Technical Service Bulletins (TSBs) for the 2010 Fusion are official communications between Ford & their dealerships that describe processes for troubleshooting or fixing certain common problems.
All vehicle manufacturers are required by U.S. law to make their TSBs available to the public.
SOME 2010-2016 EPAS EQUIPPED VEHICLES MAY EXHIBIT STEERING RELATED NOISES. THE WORKSHOP MANUAL (WSM) DIAGNOSTIC PROCEDURES HAVE BEEN UPDATED IN SECTION 211-02. WHEN DIAGNOSING AND REPAIRING EPAS STEERING NOISES USE THE UPDATED PROCEDURES. Read More »
SOME 2008-2017 FORD/MERCURY/LINCOLN VEHICLES EQUIPPED WITH SYNC MAY GENERATE A VHR THAT IDENTIFIES A CONCERN WITH THE BRAKES AND SUSPENSION CATEGORY INDICATING SERVICE IS REQUIRED DUE TO A BRAKE SYSTEM WARNING LAMP BEING ILLUMINATED. Read More »
SOME 2008-2017 FORD/MERCURY/LINCOLN VEHICLES EQUIPPED WITH SYNC MAY GENERATE A VHR THAT IDENTIFIES A CONCERN WITH THE BRAKES AND SUSPENSION CATEGORY INDICATING SERVICE IS REQUIRED DUE TO A BRAKE SYSTEM WARNING LAMP BEING ILLUMINATED. Read More »
FORD/MERCURY: SOME VEHICLES MAY EXPERIENCE ELECTRONIC NOISE ON THE MAIN POWER FEED CIRCUIT TO THE BRAKE CONTROL MODULE WITHIN THE 14290 WIRING HARNESS. *PE Read More »
FORD/MERCURY: SOME VEHICLES MAY EXPERIENCE ELECTRONIC NOISE ON THE MAIN POWER FEED CIRCUIT TO THE BRAKE CONTROL MODULE WITHIN THE 14290 WIRING HARNESS. *PE Read More »
SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP:CONTROL UNIT/MODULE
FORD/MERCURY: SOME VEHICLES MAY EXPERIENCE ELECTRONIC NOISE ON THE MAIN POWER FEED CIRCUIT TO THE BRAKE CONTROL MODULE WITHIN THE 14290 WIRING HARNESS. *PE Read More »
SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP:ABS WARNING LIGHT
FORD\MERCURY SERVICE CAMPAIGN: SEE DOCUMENT SEARCH BUTTON FOR OWNER LETTER. ON SOME AFFECTED VEHICLES, THE BRAKE SYSTEM SOFTWARE MAY UNNECESSARILY CAUSE THE REGENERATIVE BRAKE SYSTEM TO TRANSITION TO CONVENTIONAL BRAKES WITH FULL ... Read More »
FORD\MERCURY SERVICE CAMPAIGN: SEE DOCUMENT SEARCH BUTTON FOR OWNER LETTER. ON SOME AFFECTED VEHICLES, THE BRAKE SYSTEM SOFTWARE MAY UNNECESSARILY CAUSE THE REGENERATIVE BRAKE SYSTEM TO TRANSITION TO CONVENTIONAL BRAKES WITH FULL ... Read More »
FORD: DUE TO AN INTERMITTENT LOSS OF RPM OR LACK OF ACCELERATION, IN SOME VEHICLES, WITH ILLUMINATED WRENCH LIGHT, DIAGNOSTIC TROUBLE CODES (DTCS) P2111, P2112 MAY OR MAY NOT BE STORED IN POWERTRAIN CONTROL MODULE (PCM). Read More »
FORD/LINCOLN/MERCURY: SOME VEHICLES MAY EXPERIENCE AN ILLUMINATED MIL OR SAFETY STOP NOW MESSAGE, OR A NO START CONDITION OR POSSIBLE MISFIRE OR ROUGHNESS AT IDLING THROUGH 2000RPM OR A LACK OF ACCELERATION. Read More »
FORD/LINCOLN: A DIAGNOSTIC TROUBLE CODE (DTC) P0A0A (HIGH VOLTAGE SYSTEM INTERLOCK CIRCUIT) SHOWS WHEN CERTAIN VEHICLES EXPERIENCE RED TRIANGLE ON/STOP SAFELY NOW MESSAGE AND/OR A CONDITION OF NO START. Read More »
FORD/MERCURY/LINCOLN: SOME MODEL YEAR VEHICLES MAY EXHIBIT A MESSAGE WITH A RED TRIANGLE ON AND STOP SAFELY NOW, AND/OR HAVE A DIAGNOSTIC TROUBLE CODE, NO START CONDITION. *PE Read More »
FORD: THE VARIABLE CAMSHAFT TIMING VCT) SOLENOID MOVEMENT MAY BE TEMPORARILY RESTRICTED DUE TO DEBRIS IN ENGINE OIL THAT IS CAUSING DIAGNOSTIC TROUBLE CODES (DTCS). *PE Read More »
FORD: THERE MAY BE A LEAKING/STUCK CANISTER PURGE VALVE WHICH CAN CAUSE MULTIPLE DRIVING SYSTEMS. THE MALFUNCTION LIGHT MAY BE ON WITH OR WITHOUT STORED TROUBLE CODES. *RM Read More »
FORD: THERE MAY BE A HARD START OR ROUGH IDLE ACCOMPANIED WITH TWO TROUBLE CODES. THE PROBLEM MAY HAVE TO DO WITH CAMSHAFT TIMING. 2010-2011 FUSION/ESCAPE/MILAN/MARINER. *RM Read More »
6F35 TRANSMISSION - FLUID LEAK AT LEFT SIDE HALFSHAFT SEAL BUILT ON OR BEFORE 10/14/2013 ISSUE Some 2009-2014 Escape, 2009-2011 Mariner, 2010-2014 Fusion, 2010-2011 Milan, 2012-2014 Edge/Explorer, and 2013-2014 Taurus/MKT/MKZ vehicles ... Read More »
MERCURY/FORD: ON SOME VEHICLES, THERE IS A FLUID LEAKAGE, COMING FROM LEFT HAND (LH) HALFSHAFT SEAL OF THE AUTOMATIC TRANSMISSION AND A SERVICE KIT IS AVAILABLE NOW, FOR REPAIR. MODEL 2009-2012 ESCAPE, MARINER, FUSION, MILAN. Read More »
FORD: ON THE LEFT HAND HALF SHAFT SEAL, THERE IS A FLUID LEAK FROM THE TRANSMISSION BECAUSE OF WEAR ON CASE BUSHING. MODEL 2009-2012 ESCAPE, 2009-2011 MARINER, 2010-2012 FUSION, 2010-2011 MILAN. Read More »
FORD: DUE TO AN INTERMITTENT LOSS OF RPM OR LACK OF ACCELERATION, IN SOME VEHICLES, WITH ILLUMINATED WRENCH LIGHT, DIAGNOSTIC TROUBLE CODES (DTCS) P2111, P2112 MAY OR MAY NOT BE STORED IN POWERTRAIN CONTROL MODULE (PCM). Read More »
FORD\MERCURY SERVICE CAMPAIGN: SEE DOCUMENT SEARCH BUTTON FOR OWNER LETTER. ON SOME AFFECTED VEHICLES, THE BRAKE SYSTEM SOFTWARE MAY UNNECESSARILY CAUSE THE REGENERATIVE BRAKE SYSTEM TO TRANSITION TO CONVENTIONAL BRAKES WITH FULL ... Read More »
FORD: ENGINE POWER MAY BE REDUCED WITH A HIGH IDLE SPEED. THE ENGINE LIGHT MAY ALSO BE ON WITH A STORED TROUBLE CODE. PROGRAMMING ISSUE. 2010-2011 FUSION/MERUCRY MILAN/LINCOLN MKZ. *RM Read More »
FORD: THERE MAY BE A LOSS OF POWER, HESITATION, SURGE, OR LACK OF THROTTLE RESPONSE WHILE DRIVING. THE BRAKE OVER ACCELERATOR FEATURE MAY BE ACTIVATING. *RM Read More »
FORD: THROTTLE BODY WILL DEVELOP CONTAMINATION ON INTERNAL MOTOR CONTACTS RESULTING IN AN INTERMITTENT ELECTRICAL CONNECTIVITY AND MALFUNCTION INDICATOR LAMP (MIL) OR WRENCH LIGHT WILL ILLUMINATE. Read More »
FORD/LINCOLN: A DIAGNOSTIC TROUBLE CODE (DTC) P0A0A (HIGH VOLTAGE SYSTEM INTERLOCK CIRCUIT) SHOWS WHEN CERTAIN VEHICLES EXPERIENCE RED TRIANGLE ON/STOP SAFELY NOW MESSAGE AND/OR A CONDITION OF NO START. Read More »
LINCOLN/FORD: SOME VEHICLES WILL EXPERIENCE, IN HOT EXTREME AMBIENT TEMPERATURES, A STOP SAFELY NOW OR A MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATED IN PRESENT OF BATTERY ENERGY CONTROL MODULE (BECM) DTC P0A7E AND BECM NEEDS REPLACED, ... Read More »
FORD: ENGINE POWER MAY BE REDUCED WITH A HIGH IDLE SPEED. THE ENGINE LIGHT MAY ALSO BE ON WITH A STORED TROUBLE CODE. PROGRAMMING ISSUE. 2010-2011 FUSION/MERUCRY MILAN/LINCOLN MKZ. *RM Read More »
FORD: THROTTLE BODY WILL DEVELOP CONTAMINATION ON INTERNAL MOTOR CONTACTS RESULTING IN AN INTERMITTENT ELECTRICAL CONNECTIVITY AND MALFUNCTION INDICATOR LAMP (MIL) OR WRENCH LIGHT WILL ILLUMINATE. Read More »
FORD/MERCURY/LINCOLN: SOME MODEL YEAR VEHICLES MAY EXHIBIT A MESSAGE WITH A RED TRIANGLE ON AND STOP SAFELY NOW, AND/OR HAVE A DIAGNOSTIC TROUBLE CODE, NO START CONDITION. *PE Read More »
LINCOLN/FORD: SOME VEHICLES WILL EXPERIENCE, IN HOT EXTREME AMBIENT TEMPERATURES, A STOP SAFELY NOW OR A MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATED IN PRESENT OF BATTERY ENERGY CONTROL MODULE (BECM) DTC P0A7E AND BECM NEEDS REPLACED, ... Read More »
FORD\MERCURY SERVICE CAMPAIGN: SEE DOCUMENT SEARCH BUTTON FOR OWNER LETTER. ON SOME AFFECTED VEHICLES, THE BRAKE SYSTEM SOFTWARE MAY UNNECESSARILY CAUSE THE REGENERATIVE BRAKE SYSTEM TO TRANSITION TO CONVENTIONAL BRAKES WITH FULL ... Read More »
FORD: ENGINE POWER MAY BE REDUCED WITH A HIGH IDLE SPEED. THE ENGINE LIGHT MAY ALSO BE ON WITH A STORED TROUBLE CODE. PROGRAMMING ISSUE. 2010-2011 FUSION/MERUCRY MILAN/LINCOLN MKZ. *RM Read More »
FORD/MERCURY: SOME VEHICLES MAY EXPERIENCE ELECTRONIC NOISE ON THE MAIN POWER FEED CIRCUIT TO THE BRAKE CONTROL MODULE WITHIN THE 14290 WIRING HARNESS. *PE Read More »
FORD: NO SERVICE ACTION IS RECOMMENDED FOR THIS CONDITION. PLEASE USE AT YOUR DISCRETION. VARIOUS 2010-2015 VEHICLES MAY EXPERIENCE A TURBULENCE NOISE, SIMILAR TO AN HELICOPTER NOISE, AT HIGHWAY SPEEDS WHEN THE REAR DOOR WINDOW(S) OR ... Read More »
REPLACING THE ORIGINAL EQUIPMENT SYNC/NAVIGATION SYSTEM WITH EITHER AN AFTERMARKET SYNC/NAVIGATION KIT OR MODIFYING ORIGINAL SYNC/NAVIGATION PARTS TO PROVIDE ADDITIONAL FEATURES IS NOT RECOMMENDED NOR SUPPORTED ON ANY FORD, MERCURY OR ... Read More »
SOME 2010-2012 FUSION HYBRID, MILAN HYBRID AND MKZ HYBRID VEHICLES MAY EXHIBIT AN ILLUMINATED MALFUNCTION INDICATOR LAMP (MIL) WITH DIAGNOSTIC TROUBLE CODES (DTCS) P0030 AND/OR P0130. Read More »
FORD: IN VALVE BODY, A WORN SOLENOID PRESSURE REGULATOR VALVE HAS DIAGNOSTIC TROUBLE CODE (DTC) P0735 STORED AND INDICATION OF REPAIR HISTORY WAS THE VALVE BODY WAS NOT REPLACED PREVIOUSLY. Read More »
FORD: THE THROTTLE BODY INTERNAL MOTOR CONTACTS MAY BE CONTAMINATED, RESULTING IN AN ELECTRICAL, INTERMITTENT, CONNECTIVITY, CAUSING MALFUNCTION INDICATOR LAMP (MIL) OR WRENCH LIGHT TO BE ILLUMINATED. Read More »
