2004 Isuzu Ascender
196 Technical Service Bulletins (TSBs)
TSB List for the 2004 Isuzu Ascender
Technical Service Bulletins (TSBs) for the 2004 Ascender are official communications between Isuzu & their dealerships that describe processes for troubleshooting or fixing certain common problems. All vehicle manufacturers are required by U.S. law to make their TSBs available to the public.
STEERING
-
TSB #0710001
RELEASE OF STEERING GEAR STUB SHAFT BEARING KIT FOR SERVICE. *KB Read More »
-
TSB #0510001
STEERING SYSTEM MOAN, GROAN, SHUDDER AND/OR VIBRATION TYPE NOISE DURING LOW SPEED TURNING MANEUVERS. *TT Read More »
-
TSB #0410S002
RELEASE OF STEERING GEAR STUB SHAFT BEARING KIT FOR SERVICE. *TT Read More »
SUSPENSION
-
TSB #PIP5338
This Preliminary Information communication provides information to the technician about vibration complaints that are one of the most challenging complaints to accurately diagnose and repair. Read More »
-
TSB #0606003
REVISED SHOCK MODULE REPLACEMENT (SERVICE MANUAL REVISION). *KB Read More »
-
TSB #0506003
REVISED STABILIZER SHAFT REPLACEMENT (SERVICE MANUAL REVISION). *TT Read More »
-
TSB #0506002
RATTLE, CLUNK, POP, SNAP NOISE FROM FRONT AND/OR REAR SUSPENSION WHILE DRIVING OVER ROUGH, UNEVEN, WASH BOARD ROAD SURFACES. *TT Read More »
BRAKES (PWS)
-
TSB #PIT4907A
This Preliminary Information communication provides information to the technician about brake rotors on new vehicles and replacement parts from General Motors Service Parts Operations. Read More »
SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DISC:CALIPER
-
TSB #0509003
REVISED REAR BRAKE CALIPER BRACKET MOUNTING BOLT FASTENER SPECIFICATION (SERVICE MANUAL REVISION). *TT *SC Read More »
-
TSB #0509002
REVISED FRONT BRAKE CALIPER BRACKET MOUNTING BOLT FASTENER TIGHTENING SPECIFICATION (SERVICE MANUAL REVISION). *TT Read More »
-
TSB #0409S002
REVISED REAR BRAKE CALIPER BRACKET MOUNTING BOLT FASTENER SPECIFICATION. *TT Read More »
SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP
-
TSB #0409003
ABS LIGHT ON, DTCS C0265, C0201, U1041 SET AND/OR LOSS OF COMMUNICATION WITH BRAKE MODULE. *TT Read More »
SERVICE BRAKES, AIR:DISC:CALIPER
-
TSB #040523003
REVISED REAR BRAKE CALIPER BRACKET MOUNTING BOLT FASTENER SPECIFICATION. *EH Read More »
SERVICE BRAKES, AIR:ANTILOCK:ABS WARNING LIGHT
-
TSB #0709002
ABS LIGHT ON, DTC'S C0265, C0201, U1041 SET AND / OR LOSS OF COMMUNICATION WITH BRAKE MODULE. *KB Read More »
ENGINE (PWS)
-
TSB #16NA383
This technical bulletin advises of a new fuel injection cleaner kit used for decarbonizing the intake valves to correct conditions of rough idle, Crank no start, extended crank or misfire, MIL with DTCs, and explains how Top Tier fuels ... Read More »
-
TSB #PIP5029G
THIS PRELIMINARY INFORMATION COMMUNICATION PROVIDES INFORMATION TO THE TECHNICIAN ABOUT VEHICLES THAT HAVE A MALFUNCTION INDICATOR LAMP ON OR ENGINE MISFIRE, ROUGH IDLE, EXTENDED CRANK, OR CRANK NO START IN SOME CASES. Read More »
ENGINE AND ENGINE COOLING
-
TSB #IB09-X-004C
The Isuzu Commercial Truck of America (ICTA) Service Technical Assistance Center (TAC) provides diagnostic support to Isuzu dealer technicians repairing Isuzu vehicles in and out of vehicle warranty. Read More »
-
TSB #PIP5540D
This Preliminary information communicates to the technician the need to inspect the induction system for potential icing issues in very cold ambient temperatures. Read More »
-
TSB #PIP5628
This Preliminary information communicates information that will need to be provided to TAC to aid in diagnosing if a vehicle comes in with misfire and DTC Codes P0300 - P0308 and/or P050D Read More »
-
TSB #PIP5540B
This Preliminary information communicates to the technician the need to inspect the induction system for potential icing issues in very cold ambient temperatures. Read More »
-
TSB #PIP5226
This Preliminary Information communication provides information to the technician about finding needle bearings during an oil change. Technician will gain access to the roller rockers to inspect them. Read More »
-
TSB #PIP5163A
This Preliminary Information communication provides information to the technician about engine block of possible cylinder bore damage, scoring or out of round as the possible cause of engine oil consumption, misfire, cylinder leakage or ... Read More »
-
TSB #PIP5163
This Preliminary Information communication provides information to the technician about engine block of possible cylinder bore damage, scoring or out of round as the possible cause of engine oil consumption, misfire, cylinder leakage or ... Read More »
-
TSB #PIT3173C
This Preliminary Information communication provides information to the technician that fluid contamination may be directed to one of the following testing centers according to the type of fluid needing testing. Read More »
-
TSB #0501S007
INFORMATION ON USE OF KENT MOORE BOLT EXTRACTOR TOOL KIT EN-47702 FOR REMOVING CYLINDER HEAD OR MAIN BEARING CAP BOLTS ON INLINE ENGINES. *AK Read More »
-
TSB #0501005
OIL LIFE MONITORING SYSTEM - POWERTRAIN CONTROL MODULE (PCM) RESET. *TT Read More »
-
TSB #0501003
NEW SPARK PLUGS AND GAPPING. *EH Read More »
-
TSB #0501001
UNABLE TO RESET ENGINE OIL LIFE MONITOR. *EH Read More »
ENGINE AND ENGINE COOLING:ENGINE
-
TSB #0701002
INFORMATION ON NEW IN-VEHICLE SERVICE PROCEDURE FOR REMOVAL/INSTALLATION OF LL8 CYLINDER HEAD. *NJ Read More »
-
TSB #0711001
4.2L LL8 ENGINE - FLASHING AND/OR MIL LIGHT, ROUGH IDLE, MISFIRES DTC'S P0300, P0301, P0302, P0303, P0304, P0305, P0306. *KB Read More »
-
TSB #0612003
LOSS OF BLOWER MOTOR SPEEDS EXCEPT FOR LOW SPEED OR INOPERATIVE. MANUAL TEMP CONTROL, OR HEATER ONLY. *KB Read More »
-
TSB #0601001
OPERATING CHARACTERISTICS OF THE ELECTRO-VISCOUS (EV) FAN CLUTCH AND DIAGNOSTIC TIPS FOR COOLING FAN NOISE, DELAYED TRANSMISSION SHIFTS AND/OR ENGINE REVVING TOO HIGH. *TT Read More »
-
TSB #0601001
ENGINE OIL LEAK AT REAR COVER ASSEMBLY AREA. *TT Read More »
-
TSB #0501006
UNDERHOOD TICK NOISE AT IDLE. *TT Read More »
-
TSB #0501005
OIL LEAK UNDER EXTREME COLD TEMPERATURES. *TT Read More »
-
TSB #0301S004
REVISED DIAGNOSTIC TROUBLE CODE (DTC) P0336 (ENGINE CONTROL SECTION OF THE SERVICE MANUAL). *TT THIS BULLETIN SUPERSEDES SB03-01-S004 DATED 08/01/2003. *TT Read More »
-
TSB #0401S002
SERVICE ENGINE SOON/CHECK ENGINE LIGHT ILLUMINATED, MISFIRE OR ROUGHNESS, DIAGNOSTIC TROUBLE CODE P0300 SET. *TT Read More »
-
TSB #030604033
REVISED DIAGNOSTIC TROUBLE CODE P0336. *TT UPDATE. TO INCLUDE 2004 ISUZU NQR COMMERCIAL MODELS. *TT Read More »
-
TSB #0401S001
REVISED DIAGNOSTIC TROUBLE CODE (DTC) P2135 (SERVICE MANUAL REVISION). *TT Read More »
ENGINE AND ENGINE COOLING:ENGINE:OIL/LUBRICATION:FILTER/SCREEN
-
TSB #22NA009
This service bulletin provides service information on new torque specification and installation procedure for ACDelco Spin-On Oil Filters. Read More »
ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL
-
TSB #PIP4925B
This preliminary information document communicates a tip on the way to diagnose possible induction or exhaust air leaks using the evaporative emission cart smoke machine and ultrasonic leak detector tools. Read More »
-
TSB #0503S002
I/M READINESS AS PART OE EMISSION INSPECTION AND MAINTENANCE PROGRAM FOR OBD II VEHICLES. TO INCLUDE ISUZU I-280 AND I-350 2003 - 2005. *AK Read More »
-
TSB #0503003
REVISED INSPECTION/MAINTENANCE (I/M) EVAPORATIVE EMISSION (EVAP) SYSTEM SET PROCEDURE (SERVICE MANUAL REVISION). *TT Read More »
-
TSB #050604021
REVISED INSPECTION/MAINTENANCE (I/M) EVAPORATIVE EMISSION (EVAP) SYSTEM SET PROCEDURE. *TT Read More »
ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL:CATALYTIC CONVERTOR
-
TSB #PIP5232B
This Preliminary Information communication provides information to the technician about gasoline powered cars, mid-size trucks, light duty trucks, and heavy duty trucks with premature catalytic converter failures. Read More »
-
TSB #PIP5232
This Preliminary Information communication provides information to the technician about gasoline powered cars, mid-size trucks, light duty trucks, and heavy duty trucks with premature catalytic converter failures. Read More »
-
TSB #PIP5232
This Preliminary Information communication provides information to the technician about gasoline powered cars, mid-size trucks, light duty trucks, and heavy duty trucks with premature catalytic converter failures. Read More »
FUEL SYSTEM, GASOLINE
-
TSB #05-06-04-035D
This informational bulletin provides the technician with information on what E85 fuel may due to a non E85 vehicle. Read More »
FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY
-
TSB #CSB-07-02-S003
ISUZU: SEE DOCUMENT SEARCH BUTTON FOR THE OWNER LETTER. THE MALFUNCTION INDICATOR LIGHT (MIL) IS ON, DUE TO FRACTURE OF WELD ON FUEL TANK INLET CHECK VALVE (ICV), A FUEL ODOR, AND/OR DROPS OF FUEL ON GROUND WHEN REFUELING VEHICLE. Read More »
FUEL SYSTEM, GASOLINE:FUEL INJECTION SYSTEM
-
TSB #16NA383
This technical bulletin advises of a new fuel injection cleaner kit used for decarbonizing the intake valves to correct conditions of rough idle, Crank no start, extended crank or misfire, MIL with DTCs, and explains how Top Tier fuels ... Read More »
-
TSB #0702001
VARIOUS DRIVEABILITY SYMPTOMS DUE TO CLOGGED FUEL INJECTORS, MIL DTC'S P0171, P0172, P0174, P0300, P1174, AND P1175. *KB UPDATED 08-03-07. *KB Read More »
FUEL SYSTEM, OTHER
-
TSB #SB16-02-S001A
SOME 2003-2004 MODEL YEAR ISUZU ASCENDER VEHICLES CONTAIN A FUEL TANK INLET CHECK VALVE (ICV) THAT COULD FRACTURE. THE ICV IS LOCATED ABOVE THE FULL FUEL LEVEL. Read More »
-
TSB #0502001
PERCEIVED FUEL ECONOMY AND DRIVER INFORMATION CENTER SETTING. *EH Read More »
-
TSB #0402S004
VEHICLE IS DIFFICULT TO FILL WITH FUEL OR FILLING STATION PUMP SHUTS OFF BEFORE TANK IS FULL OR FUEL SPITS BACK/OUT WHEN FILLING THE TANK. *TT Read More »
-
TSB #0402S002
MULTIPLE DRIVEABILITY SYMPTOMS DUE TO CLOGGED FUEL INJECTORS. *TT Read More »
FUEL SYSTEM, OTHER:STORAGE:TANK ASSEMBLY
-
TSB #SB16-02-S001A
SOME 2003-2004 MODEL YEAR ISUZU ASCENDER VEHICLES CONTAIN A FUEL TANK INLET CHECK VALVE (ICV) THAT COULD FRACTURE. THE ICV IS LOCATED ABOVE THE FULL FUEL LEVEL. Read More »
POWER TRAIN
-
TSB #0405S008
DIAGNOSTIC INFORMATION ON DIAGNOSTIC TROUBLE CODE P0894 AND P1870. *TT Read More »
-
TSB #0505S006
MALFUNCTION INDICATOR LAMP (MIL) ON, TRANSMISSION STUCK IN SECOND OR THIRD GEAR, INSTRUMENT CLUSTER INOPERATIVE (VERIFY AND REPAIR SOURCE OF VOLTAGE LOSS IN TRANSMISSION SOLENOID POWER SUPPLY CIRCUIT. Read More »
-
TSB #0505S002
SERVICE ENGINE SOON (SES) LIGHT ON, DIAGNOSTIC TROUBLE CODE (DTC) P0741, HARSH SHIFT, CRUISE CONTROL INOPERATIVE. *TT Read More »
-
TSB #0405011
DELAYED ENGAGEMENT OF FRONT WHEELS DURING A SLIP CONDITION ON MODELS EQUIPPED WITH NEW VENTURE GEAR NVG 126 OR NVG 226 TRANSFER CASE. *TT Read More »
-
TSB #0405S004
RATTLE SOUND COMING FROM UNDER THE VEHICLE, REPOSITION TRANSMISSION OIL COOLER LINES. *TT Read More »
POWER TRAIN:MANUAL TRANSMISSION
-
TSB #0705004
INFORMATION ON 2-3 UP-SHIFT OR 3-2 DOWNSHIFT CLUNK NOISE IS HEARD. *KB Read More »
-
TSB #0505007
DIAGNOSTIC TROUBLE CODE (DTC) P0757 SET, MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATED, POOR PERFORMANCE OF TRANSMISSION, TRANSMISSION SLIPPING. *TT Read More »
POWER TRAIN:AUTOMATIC TRANSMISSION
-
TSB #0605004
DIAGNOSTIC TROUBLE CODE (DTC) P0757 SET, MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATED, POOR PERFORMANCE OF TRANSMISSION, TRANSMISSION SLIPPING. *KB Read More »
-
TSB #0405002
INFORMATION ON 2-3 UP-SHIFT OR 3-2 DOWNSHIFT CLUNK SOUND. *TT Read More »
-
TSB #0605005
INFORMATION REGARDING AUTOMATIC TRANSMISSION SHIFT LOCK CONTROL FUNCTION. *TT Read More »
-
TSB #0505013
DIAGNOSTIC TIPS FOR AUTOMATIC TRANSMISSION DTC P0756. *TT Read More »
-
TSB #0405005
DIAGNOSTIC TIPS FOR DIAGNOSTIC TROUBLE CODE (DTC) P0756 2-3 SHIFT VALVE PERFORMANCE. *TT Read More »
-
TSB #00505006
MALFUNCTION INDICATOR LAMP (MIL) ON, TRANSMISSION STUCK IN SECOND OR THIRD GEAR, INSTRUMENT CLUSTER INOPERATIVE (VERIFY AND REPAIR SOURCE OF VOLTAGE LOSS IN TRANSMISSION SOLENOID POWER SUPPLY CIRCUIT). Read More »
-
TSB #0505S012
4L60 AUTOMATIC TRANSMISSION DIAGNOSTIC INFORMATION ON HARSH 1-2 UPSHIFT. *JB Read More »
-
TSB #0505002
DIAGNOSIS OF CRACK OR BROKEN TRANSMISSION CASE. *EH Read More »
-
TSB #0505009
1-2, 2-3, 3-4 SHIFT AND TORQUE CONVERTER CLUTCH (TCC) CHARACTERISTICS DURING COLD WEATHER OPERATION ON 4L60-E TRANSMISSIONS. TO INCLUDE 2006 ISUZU ASCENDER. *TT Read More »
-
TSB #0505010
ENGAGEMENT TIME OF ELECTRONICALLY CONTROLLED 4L60-E TRANSMISSIONS. *TT Read More »
-
TSB #0505004
SHIFT STABILIZATION FEATURE FOR HYDRAMATIC 4L60E TRANSMISSION. *EH Read More »
-
TSB #0505003
AUTOMATIC TRANSMISSION SHIFT LOCK CONTROL FUNCTION. *EH Read More »
-
TSB #0405012
MALFUNCTION INDICATOR LAMP ON, TRANSMISSION STUCK IN THIRD GEAR, INSTRUMENT CLUSTER INOPERATIVE. *TT Read More »
-
TSB #0405S007
DIAGNOSTIC INFORMATION ON HARSH 1-2 UPSHIFT. *NM Read More »
-
TSB #0405S009
DIAGNOSTIC TROUBLE CODE P0757 SET, SERVICE ENGINE SOON ILLUMINATED, POOR PERFORMANCE OF TRANSMISSION, TRANSMISSION SLIPPING. *TT Read More »
-
TSB #0405S006
HARSH GARAGE SHIFT FROM PARK TO DRIVE OR FROM PARK TO REVERSE WITH TRANSMISSION FLUID AT COLD AMBIENT TEMPERATURES. *TT Read More »
-
TSB #0405S004
AUTOMATIC TRANSMISSION SHIFT, ENGINE DRIVEABILITY CONCERNS OR SERVICE ENGINE SOON (SES) LIGHT ON AS A RESULT OF THE INSTALLATION OF AN AFTERMARKET REUSABLE, EXCESSIVELY OILED AIR FILTER. *TT Read More »
POWER TRAIN:AUTOMATIC TRANSMISSION:CONTROL MODULE (TCM/PCM/TECM)
-
TSB #0704003
ERRATIC SPEEDOMETER OPERATION OR SPEEDOMETER NEEDLE SHAKES ABOVE 60 MPH. *NJ Read More »
-
TSB #0505007
GUIDELINES FOR REPLACEMENT OF TRANSFER CASE CONTROL MODULE (TCCM). *TT Read More »
POWER TRAIN:TRANSFER CASE (4-WHEEL DRIVE)
-
TSB #0405S002
INOPERATIVE 4WD/AWD LAMP AND SYSTEM. *TT Read More »
-
TSB #0505005
SERVICE 4WD LIGHT ILLUMINATED, DIAGNOSTIC TROUBLE CODE (DTC) C0374 SET. *TT Read More »
-
TSB #0405S007
DIAGNOSTIC TROUBLE CODE C0379 SET, SERVICE 4WD LIGHT ON, 4WD INOPERATIVE. *TT Read More »
POWER TRAIN:DRIVELINE:DIFFERENTIAL UNIT
-
TSB #0507002
SQUEAK, SQUEAL OR WHISTLE NOISE FROM FRONT. *TT Read More »
-
TSB #0507S001
LUBRICANT/OIL LEAK FROM FRONT AREA OF VEHICLE. *TT Read More »
POWER TRAIN:AXLE ASSEMBLY
-
TSB #PIP3720D
This Preliminary Information communication provides information to the technician with the axel setup information from American Axle Manufacturing. Read More »
-
TSB #0507001
LUBRICANT OIL LEAK FROM FRONT AREA OF VEHICLE. *EH Read More »
ELECTRICAL SYSTEM
-
TSB #PIT5399A
This Preliminary Information communication provides information to the technician about connectivity concerns when connecting an Apple device via USB cord. Read More »
-
TSB #PIC5491J
THIS PRELIMINARY INFORMATION COMMUNICATION PROVIDES INFORMATION TO THE TECHNICIAN ABOUT VEHICLES THAT HAVE AN ONSTAR SYSTEM THAT WILL NOT POWER UP. TECHNICIAN SHOULD TURN OFF THE IGNITION AND CANCEL RETAINED ACCESSORY POWER. Read More »
-
TSB #PIC4310L
This Preliminary Information communication provides information to the technician about vehicle that may have an OnStar system that has progression tones when pressing the blue or red button. Read More »
-
TSB #PIC3278F
THIS PRELIMINARY INFORMATION COMMUNICATION PROVIDES INFORMATION TO THE TECHNICIAN THE STEPS NEEDED TO DIAGNOSE AND REPAIR THE VEHICLES THAT MAY HAVE UNWANTED OR PHANTOM PHONE CALLS. Read More »
-
TSB #PIC3718E
This Preliminary Information communication provides information to the technician about vehicles may have a no power or no connect concern. Technician will find that the OnStar led is red and Diagnostic Trouble Code U1500 is set. Read More »
-
TSB #PIC4935D
This Preliminary Information communication provides information to the technician about vehicles that during battery parasitic drain test, there may be some confusion as to what the normal power consumption reading should be from the ... Read More »
-
TSB #0404004
PROPER CONNECTION INFORMATION TO AVOID BLOWN 125 AMP FUSE AND VARIOUS INTERIOR ELECTRICAL SYSTEM CONDITION WHEN JUMP STARTING VEHICLE. *TT Read More »
-
TSB #0504003
DIAGNOSTIC INFORMATION ON HEADLAMPS FLICKER OR MOMENTARILY DIM WHILE DRIVING. *TT DIAGNOSTIC INFORMATION TO CLARIFY EFFECT OF SECONDARY AIR INJECTION SYSTEM ON HEADLAMP FLICKER. *TT Read More »
-
TSB #0604001
MALFUNCTION INDICATOR LAMP (MIL) ON CHECK ENGINE LIGHT ON, DTC P0526 SET. *TT Read More »
-
TSB #0604S001
DIAGNOSTIC INFORMATION TO CLARIFY EFFECT OF SECONDARY AIR INJECTION SYSTEM ON HEADLAMP FLICKER. *TT Read More »
-
TSB #0604003
INTERMITTENT NO CRANK, NO START. *TT Read More »
-
TSB #0501004
SERVICE ENGINE SOON LIGHT ON DIAGNOSTIC TROUBLE CODE P0483. *EH Read More »
-
TSB #0505002
SERVICE ENGINE SOON LIGHT ON DIAGNOSTIC TROUBLE CODE P0741 HARSH SHIFT CRUISE CONTROL INOPERATIVE. *EH Read More »
-
TSB #0512002
AUTOMATIC DUAL ZONE HVAC BATTERY DRAW. *EH Read More »
-
TSB #0513001
ERROR CODES ON RADIO DISPLAY THEIR CAUSE AND CORRECTIVE ACTION. *EH Read More »
-
TSB #0501002
SERVICE ENGINE SOON LIGHT ON. *EH Read More »
-
TSB #0504001
VARIOUS INTERIOR ELECTRICAL CONCERNS IP GAUGES LIGHTING INOPERATIVE HVAC CONTROLS INOPERATIVE BLOWER MOTOR INOPERATIVE RADIO INOPERATIVE FLASHER INOPERATIVE. *EH Read More »
-
TSB #0505001
SERVICE 4WD LIGHT ON 4WD INOPERATIVE HARSH ENGAGEMENT OF 4WD NO COMMUNICATION WITH TCCM DTC C0550 SET. *EH Read More »
-
TSB #0501003
SERVICE ENGINE SOON LIGHT ON. *EH Read More »
-
TSB #0404S003
LOW VOLTAGE DISPLAY ON (IP) INSTRUMENT PANEL GAUGE, LIGHTS DIM AT STOP LIGHTS, BATTERY DISCHARGED, NO START, SLOW CRANKING, DIM LIGHTS AT IDLE, LOW GENERATOR OUTPUT. *TT Read More »
-
TSB #0404S001
NO START OR BATTERY DRAIN CONDITION, AFTER IGNITION SWITCH REPLACEMENT. *TT Read More »
-
TSB #0404S001
REPLACEMENT OF MIRROR ACTUATOR. *TT Read More »
ELECTRICAL SYSTEM:12V/24V/48V BATTERY
-
TSB #191
ABS, RED BRAKE, SVC AND 4WD LIGHT ON, HVAC BLOWER INOPERATIVE. *NJ Read More »
ELECTRICAL SYSTEM:WIRING
-
TSB #96
DTC C0327 WITH OR WITHOUT ADDITIONAL DTC'S SETTING. WITH 4WD. *NJ Read More »
-
TSB #0605001
SERVICE 4WD LIGHT ILLUMINATED, DTC C0374 SET. *NJ Read More »
ELECTRICAL SYSTEM: INSTRUMENT CLUSTER/PANEL
-
TSB #PIC3100F
This Preliminary Information communication provides information to the technician about vehicle's odometer appears to be inaccurate relative to a known distance traveled. Read More »
-
TSB #0704002
PRNDL DISPLAY REDUCED VISIBILITY FOR APPROXIMATELY ONE MINUTE. *KB Read More »
-
TSB #0611015
NOISE COMING FROM INSTRUMENT PANEL CLUSTER. *KB Read More »
ELECTRICAL SYSTEM:SOFTWARE
-
TSB #PIT5264A
This Preliminary Information communication provides information to the technician about vehicles that are travelling from Canada to the United States. While in the United States they are unable to receive Turn-by-Turn directions. Read More »
EXTERIOR LIGHTING
-
TSB #0511004
EXTERIOR LAMP CONDENSATION AND REPLACEMENT GUIDELINES. *TT Read More »
VISIBILITY:GLASS, SIDE/REAR
-
TSB #0511002
DISTORTIOPN IN OUTER SURFACE OF VEHICLE GLASS. *EH Read More »
VISIBILITY:POWER WINDOW DEVICES AND CONTROLS
-
TSB #0611007
DISTORTION IN OUTER SURFACE OF VEHICLE GLASS. *KB Read More »
VISIBILITY:REARVIEW MIRRORS/DEVICES
-
TSB #0511003
OUTSIDE REARVIEW MIRROR VIBRATION. *EH Read More »
VISIBILITY:DEFROSTER/DEFOGGER/HVAC SYSTEM:REAR WINDOW
-
TSB #0511008
RECONNECTION OF REAR WINDOW DEFROSTER CONTACT OR TAB. *EH Read More »
AIR BAGS
-
TSB #0511003
PROPER AIR BAG SYSTEM DIAGNOSIS AND SERVICE. *EH Read More »
SEAT BELTS:FRONT:RETRACTOR
-
TSB #0511001
AVOIDING FRONT SEAT BELT RETRACTOR JAMMING WHEN STORING SEAT BELT. *TT Read More »
STRUCTURE:FRAME AND MEMBERS
-
TSB #PIP5338
This Preliminary Information communication provides information to the technician about vibration complaints that are one of the most challenging complaints to accurately diagnose and repair. Read More »
STRUCTURE:BODY
-
TSB #0511002
THE CENTER HIGH-MOUNT STOP LAMP (CHMSL) APPLIQUE IS LOOSE ON THE LIFT-GATE GLASS. *TT Read More »
-
TSB #0411S004
LIFTGATE GLASS UNLATCHES ON ROUGH/BUMPY ROAD SURFACES. *TT Read More »
-
TSB #0411S003
REAR LICENSE PLATE POCKET GASKET LOOSE OR OUT OF POSITION. *TT Read More »
-
TSB #0411S002
RATTLE SOUND FROM THE FRONT HOOD OF THE VEHICLE. *TT Read More »
STRUCTURE:BODY:DOOR
-
TSB #0711003
DOORS ARE HARD TO CLOSE. *KB Read More »
-
TSB #0611003
DOOR LATCH FREEZING IN COLD TEMPERATURES. *TT Read More »
-
TSB #0411S001
FRONT DOOR A-PILLAR WATER INTRUSION. *TT Read More »
-
TSB #0511002
DOOR HARD TO CLOSE. *EH Read More »
STRUCTURE:BODY:HATCHBACK/LIFTGATE
-
TSB #0611012
REAR LIFTGATE BINDS, IMPROPER FIT. THIS MAY BE CAUSED BY BROKEN WELDS OR CRACKS THAT FORMED AROUND THE INNER TWO WELDS. *KB Read More »
-
TSB #0511S005
LIFTGATE OR LIFTGATE GLASS BINDS, DOES NOT OPEN COMPLETELY, CHMSL HITS ROOF. *TT Read More »
LATCHES/LOCKS/LINKAGES:HATCHBACK/LIFTGATE:LOCK
-
TSB #0711015
REAR LIFTGATE GLASS MAY NOT LOCK WHEN USING REMOTE KEYLESS ENTRY (RKE) KEY FOB TRANSMITTER/DOOR LOCK SWITCH, LIFTGATE HATCH OR LIFTGATE GLASS MAY LOCK/UNLOCK WHEN REAR LIFTGATE GLASS BUTTON DEPRESSED. Read More »
TIRES
-
TSB #PIT3271G
This Preliminary Information communication provides information to the technician about changing the tire and wheel size on vehicles. Read More »
-
TSB #0608002
TIRE CHARACTERISTICS OF ORIGINAL EQUIPMENT TIRES. *KB Read More »
WHEELS
-
TSB #PIT3271G
This Preliminary Information communication provides information to the technician about changing the tire and wheel size on vehicles. Read More »
-
TSB #0508002
COLD TIRE CHARACTERISTICS OF THE MANUFACTURER GM ORIGINAL EQUIPMENT TIRES. *TT Read More »
-
TSB #0508001
INFORMATION ON TIRE RADIAL FORCE VARIATION. TO INCLUDE 2006 ISUZU ASCENDER. *TT Read More »
EQUIPMENT
-
TSB #WB13-X-001B
Isuzu Commercial Truck of America, Inc. (ICTA) is providing the following procedural recommendations to improve dealer efficiency when submitting Parts Warranty claims. Read More »
-
TSB #IB09-X-002B
The following is a list of the Isuzu-recommended Threebond product part numbers identified in the various Isuzu Workshop Manuals and bulletins. Read More »
-
TSB #IB09-X-004C
The Isuzu Commercial Truck of America (ICTA) Service Technical Assistance Center (TAC) provides diagnostic support to Isuzu dealer technicians repairing Isuzu vehicles in and out of vehicle warranty. Read More »
-
TSB #PIC6107A
This Preliminary Information communication provides information to the technician about being unable to receive OnStar ?Over The Air? updates. Read More »
-
TSB #PIT5399A
This Preliminary Information communication provides information to the technician about connectivity concerns when connecting an Apple device via USB cord. Read More »
-
TSB #PIC5491J
THIS PRELIMINARY INFORMATION COMMUNICATION PROVIDES INFORMATION TO THE TECHNICIAN ABOUT VEHICLES THAT HAVE AN ONSTAR SYSTEM THAT WILL NOT POWER UP. TECHNICIAN SHOULD TURN OFF THE IGNITION AND CANCEL RETAINED ACCESSORY POWER. Read More »
-
TSB #PIP5226A
THIS PRELIMINARY INFORMATION COMMUNICATION PROVIDES INFORMATION TO THE TECHNICIAN ABOUT FINDING NEEDLE BEARINGS DURING AN OIL CHANGE. TECHNICIAN WILL GAIN ACCESS TO THE ROLLER ROCKERS TO INSPECT THEM. Read More »
-
TSB #PIC5588B
This Preliminary Information communication provides information to the technician on the programming and activation of the OnStar system. Read More »
-
TSB #PIC5088E
This Preliminary Information communication provides information to the technician about vehicles that may not receiving all channels on the XM band. Read More »
-
TSB #0412S006
POOR HEATER PERFORMANCE 2ND AND 3RD ROW SEATS. *TT Read More »
EQUIPMENT:ELECTRICAL
-
TSB #PIC6107A
This Preliminary Information communication provides information to the technician about being unable to receive OnStar ?Over The Air? updates. Read More »
-
TSB #PIC5953A
This Preliminary Information communication provides information to the technician about vehicles that may have an issue when using Bluetooth voice recognition with an iPhone. Read More »
-
TSB #PIT5399
This Preliminary Information communication provides information to the technician about connectivity concerns when connecting an Apple device via USB cord. Read More »
-
TSB #PIT5264C
This Preliminary Information communication provides information to the technician about vehicles that are travelling from Canada to the United States. While in the United States they are unable to receive Turn-by-Turn directions. Read More »
-
TSB #PIC3278F
THIS PRELIMINARY INFORMATION COMMUNICATION PROVIDES INFORMATION TO THE TECHNICIAN THE STEPS NEEDED TO DIAGNOSE AND REPAIR THE VEHICLES THAT MAY HAVE UNWANTED OR PHANTOM PHONE CALLS. Read More »
-
TSB #PIC4310K
This Preliminary Information communication provides information to the technician about vehicle that may have an OnStar system that has progression tones when pressing the blue or red button. Read More »
-
TSB #PIC3278F
This Preliminary Information communication provides information to the technician the steps needed to diagnose and repair the vehicles that may have unwanted or phantom phone calls. Read More »
-
TSB #PIC4310J
This Preliminary Information communication provides information to the technician about vehicle that may have an OnStar system that has progression tones when pressing the blue or red button. Read More »
-
TSB #PIC5953
This Preliminary Information communication provides information to the technician about vehicles that may have an issue when using Bluetooth voice recognition with an iPhone. Read More »
-
TSB #PIC4310H
This Preliminary Information communication provides information to the technician about vehicle that may have an OnStar system that has progression tones when pressing the blue or red button. Read More »
-
TSB #06313003
ONSTART GENERATION 6 (DIGITAL) SYSTEM INOPERATIVE, HAS NO POWER, LED LIGHT NOT ON. *TT Read More »
-
TSB #0413S001
UTILIZING TECH 2 TO RETRIEVE PART NUMBER FOR RADIOS, COMPACT DISC (CD) CHANGERS AND INSTRUMENT PANEL CLUSTERS (IPC). *TT Read More »
EQUIPMENT:ELECTRICAL:RADIO/TAPE DECK/CD ETC.
-
TSB #PIC5959B
This Preliminary Information communication provides information to the technician about vehicle that has no XM audio on certain channels but XM channel info is displayed. Read More »
-
TSB #PIC5088E
This Preliminary Information communication provides information to the technician about vehicles that may not receiving all channels on the XM band. Read More »
-
TSB #PIC5088E
This preliminary bulletin provides procedures on how to reset or refresh the XM radio receiver is the customers states that they only get a few channels. Read More »
-
TSB #0513002
COMPACT DISC PLAYER SKIPPING INOPERATIVE SLUGGISH AND OR LONG SEARCH TIMES. *EH Read More »
-
TSB #0513001
BOSE RADIO MAY HAVE POOR FIDELITY. *EH Read More »
-
TSB #0513002
BUZZ TYPE NOISE COMING FROM REAR SPEAKERS. *EH Read More »
-
TSB #0413S001
POP NOISE HEARD FROM THE REAR SPEAKERS WHEN REAR SEAT AUDIO (RSA) IS TURNED ON OR OFF. *TT Read More »
EQUIPMENT:ELECTRICAL:NAVIGATIONAL SYSTEM(GLOBAL POSITIONING SYSTEM)
-
TSB #PIC6107A
This Preliminary Information communication provides information to the technician about being unable to receive OnStar ?Over The Air? updates. Read More »
-
TSB #PIC4310L
This Preliminary Information communication provides information to the technician about vehicle that may have an OnStar system that has progression tones when pressing the blue or red button. Read More »
-
TSB #PIT5264C
This Preliminary Information communication provides information to the technician about vehicles that are travelling from Canada to the United States. While in the United States they are unable to receive Turn-by-Turn directions. Read More »
-
TSB #PIC4310K
This Preliminary Information communication provides information to the technician about vehicle that may have an OnStar system that has progression tones when pressing the blue or red button. Read More »
-
TSB #PIC4310J
This Preliminary Information communication provides information to the technician about vehicle that may have an OnStar system that has progression tones when pressing the blue or red button. Read More »
-
TSB #PIC5588B
This Preliminary Information communication provides information to the technician on the programming and activation of the OnStar system. Read More »
-
TSB #PIC4310H
This Preliminary Information communication provides information to the technician about vehicle that may have an OnStar system that has progression tones when pressing the blue or red button. Read More »
EQUIPMENT:OTHER:LABELS
-
TSB #0511001
CENTER HIGH-MOUNT STOP LAMP (CHMSL) APPLIQUE LOOSE. *NJ Read More »
-
TSB #0411S001
INCORRECT PAINT CODE LISTED ON SERVICE PARTS IDENTIFICATION LABEL. *TT Read More »
EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL
-
TSB #WB13-X-001A
Isuzu Commercial Truck of America, Inc. (ICTA) is providing the following procedural recommendations to improve dealer efficiency when submitting Parts Warranty claims. Read More »
-
TSB #PIT3099P
This Preliminary Information communication provides information to the technician about installing General Motors Accessory pats. Technician can check Service Information for some accessories. Read More »
-
TSB #0503001
REVISED INSPECTION MAINTENANCE EVAPORATIVE EMISSION SYSTEM SET PROCEDURE. *EH Read More »
EQUIPMENT ADAPTIVE/MOBILITY
-
TSB #IB09-X-004C
The Isuzu Commercial Truck of America (ICTA) Service Technical Assistance Center (TAC) provides diagnostic support to Isuzu dealer technicians repairing Isuzu vehicles in and out of vehicle warranty. Read More »
-
TSB #16NA383
This technical bulletin advises of a new fuel injection cleaner kit used for decarbonizing the intake valves to correct conditions of rough idle, Crank no start, extended crank or misfire, MIL with DTCs, and explains how Top Tier fuels ... Read More »
-
TSB #PIT3099M
This Preliminary Information communication provides information to the technician about installing General Motors Accessory pats. Technician can check Service Information for some accessories. Read More »
EQUIPMENT:APPLIANCE:AIR CONDITIONER
-
TSB #0512002
INTERMITTENT SLOW TO COOL HVAC PERFORMANCE CONCERNS IN HIGH AMBIENT TEMPERATURES AND/OR HIGH HUMIDITY CONDITIONS AFTER START UP, ESPECIALLY AT LOW ENGINE SPEEDS. *TT Read More »
-
TSB #0512001
INTERMITTENT A/C PERFORMANCE CONCERNS IN HIGH AMBIENT TEMPERATURES AND OR HIGH HUMIDITY CONDITIONS ESPECIALLY AT LOW ENGINE SPEEDS. *EH FINAL RELEASE. *TT Read More »
-
TSB #0412S005
HVAC CONTROL MODULE MEMORY FUNCTIONS ELIMINATION OF CLIMATE CONTROL PERSONALIZATION FEATURE. *TT Read More »
-
TSB #0412S003
J44551 AIR CONDITIONER SUCTION SCREEN KIT REPAIR RECOMMENDATIONS AND PROCEDURES AFTER COMPRESSION FAILURES. *TT Read More »
-
TSB #0412S004
REAR HEATER & AIR CONDITIONING (A/C) PIPE REPLACEMENT/REPAIR. *TT Read More »
UNKNOWN OR OTHER
-
TSB #IB13-R-001G
This bulletin outlines the procedures for using the Alpine Exchange Program (the "Exchange Program"). Read More »
-
TSB #0514004
ELIMINATING UNWANTED ODORS IN VEHICLES. *TT Read More »
-
TSB #0313S002
TRAILER WEIGHT AND GCWR INFORMATION. *TT Read More »
-
TSB #0311S003
VEHICLE PAINT CODES. *TT Read More »
-
TSB #No comms 2024-03
There are no Manufacturer Communications in accordance with 49 CFR 579.5 to report for March 2024 for Isuzu Motors Limited. Read More »