1991 Lincoln Continental
58 Technical Service Bulletins (TSBs)
TSB List for the 1991 Lincoln Continental
Technical Service Bulletins (TSBs) for the 1991 Continental are official communications between Lincoln & their dealerships that describe processes for troubleshooting or fixing certain common problems. All vehicle manufacturers are required by U.S. law to make their TSBs available to the public.
STEERING:HYDRAULIC POWER ASSIST SYSTEM
-
TSB #95191
THE POWER STEERING SYSTEM MAY HAVE A 'GRUNT' AND/OR 'GROAN' NOISE. THIS MAY BE CAUSED BY HYDRAULIC FLUID MOVEMENT WITHIN THE POWER STEERING RACK. Read More »
STEERING:HYDRAULIC POWER ASSIST:HOSE, PIPING, AND CONNECTIONS
-
TSB #9716
SOME POWER STEERING HOSES HAVE BEEN REPLACED WITH A REVISED DESIGN AND SHOULD NO LONGER BE USED FOR SERVICE. *JD Read More »
SUSPENSION:FRONT
-
TSB #9534
RATTLING OR CLUNKING NOISE FROM THE FRON SUSPENSION. *TW Read More »
SUSPENSION:REAR
-
TSB #95165
SUSPENSION-REAR-AVAILABILITY OF CAMBER KIT TO IMPROVE INNER EDGE WEAR ON REAR REAR TIRES. TIRES-REAR-INNER EDGE WEAR-AVAILABILITY OF CAMBER KIT TO IMPROVE WEAR. *SD Read More »
SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DISC
-
TSB #985A13
THE USE OF PETROLEUM-BASED GREASE AS A LUBRICANT IN SERVICING DISC BRAKES IS NO LONGER ACCEPTABLE. *YC Read More »
-
TSB #9562
ROUGHNESS CONCERN DURING BRAKE APPLICATION. *TW Read More »
-
TSB #9566
UNKNOWN Read More »
SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP
-
TSB #985A6
SOME VEHICLES MAY CYCLE WHEN BRAKES ARE APPLIED ON ROUGH ROADS OR ON AN INCLINE WHILE MAKING A SHARP TURN. *YC Read More »
-
TSB #95212
THE USE OF PETROLEUM-BASED GREASE AS A LUBRICANT IN SERVICING DISC BRAKES IS NO LONGER ACCEPTABLE BECAUSE IT MAY BE INCOMPATIBLE WITH THE RUBBER MATERIAL USED IN THE DISC BRAKE SYSTEM. Read More »
ENGINE AND ENGINE COOLING:ENGINE
-
TSB #9874
A NEW SILICONE GASKET AND SEALANT. *YC Read More »
-
TSB #9811329
INFORMATION REGARDING THE THE AVAILABILITY OF THE REVISED HEADGASKET FOR COOLANT LOSS CONDITIONS ON SOME ENGINES. *TT Read More »
-
TSB #97610
BLOWER MOTOR- "CHIRPING" OR "SQUEAKING" FROM BLOWER MOTOR AT LOW SPEEDS. *JD Read More »
-
TSB #9743
BLOWER MOTOR- "CHIRP" OR "SQUEAK" FROM BLOWER MOTOR AT LOW SPEEDS. *JD Read More »
ENGINE AND ENGINE COOLING:ENGINE:GASOLINE
-
TSB #99816
FORD MOTOR COMPANY NOW RECOMMENDS SAE 5W-30 VISCOSITY GRADE FOR SERVICING ANY FORD GASOLINE-POWERED VEHICLE REGARDLESS OF MODEL YEAR. *TT Read More »
-
TSB #9582
A REVISED SERVICE WINDSHIELD WIPER MOTOR IS NOW AVAILABLE. *TW Read More »
ENGINE AND ENGINE COOLING:COOLING SYSTEM
-
TSB #9849
CONCERNS WITH COOLANT MAY LEAK FROM THE HEAD GASKETS AND / OR THE VEHICLE MAY OVERHEAT. *YC Read More »
ENGINE AND ENGINE COOLING:EXHAUST SYSTEM
-
TSB #9864
INFORMATION ON A BUZZING OR RATTLE NOISE FROM THE EXHAUST SYSTEM. *TT Read More »
ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL
-
TSB #982310
MASS AIR FLOW (MAF)- SENSOR CONTAMINATION- SERVICE TIP. *AK Read More »
FUEL SYSTEM, GASOLINE
-
TSB #9523
ERRATIC DISTANCE-TO-EMPTY AND FUEL GAUGE READINGS. *TW Read More »
POWER TRAIN
-
TSB #12178
INFORMATION REGARDING TSB 98-5A-12 (TRANSAXLE/TRANSMISSION/TRANSFER CASE-VEHICLES TOWED BEHIND RECREATIONAL VEHICLES-RECOMMENDED GUIDELINES) DOES NOT LIST TOWING INFORMATION FOR CERTAIN MODEL VEHICLES. Read More »
-
TSB #97111097237
CONCERNS WITH HARSH ENGAGEMENTS AND HARSH SHIFTS WITH DIAGNOSTIC TROUBLE CODES (DTCS) 628, P0741 AND/OR P1744. *YC Read More »
POWER TRAIN:CLUTCH ASSEMBLY:PEDAL/HAND LEVER(MOTORCYCLE)
-
TSB #12559
CONCERNS WITH REVERSE CLUTCH THAT COULD BECOME SHEARED OR TORN IN EXTREMELY COLD TEMPERATURES. *TT Read More »
POWER TRAIN:MANUAL TRANSMISSION
-
TSB #9802169838
TRANSAXLES USE A NEW TRANSMISSION FLUID. *YC Read More »
POWER TRAIN:AUTOMATIC TRANSMISSION
-
TSB #0015
INFORMATION REGARDING THE NEW TRANSMISSION COOLER FLUSHER- SERVICE TIP. *MJS Read More »
-
TSB #99152
INFORMATION ON THE NEW FLUSH AND FILL TOOL AVAILABLE THROUGH ROTUNDA. *TT Read More »
-
TSB #9888
INFORMATION ON A NEW TRANSMISSION FLUID USAGE CHART. *YC Read More »
-
TSB #97511
FLUID- TRANSMISSION FLUID USAGE CHARTS. *JD Read More »
-
TSB #BC101209702
VERIFY THE TRANSAXLE INSTALLED IN THE VEHICLE IS THE CORRECT MODEL AND MODEL YEAR FOR THE VEHICLE. *JD Read More »
-
TSB #94247
THE FORWARD CLUTCH PISTON MAY CRACK ON ITS OUTSIDE DIAMETER. *TW Read More »
-
TSB #ONP/94M84
VEHICLES MAY EXHIBIT ERRATIC TRANSMISSION OPERATION. *TW Read More »
POWER TRAIN:AUTOMATIC TRANSMISSION:LEVER AND LINKAGE:COLUMN SHIFT
-
TSB #14811
INFORMATION ON ADDITIONAL PARTS REQUIRED WHEN REPLACING TRANSFER CASE ON VEHICLES EQUIPPPED WITH AX4S TRANSAXLE. *TT Read More »
-
TSB #12616
INFORMATION ON TRANSAXLE SERVICE CASE REPLACEMENT WITH OSS (OUTPUT SHAFT SPEED SENSOR) HOLE. *TT Read More »
POWER TRAIN:AUTOMATIC TRANSMISSION:TORQUE CONVERTER
-
TSB #962612
TRANSAXLE - TORQUE CONVERTER REPLACEMENT GUIDELINES AND TORQUE CONVERTER/TRANSAXLE COOLING SYSTEM CLEANING PROCEDURES - SERVICE TIP. *TW Read More »
-
TSB #96249
TORQUE CONVERTER - LEAK TEST PROCEDURE - SERVICE TIP. *TW Read More »
-
TSB #95157
THE TORQUE CONVERTER IDENTIFICATION CODES HAVE BEEN REVISED AS OF 3/1/95. *SD Read More »
POWER TRAIN:AXLE ASSEMBLY:AXLE SHAFT:SEAL
-
TSB #982675
A REVISED FORWARD CLUTCH INNER SEAL FOR THE AXOD, AXODE, AX4S & AX4N TRANSAXLE IS AVAILABLE WITH IMPROVED SEALING AND REDUCED CHANCE OF THE SEAL ROLLING DURING INSTALLATION. *YC Read More »
ELECTRICAL SYSTEM
-
TSB #98246
FORD MOTOR COMPANY HAS RELEASED A NEW ELECTRICAL GREASE ( F8AZ - 19G208-AA ) TO REDUCE THE POSSIBILITY OF MOISTURE CORROSION AT THE TERMINALS. *YC Read More »
ELECTRICAL SYSTEM:STARTER ASSEMBLY
-
TSB #97111097234
VEHICLES EXHIBITING A "SQUEAKING" OR "CHIRPING" FROM THE BLOWER MOTOR AT LOW BLOWER MOTOR SPEEDS. *YC Read More »
ELECTRICAL SYSTEM:WIRING
-
TSB #99222
SUBJECT ON A WIRE HARNESS TERMINAL REPAIR KIT AVAILABLE FOR REPAIRING ELECTRICAL WIRING HARNESSES. *TT Read More »
-
TSB #96246
WIRING - ELECTRICAL DIODE IDENTIFICATION AND SERVICE REPLACEMENTS. *TW Read More »
ELECTRICAL SYSTEM:IGNITION:MODULE
-
TSB #97613
TRANSAXLE- AX4S/AX4N- DIAGNOSTIC TROUBLE CODES (DTCS) 628, P0741 AND/OR P1744 STORED IN MEMORY AFTER TRANSAXLE EXCHANGE. *JD Read More »
VISIBILITY:WINDSHIELD
-
TSB #96221
WINDSHIELD AND INTERIOR GLASS - FOG/FILM. *TW Read More »
VISIBILITY:WINDSHIELD WIPER/WASHER
-
TSB #011201
THIS INFORMATION IS A SUPPLEMENT TO THE WIPER SYSTEM SERVICE INFORMATION PROVIDED IN THE WORKSHOP MANUALS. THIS SERVICE INFORMATION IS INTENDED AS AN AID TO ASSIST IN DIAGNOSIS AND REPAIR OF ERRATIC WIPER SYSTEM CONDITIONS. Read More »
VISIBILITY:WINDSHIELD WIPER/WASHER:MOTOR
-
TSB #02107
TRANSFER SERVICE TIPS FOR THE FRONT WIPER MOTOR MOUNT BRACKET AND DEPRESSED PARK OUTPUT ARM. *TT Read More »
-
TSB #9582
A REVISED SERVICE WINDSHIELD WIPER MOTOR IS NOW AVAILABLE. *TW Read More »
-
TSB #9546
REVISED WIPER MOTOR. *TW Read More »
-
TSB #9546
WIPER MOTOR REPLACEMENT - UPGRADED SERVICE KITS. *TW Read More »
VISIBILITY:DEFROSTER/DEFOGGER/HVAC SYSTEM:HEATER CORE
-
TSB #01156
SOME VEHICLES MAY EXHIBIT HEATER CORE LEAKS. *SLC Read More »
VISIBILITY:DEFROSTER/DEFOGGER/HVAC SYSTEM:FAN/MOTOR
-
TSB #9592
UNKNOWN Read More »
-
TSB #95511
CHIRP OR SQUEAK FROM BLOWER MOTOR. *TW Read More »
-
TSB #9566
CHIRP OR SQUEAK NOISE FROM BLOWER MOTOR AT LOW SPEEDS. *TW Read More »
-
TSB #9566
UNKNOWN Read More »
EQUIPMENT:ELECTRICAL:RADIO/TAPE DECK/CD ETC.
-
TSB #99129
EXPERIENCING A WHINE / BUZZ TYPE NOISE IN THE SPEAKERS OF THE ENTERTAINMENT RADIO OR TWO-WAY RADIO ON VEHICLES WITH AN IN-TANK ELECTRIC FUEL PUMP. *TT Read More »
-
TSB #9873
EXPERIENCING A WHINING / BUZZING NOISE IN THE SPEAKERS OF THE ENTERTAINMENT RADIO OR TWO-WAY RADIO. *TT Read More »
EQUIPMENT:APPLIANCE:AIR CONDITIONER
-
TSB #99196
INFORMATION ON IDENTIFYING NON-APPROVED / ALTERNATE REFRIGERANTS WHICH COULD CAUSE SAFETY, AND PERFORMANCE CONCERNS IF INSTALLED IN FORD A/C SYSTEMS. *TT Read More »
-
TSB #9848
ANNOUNCING THE FORD OEM AIR CONDITIONING RETROFIT KIT AVAILABILITY. *YC Read More »
UNKNOWN OR OTHER
-
TSB #01157
INFORMATION REGARDING TRANSMISSION FLUID USAGE CHARTS. *SLC Read More »
-
TSB #9768
FUEL ECONOMY- CUSTOMER EXPECTATIONS VERSUS VEHICLE USAGE. *JD Read More »