Technical Service Bulletins (TSBs) for the 2022 Outlander PHEV are official communications between Mitsubishi & their dealerships that describe processes for troubleshooting or fixing certain common problems.
All vehicle manufacturers are required by U.S. law to make their TSBs available to the public.
Service Manual Revision - This Technical Service Bulletin provides the addition of the Steering Wheel Switch Light Lens disassembly and assembly procedure in the applicable Service Manual sections. Read More »
This Revised Technical Information Notice provides dealers with the requirements needed to be entered into the Photo Required Condition & Pre-Approval Center (PRC) for a vehicle pulling/drifting and/or with steering wheel off-center ... Read More »
This is a Revised Technical Information Notice advising dealers of the instructions to follow when performing a wheel alignment check and adjustment on an affected vehicle with a customer concern of pulling/drifting and/or steering wheel ... Read More »
This Technical Information Notice was sent to dealers informing them of the photo requirement for claims when performing a wheel alignment check and adjustment on an affected vehicle with a customer concern of pulling/drifting and/or ... Read More »
This Technical Service Bulletin was sent to dealers informing them a shock absorber oil leak may result in replacement of absorbers unnecessarily when trace amounts of oil are noted to have adhered to the shock absorber. Read More »
This Technical Service Bulletin was sent to dealers informing them a shock absorber oil leak may result in replacement of absorbers unnecessarily when trace amounts of oil are noted to have adhered to the shock absorber. Read More »
This Technical Service Bulletin was sent to dealers directing them upon customer complaint basis and after diagnosis, to replace the ignition coils of all cylinders with countermeasure parts when customers report a MIL illumination and a ... Read More »
This Technical Service Bulletin supersedes TSB-22-16-001REV ("MIL illumination with DTC P030X and loss of power due to Fail Safe Mode") issued August 2023, to update the Affected Vehicle years and provide VIN cut-off information. Read More »
This Revised Technical Service Bulletin was sent to dealers directing them upon customer complaint basis and after diagnosis, to replace the ignition coils of all cylinders with countermeasure parts when customers report a MIL ... Read More »
This Technical Service Bulletin was sent to dealers directing them upon customer complaint basis and after diagnosis, to replace the ignition coils of all cylinders with countermeasure parts when customers report a MIL illumination and a ... Read More »
This is a Technical Information Notice informing dealers that new scan tool software will be available for download on the evening of Monday, September 18, 2023. Read More »
This Technical Service Bulletin provides service manual corrections to the precautions for the installation of On-Vehicle Radio Transmission Equipment. Read More »
This Technical Service Bulletin was sent to dealers directing them upon customer complaint basis and after diagnosis, to replace the ignition coils of all cylinders with countermeasure parts when customers report a MIL illumination and a ... Read More »
This Technical Information Notice was sent to dealers informing them Owner Manuals (OM) are now available electronically beginning with Model Year 2015. Read More »
This Technical Service Bulletin was sent to dealers directing them upon customer complaint basis and after diagnosis, to replace the ignition coils of all cylinders with countermeasure parts when customers report a MIL illumination and a ... Read More »
This Technical Service Bulletin was sent to dealers to explain the difference between normal dew condensation, which is a natural phenomenon, and water penetration caused by improper sealing or a defective/broken part. Read More »
This TSB provides instructions on how to remedy noise heard from the HVAC system (heater, air conditioner, ventilation vents) when the blower motor is turned on. Read More »
This TSB provides instructions on how to remedy noise heard from the HVAC system (heater, air conditioner, ventilation vents) when the blower motor is turned on. Read More »
This Technical Service Bulletin describes the procedure to prevent ice build up in A-pillar area causing the inability to open front door(s). Read More »
This is a Revised Technical Information Notice advising dealers of the instructions to follow when performing a wheel alignment check and adjustment on an affected vehicle with a customer concern of pulling/drifting and/or steering wheel ... Read More »
This is a Technical Information Notice informing dealers of actions they should take to ensure Customer Satisfaction with New Vehicle Delivery. Read More »
This Technical Service Bulletin instructs dealers to apply Nonwoven Fabric Tape between the Seat Back and Urethane Pad when customers report a condition where an abnormal rubbing noise is heard from the Seat Back when a driver and/or ... Read More »
This Technical Service Bulletin provides instructions to reprogram the SONAR CU with the countermeasure software to correct the check engine light from illuminating while driving at low speed or upon deceleration before stopping. Read More »
This is a Technical Information Notice informing dealers of actions they should take to ensure Customer Satisfaction with New Vehicle Delivery. Read More »
Service Manual Revision - This Technical Service Bulletin provides the addition of the Steering Wheel Switch Light Lens disassembly and assembly procedure in the applicable Service Manual sections. Read More »
This Technical Service Bulletin instructs dealers to apply Nonwoven Fabric Tape between the Seat Back and Urethane Pad when customers report a condition where an abnormal rubbing noise is heard from the Seat Back when a driver and/or ... Read More »
This Technical Information Notice was sent to dealers informing them certified EV dealers MUST have a set of electrically insulated gloves, MB992648-01. Read More »
This Technical Service Bulletin was sent to dealers informing them of important new model service information and features for the 2022 Outlander PHEV (U.S. models only). Read More »
This Technical Service Bulletin was sent to dealers informing them of important new model service information and features for the 2022 Outlander PHEV (U.S. models only). Read More »
This letter was sent to dealers informing them of an upcoming instructor-led course to introduce the all new Advanced Driver Assistance System. Read More »
This is a Dealer Letter sent to dealers informing that Mitsubishi Technical Training has launched the 3rd quarterly technician quiz for 2023. Read More »
This Technical Service Bulletin reviews the regulations that require a label showing the reduction in load carrying capacity be affixed to vehicles when the total net weight of accessories is more than 1. Read More »
This is a Dealer Letter sent to dealers informing that Mitsubishi Technical Training has launched the 2nd quarterly technician quiz for 2023. Read More »
This Technical Information Notice was sent to dealers to inform them Audio Manuals are now available electronically on MDL beginning with Model Year 2020. As new Model Year manuals become available, they too will be added. Read More »
This Technical Information Notice was sent to dealers informing them Owner Manuals (OM) are now available electronically beginning with Model Year 2015. Read More »
This Technical Service Bulletin instructs dealers to apply Nonwoven Fabric Tape between the Seat Back and Urethane Pad when customers report a condition where an abnormal rubbing noise is heard from the Seat Back when a driver and/or ... Read More »
This Technical Information Notice was sent to dealers to inform them Audio Manuals are now available electronically on MDL beginning with Model Year 2020. As new Model Year manuals become available, they too will be added. Read More »
This Technical Service Bulletin was sent to dealers to explain the difference between normal dew condensation, which is a natural phenomenon, and water penetration caused by improper sealing or a defective/broken part. Read More »
