Technical Service Bulletins (TSBs) for the 2007 Santa Fe are official communications between Hyundai & their dealerships that describe processes for troubleshooting or fixing certain common problems.
All vehicle manufacturers are required by U.S. law to make their TSBs available to the public.
The warranty coverage for the clock spring has been extended to 15 years with unlimited mileage from the date of original retail delivery or date of first use, whichever occurs first. Read More »
HYUNDAI: POWER STEERING GEAR BOX YOKE KIT INSTALLATION PROCEDURE. IF VEHICLE EXHIBITS A SLIGHT RATTLE NOISE ORIGINATING FROM THE STEERING GEAR BOX WHEN TURNING RIGHT ON UNEVEN ROAD SURFACES, REPLACE THE SUPPORT YOKE AND YOKE SPRING WITH ... Read More »
HYUNDAI: POWER STEERING GEAR BOX YOKE KIT INSTALLATION PROCEDURE. IF VEHICLE EXHIBITS A SLIGHT RATTLE NOISE ORIGINATING FROM THE STEERING GEAR BOX WHEN TURNING RIGHT ON UNEVEN ROAD SURFACES, REPLACE THE SUPPORT YOKE AND YOKE SPRING WITH ... Read More »
This bulletin describes the requirements for all wheel alignment and/or vehicle tracking claims and best practices when diagnosing and conducting alignment-related repairs for all models and model years. Read More »
This bulletin provides information on the rear wheel speed sensor for Santa Fe (CM), Santa Fe / XL (NC), Santa Fe Sport (AN), and Veracruz (EN) vehicles equipped with front wheel drive (FWD). Read More »
This bulletin provides information on the rear wheel speed sensor for Santa Fe (CM), Santa Fe / XL (NC), Santa Fe Sport (AN), and Veracruz (EN) vehicles equipped with front wheel drive (FWD). Read More »
This bulletin provides information on the rear wheel speed sensor for Santa Fe (CM), Santa Fe / XL (NC), Santa Fe Sport (AN), and Veracruz (EN) vehicles equipped with front wheel drive (FWD). Read More »
Some Santa Fe (CM) vehicles may have an engine that potentially leaks oil from the front cylinder banka??s valve cover onto the alternator. Read More »
Some Santa Fe (CM) vehicles may have an engine that potentially leaks oil from the front cylinder banka??s valve cover onto the alternator. Read More »
Some Santa Fe (CM) vehicles may have an engine that potentially leaks oil from the front cylinder banka??s valve cover onto the alternator. Read More »
Some Santa Fe (CM) vehicles may have an engine that potentially leaks oil from the front cylinder banka??s valve cover onto the alternator. Read More »
Some Santa Fe (CM) vehicles may have an engine that potentially leaks oil from the front cylinder banka??s valve cover onto the alternator. Read More »
Some Santa Fe (CM) vehicles may have an engine that potentially leaks oil from the front cylinder banka??s valve cover onto the alternator. Read More »
Some Santa Fe (CM) vehicles may have an engine that potentially leaks oil from the front cylinder banka??s valve cover onto the alternator. Read More »
Follow the guidelines outlined in this bulletin to inspect and clean or replace certain components of the engine intake system accordingly during engine short block or sub-assembly replacement. Read More »
This bulletin provides the service procedure for engine connecting rod bearing clearance testing. Perform the procedure outlined in this bulletin to fulfill the Bearing Clearance Test inspection requirements to determine next required ... Read More »
HYUNDAI: DTC P2135/P0638 OR COLD ENGINE RPM FLUCTUATION; TPS REPLACEMENT AND ECM UPDATE. SOME 2.7L, 3.3L OR 3.8L ENGINES IN MODELS IDENTIFIED IN THE APPLICABILITY LIST MAY EXPERIENCE ONE OR MORE OF THE CONDITIONS LISTED. Read More »
HYUNDAI: SOME VEHICLES MAY EXPERIENCE A MALFUNCTION INDICATOR LAMP ILLUMINATED WITH THE ETC (ELECTRONIC THROTTLE CONTROL) SYSTEM RELATED DTC P2135 ( FORCED LIMITED POWER) OR DTC P0638 (POWER MANAGEMENT). Read More »
HYUNDAI: AUTOMATIC TRANSAXLE RANGE SWITCH DIAGNOSTIC TROUBLE CODES P0705 (RANGE SWITCH SIGNAL PROBLEMS), P0707 (RANGE SWITCH OPEN CIRCUIT), AND P0708 (RANGE SWITCH SHORT CIRCUIT OR MULTIPLE INPUTS). Read More »
HYUNDAI: WIRE ATTACHMENT-ENGINE ROOM JUNCTION BOX. VEHICLES EQUIPPED WITH THE FULLY AUTOMATIC TEMPERATURE CONTROL (FATC) A OR THE MANUAL HVAC SYSTEM WITH THE OPTIONAL TRIP COMPUTER MAY DISPLAY AN INCORRECT OUTSIDE TEMPERATURE READING. Read More »
HYUNDAI: (SERVICE CAMPAIGN T83). SOME VEHICLES EQUIPPED WITH A TEMPERATURE CONTROL DISPLAY MAY SHOW AN INCORRECT OUTSIDE TEMPERATURE READING. Read More »
HYUNDAI: MIL ON DTC P2135 OR P0638 OR COLD ENGINE RPM FLUCTUATION- TPS REPLACEMENT & ECM UPDATE. SOME VEHICLES MAY EXPERIENCE EITHER SLIGHT ENGINE RPM FLUCTUATION AT COLD WARM UP OR MALFUNCTION INDICATOR LAMP ILLUMINATED WITH THE ETC ... Read More »
HYUNDAI: SOME VEHICLES MAY EXPERIENCE A MALFUNCTION INDICATOR LAMP ILLUMINATED WITH THE ETC (ELECTRONIC THROTTLE CONTROL) SYSTEM RELATED DTC P2135 OR DTC P0638. *PE Read More »
These SKUs are Exhaust Manifolds with Catalytic Converters. The customer communication requested return of unsold inventory due to a loss of CARB certification. Read More »
HYUNDAI: MIL ON DTC P2135 OR P0638 OR COLD ENGINE RPM FLUCTUATION- TPS REPLACEMENT & ECM UPDATE. SOME VEHICLES MAY EXPERIENCE EITHER SLIGHT ENGINE RPM FLUCTUATION AT COLD WARM UP OR MALFUNCTION INDICATOR LAMP ILLUMINATED WITH THE ETC ... Read More »
Some Santa Fe (CM) vehicles may have an engine that potentially leaks oil from the front cylinder banka??s valve cover onto the alternator. Read More »
Hyundai approves only the ATF, DCT gear oil and IVT gear oil specified in the vehicle??A?A?s owner??A?A?s manual. ??A?A? Use of other ATF may result in improper shift quality or other drivability conditions. Read More »
The automatic transmission warranty repair policy authorizes in-dealership repairs of the following components for both OEM (new) and remanufactured automatic transmissions: Read More »
This TSB provides a procedure to diagnose and repair a transaxle for the following Incorrect Ratio DTC (transaxle clutch slipping more than 200 rpm in gear). Read More »
This TSB provides a procedure to diagnose and repair a transaxle for the following Incorrect Ratio DTC (transaxle clutch slipping more than 200 rpm in gear). Read More »
This bulletin provides the procedure to write the Vehicle Identification Number (VIN) during the replacement of the Engine Control Module (ECM) or Powertrain Control Module (PCM). Read More »
If you are servicing a vehicle with a harsh and/or delayed shift, use the GDS as shown in the Service Procedure to measure shift engagement time. Read More »
HYUNDAI: AUTOMATIC TRANSAXLE RANGE SWITCH DIAGNOSTIC TROUBLE CODES P0705 (RANGE SWITCH SIGNAL PROBLEMS), P0707 (RANGE SWITCH OPEN CIRCUIT), AND P0708 (RANGE SWITCH SHORT CIRCUIT OR MULTIPLE INPUTS). Read More »
"THE PCM OR TCM CONTAINS LOGIC TO ADJUST SOLENOID DUTY AND LINE PRESSURE AS NEEDED TO COMPENSATE FOR NORMAL CLUTCH WEAR OVER THE LIFE OF THE TRANSAXLE. Read More »
"THE PCM OR TCM CONTAINS LOGIC TO ADJUST SOLENOID DUTY AND LINE PRESSURE AS NEEDED TO COMPENSATE FOR NORMAL CLUTCH WEAR OVER THE LIFE OF THE TRANSAXLE. Read More »
HYUNDAI: REAR HUB BEARING REPLACEMENT 4WD. THE PROCEDURE TO REPLACE THE REAR HUB BEARINGS ON CERTAIN SANTA FE VEHICLES. THE PROCEDURE INCLUDES INSTALLATION INSTRUCTIONS FOR DUST COVERS INCLUDED IN THE REPLACEMENT HUB BEARING KIT. Read More »
This bulletin provides information on identifying dealer stock vehicles with either: a?? A Battery SOC alert - low Battery State of Charge (SOC) at or below 50%. a?? A 30 Day alert - vehicle has not started and reported an SOC in 30 days. Read More »
This bulletin provides guidelines to inspect the USB, head unit, and multi-box for common connection conditions. 2. This bulletin presents guidelines to inspect for common Android Auto and Apple CarPlay connection conditions. 3. Read More »
This bulletin provides the procedure to write the Vehicle Identification Number (VIN) during the replacement of the Engine Control Module (ECM) or Powertrain Control Module (PCM). Read More »
HYUNDAI: ON CERTAIN VEHICLES, FRONT VALVE COVER GASKET AND ALTERNATOR NEEDS INSPECTION AND IF NECESSARY, WILL BE REPLACED DUE TO ENGINE OIL LEAKAGE FROM FRONT CYLINDER BANK VALVE COVER GASKET NEAR WHERE CYLINDER HEAD AND TIMING COVER ... Read More »
HYUNDAI: INFORMATION PROCEDURE REGARDING REPLACEMENT OF ALTERNATOR DUE TO OIL CONTAMINATION, LH (FRONT) CYLINDER HEAD COVER GASKET, RESULTING IN NO ALTERNATOR OUTPUT, NO START, NO CRANK OR LOSS OF POWER. MODEL 2007-09 SANTA FE. Read More »
HYUNDAI: WIRE ATTACHMENT-ENGINE ROOM JUNCTION BOX. VEHICLES EQUIPPED WITH THE FULLY AUTOMATIC TEMPERATURE CONTROL (FATC) A OR THE MANUAL HVAC SYSTEM WITH THE OPTIONAL TRIP COMPUTER MAY DISPLAY AN INCORRECT OUTSIDE TEMPERATURE READING. Read More »
HYUNDAI: (SERVICE CAMPAIGN T83). SOME VEHICLES EQUIPPED WITH A TEMPERATURE CONTROL DISPLAY MAY SHOW AN INCORRECT OUTSIDE TEMPERATURE READING. Read More »
HYUNDAI: (SERVICE CAMPAIGN T85). CONDUCTING A SERVICE CAMPAIGN TO UPDATE THE ECU SOFTWARE ON CERTAIN VEHICLES. REFLASH THE ECU WITH THE APPROPRIATE FILE LISTED IN THE CHARTS IN THIS TSB. Read More »
This bulletin provides information regarding condensation related to moisture accumulation in the headlamp, rear combination lamp, daytime running lamp (DRL), or fog lamp. Read More »
HYUNDAI SERVICE CAMPAIGN: SEE DOCUMENT SEARCH BUTTON FOR OWNER LETTER. STOP LAMP SWITCH REPLACEMENT (CAMPAIGN 092). THIS BULLETIN DESCRIBES THE PROCEDURE TO REMOVE, REPLACE, AND ADJUST THE STOP LAMP SWITCH. Read More »
HYUNDAI SERVICE CAMPAIGN: SEE DOCUMENT SEARCH BUTTON FOR OWNER LETTER. STOP LAMP SWITCH REPLACEMENT (CAMPAIGN 092). THIS BULLETIN DESCRIBES THE PROCEDURE TO REMOVE, REPLACE, AND ADJUST THE STOP LAMP SWITCH. Read More »
This bulletin provides information regarding condensation related to the accumulated moisture in the headlamp, rear combination lamp, daytime running lamp (DRL), or fog lamp. Read More »
The warranty coverage for the clock spring has been extended to 15 years with unlimited mileage from the date of original retail delivery or date of first use, whichever occurs first. Read More »
In some areas, a vehicle's underbody may exhibit corrosion due to road salt usage. As a precautionary measure, cavity wax coating is applied to the internal surfaces of underbody components, and an undercoating spray is applied to the ... Read More »
Hyundai applies a Paint Protection Film (PPF) on new vehicles before delivery to dealerships. It provides a barrier between the paint and contaminants, such as rail dust, acid rain, and industrial fallout. Read More »
Effective June 2, 2008, Federal Motor Vehicle Safety Standard 110 (FMVSS 110) established a threshold for correcting load carrying capacity information indicated on tire placards when vehicle weight has been increased before retail ... Read More »
This bulletin provides information on tire maintenance best practices and procedures for dealers and customers to maximize tire life and performance. Read More »
This bulletin provides information on tire maintenance best practices and procedures for dealers and customers to maximize tire life and performance. Read More »
This bulletin provides information on the rear wheel speed sensor for Santa Fe (CM), Santa Fe / XL (NC), Santa Fe Sport (AN), and Veracruz (EN) vehicles equipped with front wheel drive (FWD). Read More »
HYUNDAI: REAR HUB BEARING REPLACEMENT 4WD. DESCRIBES THE PROCEDURE TO REPLACE THE REAR HUB BEARINGS ON CERTAIN VEHICLES. THE PROCEDURE INCLUDES INSTALLATION INSTRUCTIONS FOR DUST COVERS INCLUDED IN THE REPLACEMENT HUB BEARING KIT. Read More »
The Blind Spot Detection (BSD) or Blind-Spot Collision Warning (BCW) is a system that measures the speed of and distance from the following vehicles by using two magnetic wave radar sensors attached in the rear bumper. Read More »
The Blind Spot Detection (BSD) or Blind-Spot Collision Warning (BCW) is a system that measures the speed of and distance from the following vehicles by using two magnetic wave radar sensors attached in the rear bumper. Read More »
This bulletin provides the service procedure for engine connecting rod bearing clearance testing. Perform the procedure outlined in this bulletin to fulfill the Bearing Clearance Test inspection requirements to determine next required ... Read More »
This bulletin provides information regarding condensation related to moisture accumulation in the headlamp, rear combination lamp, daytime running lamp (DRL), or fog lamp. Read More »
This bulletin describes the general guidelines to help disinfect and protect vehicle exterior/interior surfaces using recommended safe chemical products. Read More »
This bulletin provides information on identifying dealer stock vehicles with either: a?? A Battery SOC alert - low Battery State of Charge (SOC) at or below 50%. a?? A 30 Day alert - vehicle has not started and reported an SOC in 30 days. Read More »
If you are servicing a vehicle with a harsh and/or delayed shift, use the GDS as shown in the Service Procedure to measure shift engagement time. Read More »
HYUNDAI: SOME VEHICLES MAY EXPERIENCE A MALFUNCTION INDICATOR LAMP ILLUMINATED WITH THE ETC (ELECTRONIC THROTTLE CONTROL) SYSTEM RELATED DTC P2135 ( FORCED LIMITED POWER) OR DTC P0638 (POWER MANAGEMENT). Read More »
The automatic transmission warranty repair policy authorizes in-dealership repairs of the following components for both OEM (new) and remanufactured automatic transmissions: Read More »
This bulletin provides information regarding condensation related to moisture accumulation in the headlamp, rear combination lamp, daytime running lamp (DRL), or fog lamp. Read More »
The automatic transmission warranty repair policy authorizes in-dealership repairs of the following components for both OEM (new) and remanufactured automatic transmissions: Read More »
This bulletin provides instruction detailing the proper methodology for scanning and uploading captured GDS data files to the Techline Repository. Read More »
In some areas, a vehicle?s underbody may exhibit corrosion due to road salt usage. As a precautionary measure, cavity wax coating is applied to the internal surfaces of underbody components, and an undercoating spray is applied to the ... Read More »
