MALFUNCTION INDICATOR LAMP (MIL) ON, POOR ACCELERATION, THROTTLE BODY FREEZING, MULTIPLE DTCS SET, ICE ... Read More »
14404 - SPECIAL COVERAGE. SOME VEHICLES IDENTIFIED ABOVE AND, EQUIPPED WITH A 6T70 OR 6T75 - 6 SPEED FWD AUTOMATIC TRANSMISSION ?? MAY EXPERIENCE A CRACKED OR FRACTURED WAVE PLATE, RESULTING IN A LOSS OF 3RD, 5TH AND REVERSE GEARS. Read More »
THIS PRELIMINARY INFORMATION COMMUNICATION ADVISES THE TECHNICIAN THAT SOME VEHICLES MAY HAVE A SERVICE ENGINE SOON THAT COMES ON. TECHNICIAN MAY FIND A DIAGNOSTIC TROUBLE CODE U0101 CURRENT OR STORED HISTORY. Read More »
GM: THE SERVICE ENGINE SOON LIGHT IS ON AND THERE MAY BE SHIFTING PROBLEMS. HARSH SHIFTING OR NO REVERSE. THERE MAY BE A BROKEN CLUTCH WAVE PLATE. *RM Read More »
SATURN/PONTIAC/CHEVROLET: SOFT SHIFTS, ERRATIC SHIFTS, DTC P1811. VEHICLES WITH A HYDRAMATIC 4T45 TRANSAXLE MAY HAVE SOFT SHIFTS OR SHIFTS ERRATICALLY. THESE CONDITIONS MAY APPEAR INTERMITTENTLY OR SET A DTC P1811. Read More »
GMC: MALFUNCTION INDICATOR LAMP ON-CHECK ENGINE LIGHT; ENGINE CRANKS, DO NOT START, HARSH OR NO TRANSMISSION SHIFTS, INSTRUMENT CLUSTER OPERATION ERRATIC OR INOPERATIVE. *PE UPDATED 8/12/09. Read More »
GENERAL MOTORS: AN AUTOMATIC TRANSMISSION CONCERN OF NO MOVEMENT, NO REVERSE OR SLIPPING. THESE CONCERNS MAY BE DUE TO AN ISSUE WITH THE DIRECT CLUTCH. *PE Read More »
GENERAL MOTORS: ON SOME OF THESE VEHICLES, TRANSIENT VOLTAGE SURGES FROM THE ENGINE COOLING FANS MAY BE TRANSMITTED THROUGH THE ENGINE WIRING HARNESS. Read More »
GMC: INTERMITTENT SES LIGHT, DTC P2101 WITH POTENTIALLY MULTIPLE OTHER DTC'S SET. THIS CONDITION COULD BE CAUSED BY A PCM CIRCUIT SHORTED TO GROUND. *PE Read More »
POWER TRAIN:AUTOMATIC TRANSMISSION:CONTROL MODULE (TCM/PCM/TECM)
BUICK/CHEVROLET/HUMMER/GMC/PONTIAC/CADILLAC/SATURN: TECHNICIANS MAY FIND DTCS P0601, P0603, P0604, P062F OR P1621 STORED IN THE TCM AS AN ACTIVE OR A HISTORY CODE. SOME OF THESE DTCS CAN ALSO BE SET IN THE ECM OR FPCM. Read More »
GMC: INTERMITTENT SES LIGHT, DTC P2101 WITH POTENTIALLY MULTIPLE OTHER DTC'S SET. THIS CONDITION COULD BE CAUSED BY A PCM CIRCUIT SHORTED TO GROUND. *PE Read More »
GMC: MALFUNCTION INDICATOR LAMP ON. THE TRANSMISSION CONTROL MODULE (TCM) WILL NOT OPERATE AS A RESULT OF SYSTEM VOLTAGE SPIKES WHICH WILL AFFECT COMMUNICATION LINES. *PE Read More »
POWER TRAIN:AUTOMATIC TRANSMISSION:GEAR POSITION INDICATION (PRNDL)
SATURN/GMC/PONTIAC/BUICK/CHEVROLET: NO REVERSE. THE VEHICLE MAY HAVE THE CONCERN OF NO REVERSE WITH OR WITHOUT ONE OR SEVERAL OF THE FOLLOWING DIAGNOSTIC CODES SET-P0776, P2723 OR P2715. Read More »
POWER TRAIN:AUTOMATIC TRANSMISSION:LEVER AND LINKAGE:COLUMN SHIFT
THIS PRELIMINARY INFORMATION COMMUNICATION PROVIDES INFORMATION TO THE TECHNICIAN ABOUT VEHICLES THAT HAVE AN ONSTAR SYSTEM THAT WILL NOT POWER UP. TECHNICIAN SHOULD TURN OFF THE IGNITION AND CANCEL RETAINED ACCESSORY POWER. Read More »
THIS TECHNICAL BULLETIN PROVIDES A PROCEDURE TO CHECK THE CYLINDERS FOR DAMAGED PISTONS AND DETERMINE IF THE USE OF AFTERMARKET CALIBRATIONS OR PERFORMANCE PARTS MAY BE THE CAUSE. Read More »
THIS PRELIMINARY INFORMATION COMMUNICATION PROVIDES INFORMATION TO THE TECHNICIAN ABOUT THE USE OF J-35616-64B TERMINAL TEST PROBE, REPLACEMENT TERMINALS, AND TERMINATED LEADS. Read More »
THIS TECHNICAL BULLETIN PROVIDES A PROCEDURE TO PERFORM VARIOUS CHECKS AND REPAIRS TO CORRECT A CUSTOMER OF MALFUNCTION INDICATOR LAMP ON AND DTCS SET. Read More »
THIS PRELIMINARY INFORMATION COMMUNICATION ADVISES THE TECHNICIAN IF UNABLE TO PLACE AN ONSTAR CALL IN THE IGNITION ON MODE AFTER THE ONSTAR CANADA UPGRADE, TO CONTACT THE GM TECHNICAL ASSISTANCE CENTER ONSTAR GROUP FOR FURTHER ASSISTANCE. Read More »
THIS PRELIMINARY INFORMATION COMMUNICATION ADVISES THE TECHNICIAN ON THE STEPS TO DIAGNOSE THE CONCERN, AND THE STEPS TO REPAIR THE CONCERN OF THE VEHICLE CRANKS BUT DOES NOT START. Read More »
THIS PRELIMINARY INFORMATION COMMUNICATION ADVISES THE TECHNICIAN THE STEPS ON REPAIRING THE CONCERN. A CUSTOMER MAY IDENTIFY A CONCERN OF UNABLE TO REACTIVATE A VEHICLE'S ONSTAR THAT HAS BEEN PREVIOUSLY DISABLED BY ONSTAR. Read More »
THIS PRELIMINARY INFORMATION COMMUNICATION PROVIDES INFORMATION TO HELP THE DEALERSHIP TECHNICIANS PERFORM A PARASITIC DRAIN TEST FOR THE ONSTAR MODULE. Read More »
THIS PRELIMINARY INFORMATION COMMUNICATION PROVIDES INFORMATION TO HELP THE DEALERSHIP TECHNICIANS PERFORM A PARASITIC DRAIN TEST FOR THE ONSTAR MODULE. Read More »
THIS PRELIMINARY INFORMATION COMMUNICATION ADVISES THE TECHNICIAN, IF UNABLE TO PLACE AN ONSTAR CALL IN THE IGNITION ON MODE AFTER THE ONSTAR CANADA UPGRADE TO CONTACT THE GM TECHNICAL ASSISTANCE CENTER ONSTAR GROUP FOR FURTHER ASSISTANCE. Read More »
THIS PRELIMINARY INFORMATION COMMUNICATION ADVISES THE TECHNICIAN THE STEPS ON DIAGNOSING THE CONCERN. VEHICLE'S SUNROOF OPERATION INTERMITTENT, BIND, NOISE, AUTO-REVERSE, AND/OR WATER LEAKS. Read More »
THIS PRELIMINARY INFORMATION COMMUNICATION PROVIDES INFORMATION TO THE TECHNICIAN THE STEPS NEEDED TO DIAGNOSE AND REPAIR THE VEHICLES THAT MAY HAVE UNWANTED OR PHANTOM PHONE CALLS. Read More »
THIS PRELIMINARY INFORMATIONAL BULLETIN PROVIDES A LIST OF CORRECTIONS FOR MULTIPLE CONCERNS REGARDING UNEXPECTED LOSS OF RADIO AUDIO (RADIO GOES SILENT/NO SOUND) AND OTHER BLACKBERRY PHONE - BLUETOOTH ... Read More »
THIS PRELIMINARY INFORMATIONAL BULLETIN PROVIDES A PROCEDURE FOR THE REPLACEMENT OF THE CAMSHAFT COVER FOR CONCERNS RELATING TO MALFUNCTION INDICATOR LAMP (MIL) ON, POOR ACCELERATION, THROTTLE BODY FREEZING, MULTIPLE DTCS SET, ICE ... Read More »
GM: J-35616-64B TERMINAL TEST PROBE AND REPLACEMENT TERMINAL. ALSO INCLUDED MODELS VERANO, REGAL, LACROSSE, CTS, SRX, VOLT, SONIC, MALIBU, IMPALA, EQUINOX, CRUZE, AVALANCHE, TAHOE SUBURBAN, SILVERADO, SIERRA, YUKON, AND TERRAIN FOR ... Read More »
THIS INFORMATIONAL BULLETIN PROVIDES INFORMATION THAT MAY BE USEFUL ON DIAGNOSING BATTERIES THAT HAVE SET FOR A LONG PERIOD OF TIME AND/OR SET IN COLD WEATHER CLIMATES AND TESTING THOSE BATTERIES. Read More »
THIS PRELIMINARY INFORMATION COMMUNICATION PROVIDES INFORMATION TO HELP THE DEALERSHIP TECHNICIANS PERFORM A PARASITIC DRAIN TEST FOR THE ONSTAR MODULE. Read More »
THIS WARRANTY ADMINISTRATION BULLETIN PROVIDE POLICY INFORMATION ON USING THE EL-50313 MIDTRONICS GR8 BATTERY TESTER/CHARGER FOR DIAGNOSING BATTERY REPLACEMENTS AND MAINTAINING BATTERIES ON NEW VEHICLES IN DEALER INVENTORY. Read More »
GM: HYBRID FUNCTION MAY BECOME INOPERATIVE WITH A SERVICE ENGINE SOON LIGHT ON. THE HYBRID SERVICE LIGHT MAY ALSO ILLUMINATE AND FUEL ECONOMY WILL BE LOWER. *RM Read More »
SATURN\CHEVROLET SERVICE CAMPAIGN: SEE DOCUMENT SEARCH BUTTON FOR OWNER LETTER. LOSS OF HYBRID FUNCTION-REPLACE BATTERIES. THE HYBRID FUNCTION ON THESE VEHICLES MAY BECOME INOPERATIVE. Read More »
CHEVROLET/OPEL/SATURN/CADILLAC/PONTIAC: A LOW BATTERY CONDITION ON ANY OF THE ABOVE LISTED VEHICLES COULD POTENTIALLY CAUSE THE SIR LIGHT TO COME. THE SDM UNDER LOW POWER SITUATIONS COULD SET CODES B0083 AND B0084. Read More »
BUICK/CADILLAC/CHEVROLET/SATURN/GMC: THERE ARE INJECTOR CODES ON VEHICLE IF EXHIBITING MISFIRE AND SES LIGHT IS ON. *PE UPDATED 6/18/12. *PE Read More »
GM: MALFUNCTION LIGHT IS ON AND THERE IS A MISFIRE. THERE MAY BE THREE TROUBLE CODES AND COULD BE A RESULT OF WIRING PROBLEMS AT THE FUEL INJECTOR. *RM Read More »
PONTIAC/SATURN/CHEVROLET: DTC P0011 (INTAKE CAMSHAFT POSITION (CMP) SYSTEM PERFORMANCE) AND/OR P0014 (EXHAUST CAMSHAFT POSITION (CMP) SYSTEM PERFORMANCE). THEY MAY HAVE FOLLOWED ESI DIAGNOSTICS AND/OR THE CODE(S) RETURNED. Read More »
GMC: MALFUNCTION INDICATOR LAMP ON-CHECK ENGINE LIGHT; ENGINE CRANKS, DO NOT START, HARSH OR NO TRANSMISSION SHIFTS, INSTRUMENT CLUSTER OPERATION ERRATIC OR INOPERATIVE. *PE UPDATED 8/12/09. Read More »
GENERAL MOTORS: ON SOME OF THESE VEHICLES, TRANSIENT VOLTAGE SURGES FROM THE ENGINE COOLING FANS MAY BE TRANSMITTED THROUGH THE ENGINE WIRING HARNESS. Read More »
GMC: MALFUNCTION INDICATOR LAMP ON. THE TRANSMISSION CONTROL MODULE (TCM) WILL NOT OPERATE AS A RESULT OF SYSTEM VOLTAGE SPIKES WHICH WILL AFFECT COMMUNICATION LINES. *PE Read More »
BUICK/CADILLAC/CHEVROLET/SATURN/GMC: THERE ARE INJECTOR CODES ON VEHICLE IF EXHIBITING MISFIRE AND SES LIGHT IS ON. *PE UPDATED 6/18/12. *PE Read More »
THIS PRELIMINARY INFORMATION COMMUNICATION PROVIDES INFORMATION TO THE TECHNICIAN THAT AFTER REPLACING THE INSTRUMENT PANEL CLUSTER THE EXCHANGE CENTER IS UNABLE TO PROGRAM THE ACTUAL MILEAGE ON THE ODOMETER OR THE ACTUAL MILEAGE IS ... Read More »
GMC: MALFUNCTION INDICATOR LAMP ON-CHECK ENGINE LIGHT; ENGINE CRANKS, DO NOT START, HARSH OR NO TRANSMISSION SHIFTS, INSTRUMENT CLUSTER OPERATION ERRATIC OR INOPERATIVE. *PE UPDATED 8/12/09. Read More »
SATURN\CHEVROLET SERVICE CAMPAIGN: SEE DOCUMENT SEARCH BUTTON FOR OWNER LETTER. LOSS OF HYBRID FUNCTION-REPLACE BATTERIES. THE HYBRID FUNCTION ON THESE VEHICLES MAY BECOME INOPERATIVE. Read More »
BUICK/CADILLAC/CHEVROLET/GMC/PONTIAC/SATURN: LOW BEAM HEADLAMP BULB DIAGNOSIS/REPLACEMENT (INSPECT BULB AND CONNECTOR). DOES NOT APPLY TO VEHICLES EQUIPPED WITH HIGH INTENSITY DISCHARGE (HID) LAMPS. Read More »
GM: LOW BEAM HEADLAMP BULB DIAGNOSIS/ REPLACEMENT (INSPECT BULB AND CONNECTOR). DO NOT REPLACE THE ENTIRE HEADLAMP ASSEMBLY FOR THIS CONDITION. REPLACE THE BULB AND INSPECT THE CONNECTOR. *JS UPDATED 4/7/15. Read More »
BUICK/CADILLAC/CHEVROLET/GMC/PONTIAC/SATURN: LOW BEAM HEADLAMP BULB DIAGNOSIS/REPLACEMENT (INSPECT BULB AND CONNECTOR). DOES NOT APPLY TO VEHICLES EQUIPPED WITH HIGH INTENSITY DISCHARGE (HID) LAMPS. Read More »
THIS PRELIMINARY INFORMATION COMMUNICATION ADVISES THE TECHNICIAN THE STEPS ON DIAGNOSING THE CONCERN. VEHICLE'S SUNROOF OPERATION INTERMITTENT, BIND, NOISE, AUTO-REVERSE, AND/OR WATER LEAKS. Read More »
THIS INFORMATIONAL BULLETIN PROVIDES INFORMATION ON A NORMAL CONDITION ON TEMPERED GLASS OF SPOTS SHOWING ON THE REAR AND SIDE WINDOWS WHEN THE VEHICLE IS IN THE SUNLIGHT. Read More »
GENERAL MOTORS: THE WINDOWS, FRONT AND REAR, WOULD BIND, POOR FIT, MISALIGNMENT, MAKES RATTLE OR SQUEAKING NOISES, MOVES SLOWLY AND IS INOPERATIVE. MODEL 2008-2014 VEHICLES AND TRUCKS. Read More »
THIS PRELIMINARY INFORMATION COMMUNICATION ADVISES THE TECHNICIAN THE STEPS ON DIAGNOSING THE CONCERN. VEHICLE'S SUNROOF OPERATION INTERMITTENT, BIND, NOISE, AUTO-REVERSE, AND/OR WATER LEAKS. Read More »
THIS PRELIMINARY INFORMATIONAL BULLETIN PROVIDES A PROCEDURE FOR RELEARNING THE POWER FOLDING MIRRIORS AND ROAD TESTIN TO VERIFY THEY CORRECT A CONDTION OF THE POWER FOLDING MIRRIORS GLASS SHAKES, FLUTTERS AT NORMAL DRIVING CONDITIONS. Read More »
GM: THERE ARE SEAT BELT PROBLEMS: DIFFICULTY LATCHING AND UNLATCHING BUCKLE. BUCKLE RELEASE BUTTON IS STICKING. SEAT BELT WARNING LIGHT ILLUMINATED. LIKELY CAUSED BY STICKY BEVERAGES THAT ARE SPILLED INTO THE BUCKLE ASSEMBLY. Read More »
GM: THERE ARE SEAT BELT PROBLEMS: DIFFICULTY LATCHING AND UNLATCHING BUCKLE. BUCKLE RELEASE BUTTON IS STICKING. SEAT BELT WARNING LIGHT ILLUMINATED. LIKELY CAUSED BY STICKY BEVERAGES THAT ARE SPILLED INTO THE BUCKLE ASSEMBLY. Read More »
THIS PRELIMINARY INFORMATIONAL BULLETIN PROVIDES A PROCEDURE FOR RELEARNING THE POWER FOLDING MIRRIORS AND ROAD TESTIN TO VERIFY THEY CORRECT A CONDTION OF THE POWER FOLDING MIRRIORS GLASS SHAKES, FLUTTERS AT NORMAL DRIVING CONDITIONS. Read More »
THIS PRELIMINARY INFORMATIONAL BULLETIN PROVIDES INFORMATION THAT MAY BE HELPFUL WHEN ADDRESSING UNDERBODY COMPONENT CORROSION WITH CUSTOMERS. Read More »
THIS PRELIMINARY INFORMATION COMMUNICATION ADVISES THE TECHNICIAN THE STEPS ON DIAGNOSING THE CONCERN. VEHICLE'S SUNROOF OPERATION INTERMITTENT, BIND, NOISE, AUTO-REVERSE, AND/OR WATER LEAKS. Read More »
GENERAL MOTORS: THE WINDOWS, FRONT AND REAR, WOULD BIND, POOR FIT, MISALIGNMENT, MAKES RATTLE OR SQUEAKING NOISES, MOVES SLOWLY AND IS INOPERATIVE. MODEL 2008-2014 VEHICLES AND TRUCKS. Read More »
GM: THE FRONT OR REAR DOOR MAY NOT OPEN FROM THE INSIDE OR OUTSIDE HANDLE, THE DOOR WILL NOT UNLOCK WITH ANY METHOD. THE PROBABLY CAUSE AN INCORRECT INSTALLATION OF A HANDLE COMPONENT. *RM UPDATED ON 7/26/2013. Read More »
PONTIAC/SATURN/CHEVROLET: SOME VEHICLES ARE EXPERIENCING MULTIPLE ISSUES/SYMPTOMS CAUSED BY BODY HARNESS HARD CONTACT AGAINST FLOOR EDGE PANEL UNDER LEFT REAR SEAT CUSHION. MODEL 2004-12 MALIBU, MALIBU MAXX, 2007-09 AURA, 2005-10 G6. Read More »
PONTIAC/SATURN/CHEVROLET: SOME VEHICLES ARE EXPERIENCING MULTIPLE ISSUES/SYMPTOMS CAUSED BY BODY HARNESS HARD CONTACT AGAINST FLOOR EDGE PANEL UNDER LEFT REAR SEAT CUSHION. MODEL 2004-12 MALIBU, MALIBU MAXX, 2007-09 AURA, 2005-10 G6. Read More »
THIS PRELIMINARY INFORMATIONAL BULLETIN PROVIDES INFORMATION THAT MAY BE HELPFUL WHEN ADDRESSING UNDERBODY COMPONENT CORROSION WITH CUSTOMERS. Read More »
THIS PRELIMINARY INFORMATION COMMUNICATION ADVISES THE TECHNICIAN THE STEPS ON DIAGNOSING THE CONCERN. VEHICLE'S SUNROOF OPERATION INTERMITTENT, BIND, NOISE, AUTO-REVERSE, AND/OR WATER LEAKS. Read More »
THIS PRELIMINARY INFORMATION COMMUNICATION PROVIDES INFORMATION TO THE TECHNICIAN ABOUT FINDING NEEDLE BEARINGS DURING AN OIL CHANGE. TECHNICIAN WILL GAIN ACCESS TO THE ROLLER ROCKERS TO INSPECT THEM. Read More »
THIS PRELIMINARY INFORMATION COMMUNICATION PROVIDES INFORMATION TO THE TECHNICIAN THAT AFTER REPLACING THE INSTRUMENT PANEL CLUSTER THE EXCHANGE CENTER IS UNABLE TO PROGRAM THE ACTUAL MILEAGE ON THE ODOMETER OR THE ACTUAL MILEAGE IS ... Read More »
THIS PRELIMINARY INFORMATIONAL BULLETIN PROVIDES A PROCEDURE FOR RELEARNING THE POWER FOLDING MIRRIORS AND ROAD TESTIN TO VERIFY THEY CORRECT A CONDTION OF THE POWER FOLDING MIRRIORS GLASS SHAKES, FLUTTERS AT NORMAL DRIVING CONDITIONS. Read More »
THIS PRELIMINARY INFORMATION COMMUNICATION ADVISES THE TECHNICIAN TO DIAGNOSE THE CONCERN AND THE STEPS TO REPAIR THE CONCERN. THE VEHICLE'S XM TRAVEL LINK MAY BE INOPERTIVE. Read More »
THIS PRELIMINARY INFORMATION COMMUNICATION ADVISES THE TECHNICIAN THE STEPS ON REPAIRING THE CONCERN. A CUSTOMER MAY IDENTIFY A CONCERN OF UNABLE TO REACTIVATE A VEHICLE'S ONSTAR THAT HAS BEEN PREVIOUSLY DISABLED BY ONSTAR. Read More »
THIS PRELIMINARY INFORMATION COMMUNICATION PROVIDES INFORMATION TO THE TECHNICIAN THE STEPS NEEDED TO DIAGNOSE AND REPAIR THE VEHICLES THAT MAY HAVE UNWANTED OR PHANTOM PHONE CALLS. Read More »
THIS TECHNICAL BULLETIN PROVIDES A PROCEDURE TO REPROGRAM THE MEDIA DISC PLAYER WITH THE LATEST CALIBRATIONS TO CORRECT A CONDITION OF THE REAR ENTERTAINMENT SYSTEM NOT OPERATING AS INTENDED IN COLDER AMBIENT TEMPERATURE AREAS DUE TO ... Read More »
THIS PRELIMINARY INFORMATION COMMUNICATION ADVISES THE TECHNICIAN ON THE STEPS TO DIAGNOSE AND REPAIR THE CONCERN. THE VEHICLE'S XM RADIO ONLY HAS XM PREVEIW CHANNELS. Read More »
"THIS TECHNICAL BULLETIN PROVIDES A PROCEDURE TO CONTACT ONSTAR FOR HARD MUTE REQUEST TO CORRECT A CUSTOMER CONCERN WHEN THE RADIO IS ON, IT DOES NOT MUTE ENOUGH WHEN THE ONSTAR? TURN-BY-TURN NAVIGATION DIRECTIONS ARE ANNOUNCED DUE TO ... Read More »
PONTIAC/SATURN/CHEVROLET: SOME VEHICLES ARE EXPERIENCING MULTIPLE ISSUES/SYMPTOMS CAUSED BY BODY HARNESS HARD CONTACT AGAINST FLOOR EDGE PANEL UNDER LEFT REAR SEAT CUSHION. MODEL 2004-12 MALIBU, MALIBU MAXX, 2007-09 AURA, 2005-10 G6. Read More »
THIS PRELIMINARY INFORMATIONAL BULLETIN PROVIDES A LIST OF CORRECTIONS FOR MULTIPLE CONCERNS REGARDING UNEXPECTED LOSS OF RADIO AUDIO (RADIO GOES SILENT/NO SOUND) AND OTHER BLACKBERRY PHONE - BLUETOOTH ... Read More »
THIS PRELIMINARY INFORMATION COMMUNICATION ADVISES THE TECHNICIAN ON THE STEPS TO DIAGNOSE AND REPAIR THE CONCERN OF RECEIVING FREQUENT "OFF ROUTE" MESSAGES WHILE FOLLOWING TURN BY TURN (TBT) ROUTE NAVIGATION. Read More »
THIS PRELIMINARY INFORMATION COMMUNICATION ADVISES THE TECHNICIAN ON THE STEPS TO DIAGNOSE AND REPAIR THE CONCERN OF RECEIVING FREQUENT "OFF ROUTE" MESSAGES WHILE FOLLOWING TURN BY TURN (TBT) ROUTE NAVIGATION. Read More »
THIS PRELIMINARY INFORMATION COMMUNICATION ADVISES THE TECHNICIAN IF UNABLE TO PLACE AN ONSTAR CALL IN THE IGNITION ON MODE AFTER THE ONSTAR CANADA UPGRADE, TO CONTACT THE GM TECHNICAL ASSISTANCE CENTER ONSTAR GROUP FOR FURTHER ASSISTANCE. Read More »
"THIS TECHNICAL BULLETIN PROVIDES A PROCEDURE TO CONTACT ONSTAR FOR HARD MUTE REQUEST TO CORRECT A CUSTOMER CONCERN WHEN THE RADIO IS ON, IT DOES NOT MUTE ENOUGH WHEN THE ONSTAR? TURN-BY-TURN NAVIGATION DIRECTIONS ARE ANNOUNCED DUE TO ... Read More »
THIS PRELIMINARY INFORMATION COMMUNICATION ADVISES THE TECHNICIAN ON THE STEPS FOR DIAGNOSING THE CONCERN. THE VEHICLE MAY BE UNABLE TO CONNECT TO ONSTAR USING THE WHITE, BLUE OR RED ONSTAR BUTTONS. Read More »
THIS PRELIMINARY INFORMATION COMMUNICATION ADVISES THE TECHNICIAN, IF UNABLE TO PLACE AN ONSTAR CALL IN THE IGNITION ON MODE AFTER THE ONSTAR CANADA UPGRADE TO CONTACT THE GM TECHNICAL ASSISTANCE CENTER ONSTAR GROUP FOR FURTHER ASSISTANCE. Read More »
THIS PRELIMINARY INFORMATION COMMUNICATION PROVIDES INFORMATION TO THE TECHNICIAN THAT GENERAL MOTORS AND GENERAL MOTORS OF CANADA COMPANY DO NOT SUPPORT CROSS BORDER SALES. Read More »
THIS WARRANTY ADMINISTRATION BULLETIN PROVIDE POLICY ON PERFORMING GM COVERED VEHICLE SERVICES AND MAINTENANCE ON VEHICLES ORIGINATING/SOLD IN CANADA. Read More »
THIS WARRANTY ADMINISTRATION BULLETIN PROVIDE POLICY INFORMATION ON USING THE EL-50313 MIDTRONICS GR8 BATTERY TESTER/CHARGER FOR DIAGNOSING BATTERY REPLACEMENTS AND MAINTAINING BATTERIES ON NEW VEHICLES IN DEALER INVENTORY. Read More »
THIS WARRANTY ADMINISTRATION BULLETIN PROVIDES INFORMATION ON GM?S POLICY ON PERFORMING GM COVERED VEHICLE SERVICES AND MAINTENANCE ON VEHICLES ORIGINATING/SOLD IN CANADA. Read More »
CADILLAC/BUICK/SATURN/PONTIAC/CHEVROLET/ GMC: DUE TO AN ABNORMAL ENGINE NOISE OR INTERNAL BY AN OIL FILTER MISAPPLICATION, FILTER DEBRIS MAY BE TRANSFERRED THROUGHOUT ENGINE AND MAY RESULT IN ENGINE DAMAGE. Read More »
SATURN/PONTIAC/CHEVROLET: THE HVAC BLOWER MOTOR IS BEING NOISY OR INOPERATIVE. IF VEHICLE HAS ENCOUNTERED THE LISTED CONDITION, EVALUATE THE VEHICLE FOR THE FOLLOWING CONDITIONS. DOCUMENT THE EVALUATION RESULTS ON REPAIR ORDER. Read More »
