Technical Service Bulletins (TSBs) for the 2006 Passat are official communications between Volkswagen & their dealerships that describe processes for troubleshooting or fixing certain common problems.
All vehicle manufacturers are required by U.S. law to make their TSBs available to the public.
Tech Tips (Electro - Steering issues): If, after replacement of the steering rack, fault code 01309 008 is set in the ABS/ESP module only, follow the test plan in GFF for Driver Steering Recommendation (DSR) or channel 3 activation. Read More »
If replacing the high pressure fuel pump, also remove and inspect the cam follower from the timing cover/cylinder head to inspect it for wear. Read More »
Tech Tips ("Steering Column Defective? Message on MFI): Be aware that the MFI message ?Steering Column Defective? does not necessary indicate the electronic steering column lock (ESCL) requires replacement. Read More »
Tech Tips ("Steering Column Defective? Message on MFI): Be aware that the MFI message ?Steering Column Defective? does not necessary indicate the electronic steering column lock (ESCL) requires replacement. Read More »
If, after replacement of the steering rack, fault code 01309 008 is set in the ABS/ESP module only, follow the test plan in GFF for Driver Steering Recommendation (DSR) or channel 3 activation. Read More »
VOLKSWAGEN SERVICE CAMPAIGN: SEE DOCUMENT SEARCH BUTTON FOR OWNER LETTER. WHEN TRYING TO START THE VEHICLE THERE IS A LONG CRANK OR NO START CONDITION. 2009-2010 PASSAT. *RM Read More »
VOLKSWAGEN SERVICE CAMPAIGN: SEE DOCUMENT SEARCH BUTTON FOR OWNER LETTER. WHEN TRYING TO START THERE MAY BE AN EXTENDED CRANK OR NO START. 2006-2010 PASSAT. *RM Read More »
If, after replacement of the steering rack, fault code 01309 008 is set in the ABS/ESP module only, follow the test plan in GFF for Driver Steering Recommendation (DSR) or channel 3 activation. Read More »
Technical Bulletin (Front Suspension, Knocking Noise): A Knocking noise from vehicle front. Typically occurs only one time after each direction change (forward or backward, left or right). Read More »
VOLKSWAGEN: FRONT SUSPENSION, KNOCKING NOISE. KNOCKING NOISE FROM VEHICLE FRONT. TYPICALLY OCCURS ONLY ONE TIME AFTER EACH DIRECTION CHANGE (FORWARD OR BACKWARD, LEFT OR RIGHT). Read More »
Technical Bulletin (Front Suspension, Knocking Noise): A Knocking noise from vehicle front. Typically occurs only one time after each direction change (forward or backward, left or right). Read More »
If you have a complaint of DTCs for the low side fuel pressure being out of specification (e.g. P310B), check the fuel pressure with BOTH a mechanical gauge and by the display in Measured Value Block 103. Read More »
If replacing the high pressure fuel pump, also remove and inspect the cam follower from the timing cover/cylinder head to inspect it for wear. Read More »
VOLKSWAGEN: UPDATE INFORMATION ON MODELS AND MODEL YEARS REGARDING SYNCHRONIZATION OF ELECTROMECHANICAL PARKING BRAKE (EPB) MODULE AND DUE TO SWITCH AND MODULE NOT BEING SYNCHRONIZED, FAULT CODES FOUND. Read More »
SERVICE BRAKES, HYDRAULIC:POWER ASSIST:ELECTRIC:CONTROL MODULE
If, after replacement of the steering rack, fault code 01309 008 is set in the ABS/ESP module only, follow the test plan in GFF for Driver Steering Recommendation (DSR) or channel 3 activation. Read More »
SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP:WHEEL SPEED SENSOR
Fault code 02543 000 ?Brake Vacuum Sensor no Display? may be encountered in the ABS module. This may be caused by the hydraulic brake boost function (HBV) in adaptation value 61 being turned off (value = 0). Read More »
If you have a complaint of DTCs for the low side fuel pressure being out of specification (e.g. P310B), check the fuel pressure with BOTH a mechanical gauge and by the display in Measured Value Block 103. Read More »
If mechanical damage is found to the turbocharger (e.g. damaged compression wheel, loose or broken shaft), it is not enough to just replace the turbocharger. Read More »
If fault code 03200 or 16352 is present in the Electromechanical Parking Brake (EPB) module, it may be due to the switch and module not being synchronized. Read More »
If fault code 03200 or 16352 is present in the Electromechanical Parking Brake (EPB) module, it may be due to the switch and module not being synchronized. Read More »
If fault code 03200 or 16352 is present in the Electromechanical Parking Brake (EPB) module, it may be due to the switch and module not being synchronized. Read More »
2006-2008 WITH 2.0L (BPY) UPDATE SERVICE NUMBER IN WARRANTY TABLE. 2008-2009 ALL MODELS WITH 2.0L (CCTA,CBFA) UPDATE SERVICE NUMBER IN WARRANTY TABLE. Read More »
Technical Bulletin (Fuel Additive to Help Prevent Sporadic Misfire Faults): Fuel quality impacts the operating performance, efficiency and service life of the engine. Read More »
Technical Bulletin (Engine Oils Which Meet Volkswagen Oil Quality Standard): This document informs of a sample list of products generally available in the North American market that meet the Volkswagen Oil Quality ... Read More »
When diagnosis on the above engine leads to the testing of the N75, please refer to the picture below. The diagram shows which vacuum ports on the N75 valve should hold vacuum and which ones should not. Read More »
Tech Tips (2.0L FSI (BPY) Engines - Low Fuel Pressure DTCs (P310B)): This document informs on how to check fuel pressure If you have a complaint of DTCs for the low side fuel pressure being out of ... Read More »
Technical Bulletin The use of contaminated gasoline, seasonal fuel changes (summer/winter fuel) or gasoline with a low content of deposit control additives may result in one or more of the following conditions: -Excessive accumulation ... Read More »
Technical Bulletin (Oil Consumption Measurement): Customers have stated oil consumption is higher than the Volkswagen oil consumption standard of up to 0.5 quarts per 600 miles, or 0.5 liters per 1000 km. Read More »
2006 FLUID CAPACITY CHART This document contains information on what fluids, and how much for each of them are necessary to have a car up and running Read More »
In SAGA, the time units for the Volkswagen DoubleCheck labor operation were reduced in error from 50 time units to 30 time units during the system update posted on July 4th. Read More »
Tech Tips (N75 Solenoid Valve Diagnosis): This document informs with a diagram which vacuum ports on the N75 valve should hold vacuum and which ones should not for diagnosis on the Vehicles with 2. Read More »
Engine Control Module Updates: This document informs of complaints, and the software updates / Tech Bulletins associated with servicing engine control module issues: Read More »
Engine Control Module Updates: This document informs of complaints, and the software updates/Tech Bulletins associated with servicing engine control module issues: Read More »
17 17 01 July 5, 2017 2012855 Supersedes Technical Bulletin 17-16-02 (V171602) dated April 29, 2016 due to updated oil standards lists to current specifications. Read More »
Technical Bulletin (Air Conditioning, Cleaning of the Refrigerant Circuit (U.S.Only)): In cases where an air conditioning system component (such as a compressor or other system component) has failed and debris from the compressor or ... Read More »
Technical Bulletin (Electric Coolant Fans Continue to Run after Ignition is Switched OFF): This documentation informs it is considered normal operation for the electric coolant fans to continue to run for up to 15 minutes after the ... Read More »
Technical Bulletin (Electric Coolant Fans Continue to Run after Ignition is Switched OFF): This document informs it is considered normal operation for the electric coolant fans to continue to run for up to 15 minutes after the ignition ... Read More »
Technical Bulletin (Electric Coolant Fans Continue to Run after Ignition is Switched OFF): This document informs it is considered normal operation for the electric coolant fans to continue to run for up to 15 minutes after the ignition ... Read More »
Technical Bulletin (Oil Consumption Measurement): Customers have stated oil consumption is higher than the Volkswagen oil consumption standard of up to 0.5 quarts per 600 miles, or 0.5 liters per 1000 km. Read More »
Tech Tips (3.6L Passat with MIL ON, DTC P119A (lean conditions/vacuum leaks or a faulty MAF sensor reading)): This fault can set as a result of lean conditions/vacuum leaks or a faulty MAF sensor reading. Read More »
Technical Bulletin (Oil Consumption Measurement): Customer states oil consumption is higher than the Volkswagen oil consumption standard of up to 0.5 quarts per 600 miles, or 0.5 liters per 1000 km. Read More »
VOLKSWAGEN: SEE DOCUMENT SEARCH BUTTON FOR OWNER LETTER. INFORMATION PERTAINING TO SOME VEHICLES INTAKE MANIFOLD RUNNER CONTROL MOTOR AND THE PCV, POSITIVE CRANKCASE VENTILATION VALVE WARRANTY. Read More »
VOLKSWAGEN: CERTAIN MODEL YEAR VEHICLES MAY EXPERIENCE AN OIL FILLER CAP LEAKING, OR RUSHING NOISE FROM ENGINE OR A WHISTLING NOISE DUE TO CRANKCASE VENTILATION PRESSURE OR INTAKE TURBO PIPE MALFUNCTION. Read More »
VOLKSWAGEN: GASOLINE ENGINE VEHICLES INSPECT, AND IF NECESSARY, REPLACE IGNITION COILS. VEHICLES AFFECTED BY THIS ACTION MAY HAVE IGNITION COILS THAT COULD MALFUNCTION UNDER CERTAIN CONDITIONS. Read More »
VOLKSWAGEN: MIL ON OR FLASHING, MISFIRE DTCS P0300-0312 STORED IN ECM. THE MISFIRE CONDITION MAY BE CAUSED BY A MALFUNCTIONING IGNITION COIL. VEHICLES ARE OUT OF PRODUCTION. *PE Read More »
VOLKSWAGEN: VEHICLES MAY HAVE IGNITION COILS THAT COULD MALFUNCTION UNDER CERTAIN CONDITIONS. IF THIS HAPPENS, THE MALFUNCTION INDICATOR LAMP (MIL) WILL ILLUMINATED TO LET YOU KNOW THAT THE VEHICLE MAY EXPERIENCE SOME DETERIORATION IN ... Read More »
VOLKSWAGEN: THE INTAKE FLAP MOTOR OR INTAKE MANIFOLD RUNNER POSITION SENSOR G336 MAY BE INOPERATIVE (BOTH ARE INCLUDED IN ONE SINGLE UNIT). MODELS GOLF, GTI, A5 JETTA, GLI, EOS, PASSAT, PASSAT WAGON. *PE UPDATED 9/25/09. Read More »
VOLKSWAGEN: MIL ON, DTC P0299 STORED IN ECM FAULT MEMORY. CHARGE PRESSURE CONTROL, NEGATIVE DEVIATION. THE CONDITION MAY BE THE RESULT OF AN ABNORMAL TURBOCHARGER RECIRCULATIONG VALVE. *PE Read More »
VOLKSWAGEN: DUE TO FUEL INTRUSION INTO THE LOW PRESSURE SIDE FUEL PRESSURE SENSOR G410, A FALSE SIGNAL MAY BE SENT TO THE ECM RESULTING IN A READING THAT IS OUT OF TOLERANCE. Read More »
Tech Tips 92006-2014 Vehicles with 2.0T Gasoline Engine - N75 Solenoid Valve Diagnosis): When diagnosis on the above engine leads to the testing of the N75, please refer this document with graphical aid. Read More »
Tech Tips (Equipped with Turbocharged Engine Turbocharger Replacement Tip): If mechanical damage is found to the turbocharger (e.g. damaged compression wheel, loose or broken shaft), it is not enough to just replace the turbocharger. Read More »
Technical Bulletin (Fuel Rail / System Pressure, Fuel Trim, and Fuel Pressure issues): This document informs of Excessive wear of intake camshaft lobe that drives the high pressure fuel pump. Read More »
Technical Bulletin (Fuel Additive to Help Prevent Sporadic Misfire Faults): Fuel quality impacts the operating performance, efficiency and service life of the engine. Read More »
To clear static ECM fault P1250 ?Fuel Level Too Low?, add fuel to vehicle and complete a road test of at least 10 miles. Simply adding fuel without completing a road test may not allow fault to clear. Read More »
To clear static ECM fault P1250 ?Fuel Level Too Low?, add fuel to vehicle and complete a road test of at least 10 miles. Simply adding fuel without completing a road test may not allow fault to clear. Read More »
ENGINE AND ENGINE COOLING:ENGINE:ENGINE CONTROL MODULE (ECU/ECM):SOFTWARE
DTC'S P1297 (17705) OR P1557 (17965) STORED IN DTC MEMORY. THIS MAY BE CAUSED BY INTAKE HOSES LEAKING (DURING BOOST CONDITIONS) DUE TO INCORRECT TORQUE ON CLAMPS OR IMPROPER PLACEMENT, WORN OR TORN INTAKE HOSES. Read More »
COOLANT HOSE RETENTION CLIP (B9). CUSTOMER MAY REPORT A COOLANT ODOR, DRIPS AND POSSIBLE COOLANT SEEPAGE OR LEAK DUE TO A MISALIGNED COOLANT HOSE RETENTION CLIP. *TT Read More »
VOLKSWAGEN: EXHAUST HEAT SHIELD, REPLACEMENT GUIDELINES. HEAT SHIELDS ARE TO BE INSPECTED AFTER COMPLETION O ANY TYPE OF REPAIR TO THE UNDERBODY (EXHAUST SYSTEM TRANSMISSION, ETC.), AND IF DAMAGED, REPLACED. Read More »
ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL
VOLKSWAGEN:EVAPORATIVE (EVAP) EMISSION SYSTEM, DIAGNOSTIC TROUBLE CODE DIAGNOSIS. REVISED PROCEDURE DEVELOPED TO TEST EVAP SYSTEM WITHOUT FUEL CAP. *JS Read More »
VOLKSWAGEN: GASOLINE ENGINE VEHICLES INSPECT, AND IF NECESSARY, REPLACE IGNITION COILS. VEHICLES AFFECTED BY THIS ACTION MAY HAVE IGNITION COILS THAT COULD MALFUNCTION UNDER CERTAIN CONDITIONS. Read More »
VOLKSWAGEN: SEE DOCUMENT SEARCH BUTTON FOR OWNER LETTER. UPDATE- 17D2 POSITIVE CRANKCASE VENTILATION VALVE. IT IS MANDATORY TO PERFORM UPDATES ON ALL APPLICABLE VEHICLES IN DEALER INVENTORY PRIOR TO RETAIL SALE. Read More »
VOLKSWAGEN: SEE DOCUMENT SEARCH BUTTON FOR OWNER LETTER. INFORMATION PERTAINING TO SOME VEHICLES INTAKE MANIFOLD RUNNER CONTROL MOTOR AND THE PCV, POSITIVE CRANKCASE VENTILATION VALVE WARRANTY. Read More »
ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL:GAS RECIRCULATION VALVE (EGR VALVE)
VOLKSWAGEN: MIL ON, DTC P0299 STORED IN ECM FAULT MEMORY. CHARGE PRESSURE CONTROL, NEGATIVE DEVIATION. THE CONDITION MAY BE THE RESULT OF AN ABNORMAL TURBOCHARGER RECIRCULATIONG VALVE. *PE Read More »
ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:MANIFOLD/HEADER/MUFFLER/TAIL PIPE
Supersedes Technical Bulletin 24-17 03 (V241703) dated March 6, 2017 for information regarding a new style solenoid valve for Intake Manifold Flap Read More »
VOLKSWAGEN: SEE DOCUMENT SEARCHBUTTON FOR OWNER LETTER. UPDATE- 24W2 INTAKE FLAP MOTOR. PERFORM THIS UPDATE ON ALL APPLICABLE VEHICLES WITHIN INTAKE MANIFOLD RUNNER CONTROL WARRANTY EXT (10 YEARS OR 120,000 MILES (192, 000KM), ... Read More »
Tech Tips (2.0 Turbo FSI (BPY) High Pressure Fuel Pump Replacement): If replacing the high pressure fuel pump, also remove and inspect the cam follower from the timing cover/cylinder head to inspect it for wear. Read More »
Tech Tips (2.0 Turbo FSI (BPY) High Pressure Fuel Pump Replacement): If replacing the high pressure fuel pump, also remove and inspect the cam follower from the timing cover/cylinder head to inspect it for wear. Read More »
VOLKSWAGEN: MALFUNCTION LIGHT IS ON WITH THREE POSSIBLE TROUBLE CODES STORED. THERE IS WEAR OF THE CAMSHAFT LOBE CAUSING FUEL PRESSURE FLUCTUATIONS. *RM Read More »
VOLKSWAGEN: DUE TO FUEL INTRUSION INTO THE LOW PRESSURE SIDE FUEL PRESSURE SENSOR G410, A FALSE SIGNAL MAY BE SENT TO THE ECM RESULTING IN A READING THAT IS OUT OF TOLERANCE. *PE Read More »
VW: RVU-FUEL PRESSURE SENSOR REPLACEMENT (SAGA CODE 24M5/05. A MALFUNCTION OF FUEL PRESSURE SENSOR-G410-(LOW PRESSURE SIDE) MAY CAUSE AN INCORRECT FUEL PRESSURE READING FROM THE ECM. Read More »
VOLKSWAGEN: REMOVE AND INSPECT CAM FOLLOWER FROM TIMING COVER/CYLINDER HEAD, AFTER REPLACING HIGH PRESSURE FUEL PUMP, FOR ANY WEAR AND IF FOUND, NOTIFY DEALER TECHNICIAN FOR ADDITIONAL INSTRUCTIONS. Read More »
Tech Tips (2.0 Turbo FSI (BPY) High Pressure Fuel Pump Replacement): If replacing the high pressure fuel pump, also remove the cam follower from the timing cover/cylinder head and inspect for wear. Read More »
Tech Tips (2.0 Turbo FSI (BPY) High Pressure Fuel Pump Replacement): If replacing the high pressure fuel pump, also remove and inspect the cam follower from the timing cover/cylinder head to inspect it for wear. Read More »
VOLKSWAGEN: PRODUCTION PROBLEMS MAY MAKE CAMSHAFT COMPONENTS SUSCEPTIBLE TO PREMATURE WEAR. THIS COULD LEAD TO WEAR IN THE BASE OF THE HIGH PRESSURE FUEL PUMP CAMSHAFT FOLLOWER. THIS ISSUE DOES NOT CAUSE VEHICLE STALLING. Read More »
VOLKSWAGEN: FUEL PUMP REPLACEMENT CLARIFICATION. EXCESSIVE WEAR OF INTAKE CAMSHAFT LOBE THAT DRIVES THE HIGH PRESSURE FUEL PUMP. THE WEAR LIMITS MAXIMUM PUMP PISTON LIFT, CAUSING FUEL RAIL PRESSURE FLUCTUATIONS. Read More »
FUEL SYSTEM, GASOLINE:DELIVERY:HOSES, LINES/PIPING, AND FITTINGS
Fuel Additive to Help Prevent Sporadic Misfire Faults A Volkswagen approved fuel additive is available to help remove and prevent deposits on fuel injectors and intake valves. Read More »
VOLKSWAGEN: EXCESSIVE WEAR OF INTAKE CAMSHAFT LOBE CAUSING FUEL PRESSURE FLUCTUATIONS. IT CAN ALSO LEAD TO WEAR ON THE BASE OF THE FUEL PUMP CAM FOLLOWER. *RM Read More »
If replacing the high pressure fuel pump, also remove and inspect the cam follower from the timing cover/cylinder head to inspect it for wear. Read More »
To clear static ECM fault P1250 ?Fuel Level Too Low?, add fuel to vehicle and complete a road test of at least 10 miles. Simply adding fuel without completing a road test may not allow fault to clear. Read More »
To clear static ECM fault P1250 ?Fuel Level Too Low?, add fuel to vehicle and complete a road test of at least 10 miles. Simply adding fuel without completing a road test may not allow fault to clear. Read More »
Tech Tips (2.0 Turbo FSI (BPY) High Pressure Fuel Pump Replacement): If replacing the high pressure fuel pump, also remove and inspect the cam follower from the timing cover/cylinder head to inspect it for wear. Read More »
VW: RVU-FUEL PRESSURE SENSOR REPLACEMENT (SAGA CODE 24M5/05. A MALFUNCTION OF FUEL PRESSURE SENSOR-G410-(LOW PRESSURE SIDE) MAY CAUSE AN INCORRECT FUEL PRESSURE READING FROM THE ECM. Read More »
VOLKSWAGEN: MIL ON, DTC P129F AND/OR P310B STORED IN ECM FAULT MEMORY. DUE TO FUEL INTRUSION INTO THE LOW PRESSURE SIDE FUEL PRESSURE SENSOR-G410, A FALSE SIGNAL MAY BE SENT TO THE ECM RESULTING IN A READING THAT IS OUT OF TOLERANCE. Read More »
Tech Tips (ECM Fault P1250 "Fuel Level Too Low" Will Not Clear): This document informs to clear static ECM fault P1250 "Fuel Level Too Low", add fuel to vehicle and complete a road test of at least 10 miles. Read More »
VOLKSWAGEN: MIL ON, DTC P129F AND/OR P310B STORED IN ECM FAULT MEMORY. DUE TO FUEL INTRUSION INTO THE LOW PRESSURE SIDE FUEL PRESSURE SENSOR-G410, A FALSE SIGNAL MAY BE SENT TO THE ECM RESULTING IN A READING THAT IS OUT OF TOLERANCE. Read More »
VOLKSWAGEN: DUE TO FUEL INTRUSION INTO THE LOW PRESSURE SIDE FUEL PRESSURE SENSOR G410, A FALSE SIGNAL MAY BE SENT TO THE ECM RESULTING IN A READING THAT IS OUT OF TOLERANCE. *PE Read More »
VOLKSWAGEN: REMOVE AND INSPECT CAM FOLLOWER FROM TIMING COVER/CYLINDER HEAD, AFTER REPLACING HIGH PRESSURE FUEL PUMP, FOR ANY WEAR AND IF FOUND, NOTIFY DEALER TECHNICIAN FOR ADDITIONAL INSTRUCTIONS. Read More »
VOLKSWAGEN: ON SOME VEHICLES, THE HIGH PRESSURE FUEL PUMP, DRIVEN BY INTAKE CAMSHAFT LOBE, CAN WEAR EXCESSIVELY. FUEL RAIL PRESSURE FLUCTUATIONS CAUSED BY THE LIMITED PUMP PISTON LIFT. *PE Read More »
VOLKSWAGEN SERVICE CAMPAIGN: SEE DOCUMENT SEARCH BUTTON FOR OWNER LETTER. PRODUCTION ISSUES MAY CAUSE PREMATURE WEAR ON THE INTAKE CAMSHAFT AND CAMSHAFT FOLLOWER. MALFUNCTION LIGHT WILL ILLUMINATE. Read More »
Incorrect torque converter or flywheel/flexplate installation can result in transmission damage. When installing an engine, flywheel or transmission, please follow the installation procedures outlined in ELSA. Read More »
Transmission Control Module Updates: This document informs of the software, and technical bulletins that service corresponding cars and their Transmission Control Module complaint issues. Read More »
Transmission Control Module Updates: This document informs of the software, and technical bulletins that service corresponding cars and their Transmission Control Module complaint issues. Read More »
VOLKSWAGEN: THE INTAKE FLAP MOTOR OR INTAKE MANIFOLD RUNNER POSITION SENSOR G336 MAY BE INOPERATIVE (BOTH ARE INCLUDED IN ONE SINGLE UNIT). MODELS GOLF, GTI, A5 JETTA, GLI, EOS, PASSAT, PASSAT WAGON. *PE UPDATED 9/25/09. Read More »
Tech Tips (Torque Converter/Flywheel/Flexplate installation): Incorrect torque converter or flywheel/flexplate installation can result in transmission damage. Read More »
TECH TIP DENOTING POTENTIAL FOR DAMAGE OF THE DATA LINK CONNECTOR WHEN USING AFTER MARKET PLUG IN DEVICES OR SCAN TOOLS AND SUBSEQUENT DIAGNOSTIC DIRECTION. Read More »
Tech Tips (Heated Rear Window, One or More Lines Inoperative): To detect which line(s) is inoperative, utilize a volt meter to check for 0 V, which will be present after the open in the grid line. Read More »
When performing SVM updates, the scan tool should be hardwired to the vehicle and the Bluetooth physically turned off. A hard wired internet connection is also recommended. Read More »
Technical Bulletin (Electric Coolant Fans Continue to Run after Ignition is Switched OFF): This documentation informs it is considered normal operation for the electric coolant fans to continue to run for up to 15 minutes after the ... Read More »
Tech Tips (Comfort Module (J393) or BCM (J519) Replacement): This document informs if a comfort or body control module is replaced during normal diagnosis, make sure the factory mode has been switched OFF. Read More »
The DLC is intended for use with diagnostic scan tools and by emissions testing stations. However, aftermarket devices (i.e., drive data recorders) that connect to the DLC have now become available. Read More »
Tech Tips (Comfort Module (J393) or BCM (J519) Replacement): This document informs If a comfort or body control module is replaced during normal diagnosis, make sure the factory mode has been switched OFF. Read More »
Technical Bulletin (Internal Control Module Memory Check Sum Errors): This document contains Updates for the Engine Control Module using the SVM Unit code as listed in the document to address the Memory Check Sum Errors issue. Read More »
To detect which line(s) is inoperative, utilize a volt meter to check for 0 V, which will be present after the open in the grid line. The check must be performed with the engine running and heated rear window switched on. Read More »
Quick Reference Update Guide: This document informs of the corresponding software/hardware and disc availability to the customer concerns about a vehicle Read More »
Quick Reference Update Guide: This document informs of the corresponding software/hardware and disc availability to the customer concerns about a vehicle Read More »
Tech Tips (3.6L Passat with MIL ON, DTC P119A (lean conditions/vacuum leaks or a faulty MAF sensor reading)): This fault can set as a result of lean conditions/vacuum leaks or a faulty MAF sensor reading. Read More »
When diagnosing a generator charging concern, it is recommended to verify operation of the one way clutch located in the generator pulley (if equipped) before replacing generator assembly. Read More »
If fault code 03200 or 16352 is present in the Electromechanical Parking Brake (EPB) module, it may be due to the switch and module not being synchronized. Read More »
VOLKSWAGEN: NO TERMINAL 15 POWER, FAULT 02403-012. TERMINAL 15 RELAY ACTIVATION CAN BE CHECKED IN MEASURED VALUE BLOCKS FOR MODULE THAT CONTROLS RELAY, AND J519 VEHICLE ELECTRICAL SYSTEM CONTROL MODULE. Read More »
Engine Control Module Updates: This document informs of complaints, and the software updates / Tech Bulletins associated with servicing engine control module issues: Read More »
Engine Control Module Updates: This document informs of complaints, and the software updates/Tech Bulletins associated with servicing engine control module issues: Read More »
Body/Infotainment Module Software Updates: This document informs of various complaints that were addressed in software updates, and technical bulletins. Read More »
Transmission Control Module Updates: This document informs of the software, and technical bulletins that service corresponding cars and their Transmission Control Module complaint issues. Read More »
Body/Infotainment Module Software Updates: This document informs of various complaints that were addressed in software updates, and technical bulletins. Read More »
If, after replacement of the steering rack, fault code 01309 008 is set in the ABS/ESP module only, follow the test plan in GFF for Driver Steering Recommendation (DSR) or channel 3 activation. Read More »
2006 -2007 Rabbit/R32/GTI, 2005-2007 Jetta/Jetta Wagon, 2007-2008 Eos and 2006-2007 Passat/Passat Wagon Inspect Front Seat Side Impack Airbag Connectors & Install Wiring Harness Kit(s), if Necessary Read More »
VOLKSWAGEN: THE POSITIVE BATTERY CABLE ON PASSAT VEHICLES WITH V6 ENGINE MAY CORRODE AND IN INDIVIDUAL CASES BREAK. AS A RESULT, THE POWER SUPPLY MAY BE DISRUPTED AND E.G. THE VEHICLE CANNOT BE STARTED. Read More »
VOLKSWAGEN: SEE DOCUMENT SEARCH BUTTON FOR OWNER LETTER. INSPECT, AND IF NECESSARY, REPLACE POSITIVE BATTERY CABLE. VEHICLES AFFECTED BY THIS ACTION MAY HAVE A POSITIVE BATTERY CABLE THAT MAY CORRODE AND, IN RARE CASES, BREAK. Read More »
VOLKSWAGEN: THE POSITIVE BATTERY CABLE ON VEHICLES MAY CORRODE AND IN INDIVIDUAL CASES BREAK. AS A RESULT, THE POWER SUPPLY MAY BE DISRUPTED AND E.G. THE VEHICLE CANNOT BE STARTED. Read More »
VOLKSWAGEN: THE POSITIVE BATTERY CABLE ON PASSAT VEHICLES WITH V6 ENGINE MAY CORRODE AND IN INDIVIDUAL CASES BREAK. AS A RESULT, THE POWER SUPPLY MAY BE DISRUPTED AND E.G. THE VEHICLE CANNOT BE STARTED. Read More »
VOLKSWAGEN: THIS IS TO INFORM YOU OF THE RELEASE OF A NEW REQUIRED VEHICLE UPDATE. CHECK AND, IF NECESSARY, REPLACE POSITIVE BATTERY CABLE. MODELS PASSAT, PASSAT WAGON, PASSAT CC. Read More »
If replacing the high pressure fuel pump, also remove and inspect the cam follower from the timing cover/cylinder head to inspect it for wear. Read More »
2006-2008 WITH 2.0L (BPY) UPDATE SERVICE NUMBER IN WARRANTY TABLE. 2008-2009 ALL MODELS WITH 2.0L (CCTA,CBFA) UPDATE SERVICE NUMBER IN WARRANTY TABLE. Read More »
VOLKSWAGEN SERVICE CAMPAIGN: SEE DOCUMENT SEARCH BUTTON FOR OWNER LETTER. RESISTANCE IN THE AIR BAG SYSTEM CAN CAUSE THE AIR BAG LIGHT TO TURN ON EVEN THOUGH THERE IS NO PROBLEM. *RM UPDATED 4/9/13. Read More »
VOLKSWAGEN: GASOLINE ENGINE VEHICLES INSPECT, AND IF NECESSARY, REPLACE IGNITION COILS. VEHICLES AFFECTED BY THIS ACTION MAY HAVE IGNITION COILS THAT COULD MALFUNCTION UNDER CERTAIN CONDITIONS. Read More »
VOLKSWAGEN: MIL ON OR FLASHING, MISFIRE DTCS P0300-0312 STORED IN ECM. THE MISFIRE CONDITION MAY BE CAUSED BY A MALFUNCTIONING IGNITION COIL. VEHICLES ARE OUT OF PRODUCTION. *PE Read More »
VOLKSWAGEN: VEHICLES MAY HAVE IGNITION COILS THAT COULD MALFUNCTION UNDER CERTAIN CONDITIONS. IF THIS HAPPENS, THE MALFUNCTION INDICATOR LAMP (MIL) WILL ILLUMINATED TO LET YOU KNOW THAT THE VEHICLE MAY EXPERIENCE SOME DETERIORATION IN ... Read More »
To detect which line(s) is inoperative, utilize a volt meter to check for 0 V, which will be present after the open in the grid line. The check must be performed with the engine running and heated rear window switched on. Read More »
If key blade is found to stick or bind when opening or closing, check position of roll pin that secures key blade to mechanism. If roll pin is sticking out on either side (as shown below), do not replace key. Read More »
Tech Tips (Instrument Cluster Production Mode): This document informs the procedure to remove the production mode setting when it is displayed in the instrument cluster. Read More »
Tech Tips (Instrument Cluster Production Mode): During PDI, or after installation of a replacement cluster, ?Pro? may be displayed in place of the odometer. The high beam indicator may be flashing in the instrument cluster as well. Read More »
Quick Reference of vehicle concerns. Includes a list of Software versions and the technical bulletin numbers that referred to the concerns Updated Read More »
Quick Reference Update Guide of the vehicles expected upgraded software level. The latest corresponding technical bulletins that address the issues, and concerns that have been had with the vehicles. Read More »
TECH TIP DENOTING POTENTIAL FOR DAMAGE OF THE DATA LINK CONNECTOR WHEN USING AFTER MARKET PLUG IN DEVICES OR SCAN TOOLS AND SUBSEQUENT DIAGNOSTIC DIRECTION. Read More »
Quick Reference of vehicle concerns. Includes a list of Software versions and the technical bulletin numbers that referred to the concerns Updated Read More »
Tech Tips (SVM Update Instructions): This document informs when performing SVM updates, the scan tool should be hardwired to the vehicle and the Bluetooth physically turned off. A hard wired internet connection is also recommended. Read More »
Tech Tips (Electro ? Steering - DTC 01309 008 ?No Communication with -J500-? is Stored in the ABS/ESP Module Only): This document informs If, after replacement of the steering rack, fault code 01309 008 is set in the ABS/ESP module only, ... Read More »
Quick Reference Update Guide: This document informs of the corresponding software/hardware and disc availability to the customer concerns about a vehicle Read More »
Quick Reference Update Guide: This document informs of the corresponding software/hardware and disc availability to the customer concerns about a vehicle Read More »
Technical Bulletin This Technical Bulletin details the general process for carrying out a Software Version Management (SVM) software update for any Technical Bulletin (TSB) / Required Vehicle Update (RVU). Read More »
Technical Bulletin: Condensation and or water droplets becomming visible on inside of exterior light lenses issue is discussed in this document Read More »
Technical Bulletin (Exterior Lights, Moisture Accumulation): This document informs of the Condensation and or water droplets visible on inside of exterior light lenses. The document also informs how to service the issue. Read More »
Technical Bulletin (Exterior Lights, Moisture Accumulation): Exterior light assemblies (headlights, taillights, fog lights, turn signals) are vented and may collect moisture on their inner surfaces, depending on humidity and other ... Read More »
VOLKSWAGEN: SOME VEHICLES WITH XENON HEADLAMPS, CONDENSATION CAN OCCUR INSIDE THE XENON HEADLAMPS. VEHICLES WILL BE INSPECTED AND IF NECESSARY THE XENON HEADLAMP CAPS WILL BE REPLACED AND SPRING CLIPS INSTALLED. Read More »
VOLKSWAGEN SERVICE CAMPAIGN: SEE DOCUMENT SEARCH BUTTON FOR OWNER LETTER. 2006-2007 MODEL YEAR PASSAT & PASSAT WAGON WITH XENON HEADLAMPS - REPLACE HEADLAMP CAPS AND INSTALL SPRING CLIPS AND CHECK/REPLACE FRONT & REAR PARK DISTANCE ... Read More »
VOLKSWAGEN: SOME VEHICLES WITH XENON HEADLAMPS, CONDENSATION CAN OCCUR INSIDE THE XENON HEADLAMPS. VEHICLES WILL BE INSPECTED AND IF NECESSARY THE XENON HEADLAMP CAPS WILL BE REPLACED AND SPRING CLIPS INSTALLED. Read More »
Technical Bulletin (Windshield Wipers Streak or Smear): Windshield or rear window is streaked, has a snakeskin appearance, or the surface feels rough. Read More »
Tech Tips (Heated Rear Window, One or More Lines Inoperative): To detect which line(s) is inoperative, utilize a volt meter to check for 0 V, which will be present after the open in the grid line. Read More »
Technical Bulletin (Rear Door Glass Inoperative): The rear glass cannot be opened / closed, the rear glass may slide down into the door, or the rear glass motor operates but the glass does not move. Read More »
Tech Tips (Heated Rear Window, One or More Lines Inoperative): To detect which line(s) is inoperative, utilize a volt meter to check for 0 V, which will be present after the open in the grid line. Read More »
Tech Tips (Heated Rear Window, One or More Lines Inoperative): To detect which line(s) is inoperative, utilize a volt meter to check for 0 V, which will be present after the open in the grid line. Read More »
VISIBILITY:DEFROSTER/DEFOGGER/HVAC SYSTEM:REAR WINDOW:ELECTRICAL HEATING ELEMENT
To detect which line(s) is inoperative, utilize a volt meter to check for 0 V, which will be present after the open in the grid line. The check must be performed with the engine running and heated rear window switched on. Read More »
In conjunction with the Massachusetts DMV, Volkswagen will be sending Takata airbag recall reminder notices to approximately 1,498 Volkswagen owners in the State of Massachusetts on March 13, 2023. Read More »
In conjunction with the New Mexico DMV, Volkswagen will be sending Takata airbag recall reminder notices to approximately 363 Volkswagen owners in the State of New Mexico on March 13, 2023. Read More »
In conjunction with the Colorado DMV, Volkswagen will be sending Takata airbag recall reminder notices to approximately 1,414 Volkswagen owners in the State of Colorado on February 13, 2023. Read More »
In conjunction with the New York DMV, Volkswagen will be sending Takata airbag recall reminder notices to approximately 2,743 Volkswagen owners in the State of New York on October 17, 2022. Read More »
In conjunction with the South Carolina Department of Public Safety, Volkswagen is sending Takata airbag recall reminder notices to approximately 1,824 Volkswagen owners in the state of South Carolina on September 19, 2022. Read More »
In conjunction with the Georgia Department of Revenue - Motor Vehicle Division and Department of Driver Services, Volkswagen sent Takata airbag recall reminder notices to approximately 158 Volkswagen owners in the State of Puerto Rico ... Read More »
In conjunction with the Georgia Department of Revenue - Motor Vehicle Division and Department of Driver Services, Volkswagen sent Takata airbag recall reminder notices to approximately 158 Volkswagen owners in the State of Puerto Rico on ... Read More »
In conjunction with the Virginia DMV, Audi will be sending Takata airbag recall reminder notices to approximately 2,217 VW owners in the State of Virginia on July 21, 2022 Read More »
In conjunction with the Georgia Department of Revenue - Motor Vehicle Division and Department of Driver Services, Volkswagen sent Takata airbag recall reminder notices to approximately 4,588 Volkswagen owners in the State of Georgia on ... Read More »
In conjunction with the California Department of Motor Vehicles (DMV), Volkswagen sent Takata airbag recall reminder notices to approximately 7,152 Volkswagen owners in the State of California on April 29, 2022. Read More »
In conjunction with the Alabama Law Enforcement Agency (ALEA), Volkswagen is sending Takata airbag recall reminder notices to approximately 1,387 Volkswagen owners in the State of Alabama on March 23, 2022. Read More »
In conjunction with the Pennsylvania Department of Transportation, Volkswagen is sending Takata airbag recall reminder notices to approximately 4,041 Volkswagen owners in the state of Pennsylvania on January 24, 2022. Read More »
In conjunction with the South Carolina Department of Public Safety, Volkswagen is sending Takata airbag recall reminder notices to approximately 1,571 Volkswagen owners in the state of South Carolina on January 24, 2022. Read More »
In conjunction with the Idaho DMV, Volkswagen will be sending Takata airbag recall reminder notices to approximately 406 Volkswagen owners in the State of Idaho on August 30, 2021. Read More »
In conjunction with the New York DMV, Volkswagen will be sending Takata airbag recall reminder notices to approximately 4,206 Volkswagen owners in the State of New York on June 21, 2021. Read More »
In conjunction with the Texas DMV, Volkswagen will be sending Takata airbag recall reminder notices to approximately 12,375 Volkswagen owners in the State of Texas on May 17, 2021. Read More »
In conjunction with the Michigan Department of State, Volkswagen will be sending Takata airbag recall reminder notices to approximately 3,000 Volkswagen owners in the State of Michigan on August 10, 2020. Read More »
In conjunction with the County of Fort Bend, Volkswagen will be sending Takata airbag recall reminder notices to approximately 640 Volkswagen owners in the State of Texas on July 28, 2020. Read More »
In conjunction with the Tennessee DMV, Volkswagen will be sending Takata airbag recall reminder notices to approximately 4,400 Volkswagen owners in the State of Tennessee July 7, 2020. Read More »
In conjunction with the City of Miramar, Volkswagen sent Takata airbag recall reminder notices to approximately 218 Volkswagen owners in the State of Florida on June 26, 2020. Read More »
In conjunction with the Nebraska DMV, Volkswagen will be sending Takata airbag recall reminder notices to approximately 600 Volkswagen owners in the State of Nebraska on March 23, 2020. Read More »
In conjunction with the Ohio DMV, Volkswagen will be sending Takata airbag recall reminder notices to approximately 9,000 Volkswagen owners in the State of Ohio on February 10, 2020. Read More »
In conjunction with the Georgia DMV, Volkswagen will be sending Takata airbag recall reminder notices to approximately 7,900 Volkswagen owners in the State of Georgia on January 24, 2020. Read More »
In conjunction with the South Carolina Department of Public Safety, Volkswagen sent Takata airbag recall reminder notices to approximately 2,800 Volkswagen owners in the state of South Carolina on January 20, 2020. Read More »
In conjunction with the California Bureau of Automotive Repair, Volkswagen sent Takata airbag recall reminder notices to approximately 21,100 Volkswagen owners in the state of California on January 14, 2020. Read More »
In conjunction with the Houston Dept. of Neighborhoods, Volkswagen will be sending Takata airbag recall reminder notices to approximately 4,600 Volkswagen owners in the state of Texas on November 4, 2019. Read More »
In conjunction with the Florida Dept. of Highway Safety and Motor Vehicles, Volkswagen will be sending Takata airbag recall reminder notices to approximately 20,200 Volkswagen owners in the state of Florida on October 14, 2019. Read More »
In conjunction with the Minnesota DMV, Volkswagen will be sending Takata airbag recall reminder notices to approximately 3,400 Volkswagen owners in the State of Minnesota on September 16, 2019. Read More »
In conjunction with the North Carolina DMV, Volkswagen will be sending Takata airbag recall reminder notices to approximately 7,400 Volkswagen owners in the State of North Carolina on August 19, 2019. Read More »
In conjunction with the Virginia DMV, Volkswagen will be sending Takata airbag recall reminder notices to approximately 6,235 Volkswagen owners in the State of Virginia on August 12, 2019. Read More »
In conjunction with the City of Compton, Volkswagen will be sending Takata airbag recall reminder notices to approximately 68 Volkswagen owners in the State of California on August 5, 2019. Read More »
In conjunction with the Commonwealth of Kentucky Transportation Cabinet, Volkswagen will be sending Takata airbag recall reminder notices to approximately 2,592 Volkswagen owners in the state of Kentucky on July 15, 2019. Read More »
In conjunction with the Alabama Law Enforcement Agency, Volkswagen sent Takata airbag recall reminder notices to approximately 3,991 Volkswagen owners in Wisconsin on July 8, 2019. Read More »
In conjunction with the Alabama Law Enforcement Agency, Volkswagen sent Takata airbag recall reminder notices to approximately 3,200 Volkswagen owners in Alabama on June 17, 2019. Read More »
In conjunction with the New York Department of Motor Vehicles, Volkswagen will be sending Takata airbag recall reminder notices to approximately 11,500 Volkswagen owners in the state of New York on May 23, 2019. Read More »
Campaign Parts Bulletin - 69M8 and 69M9 - Takata Part ordering process - On May 5th, a Campaign Parts Bulletin about the updated Takata part ordering process was sent to all dealers. Read More »
Campaign Parts Bulletin - 69M8 and 69M9 - Today, May 5th is the final standard weekly allocation of Takata airbag inflators. After this date, Takata allocations will be based on the previous week?s paid claim volume. Read More »
2006 -2007 Rabbit/R32/GTI, 2005-2007 Jetta/Jetta Wagon, 2007-2008 Eos and 2006-2007 Passat/Passat Wagon Inspect Front Seat Side Impack Airbag Connectors & Install Wiring Harness Kit(s), if Necessary Read More »
If, after replacement of the steering rack, fault code 01309 008 is set in the ABS/ESP module only, follow the test plan in GFF for Driver Steering Recommendation (DSR) or channel 3 activation. Read More »
VOLKSWAGEN SERVICE CAMPAIGN: SEE DOCUMENT SEARCH BUTTON FOR OWNER LETTER. RESISTANCE IN THE AIR BAG SYSTEM CAN CAUSE THE AIR BAG LIGHT TO TURN ON EVEN THOUGH THERE IS NO PROBLEM. *RM UPDATED 4/9/13. Read More »
VOLKSWAGEN SERVICE CAMPAIGN: SEE DOCUMENT SEARCH BUTTON FOR OWNER LETTER. RESISTANCE IN THE AIR BAG SYSTEM CAN CAUSE THE AIR BAG LIGHT TO TURN ON EVEN THOUGH THERE IS NO PROBLEM. *RM UPDATED 4/9/13. Read More »
2006 -2007 Rabbit/R32/GTI, 2005-2007 Jetta/Jetta Wagon, 2007-2008 Eos and 2006-2007 Passat/Passat Wagon Inspect Front Seat Side Impack Airbag Connectors & Install Wiring Harness Kit(s), if Necessary Read More »
Technical Bulletin (Corrosion on Rear Door in Trim Strip Area): Because of incomplete bonding of the trim strip water can get between trim strip and door. Because of water ingress, corrosion is possible in the area of the guide holes. Read More »
Technical Bulletin (Corrosion on the Front Door in Trim Strip Area): Because of incomplete bonding of the trim strip water can get between trim strip and door. Read More »
Technical Bulletin (Paint Finish, Reducing Swirl Marks and Fine Scratches): New vehicles (prior to Retail Delivery) with swirl marks and or fine scratches from polishing or cleaning. Read More »
Technical Bulletin (Hood, Under Hood Not Painted Body Color): The paint color and/or finish of the engine compartment and underside of hood may not match the exterior paint color of the vehicle. Read More »
Technical Bulletin (Front Suspension, Knocking Noise): A Knocking noise from vehicle front. Typically occurs only one time after each direction change (forward or backward, left or right). Read More »
VOLKSWAGEN: EXHAUST HEAT SHIELD, REPLACEMENT GUIDELINES. HEAT SHIELDS ARE TO BE INSPECTED AFTER COMPLETION O ANY TYPE OF REPAIR TO THE UNDERBODY (EXHAUST SYSTEM TRANSMISSION, ETC.), AND IF DAMAGED, REPLACED. Read More »
Technical Bulletin about Paint Finish, Reducing Swirl Marks and Fine Scratches New vehicles (prior to Retail Delivery) with swirl marks and or fine scratches from polishing or cleaning. Read More »
Technical Bulletin (Front Fender - Corrosion on Wheel Arch): The wheel liner touches the arch area of the fender and rubs off the paint in the contact area. The corrosion is caused by dirt accumulations and movements of the wheel liner. Read More »
The document refers to Corrosion being found where the rear bumper cover meets the quarter panel. It discusses how it can happen, and where to find warranty coverage to service the parts Read More »
58 16 03 June 13, 2016 2039212 Supersedes Technical Bulletin 581503 dated July 21, 2015 to update Claim Processing statement. Corrosion on Rear Door in Trim Strip Area Read More »
Technical Bulletin (Rear Door Glass Inoperative issue diagnosis): The rear glass cannot be opened / closed, the rear glass may slide down into the door, or the rear glass motor operates but the glass does not ... Read More »
Tech Tips (All vehicles-Tire dressing for vehicle detailing): The use of tire dressing gives your tires that shiny finish that completes the image of a clean (new) vehicle. Read More »
The use of tire dressing gives your tires that shiny finish that completes the image of a clean (new) vehicle. There are many different tire dressing products available. When choosing a product please pay close attention to its contents. Read More »
Document discusses issues with The wheel liner touches the arch area of the fender and rubs off the paint in the contact area. The corrosion is caused by dirt accumulations and movements of the wheel liner. Read More »
Technical Bulletin (Front Fender - Corrosion on Wheel Arch): The wheel liner touches the arch area of the fender and rubs off the paint in the contact area. The corrosion is caused by dirt accumulations and movements of the wheel liner. Read More »
Tech Tips (All vehicles-Tire dressing for vehicle detailing): The use of tire dressing gives your tires that shiny finish that completes the image of a clean (new) vehicle. Read More »
The use of tire dressing gives your tires that shiny finish that completes the image of a clean (new) vehicle. There are many different tire dressing products available. When choosing a product please pay close attention to its contents. Read More »
Elsa2Go campaign information is now 100% aligned with ElsaPro. This update to Elsa2Go ensures that both systems are displaying the same campaign information, including OPEN/CLOSED status, repair date as well as criterions at the same time ... Read More »
REMOVED all 12 hour wait period before starting references. ADDED EFB to "Select correct battery type" in bottom box. Also Jetta Wagon 2005 and 2018-2020 Tiguan LWB. Read More »
This special notice is to inform dealers to return all part numbers listed in the document and order the superseded part numbers going forward. Read More »
Technical Bulletin (Corrosion on Rear Door in Trim Strip Area): Because of incomplete bonding of the trim strip water can get between trim strip and door. Because of water ingress, corrosion is possible in the area of the guide holes. Read More »
Technical Bulletin (Corrosion on the Front Door in Trim Strip Area): Because of incomplete bonding of the trim strip water can get between trim strip and door. Read More »
This document contains the VW Elsa Newsletter that contains a general overview of wiring diagrams updates, ElsaPro infomedia icons grayed out, workshop equipment tool storage application, technical bulletins, pending service solutions, ... Read More »
When performing SVM updates, the scan tool should be hardwired to the vehicle and the Bluetooth physically turned off. A hard wired internet connection is also recommended. Read More »
Technical Bulletin (Exterior Lights, Moisture Accumulation): This document informs of the Condensation and or water droplets visible on inside of exterior light lenses. The document also informs how to service the issue. Read More »
Technical Bulletin (Squeaks, Rattles, Noise, Repair Materials): This doucment contains a list of components and applications developed to repair concerns of squeaks, rattles, noise and trim fit conditions. Read More »
Tech Tips (All Models 2000-2014 - Part ordering): If a needed service part is on back order, upgrade the daily order to a red order and check the ?Car Down? box to escalate the order. Read More »
Tech Tips (All Models 2000-2014 - Part ordering): If a needed service part is on back order, upgrade the daily order to a red order and check the ?Car Down? box to escalate the order. Read More »
If a needed service part is on back order, upgrade the daily order to a red order and check the ?Car Down? box to escalate the order. If parts assistance is needed, please call 800-767-6552 to speak with a VWGoA Parts Specialist. Read More »
If a needed service part is on back order, upgrade the daily order to a red order and check the ?Car Down? box to escalate the order. If parts assistance is needed, please call 800-767-6552 to speak with a VWGoA Parts Specialist. Read More »
Tech Tips (2.0 Turbo FSI (BPY) High Pressure Fuel Pump Replacement): If replacing the high pressure fuel pump, also remove and inspect the cam follower from the timing cover/cylinder head to inspect it for wear. Read More »
Quick Reference Update Guide: This document informs of the corresponding software/hardware and disc availability to the customer concerns about a vehicle Read More »
2006 FLUID CAPACITY CHART This document contains information on what fluids, and how much for each of them are necessary to have a car up and running Read More »
In SAGA, the time units for the Volkswagen DoubleCheck labor operation were reduced in error from 50 time units to 30 time units during the system update posted on July 4th. Read More »
Passat Perfect Delivery Inspection (PDI) - Technician and Detailer Inspections: A checklist to insure a customer receives a wonderful delivery of a vehicle that looks, feels, and meets the expectations of a new vehicle that he/she has ... Read More »
Tech Tips (ECM Fault P1250 "Fuel Level Too Low" Will Not Clear): This document informs to clear static ECM fault P1250 "Fuel Level Too Low", add fuel to vehicle and complete a road test of at least 10 miles. Read More »
When performing SVM updates, the scan tool should be hardwired to the vehicle and the Bluetooth physically turned off. A hard wired internet connection is also recommended. Read More »
This technical bulletin was updated per powertain team and warranty team. Info from this bulletin is combined with TB 2031075 (V241208) and 2038161 (V241506) due to warranty extension claiming/processing confusion. Read More »
This document contains the VW Elsa Newsletter that contains a general overview of wiring diagrams updates, technical bulletins, pending service solutions, tech tips, campaigns, updates, and suggestions. Read More »
This document contains the VW Elsa Newsletter that contains a general overview of wiring diagrams updates, ElsaPro infomedia icons grayed out, workshop equipment tool storage application, technical bulletins, pending service solutions, ... Read More »
Technical Bulletin: Condensation and or water droplets becomming visible on inside of exterior light lenses issue is discussed in this document Read More »
A Volkswagen FLUID CAPACITY CHART which contains the various fluids necessary for a vehicle to run Cateorgories include (Engine Oil, Manual Transmission, Automatic Transmission, Differential Automatic Transmission, Cooling System, Power ... Read More »
2006 FLUID CAPACITY CHART This document contains information on what fluids, and how much for each of them are necessary to have a car up and running Read More »
2006 FLUID CAPACITY CHART This document contains information on what fluids, and how much for each of them are necessary to have a car up and running Read More »
Passat Perfect Delivery Inspection (PDI) - Technician and Detailer Inspections: A checklist to insure a customer receives a wonderful delivery of a vehicle that looks, feels, and meets the expectations of a new vehicle that he/she has ... Read More »
Passat Perfect Delivery Inspection (PDI) - Technician and Detailer Inspections: A checklist to insure a customer receives a wonderful delivery of a vehicle that looks, feels, and meets the expectations of a new vehicle that he/she has ... Read More »
Tech Tips (Technician Helpline Vehicle Check Sheets): When it becomes necessary to open a VW Technician Helpline VTA case while performing diagnosis for a diesel particulate filter, manual transmission repair, or turbocharger concern, ... Read More »
Tech Tips (N75 Solenoid Valve Diagnosis): This document informs with a diagram which vacuum ports on the N75 valve should hold vacuum and which ones should not for diagnosis on the Vehicles with 2. Read More »
Technical Bulletin (Paint Finish, Reducing Swirl Marks and Fine Scratches): New vehicles (prior to Retail Delivery) with swirl marks and or fine scratches from polishing or cleaning. Read More »
Technical Bulletin (Paint Finish, Reducing Swirl Marks and Fine Scratches): New vehicles (prior to Retail Delivery) with swirl marks and or fine scratches from polishing or cleaning. Read More »
Technical Bulletin (Hood, Under Hood Not Painted Body Color): The paint color and/or finish of the engine compartment and underside of hood may not match the exterior paint color of the vehicle. Read More »
Technical Bulletin (Hood, Under Hood Not Painted Body Color): The paint color and/or finish of the engine compartment and underside of hood may not match the exterior paint color of the vehicle. Read More »
Engine Control Module Updates: This document informs of complaints, and the software updates / Tech Bulletins associated with servicing engine control module issues: Read More »
Technical Bulletin (Front Suspension, Knocking Noise): A Knocking noise from vehicle front. Typically occurs only one time after each direction change (forward or backward, left or right). Read More »
Tech Tips ("Steering Column Defective? Message on MFI): Be aware that the MFI message ?Steering Column Defective? does not necessary indicate the electronic steering column lock (ESCL) requires replacement. Read More »
Body/Infotainment Module Software Updates: This document informs of various complaints that were addressed in software updates, and technical bulletins. Read More »
Transmission Control Module Updates: This document informs of the software, and technical bulletins that service corresponding cars and their Transmission Control Module complaint issues. Read More »
Document discusses Corrosion that may be found on the folded edge of the hood. The corrosion may be found on this edge anywhere around the hood. It discusses how to service it, and document that service. Read More »
Technical Bulletin (Paint Finish, Reducing Swirl Marks and Fine Scratches): New vehicles (prior to Retail Delivery) with swirl marks and or fine scratches from polishing or cleaning. Read More »
Technical Bulletin (Hood, Under Hood Not Painted Body Color): The paint color and/or finish of the engine compartment and underside of hood may not match the exterior paint color of the vehicle. Read More »
DIRECTION TO PERFORM SYSTEM RESET AFTER COMPONENT REPLACMENT OR DISCONNECT OF THE HVAC SYSTEM CONTROL HEAD. NO TEST PLAN INFORMATION TO ADDRESS THIS. Read More »
DIRECTION TO PERFORM SYSTEM RESET AFTER COMPONENT REPLACMENT OR DISCONNECT OF THE HVAC SYSTEM CONTROL HEAD. NO TEST PLAN INFORMATION TO ADDRESS THIS. Read More »
Technical Bulletin (Air Conditioning, Cleaning of the Refrigerant Circuit (U.S.Only)): In cases where an air conditioning system component (such as a compressor or other system component) has failed and debris from the compressor or ... Read More »
Technical Bulletin (Air Conditioning, Cleaning of the Refrigerant Circuit): In cases where an air conditioning system component (such as a compressor or other system component) has failed and debris from the compressor or component is ... Read More »
VOLKSWAGEN: CHILD RESTRAINT LATCH GUIDANCE FIXTURE; COMPLIANCE WITH FMVSS 225 (USA ONLY). UPDATE TO EXISTING TECHNICAL BULLETIN. NO PRODUCTION CHANGE REQUIRED. ALL MODELS. *PE Read More »
VOLKSWAGEN: CHILD RESTRAINT LATCH GUIDANCE FIXTURE; COMPLIANCE WITH FMVSS 225 (USA ONLY). UPDATE TO EXISTING TECHNICAL BULLETIN. NO PRODUCTION CHANGE REQUIRED. ALL MODELS. *PE Read More »
Fault code 02543 000 ?Brake Vacuum Sensor no Display? may be encountered in the ABS module. This may be caused by the hydraulic brake boost function (HBV) in adaptation value 61 being turned off (value = 0). Read More »
To detect which line(s) is inoperative, utilize a volt meter to check for 0 V, which will be present after the open in the grid line. The check must be performed with the engine running and heated rear window switched on. Read More »
To clear static ECM fault P1250 ?Fuel Level Too Low?, add fuel to vehicle and complete a road test of at least 10 miles. Simply adding fuel without completing a road test may not allow fault to clear. Read More »
To clear static ECM fault P1250 ?Fuel Level Too Low?, add fuel to vehicle and complete a road test of at least 10 miles. Simply adding fuel without completing a road test may not allow fault to clear. Read More »
VOLKSWAGEN SERVICE CAMPAIGN: SEE DOCUMENT SEARCH BUTTON FOR OWNER LETTER. 2006 MODEL YEAR PASSAT AND PASSAT WAGON - CHECK/REPLACE FRONT & REAR PARK ASSIST SENSORS. *NJ CSC WAS RECEIVED. UPDATED 3/20/08. Read More »
VOLKSWAGEN SERVICE CAMPAIGN: SEE DOCUMENT SEARCH BUTTON FOR OWNER LETTER. 2006-2007 MODEL YEAR PASSAT & PASSAT WAGON WITH XENON HEADLAMPS - REPLACE HEADLAMP CAPS AND INSTALL SPRING CLIPS AND CHECK/REPLACE FRONT & REAR PARK DISTANCE ... Read More »
VOLKSWAGEN: SOME VEHICLES FRONT AND REAR PARK ASSIST SENSORS (PARK DISTANCE CONTROL SENSORS) MAY NOT ALWAYS FUNCTION PROPERLY. DEALERS WILL INSPECT AND, IF NECESSARY, INSTALL NEW FRONT AND REAR PARK ASSIST SENSORS. Read More »
