2007 Mercury Mountaineer
22 Technical Service Bulletins (TSBs)
TSB List for the 2007 Mercury Mountaineer
Technical Service Bulletins (TSBs) for the 2007 Mountaineer are official communications between Mercury & their dealerships that describe processes for troubleshooting or fixing certain common problems. All vehicle manufacturers are required by U.S. law to make their TSBs available to the public.
STEERING:COLUMN
-
TSB #062414
LOWER STEERING COLUMN SHAFT POP/CLUNK NOISE. *KB Read More »
SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP
-
TSB #08-2-8
IMPROVED BRAKE PEDAL FEEL AND FIRMNESS. *NJ Read More »
SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP:WHEEL SPEED SENSOR
-
TSB #ASI-44429
FORD/MERCURY: TO PREVENT HARNESS DAMAGE, ON SOME VEHICLES, RESULTING IN CONTACT WITH TIRE OR SUSPENSION COMPONENTS, PROPER ROUTING OF WIRING HARNESS FOR WHEEL SPEED SENSOR IS KEY. 2006-2010 EXPLORER, MOUNTAINEER, EXPLORER SPORT TRAC. Read More »
SERVICE BRAKES, AIR:ANTILOCK:WHEEL SPEED SENSOR
-
TSB #ASI-44429
FORD/MERCURY: TO PREVENT HARNESS DAMAGE, ON SOME VEHICLES, RESULTING IN CONTACT WITH TIRE OR SUSPENSION COMPONENTS, PROPER ROUTING OF WIRING HARNESS FOR WHEEL SPEED SENSOR IS KEY. 2006-2010 EXPLORER, MOUNTAINEER, EXPLORER SPORT TRAC. Read More »
ENGINE (PWS)
-
TSB #TSB-12-7-4
FORD/LINCOLN/MERCURY: IF BATTERY WAS DISCONNECTED OR DEAD, VEHICLES/TRUCKS MAY EXPERIENCE HARD STARTS AND ENGINE IDLE RPM FLUCTUATION AND EXHIBIT DIAGNOSTIC TROUBLE CODES (DTCS) P0505, P0506, P2111 AND P2112. Read More »
ENGINE AND ENGINE COOLING:ENGINE
-
TSB #TSB-08-18-2
FORD/MERCURY/LINCOLN: VEHICLES MAY EXHIBIT ONE OR MORE OF THE FOLLOWING SYMPTOMS: DRIVE AWAY HESITATION, LOSS OF RPM ON DECELERATION, DIFFICULTY STARTING, AND/OR IDLE RPM LESS THAN DESIRED. THE F53 MOTORHOME CHASSIS IS INCLUDED. Read More »
-
TSB #061713
CALIBRATION UPDATE 4.0L - VARIOUS SYMPTOMS - SURGE, HESITATION, TORQUE CONVERTER CYCLING, NO UP SHIFT AFTER FORCED DOWNSHIFT, AND POOR A/C PERFORMANCE. *KB Read More »
FUEL SYSTEM, GASOLINE:DELIVERY:HOSES, LINES/PIPING, AND FITTINGS
-
TSB #07253
FUEL FILL--SLOW OR EARLY SHUT OFF--BUILT BEFORE 11/28/2007. *NJ Read More »
FUEL SYSTEM, OTHER:STORAGE:FUEL GAUGE SYSTEM
-
TSB #06167
MIL ON WITH DTC P0463 OR ERRATIC FUEL GAUGE OPERATION. *KB Read More »
POWER TRAIN:MANUAL TRANSMISSION
-
TSB #SI-20005
FORD/MERCURY: SOME VEHICLES EQUIPPED WITH 6R60 TRANSMISSIONS MAY EXHIBIT VARIOUS TRANSMISSION PERFORMANCE ISSUES. Read More »
POWER TRAIN:AUTOMATIC TRANSMISSION
-
TSB #SI-20005
FORD/MERCURY: SOME VEHICLES EQUIPPED WITH 6R60 TRANSMISSIONS MAY EXHIBIT VARIOUS TRANSMISSION PERFORMANCE ISSUES. Read More »
-
TSB #0728
OVERHEAT INDICATION AND SHIFT QUALITY IMPROVEMENTS - CALIBRATION UPDATE RELEASE - 4.6L 3V WITH 6R60 TRANSMISSION EQUIPPED VEHICLES ONLY. *KB Read More »
-
TSB #061713
CALIBRATION UPDATE 4.0L - VARIOUS SYMPTOMS - SURGE, HESITATION, TORQUE CONVERTER CYCLING, NO UP SHIFT AFTER FORCED DOWNSHIFT, AND POOR A/C PERFORMANCE. *KB Read More »
POWER TRAIN:AUTOMATIC TRANSMISSION:CONTROL MODULE (TCM/PCM/TECM)
-
TSB #TSB-08-18-2
FORD/MERCURY/LINCOLN: VEHICLES MAY EXHIBIT ONE OR MORE OF THE FOLLOWING SYMPTOMS: DRIVE AWAY HESITATION, LOSS OF RPM ON DECELERATION, DIFFICULTY STARTING, AND/OR IDLE RPM LESS THAN DESIRED. THE F53 MOTORHOME CHASSIS IS INCLUDED. Read More »
-
TSB #TSB-08-9-5
FORD/MERCURY: 4.0L/4.6L HARD START/ROUGH RUNNING; AFTER LONG HOT SOAK/DIP IN RPM WHEN COMING TO A STOP; BUILT ON OR BEFORE 4/2/08. MAY EXHIBIT A DIP IN RPM BELOW NORMAL IDLE LEVEL OF 600 RPM ON DECELERATION. Read More »
-
TSB #20144
MULTIPLE VEHICLE LINES - INTERMITTENT PCM, FUEL PUMP, IGN. COIL, A/C, ABS OR FOG LAMP OPERATION. *NJ Read More »
-
TSB #19865
MULTIPLE VEHICLE LINES - INTERMITTENT PCM, FUEL PUMP, IGN, COIL, A/C, ABS OR FOG LAMP OPERATION. *NJ Read More »
POWER TRAIN:AXLE ASSEMBLY:AXLE SHAFT
-
TSB #TSB-08-19-3
FORD: SOME VEHICLES MAY EXHIBIT OIL SEPARATION FROM THE INTERNAL LUBE FOUND IN THE UNITIZED CARTRIDGE SEAL. OIL SEPARATION APPEARS TO BE AND IS OFTEN MISDIAGNOSED, AS AN AXLE LUBE LEAK. *PE Read More »
POWER TRAIN:AXLE ASSEMBLY:AXLE SHAFT:SEAL
-
TSB #TSB-08-19-3
FORD: SOME VEHICLES MAY EXHIBIT OIL SEPARATION FROM THE INTERNAL LUBE FOUND IN THE UNITIZED CARTRIDGE SEAL. OIL SEPARATION APPEARS TO BE AND IS OFTEN MISDIAGNOSED, AS AN AXLE LUBE LEAK. *PE Read More »
ELECTRICAL SYSTEM:WIRING
-
TSB #ASI-44429
FORD/MERCURY: TO PREVENT HARNESS DAMAGE, ON SOME VEHICLES, RESULTING IN CONTACT WITH TIRE OR SUSPENSION COMPONENTS, PROPER ROUTING OF WIRING HARNESS FOR WHEEL SPEED SENSOR IS KEY. 2006-2010 EXPLORER, MOUNTAINEER, EXPLORER SPORT TRAC. Read More »
ELECTRICAL SYSTEM: INSTRUMENT CLUSTER/PANEL
-
TSB #061710
MIL ON WITH P0463 OR ERRATIC FUEL GAUGE OPERATION. *KB Read More »
VISIBILITY:DEFROSTER/DEFOGGER/HVAC SYSTEM:FAN/MOTOR
-
TSB #0782
THUMPING/LOUD FLUTTER - BEHIND DASH IN DEFROST MODE - LACK OF AIRFLOW TO FLOOR - MANUAL A/C. *KB Read More »