Technical Service Bulletins (TSBs) for the 2002 Ranger are official communications between Ford & their dealerships that describe processes for troubleshooting or fixing certain common problems.
All vehicle manufacturers are required by U.S. law to make their TSBs available to the public.
REVISED PROCEDURE FOR ADJUSTING ALIGNMENT ON ALL SUSPENSIONS - NEW RIGHT HAND UPPER CONTROL ARM DESIGN FOR TORSION BAR FRONT SUSPENSIONS. *TT Read More »
SOME VEHICLES WITH 4WABS MAY EXHIBIT DIAGNOSTIC TROUBLE CODES C1233 AND C1234 (ANTI-LOCK BRAKE SENSOR OUTPUT FAILURES) IN SLIPPERY CONDITIONS. *TT Read More »
MALFUNCTION INDICATOR LAMP ON WITH OR WITHOUT ROUGH RUNNING, LACK OF POWER, SURGE OR POOR FUEL ECONOMY WITH DIAGNOSTIC TROUBLE CODES P0401, P0402, P1400, P1401. *TT *JB Read More »
HARD START/LONG CRANK WHEN COLD OR STUMBLES/SURGES DURING DRIVE-AWAY. POSSIBLE DIAGNOSTIC TROUBLE CODES P0171, AND P0174 OR P0172 AND P0175. *TT Read More »
STREAMLINED DIAGNOSTIC PROCEDURE FOR VEHICLES WITH MALFUNCTION INDICATOR LAMP (MIL) ON AND DIAGNOSTIC TROUBLE CODES (DTCS) P0401, P0402, P1400 OR P1401, OR RUNS ROUGH, LACKS POWER, SURGE, POOR FUEL ECONOMY, AND THE ABOVE LISTED DTCS ... Read More »
INCORRECTLY INSTALLED GEAR DRIVEN CAMSHAFT POSITION (CMP) SENSOR SYNCHRONIZER ASSEMBLIES CAUSING SURGE, LOST OF POWER, MALFUNCTION INDICATOR LAMP ON AND DIAGNOSTIC TROUBLE CODES P1336, P1309 AND P0340. Read More »
SOME VEHICLES EQUIPPED WITH PASIVE ANTI-THEFT SYSTEM MAY EXHIBIT A NO CRANK / NO START CONDITION AND NO COMMUNICATION WITH NGS OR WDS FROM THE POWER TRAIN CONTROL MODULE (PCM). *TT Read More »
SOME VEHICLES WITH A MANUAL TRANSMISSION MAY EXHIBIT AN ENGINE LOSS OR REDUCTION IN POWER CONDITION ON DECELERATION, BUT WILL IMMEDIATELY RESTART. *TT Read More »
SOME VEHICLES MAY EXHIBIT VACUUM OR AIR LEAKS IN THE INTAKE MANIFOLD AND / OR ENGINE SYSTEM CAUSING DIAGNOSTIC TROUBLE CODES P0171 AND OR P0174. *TT Read More »
SOME VEHICLES EQUIPPED WITH THE 4.0 SOHC ENGINE MAY EXHIBIT A PRIMARY CHAIN RATTLE NOISE (SOMETIMES DESCRIBED AS A SPARK KNOCK-TYPE NOISE). *TT Read More »
ENGINE AND ENGINE COOLING:ENGINE:GASOLINE:BELTS AND ASSOCIATED PULLEYS
WEAR-THROUGH CONDITION ON THE ABRASION SLEEVE OF THE UPPER RADIATOR HOSE NEAR THE AIR CONDITIONING ACCUMULATOR OR TRANSMISSION FLUID DIPSTICK. *TT Read More »
ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL
SOME VEHICLES MAY EXHIBIT FUEL DIAGNOSTIC TROUBLE CODES P0171, P0172, P0174, P0175 OR MASS AIR FLOW DIAGNOSTIC TROUBLE CODES P0102, P0103, P0112, P0113. *TT Read More »
ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL:GAS RECIRCULATION VALVE (EGR VALVE)
CUSTOMER SATISFACTION PROGRAM 02M01 SUPPLEMENT #4. CERTAIN FORD 2000 THROUGH 2003 VEHICLES EQUIPPED WITH A TUBE-MOUNTED EGR PRESSURE SENSOR - ADDITIONAL EGR PRESSURE SENSOR WARRANTY COVERAGE. *TT SUPPLEMENT #3. Read More »
FUEL SYSTEM, GASOLINE:DELIVERY:HOSES, LINES/PIPING, AND FITTINGS
SOME VEHICLES MAY EXHIBIT A NO 1-2 UPSHIFT, NO 2-3 UPSHIFT, A NO ENGINE BRAKING CONDITION IN MANUAL 1 OR DIAGNOSTIC TROUBLE CODE P0732 (GEAR 2 INCORRECT RATIO) OR P0733 (GEAR 3 INCORRECT RATIO). Read More »
SOME VEHICLES BUILT PRIOR TO 9/15/2001 MAY EXHIBIT LOW LINE PRESSURE READINGS WHILE IN DRIVE, NO 2ND GEAR, NO 3RD GEAR, NO ENGINE BRAKING IN MANUAL 1ST AND SLIPPING SHIFTS AND / OR DELAYED ENGAGEMENTS. Read More »
SOME VEHICLES EQUIPPED WITH A 2.3L, 3.0L OR 4.0L ENGINE AND 5R44E OR 5R55E AUTOMATIC TRANSMISSION MAY EXHIBIT A FLUID LEAK AT THE TRANSMISSION SERVO COVERS IN COLD CLIMATES. *TT Read More »
LOW LINE PRESSURE READING AT WIDE OPEN THROTTLE (WOT), SLIPPING SHIFTS AND / OR DELAYED ENGAGEMENTS WITH POSSIBLE DIAGNOSTIC TROUBLE CODES P0732, P0733, P1762 SET ON VEHICLES BUILT BEFORE 12/1/2001. Read More »
BUZZ/HOWL IN THE TRANSFER CASE SHIFT LEVER WHILE DRIVING, AND/OR SHIFT LEVER BOOT DETACHMENT DUE TO INSUFFICIENT RETENTION OF THE BOOT(S). *TT Read More »
SOME VEHICLES EQUIPPED WITH 5R55E/5R44E TRANSMISSION MAY EXHIBIT A WHINE NOISE IN 1ST GEAR THAT GOES AWAY AFTER THE 1-2 OR 1-3 SHIFT IS COMPLETED. *TT Read More »
SOME VEHICLES WITH MANUAL TRANSMISSION MAY EXHIBIT A DIFFICULT TO ENGAGE INTO 4X4 LOW CONDITION WHEN THE AMBIENT TEMPERATURE IS 0 DEGREES F (-18 C) OR COLDER. *TT Read More »
POWER TRAIN:AUTOMATIC TRANSMISSION:COOLING UNIT AND LINES
THUMP/CLUNK ON LIGHT ACCELERATION FROM STOP OR WHEN BRAKING AND COMING TO A STOP ON CERTAIN 4X4 SUPER CAB EQUIPPED WITH AUTOMATIC TRANSMISSION AND STEEL DRIVESHAFT. *TT Read More »
SOME 4X4 SUPER CAB VEHICLES MAY EXHIBIT A LOW FREQUENCY THUMP TYPE NOISE / VIBRATION ON LIGHT ACCELERATION FROM A STOP, AND / OR WHEN COMING TO A STOP WITH LIGHT TO MODERATE BRAKING. *TT Read More »
MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATED - SYSTEM LEAN DIAGNOSTIC TROUBLE CODES (DTC'S) - SERVICE TIPS. VARIOUS MODELS INCLUDING 2004 F-SERIES. *TT Read More »
STREAMLINED DIAGNOSTIC PROCEDURE FOR VEHICLES WITH MALFUNCTION INDICATOR LAMP (MIL) ON AND DIAGNOSTIC TROUBLE CODES (DTCS) P0401, P0402, P1400 OR P1401. ADDITIONAL SYMPTOMS MAY INCLUDE RUNS ROUGH, LACKS POWER, SURGE, POOR FUEL ECONOMY. Read More »
STREAMLINED DIAGNOSTIC PROCEDURE FOR VEHICLES WITH MALFUNCTION INDICATOR LAMP ON AND DIAGNOSTIC TROUBLE CODES (DTCS) P0401, P0402, P1400 OR P1401. ADDITIONAL SYMPTOMS MAY INCLUDE RUNS ROUGH, LACKS POWER, SURGE, POOR FUEL ECONOMY. Read More »
MALFUNCTION INDICATOR LAMP ILLUMINATED WITH DIAGNOSTIC TROUBLE CODES (DTCS) P0442, P0455, P0456, P0457 OR P1442 OR A CHECK FUEL CAP LAMP ILLUMINATED WITH DTC P0457 FOR THE EVAPORATIVE EMISSION SYSTEM. Read More »
DIAGNOSTIC TROUBLE CODES (DTC) B1877 (DRIVER PRETENSIONER CIRCUIT RESISTANCE HIGH) AND/OR B1881 (PASSENGER PRETENSIONER CIRCUIT RESISTANCE HIGH), INDICATING A HIGH RESISTANCE IN THE SAFETY BELT PRETENSIONER CIRCUIT. Read More »
SOME IGNITION SWITCH LOCK CYLINDER ASSEMBLIES MAY EXHIBIT ROUGNESS AND / OR EXCESS EFFORT IN TURNING, KEY DOES NOT FULLY RETURN FROM START, A MALFUNCTION INDICATOR LAMP MAY ILLUMINATE WITH P0500, P1502 AND U1039 STORED IN POWERTRIAN ... Read More »
SOME VEHICLES EQUIPPED WITH A 2.3L ENGINE AND NO AIR CONDITIONING, MAY SET DIAGNOSTIC TROUBLE CODES P1460 (WIDE OPEN THROTTLE AIR CONDITIONER OUTPUT PRIMARY CIRCUIT MALFUNCTION) AND P1474 (LOW FAN CONTROL (LFC) PRIMARY CIRCUIT FAILURE. Read More »
This article supersedes TSB 19-2026 to update the vehicle model years affected. Some 2000 and newer Ford/Lincoln/Mercury vehicles equipped with aluminum body panels may exhibit corrosion concerns appearing as bubbled and/or peeling paint ... Read More »
Some 2000 and newer Ford, Lincoln and Mercury vehicles equipped with aluminum body panels may exhibit corrosion concerns appearing as bubbled and/or peeling paint with or without accompanying white dust. Panel replacement is recommended. Read More »
Some 2000 and newer Ford, Lincoln and Mercury vehicles equipped with aluminum body panels may exhibit corrosion concerns appearing as bubbled and/or peeling paint with or without accompanying white dust. Panel replacement is recommended. Read More »
Some 2000 and newer Ford, Lincoln and Mercury vehicles equipped with aluminum body panels may exhibit corrosion concerns appearing as bubbled and/or peeling paint with or without accompanying white dust. Panel replacement is recommended. Read More »
SUBJECT REGARDING A WHINE NOISE CONDITION FROM THE SPEAKERS WHEN USING THE RADIO OR THE CD WITH THE PIONEER TREMORE / PIONEER ULTIMATE 450 WATT AUDIO SYSTEM. *TT Read More »
SOME VEHICLES EQUIPPED WITH THE 4.0L SOHC ENGINE MAY EXHIBIT A CHECK ENGINE LIGHT ON WITH DIAGNOSTIC TROUBLE CODES P0300 (RANDOM MISFIRE) OR P0301. *TT Read More »
SOME VEHICLES MAY EXHIBIT DRIVEABILITY CONDITIONS AND / OR CHECK ENGINE LAMP ILLUMINATED WITH A DIAGNOSTIC TROUBLE P0455 (GROSS LEAK DETECTED). *TT Read More »
SOME VEHICLES MAY EXHIBIT DRIVEABILTY CONDITIONS AND/OR CHECK ENGINE LAMP ILLUMINATED WITH A DIAGNOSTIC TROUBLE CODE P0455 (GROSS LEAK DETECTED). *TT Read More »
