Technical Service Bulletins (TSBs) for the 2002 Focus are official communications between Ford & their dealerships that describe processes for troubleshooting or fixing certain common problems.
All vehicle manufacturers are required by U.S. law to make their TSBs available to the public.
FRONT END CREAKING, CRUNCHING, GRINDING AND/OR RATTLING NOISE FROM THE FRONT SUSPENSION WHILE DRIVING AT SLOW SPEEDS AND/OR WHILE TURNING. *TT *MJ Read More »
FRONT END CREAKING, CRUNCHING, GRINDING AND OR RATTLING NOISE FROM THE FRONT SUSPENSION WHILE DRIVING AT SLOW SPEEDS AND/OR WHILE TURNING. *TT Read More »
FORD: DUE TO HIGH CORROSION AREAS, WHERE VEHICLES ARE OPERATED FOR EXTENDED PERIODS, LOWER CONTROL ARM (LCA) CAN SEPARATE FROM FORWARD ATTACHMENT OF SUBFRAME. MODEL 2001-04 ESCAPE. *PE Read More »
LIGHT RATTLING/CHUCKING NOISE FROM THE REAR SUSPENSION WHILE DRIVING OVER SMALL REPETITIVE BUMPS (WASHBOARD) AT SPEEDS LESS THAN 30 MPH. *TT Read More »
VEHICLES NOT EQUIPPED WITH ANTI-LOCK BRAKE SYSTEM (ABS) MAY HAVE THE RED BRAKE LIGHT AND AMBER ABS LIGHT ON AFTER HYBRID ELECTRONC CLUSTER (HEC - INSTRUMENT CLUSTER) REPLACEMENT. *TT Read More »
MALFUNCTION INDICATOR LAMP ON WITH OR WITHOUT ROUGH RUNNING, LACK OF POWER, SURGE OR POOR FUEL ECONOMY WITH DIAGNOSTIC TROUBLE CODES P0401, P0402, P1400, P1401. *TT *JB Read More »
RUNS ROUGH AND/OR MALFUNCTION INDICATOR LAMP (MIL) ON CONDITION WITH DIAGNOSTIC TROUBLE CODES (DTCS) P402 AND/OR P0403 (EGR FLOW EXCESSIVE DETECTED/EGR CONTROL CIRCUIT) IN WET WEATHER OR IN A CAR WASH. Read More »
ROUGH IDLE, ROLLING IDLE, STALL, HIGH IDLE, OR BACK FIRE MAINLY AFTER A COLD START. ALSO HESITATION OR SURGE AT STEADY CRUISE, OR MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATED CONDITION. Read More »
STREAMLINED DIAGNOSTIC PROCEDURE FOR VEHICLES WITH MALFUNCTION INDICATOR LAMP (MIL) ON AND DIAGNOSTIC TROUBLE CODES (DTCS) P0401, P0402, P1400 OR P1401, OR RUNS ROUGH, LACKS POWER, SURGE, POOR FUEL ECONOMY, AND THE ABOVE LISTED DTCS ... Read More »
SOME ENGINE ASSEMBLIES WITH ALUMINUM CYLINDER HEADS REPAIRED IN-VEHILE HAVE BEEN FOUND TO LEAK COOLANT AND/OR OIL FROM THE CYLINDER HEAD GASKET AREA. *TT Read More »
SOME VEHICLES MAY EXHIBIT VACUUM OR AIR LEAKS IN THE INTAKE MANIFOLD AND / OR ENGINE SYSTEM CAUSING DIAGNOSTIC TROUBLE CODES P0171 AND OR P0174. *TT Read More »
ENGINE AND ENGINE COOLING:ENGINE:GASOLINE:BELTS AND ASSOCIATED PULLEYS
CUSTOMER SATISFACTION PROGRAM 02M01 SUPPLEMENT #4. CERTAIN FORD 2000 THROUGH 2003 VEHICLES EQUIPPED WITH A TUBE-MOUNTED EGR PRESSURE SENSOR - ADDITIONAL EGR PRESSURE SENSOR WARRANTY COVERAGE. *TT SUPPLEMENT #3. Read More »
ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:MANIFOLD/HEADER/MUFFLER/TAIL PIPE
A HALFSHAFT BEARING NOISE (WHINE / MOAN, WHISTLING, HUMMING, DRUMMING OR RATTLING) FROM THE DRIVETRAIN WHICH APPEARS TO BE EMANATING FROM THE TRANSMISSION. *JB Read More »
MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATED - SYSTEM LEAN DIAGNOSTIC TROUBLE CODES (DTC'S) - SERVICE TIPS. VARIOUS MODELS INCLUDING 2004 F-SERIES. *TT Read More »
STREAMLINED DIAGNOSTIC PROCEDURE FOR VEHICLES WITH MALFUNCTION INDICATOR LAMP (MIL) ON AND DIAGNOSTIC TROUBLE CODES (DTCS) P0401, P0402, P1400 OR P1401. ADDITIONAL SYMPTOMS MAY INCLUDE RUNS ROUGH, LACKS POWER, SURGE, POOR FUEL ECONOMY. Read More »
ROUGH IDLE, LOW POWER AND / OR STALL AT IDLE, A MALFUNCTION INDICATOR LAMP ILLUMINATED AND DIAGNOSTIC TROUBLE CODES P0300 THROUGH P0304 STORED IN MEMORY. *TT Read More »
STREAMLINED DIAGNOSTIC PROCEDURE FOR VEHICLES WITH MALFUNCTION INDICATOR LAMP ON AND DIAGNOSTIC TROUBLE CODES (DTCS) P0401, P0402, P1400 OR P1401. ADDITIONAL SYMPTOMS MAY INCLUDE RUNS ROUGH, LACKS POWER, SURGE, POOR FUEL ECONOMY. Read More »
HARSH TRANSMISSION ENGAGEMENT WITH POSSIBLE MALFUNCTION INDICATOR LAMP (MIL) ON AND DIAGNOSTIC TROUBLE CODE (DTC) P0705 (TR CIRCUIT FAILURE). *TT Read More »
SOME VEHICLES MAY EXHIBIT A VERTICAL CRACK IN THE OUTSIDE MIRROR GLASS WITH NO VISIBLE SIGNS OF IMPACT, ESPECIALLY DURING COLD AMBIENT TEMPERATURES. *TT Read More »
WATER IN CLIMATE CONTROL HEATER BLOWER MOTOR CASE, WHICH CAN BE ASSOCIATED WITH AN INOPERABLE HEATER BLOWER MOTOR RESISTER, BLOWER MOTOR, OR A BLOWN BLOWER MOTOR FUSE. *TT Read More »
AIRBAG LAMP ILLUMINATED WITH DIAGNOSTIC TROUBLE CODES (DTCS) B1932 (AIR BAG DRIVER CIRCUIT OPEN) OR B2232 (AIR BAG DRIVER CIRCUIT OPEN - LOOP #2). *TT Read More »
SOME VEHICLES MAY EXHIBIT A LOCKED REAR SEAT BELT RETRACTOR AFTER MOVING THE REAR SEAT FROM THE FOLD DOWN POSITION TO THE SEATING POSITION. *TT Read More »
FORD: DUE TO HIGH CORROSION AREAS, WHERE VEHICLES ARE OPERATED FOR EXTENDED PERIODS, LOWER CONTROL ARM (LCA) CAN SEPARATE FROM FORWARD ATTACHMENT OF SUBFRAME. MODEL 2001-04 ESCAPE. *PE Read More »
FORD: REAR DOOR LATCHES ARE EXPERIENCING CORROSION IN PAWL PIVOT AREA THAT PREVENT PROPER ENGAGEMENT OF PAWL INTO CATCH, WHEN OPERATED IN AREAS CAUSING HIGH CORROSION. MODEL 2000-05 FOCUS. *PE Read More »
For 2000-2005 Focus vehicles built on or before 1/26/2005 Safety Recall 05S27 has been issued for vehicles that are operated in high corrosion areas for an extended period, where the rear door latches may experience corrosion in the pawl ... Read More »
FORD: REAR DOOR LATCHES ARE EXPERIENCING CORROSION IN PAWL PIVOT AREA THAT PREVENT PROPER ENGAGEMENT OF PAWL INTO CATCH, WHEN OPERATED IN AREAS CAUSING HIGH CORROSION. MODEL 2000-05 FOCUS. *PE Read More »
FORD: ON SOME VEHICLES, OPERATING FOR AN EXTENDED TIME IN HIGH CORROSION AREA, A SAFETY RECALL 05S27 WAS ISSUED, WHERE REAR DOOR LATCHES EXPERIENCE CORROSION IN PAWL PIVOT AREA PREVENTING PROPER ENGAGEMENT OF PAWL INTO CATCH. Read More »
SOME SVT BUILT PRIOR TO 3/27/2002 ARE EQUIPPED WITH FRONT SEAT BACK TRIM COVER AND FOAM PAD SEAT BACK WITH VELCRO TO RETAIN THE TRIM COVER UNDER THE SEAT. *TT Read More »
SOME VEHICLES EQUIPPED WITH AN AUTOMATIC TRANSAXLE AND 2.0L ZETEC ENGINE MAY EXHIBIT A MALFUNCTION INDICATOR LAMP ILLUMINATED WITH DIAGNOSTIC TROUBLE CODE P0122, THROTTLE POSITION CIRCUIT LOW INPUT. Read More »
SOME 2001 VEHICLES EQUIPPED WITH A 2.0L SPI ENGINE MAY EXHIBIT A PULSING OR TICKING NOISE ORIGINATING FROM THE ENGINE COMPARTMENT AND / OR MAY HAVE A MALFUNCTION INDICATOR LAMP LIGHT ON WITH DIAGNOSTIC TROUBLE CODE P0401 OR P0402 CODE. Read More »
SOME VEHICLES EQUIPPED WITH THE 2.0L SPI ENGINE MAY EXHIBIT A MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATED AND DIAGNOSTIC TROUBLE CODES (DTC) P0300 THROUGH P0304 STORED. *TT Read More »
