Technical Service Bulletins (TSBs) for the 2008 Passat are official communications between Volkswagen & their dealerships that describe processes for troubleshooting or fixing certain common problems.
All vehicle manufacturers are required by U.S. law to make their TSBs available to the public.
Tech Tips (Electro - Steering issues): If, after replacement of the steering rack, fault code 01309 008 is set in the ABS/ESP module only, follow the test plan in GFF for Driver Steering Recommendation (DSR) or channel 3 activation. Read More »
Tech Tips ("Steering Column Defective? Message on MFI): Be aware that the MFI message ?Steering Column Defective? does not necessary indicate the electronic steering column lock (ESCL) requires replacement. Read More »
Tech Tips ("Steering Column Defective? Message on MFI): Be aware that the MFI message ?Steering Column Defective? does not necessary indicate the electronic steering column lock (ESCL) requires replacement. Read More »
If, after replacement of the steering rack, fault code 01309 008 is set in the ABS/ESP module only, follow the test plan in GFF for Driver Steering Recommendation (DSR) or channel 3 activation. Read More »
VOLKSWAGEN SERVICE CAMPAIGN: SEE DOCUMENT SEARCH BUTTON FOR OWNER LETTER. WHEN TRYING TO START THE VEHICLE THERE IS A LONG CRANK OR NO START CONDITION. 2009-2010 PASSAT. *RM Read More »
VOLKSWAGEN SERVICE CAMPAIGN: SEE DOCUMENT SEARCH BUTTON FOR OWNER LETTER. WHEN TRYING TO START THERE MAY BE AN EXTENDED CRANK OR NO START. 2006-2010 PASSAT. *RM Read More »
If, after replacement of the steering rack, fault code 01309 008 is set in the ABS/ESP module only, follow the test plan in GFF for Driver Steering Recommendation (DSR) or channel 3 activation. Read More »
Technical Bulletin (Front Suspension, Knocking Noise): A Knocking noise from vehicle front. Typically occurs only one time after each direction change (forward or backward, left or right). Read More »
VOLKSWAGEN: FRONT SUSPENSION, KNOCKING NOISE. KNOCKING NOISE FROM VEHICLE FRONT. TYPICALLY OCCURS ONLY ONE TIME AFTER EACH DIRECTION CHANGE (FORWARD OR BACKWARD, LEFT OR RIGHT). Read More »
Technical Bulletin (Front Suspension, Knocking Noise): A Knocking noise from vehicle front. Typically occurs only one time after each direction change (forward or backward, left or right). Read More »
If you have a complaint of DTCs for the low side fuel pressure being out of specification (e.g. P310B), check the fuel pressure with BOTH a mechanical gauge and by the display in Measured Value Block 103. Read More »
VOLKSWAGEN: UPDATE INFORMATION ON MODELS AND MODEL YEARS REGARDING SYNCHRONIZATION OF ELECTROMECHANICAL PARKING BRAKE (EPB) MODULE AND DUE TO SWITCH AND MODULE NOT BEING SYNCHRONIZED, FAULT CODES FOUND. Read More »
SERVICE BRAKES, HYDRAULIC:POWER ASSIST:ELECTRIC:CONTROL MODULE
If, after replacement of the steering rack, fault code 01309 008 is set in the ABS/ESP module only, follow the test plan in GFF for Driver Steering Recommendation (DSR) or channel 3 activation. Read More »
SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP:WHEEL SPEED SENSOR
Fault code 02543 000 ?Brake Vacuum Sensor no Display? may be encountered in the ABS module. This may be caused by the hydraulic brake boost function (HBV) in adaptation value 61 being turned off (value = 0). Read More »
If you have a complaint of DTCs for the low side fuel pressure being out of specification (e.g. P310B), check the fuel pressure with BOTH a mechanical gauge and by the display in Measured Value Block 103. Read More »
PASSAT 2008: INFORMATION REGARDING CODE 02543 000 PRESENT IN THE ABS MODULE WHICH SHOWS"BRAKE SENSOR NO DISPLAY". THIS INCLUDES VEHICLES WITH 3.6L EQUIPPED SEDANS . *LJ Read More »
If mechanical damage is found to the turbocharger (e.g. damaged compression wheel, loose or broken shaft), it is not enough to just replace the turbocharger. Read More »
If fault code 03200 or 16352 is present in the Electromechanical Parking Brake (EPB) module, it may be due to the switch and module not being synchronized. Read More »
If fault code 03200 or 16352 is present in the Electromechanical Parking Brake (EPB) module, it may be due to the switch and module not being synchronized. Read More »
If fault code 03200 or 16352 is present in the Electromechanical Parking Brake (EPB) module, it may be due to the switch and module not being synchronized. Read More »
This Document was revised to include information on when the replacement engine contains a Timing Chain or Timing Chain Tensioner. Also includes the CPPA engine code labor operation and time units. Read More »
2006-2008 WITH 2.0L (BPY) UPDATE SERVICE NUMBER IN WARRANTY TABLE. 2008-2009 ALL MODELS WITH 2.0L (CCTA,CBFA) UPDATE SERVICE NUMBER IN WARRANTY TABLE. Read More »
Technical Bulletin: High Pressure Fuel Pump Diagnosis. Completing the GFF high pressure pump function test is essential to diagnose proper pump operation and to avoid unnecessary replacements. Read More »
Technical Bulletin (High Pressure Fuel Pump Diagnosis): Completing the GFF high pressure pump function test is essential to diagnose proper pump operation and to avoid unnecessary replacements Read More »
Technical Bulletin (Fuel Additive to Help Prevent Sporadic Misfire Faults): Fuel quality impacts the operating performance, efficiency and service life of the engine. Read More »
Technical Bulletin (Engine Oils Which Meet Volkswagen Oil Quality Standard): This document informs of a sample list of products generally available in the North American market that meet the Volkswagen Oil Quality ... Read More »
When diagnosis on the above engine leads to the testing of the N75, please refer to the picture below. The diagram shows which vacuum ports on the N75 valve should hold vacuum and which ones should not. Read More »
Tech Tips (2.0L FSI (BPY) Engines - Low Fuel Pressure DTCs (P310B)): This document informs on how to check fuel pressure If you have a complaint of DTCs for the low side fuel pressure being out of ... Read More »
Technical Bulletin The use of contaminated gasoline, seasonal fuel changes (summer/winter fuel) or gasoline with a low content of deposit control additives may result in one or more of the following conditions: -Excessive accumulation ... Read More »
Tech Tips (CBEA, CJAA, CKRA engine codes DPF replacement and/or DTCS P2413, P2463): This document informs of the use of aftermarket air filters such as cotton bed steel mesh or cone style, can cause the MAF sensor to not read ... Read More »
Technical Bulletin (Oil Consumption Measurement): Customers have stated oil consumption is higher than the Volkswagen oil consumption standard of up to 0.5 quarts per 600 miles, or 0.5 liters per 1000 km. Read More »
In SAGA, the time units for the Volkswagen DoubleCheck labor operation were reduced in error from 50 time units to 30 time units during the system update posted on July 4th. Read More »
Tech Tips (N75 Solenoid Valve Diagnosis): This document informs with a diagram which vacuum ports on the N75 valve should hold vacuum and which ones should not for diagnosis on the Vehicles with 2. Read More »
Engine Control Module Updates: This document informs of complaints, and the software updates / Tech Bulletins associated with servicing engine control module issues: Read More »
Engine Control Module Updates: This document informs of complaints, and the software updates/Tech Bulletins associated with servicing engine control module issues: Read More »
VOLKSWAGEN: ALL MODELS EXPERIENCE THE TIMING CHAIN SLIPPING, RATTLING NOISES OF THE ENGINE AFTER STARTING, AND ENGINE FAILS TO START. 2008-13 ALL MODELS. *PE Read More »
17 17 01 July 5, 2017 2012855 Supersedes Technical Bulletin 17-16-02 (V171602) dated April 29, 2016 due to updated oil standards lists to current specifications. Read More »
Technical Bulletin (Intake manifold runner position sensor issues): This document informs what repairs are needed to fix the issue. This document contains the fault codes necessary to check the warranty coverage for servicing this issue. Read More »
Technical Bulletin (Air Conditioning, Cleaning of the Refrigerant Circuit (U.S.Only)): In cases where an air conditioning system component (such as a compressor or other system component) has failed and debris from the compressor or ... Read More »
Tech Tips (Coolant Leak or Repeat Coolant Leak from the Water Pump Area): The document informs to inspect for issues, and why issues may happen. Read More »
Technical Bulletin (Electric Coolant Fans Continue to Run after Ignition is Switched OFF): This documentation informs it is considered normal operation for the electric coolant fans to continue to run for up to 15 minutes after the ... Read More »
Technical Bulletin (Rattling Noises from Engine Compartment Area or Exhaust System): Customers may complain of a rattling noise from engine or exhaust area while accelerating from 1800-3000 RPM. Read More »
Tech Tips (2.0L CCTA/CBFA Coolant Leak or Repeat Coolant Leak from the Water Pump Area): This document informs of the observations that need to be taken to service a water pump replacement Read More »
Tech Tips (CBEA, CJAA, CKRA engine codes DPF replacement and/or DTCS P2413, P2463): This document informs of the use of aftermarket air filters such as cotton bed steel mesh or cone style, can cause the MAF sensor to not read ... Read More »
Inspect the water pump for signs of contact with engine oil. Engine oil may cause the water pump gasket to swell, which may lead to a coolant leak. Read More »
Use of aftermarket air filters such as cotton bed steel mesh or cone style, can cause the MAF sensor to not read accurately, affecting vehicle performance and critical monitoring functions for the diesel particulate filter. Read More »
Technical Bulletin (Electric Coolant Fans Continue to Run after Ignition is Switched OFF): This document informs it is considered normal operation for the electric coolant fans to continue to run for up to 15 minutes after the ignition ... Read More »
Technical Bulletin (Electric Coolant Fans Continue to Run after Ignition is Switched OFF): This document informs it is considered normal operation for the electric coolant fans to continue to run for up to 15 minutes after the ignition ... Read More »
Technical Bulletin (Oil Consumption Measurement): Customers have stated oil consumption is higher than the Volkswagen oil consumption standard of up to 0.5 quarts per 600 miles, or 0.5 liters per 1000 km. Read More »
Technical Bulletin (Oil Consumption Measurement): Customer states oil consumption is higher than the Volkswagen oil consumption standard of up to 0.5 quarts per 600 miles, or 0.5 liters per 1000 km. Read More »
When servicing the timing chain sprocket or removing the vibration damper, be aware that one bolt holds both the vibration damper (harmonic balancer) and the crankshaft timing chain sprocket to the crankshaft. Read More »
VOLKSWAGEN: DUE TO CHANGE IN COOLANT AND ENGINE OIL PART NUMBERS CHECK/REPLACE OIL COOLER. ON SOME VEHICLES WITH 2.0I TFSI ENGINE LEAKS ON THE OIL COOLER CAN OCCUR BECAUSE OF A PRODUCTION FAULT. Read More »
VOLKSWAGEN: CERTAIN MODEL YEAR VEHICLES ARE EXPERIENCING ENGINE NOT STARTING, MAKING A RATTLING NOISE WHEN ENGINE HAS STARTED, TIMING CHAIN KEEPS SLIPPING AND EXHAUST LIGHT COMES ON. *PE Read More »
VOLKSWAGEN: ON CERTAIN MODEL YEAR VEHICLES, EXPERIENCING HARSH UP/DOWN SHIFT IN GEARS 1-2, 2-3 OR 3-2, 2-1. ESPECIALLY DURING TEMPERATURES BELOW 60 C (140 F). Read More »
VOLKSWAGEN: SEE DOCUMENT SEARCH BUTTON FOR OWNER LETTER. INFORMATION PERTAINING TO SOME VEHICLES INTAKE MANIFOLD RUNNER CONTROL MOTOR AND THE PCV, POSITIVE CRANKCASE VENTILATION VALVE WARRANTY. Read More »
VOLKSWAGEN: SEE DOCUMENT SEARCH BUTTON FOR OWNER LETTER. INFORMATION PERTAINING TO SOME MODEL YEAR VEHICLES REGARDING THE FUEL PRESSURE SENSOR, CRANKCASE VENTILATION (PCV) VALVE AND INTAKE MANIFOLD RUNNER CONTROL MOTOR. Read More »
VOLKSWAGEN: CERTAIN MODEL YEAR VEHICLES MAY EXPERIENCE AN OIL FILLER CAP LEAKING, OR RUSHING NOISE FROM ENGINE OR A WHISTLING NOISE DUE TO CRANKCASE VENTILATION PRESSURE OR INTAKE TURBO PIPE MALFUNCTION. Read More »
VOLKSWAGEN: MALFUNCTION LIGHT IS ON AND THERE IS NOISE WITH THE ENGINE RUNNING ROUGH. MULTIPLE TROUBLE CODES POSSIBLY STORED. ALL MODELS 2008-2012. *RM Read More »
VOLKSWAGEN: THE INTAKE FLAP MOTOR OR INTAKE MANIFOLD RUNNER POSITION SENSOR G336 MAY BE INOPERATIVE (BOTH ARE INCLUDED IN ONE SINGLE UNIT). MODELS GOLF, GTI, A5 JETTA, GLI, EOS, PASSAT, PASSAT WAGON. *PE UPDATED 9/25/09. Read More »
VOLKSWAGEN: DUE TO CHANGE IN COOLANT AND ENGINE OIL PART NUMBERS CHECK/REPLACE OIL COOLER. ON SOME VEHICLES WITH 2.0I TFSI ENGINE LEAKS ON THE OIL COOLER CAN OCCUR BECAUSE OF A PRODUCTION FAULT. Read More »
Tech Tips 92006-2014 Vehicles with 2.0T Gasoline Engine - N75 Solenoid Valve Diagnosis): When diagnosis on the above engine leads to the testing of the N75, please refer this document with graphical aid. Read More »
Tech Tips (Equipped with Turbocharged Engine Turbocharger Replacement Tip): If mechanical damage is found to the turbocharger (e.g. damaged compression wheel, loose or broken shaft), it is not enough to just replace the turbocharger. Read More »
Technical Bulletin (Fuel Additive to Help Prevent Sporadic Misfire Faults): Fuel quality impacts the operating performance, efficiency and service life of the engine. Read More »
When diagnosing a vehicle concern, and fault P130A ?Hide Cylinder? is found in the Engine Control Module (ECM), be aware that Engine Control Module (ECM) fault P130A ?Hide Cylinder? indicates a cylinder shut down and does not require ... Read More »
To clear static ECM fault P1250 ?Fuel Level Too Low?, add fuel to vehicle and complete a road test of at least 10 miles. Simply adding fuel without completing a road test may not allow fault to clear. Read More »
To clear static ECM fault P1250 ?Fuel Level Too Low?, add fuel to vehicle and complete a road test of at least 10 miles. Simply adding fuel without completing a road test may not allow fault to clear. Read More »
ENGINE AND ENGINE COOLING:ENGINE:ENGINE CONTROL MODULE (ECU/ECM):SOFTWARE
Tech Tips (2.0L CCTA/CBFA Coolant Leak or Repeat Coolant Leak from the Water Pump Area): Inspect the water pump for signs of contact with engine oil. Engine oil may cause the water pump gasket to swell, which may lead to a coolant leak. Read More »
Tech Tips (2.0L CCTA/CBFA Coolant Leak or Repeat Coolant Leak from the Water Pump Area): This document informs of the observations that need to be taken to service a water pump replacement Read More »
VOLKSWAGEN: DUE TO CHANGE IN COOLANT AND ENGINE OIL PART NUMBERS CHECK/REPLACE OIL COOLER. ON SOME VEHICLES WITH 2.0I TFSI ENGINE LEAKS ON THE OIL COOLER CAN OCCUR BECAUSE OF A PRODUCTION FAULT. Read More »
ENGINE AND ENGINE COOLING:COOLING SYSTEM:RADIATOR ASSEMBLY
Tech Tips (2.0L CCTA/CBFA Coolant Leak or Repeat Coolant Leak from the Water Pump Area): Inspect the water pump for signs of contact with engine oil. Engine oil may cause the water pump gasket to swell, which may lead to a coolant leak. Read More »
Technical Bulletin (Rattling Noises from Engine Compartment Area or Exhaust System): Customers may complain of a rattling noise from engine or exhaust area while accelerating from 1800-3000 RPM. Read More »
VOLKSWAGEN: EXHAUST HEAT SHIELD, REPLACEMENT GUIDELINES. HEAT SHIELDS ARE TO BE INSPECTED AFTER COMPLETION O ANY TYPE OF REPAIR TO THE UNDERBODY (EXHAUST SYSTEM TRANSMISSION, ETC.), AND IF DAMAGED, REPLACED. Read More »
ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL
VOLKSWAGEN:EVAPORATIVE (EVAP) EMISSION SYSTEM, DIAGNOSTIC TROUBLE CODE DIAGNOSIS. REVISED PROCEDURE DEVELOPED TO TEST EVAP SYSTEM WITHOUT FUEL CAP. *JS Read More »
ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL:CRANKCASE (PCV)
VOLKSWAGEN: SEE DOCUMENT SEARCH BUTTON FOR OWNER LETTER. UPDATE- 17D2 POSITIVE CRANKCASE VENTILATION VALVE. IT IS MANDATORY TO PERFORM UPDATES ON ALL APPLICABLE VEHICLES IN DEALER INVENTORY PRIOR TO RETAIL SALE. Read More »
VOLKSWAGEN: SEE DOCUMENT SEARCH BUTTON FOR OWNER LETTER. INFORMATION PERTAINING TO SOME VEHICLES INTAKE MANIFOLD RUNNER CONTROL MOTOR AND THE PCV, POSITIVE CRANKCASE VENTILATION VALVE WARRANTY. Read More »
VOLKSWAGEN: SEE DOCUMENT SEARCH BUTTON FOR OWNER LETTER. INFORMATION PERTAINING TO SOME MODEL YEAR VEHICLES REGARDING THE FUEL PRESSURE SENSOR, CRANKCASE VENTILATION (PCV) VALVE AND INTAKE MANIFOLD RUNNER CONTROL MOTOR. Read More »
ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:MANIFOLD/HEADER/MUFFLER/TAIL PIPE
Supersedes Technical Bulletin 24-17 03 (V241703) dated March 6, 2017 for information regarding a new style solenoid valve for Intake Manifold Flap Read More »
Technical Bulletin (Intake Manifold Faults Stored in ECM Fault Memory issues): This document informs of a failure of Intake manifold causing fault codes to be stored in the ECM. The production solution improved intake manifold design. Read More »
Technical Bulletin (Intake Manifold Fault issues): This document informs of Intake Manifold issues that are recognized in the ECM fault memory. The Production Solution to this issue was an improved intake manifold design. Read More »
Technical Bulletin (Intake Manifold issues): This document informs of a failure of Intake manifold causing fault codes to be stored in the ECM. The fault codes are written in the document. Read More »
VOLKSWAGEN: SEE DOCUMENT SEARCHBUTTON FOR OWNER LETTER. UPDATE- 24W2 INTAKE FLAP MOTOR. PERFORM THIS UPDATE ON ALL APPLICABLE VEHICLES WITHIN INTAKE MANIFOLD RUNNER CONTROL WARRANTY EXT (10 YEARS OR 120,000 MILES (192, 000KM), ... Read More »
Technical Bulletin: High Pressure Fuel Pump Diagnosis. Completing the GFF high pressure pump function test is essential to diagnose proper pump operation and to avoid unnecessary replacements. Read More »
Technical Bulletin (High Pressure Fuel Pump Diagnosis): Completing the GFF high pressure pump function test is essential to diagnose proper pump operation and to avoid unnecessary replacements Read More »
Technical Bulletin (High Pressure Fuel Pump Diagnosis): Completing the GFF high pressure pump function test is essential to diagnose proper pump operation and to avoid unnecessary replacements. Read More »
Tech Tips (Lean Fuel Trim Readings): This document informs on the procedure to diagnose for issues with excess fuel trim, and what needs to be serviced Read More »
Technical Bulletin (High Pressure Fuel Pump Diagnosis): Completing the GFF high pressure pump function test is essential to diagnose proper pump operation and to avoid unnecessary replacements. Read More »
VOLKSWAGEN: MIL ON DTCS P310B, P129F, P008B, P129E, P008A, P2540 OR P0087 STORED IN ECM FAULT MEMORY. MIL ON AND ONE OR MORE OF THE FOLLOWING DTCS ARE STORED IN THE ECM DATA MEMORY. *JS Read More »
VOLKSWAGEN: THERE MAY BE A FALSE SIGNAL SENT TO CONTROLLER CAUSING AN OUT OF TOLERANCE READING DUE TO FUEL INTRUSION TO LOW PRESSURE SYSTEM FUEL PRESSURE SENSOR. *PE Read More »
VOLKSWAGEN: SOME VEHICLES MAY EXPERIENCE LOW PRESSURE SYSTEM FUEL PRESSURE SENSOR DUE TO FUEL INTRUSION, PROVIDING A FALSE SIGNAL SENT TO CONTROLLER SHOWING AN OUT OF TOLERANCE READING. *PE Read More »
VOLKSWAGEN: DUE TO FUEL INTRUSION INTO THE LOW PRESSURE SIDE FUEL PRESSURE SENSOR G410, A FALSE SIGNAL MAY BE SENT TO THE ECM RESULTING IN A READING THAT IS OUT OF TOLERANCE. *PE Read More »
VOLKSWAGEN: DIAGNOSIS FOR HIGH PRESSURE FUEL PUMP WHERE NO START, ENGINE CRANK, WITHOUT DRIVING, AFTER LONG PERIODS AND MAY HAVE ROUGH RUNNING ENGINE. MODELS 2008-2014 EOS, GTI, BEETLE CONVERTIBLE, JETTA, CC, PASSAT, TIGUAN, BEETLE. Read More »
VOLKSWAGEN: ON SOME VEHICLES, LOW FUEL STORED IN ECM PRESSURE, ENGINE WOULD CRANK BUT NOT START LONG PERIODS WITHOUT DRIVING, MAY RUN ROUGH AND/OR MIL ON. ALL MODELS 2008-2013. *PE Read More »
FUEL SYSTEM, GASOLINE:DELIVERY:HOSES, LINES/PIPING, AND FITTINGS
Fuel Additive to Help Prevent Sporadic Misfire Faults A Volkswagen approved fuel additive is available to help remove and prevent deposits on fuel injectors and intake valves. Read More »
Tech Tips (CBEA, CJAA, CKRA engine codes DPF replacement and/or DTCS P2413, P2463): This document informs of the use of aftermarket air filters such as cotton bed steel mesh or cone style, can cause the MAF sensor to not read ... Read More »
Tech Tips (CBEA, CJAA, CKRA engine codes DPF replacement and/or DTCS P2413, P2463): This document informs of the use of aftermarket air filters such as cotton bed steel mesh or cone style, can cause the MAF sensor to not read ... Read More »
VOLKSWAGEN: SOME VEHICLES MAY EXPERIENCE LOW PRESSURE SYSTEM FUEL PRESSURE SENSOR DUE TO FUEL INTRUSION, PROVIDING A FALSE SIGNAL SENT TO CONTROLLER SHOWING AN OUT OF TOLERANCE READING. *PE Read More »
To clear static ECM fault P1250 ?Fuel Level Too Low?, add fuel to vehicle and complete a road test of at least 10 miles. Simply adding fuel without completing a road test may not allow fault to clear. Read More »
To clear static ECM fault P1250 ?Fuel Level Too Low?, add fuel to vehicle and complete a road test of at least 10 miles. Simply adding fuel without completing a road test may not allow fault to clear. Read More »
VOLKSWAGEN: SOME VEHICLES MAY EXPERIENCE LOW PRESSURE SYSTEM FUEL PRESSURE SENSOR DUE TO FUEL INTRUSION, PROVIDING A FALSE SIGNAL SENT TO CONTROLLER SHOWING AN OUT OF TOLERANCE READING. *PE Read More »
VOLKSWAGEN: SEE DOCUMENT SEARCH BUTTON FOR OWNER LETTER. INFORMATION PERTAINING TO SOME MODEL YEAR VEHICLES REGARDING THE FUEL PRESSURE SENSOR, CRANKCASE VENTILATION (PCV) VALVE AND INTAKE MANIFOLD RUNNER CONTROL MOTOR. Read More »
VOLKSWAGEN: SEE DOCUMENT SEARCH BUTTON FOR OWNER LETTER. UPDATE- 24W3 FUEL PRESSURE SENSOR. PERFORM THIS UPDATE ON ALL APPLICABLE VEHICLES WITHIN FUEL PRESSURE SENSOR WARRANTY EXT (10 YEARS 120,000 MILES (192, 000KM), WHICHEVER OCCURS ... Read More »
VOLKSWAGEN: MIL ON, DTC P129F AND/OR P310B STORED IN ECM FAULT MEMORY. DUE TO FUEL INTRUSION INTO THE LOW PRESSURE SIDE FUEL PRESSURE SENSOR-G410, A FALSE SIGNAL MAY BE SENT TO THE ECM RESULTING IN A READING THAT IS OUT OF TOLERANCE. Read More »
Tech Tips (ECM Fault P1250 "Fuel Level Too Low" Will Not Clear): This document informs to clear static ECM fault P1250 "Fuel Level Too Low", add fuel to vehicle and complete a road test of at least 10 miles. Read More »
VOLKSWAGEN: MIL ON, DTC P129F AND/OR P310B STORED IN ECM FAULT MEMORY. DUE TO FUEL INTRUSION INTO THE LOW PRESSURE SIDE FUEL PRESSURE SENSOR-G410, A FALSE SIGNAL MAY BE SENT TO THE ECM RESULTING IN A READING THAT IS OUT OF TOLERANCE. Read More »
VOLKSWAGEN: DUE TO FUEL INTRUSION INTO THE LOW PRESSURE SIDE FUEL PRESSURE SENSOR G410, A FALSE SIGNAL MAY BE SENT TO THE ECM RESULTING IN A READING THAT IS OUT OF TOLERANCE. *PE Read More »
VOLKSWAGEN: DIAGNOSIS FOR HIGH PRESSURE FUEL PUMP WHERE NO START, ENGINE CRANK, WITHOUT DRIVING, AFTER LONG PERIODS AND MAY HAVE ROUGH RUNNING ENGINE. MODELS 2008-2014 EOS, GTI, BEETLE CONVERTIBLE, JETTA, CC, PASSAT, TIGUAN, BEETLE. Read More »
VOLKSWAGEN: ON SOME VEHICLES, LOW FUEL STORED IN ECM PRESSURE, ENGINE WOULD CRANK BUT NOT START LONG PERIODS WITHOUT DRIVING, MAY RUN ROUGH AND/OR MIL ON. ALL MODELS 2008-2013. *PE Read More »
Incorrect torque converter or flywheel/flexplate installation can result in transmission damage. When installing an engine, flywheel or transmission, please follow the installation procedures outlined in ELSA. Read More »
Tech Tips (Lean Fuel Trim Readings): This document informs to recheck the crankcase vacuum at idle. If low, check for additional oil leaks and verify crankcase breather operation (repairing as necessary). Read More »
Technical Bulletin (ECM, TCM Software Update and Valve Body Replacement for Harsh Up - Down Shift from Transmission when Cold): Customer may experience harsh up shift in gears 1-2 and 2-3, or harsh down shift in gears 3-2 and 2-1. Read More »
Technical Bulletin (ECM, TCM Software Update and Valve Body Replacement for Harsh Up - Down Shift from Transmission when Cold): Customer may experience harsh up shift in gears 1-2 and 2-3, or harsh down shift in gears 3-2 and 2-1. Read More »
Technical Bulletin (ECM, TCM Software Update and Valve Body Replacement for Harsh Up - Down Shift from Transmission when Cold): Customer may experience harsh up shift in gears 1-2 and 2-3, or harsh down shift in gears 3-2 and 2-1. Read More »
Technical Bulletin (ECM, TCM Software Update and Valve Body Replacement for Harsh Up - Down Shift from Transmission when Cold): Customer may experience harsh up shift in gears 1-2 and 2-3, or harsh down shift in gears 3-2 and 2-1. Read More »
When servicing the timing chain sprocket or removing the vibration damper, be aware that one bolt holds both the vibration damper (harmonic balancer) and the crankshaft timing chain sprocket to the crankshaft. Read More »
Transmission Control Module Updates: This document informs of the software, and technical bulletins that service corresponding cars and their Transmission Control Module complaint issues. Read More »
Transmission Control Module Updates: This document informs of the software, and technical bulletins that service corresponding cars and their Transmission Control Module complaint issues. Read More »
VOLKSWAGEN SERVICE CAMPAIGN: SEE DOCUMENT SEARCH BUTTON FOR OWNER LETTER. IN SOME VEHICLES IT IS POSSIBLE THAT A BUSHING INSIDE THE MECHATRONIC UNIT HAS THE POTENTIAL TO WEAR OUT PREMATURELY, CAUSING THE CLUTCHES INSIDE THE ... Read More »
VOLKSWAGEN: ON CERTAIN MODEL YEAR VEHICLES, EXPERIENCING HARSH UP/DOWN SHIFT IN GEARS 1-2, 2-3 OR 3-2, 2-1. ESPECIALLY DURING TEMPERATURES BELOW 60 C (140 F). Read More »
VOLKSWAGEN: THE INTAKE FLAP MOTOR OR INTAKE MANIFOLD RUNNER POSITION SENSOR G336 MAY BE INOPERATIVE (BOTH ARE INCLUDED IN ONE SINGLE UNIT). MODELS GOLF, GTI, A5 JETTA, GLI, EOS, PASSAT, PASSAT WAGON. *PE UPDATED 9/25/09. Read More »
POWER TRAIN:AUTOMATIC TRANSMISSION:CONTROL MODULE:SOFTWARE
Tech Tips (Torque Converter/Flywheel/Flexplate installation): Incorrect torque converter or flywheel/flexplate installation can result in transmission damage. Read More »
Technical Bulletin (Engine, Misfire Diagnostic Aid): This document informs that Multiple components SHOULD NOT be replaced for 1 misfiring cylinder. Repeat repairs must be carefully addressed to identify the root cause of the concern. Read More »
Technical Bulletin: High Pressure Fuel Pump Diagnosis. Completing the GFF high pressure pump function test is essential to diagnose proper pump operation and to avoid unnecessary replacements. Read More »
Tech Tips (Heated Rear Window, One or More Lines Inoperative): To detect which line(s) is inoperative, utilize a volt meter to check for 0 V, which will be present after the open in the grid line. Read More »
Technical Bulletin (High Pressure Fuel Pump Diagnosis): Completing the GFF high pressure pump function test is essential to diagnose proper pump operation and to avoid unnecessary replacements Read More »
Technical Bulletin (P2014 or P2015 Intake Manifold Faults Stored in ECM Fault Memory ): Document discusses diagnosis Codes necessary to diagnosis, and potential remedy of issue. Read More »
When performing SVM updates, the scan tool should be hardwired to the vehicle and the Bluetooth physically turned off. A hard wired internet connection is also recommended. Read More »
Tech Tips (Fault Code 02543 000 Present in ABS): Fault code 02543 000 ?Brake Vacuum Sensor no Display? may be encountered in the ABS module. Read More »
Technical Bulletin (Electric Coolant Fans Continue to Run after Ignition is Switched OFF): This documentation informs it is considered normal operation for the electric coolant fans to continue to run for up to 15 minutes after the ... Read More »
Tech Tips (Comfort Module (J393) or BCM (J519) Replacement): This document informs if a comfort or body control module is replaced during normal diagnosis, make sure the factory mode has been switched OFF. Read More »
The DLC is intended for use with diagnostic scan tools and by emissions testing stations. However, aftermarket devices (i.e., drive data recorders) that connect to the DLC have now become available. Read More »
Tech Tips (Comfort Module (J393) or BCM (J519) Replacement): This document informs If a comfort or body control module is replaced during normal diagnosis, make sure the factory mode has been switched OFF. Read More »
Tech Tips (Engine Control Module Fault P130A ?Hide Cylinder?): This document informs that DTC P130A ?Hide Cylinder? indicates that excessive misfiring has occurred. Read More »
When replacing the complete vehicle lock set (all vehicle keys and lock cylinders) for any reason, be aware that the ?Adapt keys? test plan will not allow the new keys to adapt to the vehicle. Read More »
To detect which line(s) is inoperative, utilize a volt meter to check for 0 V, which will be present after the open in the grid line. The check must be performed with the engine running and heated rear window switched on. Read More »
Use of aftermarket air filters such as cotton bed steel mesh or cone style, can cause the MAF sensor to not read accurately, affecting vehicle performance and critical monitoring functions for the diesel particulate filter. Read More »
Quick Reference Update Guide: This document informs of the corresponding software/hardware and disc availability to the customer concerns about a vehicle Read More »
Quick Reference Update Guide: This document informs of the corresponding software/hardware and disc availability to the customer concerns about a vehicle Read More »
When diagnosing a vehicle concern, and fault P130A ?Hide Cylinder? is found in the Engine Control Module (ECM), be aware that Engine Control Module (ECM) fault P130A ?Hide Cylinder? indicates a cylinder shut down and does not require ... Read More »
When diagnosing a generator charging concern, it is recommended to verify operation of the one way clutch located in the generator pulley (if equipped) before replacing generator assembly. Read More »
If fault code 03200 or 16352 is present in the Electromechanical Parking Brake (EPB) module, it may be due to the switch and module not being synchronized. Read More »
Engine Control Module Updates: This document informs of complaints, and the software updates / Tech Bulletins associated with servicing engine control module issues: Read More »
Engine Control Module Updates: This document informs of complaints, and the software updates/Tech Bulletins associated with servicing engine control module issues: Read More »
Body/Infotainment Module Software Updates: This document informs of various complaints that were addressed in software updates, and technical bulletins. Read More »
Transmission Control Module Updates: This document informs of the software, and technical bulletins that service corresponding cars and their Transmission Control Module complaint issues. Read More »
Body/Infotainment Module Software Updates: This document informs of various complaints that were addressed in software updates, and technical bulletins. Read More »
If, after replacement of the steering rack, fault code 01309 008 is set in the ABS/ESP module only, follow the test plan in GFF for Driver Steering Recommendation (DSR) or channel 3 activation. Read More »
VOLKSWAGEN: THE POSITIVE BATTERY CABLE ON PASSAT VEHICLES WITH V6 ENGINE MAY CORRODE AND IN INDIVIDUAL CASES BREAK. AS A RESULT, THE POWER SUPPLY MAY BE DISRUPTED AND E.G. THE VEHICLE CANNOT BE STARTED. Read More »
VOLKSWAGEN: SEE DOCUMENT SEARCH BUTTON FOR OWNER LETTER. INSPECT, AND IF NECESSARY, REPLACE POSITIVE BATTERY CABLE. VEHICLES AFFECTED BY THIS ACTION MAY HAVE A POSITIVE BATTERY CABLE THAT MAY CORRODE AND, IN RARE CASES, BREAK. Read More »
VOLKSWAGEN: THE POSITIVE BATTERY CABLE ON VEHICLES MAY CORRODE AND IN INDIVIDUAL CASES BREAK. AS A RESULT, THE POWER SUPPLY MAY BE DISRUPTED AND E.G. THE VEHICLE CANNOT BE STARTED. Read More »
VOLKSWAGEN: THE POSITIVE BATTERY CABLE ON PASSAT VEHICLES WITH V6 ENGINE MAY CORRODE AND IN INDIVIDUAL CASES BREAK. AS A RESULT, THE POWER SUPPLY MAY BE DISRUPTED AND E.G. THE VEHICLE CANNOT BE STARTED. Read More »
VOLKSWAGEN: THIS IS TO INFORM YOU OF THE RELEASE OF A NEW REQUIRED VEHICLE UPDATE. CHECK AND, IF NECESSARY, REPLACE POSITIVE BATTERY CABLE. MODELS PASSAT, PASSAT WAGON, PASSAT CC. Read More »
2006-2008 WITH 2.0L (BPY) UPDATE SERVICE NUMBER IN WARRANTY TABLE. 2008-2009 ALL MODELS WITH 2.0L (CCTA,CBFA) UPDATE SERVICE NUMBER IN WARRANTY TABLE. Read More »
Technical Bulletin: This document has the fault codes to trouble shoot Intake Manifold Faults. It also contains the claim codes for warranty coverage Read More »
VOLKSWAGEN: HVAC BLOWER ONLY OPERATES ON HIGH SPEED (US ONLY). FRESH AIR BLOWER RUNS ONLY AT HIGHEST LEVEL. BECAUSE OF PERMANENT FROST AND SNOWFALL FINE SNOW CAN GET INTO THE FRESH AIR BLOWER VIA THE AIR INTAKE. Read More »
To detect which line(s) is inoperative, utilize a volt meter to check for 0 V, which will be present after the open in the grid line. The check must be performed with the engine running and heated rear window switched on. Read More »
If key blade is found to stick or bind when opening or closing, check position of roll pin that secures key blade to mechanism. If roll pin is sticking out on either side (as shown below), do not replace key. Read More »
Tech Tips (Instrument Cluster Production Mode): This document informs the procedure to remove the production mode setting when it is displayed in the instrument cluster. Read More »
Tech Tips (Instrument Cluster Production Mode): During PDI, or after installation of a replacement cluster, ?Pro? may be displayed in place of the odometer. The high beam indicator may be flashing in the instrument cluster as well. Read More »
ELECTRICAL SYSTEM:INSTRUMENT PANEL:SPEEDOMETER/ODOMETER:SENSOR/SENDING UNIT
"Instructional document regarding the installation of a hotfix for the ODIS service software. Hotfix is to be used during the following actions: Brake Electronics (ABS) A3 Passat NMS Software ... Read More »
As a result, in order to ensure proper diagnostic procedure completions and log submissions as required by Takata Airbag Recall 69Q9, all diagnostic devices in service must be updated to V2.36.5 prior to performing the recall procedures. Read More »
Quick Reference of vehicle concerns. Includes a list of Software versions and the technical bulletin numbers that referred to the concerns Updated Read More »
Quick Reference Update Guide of the vehicles expected upgraded software level. The latest corresponding technical bulletins that address the issues, and concerns that have been had with the vehicles. Read More »
Quick Reference of vehicle concerns. Includes a list of Software versions and the technical bulletin numbers that referred to the concerns Updated Read More »
Tech Tips (SVM Update Instructions): This document informs when performing SVM updates, the scan tool should be hardwired to the vehicle and the Bluetooth physically turned off. A hard wired internet connection is also recommended. Read More »
Tech Tips (Electro ? Steering - DTC 01309 008 ?No Communication with -J500-? is Stored in the ABS/ESP Module Only): This document informs If, after replacement of the steering rack, fault code 01309 008 is set in the ABS/ESP module only, ... Read More »
Quick Reference Update Guide: This document informs of the corresponding software/hardware and disc availability to the customer concerns about a vehicle Read More »
Quick Reference Update Guide: This document informs of the corresponding software/hardware and disc availability to the customer concerns about a vehicle Read More »
Technical Bulletin This Technical Bulletin details the general process for carrying out a Software Version Management (SVM) software update for any Technical Bulletin (TSB) / Required Vehicle Update (RVU). Read More »
Technical Bulletin (ECM, TCM Software Update and Valve Body Replacement for Harsh Up - Down Shift from Transmission when Cold): Customer may experience harsh up shift in gears 1-2 and 2-3, or harsh down shift in gears 3-2 and 2-1. Read More »
Technical Bulletin (ECM, TCM Software Update and Valve Body Replacement for Harsh Up - Down Shift from Transmission when Cold): Customer may experience harsh up shift in gears 1-2 and 2-3, or harsh down shift in gears 3-2 and 2-1. Read More »
VOLKSWAGEN: ON CERTAIN MODEL YEAR VEHICLES, EXPERIENCING HARSH UP/DOWN SHIFT IN GEARS 1-2, 2-3 OR 3-2, 2-1. ESPECIALLY DURING TEMPERATURES BELOW 60 C (140 F). Read More »
Technical Bulletin: Condensation and or water droplets becomming visible on inside of exterior light lenses issue is discussed in this document Read More »
Technical Bulletin (Exterior Lights, Moisture Accumulation): This document informs of the Condensation and or water droplets visible on inside of exterior light lenses. The document also informs how to service the issue. Read More »
Technical Bulletin (Exterior Lights, Moisture Accumulation): Exterior light assemblies (headlights, taillights, fog lights, turn signals) are vented and may collect moisture on their inner surfaces, depending on humidity and other ... Read More »
Technical Bulletin (Windshield Wipers Streak or Smear): Windshield or rear window is streaked, has a snakeskin appearance, or the surface feels rough. Read More »
Technical Bulletin (Wiper Blade Inspection for Proper Warranty Coding): Wiper blade inspection guidelines for wear and tear, outside influence and factory defect. Read More »
Tech Tips (Heated Rear Window, One or More Lines Inoperative): To detect which line(s) is inoperative, utilize a volt meter to check for 0 V, which will be present after the open in the grid line. Read More »
Technical Bulletin (Rear Door Glass Inoperative): The rear glass cannot be opened / closed, the rear glass may slide down into the door, or the rear glass motor operates but the glass does not move. Read More »
Tech Tips (Heated Rear Window, One or More Lines Inoperative): To detect which line(s) is inoperative, utilize a volt meter to check for 0 V, which will be present after the open in the grid line. Read More »
Technical Bulletin (Wiper Blade Inspection for Proper Warranty Coding): Wiper blade inspection guidelines for wear and tear, outside influence or a factory issue. This document informs what is under coverage for wiper blade issues. Read More »
Technical Bulletin (Wiper Blade Inspection for Proper Warranty Coding): Wiper blade inspection guidelines for wear and tear, outside influence and factory defect. Read More »
Cleaning of Heating and Ventilation system, Updated to include additional model year applicability and cost of cleaning solution in warranty table. Read More »
Tech Tips (Heated Rear Window, One or More Lines Inoperative): To detect which line(s) is inoperative, utilize a volt meter to check for 0 V, which will be present after the open in the grid line. Read More »
VISIBILITY:DEFROSTER/DEFOGGER/HVAC SYSTEM:REAR WINDOW:ELECTRICAL HEATING ELEMENT
To detect which line(s) is inoperative, utilize a volt meter to check for 0 V, which will be present after the open in the grid line. The check must be performed with the engine running and heated rear window switched on. Read More »
In conjunction with the Massachusetts DMV, Volkswagen will be sending Takata airbag recall reminder notices to approximately 1,498 Volkswagen owners in the State of Massachusetts on March 13, 2023. Read More »
In conjunction with the New Mexico DMV, Volkswagen will be sending Takata airbag recall reminder notices to approximately 363 Volkswagen owners in the State of New Mexico on March 13, 2023. Read More »
In conjunction with the Colorado DMV, Volkswagen will be sending Takata airbag recall reminder notices to approximately 1,414 Volkswagen owners in the State of Colorado on February 13, 2023. Read More »
In conjunction with the New York DMV, Volkswagen will be sending Takata airbag recall reminder notices to approximately 2,743 Volkswagen owners in the State of New York on October 17, 2022. Read More »
In conjunction with the South Carolina Department of Public Safety, Volkswagen is sending Takata airbag recall reminder notices to approximately 1,824 Volkswagen owners in the state of South Carolina on September 19, 2022. Read More »
In conjunction with the Georgia Department of Revenue - Motor Vehicle Division and Department of Driver Services, Volkswagen sent Takata airbag recall reminder notices to approximately 158 Volkswagen owners in the State of Puerto Rico ... Read More »
In conjunction with the Georgia Department of Revenue - Motor Vehicle Division and Department of Driver Services, Volkswagen sent Takata airbag recall reminder notices to approximately 158 Volkswagen owners in the State of Puerto Rico on ... Read More »
In conjunction with the Virginia DMV, Audi will be sending Takata airbag recall reminder notices to approximately 2,217 VW owners in the State of Virginia on July 21, 2022 Read More »
In conjunction with the Georgia Department of Revenue - Motor Vehicle Division and Department of Driver Services, Volkswagen sent Takata airbag recall reminder notices to approximately 4,588 Volkswagen owners in the State of Georgia on ... Read More »
In conjunction with the California Department of Motor Vehicles (DMV), Volkswagen sent Takata airbag recall reminder notices to approximately 7,152 Volkswagen owners in the State of California on April 29, 2022. Read More »
In conjunction with the Alabama Law Enforcement Agency (ALEA), Volkswagen is sending Takata airbag recall reminder notices to approximately 1,387 Volkswagen owners in the State of Alabama on March 23, 2022. Read More »
In conjunction with the Pennsylvania Department of Transportation, Volkswagen is sending Takata airbag recall reminder notices to approximately 4,041 Volkswagen owners in the state of Pennsylvania on January 24, 2022. Read More »
In conjunction with the South Carolina Department of Public Safety, Volkswagen is sending Takata airbag recall reminder notices to approximately 1,571 Volkswagen owners in the state of South Carolina on January 24, 2022. Read More »
In conjunction with the Idaho DMV, Volkswagen will be sending Takata airbag recall reminder notices to approximately 406 Volkswagen owners in the State of Idaho on August 30, 2021. Read More »
In conjunction with the New York DMV, Volkswagen will be sending Takata airbag recall reminder notices to approximately 4,206 Volkswagen owners in the State of New York on June 21, 2021. Read More »
In conjunction with the Texas DMV, Volkswagen will be sending Takata airbag recall reminder notices to approximately 12,375 Volkswagen owners in the State of Texas on May 17, 2021. Read More »
In conjunction with the Michigan Department of State, Volkswagen will be sending Takata airbag recall reminder notices to approximately 3,000 Volkswagen owners in the State of Michigan on August 10, 2020. Read More »
In conjunction with the County of Fort Bend, Volkswagen will be sending Takata airbag recall reminder notices to approximately 640 Volkswagen owners in the State of Texas on July 28, 2020. Read More »
In conjunction with the Tennessee DMV, Volkswagen will be sending Takata airbag recall reminder notices to approximately 4,400 Volkswagen owners in the State of Tennessee July 7, 2020. Read More »
In conjunction with the City of Miramar, Volkswagen sent Takata airbag recall reminder notices to approximately 218 Volkswagen owners in the State of Florida on June 26, 2020. Read More »
In conjunction with the Nebraska DMV, Volkswagen will be sending Takata airbag recall reminder notices to approximately 600 Volkswagen owners in the State of Nebraska on March 23, 2020. Read More »
In conjunction with the Ohio DMV, Volkswagen will be sending Takata airbag recall reminder notices to approximately 9,000 Volkswagen owners in the State of Ohio on February 10, 2020. Read More »
In conjunction with the Georgia DMV, Volkswagen will be sending Takata airbag recall reminder notices to approximately 7,900 Volkswagen owners in the State of Georgia on January 24, 2020. Read More »
In conjunction with the South Carolina Department of Public Safety, Volkswagen sent Takata airbag recall reminder notices to approximately 2,800 Volkswagen owners in the state of South Carolina on January 20, 2020. Read More »
In conjunction with the California Bureau of Automotive Repair, Volkswagen sent Takata airbag recall reminder notices to approximately 21,100 Volkswagen owners in the state of California on January 14, 2020. Read More »
In conjunction with the Houston Dept. of Neighborhoods, Volkswagen will be sending Takata airbag recall reminder notices to approximately 4,600 Volkswagen owners in the state of Texas on November 4, 2019. Read More »
In conjunction with the Florida Dept. of Highway Safety and Motor Vehicles, Volkswagen will be sending Takata airbag recall reminder notices to approximately 20,200 Volkswagen owners in the state of Florida on October 14, 2019. Read More »
In conjunction with the Minnesota DMV, Volkswagen will be sending Takata airbag recall reminder notices to approximately 3,400 Volkswagen owners in the State of Minnesota on September 16, 2019. Read More »
In conjunction with the North Carolina DMV, Volkswagen will be sending Takata airbag recall reminder notices to approximately 7,400 Volkswagen owners in the State of North Carolina on August 19, 2019. Read More »
In conjunction with the Virginia DMV, Volkswagen will be sending Takata airbag recall reminder notices to approximately 6,235 Volkswagen owners in the State of Virginia on August 12, 2019. Read More »
In conjunction with the City of Compton, Volkswagen will be sending Takata airbag recall reminder notices to approximately 68 Volkswagen owners in the State of California on August 5, 2019. Read More »
Volkswagen will be sending Takata airbag recall reminder notices daily over a span of five business days to approximately 1,712 High Risk Volkswagen owners. Read More »
In conjunction with the Commonwealth of Kentucky Transportation Cabinet, Volkswagen will be sending Takata airbag recall reminder notices to approximately 2,592 Volkswagen owners in the state of Kentucky on July 15, 2019. Read More »
In conjunction with the Alabama Law Enforcement Agency, Volkswagen sent Takata airbag recall reminder notices to approximately 3,991 Volkswagen owners in Wisconsin on July 8, 2019. Read More »
In conjunction with the Alabama Law Enforcement Agency, Volkswagen sent Takata airbag recall reminder notices to approximately 3,200 Volkswagen owners in Alabama on June 17, 2019. Read More »
In conjunction with the New York Department of Motor Vehicles, Volkswagen will be sending Takata airbag recall reminder notices to approximately 11,500 Volkswagen owners in the state of New York on May 23, 2019. Read More »
As a result, in order to ensure proper diagnostic procedure completions and log submissions as required by Takata Airbag Recall 69Q9, all diagnostic devices in service must be updated to V2.36.5 prior to performing the recall procedures. Read More »
Campaign Parts Bulletin - 69M8 and 69M9 - Takata Part ordering process - On May 5th, a Campaign Parts Bulletin about the updated Takata part ordering process was sent to all dealers. Read More »
Campaign Parts Bulletin - 69M8 and 69M9 - Today, May 5th is the final standard weekly allocation of Takata airbag inflators. After this date, Takata allocations will be based on the previous week?s paid claim volume. Read More »
This document reminds dealers that Takata SDI Frontal Airbag Inflators replaced with the 69M9 Safety Recall will not be requested for return through the Warranty Parts Portal but will be requested for return through the Takata XPO Return ... Read More »
If, after replacement of the steering rack, fault code 01309 008 is set in the ABS/ESP module only, follow the test plan in GFF for Driver Steering Recommendation (DSR) or channel 3 activation. Read More »
Technical Bulletin (Corrosion on Rear Door in Trim Strip Area): Because of incomplete bonding of the trim strip water can get between trim strip and door. Because of water ingress, corrosion is possible in the area of the guide holes. Read More »
Technical Bulletin (Corrosion on the Front Door in Trim Strip Area): Because of incomplete bonding of the trim strip water can get between trim strip and door. Read More »
Technical Bulletin (Paint Finish, Reducing Swirl Marks and Fine Scratches): New vehicles (prior to Retail Delivery) with swirl marks and or fine scratches from polishing or cleaning. Read More »
Technical Bulletin (Hood, Under Hood Not Painted Body Color): The paint color and/or finish of the engine compartment and underside of hood may not match the exterior paint color of the vehicle. Read More »
Technical Bulletin (Front Suspension, Knocking Noise): A Knocking noise from vehicle front. Typically occurs only one time after each direction change (forward or backward, left or right). Read More »
VOLKSWAGEN: EXHAUST HEAT SHIELD, REPLACEMENT GUIDELINES. HEAT SHIELDS ARE TO BE INSPECTED AFTER COMPLETION O ANY TYPE OF REPAIR TO THE UNDERBODY (EXHAUST SYSTEM TRANSMISSION, ETC.), AND IF DAMAGED, REPLACED. Read More »
Technical Bulletin about Paint Finish, Reducing Swirl Marks and Fine Scratches New vehicles (prior to Retail Delivery) with swirl marks and or fine scratches from polishing or cleaning. Read More »
Technical Bulletin (Front Fender - Corrosion on Wheel Arch): The wheel liner touches the arch area of the fender and rubs off the paint in the contact area. The corrosion is caused by dirt accumulations and movements of the wheel liner. Read More »
The document refers to Corrosion being found where the rear bumper cover meets the quarter panel. It discusses how it can happen, and where to find warranty coverage to service the parts Read More »
58 16 03 June 13, 2016 2039212 Supersedes Technical Bulletin 581503 dated July 21, 2015 to update Claim Processing statement. Corrosion on Rear Door in Trim Strip Area Read More »
Technical Bulletin (Rear Door Glass Inoperative issue diagnosis): The rear glass cannot be opened / closed, the rear glass may slide down into the door, or the rear glass motor operates but the glass does not ... Read More »
Tech Tips (All vehicles-Tire dressing for vehicle detailing): The use of tire dressing gives your tires that shiny finish that completes the image of a clean (new) vehicle. Read More »
The use of tire dressing gives your tires that shiny finish that completes the image of a clean (new) vehicle. There are many different tire dressing products available. When choosing a product please pay close attention to its contents. Read More »
Document discusses issues with The wheel liner touches the arch area of the fender and rubs off the paint in the contact area. The corrosion is caused by dirt accumulations and movements of the wheel liner. Read More »
Technical Bulletin (Front Fender - Corrosion on Wheel Arch): The wheel liner touches the arch area of the fender and rubs off the paint in the contact area. The corrosion is caused by dirt accumulations and movements of the wheel liner. Read More »
Tech Tips (All vehicles-Tire dressing for vehicle detailing): The use of tire dressing gives your tires that shiny finish that completes the image of a clean (new) vehicle. Read More »
The use of tire dressing gives your tires that shiny finish that completes the image of a clean (new) vehicle. There are many different tire dressing products available. When choosing a product please pay close attention to its contents. Read More »
Elsa2Go campaign information is now 100% aligned with ElsaPro. This update to Elsa2Go ensures that both systems are displaying the same campaign information, including OPEN/CLOSED status, repair date as well as criterions at the same time ... Read More »
REMOVED all 12 hour wait period before starting references. ADDED EFB to "Select correct battery type" in bottom box. Also Jetta Wagon 2005 and 2018-2020 Tiguan LWB. Read More »
This special notice is to inform dealers to return all part numbers listed in the document and order the superseded part numbers going forward. Read More »
Technical Bulletin (Corrosion on Rear Door in Trim Strip Area): Because of incomplete bonding of the trim strip water can get between trim strip and door. Because of water ingress, corrosion is possible in the area of the guide holes. Read More »
Technical Bulletin (Corrosion on the Front Door in Trim Strip Area): Because of incomplete bonding of the trim strip water can get between trim strip and door. Read More »
This document contains the VW Elsa Newsletter that contains a general overview of wiring diagrams updates, ElsaPro infomedia icons grayed out, workshop equipment tool storage application, technical bulletins, pending service solutions, ... Read More »
When performing SVM updates, the scan tool should be hardwired to the vehicle and the Bluetooth physically turned off. A hard wired internet connection is also recommended. Read More »
Technical Bulletin (Exterior Lights, Moisture Accumulation): This document informs of the Condensation and or water droplets visible on inside of exterior light lenses. The document also informs how to service the issue. Read More »
Technical Bulletin (Squeaks, Rattles, Noise, Repair Materials): This doucment contains a list of components and applications developed to repair concerns of squeaks, rattles, noise and trim fit conditions. Read More »
When replacing the complete vehicle lock set (all vehicle keys and lock cylinders) for any reason, be aware that the ?Adapt keys? test plan will not allow the new keys to adapt to the vehicle. Read More »
Tech Tips (All Models 2000-2014 - Part ordering): If a needed service part is on back order, upgrade the daily order to a red order and check the ?Car Down? box to escalate the order. Read More »
Tech Tips (All Models 2000-2014 - Part ordering): If a needed service part is on back order, upgrade the daily order to a red order and check the ?Car Down? box to escalate the order. Read More »
If a needed service part is on back order, upgrade the daily order to a red order and check the ?Car Down? box to escalate the order. If parts assistance is needed, please call 800-767-6552 to speak with a VWGoA Parts Specialist. Read More »
If a needed service part is on back order, upgrade the daily order to a red order and check the ?Car Down? box to escalate the order. If parts assistance is needed, please call 800-767-6552 to speak with a VWGoA Parts Specialist. Read More »
Quick Reference Update Guide: This document informs of the corresponding software/hardware and disc availability to the customer concerns about a vehicle Read More »
In SAGA, the time units for the Volkswagen DoubleCheck labor operation were reduced in error from 50 time units to 30 time units during the system update posted on July 4th. Read More »
Passat Perfect Delivery Inspection (PDI) - Technician and Detailer Inspections: A checklist to insure a customer receives a wonderful delivery of a vehicle that looks, feels, and meets the expectations of a new vehicle that he/she has ... Read More »
Technical Bulletin (Wiper Blade Inspection for Proper Warranty Coding): Wiper blade inspection guidelines for wear and tear, outside influence and factory defect. Read More »
Tech Tips (ECM Fault P1250 "Fuel Level Too Low" Will Not Clear): This document informs to clear static ECM fault P1250 "Fuel Level Too Low", add fuel to vehicle and complete a road test of at least 10 miles. Read More »
When performing SVM updates, the scan tool should be hardwired to the vehicle and the Bluetooth physically turned off. A hard wired internet connection is also recommended. Read More »
This technical bulletin was updated per powertain team and warranty team. Info from this bulletin is combined with TB 2031075 (V241208) and 2038161 (V241506) due to warranty extension claiming/processing confusion. Read More »
This document contains the VW Elsa Newsletter that contains a general overview of wiring diagrams updates, technical bulletins, pending service solutions, tech tips, campaigns, updates, and suggestions. Read More »
This document contains the VW Elsa Newsletter that contains a general overview of wiring diagrams updates, ElsaPro infomedia icons grayed out, workshop equipment tool storage application, technical bulletins, pending service solutions, ... Read More »
Technical Bulletin: Condensation and or water droplets becomming visible on inside of exterior light lenses issue is discussed in this document Read More »
VOLKSWAGEN: SEE DOCUMENT SEARCH BUTTON FOR OWNER LETTER. AN EXTENSION WARRANTY, WITH SPECIFIC CONDITIONS, 10 YRS OR 120,000 MILES,WHICHEVER IS FIRST, HAS BEEN ISSUED FOR EMISSIONS CONTROL SYSTEMS WARRANTY FOR INTAKE MANIFOLD AND FUEL ... Read More »
Tech Tips (Lean Fuel Trim Readings): This document informs on the procedure to diagnose for issues with excess fuel trim, and what needs to be serviced Read More »
Passat Perfect Delivery Inspection (PDI) - Technician and Detailer Inspections: A checklist to insure a customer receives a wonderful delivery of a vehicle that looks, feels, and meets the expectations of a new vehicle that he/she has ... Read More »
Passat Perfect Delivery Inspection (PDI) - Technician and Detailer Inspections: A checklist to insure a customer receives a wonderful delivery of a vehicle that looks, feels, and meets the expectations of a new vehicle that he/she has ... Read More »
Tech Tips (Technician Helpline Vehicle Check Sheets): When it becomes necessary to open a VW Technician Helpline VTA case while performing diagnosis for a diesel particulate filter, manual transmission repair, or turbocharger concern, ... Read More »
Tech Tips (N75 Solenoid Valve Diagnosis): This document informs with a diagram which vacuum ports on the N75 valve should hold vacuum and which ones should not for diagnosis on the Vehicles with 2. Read More »
Technical Bulletin (Paint Finish, Reducing Swirl Marks and Fine Scratches): New vehicles (prior to Retail Delivery) with swirl marks and or fine scratches from polishing or cleaning. Read More »
Technical Bulletin (Paint Finish, Reducing Swirl Marks and Fine Scratches): New vehicles (prior to Retail Delivery) with swirl marks and or fine scratches from polishing or cleaning. Read More »
Technical Bulletin (Hood, Under Hood Not Painted Body Color): The paint color and/or finish of the engine compartment and underside of hood may not match the exterior paint color of the vehicle. Read More »
Technical Bulletin (Hood, Under Hood Not Painted Body Color): The paint color and/or finish of the engine compartment and underside of hood may not match the exterior paint color of the vehicle. Read More »
Engine Control Module Updates: This document informs of complaints, and the software updates / Tech Bulletins associated with servicing engine control module issues: Read More »
Technical Bulletin (Front Suspension, Knocking Noise): A Knocking noise from vehicle front. Typically occurs only one time after each direction change (forward or backward, left or right). Read More »
Tech Tips ("Steering Column Defective? Message on MFI): Be aware that the MFI message ?Steering Column Defective? does not necessary indicate the electronic steering column lock (ESCL) requires replacement. Read More »
Body/Infotainment Module Software Updates: This document informs of various complaints that were addressed in software updates, and technical bulletins. Read More »
Transmission Control Module Updates: This document informs of the software, and technical bulletins that service corresponding cars and their Transmission Control Module complaint issues. Read More »
Document discusses Corrosion that may be found on the folded edge of the hood. The corrosion may be found on this edge anywhere around the hood. It discusses how to service it, and document that service. Read More »
Technical Bulletin (Paint Finish, Reducing Swirl Marks and Fine Scratches): New vehicles (prior to Retail Delivery) with swirl marks and or fine scratches from polishing or cleaning. Read More »
Technical Bulletin (Hood, Under Hood Not Painted Body Color): The paint color and/or finish of the engine compartment and underside of hood may not match the exterior paint color of the vehicle. Read More »
DIRECTION TO PERFORM SYSTEM RESET AFTER COMPONENT REPLACMENT OR DISCONNECT OF THE HVAC SYSTEM CONTROL HEAD. NO TEST PLAN INFORMATION TO ADDRESS THIS. Read More »
DIRECTION TO PERFORM SYSTEM RESET AFTER COMPONENT REPLACMENT OR DISCONNECT OF THE HVAC SYSTEM CONTROL HEAD. NO TEST PLAN INFORMATION TO ADDRESS THIS. Read More »
Technical Bulletin (Air Conditioning, Cleaning of the Refrigerant Circuit (U.S.Only)): In cases where an air conditioning system component (such as a compressor or other system component) has failed and debris from the compressor or ... Read More »
Technical Bulletin (Air Conditioning, Cleaning of the Refrigerant Circuit): In cases where an air conditioning system component (such as a compressor or other system component) has failed and debris from the compressor or component is ... Read More »
VOLKSWAGEN: CHILD RESTRAINT LATCH GUIDANCE FIXTURE; COMPLIANCE WITH FMVSS 225 (USA ONLY). UPDATE TO EXISTING TECHNICAL BULLETIN. NO PRODUCTION CHANGE REQUIRED. ALL MODELS. *PE Read More »
VOLKSWAGEN: CHILD RESTRAINT LATCH GUIDANCE FIXTURE; COMPLIANCE WITH FMVSS 225 (USA ONLY). UPDATE TO EXISTING TECHNICAL BULLETIN. NO PRODUCTION CHANGE REQUIRED. ALL MODELS. *PE Read More »
Fault code 02543 000 ?Brake Vacuum Sensor no Display? may be encountered in the ABS module. This may be caused by the hydraulic brake boost function (HBV) in adaptation value 61 being turned off (value = 0). Read More »
VOLKSWAGEN: SEE DOCUMENT SEARCH BUTTON FOR OWNER LETTER. AN EXTENSION WARRANTY, WITH SPECIFIC CONDITIONS, 10 YRS OR 120,000 MILES,WHICHEVER IS FIRST, HAS BEEN ISSUED FOR EMISSIONS CONTROL SYSTEMS WARRANTY FOR INTAKE MANIFOLD AND FUEL ... Read More »
To detect which line(s) is inoperative, utilize a volt meter to check for 0 V, which will be present after the open in the grid line. The check must be performed with the engine running and heated rear window switched on. Read More »
To clear static ECM fault P1250 ?Fuel Level Too Low?, add fuel to vehicle and complete a road test of at least 10 miles. Simply adding fuel without completing a road test may not allow fault to clear. Read More »
To clear static ECM fault P1250 ?Fuel Level Too Low?, add fuel to vehicle and complete a road test of at least 10 miles. Simply adding fuel without completing a road test may not allow fault to clear. Read More »
VOLKSWAGEN: HVAC BLOWER ONLY OPERATES ON HIGH SPEED (US ONLY). FRESH AIR BLOWER RUNS ONLY AT HIGHEST LEVEL. BECAUSE OF PERMANENT FROST AND SNOWFALL FINE SNOW CAN GET INTO THE FRESH AIR BLOWER VIA THE AIR INTAKE. Read More »
