Technical Service Bulletins (TSBs) for the 1998 Beetle are official communications between Volkswagen & their dealerships that describe processes for troubleshooting or fixing certain common problems.
All vehicle manufacturers are required by U.S. law to make their TSBs available to the public.
Technical Bulletin (Engine Oils Which Meet Volkswagen Oil Quality Standard): This document informs of a sample list of products generally available in the North American market that meet the Volkswagen Oil Quality ... Read More »
Tech Tips (Models with 1.8T Engine - Pressure Loss issues): Fault code P1297 may be set and fuel mixtures may go lean if the vehicle is driven under load or revved up and then returned to idle. Read More »
17 17 01 July 5, 2017 2012855 Supersedes Technical Bulletin 17-16-02 (V171602) dated April 29, 2016 due to updated oil standards lists to current specifications. Read More »
Technical Bulletin (Air Conditioning, Cleaning of the Refrigerant Circuit (U.S.Only)): In cases where an air conditioning system component (such as a compressor or other system component) has failed and debris from the compressor or ... Read More »
EVALUATING FUEL MIXTURE DIAGNOSTIC TROUBLE CODES (DTC) - HOW TO PERFORM EFFECTIVE DIAGNOSTIC RELATED TO FUEL SYSTEM ADAPTATION SYSTEM TOO RICH/ TOO LEAN. VOLKSWAGEN. *MJ Read More »
VOLKSWAGEN: DIAGNOSIS N75 SOLENOID VALVE ON TURBOCHARGER, WITH FAULT CODES P0299 AND P0234, THAT LEADS TO TESTING ON WHICH VACUUM PORTS THAT WOULD HOLD AND WHICH ONES WILL NOT. NO MODELS WERE LISTED. MODEL YEARS 2006-2013 WITH 2. Read More »
ENGINE AND ENGINE COOLING:ENGINE:GASOLINE:TURBO/SUPERCHARGER
VOLKSWAGEN: DIAGNOSIS N75 SOLENOID VALVE ON TURBOCHARGER, WITH FAULT CODES P0299 AND P0234, THAT LEADS TO TESTING ON WHICH VACUUM PORTS THAT WOULD HOLD AND WHICH ONES WILL NOT. NO MODELS WERE LISTED. MODEL YEARS 2006-2013 WITH 2. Read More »
DTC'S P1297 (17705) OR P1557 (17965) STORED IN DTC MEMORY. THIS MAY BE CAUSED BY INTAKE HOSES LEAKING (DURING BOOST CONDITIONS) DUE TO INCORRECT TORQUE ON CLAMPS OR IMPROPER PLACEMENT, WORN OR TORN INTAKE HOSES. Read More »
VOLKSWAGEN: EXHAUST HEAT SHIELD, REPLACEMENT GUIDELINES. HEAT SHIELDS ARE TO BE INSPECTED AFTER COMPLETION O ANY TYPE OF REPAIR TO THE UNDERBODY (EXHAUST SYSTEM TRANSMISSION, ETC.), AND IF DAMAGED, REPLACED. Read More »
Tech Tips (Heated Rear Window, One or More Lines Inoperative): To detect which line(s) is inoperative, utilize a volt meter to check for 0 V, which will be present after the open in the grid line. Read More »
To detect which line(s) is inoperative, utilize a volt meter to check for 0 V, which will be present after the open in the grid line. The check must be performed with the engine running and heated rear window switched on. Read More »
SUBJECT REGARDING WIRING DIAGRAM FOR CENTRAL CONTROL MODULE FOR COMFORT SYSTEM, SWITCH FOR REMOTE UNLOCK, REAR LID, CONTROL MODULE FOR COMFORT SYSTEM. *TT Read More »
SUBJECT REGARDING WIRING DIAGRAM FOR THE DFI ENGINE CONTROL MODULE (ECM), KICK DOWN SWITCH, CLOSED THROTTLE POSITION (CTP) SENSOR, CLOSED THOTTLE POSITION (CTP) SWITCH, GLOW PLUG RELAY, GLOW PLUGS (ENGINE). Read More »
INFORMATION CONTAINING A WIRING DIAGRAM FOR THE MOTRONIC ENGINE CONTROL MODULE (ECM), ENGINE SPEED (RPM) SENSOR, KNOCK SENSOR (KS) 1, KNOCK SENSOR (KS) 2. *TT Read More »
INFORMATION CONTAINING A COMPONENT GROUND IDENTIFICATION CHART WHICH LISTS GROUND LOCATIONS THAT HAVE BEEN INTEGRATED INTO THE REPAIR INFORMATION SYSTEM. *TT Read More »
VOLKSWAGEN: HEADLIGHTS MAY INTERMITTENTLY DIM SLIGHTLY AT IDLE. AT IDLE SPEED THE ALTERNATOR VOLTAGE CAN FLUCTUATE, AS THE ALTERNATOR CANNOT FULLY COMPENSATE THE FLUCTUATIONS. Read More »
VOLKSWAGEN: HEADLIGHTS MAY INTERMITTENTLY DIM SLIGHTLY AT IDLE. AT IDLE SPEED THE ALTERNATOR VOLTAGE CAN FLUCTUATE, AS THE ALTERNATOR CANNOT FULLY COMPENSATE THE FLUCTUATIONS. Read More »
A CONDITION MAY EXIST WITH COOLANT LEAKING FROM THE COOLANT RESERVOIR BOTTLE WIRING CONNECTOR CONTAMINATING THE WIRING HARNESS AND / OR CONTAMINATION RESULTING IN VARIOUS MALFUNCTIONS OF THE INSTRUMENT PLANEL. Read More »
To detect which line(s) is inoperative, utilize a volt meter to check for 0 V, which will be present after the open in the grid line. The check must be performed with the engine running and heated rear window switched on. Read More »
Technical Bulletin: Condensation and or water droplets becomming visible on inside of exterior light lenses issue is discussed in this document Read More »
Technical Bulletin (Exterior Lights, Moisture Accumulation): This document informs of the Condensation and or water droplets visible on inside of exterior light lenses. The document also informs how to service the issue. Read More »
Technical Bulletin (Exterior Lights, Moisture Accumulation): Exterior light assemblies (headlights, taillights, fog lights, turn signals) are vented and may collect moisture on their inner surfaces, depending on humidity and other ... Read More »
VOLKSWAGEN: HEADLIGHTS MAY INTERMITTENTLY DIM SLIGHTLY AT IDLE. AT IDLE SPEED THE ALTERNATOR VOLTAGE CAN FLUCTUATE, AS THE ALTERNATOR CANNOT FULLY COMPENSATE THE FLUCTUATIONS. Read More »
Technical Bulletin (Windshield Wipers Streak or Smear): Windshield or rear window is streaked, has a snakeskin appearance, or the surface feels rough. Read More »
Tech Tips (Heated Rear Window, One or More Lines Inoperative): To detect which line(s) is inoperative, utilize a volt meter to check for 0 V, which will be present after the open in the grid line. Read More »
Tech Tips (Heated Rear Window, One or More Lines Inoperative): To detect which line(s) is inoperative, utilize a volt meter to check for 0 V, which will be present after the open in the grid line. Read More »
Tech Tips (Heated Rear Window, One or More Lines Inoperative): To detect which line(s) is inoperative, utilize a volt meter to check for 0 V, which will be present after the open in the grid line. Read More »
VISIBILITY:DEFROSTER/DEFOGGER/HVAC SYSTEM:REAR WINDOW:ELECTRICAL HEATING ELEMENT
To detect which line(s) is inoperative, utilize a volt meter to check for 0 V, which will be present after the open in the grid line. The check must be performed with the engine running and heated rear window switched on. Read More »
DRIVER AND PASSENGER DOOR WINDOW REGULATOR REPAIRING. *MJ ADDITIONAL INFORMATION REGARDING DOOR WINDOW, SEPARATES FROM WINDOW REGULATOR CLAMPS. *TT Read More »
VOLKSWAGEN: EXHAUST HEAT SHIELD, REPLACEMENT GUIDELINES. HEAT SHIELDS ARE TO BE INSPECTED AFTER COMPLETION O ANY TYPE OF REPAIR TO THE UNDERBODY (EXHAUST SYSTEM TRANSMISSION, ETC.), AND IF DAMAGED, REPLACED. Read More »
SOME VEHICLES MAY EXHIBIT THROTTLE PEDAL VIBRATION AT IDLE AND / OR RAPPING NOISE AGAINST ENGINE COVER HEARD ON VEHICLES WITH SECONDARY AIR INJECTION. *TT Read More »
This special notice is to inform dealers to return all part numbers listed in the document and order the superseded part numbers going forward. Read More »
This document contains the VW Elsa Newsletter that contains a general overview of wiring diagrams updates, ElsaPro infomedia icons grayed out, workshop equipment tool storage application, technical bulletins, pending service solutions, ... Read More »
Technical Bulletin (Exterior Lights, Moisture Accumulation): This document informs of the Condensation and or water droplets visible on inside of exterior light lenses. The document also informs how to service the issue. Read More »
Technical Bulletin (Squeaks, Rattles, Noise, Repair Materials): This doucment contains a list of components and applications developed to repair concerns of squeaks, rattles, noise and trim fit conditions. Read More »
This document contains the VW Elsa Newsletter that contains a general overview of wiring diagrams updates, technical bulletins, pending service solutions, tech tips, campaigns, updates, and suggestions. Read More »
This document contains the VW Elsa Newsletter that contains a general overview of wiring diagrams updates, ElsaPro infomedia icons grayed out, workshop equipment tool storage application, technical bulletins, pending service solutions, ... Read More »
Technical Bulletin: Condensation and or water droplets becomming visible on inside of exterior light lenses issue is discussed in this document Read More »
Beetle Perfect Delivery Inspection (PDI) - Technician and Detailer Inspections: A checklist to insure a customer receives a wonderful delivery of a vehicle that looks, feels, and meets the expectations of a new vehicle that he/she has ... Read More »
Beetle Perfect Delivery Inspection (PDI) - Technician and Detailer Inspections: A checklist to insure a customer receives a wonderful delivery of a vehicle that looks, feels, and meets the expectations of a new vehicle that he/she has ... Read More »
Technical Bulletin (Air Conditioning, Cleaning of the Refrigerant Circuit (U.S.Only)): In cases where an air conditioning system component (such as a compressor or other system component) has failed and debris from the compressor or ... Read More »
Technical Bulletin (Air Conditioning, Cleaning of the Refrigerant Circuit): In cases where an air conditioning system component (such as a compressor or other system component) has failed and debris from the compressor or component is ... Read More »
Technical Bulletin (Temperature Output Control Cannot Be Adjusted): Customer states cannot adjust temperature and/or A/C is not cold. The blend door control lever moves freely, but the blend door does not operate. Read More »
To detect which line(s) is inoperative, utilize a volt meter to check for 0 V, which will be present after the open in the grid line. The check must be performed with the engine running and heated rear window switched on. Read More »
