Technical Service Bulletins (TSBs) for the 2011 Fusion are official communications between Ford & their dealerships that describe processes for troubleshooting or fixing certain common problems.
All vehicle manufacturers are required by U.S. law to make their TSBs available to the public.
Some 2010-2012 Fusion/Milan and 2011-2012 MKZ vehicles equipped with a 2.5L or 3.0L engine and electronic power assist steering (EPAS), a remanufactured replacement steering gear (MU2Z-3V504-ARM) is available which is significantly less ... Read More »
SOME 2010-2016 EPAS EQUIPPED VEHICLES MAY EXHIBIT STEERING RELATED NOISES. THE WORKSHOP MANUAL (WSM) DIAGNOSTIC PROCEDURES HAVE BEEN UPDATED IN SECTION 211-02. WHEN DIAGNOSING AND REPAIRING EPAS STEERING NOISES USE THE UPDATED PROCEDURES. Read More »
LINCOLN/FORD: STEERING SYSTEM SENSES, HALF FRONT LOWER CONTROL ARMS/REARWARD IS EXPERIENCING A HIGHER FRICTION CONDITION AND CAUSING THE INSTRUMENT CLUSTER STABILITY/TRACTION TO ILLUMINATE. MODEL 2011-2012 FUSION, MKZ. Read More »
LINCOLN/FORD: STEERING SYSTEM SENSES, HALF FRONT LOWER CONTROL ARMS/REARWARD IS EXPERIENCING A HIGHER FRICTION CONDITION AND CAUSING THE INSTRUMENT CLUSTER STABILITY/TRACTION TO ILLUMINATE. MODEL 2011-2012 FUSION, MKZ. Read More »
SOME 2008-2017 FORD/MERCURY/LINCOLN VEHICLES EQUIPPED WITH SYNC MAY GENERATE A VHR THAT IDENTIFIES A CONCERN WITH THE BRAKES AND SUSPENSION CATEGORY INDICATING SERVICE IS REQUIRED DUE TO A BRAKE SYSTEM WARNING LAMP BEING ILLUMINATED. Read More »
SOME 2008-2017 FORD/MERCURY/LINCOLN VEHICLES EQUIPPED WITH SYNC MAY GENERATE A VHR THAT IDENTIFIES A CONCERN WITH THE BRAKES AND SUSPENSION CATEGORY INDICATING SERVICE IS REQUIRED DUE TO A BRAKE SYSTEM WARNING LAMP BEING ILLUMINATED. Read More »
CERTAIN 2011-2012 MODEL YEAR FUSION VEHICLES EQUIPPED WITH 2.5L OR 3.0L ENGINES - POWERTRAIN CONTROL MODULE REPROGRAMMING AND CANISTER PURGE VALVE INSPECTION Read More »
The Powertrain Control/Emissions Diagnosis (PC/ED) manual has been revised for diagnosing electronic throttle bodies (ETBs). The ETC_ACT and ETC_DSD PIDs should not used to diagnose possible ETB concerns. Read More »
FORD: DUE TO AN INTERMITTENT LOSS OF RPM OR LACK OF ACCELERATION, IN SOME VEHICLES, WITH ILLUMINATED WRENCH LIGHT, DIAGNOSTIC TROUBLE CODES (DTCS) P2111, P2112 MAY OR MAY NOT BE STORED IN POWERTRAIN CONTROL MODULE (PCM). Read More »
FORD/LINCOLN/MERCURY: SOME VEHICLES MAY EXPERIENCE AN ILLUMINATED MIL OR SAFETY STOP NOW MESSAGE, OR A NO START CONDITION OR POSSIBLE MISFIRE OR ROUGHNESS AT IDLING THROUGH 2000RPM OR A LACK OF ACCELERATION. Read More »
FORD/LINCOLN: A DIAGNOSTIC TROUBLE CODE (DTC) P0A0A (HIGH VOLTAGE SYSTEM INTERLOCK CIRCUIT) SHOWS WHEN CERTAIN VEHICLES EXPERIENCE RED TRIANGLE ON/STOP SAFELY NOW MESSAGE AND/OR A CONDITION OF NO START. Read More »
FORD/MERCURY/LINCOLN: SOME VEHICLES EXHIBIT A COLD WEATHER PHENOMENON WHERE FLUID HAS EXPELLED OUT OF VENT ON REAR DRIVE UNITS (RDU) AND FLUID, ON OCCASION, WOULD BURP OUT. *PE Read More »
When performing any transmission fluid change or topoff involving MotorcraftA? Premium ATF, MERCONA? V has replaced all versions of MotorcraftA? Premium ATF and can be used going forward. Read More »
The Powertrain Control/Emissions Diagnosis (PC/ED) manual has been revised for diagnosing electronic throttle bodies (ETBs). The ETC_ACT and ETC_DSD PIDs should not used to diagnose possible ETB concerns. Read More »
The Powertrain Control/Emissions Diagnosis (PC/ED) manual has been revised for diagnosing electronic throttle bodies (ETBs). The ETC_ACT and ETC_DSD PIDs should not used to diagnose possible ETB concerns. Read More »
FORD/MERCURY/LINCOLN: SOME MODEL YEAR VEHICLES MAY EXHIBIT A MESSAGE WITH A RED TRIANGLE ON AND STOP SAFELY NOW, AND/OR HAVE A DIAGNOSTIC TROUBLE CODE, NO START CONDITION. *PE Read More »
FORD: THE VARIABLE CAMSHAFT TIMING VCT) SOLENOID MOVEMENT MAY BE TEMPORARILY RESTRICTED DUE TO DEBRIS IN ENGINE OIL THAT IS CAUSING DIAGNOSTIC TROUBLE CODES (DTCS). *PE Read More »
FORD: THERE MAY BE A LEAKING/STUCK CANISTER PURGE VALVE WHICH CAN CAUSE MULTIPLE DRIVING SYSTEMS. THE MALFUNCTION LIGHT MAY BE ON WITH OR WITHOUT STORED TROUBLE CODES. *RM Read More »
FORD: THERE MAY BE A HARD START OR ROUGH IDLE ACCOMPANIED WITH TWO TROUBLE CODES. THE PROBLEM MAY HAVE TO DO WITH CAMSHAFT TIMING. 2010-2011 FUSION/ESCAPE/MILAN/MARINER. *RM Read More »
The Powertrain Control/Emissions Diagnosis (PC/ED) manual has been revised for diagnosing electronic throttle bodies (ETBs). The ETC_ACT and ETC_DSD PIDs should not used to diagnose possible ETB concerns. Read More »
ENGINE AND ENGINE COOLING:ENGINE:GASOLINE:BELTS AND ASSOCIATED PULLEYS
The Powertrain Control/Emissions Diagnosis (PC/ED) manual has been revised for diagnosing electronic throttle bodies (ETBs). The ETC_ACT and ETC_DSD PIDs should not used to diagnose possible ETB concerns. Read More »
ENGINE AND ENGINE COOLING:ENGINE:GASOLINE:TURBO/SUPERCHARGER
The Powertrain Control/Emissions Diagnosis (PC/ED) manual has been revised for diagnosing electronic throttle bodies (ETBs). The ETC_ACT and ETC_DSD PIDs should not used to diagnose possible ETB concerns. Read More »
The Powertrain Control/Emissions Diagnosis (PC/ED) manual has been revised for diagnosing electronic throttle bodies (ETBs). The ETC_ACT and ETC_DSD PIDs should not used to diagnose possible ETB concerns. Read More »
ENGINE AND ENGINE COOLING:ENGINE:OTHER FUEL TYPES:TURBO/SUPERCHARGER
The Powertrain Control/Emissions Diagnosis (PC/ED) manual has been revised for diagnosing electronic throttle bodies (ETBs). The ETC_ACT and ETC_DSD PIDs should not used to diagnose possible ETB concerns. Read More »
The Powertrain Control/Emissions Diagnosis (PC/ED) manual has been revised for diagnosing electronic throttle bodies (ETBs). The ETC_ACT and ETC_DSD PIDs should not used to diagnose possible ETB concerns. Read More »
ENGINE AND ENGINE COOLING:COOLING SYSTEM:RADIATOR ASSEMBLY
The Powertrain Control/Emissions Diagnosis (PC/ED) manual has been revised for diagnosing electronic throttle bodies (ETBs). The ETC_ACT and ETC_DSD PIDs should not used to diagnose possible ETB concerns. Read More »
The Powertrain Control/Emissions Diagnosis (PC/ED) manual has been revised for diagnosing electronic throttle bodies (ETBs). The ETC_ACT and ETC_DSD PIDs should not used to diagnose possible ETB concerns. Read More »
ENGINE AND ENGINE COOLING:COOLING SYSTEM:HOSES/LINES/PIPING/FITTINGS
The Powertrain Control/Emissions Diagnosis (PC/ED) manual has been revised for diagnosing electronic throttle bodies (ETBs). The ETC_ACT and ETC_DSD PIDs should not used to diagnose possible ETB concerns. Read More »
The Powertrain Control/Emissions Diagnosis (PC/ED) manual has been revised for diagnosing electronic throttle bodies (ETBs). The ETC_ACT and ETC_DSD PIDs should not used to diagnose possible ETB concerns. Read More »
ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL
The Powertrain Control/Emissions Diagnosis (PC/ED) manual has been revised for diagnosing electronic throttle bodies (ETBs). The ETC_ACT and ETC_DSD PIDs should not used to diagnose possible ETB concerns. Read More »
The Powertrain Control/Emissions Diagnosis (PC/ED) manual has been revised for diagnosing electronic throttle bodies (ETBs). The ETC_ACT and ETC_DSD PIDs should not used to diagnose possible ETB concerns. Read More »
ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL:GAS RECIRCULATION VALVE (EGR VALVE)
The Powertrain Control/Emissions Diagnosis (PC/ED) manual has been revised for diagnosing electronic throttle bodies (ETBs). The ETC_ACT and ETC_DSD PIDs should not used to diagnose possible ETB concerns. Read More »
ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL:CATALYTIC CONVERTOR
The Powertrain Control/Emissions Diagnosis (PC/ED) manual has been revised for diagnosing electronic throttle bodies (ETBs). The ETC_ACT and ETC_DSD PIDs should not used to diagnose possible ETB concerns. Read More »
ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:MANIFOLD/HEADER/MUFFLER/TAIL PIPE
The Powertrain Control/Emissions Diagnosis (PC/ED) manual has been revised for diagnosing electronic throttle bodies (ETBs). The ETC_ACT and ETC_DSD PIDs should not used to diagnose possible ETB concerns. Read More »
On vehicles equipped with an automatic transmission it is imperative that the converter pilot hub be greased with Motorcraft Multi-Purpose Grease Spray XL-5-A even if grease was not applied from the factory. Read More »
6F35 TRANSMISSION - FLUID LEAK AT LEFT SIDE HALFSHAFT SEAL BUILT ON OR BEFORE 10/14/2013 ISSUE Some 2009-2014 Escape, 2009-2011 Mariner, 2010-2014 Fusion, 2010-2011 Milan, 2012-2014 Edge/Explorer, and 2013-2014 Taurus/MKT/MKZ vehicles ... Read More »
Some 2010-2012 Fusion hybrid electric vehicles (HEV), 2010-2011 Milan HEV and 2011-2012 MKZ HEV vehicles may experience reduced electric vehicle operation and increased gasoline engine operation around 10 years of vehicle age and beyond. Read More »
MERCURY/FORD: ON SOME VEHICLES, THERE IS A FLUID LEAKAGE, COMING FROM LEFT HAND (LH) HALFSHAFT SEAL OF THE AUTOMATIC TRANSMISSION AND A SERVICE KIT IS AVAILABLE NOW, FOR REPAIR. MODEL 2009-2012 ESCAPE, MARINER, FUSION, MILAN. Read More »
FORD: ON THE LEFT HAND HALF SHAFT SEAL, THERE IS A FLUID LEAK FROM THE TRANSMISSION BECAUSE OF WEAR ON CASE BUSHING. MODEL 2009-2012 ESCAPE, 2009-2011 MARINER, 2010-2012 FUSION, 2010-2011 MILAN. Read More »
POWER TRAIN:AUTOMATIC TRANSMISSION:CONTROL MODULE (TCM/PCM/TECM)
Some 2010-2012 Fusion hybrid electric vehicles (HEV), 2010-2011 Milan HEV and 2011-2012 MKZ HEV vehicles may experience reduced electric vehicle operation and increased gasoline engine operation around 10 years of vehicle age and beyond. Read More »
FORD/LINCOLN: THERE IS AN EXTENDED WARRANTY COVERAGE FOR THE LOSS OF ABS SPEED SIGNAL RELATED COMMUNICATION THAT DISABLE OBDII SYSTEM MONITORS FOR PCM REPROGRAMMING. MODEL 2011-14 F-SUPER DUTY, ESCAPE, TAURUS, FUSION, MKT, MKZ. Read More »
FORD: DUE TO AN INTERMITTENT LOSS OF RPM OR LACK OF ACCELERATION, IN SOME VEHICLES, WITH ILLUMINATED WRENCH LIGHT, DIAGNOSTIC TROUBLE CODES (DTCS) P2111, P2112 MAY OR MAY NOT BE STORED IN POWERTRAIN CONTROL MODULE (PCM). Read More »
FORD: ENGINE POWER MAY BE REDUCED WITH A HIGH IDLE SPEED. THE ENGINE LIGHT MAY ALSO BE ON WITH A STORED TROUBLE CODE. PROGRAMMING ISSUE. 2010-2011 FUSION/MERUCRY MILAN/LINCOLN MKZ. *RM Read More »
FORD: THERE MAY BE A LOSS OF POWER, HESITATION, SURGE, OR LACK OF THROTTLE RESPONSE WHILE DRIVING. THE BRAKE OVER ACCELERATOR FEATURE MAY BE ACTIVATING. *RM Read More »
FORD: THROTTLE BODY WILL DEVELOP CONTAMINATION ON INTERNAL MOTOR CONTACTS RESULTING IN AN INTERMITTENT ELECTRICAL CONNECTIVITY AND MALFUNCTION INDICATOR LAMP (MIL) OR WRENCH LIGHT WILL ILLUMINATE. Read More »
FORD/LINCOLN: A DIAGNOSTIC TROUBLE CODE (DTC) P0A0A (HIGH VOLTAGE SYSTEM INTERLOCK CIRCUIT) SHOWS WHEN CERTAIN VEHICLES EXPERIENCE RED TRIANGLE ON/STOP SAFELY NOW MESSAGE AND/OR A CONDITION OF NO START. Read More »
LINCOLN/FORD: SOME VEHICLES WILL EXPERIENCE, IN HOT EXTREME AMBIENT TEMPERATURES, A STOP SAFELY NOW OR A MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATED IN PRESENT OF BATTERY ENERGY CONTROL MODULE (BECM) DTC P0A7E AND BECM NEEDS REPLACED, ... Read More »
FORD: ENGINE POWER MAY BE REDUCED WITH A HIGH IDLE SPEED. THE ENGINE LIGHT MAY ALSO BE ON WITH A STORED TROUBLE CODE. PROGRAMMING ISSUE. 2010-2011 FUSION/MERUCRY MILAN/LINCOLN MKZ. *RM Read More »
FORD: THROTTLE BODY WILL DEVELOP CONTAMINATION ON INTERNAL MOTOR CONTACTS RESULTING IN AN INTERMITTENT ELECTRICAL CONNECTIVITY AND MALFUNCTION INDICATOR LAMP (MIL) OR WRENCH LIGHT WILL ILLUMINATE. Read More »
FORD/MERCURY/LINCOLN: SOME MODEL YEAR VEHICLES MAY EXHIBIT A MESSAGE WITH A RED TRIANGLE ON AND STOP SAFELY NOW, AND/OR HAVE A DIAGNOSTIC TROUBLE CODE, NO START CONDITION. *PE Read More »
LINCOLN/FORD: STEERING SYSTEM SENSES, HALF FRONT LOWER CONTROL ARMS/REARWARD IS EXPERIENCING A HIGHER FRICTION CONDITION AND CAUSING THE INSTRUMENT CLUSTER STABILITY/TRACTION TO ILLUMINATE. MODEL 2011-2012 FUSION, MKZ. Read More »
LINCOLN/FORD: SOME VEHICLES WILL EXPERIENCE, IN HOT EXTREME AMBIENT TEMPERATURES, A STOP SAFELY NOW OR A MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATED IN PRESENT OF BATTERY ENERGY CONTROL MODULE (BECM) DTC P0A7E AND BECM NEEDS REPLACED, ... Read More »
FORD/LINCOLN: THERE IS AN EXTENDED WARRANTY COVERAGE FOR THE LOSS OF ABS SPEED SIGNAL RELATED COMMUNICATION THAT DISABLE OBDII SYSTEM MONITORS FOR PCM REPROGRAMMING. MODEL 2011-14 F-SUPER DUTY, ESCAPE, TAURUS, FUSION, MKT, MKZ. Read More »
LINCOLN/FORD: IN POWERTRAIN CONTROL MODULE (PCM), THAT ALLOWS ANTI LOCK BRAKE SYSTEM (ABS) AND OUTPUT SHAFT SPEED SENSOR (OSS) SIGNAL FAULTS, A SOFTWARE ERROR HAS OCCUR AND DISABLED ON BOARD DIAGNOSTIC (OBD) MONITORS WITH NO ILLUMINATION ... Read More »
FORD: ENGINE POWER MAY BE REDUCED WITH A HIGH IDLE SPEED. THE ENGINE LIGHT MAY ALSO BE ON WITH A STORED TROUBLE CODE. PROGRAMMING ISSUE. 2010-2011 FUSION/MERUCRY MILAN/LINCOLN MKZ. *RM Read More »
Some 2010-2012 Fusion hybrid electric vehicles (HEV), 2010-2011 Milan HEV and 2011-2012 MKZ HEV vehicles may experience reduced electric vehicle operation and increased gasoline engine operation around 10 years of vehicle age and beyond. Read More »
Some 2010-2020 vehicles may exhibit distorted glass with a subtle orange peel pattern or streaking etched into the surface. This is caused by hydrofluoric acid which is used in some car wash solutions as a cleaning agent. Read More »
Some 2010-2020 vehicles may exhibit distorted glass with a subtle orange peel pattern or streaking etched into the surface. This is caused by hydrofluoric acid which is used in some car wash solutions as a cleaning agent. Read More »
FORD: NO SERVICE ACTION IS RECOMMENDED FOR THIS CONDITION. PLEASE USE AT YOUR DISCRETION. VARIOUS 2010-2015 VEHICLES MAY EXPERIENCE A TURBULENCE NOISE, SIMILAR TO AN HELICOPTER NOISE, AT HIGHWAY SPEEDS WHEN THE REAR DOOR WINDOW(S) OR ... Read More »
Certain 2005-2014 Mustang, 2005-2006 GT, 2004-2011 Ranger, 2006-2012 Fusion and MKZ/Zephyr, 2006-2011 Milan, and 2007-2010 Edge & MKX Vehicles Driver & Passenger Airbag Module Quality Control Inspection REASON FOR THIS SUPPLEMENT ... Read More »
Certain 2005-2014 Mustang, 2005-2006 GT, 2004-2011 Ranger, 2006-2012 Fusion & MKZ/Zephyr, 2006-2011 Milan, and 2007-2010 Edge & MKX Vehicles Driver & Passenger Airbag Module Quality Control Inspection: Ford Motor Company has determined ... Read More »
All accessory stick-on keyless entry keypads come with a wallet card containing the master code. If the accessory keypad was factory installed, this card will be placed in the glove box and should be handed to the vehicles owner during ... Read More »
Replacing the original equipment SYNC/Navigation system with either an aftermarket SYNC/Navigation kit or modifying original SYNC/Navigation parts to provide additional features is not recommended nor supported on any Ford, Mercury or ... Read More »
REPLACING THE ORIGINAL EQUIPMENT SYNC/NAVIGATION SYSTEM WITH EITHER AN AFTERMARKET SYNC/NAVIGATION KIT OR MODIFYING ORIGINAL SYNC/NAVIGATION PARTS TO PROVIDE ADDITIONAL FEATURES IS NOT RECOMMENDED NOR SUPPORTED ON ANY FORD, MERCURY OR ... Read More »
SOME 2010-2012 FUSION HYBRID, MILAN HYBRID AND MKZ HYBRID VEHICLES MAY EXHIBIT AN ILLUMINATED MALFUNCTION INDICATOR LAMP (MIL) WITH DIAGNOSTIC TROUBLE CODES (DTCS) P0030 AND/OR P0130. Read More »
FORD: THE THROTTLE BODY INTERNAL MOTOR CONTACTS MAY BE CONTAMINATED, RESULTING IN AN ELECTRICAL, INTERMITTENT, CONNECTIVITY, CAUSING MALFUNCTION INDICATOR LAMP (MIL) OR WRENCH LIGHT TO BE ILLUMINATED. Read More »
FORD: ON VARIOUS VEHICLES WITH MY TOUCH,AFTER ANY APIM PROGRAMMING, REPLACEMENT OR DISCONNECT FROM FRONT DISPLAY INTERFACE MODULE (FDIM), TOUCHSCREEN CALIBRATION MUST BE PERFORMED. MODEL YEARS 2011-2013. NO MODELS LISTED. Read More »
2010-2018 various vehicles equipped with SYNC or SYNC 3 may not function when attempting to find or use the Spotify app via AppLink. As of an update released on 1/15/2018 Spotify will no longer be supporting their AppLink integration. Read More »
FORD: ON VARIOUS VEHICLES WITH MY TOUCH,AFTER ANY APIM PROGRAMMING, REPLACEMENT OR DISCONNECT FROM FRONT DISPLAY INTERFACE MODULE (FDIM), TOUCHSCREEN CALIBRATION MUST BE PERFORMED. MODEL YEARS 2011-2013. NO MODELS LISTED. Read More »
