Technical Service Bulletins (TSBs) for the 2007 Eos are official communications between Volkswagen & their dealerships that describe processes for troubleshooting or fixing certain common problems.
All vehicle manufacturers are required by U.S. law to make their TSBs available to the public.
Tech Tips (Electro - Steering issues): If, after replacement of the steering rack, fault code 01309 008 is set in the ABS/ESP module only, follow the test plan in GFF for Driver Steering Recommendation (DSR) or channel 3 activation. Read More »
If the steering rack is replaced on the above models for any reason, it is necessary to replace the steering harness as well. The new harness may be equipped with an extra connector. Read More »
If, after replacement of the steering rack, fault code 01309 008 is set in the ABS/ESP module only, follow the test plan in GFF for Driver Steering Recommendation (DSR) or channel 3 activation. Read More »
If the steering rack is replaced on the above models for any reason, it is necessary to replace the steering harness as well. The new harness may be equipped with an extra connector. Read More »
If, after replacement of the steering rack, fault code 01309 008 is set in the ABS/ESP module only, follow the test plan in GFF for Driver Steering Recommendation (DSR) or channel 3 activation. Read More »
If you have a complaint of DTCs for the low side fuel pressure being out of specification (e.g. P310B), check the fuel pressure with BOTH a mechanical gauge and by the display in Measured Value Block 103. Read More »
SERVICE BRAKES, HYDRAULIC:POWER ASSIST:ELECTRIC:CONTROL MODULE
If, after replacement of the steering rack, fault code 01309 008 is set in the ABS/ESP module only, follow the test plan in GFF for Driver Steering Recommendation (DSR) or channel 3 activation. Read More »
SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP:WHEEL SPEED SENSOR
If you have a complaint of DTCs for the low side fuel pressure being out of specification (e.g. P310B), check the fuel pressure with BOTH a mechanical gauge and by the display in Measured Value Block 103. Read More »
If mechanical damage is found to the turbocharger (e.g. damaged compression wheel, loose or broken shaft), it is not enough to just replace the turbocharger. Read More »
2006-2008 WITH 2.0L (BPY) UPDATE SERVICE NUMBER IN WARRANTY TABLE. 2008-2009 ALL MODELS WITH 2.0L (CCTA,CBFA) UPDATE SERVICE NUMBER IN WARRANTY TABLE. Read More »
Technical Bulletin (Fuel Additive to Help Prevent Sporadic Misfire Faults): Fuel quality impacts the operating performance, efficiency and service life of the engine. Read More »
Technical Bulletin (Engine Oils Which Meet Volkswagen Oil Quality Standard): This document informs of a sample list of products generally available in the North American market that meet the Volkswagen Oil Quality ... Read More »
When diagnosis on the above engine leads to the testing of the N75, please refer to the picture below. The diagram shows which vacuum ports on the N75 valve should hold vacuum and which ones should not. Read More »
Technical Bulletin (Oil Consumption Measurement): Customer states oil consumption is higher than the Volkswagen oil consumption standard of up to 0.5 quarts per 600 miles, or 0.5 liters per 1000 km. Read More »
Tech Tips (2.0L FSI (BPY) Engines - Low Fuel Pressure DTCs (P310B)): This document informs on how to check fuel pressure If you have a complaint of DTCs for the low side fuel pressure being out of ... Read More »
Technical Bulletin The use of contaminated gasoline, seasonal fuel changes (summer/winter fuel) or gasoline with a low content of deposit control additives may result in one or more of the following conditions: -Excessive accumulation ... Read More »
Technical Bulletin (Oil Consumption Measurement): Customers have stated oil consumption is higher than the Volkswagen oil consumption standard of up to 0.5 quarts per 600 miles, or 0.5 liters per 1000 km. Read More »
In SAGA, the time units for the Volkswagen DoubleCheck labor operation were reduced in error from 50 time units to 30 time units during the system update posted on July 4th. Read More »
Tech Tips (N75 Solenoid Valve Diagnosis): This document informs with a diagram which vacuum ports on the N75 valve should hold vacuum and which ones should not for diagnosis on the Vehicles with 2. Read More »
Engine Control Module Updates: This document informs of complaints, and the software updates / Tech Bulletins associated with servicing engine control module issues: Read More »
Engine Control Module Updates: This document informs of complaints, and the software updates/Tech Bulletins associated with servicing engine control module issues: Read More »
17 17 01 July 5, 2017 2012855 Supersedes Technical Bulletin 17-16-02 (V171602) dated April 29, 2016 due to updated oil standards lists to current specifications. Read More »
Technical Bulletin (Air Conditioning, Cleaning of the Refrigerant Circuit (U.S.Only)): In cases where an air conditioning system component (such as a compressor or other system component) has failed and debris from the compressor or ... Read More »
Technical Bulletin (Electric Coolant Fans Continue to Run after Ignition is Switched OFF): This documentation informs it is considered normal operation for the electric coolant fans to continue to run for up to 15 minutes after the ... Read More »
Technical Bulletin (Electric Coolant Fans Continue to Run after Ignition is Switched OFF): This document informs it is considered normal operation for the electric coolant fans to continue to run for up to 15 minutes after the ignition ... Read More »
Technical Bulletin (Electric Coolant Fans Continue to Run after Ignition is Switched OFF): This document informs it is considered normal operation for the electric coolant fans to continue to run for up to 15 minutes after the ignition ... Read More »
Technical Bulletin (Oil Consumption Measurement): Customers have stated oil consumption is higher than the Volkswagen oil consumption standard of up to 0.5 quarts per 600 miles, or 0.5 liters per 1000 km. Read More »
Technical Bulletin (Oil Consumption Measurement): Customer states oil consumption is higher than the Volkswagen oil consumption standard of up to 0.5 quarts per 600 miles, or 0.5 liters per 1000 km. Read More »
VOLKSWAGEN: SEE DOCUMENT SEARCH BUTTON FOR OWNER LETTER. INFORMATION PERTAINING TO SOME VEHICLES INTAKE MANIFOLD RUNNER CONTROL MOTOR AND THE PCV, POSITIVE CRANKCASE VENTILATION VALVE WARRANTY. Read More »
VOLKSWAGEN: SEE DOCUMENT SEARCH BUTTON FOR OWNER LETTER. INFORMATION PERTAINING TO SOME MODEL YEAR VEHICLES REGARDING THE FUEL PRESSURE SENSOR, CRANKCASE VENTILATION (PCV) VALVE AND INTAKE MANIFOLD RUNNER CONTROL MOTOR. Read More »
VOLKSWAGEN: CERTAIN MODEL YEAR VEHICLES MAY EXPERIENCE AN OIL FILLER CAP LEAKING, OR RUSHING NOISE FROM ENGINE OR A WHISTLING NOISE DUE TO CRANKCASE VENTILATION PRESSURE OR INTAKE TURBO PIPE MALFUNCTION. Read More »
VOLKSWAGEN: GASOLINE ENGINE VEHICLES INSPECT, AND IF NECESSARY, REPLACE IGNITION COILS. VEHICLES AFFECTED BY THIS ACTION MAY HAVE IGNITION COILS THAT COULD MALFUNCTION UNDER CERTAIN CONDITIONS. Read More »
VOLKSWAGEN: MIL ON OR FLASHING, MISFIRE DTCS P0300-0312 STORED IN ECM. THE MISFIRE CONDITION MAY BE CAUSED BY A MALFUNCTIONING IGNITION COIL. VEHICLES ARE OUT OF PRODUCTION. *PE Read More »
VOLKSWAGEN: VEHICLES MAY HAVE IGNITION COILS THAT COULD MALFUNCTION UNDER CERTAIN CONDITIONS. IF THIS HAPPENS, THE MALFUNCTION INDICATOR LAMP (MIL) WILL ILLUMINATED TO LET YOU KNOW THAT THE VEHICLE MAY EXPERIENCE SOME DETERIORATION IN ... Read More »
VOLKSWAGEN: THE INTAKE FLAP MOTOR OR INTAKE MANIFOLD RUNNER POSITION SENSOR G336 MAY BE INOPERATIVE (BOTH ARE INCLUDED IN ONE SINGLE UNIT). MODELS GOLF, GTI, A5 JETTA, GLI, EOS, PASSAT, PASSAT WAGON. *PE UPDATED 9/25/09. Read More »
VOLKSWAGEN: MIL ON, DTC P0299 STORED IN ECM FAULT MEMORY. CHARGE PRESSURE CONTROL, NEGATIVE DEVIATION. THE CONDITION MAY BE THE RESULT OF AN ABNORMAL TURBOCHARGER RECIRCULATIONG VALVE. *PE Read More »
VOLKSWAGEN: DUE TO FUEL INTRUSION INTO THE LOW PRESSURE SIDE FUEL PRESSURE SENSOR G410, A FALSE SIGNAL MAY BE SENT TO THE ECM RESULTING IN A READING THAT IS OUT OF TOLERANCE. Read More »
Tech Tips 92006-2014 Vehicles with 2.0T Gasoline Engine - N75 Solenoid Valve Diagnosis): When diagnosis on the above engine leads to the testing of the N75, please refer this document with graphical aid. Read More »
Tech Tips (Equipped with Turbocharged Engine Turbocharger Replacement Tip): If mechanical damage is found to the turbocharger (e.g. damaged compression wheel, loose or broken shaft), it is not enough to just replace the turbocharger. Read More »
Technical Bulletin (Fuel Rail / System Pressure, Fuel Trim, and Fuel Pressure issues): This document informs of Excessive wear of intake camshaft lobe that drives the high pressure fuel pump. Read More »
Technical Bulletin (Fuel Additive to Help Prevent Sporadic Misfire Faults): Fuel quality impacts the operating performance, efficiency and service life of the engine. Read More »
To clear static ECM fault P1250 ?Fuel Level Too Low?, add fuel to vehicle and complete a road test of at least 10 miles. Simply adding fuel without completing a road test may not allow fault to clear. Read More »
To clear static ECM fault P1250 ?Fuel Level Too Low?, add fuel to vehicle and complete a road test of at least 10 miles. Simply adding fuel without completing a road test may not allow fault to clear. Read More »
ENGINE AND ENGINE COOLING:ENGINE:ENGINE CONTROL MODULE (ECU/ECM):SOFTWARE
VOLKSWAGEN: EXHAUST HEAT SHIELD, REPLACEMENT GUIDELINES. HEAT SHIELDS ARE TO BE INSPECTED AFTER COMPLETION O ANY TYPE OF REPAIR TO THE UNDERBODY (EXHAUST SYSTEM TRANSMISSION, ETC.), AND IF DAMAGED, REPLACED. Read More »
ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL
VOLKSWAGEN:EVAPORATIVE (EVAP) EMISSION SYSTEM, DIAGNOSTIC TROUBLE CODE DIAGNOSIS. REVISED PROCEDURE DEVELOPED TO TEST EVAP SYSTEM WITHOUT FUEL CAP. *JS Read More »
VOLKSWAGEN: GASOLINE ENGINE VEHICLES INSPECT, AND IF NECESSARY, REPLACE IGNITION COILS. VEHICLES AFFECTED BY THIS ACTION MAY HAVE IGNITION COILS THAT COULD MALFUNCTION UNDER CERTAIN CONDITIONS. Read More »
ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL:CRANKCASE (PCV)
VOLKSWAGEN: SEE DOCUMENT SEARCH BUTTON FOR OWNER LETTER. UPDATE- 17D2 POSITIVE CRANKCASE VENTILATION VALVE. IT IS MANDATORY TO PERFORM UPDATES ON ALL APPLICABLE VEHICLES IN DEALER INVENTORY PRIOR TO RETAIL SALE. Read More »
VOLKSWAGEN: SEE DOCUMENT SEARCH BUTTON FOR OWNER LETTER. INFORMATION PERTAINING TO SOME VEHICLES INTAKE MANIFOLD RUNNER CONTROL MOTOR AND THE PCV, POSITIVE CRANKCASE VENTILATION VALVE WARRANTY. Read More »
VOLKSWAGEN: SEE DOCUMENT SEARCH BUTTON FOR OWNER LETTER. INFORMATION PERTAINING TO SOME MODEL YEAR VEHICLES REGARDING THE FUEL PRESSURE SENSOR, CRANKCASE VENTILATION (PCV) VALVE AND INTAKE MANIFOLD RUNNER CONTROL MOTOR. Read More »
ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL:GAS RECIRCULATION VALVE (EGR VALVE)
VOLKSWAGEN: MIL ON, DTC P0299 STORED IN ECM FAULT MEMORY. CHARGE PRESSURE CONTROL, NEGATIVE DEVIATION. THE CONDITION MAY BE THE RESULT OF AN ABNORMAL TURBOCHARGER RECIRCULATIONG VALVE. *PE Read More »
ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:MANIFOLD/HEADER/MUFFLER/TAIL PIPE
Supersedes Technical Bulletin 24-17 03 (V241703) dated March 6, 2017 for information regarding a new style solenoid valve for Intake Manifold Flap Read More »
VOLKSWAGEN: SEE DOCUMENT SEARCHBUTTON FOR OWNER LETTER. UPDATE- 24W2 INTAKE FLAP MOTOR. PERFORM THIS UPDATE ON ALL APPLICABLE VEHICLES WITHIN INTAKE MANIFOLD RUNNER CONTROL WARRANTY EXT (10 YEARS OR 120,000 MILES (192, 000KM), ... Read More »
VOLKSWAGEN: MIL ON DTCS P310B, P129F, P008B, P129E, P008A, P2540 OR P0087 STORED IN ECM FAULT MEMORY. MIL ON AND ONE OR MORE OF THE FOLLOWING DTCS ARE STORED IN THE ECM DATA MEMORY. *JS Read More »
VOLKSWAGEN: THERE MAY BE A FALSE SIGNAL SENT TO CONTROLLER CAUSING AN OUT OF TOLERANCE READING DUE TO FUEL INTRUSION TO LOW PRESSURE SYSTEM FUEL PRESSURE SENSOR. *PE Read More »
VOLKSWAGEN: SOME VEHICLES MAY EXPERIENCE LOW PRESSURE SYSTEM FUEL PRESSURE SENSOR DUE TO FUEL INTRUSION, PROVIDING A FALSE SIGNAL SENT TO CONTROLLER SHOWING AN OUT OF TOLERANCE READING. *PE Read More »
VOLKSWAGEN: MALFUNCTION LIGHT IS ON WITH THREE POSSIBLE TROUBLE CODES STORED. THERE IS WEAR OF THE CAMSHAFT LOBE CAUSING FUEL PRESSURE FLUCTUATIONS. *RM Read More »
VOLKSWAGEN: DUE TO FUEL INTRUSION INTO THE LOW PRESSURE SIDE FUEL PRESSURE SENSOR G410, A FALSE SIGNAL MAY BE SENT TO THE ECM RESULTING IN A READING THAT IS OUT OF TOLERANCE. *PE Read More »
VW: RVU-FUEL PRESSURE SENSOR REPLACEMENT (SAGA CODE 24M5/05. A MALFUNCTION OF FUEL PRESSURE SENSOR-G410-(LOW PRESSURE SIDE) MAY CAUSE AN INCORRECT FUEL PRESSURE READING FROM THE ECM. Read More »
VOLKSWAGEN: PRODUCTION PROBLEMS MAY MAKE CAMSHAFT COMPONENTS SUSCEPTIBLE TO PREMATURE WEAR. THIS COULD LEAD TO WEAR IN THE BASE OF THE HIGH PRESSURE FUEL PUMP CAMSHAFT FOLLOWER. THIS ISSUE DOES NOT CAUSE VEHICLE STALLING. Read More »
VOLKSWAGEN: FUEL PUMP REPLACEMENT CLARIFICATION. EXCESSIVE WEAR OF INTAKE CAMSHAFT LOBE THAT DRIVES THE HIGH PRESSURE FUEL PUMP. THE WEAR LIMITS MAXIMUM PUMP PISTON LIFT, CAUSING FUEL RAIL PRESSURE FLUCTUATIONS. Read More »
Fuel Additive to Help Prevent Sporadic Misfire Faults A Volkswagen approved fuel additive is available to help remove and prevent deposits on fuel injectors and intake valves. Read More »
VOLKSWAGEN: EXCESSIVE WEAR OF INTAKE CAMSHAFT LOBE CAUSING FUEL PRESSURE FLUCTUATIONS. IT CAN ALSO LEAD TO WEAR ON THE BASE OF THE FUEL PUMP CAM FOLLOWER. *RM Read More »
VOLKSWAGEN: SOME VEHICLES MAY EXPERIENCE LOW PRESSURE SYSTEM FUEL PRESSURE SENSOR DUE TO FUEL INTRUSION, PROVIDING A FALSE SIGNAL SENT TO CONTROLLER SHOWING AN OUT OF TOLERANCE READING. *PE Read More »
To clear static ECM fault P1250 ?Fuel Level Too Low?, add fuel to vehicle and complete a road test of at least 10 miles. Simply adding fuel without completing a road test may not allow fault to clear. Read More »
To clear static ECM fault P1250 ?Fuel Level Too Low?, add fuel to vehicle and complete a road test of at least 10 miles. Simply adding fuel without completing a road test may not allow fault to clear. Read More »
VOLKSWAGEN: SOME VEHICLES MAY EXPERIENCE LOW PRESSURE SYSTEM FUEL PRESSURE SENSOR DUE TO FUEL INTRUSION, PROVIDING A FALSE SIGNAL SENT TO CONTROLLER SHOWING AN OUT OF TOLERANCE READING. *PE Read More »
VOLKSWAGEN: SEE DOCUMENT SEARCH BUTTON FOR OWNER LETTER. INFORMATION PERTAINING TO SOME MODEL YEAR VEHICLES REGARDING THE FUEL PRESSURE SENSOR, CRANKCASE VENTILATION (PCV) VALVE AND INTAKE MANIFOLD RUNNER CONTROL MOTOR. Read More »
VOLKSWAGEN: SEE DOCUMENT SEARCH BUTTON FOR OWNER LETTER. UPDATE- 24W3 FUEL PRESSURE SENSOR. PERFORM THIS UPDATE ON ALL APPLICABLE VEHICLES WITHIN FUEL PRESSURE SENSOR WARRANTY EXT (10 YEARS 120,000 MILES (192, 000KM), WHICHEVER OCCURS ... Read More »
VW: RVU-FUEL PRESSURE SENSOR REPLACEMENT (SAGA CODE 24M5/05. A MALFUNCTION OF FUEL PRESSURE SENSOR-G410-(LOW PRESSURE SIDE) MAY CAUSE AN INCORRECT FUEL PRESSURE READING FROM THE ECM. Read More »
VOLKSWAGEN: MIL ON, DTC P129F AND/OR P310B STORED IN ECM FAULT MEMORY. DUE TO FUEL INTRUSION INTO THE LOW PRESSURE SIDE FUEL PRESSURE SENSOR-G410, A FALSE SIGNAL MAY BE SENT TO THE ECM RESULTING IN A READING THAT IS OUT OF TOLERANCE. Read More »
Tech Tips (ECM Fault P1250 "Fuel Level Too Low" Will Not Clear): This document informs to clear static ECM fault P1250 "Fuel Level Too Low", add fuel to vehicle and complete a road test of at least 10 miles. Read More »
VOLKSWAGEN: MIL ON, DTC P129F AND/OR P310B STORED IN ECM FAULT MEMORY. DUE TO FUEL INTRUSION INTO THE LOW PRESSURE SIDE FUEL PRESSURE SENSOR-G410, A FALSE SIGNAL MAY BE SENT TO THE ECM RESULTING IN A READING THAT IS OUT OF TOLERANCE. Read More »
VOLKSWAGEN: DUE TO FUEL INTRUSION INTO THE LOW PRESSURE SIDE FUEL PRESSURE SENSOR G410, A FALSE SIGNAL MAY BE SENT TO THE ECM RESULTING IN A READING THAT IS OUT OF TOLERANCE. *PE Read More »
VOLKSWAGEN: ON SOME VEHICLES, THE HIGH PRESSURE FUEL PUMP, DRIVEN BY INTAKE CAMSHAFT LOBE, CAN WEAR EXCESSIVELY. FUEL RAIL PRESSURE FLUCTUATIONS CAUSED BY THE LIMITED PUMP PISTON LIFT. *PE Read More »
VOLKSWAGEN SERVICE CAMPAIGN: SEE DOCUMENT SEARCH BUTTON FOR OWNER LETTER. PRODUCTION ISSUES MAY CAUSE PREMATURE WEAR ON THE INTAKE CAMSHAFT AND CAMSHAFT FOLLOWER. MALFUNCTION LIGHT WILL ILLUMINATE. Read More »
Incorrect torque converter or flywheel/flexplate installation can result in transmission damage. When installing an engine, flywheel or transmission, please follow the installation procedures outlined in ELSA. Read More »
Tech Tips (Measure Value Block Request): If a request has been made for several MVBs from a DSG transmission, the test plan "Read measured values for obligation to report" can be selected. Read More »
VOLKSWAGEN SERVICE CAMPAIGN: SEE DOCUMENT SEARCH BUTTON FOR OWNER LETTER. IN SOME VEHICLES IT IS POSSIBLE THAT A BUSHING INSIDE THE MECHATRONIC UNIT HAS THE POTENTIAL TO WEAR OUT PREMATURELY, CAUSING THE CLUTCHES INSIDE THE ... Read More »
VOLKSWAGEN: THE INTAKE FLAP MOTOR OR INTAKE MANIFOLD RUNNER POSITION SENSOR G336 MAY BE INOPERATIVE (BOTH ARE INCLUDED IN ONE SINGLE UNIT). MODELS GOLF, GTI, A5 JETTA, GLI, EOS, PASSAT, PASSAT WAGON. *PE UPDATED 9/25/09. Read More »
POWER TRAIN:AUTOMATIC TRANSMISSION:TORQUE CONVERTER
Tech Tips (Torque Converter/Flywheel/Flexplate installation): Incorrect torque converter or flywheel/flexplate installation can result in transmission damage. Read More »
Tech Tips (Fault Code 02805 ?System Interference? in Convertible Top): Fault code 02805 is a generic fault code for one top condition out of sequence Read More »
Tech Tips (Heated Rear Window, One or More Lines Inoperative): To detect which line(s) is inoperative, utilize a volt meter to check for 0 V, which will be present after the open in the grid line. Read More »
When performing SVM updates, the scan tool should be hardwired to the vehicle and the Bluetooth physically turned off. A hard wired internet connection is also recommended. Read More »
Technical Bulletin (Electric Coolant Fans Continue to Run after Ignition is Switched OFF): This documentation informs it is considered normal operation for the electric coolant fans to continue to run for up to 15 minutes after the ... Read More »
Tech Tips (Comfort Module (J393) or BCM (J519) Replacement): This document informs if a comfort or body control module is replaced during normal diagnosis, make sure the factory mode has been switched OFF. Read More »
The DLC is intended for use with diagnostic scan tools and by emissions testing stations. However, aftermarket devices (i.e., drive data recorders) that connect to the DLC have now become available. Read More »
Tech Tips (Comfort Module (J393) or BCM (J519) Replacement): This document informs If a comfort or body control module is replaced during normal diagnosis, make sure the factory mode has been switched OFF. Read More »
Technical Bulletin (Internal Control Module Memory Check Sum Errors): This document contains Updates for the Engine Control Module using the SVM Unit code as listed in the document to address the Memory Check Sum Errors issue. Read More »
To detect which line(s) is inoperative, utilize a volt meter to check for 0 V, which will be present after the open in the grid line. The check must be performed with the engine running and heated rear window switched on. Read More »
Quick Reference Update Guide: This document informs of the corresponding software/hardware and disc availability to the customer concerns about a vehicle Read More »
Quick Reference Update Guide: This document informs of the corresponding software/hardware and disc availability to the customer concerns about a vehicle Read More »
When diagnosing a generator charging concern, it is recommended to verify operation of the one way clutch located in the generator pulley (if equipped) before replacing generator assembly. Read More »
Engine Control Module Updates: This document informs of complaints, and the software updates / Tech Bulletins associated with servicing engine control module issues: Read More »
Engine Control Module Updates: This document informs of complaints, and the software updates/Tech Bulletins associated with servicing engine control module issues: Read More »
Body/Infotainment Module Software Updates: This document informs of various complaints that were addressed in software updates, and technical bulletins. Read More »
Body/Infotainment Module Software Updates: This document informs of various complaints that were addressed in software updates, and technical bulletins. Read More »
If, after replacement of the steering rack, fault code 01309 008 is set in the ABS/ESP module only, follow the test plan in GFF for Driver Steering Recommendation (DSR) or channel 3 activation. Read More »
2006 -2007 Rabbit/R32/GTI, 2005-2007 Jetta/Jetta Wagon, 2007-2008 Eos and 2006-2007 Passat/Passat Wagon Inspect Front Seat Side Impack Airbag Connectors & Install Wiring Harness Kit(s), if Necessary Read More »
2006-2008 WITH 2.0L (BPY) UPDATE SERVICE NUMBER IN WARRANTY TABLE. 2008-2009 ALL MODELS WITH 2.0L (CCTA,CBFA) UPDATE SERVICE NUMBER IN WARRANTY TABLE. Read More »
VOLKSWAGEN SERVICE CAMPAIGN: SEE DOCUMENT SEARCH BUTTON FOR OWNER LETTER. RESISTANCE IN THE AIR BAG SYSTEM CAN CAUSE THE AIR BAG LIGHT TO TURN ON EVEN THOUGH THERE IS NO PROBLEM. *RM UPDATED 4/9/13. Read More »
Tech Tips (with 1K0 Part Number J500 ? Replacement Steering Harness): If the steering rack is replaced on the above models for any reason, it is necessary to replace the steering harness as well. Read More »
VOLKSWAGEN: GASOLINE ENGINE VEHICLES INSPECT, AND IF NECESSARY, REPLACE IGNITION COILS. VEHICLES AFFECTED BY THIS ACTION MAY HAVE IGNITION COILS THAT COULD MALFUNCTION UNDER CERTAIN CONDITIONS. Read More »
VOLKSWAGEN: MIL ON OR FLASHING, MISFIRE DTCS P0300-0312 STORED IN ECM. THE MISFIRE CONDITION MAY BE CAUSED BY A MALFUNCTIONING IGNITION COIL. VEHICLES ARE OUT OF PRODUCTION. *PE Read More »
VOLKSWAGEN: VEHICLES MAY HAVE IGNITION COILS THAT COULD MALFUNCTION UNDER CERTAIN CONDITIONS. IF THIS HAPPENS, THE MALFUNCTION INDICATOR LAMP (MIL) WILL ILLUMINATED TO LET YOU KNOW THAT THE VEHICLE MAY EXPERIENCE SOME DETERIORATION IN ... Read More »
To detect which line(s) is inoperative, utilize a volt meter to check for 0 V, which will be present after the open in the grid line. The check must be performed with the engine running and heated rear window switched on. Read More »
If key blade is found to stick or bind when opening or closing, check position of roll pin that secures key blade to mechanism. If roll pin is sticking out on either side (as shown below), do not replace key. Read More »
Tech Tips (Instrument Cluster Production Mode): This document informs the procedure to remove the production mode setting when it is displayed in the instrument cluster. Read More »
Tech Tips (Instrument Cluster Production Mode): During PDI, or after installation of a replacement cluster, ?Pro? may be displayed in place of the odometer. The high beam indicator may be flashing in the instrument cluster as well. Read More »
Quick Reference of vehicle concerns. Includes a list of Software versions and the technical bulletin numbers that referred to the concerns Updated Read More »
Quick Reference Update Guide of the vehicles expected upgraded software level. The latest corresponding technical bulletins that address the issues, and concerns that have been had with the vehicles. Read More »
Quick Reference of vehicle concerns. Includes a list of Software versions and the technical bulletin numbers that referred to the concerns Updated Read More »
Tech Tips (SVM Update Instructions): This document informs when performing SVM updates, the scan tool should be hardwired to the vehicle and the Bluetooth physically turned off. A hard wired internet connection is also recommended. Read More »
Tech Tips (Electro ? Steering - DTC 01309 008 ?No Communication with -J500-? is Stored in the ABS/ESP Module Only): This document informs If, after replacement of the steering rack, fault code 01309 008 is set in the ABS/ESP module only, ... Read More »
Quick Reference Update Guide: This document informs of the corresponding software/hardware and disc availability to the customer concerns about a vehicle Read More »
Quick Reference Update Guide: This document informs of the corresponding software/hardware and disc availability to the customer concerns about a vehicle Read More »
Technical Bulletin This Technical Bulletin details the general process for carrying out a Software Version Management (SVM) software update for any Technical Bulletin (TSB) / Required Vehicle Update (RVU). Read More »
Technical Bulletin: Condensation and or water droplets becomming visible on inside of exterior light lenses issue is discussed in this document Read More »
Technical Bulletin (Exterior Lights, Moisture Accumulation): This document informs of the Condensation and or water droplets visible on inside of exterior light lenses. The document also informs how to service the issue. Read More »
Technical Bulletin (Exterior Lights, Moisture Accumulation): Exterior light assemblies (headlights, taillights, fog lights, turn signals) are vented and may collect moisture on their inner surfaces, depending on humidity and other ... Read More »
Technical Bulletin (Windshield Wipers Streak or Smear): Windshield or rear window is streaked, has a snakeskin appearance, or the surface feels rough. Read More »
Tech Tips (Heated Rear Window, One or More Lines Inoperative): To detect which line(s) is inoperative, utilize a volt meter to check for 0 V, which will be present after the open in the grid line. Read More »
Tech Tips (Heated Rear Window, One or More Lines Inoperative): To detect which line(s) is inoperative, utilize a volt meter to check for 0 V, which will be present after the open in the grid line. Read More »
It is acceptable to have a few water droplets enter the vehicle under certain circumstances. As described in the Owner?s Manual, this vehicle is not to be subjected to high pressure washes, neither brushless automatic nor handheld. Read More »
Cleaning of Heating and Ventilation system, Updated to include additional model year applicability and cost of cleaning solution in warranty table. Read More »
Tech Tips (Heated Rear Window, One or More Lines Inoperative): To detect which line(s) is inoperative, utilize a volt meter to check for 0 V, which will be present after the open in the grid line. Read More »
VISIBILITY:DEFROSTER/DEFOGGER/HVAC SYSTEM:REAR WINDOW:ELECTRICAL HEATING ELEMENT
To detect which line(s) is inoperative, utilize a volt meter to check for 0 V, which will be present after the open in the grid line. The check must be performed with the engine running and heated rear window switched on. Read More »
2006 -2007 Rabbit/R32/GTI, 2005-2007 Jetta/Jetta Wagon, 2007-2008 Eos and 2006-2007 Passat/Passat Wagon Inspect Front Seat Side Impack Airbag Connectors & Install Wiring Harness Kit(s), if Necessary Read More »
If, after replacement of the steering rack, fault code 01309 008 is set in the ABS/ESP module only, follow the test plan in GFF for Driver Steering Recommendation (DSR) or channel 3 activation. Read More »
VOLKSWAGEN SERVICE CAMPAIGN: SEE DOCUMENT SEARCH BUTTON FOR OWNER LETTER. RESISTANCE IN THE AIR BAG SYSTEM CAN CAUSE THE AIR BAG LIGHT TO TURN ON EVEN THOUGH THERE IS NO PROBLEM. *RM UPDATED 4/9/13. Read More »
VOLKSWAGEN SERVICE CAMPAIGN: SEE DOCUMENT SEARCH BUTTON FOR OWNER LETTER. RESISTANCE IN THE AIR BAG SYSTEM CAN CAUSE THE AIR BAG LIGHT TO TURN ON EVEN THOUGH THERE IS NO PROBLEM. *RM UPDATED 4/9/13. Read More »
2006 -2007 Rabbit/R32/GTI, 2005-2007 Jetta/Jetta Wagon, 2007-2008 Eos and 2006-2007 Passat/Passat Wagon Inspect Front Seat Side Impack Airbag Connectors & Install Wiring Harness Kit(s), if Necessary Read More »
Tech Tips (Convertible Top Inoperative With Faults 03053, 03055, and/or 03057 Stored): When diagnosing a customer concern of convertible top inoperative with faults 03053-008 ?Left Roof Pillar Lock Sensor G558 implausible signal?, ... Read More »
VOLKSWAGEN: SOME VEHICLES ARE EXPERIENCING A WATER LEAKAGE FROM A PILLAR AREA TRIM NEAR SUNROOF DRAIN HOSES OR EITHER SIDE AND/OR DOME LAMP AREA. MODEL 2007-13 EOS. *PE Read More »
Tech Tips (Convertible Top Inoperative With Faults 03053, 03055, and/or 03057 Stored): When diagnosing a customer concern of convertible top inoperative with faults 03053-008 ?Left Roof Pillar Lock Sensor G558 implausible signal?, ... Read More »
Tech Tips (Convertible Top Inoperative With Faults 03053, 03055, and/or 03057 Stored): When diagnosing a customer concern of convertible top inoperative with faults 03053-008 ?Left Roof Pillar Lock Sensor G558 implausible signal?, ... Read More »
Tech Tips (Acceptable Conditions Concerning Water Leaks): This document informs of the certain circumstances to have a few water droplets enter the vehicle. Read More »
It is acceptable to have a few water droplets enter the vehicle under certain circumstances. As described in the Owner?s Manual, this vehicle is not to be subjected to high pressure washes, neither brushless automatic nor handheld. Read More »
Technical Bulletin (Paint Finish, Reducing Swirl Marks and Fine Scratches): New vehicles (prior to Retail Delivery) with swirl marks and or fine scratches from polishing or cleaning. Read More »
Technical Bulletin (Hood, Under Hood Not Painted Body Color): The paint color and/or finish of the engine compartment and underside of hood may not match the exterior paint color of the vehicle. Read More »
If, during diagnosis of the convertible top, the adjuster arm for the front lock is found damaged, order part number 1Q0898499 or latest supersession. This one part number will include both sides in the package. Read More »
VOLKSWAGEN: SOME VEHICLES ARE EXPERIENCING A WATER LEAKAGE FROM A PILLAR AREA TRIM NEAR SUNROOF DRAIN HOSES OR EITHER SIDE AND/OR DOME LAMP AREA. MODEL 2007-13 EOS. *PE Read More »
VOLKSWAGEN: EXHAUST HEAT SHIELD, REPLACEMENT GUIDELINES. HEAT SHIELDS ARE TO BE INSPECTED AFTER COMPLETION O ANY TYPE OF REPAIR TO THE UNDERBODY (EXHAUST SYSTEM TRANSMISSION, ETC.), AND IF DAMAGED, REPLACED. Read More »
Technical Bulletin about Paint Finish, Reducing Swirl Marks and Fine Scratches New vehicles (prior to Retail Delivery) with swirl marks and or fine scratches from polishing or cleaning. Read More »
Information on areas Surface corrosion or corrosion perforation can occur on various locations around the front wheel arch. Also gives examples of how to calculate cost to repair or replace Read More »
Tech Tips (Acceptable Conditions Concerning Water Leaks): This document informs of the certain circumstances to have a few water droplets enter the vehicle. Read More »
If, during diagnosis of the convertible top, the adjuster arm for the front lock is found damaged, order part number 1Q0898499 or latest supersession. This one part number will include both sides in the package. Read More »
If, during diagnosis of the convertible top, the adjuster arm for the front lock is found damaged, order part number 1Q0898499 or latest supersession. This one part number will include both sides in the package. Read More »
Tech Tips (All vehicles-Tire dressing for vehicle detailing): The use of tire dressing gives your tires that shiny finish that completes the image of a clean (new) vehicle. Read More »
The use of tire dressing gives your tires that shiny finish that completes the image of a clean (new) vehicle. There are many different tire dressing products available. When choosing a product please pay close attention to its contents. Read More »
Summary of Technical Bulletin to include additional model and model year applicability. Corrosion, Front Fenders, at Upper Wheel Opening (U.S. Only) Read More »
Information on areas Surface corrosion or corrosion perforation can occur on various locations around the front wheel arch. Also gives examples of how to calculate cost to repair or replace Read More »
Tech Tips (All vehicles-Tire dressing for vehicle detailing): The use of tire dressing gives your tires that shiny finish that completes the image of a clean (new) vehicle. Read More »
The use of tire dressing gives your tires that shiny finish that completes the image of a clean (new) vehicle. There are many different tire dressing products available. When choosing a product please pay close attention to its contents. Read More »
Tech Tips (Convertible Top Inoperative With Faults 03053, 03055, and/or 03057 Stored): When diagnosing a customer concern of convertible top inoperative with faults 03053-008 ?Left Roof Pillar Lock Sensor G558 implausible signal?, ... Read More »
Elsa2Go campaign information is now 100% aligned with ElsaPro. This update to Elsa2Go ensures that both systems are displaying the same campaign information, including OPEN/CLOSED status, repair date as well as criterions at the same time ... Read More »
REMOVED all 12 hour wait period before starting references. ADDED EFB to "Select correct battery type" in bottom box. Also Jetta Wagon 2005 and 2018-2020 Tiguan LWB. Read More »
This special notice is to inform dealers to return all part numbers listed in the document and order the superseded part numbers going forward. Read More »
This document contains the VW Elsa Newsletter that contains a general overview of wiring diagrams updates, ElsaPro infomedia icons grayed out, workshop equipment tool storage application, technical bulletins, pending service solutions, ... Read More »
When performing SVM updates, the scan tool should be hardwired to the vehicle and the Bluetooth physically turned off. A hard wired internet connection is also recommended. Read More »
Technical Bulletin (Exterior Lights, Moisture Accumulation): This document informs of the Condensation and or water droplets visible on inside of exterior light lenses. The document also informs how to service the issue. Read More »
Technical Bulletin (Squeaks, Rattles, Noise, Repair Materials): This doucment contains a list of components and applications developed to repair concerns of squeaks, rattles, noise and trim fit conditions. Read More »
Tech Tips (All Models 2000-2014 - Part ordering): If a needed service part is on back order, upgrade the daily order to a red order and check the ?Car Down? box to escalate the order. Read More »
Tech Tips (All Models 2000-2014 - Part ordering): If a needed service part is on back order, upgrade the daily order to a red order and check the ?Car Down? box to escalate the order. Read More »
If a needed service part is on back order, upgrade the daily order to a red order and check the ?Car Down? box to escalate the order. If parts assistance is needed, please call 800-767-6552 to speak with a VWGoA Parts Specialist. Read More »
If a needed service part is on back order, upgrade the daily order to a red order and check the ?Car Down? box to escalate the order. If parts assistance is needed, please call 800-767-6552 to speak with a VWGoA Parts Specialist. Read More »
Quick Reference Update Guide: This document informs of the corresponding software/hardware and disc availability to the customer concerns about a vehicle Read More »
In SAGA, the time units for the Volkswagen DoubleCheck labor operation were reduced in error from 50 time units to 30 time units during the system update posted on July 4th. Read More »
Tech Tips (ECM Fault P1250 "Fuel Level Too Low" Will Not Clear): This document informs to clear static ECM fault P1250 "Fuel Level Too Low", add fuel to vehicle and complete a road test of at least 10 miles. Read More »
When performing SVM updates, the scan tool should be hardwired to the vehicle and the Bluetooth physically turned off. A hard wired internet connection is also recommended. Read More »
REPAIR TIP TO ASSIST IN ADDRESSING CONVERTIBLE TOP DAMAGE TO THE ADJUSTER ARM AND ADDITIONAL REFERENCE FOR FURTHER REPAIR INFORMATION TO ADDRESS ROOT CAUSE OF FAILURE. Read More »
This technical bulletin was updated per powertain team and warranty team. Info from this bulletin is combined with TB 2031075 (V241208) and 2038161 (V241506) due to warranty extension claiming/processing confusion. Read More »
This document contains the VW Elsa Newsletter that contains a general overview of wiring diagrams updates, technical bulletins, pending service solutions, tech tips, campaigns, updates, and suggestions. Read More »
This document contains the VW Elsa Newsletter that contains a general overview of wiring diagrams updates, ElsaPro infomedia icons grayed out, workshop equipment tool storage application, technical bulletins, pending service solutions, ... Read More »
Technical Bulletin: Condensation and or water droplets becomming visible on inside of exterior light lenses issue is discussed in this document Read More »
A Volkswagen FLUID CAPACITY CHART which contains the various fluids necessary for a vehicle to run Cateorgories include (Engine Oil, Manual Transmission, Automatic Transmission, Differential Automatic Transmission, Cooling System, Power ... Read More »
EOS Perfect Delivery Inspection (PDI) - Technician and Detailer Inspections: A checklist to insure a customer receives a wonderful delivery of a vehicle that looks, feels, and meets the expectations of a new vehicle that he/she has ... Read More »
EOS Perfect Delivery Inspection (PDI) - Technician and Detailer Inspections: A checklist to insure a customer receives a wonderful delivery of a vehicle that looks, feels, and meets the expectations of a new vehicle that he/she has ... Read More »
Tech Tips (Technician Helpline Vehicle Check Sheets): When it becomes necessary to open a VW Technician Helpline VTA case while performing diagnosis for a diesel particulate filter, manual transmission repair, or turbocharger concern, ... Read More »
Tech Tips (N75 Solenoid Valve Diagnosis): This document informs with a diagram which vacuum ports on the N75 valve should hold vacuum and which ones should not for diagnosis on the Vehicles with 2. Read More »
Tech Tips (Acceptable Conditions Concerning Water Leaks): This document informs of the certain circumstances to have a few water droplets enter the vehicle. Read More »
Technical Bulletin (Paint Finish, Reducing Swirl Marks and Fine Scratches): New vehicles (prior to Retail Delivery) with swirl marks and or fine scratches from polishing or cleaning. Read More »
Technical Bulletin (Paint Finish, Reducing Swirl Marks and Fine Scratches): New vehicles (prior to Retail Delivery) with swirl marks and or fine scratches from polishing or cleaning. Read More »
Technical Bulletin (Hood, Under Hood Not Painted Body Color): The paint color and/or finish of the engine compartment and underside of hood may not match the exterior paint color of the vehicle. Read More »
Technical Bulletin (Hood, Under Hood Not Painted Body Color): The paint color and/or finish of the engine compartment and underside of hood may not match the exterior paint color of the vehicle. Read More »
Engine Control Module Updates: This document informs of complaints, and the software updates / Tech Bulletins associated with servicing engine control module issues: Read More »
Body/Infotainment Module Software Updates: This document informs of various complaints that were addressed in software updates, and technical bulletins. Read More »
Tech Tips (Convertible Top Inoperative With Faults 03053, 03055, and/or 03057 Stored): When diagnosing a customer concern of convertible top inoperative with faults 03053-008 ?Left Roof Pillar Lock Sensor G558 implausible signal?, ... Read More »
Technical Bulletin (Paint Finish, Reducing Swirl Marks and Fine Scratches): New vehicles (prior to Retail Delivery) with swirl marks and or fine scratches from polishing or cleaning. Read More »
Technical Bulletin (Hood, Under Hood Not Painted Body Color): The paint color and/or finish of the engine compartment and underside of hood may not match the exterior paint color of the vehicle. Read More »
VOLKSWAGEN: REAR CUP HOLDER LOOSE. REAR CUP HOLDER IS DESIGNED TO BREAK AWAY IN CASE OF AN ACCIDENT TO PREVENT INJURIES. IT MAY ALSO COME LOOSE IF SUFFICIENT FORCE IS APPLIED (I.E. PASSENGER ACCIDENTALLY KICKING ASSEMBLY). Read More »
Technical Bulletin (Air Conditioning, Cleaning of the Refrigerant Circuit (U.S.Only)): In cases where an air conditioning system component (such as a compressor or other system component) has failed and debris from the compressor or ... Read More »
Technical Bulletin (Air Conditioning, Cleaning of the Refrigerant Circuit): In cases where an air conditioning system component (such as a compressor or other system component) has failed and debris from the compressor or component is ... Read More »
VOLKSWAGEN: CHILD RESTRAINT LATCH GUIDANCE FIXTURE; COMPLIANCE WITH FMVSS 225 (USA ONLY). UPDATE TO EXISTING TECHNICAL BULLETIN. NO PRODUCTION CHANGE REQUIRED. ALL MODELS. *PE Read More »
VOLKSWAGEN: CHILD RESTRAINT LATCH GUIDANCE FIXTURE; COMPLIANCE WITH FMVSS 225 (USA ONLY). UPDATE TO EXISTING TECHNICAL BULLETIN. NO PRODUCTION CHANGE REQUIRED. ALL MODELS. *PE Read More »
To detect which line(s) is inoperative, utilize a volt meter to check for 0 V, which will be present after the open in the grid line. The check must be performed with the engine running and heated rear window switched on. Read More »
If, during diagnosis of the convertible top, the adjuster arm for the front lock is found damaged, order part number 1Q0898499 or latest supersession. This one part number will include both sides in the package. Read More »
To clear static ECM fault P1250 ?Fuel Level Too Low?, add fuel to vehicle and complete a road test of at least 10 miles. Simply adding fuel without completing a road test may not allow fault to clear. Read More »
To clear static ECM fault P1250 ?Fuel Level Too Low?, add fuel to vehicle and complete a road test of at least 10 miles. Simply adding fuel without completing a road test may not allow fault to clear. Read More »
