Technical Service Bulletins (TSBs) for the 2019 RAV4 are official communications between Toyota & their dealerships that describe processes for troubleshooting or fixing certain common problems.
All vehicle manufacturers are required by U.S. law to make their TSBs available to the public.
TT: Some customers may encounter Bluetooth? connectivity concerns such as: ?Difficulty to pair the phone. ?Intermittent Bluetooth? failure to connect to the vehicle when first turning on the vehicle. Read More »
TT: Some customers may experience an abnormal steering sensation (?pulling?, ?drifting?). Condition may be more pronounced after a cold soak. Read More »
TT: Some customers may experience an abnormal steering sensation (?pulling?, ?drifting?). Condition may be more pronounced after a cold soak. Read More »
TT: Some customers may experience an abnormal steering sensation (?pulling?, ?drifting?). Condition may be more pronounced after a cold soak. Read More »
TSB: Some 2019 ? 2020 model year RAV4 or RAV4 Hybrid vehicles may experience a red or yellow Electronic Power Steering (EPS) light ON condition with Diagnostic Trouble Code (DTC) C05D604 present when starting the vehicle or while driving. Read More »
Some 2019 model year RAV4, RAV4 Hybrid and some 2019 ? 2020 model year Sienna vehicles equipped Audio Plus (version 1010) or Premium Audio (version 1010) or earlier may exhibit one or more of the following conditions: ?Toyota Apps fail ... Read More »
TT: Some customers may encounter Bluetooth? connectivity concerns such as: ? Difficulty to pair the phone. ? Intermittent Bluetooth? failure to connect to the vehicle when first turning on the vehicle. Read More »
TT: Some customers may experience an abnormal steering sensation (?pulling?, ?drifting?). Condition may be more pronounced with ADAS systems (LTA, LKA, DRCC) turned on or after a cold soak. Read More »
TT: Some 19-21MY RAV4 Japan produced vehicles in Puerto Rico only exhibit a squeak type noise from the front suspension over bumps. Japan produced vehicles can be identified by VINs beginning with J. Read More »
TSB: Some 2019 ? 2021 model year RAV4 and RAV4 Hybrid vehicles may exhibit a vibration/shaking of the image shown in the outer rear-view mirror(s) while driving. Read More »
TSB: Some 2019 ? 2020 model year RAV4 and RAV4 Hybrid vehicles may exhibit a vibration/shaking of the image shown in the outer rear view mirror(s) while driving. Read More »
TT: Alignment specifications for some 2019 and 2020 new model vehicles have been updated and are significantly different from the previous model. Read More »
TSB: Some 2019 ? 2023 model year RAV4 and RAV4 Hybrid vehicles may exhibit a squeal/squeak noise from the front brakes with light to moderate braking. Read More »
TT: Some Toyota vehicles installed with Toyota Complete Maintenance Care (TCMC) brake pads may exhibit a groan or squeak noise in various driving conditions. Read More »
TT: Some Toyota vehicles installed with Toyota Complete Maintenance Care (TCMC) brake pads may exhibit a groan or squeak noise in various driving conditions. Read More »
TT: Some 2019-2020 model year RAV4 2WD vehicles may exhibit a front brake squeak at low/parking lot speeds (< 10 MPH). This condition is more likely to occur after a cold soak. Read More »
TSB: Some 2018 ? 2024 model year Toyota vehicles equipped with an A25A-FKS, A25A-FXS, M20A-FKS, or M20A-FXS engine may exhibit one or more of the following conditions: ?Milky/discolored engine oil. Read More »
TSB: Some 2014 ? 2020 model year Toyota vehicles may exhibit a hard start and/or MIL ON condition with one or more of the following Diagnostic Trouble Codes (DTCs): ?DTC P0171 and/or P0174 (System Too Lean Bank 1/Bank 2) ?DTC P0087 ... Read More »
TT: Some Toyota vehicles installed with Toyota Complete Maintenance Care (TCMC) brake pads may exhibit a groan or squeak noise in various driving conditions Read More »
TT: Some Toyota vehicles installed with Toyota Complete Maintenance Care (TCMC) brake pads may exhibit a groan or squeak noise in various driving conditions. Read More »
Some 2019 model year RAV4, RAV4 Hybrid and some 2019 ? 2020 model year Sienna vehicles equipped Audio Plus (version 1010) or Premium Audio (version 1010) or earlier may exhibit one or more of the following conditions: ?Toyota Apps fail ... Read More »
TSB: Some 2018 ? 2022 model year Toyota vehicles equipped with an A25A-FKS, A25A-FXS, or M20A-FKS engine may exhibit one or more of the following conditions: ?Milky/Discolored engine oil. Read More »
TSB: REVISION NOTICE December 23, 2019 Rev2: ? The Production Change Information section has been updated. November 20, 2019 Rev1: ? The Introduction, Production Change Information, and Repair Procedure sections have been updated. Read More »
TSB: REVISION NOTICE December 17, 2019 Rev1: ?The Parts and Calibration tables have been updated. Any previous printed versions of this bulletin should be discarded. Read More »
TSB: REVISION NOTICE July 01, 2019 Rev2: ? Applicability has been updated to 2019 ? 2020 model year Toyota vehicles. ? The Techstream Preparation and Process Overview sections have been updated. Read More »
TT: When repairing a 1234YF HVAC system on a gas powered (Non-Hybrid) Toyota and the addition of compressor oil is required to complete the repairs, the various 1234YF compressor oils (ND-12, PS-D1, or VC100YF) are available through the ... Read More »
This is to advise of various price adjustments that will affect Toyota Genuine Motor Oil and Long Life Coolant, effective March 1, 2024. These products are ordered through the Toyota Complete Maintenance Care (TCMC) website. Read More »
DP: Although the HV Floor Under Wire Harness and Rear Traction Motor Cable is covered by Toyota?s New Vehicle Limited Warranty for 3 years or 36,000 miles (whichever comes first), we at Toyota care about the customers? ownership experience. Read More »
TI: TECHNICAL INSTRUCTIONS FOR CUSTOMER SUPPORT PROGRAM 22TE09 HV FLOOR UNDER WIRE HARNESS AND REAR TRACTION MOTOR CABLE CORROSION CERTAIN 2021 ? 2022 MODEL YEAR RAV4 PRIME Read More »
TSB: Some 2021 ? 2022 model year Avalon, 2018 ? 2024 Camry, and 2019 ? 2024 RAV4 vehicles with A25A-FKS engines may have a MIL ON condition with one or more of the following Diagnostic Trouble Codes (DTCs) upon cold soak start up with ... Read More »
TSB: Some 2021 model year Avalon, 2020 ? 2022 model year Camry, and 2019 ? 2022 model year RAV4 vehicles equipped with an A25A-FKS engine may exhibit reduced engine power and/or a MIL ON condition with one or more of the following ... Read More »
TI: TECHNICAL INSTRUCTIONS FOR CUSTOMER SUPPORT PROGRAM 22TE09 HV FLOOR UNDER WIRE HARNESS AND REAR TRACTION MOTOR CABLE CORROSION CERTAIN 2019 ?2022 MODEL YEAR RAV4 HYBRID AWD (Amendment) Read More »
TT: Some Model Year 2018-2021 vehicles equipped with A25A-FKS/FXS or M20A-FKS/FXS engines may display the following message ?Engine Maintenance Required Visit Your Dealer? on the combination meter. Read More »
TT: Some Model Year 2018-2022 vehicles equipped with A25A-FKS or A25A-FXS engines may experience a MIL ON condition with the following DTCs: P043F00, P043E00, P24007E, P24007F, P24187E Read More »
TSB: This Service Bulletin provides a procedure to properly perform the Techstream ?Control the Injection Mode? active test in some 2016 ? 2022 model year Toyota vehicles equipped with an FKS engine Read More »
TT: Some 2019-2020 model year RAV4 HV vehicles may experience DTC codes P0AA649 / P1C8049. - P0AA649-Hybrid/EV Battery Voltage System Isolation Internal Electronic Failure - P1C8049-Hybrid/EV Battery Voltage System Isolation (Rear Motor ... Read More »
TT: Repairing a 1234YF HVAC system on a gas powered (non-hybrid) Toyota vehicle may require additional compressor oil to complete the repairs. Read More »
TSB: Some 2019 model year RAV4 vehicles may exhibit a hesitation on acceleration from a slow roll or rolling stop under the following conditions. Read More »
ENGINE AND ENGINE COOLING:ENGINE:HARD PARTS INTERNAL/MECHANICAL
TT: Some Model Year 2018-2023 vehicles equipped with A25A-FKS/FXS or M20A-FKS/FXS engines may display the following message ?Engine Maintenance Required Visit Your Dealer? on the combination meter Read More »
This is to advise of various price adjustments that will affect Toyota Genuine Motor Oil and Long Life Coolant, effective March 1, 2024. These products are ordered through the Toyota Complete Maintenance Care (TCMC) website. Read More »
ENGINE AND ENGINE COOLING:ENGINE:ENGINE CONTROL MODULE (ECU/ECM)
TSB: Some 2019 ? 2022 model year RAV4 vehicles may exhibit a MIL ON condition with one or more of the following Diagnostic Trouble Codes (DTCs) present: ?P0087/P008700 ? Fuel Rail/System Pressure ? Too Low ?P107A2A ? Fuel Rail ... Read More »
ENGINE AND ENGINE COOLING:ENGINE:ENGINE CONTROL MODULE (ECU/ECM):SOFTWARE
TT: Some Model Year 2018-2021 vehicles equipped with A25A-FKS/FXS or M20A-FKS/FXS engines may display the following message ?Engine Maintenance Required Visit Your Dealer? on the combination meter. Read More »
TSB: Some 2018 ? 2024 model year Toyota vehicles equipped with an A25A-FKS, A25A-FXS, M20A-FKS, or M20A-FXS engine may exhibit one or more of the following conditions: ?Milky/discolored engine oil. Read More »
TSB: Some 2003 ? 2020 model year Prius, Prius C, Prius V; 2006 ? 2019 model year Highlander Hybrid Vehicle; 2007 ? 2020 Camry Hybrid Vehicle; 2013 ? 2020 model year Avalon Hybrid Vehicle; 2016 ? 2020 model year Mirai and RAV4 Hybrid ... Read More »
ENGINE AND ENGINE COOLING:COOLING SYSTEM:HOSES/LINES/PIPING/FITTINGS
TT: Any HVAC repair requiring reassembly of the quick connect fitting between the suction hose sub-assembly and the suction pipe sub-assembly located at the top right of the engine compartment. Read More »
DP: Toyota has received customer reports of certain 2019-2021 model year RAV4 HV vehicle fuel gauges displaying less than full and/or total fuel dispensed is less than expected, when the fuel nozzle automatically clicks off. Read More »
DP: Toyota has received customer reports of certain 2019-2021 model year RAV4 HV vehicle fuel gauges displaying less than full and/or total fuel dispensed is less than expected, when the fuel nozzle automatically clicks off. Read More »
DP: Toyota has received customer reports of certain 2019-2021 model year RAV4 HV vehicle fuel gauges displaying less than full and/or total fuel dispensed is less than expected, when the fuel nozzle automatically clicks off. Read More »
RE: Toyota has received customer reports of certain 2019-2021 model year RAV4 HV vehicle fuel gauges displaying less than full and/or total fuel dispensed is less than expected, when the fuel nozzle automatically clicks off. Read More »
TSB: Some 2019 ? 2021 model year RAV4 Hybrid vehicles may experience one or both of the following conditions: ?The fuel gauge displays less than full when the fuel nozzle automatically clicks off. Read More »
DE: Toyota has received customer reports of certain 2019-2021 model year RAV4 HV vehicle fuel gauges displaying less than full and/or total fuel dispensed is less than expected, when the fuel nozzle automatically clicks off. Read More »
DP: Toyota has received customer reports of certain 2019-2020 model year RAV4 HV vehicle fuel gauges displaying less than full and/or total fuel dispensed is less than expected, when the fuel nozzle automatically clicks off. Read More »
DP: Toyota has received customer reports of certain 2019-2020 model year RAV4 HV vehicle fuel gauges displaying less than full and/or total fuel dispensed is less than expected, when the fuel nozzle automatically clicks off. Read More »
DP: Toyota has received customer reports of certain 2019-2020 model year RAV4 HV vehicle fuel gauges displaying less than full and/or total fuel dispensed is less than expected, when the fuel nozzle automatically clicks off. Read More »
DP: Toyota has received customer reports of certain 2019-2020 model year RAV4 HV vehicle fuel gauges displaying less than full and/or total fuel dispensed is less than expected, when the fuel nozzle automatically clicks off. Read More »
TSB: Some 2019 ? 2020 model year RAV4 Hybrid vehicles may experience one or both of the following conditions: ?The fuel gauge displays less than full when the fuel nozzle automatically clicks off. Read More »
RE: Toyota has received customer reports of certain 2019-2020 model year RAV4 HV vehicle fuel gauges displaying less than full and/or total fuel dispensed is less than expected, when the fuel nozzle automatically clicks off. Read More »
Some 2019 - 2020 model year RAV4 HV customers may be experiencing some concern related to the fuel gauge reading less than full. Please note, this communication refers to 2019-2020 RAV4 HV customers only. Read More »
TT: Some 2019 model year RAV4 HV customers may be experiencing some concern related to fuel gauge reading less than full. Please note, this communication refers to 2019 RAV4 HV customers only. Read More »
DP: Although the high-pressure fuel pump is covered by Toyota?s New Vehicle Limited Warranty for 5 years or 60,000 miles (whichever comes first), we at Toyota care about the customers? ownership experience. Read More »
RL: Toyota has received customer reports of certain 2019-2020 model year RAV4 HV vehicle fuel gauges displaying less than full and/or total fuel dispensed is less than expected, when the fuel nozzle automatically clicks off. Read More »
DP: This Customer Support Program provides coverage for a condition involving the front transfer case electro-magnetic clutch in certain 2019 ? 2020 model year RAV4 Adventure and Limited grade AWD vehicles. Read More »
TSB: Some 2019 ? 2022 model year RAV4 vehicles may exhibit a MIL ON condition with one or more of the following Diagnostic Trouble Codes (DTCs) present: ?P0087/P008700 ? Fuel Rail/System Pressure ? Too Low ?P107A2A ? Fuel Rail ... Read More »
TT: Some 2019- 2023 RAV4 HV vehicles may duplicate an abnormal noise (Growl, Humming and/or other) from the Hybrid T/A and/or MGR at various vehicle speeds and normal drive conditions Read More »
This condition may occur when the vehicle is operated at high altitude and high temperatures; typically, above 3,300 feet (1,000 meters) and at ambient temperatures above 85?F (30?C). Read More »
TSB: Some 2019 ? 2020 model year RAV4 Adventure and Limited grade AWD vehicles may exhibit an abnormal noise from the vehicle?s AWD Dynamic Torque Vectoring Disconnect system from either the transfer assembly or rear differential carrier ... Read More »
TSB: Some 2019 ? 2020 model year RAV4 Adventure and Limited grade AWD vehicles may exhibit an abnormal noise from the vehicle?s AWD Dynamic Torque Vectoring Disconnect system from either the transfer assembly or rear differential carrier ... Read More »
TSB: Some 2019 ? 2020 model year RAV4 Adventure and Limited grade AWD vehicles may exhibit an abnormal noise from the vehicle?s AWD Dynamic Torque Vectoring Disconnect system from either the transfer assembly or rear differential carrier ... Read More »
TT: Some 2014-2021 model year vehicles equipped with Dynamic Torque Control AWD system may experience a ?Noise? or ?Abnormal Operation? condition from the rear differential front coupling. Read More »
TT: Currently under investigation. Please contact TAS if you have a vehicle that exhibits a leak from the Transmission Side Cover with no signs of damage or other conditions unrelated to regardless of miles or months in service. Read More »
TT: Some 2018-2020 model year UA80/UB80 transmission equipped models may experience a leak from the Transmission Side Cover. This issue is currently under investigation. Vehicles are being sought regardless of months in service or mileage. Read More »
TSB: REVISION NOTICE July 01, 2019 Rev2: ? Applicability has been updated to 2019 ? 2020 model year Toyota vehicles. ? The Techstream Preparation and Process Overview sections have been updated. Read More »
TSB: Some 2019 model year RAV4 vehicles may exhibit an abnormal buzz/groan noise at 20 ? 30 mph when accelerating from a stop and/or at 13 ? 20 mph on deceleration after driving the vehicle for 15 ? 20 minutes or more. Read More »
TT: Customers may experience abnormal noise/vibration from the hybrid transaxle. Note: This is different from Vehicle Proximity Notification system. Read More »
DP: Although the HV Floor Under Wire Harness and Rear Traction Motor Cable is covered by Toyota?s New Vehicle Limited Warranty for 3 years or 36,000 miles (whichever comes first), we at Toyota care about the customers? ownership experience. Read More »
TI: TECHNICAL INSTRUCTIONS FOR CUSTOMER SUPPORT PROGRAM 22TE09 HV FLOOR UNDER WIRE HARNESS AND REAR TRACTION MOTOR CABLE CORROSION CERTAIN 2021 ? 2022 MODEL YEAR RAV4 PRIME Read More »
TSB: Some 2019 model year RAV4 vehicles may exhibit an AWD Warning Light/Message ON condition with Diagnostic Trouble Code (DTC) C13F800 (4WD/AWD Rear Disconnect System Performance) present. Read More »
TSB: Some 2019 ? 2020 model year RAV4 Adventure and Limited grade AWD vehicles may exhibit an abnormal buzz/groan noise from the front transfer case at 20 ? 30 mph when accelerating from a stop and/or at 20 ? 13 mph on deceleration after ... Read More »
DL: This Customer Support Program provides coverage for a condition involving the front transfer case electro-magnetic clutch in certain 2019 ? 2020 model year RAV4 Adventure and Limited grade AWD vehicles. Read More »
DP: This Customer Support Program provides coverage for a condition involving the front transfer case electro-magnetic clutch in certain 2019 ? 2020 model year RAV4 Adventure and Limited grade AWD vehicles. Read More »
RE: This Customer Support Program provides coverage for a condition involving the front transfer case electro-magnetic clutch in certain 2019 ? 2020 model year RAV4 Adventure and Limited grade AWD vehicles. Read More »
TSB: Some 2019 model year RAV4 Adventure and Limited grade AWD vehicles may exhibit an abnormal buzz/groan noise from the front transfer case at 20 ? 30 mph when accelerating from a stop and/or at 20 ? 13 mph on deceleration after driving ... Read More »
TSB: REVISION NOTICE November 20, 2019 Rev1: ? The Introduction, Production Change Information, and Repair Procedure sections have been updated. Any previous printed versions of this bulletin should be discarded. Read More »
TSB: Some 2019 - 2020 model year RAV4 Adventure and Limited grade AWD vehicles may exhibit an abnormal noise from the rear differential assembly when accelerating from a stop and/or on deceleration after driving the vehicle for 15 - 20 ... Read More »
TSB: The Immobilizer and Smart Key Reset is a feature that allows the registration of new keys when all master keys are lost. Once the system is reset, all previously registered keys will be erased and can never be reused. Read More »
TSB: Some 2018 ? 2024 model year Toyota vehicles equipped with an A25A-FKS, A25A-FXS, M20A-FKS, or M20A-FXS engine may exhibit one or more of the following conditions: ?Milky/discolored engine oil. Read More »
TT: Some Model Year 2018-2022 vehicles equipped with A25A-FKS or A25A-FXS engines may experience a MIL ON condition with the following DTCs: P043F00, P043E00, P24007E, P24007F, P24187E Read More »
This condition may occur when the vehicle is operated at high altitude and high temperatures; typically, above 3,300 feet (1,000 meters) and at ambient temperatures above 85?F (30?C). Read More »
TSB: Some 2019 ? 2022 model year RAV4 vehicles may exhibit a MIL ON condition with one or more of the following Diagnostic Trouble Codes (DTCs) present: ?P0087/P008700: Fuel Rail/System Pressure ? Too Low ?P107A2A: Fuel Rail Pressure ... Read More »
TSB: Some 2018 ? 2022 model year Toyota vehicles equipped with an A25A-FKS, A25A-FXS, or M20A-FKS engine may exhibit one or more of the following conditions: ?Milky/Discolored engine oil. Read More »
DP: Toyota has received customer reports of certain 2019-2021 model year RAV4 HV vehicle fuel gauges displaying less than full and/or total fuel dispensed is less than expected, when the fuel nozzle automatically clicks off. Read More »
TSB: Some 2019 model year Avalon and Avalon Hybrid vehicles equipped with Entune? Audio Plus (version 1002) or Entune? Premium Audio (version 1002) or earlier may exhibit one or more of the following conditions: ?Incorrect GPS date and ... Read More »
TT: To assist with the early detection and early resolution of audio related concerns, it may be requested as part of the remanufactured head unit return to recover MMR data from the head unit. Read More »
TT: Some 2019-2020 model year RAV4 HV vehicles may experience DTC codes P0AA649 / P1C8049. - P0AA649-Hybrid/EV Battery Voltage System Isolation Internal Electronic Failure - P1C8049-Hybrid/EV Battery Voltage System Isolation (Rear Motor ... Read More »
TT: Some customers may encounter Bluetooth? connectivity concerns such as: ?Difficulty to pair the phone. ?Intermittent Bluetooth? failure to connect to the vehicle when first turning on the vehicle. Read More »
TSB Some 2019 ? 2020 model year RAV4 vehicles may exhibit an AWD Warning Light ON condition with Diagnostic Trouble Code (DTC) C13F800 (4WD/AWD Rear Disconnect System Performance) present. Read More »
TT: Some customers may experience an abnormal steering sensation (?pulling?, ?drifting?). Condition may be more pronounced after a cold soak. Read More »
TSB: Some 2003 ? 2020 model year Prius, Prius C, Prius V; 2006 ? 2019 model year Highlander Hybrid Vehicle; 2007 ? 2020 Camry Hybrid Vehicle; 2013 ? 2020 model year Avalon Hybrid Vehicle; 2016 ? 2020 model year Mirai and RAV4 Hybrid ... Read More »
TSB: Some 2004 ? 2020 model year Hybrid vehicles may exhibit an excessive buildup of dust, lint, or debris in the HV battery intake filter or cooling fan. The condition could reduce the efficiency of the HV battery cooling system. Read More »
TSB: Some 2019 ? 2020 model year RAV4 or RAV4 Hybrid vehicles may experience a red or yellow Electronic Power Steering (EPS) light ON condition with Diagnostic Trouble Code (DTC) C05D604 present when starting the vehicle or while driving. Read More »
TT: Some customers may experience an abnormal steering sensation (?pulling?, ?drifting?). Condition may be more pronounced with ADAS systems (LTA, LKA, DRCC) turned on or after a cold soak. Read More »
TT: To assist with the early detection and early resolution of audio related concerns, it may be requested as part of the remanufactured head unit return to recover MMR data from the head unit. Read More »
TT: The microphone circuit passes through the DCM before reaching the radio/navigation system. To simplify the diagnosis of the microphone, Safety Connect SOS button lights, and DCM (Data Communication Module/telematics transceiver) ... Read More »
TSB: SUPERSESSION NOTICE The information contained in this bulletin supersedes Service Bulletin No. T-SB-0143-18. Service Bulletin No. T-SB-0143-18 is obsolete and any printed versions should be discarded. Read More »
TSB: Some 2019 ? 2020 model year RAV4 HV vehicles may experience a difficult-to-start condition accompanied by a hybrid system warning lamp occurring during below-freezing temperatures (< 32?F). Read More »
Some 2019 model year RAV4, RAV4 Hybrid and some 2019 ? 2020 model year Sienna vehicles equipped Audio Plus (version 1010) or Premium Audio (version 1010) or earlier may exhibit one or more of the following conditions: ?Toyota Apps fail ... Read More »
TSB: REVISION NOTICE December 23, 2019 Rev1: ? The Parts Information and Repair Procedure sections have been updated. Any previous printed versions of this bulletin should be discarded. Read More »
TT: Safety Connect is a vehicle option which requires a subscription fee for the system to be active after the initial trial period. Once the subscription has expired the DCM (Telematics Transceiver) will be in an inactive state. Read More »
TT: Some customers may experience a call failure when attempting to call a conference call number that has been saved in their phonebook (ex: ?8005550122,,,1.,2;;;2#?). Read More »
TT: The new DCA-8000 Diagnostic Charger may cause your facility?s Ground Fault Circuit Interrupter (GFCI) breaker to trip. A GFCI breaker can be tripped for various reasons, one of the reasons may be related to the DCA-8000. Read More »
TSB: Some 2019 model year RAV4 Hybrid vehicles may exhibit a flutter/rattle noise during vehicle operation from the HV battery cooling fan. A new HV battery intake duct has been developed. Read More »
TSB: REVISION NOTICE July 01, 2019 Rev2: ? Applicability has been updated to 2019 ? 2020 model year Toyota vehicles. ? The Techstream Preparation and Process Overview sections have been updated. Read More »
TSB: REVISION NOTICE June 17, 2019 Rev1: ? Applicability has been updated to include 2019 ? 2020 model year Corolla Hatchback, RAV4, and RAV4 Hybrid and 2020 model year Corolla and Corolla Hybrid vehicles. Read More »
TT: Some customers may encounter Bluetooth? connectivity concerns such as: ? Difficulty to pair the phone. ? Intermittent Bluetooth? failure to connect to the vehicle when first turning on the vehicle. Read More »
TT: Vehicle control apps might not operate as expected at times due to preconditions (normal operating parameters) not being established, vehicle settings and/or network/cellular coverage concerns. Read More »
TSB: REVISION NOTICE February 11, 2019 Rev2: ? The Before Inspection section has been updated. January 14, 2019 Rev1: ? The Required Tools & Equipment section has been updated. Read More »
TSB: Pre-Delivery Service (PDS) is a critical step in satisfying our new car customers. Customer feedback indicates the following areas deserve special attention when performing PDS: ? Careful inspection for paint chips/scratches and body ... Read More »
TSB: SUPERSESSION NOTICE The information contained in this bulletin supersedes Service Bulletin No. T-SB-0235-17. ? Applicability has been updated to include 2019 model year Toyota vehicles. Service Bulletin No. Read More »
TSB: REVISION NOTICE May 08, 2018 Rev1: * Applicability has been updated to include 2019 model year Toyota vehicles. Any previous printed versions of this bulletin should be discarded. Read More »
TT: When customers have a concern about a discharged battery, no start, or general battery concern, the DCA-8000 is the only appropriate tool to use for diagnosis Read More »
TT: The new DCA-8000 Diagnostic Charger may cause your facility?s Ground Fault Circuit Interrupter (GFCI) breaker to trip. A GFCI breaker can be tripped for various reasons, one of the reasons may be related to the DCA-8000. Read More »
TSB: Some 2019 model year RAV4 Hybrid vehicles may exhibit a flutter/rattle noise during vehicle operation from the HV battery cooling fan. A new HV battery intake duct has been developed. Read More »
TSB This Service Bulletin includes guidelines meant to help determine whether to repair or replace a wire harness assembly based on damage type. Read More »
DP: Toyota has received customer reports of certain 2019-2021 model year RAV4 HV vehicle fuel gauges displaying less than full and/or total fuel dispensed is less than expected, when the fuel nozzle automatically clicks off. Read More »
TSB: Some 2019 ? 2020 model year RAV4 Adventure and Limited grade AWD vehicles may exhibit an abnormal buzz/groan noise from the front transfer case at 20 ? 30 mph when accelerating from a stop and/or at 20 ? 13 mph on deceleration after ... Read More »
TSB: Some 2018 ? 2020 model year Toyota vehicles equipped with a Premium Audio with Dynamic Navigation System require a Special Service Tool (SST) USB flash drive to update the map, points of interest, and system software. Read More »
TSB: Some 2018 ? 2020 model year Toyota vehicles equipped with a Premium Audio with Dynamic Navigation System require a Special Service Tool (SST) USB flash drive to update the map, points of interest, and system software. Read More »
TSB: SUPERSESSION NOTICE The information contained in this bulletin supersedes Service Bulletin No. T-SB-0160-19. Service Bulletin No. T-SB-0160-19 is obsolete and any printed versions should be discarded. Read More »
TSB: The Immobilizer and Smart Key Reset is a feature that allows the registration of new keys when all master keys are lost. Once the system is reset, all previously registered keys will be erased and can never be reused. Read More »
TSB: Some 2018 ? 2019 model year Toyota vehicles equipped with the Entune? 3.0 Premium Audio Navigation System require a Special Service Tool (SST) USB flash drive to update the map, points of interest, and system software. Read More »
TT: Some 2019- 2023 RAV4 HV vehicles may duplicate an abnormal noise (Growl, Humming and/or other) from the Hybrid T/A and/or MGR at various vehicle speeds and normal drive conditions. Read More »
TT: When used in conjunction with the Repair Manual, these Blind Spot Monitor, Forward Recognition Camera, and Front Millimeter Wave Radar tips leverage SSTs and readily available tools to support target placement in varying shop ... Read More »
TSB: Some 2019 ? 2021 model year RAV4 and RAV4 Hybrid vehicles may exhibit a vibration/shaking of the image shown in the outer rear-view mirror(s) while driving. Read More »
TSB: Some 2019 ? 2020 model year RAV4 and RAV4 Hybrid vehicles may exhibit a vibration/shaking of the image shown in the outer rear view mirror(s) while driving. Read More »
TSB: Some 2019 ? 2020 model year RAV4 and RAV4 Hybrid vehicles may exhibit a vibration/shaking of the image shown in the outer rear view mirror(s) while driving. Read More »
TT: The blind spot monitor (BSM) sensor angle inspection is used to confirm that the BSM sensor is within the specified angle before performing axis beam adjustment. Read More »
TT: The blind spot monitor (BSM) sensor angle inspection is used to confirm that the BSM sensor is within the specified angle before performing axis beam adjustment. Read More »
TT: When used in conjunction with the Repair Manual, these Blind Spot Monitor, Forward Recognition Camera, and Front Millimeter Wave Radar tips leverage SSTs and readily available tools to support target placement in varying shop ... Read More »
VISIBILITY:DEFROSTER/DEFOGGER/HVAC SYSTEM:REFRIGERANT HOSES AND FITTINGS
TSB: The air conditioning dye injection tool kit has been developed to aid in identifying the location of air conditioning refrigerant leaks. Read More »
TSB: Replacement certification labels (the vinyl label installed on the driver door or door post) and VIN plates (the metal plate riveted to dashboard) (see Figure 1) for most 1979 ? 2023 model year vehicles may be available provided the ... Read More »
TSB: Some 2005 ? 2022 model year Toyota vehicles that have undergone water intrusion may exhibit a condition in which a musty smell is present. Follow the procedures in this bulletin to remediate the odor and address this condition. Read More »
DP: Toyota has received customer reports of certain 2019-2021 model year RAV4 HV vehicle fuel gauges displaying less than full and/or total fuel dispensed is less than expected, when the fuel nozzle automatically clicks off. Read More »
DP: Toyota has received customer reports of certain 2019-2020 model year RAV4 HV vehicle fuel gauges displaying less than full and/or total fuel dispensed is less than expected, when the fuel nozzle automatically clicks off. Read More »
RE: Toyota has received customer reports of certain 2019-2020 model year RAV4 HV vehicle fuel gauges displaying less than full and/or total fuel dispensed is less than expected, when the fuel nozzle automatically clicks off. Read More »
TSB: Some 2010 ? 2022 model year Toyota vehicles may exhibit paint stains after the removal of Rapgard?. The paint stains may appear to be under the clear coat but are usually under wrinkles in the Rapgard?. Read More »
TSB: Some 2010 ? 2022 model year Toyota vehicles may exhibit paint stains after the removal of Rapgard?. The paint stains may appear to be under the clear coat but are usually under wrinkles in the Rapgard?. Read More »
TSB: Some 2005 ? 2022 model year Toyota vehicles that have undergone water intrusion may exhibit a condition in which a musty smell is present. Follow the procedures in this bulletin to remediate the odor and address this condition. Read More »
TSB: Some 2018 ? 2020 model year Toyota vehicles equipped with a Premium Audio with Dynamic Navigation System require a Special Service Tool (SST) USB flash drive to update the map, points of interest, and system software. Read More »
TSB: TMNA Accessory Sales and Marketing has developed a Toyota paint protection film (PPF) decal (treated with a specially developed light adhesive) for 2019 ? 2020 model year Toyota vehicles. The decal comes in two sizes (2.8 in. x 8 in. Read More »
TSB: REVISION NOTICE January 14, 2019 Rev1: ? The Required Tools & Equipment section has been updated. Any previous printed versions of this bulletin should be discarded. Read More »
TSB: Pre-Delivery Service (PDS) is a critical step in satisfying our new car customers. Customer feedback indicates the following areas deserve special attention when performing PDS: ? Careful inspection for paint chips/scratches and body ... Read More »
TSB: Some 2019 ? 2021 model year RAV4 and RAV4 Hybrid and 2021 model year RAV4 Prime vehicles may exhibit water entry from one or more roof rail garnish clips. Follow the procedures in this bulletin to address this condition. Read More »
TSB: Some 2019 ? 2022 model year RAV4 and RAV4 Hybrid, and 2021 ? 2022 model year RAV4 Prime vehicles may exhibit a sloshing or splashing noise from inside one or more door panels when driving, opening and/or closing a door, and/or braking. Read More »
TSB: Some 2019 model year RAV4 and RAV4 Hybrid vehicles may exhibit an inoperative shift-linked and/or speed-linked automatic door lock condition. Read More »
DL: Although the roof rails are covered by Toyota?s New Vehicle Limited Warranty for 3 years or 36,000 miles (whichever comes first), we at Toyota care about the customers? ownership experience. Read More »
RL: The specific condition covered by this program is roof rail water leaks from the roof rail mounting clips due to deterioration of the seal of the roof rail clips. Read More »
TSB: Some 2019 ? 2021 model year RAV4 and RAV4 Hybrid and 2021 model year RAV4 Prime vehicles may exhibit water entry from one or more roof rail garnish clips. Follow the procedures in this bulletin to address this condition. Read More »
TSB: REVISION NOTICE November 11, 2019 Rev1: ? The title of this bulletin has been updated to include ?Lock.? Any previous printed versions of this bulletin should be discarded. Read More »
TSB: Replacement certification labels (the vinyl label installed on the driver door or door post) and VIN plates (the metal plate riveted to dashboard) (see Figure 1) for most 1979 ? 2023 model year vehicles may be available provided the ... Read More »
TSB: Some 2019 ? 2022 model year RAV4 and RAV4 Hybrid and 2021 ? 2022 model year RAV4 Prime vehicles may exhibit a sloshing or splashing noise from inside one or more door panels when driving, opening and/or closing a door, and/or braking. Read More »
TI: TECHNICAL INSTRUCTIONS FOR CUSTOMER SUPPORT PROGRAM 22TE09 HV FLOOR UNDER WIRE HARNESS AND REAR TRACTION MOTOR CABLE CORROSION CERTAIN 2019 ?2022 MODEL YEAR RAV4 HYBRID AWD (Amendment) Read More »
TSB: Some 2021 model year Avalon, 2020 ? 2022 model year Camry, and 2019 ? 2022 model year RAV4 vehicles equipped with an A25A-FKS engine may exhibit reduced engine power and/or a MIL ON condition with one or more of the following ... Read More »
POL: This consolidated Tire Warranty Guide contains the complete warranty terms for all brands of ground and spare tires currently in use by Toyota. Read More »
POL: This consolidated Tire Warranty Guide contains the complete warranty terms for all brands of ground and spare tires currently in use by Toyota. Read More »
Some 2019 model year RAV4, RAV4 Hybrid and some 2019 ? 2020 model year Sienna vehicles equipped Audio Plus (version 1010) or Premium Audio (version 1010) or earlier may exhibit one or more of the following conditions: ?Toyota Apps fail ... Read More »
TSB: Some 2009 ? 2019 model year Toyota vehicles with super chrome wheel finishes may become discolored and/or damaged when aftermarket cleaners, polishes, or brake dust removal products are used on wheels with super chrome finishes. Read More »
TSB: Some 2010 ? 2022 model year Toyota vehicles may exhibit paint stains after the removal of Rapgard?. The paint stains may appear to be under the clear coat but are usually under wrinkles in the Rapgard?. Read More »
TSB: Some 2010 ? 2021 model year Toyota vehicles may exhibit paint stains after the removal of Rapgard?. The paint stains may appear to be under the clear coat but are usually under wrinkles in the Rapgard?. Read More »
TT: Some 2019 model year RAV4 & RAV4 HV may exhibit a condition where the driver seat memory is inoperative or is not registered (initialized). This may be caused by the seat memory initialization not being conducted during PDS. Read More »
TT: Some 19-21MY RAV4 Japan produced vehicles in Puerto Rico only exhibit a squeak type noise from the front suspension over bumps. Japan produced vehicles can be identified by VINs beginning with J. Read More »
TT: When adjusting the Forward Recognition Camera on vehicles with Toyota Safety Sense, it can be difficult to print the repair manual target to the proper size. Read More »
FORWARD COLLISION AVOIDANCE: SENSING SYSTEM: CAMERA
TT: When adjusting the Forward Recognition Camera on vehicles with Toyota Safety Sense, it can be difficult to print the repair manual target to the proper size. Read More »
TSB: Some 2018 ? 2024 model year Toyota vehicles equipped with an A25A-FKS, A25A-FXS, M20A-FKS, or M20A-FXS engine may exhibit one or more of the following conditions: ?Milky/discolored engine oil. Read More »
TT: When used in conjunction with the Repair Manual, these Blind Spot Monitor, Forward Recognition Camera, and Front Millimeter Wave Radar tips leverage SSTs and readily available tools to support target placement in varying shop ... Read More »
TT: The blind spot monitor (BSM) sensor angle inspection is used to confirm that the BSM sensor is within the specified angle before performing axis beam adjustment. Read More »
TT: The blind spot monitor (BSM) sensor angle inspection is used to confirm that the BSM sensor is within the specified angle before performing axis beam adjustment. Read More »
TT: When used in conjunction with the Repair Manual, these Blind Spot Monitor, Forward Recognition Camera, and Front Millimeter Wave Radar tips leverage SSTs and readily available tools to support target placement in varying shop ... Read More »
TT: When used in conjunction with the Repair Manual, these Blind Spot Monitor, Forward Recognition Camera, and Front Millimeter Wave Radar tips leverage SSTs and readily available tools to support target placement in varying shop ... Read More »
TT: When used in conjunction with the Repair Manual, these Blind Spot Monitor, Forward Recognition Camera, and Front Millimeter Wave Radar tips leverage SSTs and readily available tools to support target placement in varying shop ... Read More »
DP: This Customer Support Program provides coverage for a condition involving the front transfer case electro-magnetic clutch in certain 2019 ? 2020 model year RAV4 Adventure and Limited grade AWD vehicles. Read More »
TT: Some 19-21MY RAV4 Japan produced vehicles in Puerto Rico only exhibit a squeak type noise from the front suspension over bumps. Japan produced vehicles can be identified by VINs beginning with J. Read More »
TSB: Some 2019 ? 2021 model year RAV4 and RAV4 Hybrid and 2021 model year RAV4 Prime vehicles may exhibit a rattle noise from the sliding roof assembly when it is in the tilted open position while driving over a bumpy road. Read More »
TT: Some Toyota vehicles installed with Toyota Complete Maintenance Care (TCMC) brake pads may exhibit a groan or squeak noise in various driving conditions Read More »
TSB: Some 2019 ? 2022 model year RAV4 and RAV4 Hybrid and 2021 ? 2022 model year RAV4 Prime vehicles may exhibit a sloshing or splashing noise from inside one or more door panels when driving, opening and/or closing a door, and/or braking. Read More »
TT: Some Toyota vehicles installed with Toyota Complete Maintenance Care (TCMC) brake pads may exhibit a groan or squeak noise in various driving conditions. Read More »
TT: Some Toyota vehicles installed with Toyota Complete Maintenance Care (TCMC) brake pads may exhibit a groan or squeak noise in various driving conditions. Read More »
TSB: Some 2019 ? 2020 model year RAV4 Adventure and Limited grade AWD vehicles may exhibit an abnormal buzz/groan noise from the front transfer case at 20 ? 30 mph when accelerating from a stop and/or at 20 ? 13 mph on deceleration after ... Read More »
TSB: Some 2019 model year RAV4 and RAV4 Hybrid and 2018 ? 2020 model year Sienna vehicles equipped with Audio Plus (version 1010) or Premium Audio (version 1010) or earlier may exhibit one or more of the following conditions: ?Toyota apps ... Read More »
TSB: SUPERSESSION NOTICE The information contained in this bulletin supersedes Service Bulletin No. T-SB-0065-19. ?Production Change Information section has been updated. Service Bulletin No. Read More »
TSB: SUPERSESSION NOTICE The information contained in this bulletin supersedes Service Bulletin No. T-SB-0039-19. The aforementioned bulletin is obsolete, and any printed versions should be discarded. Read More »
Some 2019 model year RAV4, RAV4 Hybrid and some 2019 ? 2020 model year Sienna vehicles equipped Audio Plus (version 1010) or Premium Audio (version 1010) or earlier may exhibit one or more of the following conditions: ?Toyota Apps fail ... Read More »
TSB: Some 2018 ? 2020 model year Toyota vehicles equipped with a Premium Audio with Dynamic Navigation System require a Special Service Tool (SST) USB flash drive to update the map, points of interest, and system software. Read More »
TT: A very small percentage of customers experience operational difficulties with some telematics features which they cannot resolve on their own. Read More »
TT: To improve customer support of telematics connected services features, additional resources have been provided in the Service Lane - Knowledge Center. Read More »
TSB: Replacement certification labels (the vinyl label installed on the driver door or door post) and VIN plates (the metal plate riveted to dashboard) (see Figure 1) for most 1979 ? 2023 model year vehicles may be available provided the ... Read More »
TSB: Some 2014 ? 2020 model year Toyota vehicles may exhibit a hard start and/or MIL ON condition with one or more of the following Diagnostic Trouble Codes (DTCs): ?DTC P0171 and/or P0174 (System Too Lean Bank 1/Bank 2) ?DTC P0087 ... Read More »
TSB: Some 2018 ? 2022 model year Toyota vehicles equipped with an A25A-FKS, A25A-FXS, or M20A-FKS engine may exhibit one or more of the following conditions: ?Milky/Discolored engine oil. Read More »
TSB: Some 2019 ? 2022 model year RAV4 and RAV4 Hybrid, and 2021 ? 2022 model year RAV4 Prime vehicles may exhibit a sloshing or splashing noise from inside one or more door panels when driving, opening and/or closing a door, and/or braking. Read More »
TSB: Some 2019 ? 2020 model year RAV4 Adventure and Limited grade AWD vehicles may exhibit an abnormal buzz/groan noise from the front transfer case at 20 ? 30 mph when accelerating from a stop and/or at 20 ? 13 mph on deceleration after ... Read More »
TSB: Some 2019 model year Avalon and Avalon Hybrid vehicles equipped with Entune? Audio Plus (version 1002) or Entune? Premium Audio (version 1002) or earlier may exhibit one or more of the following conditions: ?Incorrect GPS date and ... Read More »
TSB: Replacement certification labels (the vinyl label installed on the driver door or door post) and VIN plates (the metal plate riveted to dashboard) (see Figure 1) for most 1979 ? 2021 model year vehicles may be available provided the ... Read More »
DP: Toyota has received customer reports of certain 2019-2020 model year RAV4 HV vehicle fuel gauges displaying less than full and/or total fuel dispensed is less than expected, when the fuel nozzle automatically clicks off. Read More »
DL: This Customer Support Program provides coverage for a condition involving the front transfer case electro-magnetic clutch in certain 2019 ? 2020 model year RAV4 Adventure and Limited grade AWD vehicles. Read More »
DP: This Customer Support Program provides coverage for a condition involving the front transfer case electro-magnetic clutch in certain 2019 ? 2020 model year RAV4 Adventure and Limited grade AWD vehicles. Read More »
RE: This Customer Support Program provides coverage for a condition involving the front transfer case electro-magnetic clutch in certain 2019 ? 2020 model year RAV4 Adventure and Limited grade AWD vehicles. Read More »
TSB: Some 2019 ? 2020 model year RAV4 Hybrid vehicles may experience one or both of the following conditions: ?The fuel gauge displays less than full when the fuel nozzle automatically clicks off. Read More »
TT: NOTE: This document only applies to certain audio packages for the following vehicles. 2019 C-HR (Audio Plus & Premium Only) 2020 Prius (Audio Only) 2020 Prius Prime (Audio Plus Only) Head unit telematics services become ... Read More »
TT: Some customers may encounter Bluetooth? connectivity concerns such as: ?Difficulty to pair the phone. ?Intermittent Bluetooth? failure to connect to the vehicle when first turning on the vehicle. Read More »
TSB Some 2019 ? 2020 model year RAV4 vehicles may exhibit an AWD Warning Light ON condition with Diagnostic Trouble Code (DTC) C13F800 (4WD/AWD Rear Disconnect System Performance) present. Read More »
TT: Some customers may experience an abnormal steering sensation (?pulling?, ?drifting?). Condition may be more pronounced after a cold soak. Read More »
TT: Some customers may experience an abnormal steering sensation (?pulling?, ?drifting?). Condition may be more pronounced after a cold soak. Read More »
TSB: Some 2019 ? 2020 model year RAV4 and RAV4 Hybrid vehicles may exhibit a vibration/shaking of the image shown in the outer rear view mirror(s) while driving. Read More »
TSB: Some 2019 ? 2020 model year RAV4 and RAV4 Hybrid vehicles may exhibit a vibration/shaking of the image shown in the outer rear view mirror(s) while driving. Read More »
TSB: Some 2003 ? 2020 model year Prius, Prius C, Prius V; 2006 ? 2019 model year Highlander Hybrid Vehicle; 2007 ? 2020 Camry Hybrid Vehicle; 2013 ? 2020 model year Avalon Hybrid Vehicle; 2016 ? 2020 model year Mirai and RAV4 Hybrid ... Read More »
TT: To assist with the early detection and early resolution of audio related concerns, it may be requested as part of the remanufactured head unit return to recover MMR data from the head unit. Read More »
TT: The microphone circuit passes through the DCM before reaching the radio/navigation system. To simplify the diagnosis of the microphone, Safety Connect SOS button lights, and DCM (Data Communication Module/telematics transceiver) ... Read More »
TT: Due to the challenges caused by the COVID-19 virus threat, some dealers are experiencing reduced traffic into their stores and causing dealer stock to age. Read More »
TSB: SUPERSESSION NOTICE The information contained in this bulletin supersedes Service Bulletin Nos. PG021-88, PG015-89, PG0015-90, PG002-91, PG002-93, PG005-97, PG007-01, PG007-07, PG006-01, PG004-97, T-SB-0144-08, and T-SB-0304-17. Read More »
TT: Some 2019-2020 model year RAV4 2WD vehicles may exhibit a front brake squeak at low/parking lot speeds (< 10 MPH). This condition is more likely to occur after a cold soak. Read More »
Toyota is investigating reports of certain 2019 and 2020 RAV4 Hybrid vehicle fuel gauges displaying less than full and/or total fuel dispensed is less than expected, when the fuel nozzle automatically clicks off. Read More »
TSB: Vehicles may display evidence of a fluid leak or fluid seep from powertrain components. This bulletin explains how to determine the differences between a fluid leak versus a fluid seep. Read More »
TT: Some vehicles equipped with Dynamic Navigation may experience a pop-up message notifying them that their map update service will end soon. The date that is shown could be more than one year in the future. Read More »
TSB: REVISION NOTICE December 20, 2019 Rev1: ? The entire bulletin has been updated. Any previous printed versions of this bulletin should be discarded. Read More »
TSB: REVISION NOTICE December 17, 2019 Rev1: ?The Parts and Calibration tables have been updated. Any previous printed versions of this bulletin should be discarded. Read More »
TSB: REVISION NOTICE December 13, 2019 Rev1: ? Applicability has been updated to include several 2020 model year Toyota vehicles. ? The Required Tools & Equipment section has been updated. Read More »
TSB: REVISION NOTICE November 20, 2019 Rev1: ? The Introduction, Production Change Information, and Repair Procedure sections have been updated. Any previous printed versions of this bulletin should be discarded. Read More »
TSB: REVISION NOTICE September 24, 2019 Rev1: ? Applicability has been updated to include 2020 model year RAV4 and RAV4 HV vehicles. Any previous printed versions of this bulletin should be discarded. Read More »
TSB: Some 2019 model year RAV4 vehicles may exhibit an AWD Warning Light/Message ON condition with Diagnostic Trouble Code (DTC) C13F800 (4WD/AWD Rear Disconnect System Performance) present. Read More »
TT: The new DCA-8000 Diagnostic Charger may cause your facility?s Ground Fault Circuit Interrupter (GFCI) breaker to trip. A GFCI breaker can be tripped for various reasons, one of the reasons may be related to the DCA-8000. Read More »
TSB: Some 2009 ? 2019 model year Toyota vehicles with super chrome wheel finishes may become discolored and/or damaged when aftermarket cleaners, polishes, or brake dust removal products are used on wheels with super chrome finishes. Read More »
TT: When repairing a 1234YF HVAC system on a gas powered (Non-Hybrid) Toyota and the addition of compressor oil is required to complete the repairs, the various 1234YF compressor oils (ND-12, PS-D1, or VC100YF) are available through the ... Read More »
TSB: TMNA Accessory Sales and Marketing has developed a Toyota paint protection film (PPF) decal (treated with a specially developed light adhesive) for 2019 ? 2020 model year Toyota vehicles. The decal comes in two sizes (2.8 in. x 8 in. Read More »
TSB: REVISION NOTICE June 17, 2019 Rev1: ? Applicability has been updated to include 2019 ? 2020 model year Corolla Hatchback, RAV4, and RAV4 Hybrid and 2020 model year Corolla and Corolla Hybrid vehicles. Read More »
TSB: REVISION NOTICE May 15, 2019 Rev1: ? Applicability has been updated to include 2019 model year C-HR, Camry, Camry Hybrid, Corolla Hatchback, RAV4, and RAV4 Hybrid and 2020 model year Corolla and Corolla Hybrid vehicles. Read More »
TSB: Some 2018 ? 2019 model year Toyota vehicles equipped with the Entune? 3.0 Premium Audio Navigation System require a Special Service Tool (SST) USB flash drive to update the map, points of interest, and system software. Read More »
TT: Some customers may encounter Bluetooth? connectivity concerns such as: ? Difficulty to pair the phone. ? Intermittent Bluetooth? failure to connect to the vehicle when first turning on the vehicle. Read More »
TT: Vehicle control apps might not operate as expected at times due to preconditions (normal operating parameters) not being established, vehicle settings and/or network/cellular coverage concerns. Read More »
TSB: REVISION NOTICE February 11, 2019 Rev2: ? The Before Inspection section has been updated. January 14, 2019 Rev1: ? The Required Tools & Equipment section has been updated. Read More »
TT: Some Toyota vehicles may exhibit a Lexus Enform Activation pop-up screen during the PDS process. This is a normal condition, please see the recommendations section below. Read More »
TSB: REVISION NOTICE January 14, 2019 Rev1: ? The Required Tools & Equipment section has been updated. Any previous printed versions of this bulletin should be discarded. Read More »
TT: When adjusting the Forward Recognition Camera on vehicles with Toyota Safety Sense, it can be difficult to print the repair manual target to the proper size. Read More »
TSB: Some 2019 model year RAV4 and RAV4 HV vehicles shipped from Japan may have front emergency towing eyelets installed to aid in transportation. Read More »
TT: Some customers may encounter Bluetooth? connectivity concerns such as: ? Difficulty to pair the phone. ? Intermittent Bluetooth? failure to connect to the vehicle when first turning on the vehicle. Read More »
TT: Some customers may encounter Bluetooth? connectivity concerns such as: ?Difficulty to pair the phone. ?Intermittent Bluetooth? failure to connect to the vehicle when first turning on the vehicle. Read More »
TSB: Some 2018 ? 2020 model year Sienna (XLE, Limited); 2019 model year Avalon, Avalon Hybrid, Corolla Hatchback, Highlander (Platinum only), Highlander Hybrid (Platinum only), RAV4, and RAV4 Hybrid; and 2020 model year Corolla, Corolla ... Read More »
TT: NOTE: This document only applies to certain audio packages for the following vehicles. 2019 C-HR (Audio Plus & Premium Only) 2020 Prius (Audio Only) 2020 Prius Prime (Audio Plus Only) Head unit telematics services become ... Read More »
TSB: Some 2019 model year RAV4 and RAV4 Hybrid and 2018 ? 2020 model year Sienna vehicles equipped with Audio Plus (version 1010) or Premium Audio (version 1010) or earlier may exhibit one or more of the following conditions: ?Toyota apps ... Read More »
TSB: Some 2018 ? 2020 model year Sienna (XLE, Limited); 2019 model year Avalon, Avalon Hybrid, Corolla Hatchback, Highlander (Platinum only), Highlander Hybrid (Platinum only), RAV4, and RAV4 Hybrid; and 2020 model year Corolla, Corolla ... Read More »
TSB: Some 2004 ? 2020 model year Hybrid vehicles may exhibit an excessive buildup of dust, lint, or debris in the HV battery intake filter or cooling fan. The condition could reduce the efficiency of the HV battery cooling system. Read More »
TT: Some vehicles equipped with Dynamic Navigation may experience a pop-up message notifying them that their map update service will end soon. The date that is shown could be more than one year in the future. Read More »
TSB: REVISION NOTICE January 15, 2020 Rev1: ? Applicability has been updated to include 2019 model year RAV4 and RAV4 Hybrid vehicles. Any previous printed versions of this bulletin should be discarded. Read More »
TT: Some customers may encounter Bluetooth? connectivity concerns such as: ? Difficulty to pair the phone. ? Intermittent Bluetooth? failure to connect to the vehicle when first turning on the vehicle. Read More »
TT: Vehicle control apps might not operate as expected at times due to preconditions (normal operating parameters) not being established, vehicle settings and/or network/cellular coverage concerns. Read More »
TT: Some customers may encounter Bluetooth? connectivity concerns such as: ? Difficulty to pair the phone. ? Intermittent Bluetooth? failure to connect to the vehicle when first turning on the vehicle. Read More »
TSB: The Immobilizer and Smart Key Reset is a feature that allows the registration of new keys when all master keys are lost. Once the system is reset, all previously registered keys will be erased and can never be reused. Read More »
TT: To assist with the early detection and early resolution of audio related concerns, it may be requested as part of the remanufactured head unit return to recover MMR data from the head unit. Read More »
TT: Vehicles listed above equipped with a Denso Ten radio (Entune Audio Plus or Premium Audio) may exhibit a condition in which the radio screen continues to show a Bluetooth phone call in progress after the call has ended. Read More »
TT: To assist with the early detection and early resolution of audio related concerns, it may be requested as part of the remanufactured head unit return to recover MMR data from the head unit. Read More »
TSB: Some 2018 ? 2020 model year Toyota vehicles equipped with a Premium Audio with Dynamic Navigation System require a Special Service Tool (SST) USB flash drive to update the map, points of interest, and system software. Read More »
TSB: Some 2018 ? 2022 model year Toyota vehicles equipped with a Premium Audio with Dynamic Navigation System require a Special Service Tool (SST) USB flash drive to update the map, points of interest, and system software. Read More »
TSB: Some 2018 ? 2022 model year Toyota vehicles equipped with a Premium Audio with Dynamic Navigation System, require a Special Service Tool (SST) USB flash drive to update the map, points of interest, and system software. Read More »
TSB: Some 2018 ? 2020 model year Toyota vehicles equipped with a Premium Audio with Dynamic Navigation System require a Special Service Tool (SST) USB flash drive to update the map, points of interest, and system software. Read More »
TT: To assist with the early detection and early resolution of audio related concerns, it may be requested as part of the remanufactured head unit return to recover MMR data from the head unit. Read More »
TSB: Some 2018 ? 2020 model year Toyota vehicles equipped with a Premium Audio with Dynamic Navigation System require a Special Service Tool (SST) USB flash drive to update the map, points of interest, and system software. Read More »
TSB: Some 2018 ? 2020 model year Toyota vehicles equipped with a Premium Audio with Dynamic Navigation System require a Special Service Tool (SST) USB flash drive to update the map, points of interest, and system software. Read More »
TT: Safety Connect is a vehicle option which requires a subscription fee for the system to be active after the initial trial period. Once the subscription has expired the DCM (Telematics Transceiver) will be in an inactive state. Read More »
TSB: Some 2019 model year RAV4 and RAV4 Hybrid and 2018 ? 2020 model year Sienna vehicles equipped with Audio Plus (version 1010) or Premium Audio (version 1010) or earlier may exhibit one or more of the following conditions: ?Toyota ... Read More »
TSB: Some 2005 ? 2022 model year Toyota vehicles that have undergone water intrusion may exhibit a condition in which a musty smell is present. Follow the procedures in this bulletin to remediate the odor and address this condition. Read More »
POL: This consolidated Tire Warranty Guide contains the complete warranty terms for all brands of ground and spare tires currently in use by Toyota. Read More »
TSB: This Service Bulletin provides a procedure to properly perform the Techstream ?Control the Injection Mode? active test in some 2016 ? 2021 model year Toyota vehicles equipped with an FKS engine. Read More »
TT: Safety Connect is a vehicle option which requires a subscription fee for the system to be active after the initial trial period. Once the subscription has expired the DCM (Telematics Transceiver) will be in an inactive state. Read More »
TSB: REVISION NOTICE November 11, 2019 Rev1: ? The title of this bulletin has been updated to include ?Lock.? Any previous printed versions of this bulletin should be discarded. Read More »
TT: The blind spot monitor (BSM) sensor angle inspection is used to confirm that the BSM sensor is within the specified angle before performing axis beam adjustment. Read More »
TSB: REVISION NOTICE February 7, 2019 Rev2: * Applicability has been updated to include 2010 - 2014 model year Matrix, 2017 - 2019 model year C-HR, 2019 model year Corolla Hatchback, and 2018 - 2019 model year Toyota vehicles. Read More »
TSB: Some 2019 ? 2020 model year RAV4 Adventure and Limited grade AWD vehicles may exhibit an abnormal buzz/groan noise from the front transfer case at 20 ? 30 mph when accelerating from a stop and/or at 20 ? 13 mph on deceleration after ... Read More »
TSB: Some 2019 model year Avalon and Avalon Hybrid vehicles equipped with Entune? Audio Plus (version 1002) or Entune? Premium Audio (version 1002) or earlier may exhibit one or more of the following conditions: ?Incorrect GPS date and ... Read More »
DP: Toyota has received customer reports of certain 2019-2020 model year RAV4 HV vehicle fuel gauges displaying less than full and/or total fuel dispensed is less than expected, when the fuel nozzle automatically clicks off. Read More »
DL: This Customer Support Program provides coverage for a condition involving the front transfer case electro-magnetic clutch in certain 2019 ? 2020 model year RAV4 Adventure and Limited grade AWD vehicles. Read More »
DP: This Customer Support Program provides coverage for a condition involving the front transfer case electro-magnetic clutch in certain 2019 ? 2020 model year RAV4 Adventure and Limited grade AWD vehicles. Read More »
RE: This Customer Support Program provides coverage for a condition involving the front transfer case electro-magnetic clutch in certain 2019 ? 2020 model year RAV4 Adventure and Limited grade AWD vehicles. Read More »
TT: Some customers may encounter Bluetooth? connectivity concerns such as: ?Difficulty to pair the phone. ?Intermittent Bluetooth? failure to connect to the vehicle when first turning on the vehicle. Read More »
TSB Some 2019 ? 2020 model year RAV4 vehicles may exhibit an AWD Warning Light ON condition with Diagnostic Trouble Code (DTC) C13F800 (4WD/AWD Rear Disconnect System Performance) present. Read More »
TT: Any HVAC repair requiring reassembly of the quick connect fitting between the suction hose sub-assembly and the suction pipe sub-assembly located at the top right of the engine compartment. Read More »
TT: Some customers may experience an abnormal steering sensation (?pulling?, ?drifting?). Condition may be more pronounced after a cold soak. Read More »
TSB: Some 2019 ? 2020 model year RAV4 and RAV4 Hybrid vehicles may exhibit a vibration/shaking of the image shown in the outer rear view mirror(s) while driving. Read More »
TSB: Some 2019 model year RAV4 Hybrid vehicles may exhibit a flutter/rattle noise during vehicle operation from the HV battery cooling fan. A new HV battery intake duct has been developed. Read More »
TSB: Some 2019 model year RAV4 Adventure and Limited grade AWD vehicles may exhibit an abnormal buzz/groan noise from the front transfer case at 20 ? 30 mph when accelerating from a stop and/or at 20 ? 13 mph on deceleration after driving ... Read More »
TSB: REVISION NOTICE December 23, 2019 Rev2: ? The Production Change Information section has been updated. November 20, 2019 Rev1: ? The Introduction, Production Change Information, and Repair Procedure sections have been updated. Read More »
TSB: SUPERSESSION NOTICE The information contained in this bulletin supersedes Service Bulletin No. T-SB-0033-14. ? Applicability has been updated to include 2019 model year Toyota vehicles. Service Bulletin No. Read More »
TSB: Some 2018 ? 2019 model year Toyota vehicles equipped with the Entune? 3.0 Premium Audio Navigation System require a Special Service Tool (SST) USB flash drive to update the map, points of interest, and system software. Read More »
TT: The blind spot monitor (BSM) sensor angle inspection is used to confirm that the BSM sensor is within the specified angle before performing axis beam adjustment. Read More »
TSB: Some 2006 ? 2022 model year Toyota vehicles in particular geographic areas may exhibit a condition where the HVAC evaporator drain hose has become obstructed with an insect nest. Read More »
TT: Any HVAC repair requiring reassembly of the quick connect fitting between the suction hose sub-assembly and the suction pipe sub-assembly located at the top right of the engine compartment. Read More »
TT: Any HVAC repair requiring reassembly of the quick connect fitting between the suction hose sub-assembly and the suction pipe sub-assembly located at the top right of the engine compartment. Read More »
TSB: SUPERSESSION NOTICE The information contained in this bulletin supersedes Service Bulletin No. T-SB-0033-14. ? Applicability has been updated to include 2019 model year Toyota vehicles. Service Bulletin No. Read More »
TSB: Some 2018 ? 2022 model year Toyota vehicles equipped with a Premium Audio with Dynamic Navigation System require a Special Service Tool (SST) USB flash drive to update the map, points of interest, and system software. Read More »
TT: A very small percentage of customers experience operational difficulties with some telematics features which they cannot resolve on their own. Read More »
DL: Although the roof rails are covered by Toyota?s New Vehicle Limited Warranty for 3 years or 36,000 miles (whichever comes first), we at Toyota care about the customers? ownership experience. Read More »
RL: The specific condition covered by this program is roof rail water leaks from the roof rail mounting clips due to deterioration of the seal of the roof rail clips. Read More »
TSB: Some 2019 ? 2021 model year RAV4 and RAV4 Hybrid and 2021 model year RAV4 Prime vehicles may exhibit water entry from one or more roof rail garnish clips. Follow the procedures in this bulletin to address this condition. Read More »
