Technical Service Bulletins (TSBs) for the 2005 C320 are official communications between Mercedes-Benz & their dealerships that describe processes for troubleshooting or fixing certain common problems.
All vehicle manufacturers are required by U.S. law to make their TSBs available to the public.
MERCEDES: LEAKAGE AT PRESS-FIT SLEEVE OF ABC PULSATION DAMPER. MODELS 215, AND 220. MODEL YEARS NOT GIVEN. *KB UPDATED 12/30/13. *PE UPDATED 12/12/14. *PE Read More »
MERCEDES BENZ (DAIMLER): UNSATISFACTORY BRAKE SERVO ASSISTANCE AFTER A COLD START, PRIMARILY WHEN MANEUVERING. LOW VACUUM IN THE INTAKE MANIFOLD DUE TO WIDE OPEN THROTTLE VALVE. RETROFIT ELECTRIC BRAKE BOOSTER VACUUM PUMP (M56). Read More »
MERCEDES VEHICLE: THE ANTI-LOCK BRAKE SYSTEM (ABS) RETURN FLOW PUMP RUNNING WITHOUT CONTROL WITH CORRESPONDING FAULT CODE C1401, CLEAN AND INSULATED THE CONNECTOR FOR THE RETURN FLOW PUMP RELAY. MODELS 202 AND 208. MODEL YEARS UNKNOWN. Read More »
MERCEDES VEHICLE: THE ANTI-LOCK BRAKE SYSTEM (ABS) RETURN FLOW PUMP RUNNING WITHOUT CONTROL WITH CORRESPONDING FAULT CODE C1401, CLEAN AND INSULATED THE CONNECTOR FOR THE RETURN FLOW PUMP RELAY. MODELS 202 AND 208. MODEL YEARS UNKNOWN. Read More »
ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL:CATALYTIC CONVERTOR
MERCEDES: REPLACING THE LONGITUDINAL MEMBER (LEFT AND RIGHT) BELOW THE MAIN FLOOR PANEL ON ALL MY 204 UP TO 12/31/07. (C300, C350, C300 4-MATIC, C63 AME). *PE Read More »
MERCEDES: THE FUEL LEVEL INDICATED IN THE INSTRUMENT CLUSTER DOES NOT MATCH THE ACTUAL FILL LEVEL. THIS MAY BE CAUSED BY A FAULT IN THE FUEL LEVEL SENSOR FUNCTION CHAIN: HYDRAULIC AND ELECTRICAL LINES AND THEIR CONNECTIONS, REAR SAM OR ... Read More »
MERCEDES: REPLACING THE LONGITUDINAL MEMBER (LEFT AND RIGHT) BELOW THE MAIN FLOOR PANEL ON ALL MY 204 UP TO 12/31/07. (C300, C350, C300 4-MATIC, C63 AME). *PE Read More »
MERCEDES: THE FUEL LEVEL INDICATED IN THE INSTRUMENT CLUSTER DOES NOT MATCH THE ACTUAL FILL LEVEL. THIS MAY BE CAUSED BY A FAULT IN THE FUEL LEVEL SENSOR FUNCTION CHAIN: HYDRAULIC AND ELECTRICAL LINES AND THEIR CONNECTIONS, REAR SAM OR ... Read More »
INSPECT TRANSMISSION PILOT BUSHING AT ELECTROCHYDRAULIC UNIT AND REPLACE IF NECESSARY. THE TRANSMISSION PILOT BUSHING MAY HAVE BEEN INSTALLED ON THE CONTROL UNITS WITH NON-TEMPERED SEALING RINGS WHICH MAY CAUSE A SMALL LEAK TO OCCUR. Read More »
INSPECT TRANSMISSION PILOT BUSHING AT ELECTROCHYDRAULIC UNIT AND REPLACE IF NECESSARY. THE TRANSMISSION PILOT BUSHING MAY HAVE BEEN INSTALLED ON THE CONTROL UNITS WITH NON-TEMPERED SEALING RINGS WHICH MAY CAUSE A SMALL LEAK TO OCCUR. Read More »
MERCEDES: VEHICLE JERKS DURING GEARCHANGE, HARD 1-2 AND 2-3 SHIFTS, TORQUE CONVERTER LOCKUP CLUTCH NOT ENGAGEABLE. MODELS 212, 216, 218, 221, 251, AND 164. MODEL YEARS NOT GIVEN. *KB UPDATED 10/11/12. Read More »
MERCEDES BENZ: MODELS 203, 209, 211, 219,230, AND 463; MODEL YEARS 2005-2007. REPLACE PILOT BUSHING AT ELECTROHYDRAULIC UNIT. DAIMLER AG HAS DETERMINED THAT ON AFFECTED VEHICLES THE TRANSMISSION PILOT BUSHING MAY LEAK. Read More »
MERCEDES: REPLACE TRANSFER CASE ON AFFECTED VEHICLES OPTIMIZED TRANSFER CASES WILL REDUCE VIBRATIONS WHEN CORNERING OR WHEN PARKING. MODELS 203, 211, 220. *PE Read More »
DAIMLER/XENTRY: FUEL LEVEL INDICATOR AND RADIO FREQUENCY CENTRAL LOCKING INOPERATIVE, INSTRUMENT CLUSTER REPORTS TURN SIGNALS INOPERATIVE, DIAGNOSIS OF REAR SAM NOT POSSIBLE. CONTROL MODULES. MODELS C CLASS, MODEL SERIES 204. Read More »
MERCEDES VEHICLE: THE SRS INDICATOR LAMP IS ILLUMINATED AND CODE B1058 AND B2DBO ARE STORED, REPLACE THE SRS CONTROL UNIT. MODELS 203 AND MODEL 209. MODEL YEARS UNKNOWN. *PE Read More »
MERCEDES: CAMSHAFT ADJUSTMENT SOLENOID MAY LEAK OIL DUE TO SETTLING PROPERTIES OF SEAL AND THE ENGINE WIRING HARNESS WILL BE RETROFITTED WITH FOUR ADAPTER HARNESSES AS A PRECAUTIONARY MEASURE. Read More »
MERCEDES BENZ SERVICE CAMPAIGN: SEE DOCUMENT SEARCH BUTTON FOR OWNER LETTER. SOFTWARE CALIBRATION NUMBER (SCN) CODING; ENGINE CONTROL MODULE. Read More »
MERCEDES VEHICLES: THE XENON OR BI-XENON HEADLAMP NOT FUNCTIONING. A FUNCTION DESCRIPTION CAN BE FOUND IN WIS DOCUMENT GF8S.10-P-20010 (203), GF82.10-P-0003Q (209); GF82.10-P-3002R (230). MODEL YEARS UKNOWN. Read More »
MERCEDES: AIRBAG DURABILITY AND RELIABILITY. AIR BAG SRS CONTROL MODULE (N2/2) DOES NOT HAVE A SET SHELF LIFE AND WILL NORMALLY BE RELIABLE FOR THE LIFE OF A VEHICLE. Read More »
MERCEDES VEHICLE: THE SRS INDICATOR LAMP IS ILLUMINATED AND CODE B1058 AND B2DBO ARE STORED, REPLACE THE SRS CONTROL UNIT. MODELS 203 AND MODEL 209. MODEL YEARS UNKNOWN. *PE Read More »
ALL MODEL 171, 203 AND 209 VEHICLES EQUIPPED WITH SALES CODE 477 - TIRE LOSS WARNING SYSTEM (INDIRECT ESP BASED) WITH RUN FLAT TIRES. [TIRE PRESSURE MONITORING INACTIVE] DISPLAYED INSTRUMENT CLUSTER. MODEL YEAR 2005-2007. Read More »
