Technical Service Bulletins (TSBs) for the 2007 Camry Hybrid are official communications between Toyota & their dealerships that describe processes for troubleshooting or fixing certain common problems.
All vehicle manufacturers are required by U.S. law to make their TSBs available to the public.
TOYOTA SERVICE CAMPAIGN: SEE DOCUMENT SEARCH BUTTON FOR OWNER LETTER. DUE TO INSUFFICIENT ADHESION BETWEEN THE PERMANENT MAGNETS AND THE ROTOR OF THE EPS, THE MOTOR MAY GRADUALLY LOSE TORQUE WHEN THE WHEEL IS TURNED TO COMPLETE LEFT OR ... Read More »
TOYOTA SERVICE CAMPAIGN: SEE DOCUMENT SEARCH BUTTON FOR OWNER LETTER. DUE TO INSUFFICIENT ADHESION BETWEEN THE PERMANENT MAGNETS AND THE ROTOR OF THE EPS, THE MOTOR MAY GRADUALLY LOSE TORQUE WHEN THE WHEEL IS TURNED TO COMPLETE LEFT OR ... Read More »
TOYOTA: VEHICLES MAY EXHIBIT A CONDITION WITH MULTIPLE WARNING LIGHTS ILLUMINATED, VEHICLE NOT SHIFTING FROM PARK TO DRIVE, AND OTHER ACCESSORIES BECOMING INOPERATIVE AFTER THE VEHICLE HAS COLD SOAKED IN SUB FREEZING (BELOW 14 F[-10 C]) ... Read More »
TOYOTA: FRONT SUSPENSION- SOME 2007-2008 MODEL YEAR AVALON, CAMRY, CAMRY HV, AND SOLARA VEHICLES MAY EXHIBIT A STEERING WHEEL FLUTTER AND/OR A BODY VIBRATION (FLOOR OR SEATS) AT HIGHWAY SPEEDS (APPROX. 65-75 MPH [105-121 KM/H]). Read More »
TOYOTA: SEE DOCUMENT SEARCH BUTTON FOR OWNER LETTER. DUE TO AN INTERNAL MALFUNCTION OF BRAKE ACTUATOR ASSEMBLY, THE BRAKE SYSTEM WARNING LIGHT WILL ILLUMINATE AND WARRANTY COVERAGE HAS BEEN EXTENDED. MODEL 2007-2011 CAMRY HYBRID. Read More »
SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP:ABS WARNING LIGHT
TOYOTA: SEE DOCUMENT SEARCH BUTTON FOR OWNER LETTER. DUE TO SMALL INTERNAL BRAKE FLUID LEAKAGE, IN BRAKE ACTUATOR, THE ABS AND/OR TRAC WARNING LIGHT, FOR BRAKES, ARE ON AND CHECK VSC IS DISPLAYING A MESSAGE. MODEL 2007-2011 CAMRY. Read More »
TOYOTA: SEE DOCUMENT SEARCH BUTTON FOR OWNER LETTER. DUE TO LOW FLUID LEVEL IN ONE OF RESERVOIR CHAMBERS, BRAKE WARNING LAMP WILL ILLUMINATE, FROM FILTER THAT IS CONNECTED BY TWO SEPARATE BRAKE RESERVOIR CHAMBERS, TO BECOME CLOGGED. Read More »
TOYOTA: CERTAIN VEHICLES EXPERIENCING A CONDITION WHERE THE ABS, BRAKE AND/OR TRAC WARNING LIGHT(S) ARE ON AND WOULD DISPLAY A MESSAGE, DUE TO BRAKE FLUID LEAKING INSIDE BRAKE ACTUATOR. MODEL 2007-2011 CAMRY HV. Read More »
TOYOTA: SEE DOCUMENT SEARCH BUTTON FOR OWNER LETTER. DUE TO SMALL INTERNAL BRAKE FLUID LEAKAGE, IN BRAKE ACTUATOR, THE ABS AND/OR TRAC WARNING LIGHT, FOR BRAKES, ARE ON AND CHECK VSC IS DISPLAYING A MESSAGE. MODEL 2007-2011 CAMRY. Read More »
TOYOTA: CERTAIN VEHICLES EXPERIENCING A CONDITION WHERE THE ABS, BRAKE AND/OR TRAC WARNING LIGHT(S) ARE ON AND WOULD DISPLAY A MESSAGE, DUE TO BRAKE FLUID LEAKING INSIDE BRAKE ACTUATOR. MODEL 2007-2011 CAMRY HV. Read More »
TSB: SOME 2007 - 2011 MODEL YEAR CAMRY HV VEHICLES EQUIPPED WITH 2AZ-FXE ENGINES MAY EXHIBIT A LACK OF ACCELERATION, POTENTIAL ROUGH ENGINE IDLE, AND POSSIBLE ENGINE STALL CONDITION WHILE THE VEHICLE IS STOPPED. Read More »
"WPB: THE ENGINE IS COVERED UNDER THE TOYOTA NEW VEHICLE LIMITED WARRANTY FOR 5 YEARS FROM THE DATE OF FIRST USE OR 60,000 MILES (WHICHEVER OCCURS FIRST). Read More »
"WPB: THE ENGINE IS COVERED UNDER THE TOYOTA NEW VEHICLE LIMITED WARRANTY FOR 5 YEARS FROM THE DATE OF FIRST USE OR 60,000 MILES (WHICHEVER OCCURS FIRST). Read More »
DD: IN LIMITED CASES VEHICLES BEING SERVICED FOR ZE7 WILL REQUIRE A REPLACEMENT SHORT BLOCK. DEALERS WILL NEED TO INSTALL THE DOWEL PINS BETWEEN THE SHORT BLOCK AND LOWER CRANKCASE WHEN PERFORMING THIS REPAIR. Read More »
"TT: BASED ON CURRENT PART ORDER ALLOCATION, SOME PISTON TYPES HAVE BEEN INCORRECTLY IDENTIFIED WHILE UNDERGOING THE ZE7 2AZ OIL CONSUMPTION REPAIR PROCEDURE. Read More »
"TSB: SOME 2006 ? 2013 MODEL YEAR VEHICLES EQUIPPED WITH THE 2AZ ENGINE MAY EXHIBIT ENGINE OIL CONSUMPTION. THE PISTON ASSEMBLY HAS BEEN CHANGED TO MINIMIZE OIL CONSUMPTION. USE THE FOLLOWING REPAIR PROCEDURE TO ADDRESS THIS CONDITION. Read More »
TT: THERE HAS BEEN SOME CONCERN WITH 3 PIECE RING INSTALLATIONS FOR 2AZ-FE AND 2AZ-FXE ENGINES. THIS TECH TIP CONTAINS THE ACCEPTED INSTALLATION METHOD REQUIRED FOR TOYOTA VEHICLES. Read More »
TT: THERE HAS BEEN SOME CONCERN WITH 3 PIECE RING INSTALLATIONS FOR 2AZ-FE AND 2AZ-FXE ENGINES. THIS TECH TIP CONTAINS THE ACCEPTED INSTALLATION METHOD REQUIRED FOR TOYOTA VEHICLES. Read More »
TT: BASED ON CURRENT PART ORDER ALLOCATION, SOME PISTON TYPES HAVE BEEN INCORRECTLY IDENTIFIED WHILE UNDERGOING THE ZE7 2AZ OIL CONSUMPTION REPAIR PROCEDURE. Read More »
WPB: TOYOTA HAS RECEIVED SOME REPORTS WHERE VEHICLES MAY EXHIBIT EXCESSIVE ENGINE OIL CONSUMPTION. TOYOTA IS NOW ANNOUNCING THE PART REPLACEMENT PHASE OF WARRANTY ENHANCEMENT PROGRAM ZE7 FOR VEHICLES EXHIBITING EXCESSIVE ENGINE OIL ... Read More »
"TSB: FLASH REPROGRAMMING ALLOWS THE ECU SOFTWARE TO BE UPDATED WITHOUT REPLACING THE ECU. FLASH CALIBRATION UPDATES FOR SPECIFIC VEHICLE MODELS/ECUS ARE RELEASED AS FIELD-FIX PROCEDURES DESCRIBED IN INDIVIDUAL SERVICE BULLETINS. Read More »
TOYOTA 2006-2011: THIS TSB CONTAINS AN OWNER NOTIFICATION LETTER. SELECT DOCUMENT SEARCH BUTTON BELOW. INFORMATION REGARDING ENGINE OIL CONSUMPTION ON CERTAIN CAMRY, SOLARA, COROLLA, MATRIX, SCION AND RAV4 VEHICLES. Read More »
TOYOTA: INTAKE CAMSHAFT GEAR ASSEMBLY WAS IMPROVED TO PREVENT CONDITION OF ENGINE EXHIBITING INTERMITTENT MIL ON. MODEL 2006-2012 CAMRY, CAMRY HV, COROLLA, MATRIX, RAV4, SOLARA. *PE Read More »
TOYOTA: 2AZ-FE & 2AZ-FXE THROTTLE BODY. ENGINE CONTROL. PROVIDE UPDATED THROTTLE BODY PART NUMBER INFORMATION FOR CERTAIN VEHICLES. THE DRAIN PIPE HAS BEEN ELIMINATED ON THROTTLE BODY SERVICE PARTS. Read More »
TOYOTA: SOME VEHICLES MAY EXHIBIT A M.I.L. ON CONDITION WITH DIAGNOSTIC TROUBLE CODES (DTC) P0351-P0354 (IGNITION COIL PRIMARY/SECONDARY CIRCUIT) STORED IN THE ENGINE CONTROL MODULE/ECM (SAE TERM: POWERTRAIN CONTROL MODULE/PCM). Read More »
TOYOTA: DUE TO DEBRIS OR DUST BUILD UP IN HV BATTERY COOLING FAN, THE MALFUNCTION INDICATOR LAMP (MIL) WILL BE ON WITH DIAGNOSTIC TROUBLE CODE (DTC) P0A80 OR P0A7F. MODEL 2007-2011 CAMRY HV. Read More »
ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL
TOYOTA: METER, GAUGE, DISPLAY. SOME VEHICLES MAY EXHIBIT A MIL ON CONDITION WITH DIAGNOSTIC TROUBLE CODE (DTC) P1423, OR A FUEL CAP BINDING UPON INSTALLATION OR REMOVAL. *PE UPDATED 5/16/11. Read More »
POWER TRAIN:AUTOMATIC TRANSMISSION:CONTROL MODULE (TCM/PCM/TECM)
TOYOTA: SOME VEHICLES MAY EXHIBIT A M.I.L. ON CONDITION WITH DIAGNOSTIC TROUBLE CODES (DTC) P0351-P0354 (IGNITION COIL PRIMARY/SECONDARY CIRCUIT) STORED IN THE ENGINE CONTROL MODULE/ECM (SAE TERM: POWERTRAIN CONTROL MODULE/PCM). Read More »
POWER TRAIN:AUTOMATIC TRANSMISSION:TORQUE CONVERTER
TT: HV BATTERIES HAVE LIQUID FILLED CELL MODULES, TO PREVENT LEAKAGE FROM CELLS, IT IS VERY IMPORTANT TO CONFIRM THE PROPER ORIENTATION MARK OF THE DRC. Read More »
TSB: SOME 2007 - 2011 MODEL YEAR CAMRY HV VEHICLES EQUIPPED WITH 2AZ-FXE ENGINES MAY EXHIBIT A LACK OF ACCELERATION, POTENTIAL ROUGH ENGINE IDLE, AND POSSIBLE ENGINE STALL CONDITION WHILE THE VEHICLE IS STOPPED. Read More »
TSB: THIS BULLETIN INCLUDES BASIC PROCEDURES FOR PERFORMING A RESCUE CHARGE ON NI-MH HIGH VOLTAGE (HV) BATTERIES. THIS BULLETIN SHOULD BE USED IN CONJUNCTION WITH THE REPAIR MANUAL WHILE PERFORMING RESCUE CHARGE. Read More »
"TSB: FLASH REPROGRAMMING ALLOWS THE ECU SOFTWARE TO BE UPDATED WITHOUT REPLACING THE ECU. FLASH CALIBRATION UPDATES FOR SPECIFIC VEHICLE MODELS/ECUS ARE RELEASED AS FIELD-FIX PROCEDURES DESCRIBED IN INDIVIDUAL SERVICE BULLETINS. Read More »
TOYOTA: THE INSTRUMENT PANEL WILL DISPLAY MALFUNCTION INDICATOR LAMP (MIL) ON AND THE ILLUMINATION OF THE BRAKE WARNING LIGHTS (ABS/VSC), WITH DIAGNOSTIC TROUBLE CODE (DTC) C1247). MODEL 2007-2011 CAMRY HV. Read More »
TSB: THIS BULLETIN INCLUDES BASIC PROCEDURES FOR PERFORMING A RESCUE CHARGE ON NI-MH HIGH VOLTAGE (HV) BATTERIES. THIS BULLETIN SHOULD BE USED IN CONJUNCTION WITH THE REPAIR MANUAL WHILE PERFORMING RESCUE CHARGE. Read More »
TT: A VEHICLE MAY ARRIVE TO THE DEALER WITH A MIL ?ON? CONDITION AND P0A80 STORED IN THE MEMORY. SOME CASES HAVE BEEN IDENTIFIED WITH INTERNAL MODIFICATION DONE TO THE HV BATTERY. MODIFIED OR ALTERED PARTS ARE NOT COVERED UNDER WARRANTY. Read More »
TOYOTA: DUE TO DEBRIS OR DUST BUILD UP IN HV BATTERY COOLING FAN, THE MALFUNCTION INDICATOR LAMP (MIL) WILL BE ON WITH DIAGNOSTIC TROUBLE CODE (DTC) P0A80 OR P0A7F. MODEL 2007-2011 CAMRY HV. Read More »
TOYOTA: HYBRID/BATTERY CONTROL SYSTEM. SOME MODEL YEAR TSUTSUMI BUILT VEHICLES MAY EXHIBIT A MIL ON CONDITION WITH DTC P0A84 (HYBRID BATTERY PACK COOLING FAN 1). Read More »
TOYOTA: VEHICLES MAY EXHIBIT A CONDITION WITH MULTIPLE WARNING LIGHTS ILLUMINATED, VEHICLE NOT SHIFTING FROM PARK TO DRIVE, AND OTHER ACCESSORIES BECOMING INOPERATIVE AFTER THE VEHICLE HAS COLD SOAKED IN SUB FREEZING (BELOW 14 F[-10 C]) ... Read More »
TOYOTA: VEHICLES MAY EXHIBIT A CONDITION WITH MULTIPLE WARNING LIGHTS ILLUMINATED, VEHICLE NOT SHIFTING FROM PARK TO DRIVE, AND OTHER ACCESSORIES BECOMING INOPERATIVE AFTER THE VEHICLE HAS COLD SOAKED IN SUB FREEZING (BELOW 14 F[-10 C]) ... Read More »
TOYOTA: DURING THE HUMIDITY OR HEAT, THE DASHBOARD WOULD BE EITHER STICKY, MELTING, OR CRACKED AND A PART REPLACEMENT HAS PHASED INTO PROGRAM. Read More »
TOYOTA 2003-2008: INFORMATION REGARDING WARRANTY EXTENSION FOR CRACKED OR STICKY/ MELTING DUE TO HEAT AND HUMIDITY FOR CERTAIN VEHICLES. MY RUNNER, AVALON, CAMRY& HYBRID, SIENNA, SOLARA. *LJ Read More »
TOYOTA: VEHICLES MAY EXHIBIT A CONDITION WITH MULTIPLE WARNING LIGHTS ILLUMINATED, VEHICLE NOT SHIFTING FROM PARK TO DRIVE, AND OTHER ACCESSORIES BECOMING INOPERATIVE AFTER THE VEHICLE HAS COLD SOAKED IN SUB FREEZING (BELOW 14 F[-10 C]) ... Read More »
TOYOTA: HYBRID/BATTERY CONTROL SYSTEM. SOME MODEL YEAR TSUTSUMI BUILT VEHICLES MAY EXHIBIT A MIL ON CONDITION WITH DTC P0A84 (HYBRID BATTERY PACK COOLING FAN 1). Read More »
TOYOTA: VEHICLES WOULD HAVE WATER LEAK CONDITION IN THE HEADLINER. THIS CAUSES THE FOOT WELL TO BE WET. IT MAY RESULT FROM MOON ROOF DRAIN HOSES ARE LOOSE OR DISCONNECTED FROM DRAIN PAN NIPPLE. Read More »
"WPB: TOYOTA HAS RECEIVED REPORTS WHERE SOME VEHICLES MAY EXHIBIT CRACKED AND/OR STICKY/MELTING DASHBOARDS AS A RESULT OF HEAT OR HUMIDITY. Read More »
TOYOTA: ACCELERATOR PEDAL SENSOR ASSEMBLY INFORMATION REGARDING THE INSPECTION, REMOVAL, AND INSTALLATION, IF LUBRICATION OR OIL, IS APPLIED. *PE Read More »
TT: HV BATTERIES HAVE LIQUID FILLED CELL MODULES, TO PREVENT LEAKAGE FROM CELLS, IT IS VERY IMPORTANT TO CONFIRM THE PROPER ORIENTATION MARK OF THE DRC. Read More »
DL: IN OUR CONTINUING EFFORTS TO ENSURE THE BEST IN CUSTOMER SATISFACTION, TOYOTA HAS ANNOUNCED A WARRANTY ENHANCEMENT PROGRAM (THE ?PROGRAM?). Read More »
DD: IN MID-DECEMBER 2014, TOYOTA ANNOUNCED THE REIMBURSEMENT PHASE OF THIS PROGRAM. SINCE PRIOR TO THAT ANNOUNCEMENT, TOYOTA HAS BEEN DILIGENTLY MAKING PARTS PREPARATIONS FOR THE PARTS REPLACEMENT PHASE OF THIS PROGRAM. Read More »
"WPB: TOYOTA HAS RECEIVED REPORTS WHERE SOME VEHICLES MAY EXHIBIT CRACKED AND/OR STICKY/MELTING DASHBOARDS AS A RESULT OF HEAT OR HUMIDITY. Read More »
"WPB: THE ENGINE IS COVERED UNDER THE TOYOTA NEW VEHICLE LIMITED WARRANTY FOR 5 YEARS FROM THE DATE OF FIRST USE OR 60,000 MILES (WHICHEVER OCCURS FIRST). Read More »
"WPB: THE ENGINE IS COVERED UNDER THE TOYOTA NEW VEHICLE LIMITED WARRANTY FOR 5 YEARS FROM THE DATE OF FIRST USE OR 60,000 MILES (WHICHEVER OCCURS FIRST). Read More »
DD: IN LIMITED CASES VEHICLES BEING SERVICED FOR ZE7 WILL REQUIRE A REPLACEMENT SHORT BLOCK. DEALERS WILL NEED TO INSTALL THE DOWEL PINS BETWEEN THE SHORT BLOCK AND LOWER CRANKCASE WHEN PERFORMING THIS REPAIR. Read More »
TT: CUSTOMERS MAY EXPERIENCE CONNECTIVITY ISSUES WHEN THE FOLLOWING CONDITIONS ARE MET: THE CUSTOMER'S IPHONE IS OPERATING ON IOS9 FIRMWARE. THE CUSTOMER'S IPHONE IS CONNECTED TO THE VEHICLE VIA BLUETOOTH. Read More »
"WPB: TOYOTA HAS RECEIVED REPORTS WHERE SOME VEHICLES MAY EXHIBIT CRACKED AND/OR STICKY/MELTING DASHBOARDS AS A RESULT OF HEAT OR HUMIDITY. Read More »
TOYOTA: SEE DOCUMENT RESEARCH BUTTON FOR OWNER LETTER. IN SOME VEHICLES, THE SUN VISORS WOULD SLOWLY ROTATE DOWNWARD AND SOME TIMES WOULD BECOME DETACHED. MODELS 2007-11 CAMRY & CAMRY HYBRIDS. Read More »
TT: CUSTOMERS MAY EXPERIENCE CONNECTIVITY ISSUES WHEN THE FOLLOWING CONDITIONS ARE MET: THE CUSTOMER'S IPHONE IS OPERATING ON IOS9 FIRMWARE. THE CUSTOMER'S IPHONE IS CONNECTED TO THE VEHICLE VIA BLUETOOTH. Read More »
WARRANTY POLICY BULLETIN (POL14-12): ADDED THE SHORT BLOCK RELEASE AUTHORIZATION FLOW CHART. TOYOTA HAS RECEIVED SOME REPORTS WHERE VEHICLES MAY EXHIBIT EXCESSIVE ENGINE OIL CONSUMPTION. Read More »
TOYOTA: SEE DOCUMENT SEARCH BUTTON FOR OWNER LETTER. DUE TO AN INTERNAL MALFUNCTION OF BRAKE ACTUATOR ASSEMBLY, THE BRAKE SYSTEM WARNING LIGHT WILL ILLUMINATE AND WARRANTY COVERAGE HAS BEEN EXTENDED. MODEL 2007-2011 CAMRY HYBRID. Read More »
TOYOTA: VEHICLE INTERIOR: INTERIOR PANELS/TRIM TO IMPROVE SERVICEABILITY OF THE FLOOR CARPET GROMMET (FLOOR CLAMP RETAINER), A NEW SERVICE PART HAS BEEN DEVELOPED WHICH ALLOWS THE FLOOR CARPET GROMMET TO BE REPLACED SEPARATELY FROM THE ... Read More »
TOYOTA: A CONDITION MAY EXHIBIT IN SOME VEHICLES WHERE DUST OR POWDER IS VISIBLE FROM HVAC VENTS. A PROCEDURE FOR INSTALLATION, BLOWER MOTOR CLEANING, EVAPORATOR REMOVAL AND HVAC SYSTEM CLEANING HAS BEEN DESIGNED FOR THIS CONDITION. Read More »
