Technical Service Bulletins (TSBs) for the 2011 Touareg are official communications between Volkswagen & their dealerships that describe processes for troubleshooting or fixing certain common problems.
All vehicle manufacturers are required by U.S. law to make their TSBs available to the public.
MIL-ON, FAULT P309F OR P309D, NO ELECTRIC DRIVE MODE CUSTOMER STATES CRANK NO START AND/OR IN-TANK FUEL PUMP MAKING NOISE AND POSSIBLY WITH FUEL PUMP FAULTS MIL-ON, FAULT P013E IN THE ECM MIL-ON, FAULT P164B IN ECM MIL-ON, ... Read More »
Technical Bulletin (Squeaking Noises From Front Of Vehicle): Squeaking/creaking noise from front of vehicle while fully turning steering wheel. Read More »
Technical Bulletin: Vibrations in Steering Wheel issues Document discusses diagnosis of problem, and potential remedy of issue. The diagnosis codes for checking warranty coverage for servicing the vehicle are also available. Read More »
Technical Bulletin (Vibrations in Steering Wheel): After a short stationary period (sometimes as little as a few hours) flat spots can develop after the warm tire has cooled down. Read More »
Technical Bulletin (Power Steering Rack Vibrations in Steering Wheel): This document informs that After a short stationary period (sometimes as little as a few hours) flat spots can develop after the warm tire has cooled down. Read More »
Tech Tips (Vibration or Steering Wheel Shimmy at Highway Speeds): The suspension characteristics of the Touareg make it more susceptible to variations in the rim and/or tire. Read More »
Technical Bulletin (Vibrations in Steering Wheel): After a short stationary period (sometimes as little as a few hours) flat spots can develop after the warm tire has cooled down. Read More »
MIL-ON, FAULT P309F OR P309D, NO ELECTRIC DRIVE MODE CUSTOMER STATES CRANK NO START AND/OR IN-TANK FUEL PUMP MAKING NOISE AND POSSIBLY WITH FUEL PUMP FAULTS MIL-ON, FAULT P013E IN THE ECM MIL-ON, FAULT P164B IN ECM MIL-ON, ... Read More »
MIL-ON, FAULT P309F OR P309D, NO ELECTRIC DRIVE MODE CUSTOMER STATES CRANK NO START AND/OR IN-TANK FUEL PUMP MAKING NOISE AND POSSIBLY WITH FUEL PUMP FAULTS MIL-ON, FAULT P013E IN THE ECM MIL-ON, FAULT P164B IN ECM MIL-ON, ... Read More »
Tech Tips (Vibration or Steering Wheel Shimmy at Highway Speeds): The suspension characteristics of the Touareg make it more susceptible to variations in the rim and/or tire. Read More »
Tech Tips (Vibration or Steering Wheel Shimmy at Highway Speeds): The suspension characteristics of the Touareg make it more susceptible to variations in the rim and/or tire. Read More »
Tech Tips (Vibration or Steering Wheel Shimmy at Highway Speeds): The suspension characteristics of the Touareg make it more susceptible to variations in the rim and/or tire. Read More »
Technical Bulletin (Vibrations in Steering Wheel): After a short stationary period (sometimes as little as a few hours) flat spots can develop after the warm tire has cooled down. Read More »
VOLKSWAGEN: SEE DOCUMENT SEARCH BUTTON FOR OWNER LETTER. INFORMATION IN OWNER'S MANUAL REGARDING THE ISSUE OF ELECTRONIC PARKING BRAKE. MODEL 2011-2012 TOUAREG. *PE Read More »
VOLKSWAGEN: SEE DOCUMENT SEARCH BUTTON FOR OWNER LETTER. INFORMATION IN OWNER'S MANUAL REGARDING THE ISSUE OF ELECTRONIC PARKING BRAKE. MODEL 2011-2012 TOUAREG. *PE Read More »
If mechanical damage is found to the turbocharger (e.g. damaged compression wheel, loose or broken shaft), it is not enough to just replace the turbocharger. Read More »
MIL-ON, FAULT P309F OR P309D, NO ELECTRIC DRIVE MODE CUSTOMER STATES CRANK NO START AND/OR IN-TANK FUEL PUMP MAKING NOISE AND POSSIBLY WITH FUEL PUMP FAULTS MIL-ON, FAULT P013E IN THE ECM MIL-ON, FAULT P164B IN ECM MIL-ON, ... Read More »
MIL-ON, FAULT P309F OR P309D, NO ELECTRIC DRIVE MODE CUSTOMER STATES CRANK NO START AND/OR IN-TANK FUEL PUMP MAKING NOISE AND POSSIBLY WITH FUEL PUMP FAULTS MIL-ON, FAULT P013E IN THE ECM MIL-ON, FAULT P164B IN ECM MIL-ON, ... Read More »
Technical Bulletin (Washer Level Sensor issues): The sensitivity of the washer solvent level sensor (G33) can be affected by the type, concentration, and the presence of additives in the washer solvent currently in the tank. Read More »
Technical Bulletin: High Pressure Fuel Pump Diagnosis. Completing the GFF high pressure pump function test is essential to diagnose proper pump operation and to avoid unnecessary replacements. Read More »
Technical Bulletin (High Pressure Fuel Pump Diagnosis): Completing the GFF high pressure pump function test is essential to diagnose proper pump operation and to avoid unnecessary replacements Read More »
Technical Bulletin (Fuel Additive to Help Prevent Sporadic Misfire Faults): Fuel quality impacts the operating performance, efficiency and service life of the engine. Read More »
Technical Bulletin (Engine Oils Which Meet Volkswagen Oil Quality Standard): This document informs of a sample list of products generally available in the North American market that meet the Volkswagen Oil Quality ... Read More »
When diagnosis on the above engine leads to the testing of the N75, please refer to the picture below. The diagram shows which vacuum ports on the N75 valve should hold vacuum and which ones should not. Read More »
Technical Bulletin (Oil Consumption Measurement): Customer states oil consumption is higher than the Volkswagen oil consumption standard of up to 0.5 quarts per 600 miles, or 0.5 liters per 1000 km. Read More »
Technical Bulletin The use of contaminated gasoline, seasonal fuel changes (summer/winter fuel) or gasoline with a low content of deposit control additives may result in one or more of the following conditions: -Excessive accumulation ... Read More »
Technical Bulletin (Proper Removal of Engine Cover to Avoid Breakage): Pulling on the engine cover in some areas can cause damage. This document informs on the procedure to remove the engine cover. Read More »
Technical Bulletin (Oil Consumption Measurement): Customers have stated oil consumption is higher than the Volkswagen oil consumption standard of up to 0.5 quarts per 600 miles, or 0.5 liters per 1000 km. Read More »
VOLKSWAGEN: SEE DOCUMENT SEARCH BUTTON FOR OWNER LETTER. CORROSION FORMING IN DIFFERENTIAL PRESSURE SENSOR CAUSING MALFUNCTION INDICATOR LIGHT (MIL) TO COME ON AND AN ISSUE WITH ENGINE CONTROL MODULE (ECM) SOFTWARE. Read More »
VOLKSWAGEN: ACTIVATED CHARCOAL FILTER SYSTEM, SOLENOID VALVE AND PERFORMING GFF FUNCTION TEST A VACUUM CHECK ON CANISTER PURGE VALVE N80 ARE ESSENTIAL TO DIAGNOSE PROPER OPERATION. MODEL 2009-14 ALL BUT ROUTAN. Read More »
In SAGA, the time units for the Volkswagen DoubleCheck labor operation were reduced in error from 50 time units to 30 time units during the system update posted on July 4th. Read More »
VOLKSWAGEN: DUE TO THE DIAGNOSTIC STRATEGY BEING TOO SENSITIVE, AND FAULT CODES STORED IN ECM MEMORY, SOFTWARE FOR ECM NEEDS IMPROVING. MODELS 2011-2012 TOUAREG. *PE Read More »
Engine Control Module Updates: This document informs of complaints, and the software updates / Tech Bulletins associated with servicing engine control module issues: Read More »
Engine Control Module Updates: This document informs of complaints, and the software updates/Tech Bulletins associated with servicing engine control module issues: Read More »
UPDATE Technical Bulletin (UPDATE ? 23K9 Touareg TDI Software): This UPDATE installs new ECM/EDC software to prevent a false illumination of the check engine light. Read More »
VOLKSWAGEN DEALERSHIP COMMUNICATION (UPDATE 23K9 TDI Software): Volkswagen informs dealers on an upcomming update necessary to address an impendending issue. Read More »
VOLKSWAGEN: ALL MODELS EXPERIENCE THE TIMING CHAIN SLIPPING, RATTLING NOISES OF THE ENGINE AFTER STARTING, AND ENGINE FAILS TO START. 2008-13 ALL MODELS. *PE Read More »
17 17 01 July 5, 2017 2012855 Supersedes Technical Bulletin 17-16-02 (V171602) dated April 29, 2016 due to updated oil standards lists to current specifications. Read More »
Technical Bulletin (Intake manifold runner position sensor issues): This document informs what repairs are needed to fix the issue. This document contains the fault codes necessary to check the warranty coverage for servicing this issue. Read More »
Technical Bulletin (Air Conditioning, Cleaning of the Refrigerant Circuit (U.S.Only)): In cases where an air conditioning system component (such as a compressor or other system component) has failed and debris from the compressor or ... Read More »
Technical Bulletin (Electric Coolant Fans Continue to Run after Ignition is Switched OFF): This documentation informs it is considered normal operation for the electric coolant fans to continue to run for up to 15 minutes after the ... Read More »
For an upcoming campaign that will include all MY09-14 TDI (CBEA/CJAA) vehicles, we need to test the SVM3339 code in 200 vehicles of various model-years and engine/transmission combinations. Read More »
Technical Bulletin (Rattling Noises from Engine Compartment Area or Exhaust System): Customers may complain of a rattling noise from engine or exhaust area while accelerating from 1800-3000 RPM. Read More »
Tech Tips (3.6L ? MIL ON with DTCs P2400, P2404): This document informs for concerns of MIL ON and P2400/P2404. This can be caused by the change over valve on the water pump. Read More »
Tech Tips (3.6L ? MIL ON with DTCs P2400, P2404): This document informs for concerns of MIL ON and P2400/P2404. This can be caused by the change over valve on the water pump. Read More »
Technical Bulletin (Electric Coolant Fans Continue to Run after Ignition is Switched OFF): This document informs it is considered normal operation for the electric coolant fans to continue to run for up to 15 minutes after the ignition ... Read More »
Technical Bulletin (Electric Coolant Fans Continue to Run after Ignition is Switched OFF): This document informs it is considered normal operation for the electric coolant fans to continue to run for up to 15 minutes after the ignition ... Read More »
Technical Bulletin (Oil Consumption Measurement): Customers have stated oil consumption is higher than the Volkswagen oil consumption standard of up to 0.5 quarts per 600 miles, or 0.5 liters per 1000 km. Read More »
Technical Bulletin (Cold Start - Rough Idle Concern): This document informs that customers may complain of a rough running condition that occurs during cold start. The production solution for this issue was improved software. Read More »
Technical Bulletin (Oil Consumption Measurement): Customer states oil consumption is higher than the Volkswagen oil consumption standard of up to 0.5 quarts per 600 miles, or 0.5 liters per 1000 km. Read More »
After a cold start, the engine coolant temperature gauge will slowly rise to approximately 190? F. When the F265 mapped thermostat opens, the gauge may drop by approximately 60? F before again rising to 190? F. Read More »
When servicing the timing chain sprocket or removing the vibration damper, be aware that one bolt holds both the vibration damper (harmonic balancer) and the crankshaft timing chain sprocket to the crankshaft. Read More »
Technical Bulletin (TDI Clean Diesel I/M (Inspection Maintenance) Testing Issues due to Readiness Not Set): Some readiness codes on TDI clean diesel vehicles require special driving conditions to be set. Read More »
VOLKSWAGEN: CERTAIN MODEL YEAR VEHICLES ARE EXPERIENCING ENGINE NOT STARTING, MAKING A RATTLING NOISE WHEN ENGINE HAS STARTED, TIMING CHAIN KEEPS SLIPPING AND EXHAUST LIGHT COMES ON. *PE Read More »
MIL-ON, FAULT P309F OR P309D, NO ELECTRIC DRIVE MODE CUSTOMER STATES CRANK NO START AND/OR IN-TANK FUEL PUMP MAKING NOISE AND POSSIBLY WITH FUEL PUMP FAULTS MIL-ON, FAULT P013E IN THE ECM MIL-ON, FAULT P164B IN ECM MIL-ON, ... Read More »
Tech Tips (Equipped with Turbocharged Engine Turbocharger Replacement Tip): If mechanical damage is found to the turbocharger (e.g. damaged compression wheel, loose or broken shaft), it is not enough to just replace the turbocharger. Read More »
VOLKSWAGEN: MALFUNCTION INDICATOR LAMP (MIL) IS ON AND ROUGH RUNNING, AND FAILS TO START ON SOME VEHICLES, NO ROOT CAUSE FOUND, CHECK FOR METALLIC PARTICLES IN HIGH PRESSURE FUEL PUMP. MODEL 2009-12 TOUAREG, PASSAT. Read More »
Technical Bulletin (TDI Clean Diesel I/M (Inspection Maintenance) Testing Issues due to Readiness Not Set): Some readiness codes on TDI clean diesel vehicles require special driving conditions to be set. Read More »
ENGINE AND ENGINE COOLING:ENGINE:OTHER FUEL TYPES:TURBO/SUPERCHARGER
Technical Bulletin (No Start, or Rough Running due to Fuel Rail issues): When diagnosing the condition above on a common rail diesel vehicle, if no root cause is found after checking all other components and all GFF diagnostic ... Read More »
Technical Bulletin (No Start, or Rough Running issues): When diagnosing a MIL ON, no-start or rough running concern on a common rail diesel vehicle, and no root cause is found after following all GFF diagnostic procedures, it may be ... Read More »
Technical Bulletin (Fuel Additive to Help Prevent Sporadic Misfire Faults): Fuel quality impacts the operating performance, efficiency and service life of the engine. Read More »
When diagnosing a vehicle concern, and fault P130A ?Hide Cylinder? is found in the Engine Control Module (ECM), be aware that Engine Control Module (ECM) fault P130A ?Hide Cylinder? indicates a cylinder shut down and does not require ... Read More »
To clear static ECM fault P1250 ?Fuel Level Too Low?, add fuel to vehicle and complete a road test of at least 10 miles. Simply adding fuel without completing a road test may not allow fault to clear. Read More »
To clear static ECM fault P1250 ?Fuel Level Too Low?, add fuel to vehicle and complete a road test of at least 10 miles. Simply adding fuel without completing a road test may not allow fault to clear. Read More »
It is recommended to perform the EVAP tank leak test on V6 equipped Touareg through Control Module OBD. The test can be selected from the basic settings selection under the ECM address 01. Read More »
ENGINE AND ENGINE COOLING:ENGINE:ENGINE CONTROL MODULE (ECU/ECM):SOFTWARE
This special notice is to inform dealers to return all part numbers listed in the document. Only superseded part numbers to be ordered going forward. Read More »
Technical Bulletin (Rattling Noises from Engine Compartment Area or Exhaust System): Customers may complain of a rattling noise from engine or exhaust area while accelerating from 1800-3000 RPM. Read More »
Technical Bulletin Activated Charcoal Filter System, Solenoid Valve 1 -N80- (Canister Purge Valve) Diagnosis): Completing the GFF function test and performing a vacuum check on the Canister Purge Valve -N80- are essential to diagnose ... Read More »
This Document informs dealers on the Revised VWC-17-11 - REVISED - Pre-existing MIL-On Condition in Regards to the TDI AEM Recalls for Customer Vehicles (Revised 12/17/18). Gen 1 and Gen 3 2.0L TDI no longer apply. Read More »
VOLKSWAGEN:EVAPORATIVE (EVAP) EMISSION SYSTEM, DIAGNOSTIC TROUBLE CODE DIAGNOSIS. REVISED PROCEDURE DEVELOPED TO TEST EVAP SYSTEM WITHOUT FUEL CAP. *JS Read More »
This Document informs dealers on the Revised VWC-17-11 - REVISED - Pre-existing MIL-On Condition in Regards to the TDI AEM Recalls for Customer Vehicles (Revised 12/17/18). Gen 1, Gen 2 and Gen 3 2.0L TDI no longer apply. Read More »
This special notice is to inform dealers to return all part numbers listed in the document. Only superseded part numbers to be ordered going forward. Read More »
ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:MANIFOLD/HEADER/MUFFLER/TAIL PIPE
Update to existing Tech Tip to address correct octane usage by model year and fuel quality that effect cold start performance. Update model year applicability and add DTC P13EA Read More »
Technical Bulletin: High Pressure Fuel Pump Diagnosis. Completing the GFF high pressure pump function test is essential to diagnose proper pump operation and to avoid unnecessary replacements. Read More »
Technical Bulletin (High Pressure Fuel Pump Diagnosis): Completing the GFF high pressure pump function test is essential to diagnose proper pump operation and to avoid unnecessary replacements Read More »
Because Volkswagen supports the development and use of renewable fuels (such as biodiesel fuel blends), customers with certain 2009-2015 MY Volkswagen TDI? Clean Diesel Engine vehicles registered in the State of Minnesota only will ... Read More »
Carefree Maintenance Coverage for Interim Oil Changes for Certain 2009 ? 2015 MY Volkswagen TDI? Clean Diesel Engine Vehicles Registered in the State of Minnesota Only (US Dealers Read More »
Tech Tips (V6 3.6L-Evap Tank Leak Test): It is recommended to perform the EVAP tank leak test on V6 equipped Touareg through Control Module OBD. The test can be selected from the basic settings selection under the ECM address 01. Read More »
Tech Tips (Adapting Injector Quantity adjustment correction values (IMA/IVA)): When replacing or adapting fuel injectors, if there is no Guided Functions Test Plan, utilize this documents procedure Read More »
When replacing or adapting fuel injectors, if there is no Guided Functions Test Plan, utilize the following :UDS vehicles: Go to Guided Functions / Adapting Injector Quantity Adjustment correct values (IMA-IVA). Read More »
Technical Bulletin (High Pressure Fuel Pump Diagnosis): Completing the GFF high pressure pump function test is essential to diagnose proper pump operation and to avoid unnecessary replacements. Read More »
It is recommended to perform the EVAP tank leak test on V6 equipped Touareg through Control Module OBD. The test can be selected from the basic settings selection under the ECM address 01. Read More »
When the RNS 850 system is in 3D mode, the top portion of the screen will not display streets. This line represents the horizon and is a normal operation of system. No repairs should be made. Read More »
When the Navigation RNS 850/510/315 is in 3D mode, the top portion of the screen may not display streets. This line represents the horizon and is a normal operation of system. No repairs should be made. Read More »
It is recommended to perform the EVAP tank leak test on V6 equipped Touareg through Control Module OBD. The test can be selected from the basic settings selection under the ECM address 01. Read More »
MIL-ON, FAULT P309F OR P309D, NO ELECTRIC DRIVE MODE CUSTOMER STATES CRANK NO START AND/OR IN-TANK FUEL PUMP MAKING NOISE AND POSSIBLY WITH FUEL PUMP FAULTS MIL-ON, FAULT P013E IN THE ECM MIL-ON, FAULT P164B IN ECM MIL-ON, ... Read More »
MIL-ON, FAULT P309F OR P309D, NO ELECTRIC DRIVE MODE CUSTOMER STATES CRANK NO START AND/OR IN-TANK FUEL PUMP MAKING NOISE AND POSSIBLY WITH FUEL PUMP FAULTS MIL-ON, FAULT P013E IN THE ECM MIL-ON, FAULT P164B IN ECM MIL-ON, ... Read More »
VOLKSWAGEN: ON SOME VEHICLES, LOW FUEL STORED IN ECM PRESSURE, ENGINE WOULD CRANK BUT NOT START LONG PERIODS WITHOUT DRIVING, MAY RUN ROUGH AND/OR MIL ON. ALL MODELS 2008-2013. *PE Read More »
FUEL SYSTEM, GASOLINE:DELIVERY:HOSES, LINES/PIPING, AND FITTINGS
Fuel Additive to Help Prevent Sporadic Misfire Faults A Volkswagen approved fuel additive is available to help remove and prevent deposits on fuel injectors and intake valves. Read More »
Tech Tips (Adapting Injector Quantity adjustment correction values (IMA/IVA)): When replacing or adapting fuel injectors, if there is no Guided Functions Test Plan, utilize this documents procedure Read More »
This document informs dealers of the Extended Emissions Warranty Limited Warranty Extension for 3.0L TDI Gen 1.2 vehicles. Added clarification on totaled vehicles and loaners. Read More »
Technical Bulletin (Fuel Rail/System issues): When diagnosing the condition above on a common rail diesel vehicle, if no root cause is found after checking all other components and all GFF diagnostic procedures have been performed, it ... Read More »
Technical Bulletin (Fuel Rail/System Pressure, and Fuel Rail Pressure Sensor issues): When diagnosing the condition above on a common rail diesel vehicle, if no root cause is found after checking all other components and all GFF ... Read More »
Technical Bulletin (TDI Clean Diesel I/M (Inspection Maintenance) Testing Issues due to Readiness Not Set): A Volkswagen TDI clean diesel is not ready for I/M (Inspection Maintenance) testing due to readiness codes not being fully set. Read More »
Warranty Extension for High-Pressure Fuel Pump: Volkswagen informed customers of a decision to extend the warranty for the high-pressure fuel pump (HPFP) in the TDI? Clean Diesel engine vehicle under specific conditions to 10 years or ... Read More »
Warranty Extension for High-Pressure Fuel Pump Certain 2009-2012 Model Year Volkswagen Touareg TDI? Clean Diesel Engine Vehicles & Certain 2012 Model Year Volkswagen Passat TDI? Clean Diesel Engine Vehicles. Read More »
Technical Bulletin (No Start, or Rough Running issues): When diagnosing the condition(No Start, or Rough Running) on a common rail diesel vehicle, if no root cause is found after checking all other components and all GFF diagnostic ... Read More »
VOLKSWAGEN DEALERSHIP COMMUNICATION: This document announced a warranty Volkswagen extension program to cover the High Pressure Fuel Pump on 2009-2012 model year TDI Clean Diesel Engine vehicles. Read More »
VOLKSWAGEN DEALERSHIP COMMUNICATION: Volkswagen announced a warranty extension program to cover the High Pressure Fuel Pump on 2009-2012 model year TDI Clean Diesel Engine vehicles Read More »
2009-2015 Model Year Volkswagen TDI? Clean Diesel Vehicles Registered in Minnesota Engine Codes CBEA, CJAA, CKRA, CATA, CNRB Using Biodiesel Blend Fuels: Biodiesel is a domestically produced, clean-burning and renewable partial ... Read More »
Upcoming Communication to Owners of 2009-2015 MY Volkswagen TDI Clean Diesel Engine Vehicles Registered in the State of Minnesota Engine Codes CBEA, CJAA, CKRA, CATA, CNRB Using Biodiesel Fuel Blends: This document informs that Due to ... Read More »
Because Volkswagen supports the development and use of renewable fuels (such as biodiesel fuel blends), customers with certain 2009-2015 MY Volkswagen TDI? Clean Diesel Engine vehicles registered in the State of Minnesota only will ... Read More »
Carefree Maintenance Coverage for Interim Oil Changes for Certain 2009 ? 2015 MY Volkswagen TDI? Clean Diesel Engine Vehicles Registered in the State of Minnesota Only (US Dealers Read More »
Technical Bulletin (TDI Clean Diesel I/M (Inspection Maintenance) Testing Issues due to Readiness Not Set): Some readiness codes on TDI clean diesel vehicles require special driving conditions to be set. Read More »
Tech Tips (Touareg - 3.0L TDI Ad Blue Reset Procedure): this document informs how To reset the Ad Blue level light after the tank has been filled, and if that is not successful Read More »
To clear static ECM fault P1250 ?Fuel Level Too Low?, add fuel to vehicle and complete a road test of at least 10 miles. Simply adding fuel without completing a road test may not allow fault to clear. Read More »
To clear static ECM fault P1250 ?Fuel Level Too Low?, add fuel to vehicle and complete a road test of at least 10 miles. Simply adding fuel without completing a road test may not allow fault to clear. Read More »
VOLKSWAGEN DEALERSHIP COMMUNICATION (Upcoming Communication to Owners of 2009-2013 MY Volkswagen TDI Clean Diesel Engine Vehicles Registered in the State of Illinois - Using Biodiesel Fuel Blends): Due to Illinois state tax incentives ... Read More »
MIL-ON, FAULT P309F OR P309D, NO ELECTRIC DRIVE MODE CUSTOMER STATES CRANK NO START AND/OR IN-TANK FUEL PUMP MAKING NOISE AND POSSIBLY WITH FUEL PUMP FAULTS MIL-ON, FAULT P013E IN THE ECM MIL-ON, FAULT P164B IN ECM MIL-ON, ... Read More »
MIL-ON, FAULT P309F OR P309D, NO ELECTRIC DRIVE MODE CUSTOMER STATES CRANK NO START AND/OR IN-TANK FUEL PUMP MAKING NOISE AND POSSIBLY WITH FUEL PUMP FAULTS MIL-ON, FAULT P013E IN THE ECM MIL-ON, FAULT P164B IN ECM MIL-ON, ... Read More »
Tech Tips (ECM Fault P1250 "Fuel Level Too Low" Will Not Clear): This document informs to clear static ECM fault P1250 "Fuel Level Too Low", add fuel to vehicle and complete a road test of at least 10 miles. Read More »
VOLKSWAGEN: TSB CONTAINS AN OWNER'S NOTIFICATION LETTER. SEE DOCUMENT SEARCH BUTTON BELOW. ON CERTAIN VEHICLES, A WARRANTY EXTENSION HAS BEEN ISSUED FOR HIGH PRESSURE FUEL PUMP. MODEL 2009-12 TOUAREG, 2012 PASSAT. Read More »
VOLKSWAGEN: ON SOME VEHICLES, LOW FUEL STORED IN ECM PRESSURE, ENGINE WOULD CRANK BUT NOT START LONG PERIODS WITHOUT DRIVING, MAY RUN ROUGH AND/OR MIL ON. ALL MODELS 2008-2013. *PE Read More »
Incorrect torque converter or flywheel/flexplate installation can result in transmission damage. When installing an engine, flywheel or transmission, please follow the installation procedures outlined in ELSA. Read More »
For an upcoming campaign that will include all MY09-14 TDI (CBEA/CJAA) vehicles, we need to test the SVM3339 code in 200 vehicles of various model-years and engine/transmission combinations. Read More »
This bulletin provides a procedure to determine ?repair? versus ?replacement? of an automatic transmission. This procedure is to be used ?After? the transmission has been removed from the vehicle. Read More »
Technical Bulletin (Automatic Transmission Fluid Requirements): At this time, Volkswagen Group of America, Volkswagen Canada do not support or warranty any use of aftermarket universal automatic transmission fluids or the machines used ... Read More »
When servicing the timing chain sprocket or removing the vibration damper, be aware that one bolt holds both the vibration damper (harmonic balancer) and the crankshaft timing chain sprocket to the crankshaft. Read More »
Technical Bulletin (Slave Cylinder - Clutch Pedal Operation Diagnosis): A Customer may comment: ? Complaints on clutch system. ? After pressing the clutch pedal, it remains on the floor. Read More »
Technical Bulletin (High-voltage repairs on Hybrid and Electric vehicles): High Voltage topics are very diverse and latest information is changing regularly. Therefore, they need to be addressed on a case-by-case basis. Read More »
Technical Bulletin (Slave Cylinder - Clutch Pedal Operation Diagnosis): Customer may comment: ? Complaints on clutch system. ? After pressing the clutch pedal, it remains on the floor. Read More »
MIL-ON, FAULT P309F OR P309D, NO ELECTRIC DRIVE MODE CUSTOMER STATES CRANK NO START AND/OR IN-TANK FUEL PUMP MAKING NOISE AND POSSIBLY WITH FUEL PUMP FAULTS MIL-ON, FAULT P013E IN THE ECM MIL-ON, FAULT P164B IN ECM MIL-ON, ... Read More »
MIL-ON, FAULT P309F OR P309D, NO ELECTRIC DRIVE MODE CUSTOMER STATES CRANK NO START AND/OR IN-TANK FUEL PUMP MAKING NOISE AND POSSIBLY WITH FUEL PUMP FAULTS MIL-ON, FAULT P013E IN THE ECM MIL-ON, FAULT P164B IN ECM MIL-ON, ... Read More »
Technical Bulletin (Slave Cylinder - Clutch Pedal Operation Diagnosis): A Customer may comment: ? Complaints on clutch system. ? After pressing the clutch pedal, it remains on the floor. Read More »
This document was created In response to multiple dealership inquires about aftermarket universal (one fluid fits all) automatic transmission fluids and transmission flushing, Volkswagen Group of America, Volkswagen Canada have prepared ... Read More »
Technical Bulletin (Automatic Transmission Fluid Requirements): At this time, Volkswagen Group of America, Volkswagen Canada do not support or warranty any use of aftermarket universal automatic transmission fluids or the machines used ... Read More »
POWER TRAIN:AUTOMATIC TRANSMISSION:CONTROL MODULE (TCM/PCM/TECM)
Tech Tips (Torque Converter/Flywheel/Flexplate installation): Incorrect torque converter or flywheel/flexplate installation can result in transmission damage. Read More »
TECH TIP DENOTING POTENTIAL FOR DAMAGE OF THE DATA LINK CONNECTOR WHEN USING AFTER MARKET PLUG IN DEVICES OR SCAN TOOLS AND SUBSEQUENT DIAGNOSTIC DIRECTION. Read More »
Technical Bulletin (Engine, Misfire Diagnostic Aid): This document informs that Multiple components SHOULD NOT be replaced for 1 misfiring cylinder. Repeat repairs must be carefully addressed to identify the root cause of the concern. Read More »
Technical Bulletin: High Pressure Fuel Pump Diagnosis. Completing the GFF high pressure pump function test is essential to diagnose proper pump operation and to avoid unnecessary replacements. Read More »
Technical Bulletin (TDI Clean Diesel I/M (Inspection Maintenance) Testing Issues due to Readiness Not Set): A Volkswagen TDI clean diesel is not ready for I/M (Inspection Maintenance) testing due to readiness codes not being fully set. Read More »
Technical Bulletin (Selective Catalyst Reduction (SCR) heater electronics being ) contaminated with Ad Blue): This document informs what repairs are needed to fix the issue. Read More »
Technical Bulletin (No Start, or Rough Running issues): When diagnosing the condition(No Start, or Rough Running) on a common rail diesel vehicle, if no root cause is found after checking all other components and all GFF diagnostic ... Read More »
Tech Tips (Heated Rear Window, One or More Lines Inoperative): To detect which line(s) is inoperative, utilize a volt meter to check for 0 V, which will be present after the open in the grid line. Read More »
Technical Bulletin (High Pressure Fuel Pump Diagnosis): Completing the GFF high pressure pump function test is essential to diagnose proper pump operation and to avoid unnecessary replacements Read More »
Technical Bulletin (P2014 or P2015 Intake Manifold Faults Stored in ECM Fault Memory ): Document discusses diagnosis Codes necessary to diagnosis, and potential remedy of issue. Read More »
After replacement of the Driver seat control module (J810) the vehicle may not recognize the new module. The adaptation test plan may not set the seat module location properly and it may display as a passenger seat control module. Read More »
When performing SVM updates, the scan tool should be hardwired to the vehicle and the Bluetooth physically turned off. A hard wired internet connection is also recommended. Read More »
Technical Bulletin (Vibrations in Steering Wheel): After a short stationary period (sometimes as little as a few hours) flat spots can develop after the warm tire has cooled down. Read More »
Technical Bulletin (Electric Coolant Fans Continue to Run after Ignition is Switched OFF): This documentation informs it is considered normal operation for the electric coolant fans to continue to run for up to 15 minutes after the ... Read More »
Tech Tips (Comfort Module (J393) or BCM (J519) Replacement): This document informs if a comfort or body control module is replaced during normal diagnosis, make sure the factory mode has been switched OFF. Read More »
The DLC is intended for use with diagnostic scan tools and by emissions testing stations. However, aftermarket devices (i.e., drive data recorders) that connect to the DLC have now become available. Read More »
Technical Bulletin (Power Steering Rack Vibrations in Steering Wheel): This document informs that After a short stationary period (sometimes as little as a few hours) flat spots can develop after the warm tire has cooled down. Read More »
Tech Tips (Comfort Module (J393) or BCM (J519) Replacement): This document informs If a comfort or body control module is replaced during normal diagnosis, make sure the factory mode has been switched OFF. Read More »
Tech Tips (V6 3.6L-Evap Tank Leak Test): It is recommended to perform the EVAP tank leak test on V6 equipped Touareg through Control Module OBD. The test can be selected from the basic settings selection under the ECM address 01. Read More »
Tech Tips (Engine Control Module Fault P130A ?Hide Cylinder?): This document informs that DTC P130A ?Hide Cylinder? indicates that excessive misfiring has occurred. Read More »
Tech Tips (Touareg Key Adaptation): When adapting keys on a 2011-2014 Touareg, it is necessary to complete the ?Adapt Immobilizer? test plan under 05 access start module. Read More »
When adapting keys on a 2011-2014 Touareg, it is necessary to complete the ?Adapt Immobilizer? test plan under 05 access start module. Right click on address word 05, and open Guided Functions. Select the ?Adapt immobilizer? test plan. Read More »
Technical Bulletin (Sunroof / Sunshade, Will Not Open): The panoramic sunroof, regular sunroof or sunshade cannot be opened. This document discusses the "Fault Codes" necessary to diagnosis, and potential remedy of the issue. Read More »
When the headlamps are switched ?ON? and fog lamps are switched to the ?OFF? position, the fog lamps act as cornering lamps. Explain this to the customer should a concern arise. Read More »
When replacing the complete vehicle lock set (all vehicle keys and lock cylinders) for any reason, be aware that the ?Adapt keys? test plan will not allow the new keys to adapt to the vehicle. Read More »
To detect which line(s) is inoperative, utilize a volt meter to check for 0 V, which will be present after the open in the grid line. The check must be performed with the engine running and heated rear window switched on. Read More »
Tech Tips (Bluetooth Compatibility): This document informs of the web address that can be used to check Bluetooth compatibility for all 2011, and newer vehicles, as well as 2010 Routan Read More »
Quick Reference Update Guide: This document informs of the corresponding software/hardware and disc availability to the customer concerns about a vehicle Read More »
Quick Reference Update Guide: This document informs of the corresponding software/hardware and disc availability to the customer concerns about a vehicle Read More »
Technical Bulletin (High Voltage Repairs on Hybrid Vehicles): High Voltage topics are very diverse and latest information is changing regularly. Therefore, they need to be addressed on a case-by-case basis. Read More »
Technical Bulletin (High Voltage Repairs on Hybrid Vehicles): High Voltage topics are very diverse and latest information is changing regularly. Therefore, they need to be addressed on a case-by-case basis. Read More »
Technical Bulletin (Cold Start - Rough Idle Concern): This document informs that customers may complain of a rough running condition that occurs during cold start. The production solution for this issue was improved software. Read More »
When diagnosing a vehicle concern, and fault P130A ?Hide Cylinder? is found in the Engine Control Module (ECM), be aware that Engine Control Module (ECM) fault P130A ?Hide Cylinder? indicates a cylinder shut down and does not require ... Read More »
Customer concern of seat backrest in a different position when re-entering the vehicle may be caused by customer contacting backrest adjustment switch while exiting the vehicle. Read More »
After installing the -J345- trailer recognition control module (vehicles with PR code 1D8 only), wiring harness and plug, the following steps need to be performed in order to enable the system. Read More »
Technical Bulletin (Bluetooth System Identification): This document informs how to identify the various Bluetooth systems by: ? Visual Identification ? PR Code ? Part Number Read More »
Tech Tips (Keyless Entry Remotes Inoperative issue): If all keyless entry remotes are inoperative but power door locks work from buttons inside vehicle, static current measuring mode may be active in the Diagnostic interface for databus ... Read More »
Customer concern of seat backrest in a different position when re-entering the vehicle may be caused by customer contacting backrest adjustment switch while exiting the vehicle. Read More »
Technical Bulletin (Sunroof / Sunshade, Will Not Open): The issued of The panoramic sunroof, regular sunroof or sunshade cannot be opened. The sunroof?s ?Basic Setting? has been unintentionally initiated by the customer. Read More »
Technical Bulletin (Sunroof / Sunshade, Will Not Open): The issued of The panoramic sunroof, regular sunroof or sunshade cannot be opened. The sunroof?s ?Basic Setting? has been unintentionally initiated by the customer. Read More »
Engine Control Module Updates: This document informs of complaints, and the software updates / Tech Bulletins associated with servicing engine control module issues: Read More »
Engine Control Module Updates: This document informs of complaints, and the software updates/Tech Bulletins associated with servicing engine control module issues: Read More »
UPDATE Technical Bulletin (UPDATE ? 23K9 Touareg TDI Software): This UPDATE installs new ECM/EDC software to prevent a false illumination of the check engine light. Read More »
VOLKSWAGEN DEALERSHIP COMMUNICATION (UPDATE 23K9 TDI Software): Volkswagen informs dealers on an upcomming update necessary to address an impendending issue. Read More »
Technical Bulletin (Bluetooth System Identification): This document informs of the method to understand how to identify the various Bluetooth systems by: ? Visual Identification ? PR Code ? Part ... Read More »
Technical Bulletin (Bluetooth System Identification): This document informs of the method to understand how to identify the various Bluetooth systems by: ? Visual Identification ? PR Code ? Part ... Read More »
Body/Infotainment Module Software Updates: This document informs of various complaints that were addressed in software updates, and technical bulletins. Read More »
Body/Infotainment Module Software Updates: This document informs of various complaints that were addressed in software updates, and technical bulletins. Read More »
It is recommended to perform the EVAP tank leak test on V6 equipped Touareg through Control Module OBD. The test can be selected from the basic settings selection under the ECM address 01. Read More »
MIL-ON, FAULT P309F OR P309D, NO ELECTRIC DRIVE MODE CUSTOMER STATES CRANK NO START AND/OR IN-TANK FUEL PUMP MAKING NOISE AND POSSIBLY WITH FUEL PUMP FAULTS MIL-ON, FAULT P013E IN THE ECM MIL-ON, FAULT P164B IN ECM MIL-ON, ... Read More »
After installing the -J345- trailer recognition control module (vehicles with PR code 1D8 only), wiring harness and plug, the following steps need to be performed in order to enable the system. Read More »
ELECTRICAL SYSTEM: INTEGRATED TRAILER BRAKE CONTROL
Information on the location of trailer brake controller connector and adapter harness creation. This document also applies to the 2004 Touareg. Read More »
After installing the -J345- trailer recognition control module (vehicles with PR code 1D8 only), wiring harness and plug, the following steps need to be performed in order to enable the system. Read More »
ELECTRICAL SYSTEM:WIRING:FUSES AND CIRCUIT BREAKERS
After replacement of the Driver seat control module (J810) the vehicle may not recognize the new module. The adaptation test plan may not set the seat module location properly and it may display as a passenger seat control module. Read More »
To detect which line(s) is inoperative, utilize a volt meter to check for 0 V, which will be present after the open in the grid line. The check must be performed with the engine running and heated rear window switched on. Read More »
If key blade is found to stick or bind when opening or closing, check position of roll pin that secures key blade to mechanism. If roll pin is sticking out on either side (as shown below), do not replace key. Read More »
Tech Tips (Instrument Cluster Production Mode): This document informs the procedure to remove the production mode setting when it is displayed in the instrument cluster. Read More »
Tech Tips (Instrument Cluster Production Mode): During PDI, or after installation of a replacement cluster, ?Pro? may be displayed in place of the odometer. The high beam indicator may be flashing in the instrument cluster as well. Read More »
Quick Reference of vehicle concerns. Includes a list of Software versions and the technical bulletin numbers that referred to the concerns Updated Read More »
Quick Reference Update Guide of the vehicles expected upgraded software level. The latest corresponding technical bulletins that address the issues, and concerns that have been had with the vehicles. Read More »
TECH TIP DENOTING POTENTIAL FOR DAMAGE OF THE DATA LINK CONNECTOR WHEN USING AFTER MARKET PLUG IN DEVICES OR SCAN TOOLS AND SUBSEQUENT DIAGNOSTIC DIRECTION. Read More »
Quick Reference of vehicle concerns. Includes a list of Software versions and the technical bulletin numbers that referred to the concerns Updated Read More »
Tech Tips (SVM Update Instructions): This document informs when performing SVM updates, the scan tool should be hardwired to the vehicle and the Bluetooth physically turned off. A hard wired internet connection is also recommended. Read More »
Quick Reference Update Guide: This document informs of the corresponding software/hardware and disc availability to the customer concerns about a vehicle Read More »
Technical Bulletin (Radio Software issues): Customer may report one of the following concerns: * HD Radio does not play back in stereo (plays in mono) * Intermittent erratic display problems * Displayed radio station does not match ... Read More »
Quick Reference Update Guide: This document informs of the corresponding software/hardware and disc availability to the customer concerns about a vehicle Read More »
Tech Tips (Resetting Inspection Service and Interval Service): This document references a difference between The procedure for resetting the "Reset Inspection Service" which is different from "Reset Interval Service". Read More »
Tech Tips (Vehicles equipped with Premium (RCD 510) Radios ? Coding Information for Replacing ?AC? Suffix Radios with ?AF? Suffix Replacement Unit): When replacing the radio on a 2010 ? 2011 vehicle equipped with a Premium 8 (RCD 510) ... Read More »
Tech Tips (MDI Functions with iPhone 5 Variants (5, 5c, 5s and iPad fourth generation, iPod Nano seventh generation)): The Apple iPhone 5, iPhone 5c, and iPhone 5s, as well as the iPad 4th generation and iPod Nano 7th generation use a ... Read More »
Technical Bulletin This Technical Bulletin details the general process for carrying out a Software Version Management (SVM) software update for any Technical Bulletin (TSB) / Required Vehicle Update (RVU). Read More »
VOLKSWAGEN: SEE DOCUMENT SEARCH BUTTON FOR OWNER LETTER. CORROSION FORMING IN DIFFERENTIAL PRESSURE SENSOR CAUSING MALFUNCTION INDICATOR LIGHT (MIL) TO COME ON AND AN ISSUE WITH ENGINE CONTROL MODULE (ECM) SOFTWARE. Read More »
UPDATE Technical Bulletin (UPDATE ? 23K9 Touareg TDI Software): This UPDATE installs new ECM/EDC software to prevent a false illumination of the check engine light. Read More »
VOLKSWAGEN DEALERSHIP COMMUNICATION (UPDATE 23K9 TDI Software): Volkswagen informs dealers on an upcomming update necessary to address an impendending issue. Read More »
It is recommended to perform the EVAP tank leak test on V6 equipped Touareg through Control Module OBD. The test can be selected from the basic settings selection under the ECM address 01. Read More »
Technical Bulletin: Condensation and or water droplets becomming visible on inside of exterior light lenses issue is discussed in this document Read More »
Technical Bulletin (Exterior Lights, Moisture Accumulation): This document informs of the Condensation and or water droplets visible on inside of exterior light lenses. The document also informs how to service the issue. Read More »
When the headlamps are switched ?ON? and fog lamps are switched to the ?OFF? position, the fog lamps act as cornering lamps. Explain this to the customer should a concern arise. Read More »
Technical Bulletin (Exterior Lights, Moisture Accumulation): Exterior light assemblies (headlights, taillights, fog lights, turn signals) are vented and may collect moisture on their inner surfaces, depending on humidity and other ... Read More »
Tech Tips (Fog Lamp): When the headlamps are switched ?ON? and fog lamps are switched to the ?OFF? position, the fog lamps act as cornering lamps. Explain this to the customer should a concern arise. Read More »
Technical Bulletin (Windshield Wipers Streak or Smear): Windshield or rear window is streaked, has a snakeskin appearance, or the surface feels rough. Read More »
The indicator lamp in the I.P. for washer fluid remains illuminated and the washer reservoir is full. Validate the washer reservoir is full with the proper washer solvent (G-052-164). Read More »
The indicator lamp in the I.P. for washer fluid remains illuminated and the washer reservoir is full. Validate the washer reservoir is full with the proper washer solvent (G-052-164). Read More »
Technical Bulletin (Sunroof / Sunshade, Will Not Open): The issued of The panoramic sunroof, regular sunroof or sunshade cannot be opened. The sunroof?s ?Basic Setting? has been unintentionally initiated by the customer. Read More »
Technical Bulletin (Wiper Blade Inspection for Proper Warranty Coding): Wiper blade inspection guidelines for wear and tear, outside influence and factory defect. Read More »
MIL-ON, FAULT P309F OR P309D, NO ELECTRIC DRIVE MODE CUSTOMER STATES CRANK NO START AND/OR IN-TANK FUEL PUMP MAKING NOISE AND POSSIBLY WITH FUEL PUMP FAULTS MIL-ON, FAULT P013E IN THE ECM MIL-ON, FAULT P164B IN ECM MIL-ON, ... Read More »
Tech Tips (Heated Rear Window, One or More Lines Inoperative): To detect which line(s) is inoperative, utilize a volt meter to check for 0 V, which will be present after the open in the grid line. Read More »
MIL-ON, FAULT P309F OR P309D, NO ELECTRIC DRIVE MODE CUSTOMER STATES CRANK NO START AND/OR IN-TANK FUEL PUMP MAKING NOISE AND POSSIBLY WITH FUEL PUMP FAULTS MIL-ON, FAULT P013E IN THE ECM MIL-ON, FAULT P164B IN ECM MIL-ON, ... Read More »
Tech Tips (Heated Rear Window, One or More Lines Inoperative): To detect which line(s) is inoperative, utilize a volt meter to check for 0 V, which will be present after the open in the grid line. Read More »
MIL-ON, FAULT P309F OR P309D, NO ELECTRIC DRIVE MODE CUSTOMER STATES CRANK NO START AND/OR IN-TANK FUEL PUMP MAKING NOISE AND POSSIBLY WITH FUEL PUMP FAULTS MIL-ON, FAULT P013E IN THE ECM MIL-ON, FAULT P164B IN ECM MIL-ON, ... Read More »
Technical Bulletin (Sunroof / Sunshade, Will Not Open): The issued of The panoramic sunroof, regular sunroof or sunshade cannot be opened. The sunroof?s ?Basic Setting? has been unintentionally initiated by the customer. Read More »
The indicator lamp in the I.P. for washer fluid remains illuminated and the washer reservoir is full. Validate the washer reservoir is full with the proper washer solvent (G-052-164). Read More »
The indicator lamp in the I.P. for washer fluid remains illuminated and the washer reservoir is full. Validate the washer reservoir is full with the proper washer solvent (G-052-164). Read More »
Technical Bulletin (Wiper Blade Inspection for Proper Warranty Coding): Wiper blade inspection guidelines for wear and tear, outside influence or a factory issue. This document informs what is under coverage for wiper blade issues. Read More »
Technical Bulletin (Wiper Blade Inspection for Proper Warranty Coding): Wiper blade inspection guidelines for wear and tear, outside influence and factory defect. Read More »
Tech Tips (Washer Level Sensor issues): This document discusses approved windshield washer fluids and the damages non - approved fluids can cause. Read More »
Reporting procedure for A/C compressor replacement regardless of the reason for failure. Update to model year applicability and new warranty GFF labor operation number Read More »
Cleaning of Heating and Ventilation system, Updated to include additional model year applicability and cost of cleaning solution in warranty table. Read More »
Tech Tips (Heated Rear Window, One or More Lines Inoperative): To detect which line(s) is inoperative, utilize a volt meter to check for 0 V, which will be present after the open in the grid line. Read More »
VISIBILITY:DEFROSTER/DEFOGGER/HVAC SYSTEM:REAR WINDOW:ELECTRICAL HEATING ELEMENT
To detect which line(s) is inoperative, utilize a volt meter to check for 0 V, which will be present after the open in the grid line. The check must be performed with the engine running and heated rear window switched on. Read More »
When replacing the Air Conditioning compressor it is necessary to flush the entire system to remove all the PAG oil. Replacement AC compressors come with a full charge of oil. Read More »
MIL-ON, FAULT P309F OR P309D, NO ELECTRIC DRIVE MODE CUSTOMER STATES CRANK NO START AND/OR IN-TANK FUEL PUMP MAKING NOISE AND POSSIBLY WITH FUEL PUMP FAULTS MIL-ON, FAULT P013E IN THE ECM MIL-ON, FAULT P164B IN ECM MIL-ON, ... Read More »
MIL-ON, FAULT P309F OR P309D, NO ELECTRIC DRIVE MODE CUSTOMER STATES CRANK NO START AND/OR IN-TANK FUEL PUMP MAKING NOISE AND POSSIBLY WITH FUEL PUMP FAULTS MIL-ON, FAULT P013E IN THE ECM MIL-ON, FAULT P164B IN ECM MIL-ON, ... Read More »
Technical Bulletin (Removing Paint Contaminants from Exterior Paint): This document informs how to remove paint contaminants such as rail dust and industrial fallout from exterior paint. Read More »
Technical Bulletin (Sunroof / Sunshade, Will Not Open): The panoramic sunroof, regular sunroof or sunshade cannot be opened. This document discusses the "Fault Codes" necessary to diagnosis, and potential remedy of the issue. Read More »
Technical Bulletin (Damage on External Chrome or Aluminum Surfaces) The surfaces of chrome parts can get damaged in the production process or by external influences. Read More »
Technical Bulletin (Paint Finish, Reducing Swirl Marks and Fine Scratches): New vehicles (prior to Retail Delivery) with swirl marks and or fine scratches from polishing or cleaning. Read More »
Technical Bulletin (Hood, Under Hood Not Painted Body Color): The paint color and/or finish of the engine compartment and underside of hood may not match the exterior paint color of the vehicle. Read More »
Technical Bulletin about Paint Finish, Reducing Swirl Marks and Fine Scratches New vehicles (prior to Retail Delivery) with swirl marks and or fine scratches from polishing or cleaning. Read More »
MIL-ON, FAULT P309F OR P309D, NO ELECTRIC DRIVE MODE CUSTOMER STATES CRANK NO START AND/OR IN-TANK FUEL PUMP MAKING NOISE AND POSSIBLY WITH FUEL PUMP FAULTS MIL-ON, FAULT P013E IN THE ECM MIL-ON, FAULT P164B IN ECM MIL-ON, ... Read More »
Tech Tips (All vehicles-Tire dressing for vehicle detailing): The use of tire dressing gives your tires that shiny finish that completes the image of a clean (new) vehicle. Read More »
The use of tire dressing gives your tires that shiny finish that completes the image of a clean (new) vehicle. There are many different tire dressing products available. When choosing a product please pay close attention to its contents. Read More »
Technical Bulletin (Vibrations in Steering Wheel): After a short stationary period (sometimes as little as a few hours) flat spots can develop after the warm tire has cooled down. Read More »
Tech Tips (Vibration or Steering Wheel Shimmy at Highway Speeds): The suspension characteristics of the Touareg make it more susceptible to variations in the rim and/or tire. Read More »
Tech Tips (All vehicles-Tire dressing for vehicle detailing): The use of tire dressing gives your tires that shiny finish that completes the image of a clean (new) vehicle. Read More »
The use of tire dressing gives your tires that shiny finish that completes the image of a clean (new) vehicle. There are many different tire dressing products available. When choosing a product please pay close attention to its contents. Read More »
After installing the -J345- trailer recognition control module (vehicles with PR code 1D8 only), wiring harness and plug, the following steps need to be performed in order to enable the system. Read More »
After replacement of the Driver seat control module (J810) the vehicle may not recognize the new module. The adaptation test plan may not set the seat module location properly and it may display as a passenger seat control module. Read More »
Customer concern of seat backrest in a different position when re-entering the vehicle may be caused by customer contacting backrest adjustment switch while exiting the vehicle. Read More »
Tech Tips (Front Seat Backrest is in a Different Position When Re-entering the Vehicle): Customer concern of seat backrest in a different position when re-entering the vehicle may be caused by customer contacting backrest adjustment ... Read More »
Tech Tips (Front Seat Backrest is in a Different Position When Re-entering the Vehicle): This document informs on the hardware installed to prevent accidental movement of the seat when exiting the vehicle. Read More »
Tech Tips (Front Seat Backrest is in a Different Position When Re-entering the Vehicle): This document informs on the hardware installed to prevent accidental movement of the seat when exiting the vehicle. Read More »
Tech Tips (Vibration or Steering Wheel Shimmy at Highway Speeds): The suspension characteristics of the Touareg make it more susceptible to variations in the rim and/or tire. Read More »
When replacing the radio on a 2010 ? 2011 vehicle equipped with a Premium 8 (RCD 510) radio with part number ending in the suffix ?AC? (1K0 035 180 AC), if the replacement part has a suffix ?AF?, make sure that online coding is performed. Read More »
VOLKSWAGEN: BEFORE REAR VIEW CAMERA IS PROPERLY OPERATIONAL, SHOULD BE CONNECTED TO BUZZER OR SENSOR FAULTS AND WORKING IN CONJUNCTION WITH REAR PARKING AID SYSTEM. MODELS 2009-15 TIGUAN, CC, PASSAT, TOUAREG. Read More »
Tech Tips (Rear View Camera Inoperative issues): The rear view camera operates in conjunction with the rear parking aid system. If there are no faults in the radio or rear view camera, be sure to check the parking aid system for faults. Read More »
Elsa2Go campaign information is now 100% aligned with ElsaPro. This update to Elsa2Go ensures that both systems are displaying the same campaign information, including OPEN/CLOSED status, repair date as well as criterions at the same time ... Read More »
This document informs dealers of the Extended Emissions Warranty Limited Warranty Extension for 3.0L TDI Gen 1.2 vehicles. Added clarification on totaled vehicles and loaners. Read More »
REMOVED all 12 hour wait period before starting references. ADDED EFB to "Select correct battery type" in bottom box. Also Jetta Wagon 2005 and 2018-2020 Tiguan LWB. Read More »
This document details updates to the ODIS diagnostic software. Updates include fixes to SVMs and diagnostic tests. Also includes 2009 Tiguan. Read More »
This Document informs dealers on the Revised VWC-17-11 - REVISED - Pre-existing MIL-On Condition in Regards to the TDI AEM Recalls for Customer Vehicles (Revised 12/17/18). Gen 1, Gen 2 and Gen 3 2.0L TDI no longer apply. Read More »
This special notice is to inform dealers to return all part numbers listed in the document and order the superseded part numbers going forward. Read More »
This document gives answers to frequently ask questions concerning the current owners and lessees of TDI vehicles affected by the emissions issue eligiblality options and issues. Read More »
This document contains the VW Elsa Newsletter that contains a general overview of wiring diagrams updates, ElsaPro infomedia icons grayed out, workshop equipment tool storage application, technical bulletins, pending service solutions, ... Read More »
Technical Bulletin: This document concerns the sensitivity of the washer solvent level sensor (G33) can be affected by the type, concentration, and the presence of additives in the washer solvent currently in the tank. Read More »
VOLKSWAGEN: BEFORE REAR VIEW CAMERA IS PROPERLY OPERATIONAL, SHOULD BE CONNECTED TO BUZZER OR SENSOR FAULTS AND WORKING IN CONJUNCTION WITH REAR PARKING AID SYSTEM. MODELS 2009-15 TIGUAN, CC, PASSAT, TOUAREG. Read More »
When performing SVM updates, the scan tool should be hardwired to the vehicle and the Bluetooth physically turned off. A hard wired internet connection is also recommended. Read More »
Technical Bulletin (Removing Paint Contaminants from Exterior Paint): This document informs how to remove paint contaminants such as rail dust and industrial fallout from exterior paint. Read More »
Technical Bulletin (Exterior Lights, Moisture Accumulation): This document informs of the Condensation and or water droplets visible on inside of exterior light lenses. The document also informs how to service the issue. Read More »
Tech Tips: 3.0L TDI Ad Blue Reset Procedure: To reset the Ad Blue level light after the tank has been filled; this document informs of the procedure necessary to perform the service Read More »
Technical Bulletin (Squeaks, Rattles, Noise, Repair Materials): This doucment contains a list of components and applications developed to repair concerns of squeaks, rattles, noise and trim fit conditions. Read More »
When replacing the complete vehicle lock set (all vehicle keys and lock cylinders) for any reason, be aware that the ?Adapt keys? test plan will not allow the new keys to adapt to the vehicle. Read More »
Tech Tips (Child Seat Anchor Covers): The child seat anchor covers should only be used when a child seat will be installed into the vehicle. Read More »
Tech Tips (All Models 2000-2014 - Part ordering): If a needed service part is on back order, upgrade the daily order to a red order and check the ?Car Down? box to escalate the order. Read More »
Tech Tips (All Models 2000-2014 - Part ordering): If a needed service part is on back order, upgrade the daily order to a red order and check the ?Car Down? box to escalate the order. Read More »
If a needed service part is on back order, upgrade the daily order to a red order and check the ?Car Down? box to escalate the order. If parts assistance is needed, please call 800-767-6552 to speak with a VWGoA Parts Specialist. Read More »
If a needed service part is on back order, upgrade the daily order to a red order and check the ?Car Down? box to escalate the order. If parts assistance is needed, please call 800-767-6552 to speak with a VWGoA Parts Specialist. Read More »
Tech Tips (Bluetooth Compatibility): This document informs of the web address that can be used to check Bluetooth compatibility for all 2011, and newer vehicles, as well as 2010 Routan Read More »
Quick Reference Update Guide: This document informs of the corresponding software/hardware and disc availability to the customer concerns about a vehicle Read More »
Warranty Information (Volkswagen DoubleCheck Labor Operations): Volkswagen DoubleCheck Labor Operations for All VW Models Except Routan ElsaWeb/Pro was updated on August 12, 2013 with the following Volkswagen DoubleCheck labor ... Read More »
Technical Bulletin (RNS 850 Radio Software Update): Customer may report one of the following concerns: ? HD Radio does not play back in stereo (plays in mono) ? Intermittent erratic display problems ? Displayed radio station does not ... Read More »
Technical Bulletin (RNS 850 Radio Software Update): Customer may report one of the following concerns: ? HD Radio does not play back in stereo (plays in mono) ? Intermittent erratic display problems ? Displayed radio station does not ... Read More »
In SAGA, the time units for the Volkswagen DoubleCheck labor operation were reduced in error from 50 time units to 30 time units during the system update posted on July 4th. Read More »
"Touareg Perfect Delivery Inspection (PDI) - Technician and Detailer Inspections: A checklist to insure a customer receives a wonderful delivery of a vehicle that looks, feels, and meets the expectations of a new vehicle that he/she has ... Read More »
VOLKSWAGEN DEALERSHIP COMMUNICATION (20R9 Service Action Kit Allocation): This document informs of the submission of additional 20R9 kits for dealership?s use. Read More »
VOLKSWAGEN DEALERSHIP COMMUNICATION (20R9 Service Action Kit Allocation): Volkswagen will be sending an additional allocation of 20R9 kits for dealership?s to use. Read More »
Warranty Information (Regularly Scheduled Maintenance Interval Time or Mileage Guidelines): The Volkswagen Customer Experience Team has monitored the claims processed through the Carefree Maintenance (CFM) program from its inception. Read More »
Technical Bulletin (PDI - Vehicle Inspection, Protection Removal and Detailing): This document informs of the procedure to perform when a dealer receives a car. Read More »
Technical Bulletin (Wiper Blade Inspection for Proper Warranty Coding): Wiper blade inspection guidelines for wear and tear, outside influence and factory defect. Read More »
Technical Bulletin (PDI - Vehicle Inspection, Protection Removal and Detailing): This document informs of the procedure to perform when a dealer receives a car. Read More »
Technical Bulletin (Sunroof / Sunshade, Will Not Open): The issued of The panoramic sunroof, regular sunroof or sunshade cannot be opened. The sunroof?s ?Basic Setting? has been unintentionally initiated by the customer. Read More »
UPDATE Technical Bulletin (UPDATE ? 23K9 Touareg TDI Software): This UPDATE installs new ECM/EDC software to prevent a false illumination of the check engine light. Read More »
Technical Bulletin (Bluetooth System Identification): This document informs of the method to understand how to identify the various Bluetooth systems by: ? Visual Identification ? PR Code ? Part ... Read More »
Warranty Information (Volkswagen Amenity Subsidy Program - Revised): Volkswagen announced a new short-term program that reimburses Dealers $20 per repair order when model year 2010 ? 2013 Volkswagen customers bring in their vehicle for ... Read More »
MIL-ON, FAULT P309F OR P309D, NO ELECTRIC DRIVE MODE CUSTOMER STATES CRANK NO START AND/OR IN-TANK FUEL PUMP MAKING NOISE AND POSSIBLY WITH FUEL PUMP FAULTS MIL-ON, FAULT P013E IN THE ECM MIL-ON, FAULT P164B IN ECM MIL-ON, ... Read More »
MIL-ON, FAULT P309F OR P309D, NO ELECTRIC DRIVE MODE CUSTOMER STATES CRANK NO START AND/OR IN-TANK FUEL PUMP MAKING NOISE AND POSSIBLY WITH FUEL PUMP FAULTS MIL-ON, FAULT P013E IN THE ECM MIL-ON, FAULT P164B IN ECM MIL-ON, ... Read More »
Tech Tips (ECM Fault P1250 "Fuel Level Too Low" Will Not Clear): This document informs to clear static ECM fault P1250 "Fuel Level Too Low", add fuel to vehicle and complete a road test of at least 10 miles. Read More »
Tech Tips (Bluetooth Compatibility): This document informs of the web address that can be used to check Bluetooth compatibility for all 2011, and newer vehicles, as well as 2010 Routan Read More »
Warranty Information (Volkswagen DoubleCheck Labor Operations): Volkswagen DoubleCheck Labor Operations for All VW Models Except Routan ElsaWeb/Pro was updated on August 12, 2013 with the following Volkswagen DoubleCheck labor ... Read More »
Technical Bulletin (Radio Software issues): Customer may report one of the following concerns: * HD Radio does not play back in stereo (plays in mono) * Intermittent erratic display problems * Displayed radio station does not match ... Read More »
When replacing the radio on a 2010 ? 2011 vehicle equipped with a Premium 8 (RCD 510) radio with part number ending in the suffix ?AC? (1K0 035 180 AC), if the replacement part has a suffix ?AF?, make sure that online coding is performed. Read More »
Technical Bulletin (Bluetooth System Identification): This document informs of the method to understand how to identify the various Bluetooth systems by: ? Visual Identification ? PR Code ? Part ... Read More »
Tech Tips (All Navigation Radios-All Models): When the Navigation RNS 850/510/315 is in 3D mode, the top portion of the screen may not display streets. This line represents the horizon and is a normal operation of system. Read More »
Technical Bulletin (Bluetooth System Identification): This document informs of the method to understand how to identify the various Bluetooth systems by: ? Visual Identification ? PR Code ? Part ... Read More »
For concerns of navigation inaccuracy, with or without antenna fault codes, begin by checking the number of received satellites in the area of the concern. Read More »
The procedure for resetting the "Reset Inspection Service" is different from "Reset Interval Service". Both of these procedures are available in Guided Functions in Address Word 17. Read More »
When performing SVM updates, the scan tool should be hardwired to the vehicle and the Bluetooth physically turned off. A hard wired internet connection is also recommended. Read More »
When pairing an Android phone to the Bluetooth system, a few extra steps may be necessary. Follow the instructions below to pair the phone: Read More »
UPDATE Technical Bulletin (UPDATE ? 24U5 Emissions Label): This update has been proactively released to replace the emissions label on the vehicle. Read More »
UPDATE Technical Bulletin (UPDATE ? 24U5 Emissions Label): This update has been proactively released to replace the emissions label on the vehicle. Read More »
VOLKSWAGEN: SEE DOCUMENT SEARCH BUTTON FOR CUSTOMER LETTER. INFORMATION PACKAGES WILL BE PROVIDED REGARDING PROPER LABELS/STICKERS ON VEHICLES FOR USING DIESEL FUEL ONLY WITH TDI CLEAN DIESEL ENGINES. Read More »
This document informs dealers of coding instructions for AdBlue refills after AEM performed for 3.0L TDI Gen 1.1, Gen 1.2, Gen 2.1 and Gen 2.2 Touareg vehicles. Read More »
This document informs dealers of coding instructions for fuel fill after AEM performed for 3.0L TDI Gen1.1, Gen 1.2, Gen 2.1 and Gen 2.2 Touareg vehicles. Read More »
Update to existing Tech Tip to address correct octane usage by model year and fuel quality that effect cold start performance. Update model year applicability and add DTC P13EA Read More »
This document gives answers to frequently ask questions concerning the current owners and lessees of TDI vehicles affected by the emissions issue eligiblality options and issues. Read More »
"Touareg - 2011 FLUID CAPACITY CHART" This document contains information on what fluids, and how much for each of them are necessary to have a car up and running Read More »
This document contains the VW Elsa Newsletter that contains a general overview of wiring diagrams updates, technical bulletins, pending service solutions, tech tips, campaigns, updates, and suggestions. Read More »
This document contains the VW Elsa Newsletter that contains a general overview of wiring diagrams updates, ElsaPro infomedia icons grayed out, workshop equipment tool storage application, technical bulletins, pending service solutions, ... Read More »
VOLKSWAGEN DEALERSHIP COMMUNICATION: This document announced a warranty Volkswagen extension program to cover the High Pressure Fuel Pump on 2009-2012 model year TDI Clean Diesel Engine vehicles. Read More »
VOLKSWAGEN DEALERSHIP COMMUNICATION: Volkswagen announced a warranty extension program to cover the High Pressure Fuel Pump on 2009-2012 model year TDI Clean Diesel Engine vehicles Read More »
Technical Bulletin: Condensation and or water droplets becomming visible on inside of exterior light lenses issue is discussed in this document Read More »
VOLKSWAGEN: SEE DOCUMENT SEARCH BUTTON FOR OWNER LETTER. AN EXTENSION WARRANTY, WITH SPECIFIC CONDITIONS, 10 YRS OR 120,000 MILES,WHICHEVER IS FIRST, HAS BEEN ISSUED FOR EMISSIONS CONTROL SYSTEMS WARRANTY FOR INTAKE MANIFOLD AND FUEL ... Read More »
Technical Bulletin (High-voltage repairs on Hybrid and Electric vehicles): High Voltage topics are very diverse and latest information is changing regularly. Therefore, they need to be addressed on a case-by-case basis. Read More »
Technical Bulletin (PDI - Vehicle Inspection, Protection Removal and Detailing): This document informs on the service a vehicle shouold received when it has successfully reached a dealership. Read More »
Technical Bulletin (High Voltage Repairs on Hybrid Vehicles): High Voltage topics are very diverse and latest information is changing regularly. Therefore, they need to be addressed on a case-by-case basis. Read More »
TOUAREG Perfect Delivery Inspection (PDI) - Technician and Detailer Inspections: A checklist to insure a customer receives a wonderful delivery of a vehicle that looks, feels, and meets the expectations of a new vehicle that he/she has ... Read More »
"Touareg Perfect Delivery Inspection (PDI) - Technician and Detailer Inspections: A checklist to insure a customer receives a wonderful delivery of a vehicle that looks, feels, and meets the expectations of a new vehicle that he/she has ... Read More »
We would like to inform you that the FAQ for Service Action 20T8 has been revised to include additional information for dealers to share with customers about the misfueling guard. Read More »
Tech Tips (Technician Helpline Vehicle Check Sheets): When it becomes necessary to open a VW Technician Helpline VTA case while performing diagnosis for a diesel particulate filter, manual transmission repair, or turbocharger concern, ... Read More »
VOLKSWAGEN DEALERSHIP COMMUNICATION (20R9 Service Action Kit Allocation): This document informs of the submission of additional 20R9 kits for dealership?s use. Read More »
VOLKSWAGEN DEALERSHIP COMMUNICATION (20R9 Service Action Kit Allocation): Volkswagen will be sending an additional allocation of 20R9 kits for dealership?s to use. Read More »
Warranty Information (Regularly Scheduled Maintenance Interval Time or Mileage Guidelines): The Volkswagen Customer Experience Team has monitored the claims processed through the Carefree Maintenance (CFM) program from its inception. Read More »
Tech Tips (Front Seat Backrest is in a Different Position When Re-entering the Vehicle): This document informs on the hardware installed to prevent accidental movement of the seat when exiting the vehicle. Read More »
Technical Bulletin (PDI - Vehicle Inspection, Protection Removal and Detailing): This document informs of the procedure to perform when a dealer receives a car. Read More »
Technical Bulletin (Slave Cylinder - Clutch Pedal Operation Diagnosis): A Customer may comment: ? Complaints on clutch system. ? After pressing the clutch pedal, it remains on the floor. Read More »
Technical Bulletin (Paint Finish, Reducing Swirl Marks and Fine Scratches): New vehicles (prior to Retail Delivery) with swirl marks and or fine scratches from polishing or cleaning. Read More »
Technical Bulletin (Paint Finish, Reducing Swirl Marks and Fine Scratches): New vehicles (prior to Retail Delivery) with swirl marks and or fine scratches from polishing or cleaning. Read More »
Technical Bulletin (Hood, Under Hood Not Painted Body Color): The paint color and/or finish of the engine compartment and underside of hood may not match the exterior paint color of the vehicle. Read More »
Technical Bulletin (Hood, Under Hood Not Painted Body Color): The paint color and/or finish of the engine compartment and underside of hood may not match the exterior paint color of the vehicle. Read More »
Engine Control Module Updates: This document informs of complaints, and the software updates / Tech Bulletins associated with servicing engine control module issues: Read More »
VOLKSWAGEN DEALERSHIP COMMUNICATION (UPDATE 23K9 TDI Software): Volkswagen informs dealers on an upcomming update necessary to address an impendending issue. Read More »
Technical Bulletin (Bluetooth System Identification): This document informs of the method to understand how to identify the various Bluetooth systems by: ? Visual Identification ? PR Code ? Part ... Read More »
Warranty Information (Volkswagen Amenity Subsidy Program - Revised): Volkswagen announced a new short-term program that reimburses Dealers $20 per repair order when model year 2010 ? 2013 Volkswagen customers bring in their vehicle for ... Read More »
Body/Infotainment Module Software Updates: This document informs of various complaints that were addressed in software updates, and technical bulletins. Read More »
Tech Tips (Test Plan to Calibrate Adaptive Cruise Control Sensors Will Not Begin notice): Notification that If the test plan to calibrate the Adaptive Cruise Control Sensors will not begin, turn off the overhead lights in the shop. Read More »
VOLKSWAGEN: BEFORE REAR VIEW CAMERA IS PROPERLY OPERATIONAL, SHOULD BE CONNECTED TO BUZZER OR SENSOR FAULTS AND WORKING IN CONJUNCTION WITH REAR PARKING AID SYSTEM. MODELS 2009-15 TIGUAN, CC, PASSAT, TOUAREG. Read More »
Tech Tips (Child Seat Anchor Covers): The child seat anchor covers should only be used when a child seat will be installed into the vehicle. Read More »
Technical Bulletin (Slave Cylinder - Clutch Pedal Operation Diagnosis): A Customer may comment: ? Complaints on clutch system. ? After pressing the clutch pedal, it remains on the floor. Read More »
Technical Bulletin (Paint Finish, Reducing Swirl Marks and Fine Scratches): New vehicles (prior to Retail Delivery) with swirl marks and or fine scratches from polishing or cleaning. Read More »
Technical Bulletin (Hood, Under Hood Not Painted Body Color): The paint color and/or finish of the engine compartment and underside of hood may not match the exterior paint color of the vehicle. Read More »
Technical Bulletin (TDI Clean Diesel I/M (Inspection Maintenance) Testing Issues due to Readiness Not Set): Some readiness codes on TDI clean diesel vehicles require special driving conditions to be set. Read More »
VOLKSWAGEN: SEE DOCUMENT SEARCH BUTTON FOR CUSTOMER LETTER. INFORMATION PACKAGES WILL BE PROVIDED REGARDING PROPER LABELS/STICKERS ON VEHICLES FOR USING DIESEL FUEL ONLY WITH TDI CLEAN DIESEL ENGINES. Read More »
Statement referring to TB 2043893 removed. To include additional models and model year applicability. A.C. Compressor Replacement, GFF Required Regardless of Concern and Flush Requirement Read More »
MIL-ON, FAULT P309F OR P309D, NO ELECTRIC DRIVE MODE CUSTOMER STATES CRANK NO START AND/OR IN-TANK FUEL PUMP MAKING NOISE AND POSSIBLY WITH FUEL PUMP FAULTS MIL-ON, FAULT P013E IN THE ECM MIL-ON, FAULT P164B IN ECM MIL-ON, ... Read More »
MIL-ON, FAULT P309F OR P309D, NO ELECTRIC DRIVE MODE CUSTOMER STATES CRANK NO START AND/OR IN-TANK FUEL PUMP MAKING NOISE AND POSSIBLY WITH FUEL PUMP FAULTS MIL-ON, FAULT P013E IN THE ECM MIL-ON, FAULT P164B IN ECM MIL-ON, ... Read More »
Technical Bulletin (Air Conditioning, Cleaning of the Refrigerant Circuit (U.S.Only)): In cases where an air conditioning system component (such as a compressor or other system component) has failed and debris from the compressor or ... Read More »
Technical Bulletin (Air Conditioning, Cleaning of the Refrigerant Circuit): In cases where an air conditioning system component (such as a compressor or other system component) has failed and debris from the compressor or component is ... Read More »
Tech Tips (AC Compressor Replacement, Refrigerant Circuit Flushing Requirement): This document informs when replacing the Air Conditioning compressor it is necessary to flush the entire system to remove all the PAG oil. Read More »
Tech Tips (Child Seat Anchor Covers): The child seat anchor covers should only be used when a child seat will be installed into the vehicle. Read More »
After replacement of the Driver seat control module (J810) the vehicle may not recognize the new module. The adaptation test plan may not set the seat module location properly and it may display as a passenger seat control module. Read More »
VOLKSWAGEN: SEE DOCUMENT SEARCH BUTTON FOR OWNER LETTER. AN EXTENSION WARRANTY, WITH SPECIFIC CONDITIONS, 10 YRS OR 120,000 MILES,WHICHEVER IS FIRST, HAS BEEN ISSUED FOR EMISSIONS CONTROL SYSTEMS WARRANTY FOR INTAKE MANIFOLD AND FUEL ... Read More »
To detect which line(s) is inoperative, utilize a volt meter to check for 0 V, which will be present after the open in the grid line. The check must be performed with the engine running and heated rear window switched on. Read More »
To clear static ECM fault P1250 ?Fuel Level Too Low?, add fuel to vehicle and complete a road test of at least 10 miles. Simply adding fuel without completing a road test may not allow fault to clear. Read More »
To clear static ECM fault P1250 ?Fuel Level Too Low?, add fuel to vehicle and complete a road test of at least 10 miles. Simply adding fuel without completing a road test may not allow fault to clear. Read More »
