Technical Service Bulletins (TSBs) for the 1999 F-550 are official communications between Ford & their dealerships that describe processes for troubleshooting or fixing certain common problems.
All vehicle manufacturers are required by U.S. law to make their TSBs available to the public.
A SLOW RELEASE OF THE HUBS, AT TIMES, WHICH MAY BE REGARDED A NOT NORMAL BY THE OPERATOR. SLOW RELEASE OF THE HUBLOCKS IS NOT CONSIDERED ABNORMAL FOR THIS SYSTEM. Read More »
CLEAR GEL-LIKE SUBSTANCE IN THE HYDRAULIC BRAKE MASTER CYLINDER RESERVOIR. THIS SUBSTANCE IS A SILICONE BASE LUBRICANT USED DURING ASSEMBLY OF THE MASTER CYLINDER. *TT Read More »
ALL VEHICLES WITH ANTILOCK BRAKE MODULE CONCERNS THAT REQUIRE A MODULE REPLACEMENT, THE TECHNICIAN MUST CALL FOR APPROVAL BEFORE REMOVING AND / OR REPLACING THE MODULE. *TT Read More »
SERVICE BRAKES, AIR:SUPPLY:LOW PRESSURE WARNING:SWITCH
JERR-DAN: ANTI STALL FEATURE FOR FORD F SERIES LIGHT DUTY CHASSIS WITH V10 GAS ENGINE AND AN ENGINE DRIVE CLUTCH PUMP. MODEL YEARS UNKNOWN. *PE Read More »
ROUGH IDLE, MISS AND VARIOUS OTHER DRIVEABILITY CONCERNS ON VEHICLES WITH 7.3L DIT ENGINE. THIS MAY BE RELATED TO INJECTOR BORE SCUFFING CAUSED BY FUEL QUALITY ISSUES. *TT Read More »
SOME VEHICLES BUILT 7/1998 TO 6/1999 EQUIPPED WITH A 4.6 / 5.4L WINSOR BUILT ENGINES MAY EXHIBIT AN OIL LEAK FROM THE CYLINDER HEAT GASKET AREA. *TT Read More »
SOME VEHICLES BUILT 7/1998 TO 6/1999 EQUIPPED WITH A 4.6 / 5.4L WINDSOR BUILT ENGINE MAY EXHIBIT AN OIL LEAK FROM THE CYLINDER HEAD GASKET AREA. *TT Read More »
SOME VEHICLES BUILT 7/1998 TO 6/1999 EQUIPPED WITH A 4.6 / 5.4L WINDSOR BUILT ENGINES MAY EXHIBIT AN OIL LEAK FROM THE CYLINDER HEAD GASKET AREA. *TT Read More »
SOME SUPER DUTY TRUCKS EQUIPPED WITH THE 7.3L DIT ENGINE MAY EXHIBIT A LACK OF POWER AND / OR A WHISTLE NOISE COMING FROM THE ENGINE COMPARTMENT. *TT Read More »
FORD: CERTAIN 1999-2001 MODEL YEAR VEHICLES UP TO 6000 LB GVWR REGISTERED IN NEW YORK AND CERTAIN 2001 VEHICLES UP TO 6000 LB GVWR REGISTERED IN THE STATE OF MAINE, CERTIFIED FOR SALE IN CALIFORNIA-FEDERAL EMISSION WARRANTY REFUND. Read More »
FORD: CERTAIN 1999-2001 MODEL YEAR VEHICLES UP TO 6000 LB GVWR REGISTERED IN NEW YORK AND CERTAIN 2001 VEHICLES UP TO 6000 LB GVWR REGISTERED IN THE STATE OF MAINE, CERTIFIED FOR SALE IN CALIFORNIA-FEDERAL EMISSION WARRANTY REFUND. Read More »
EMISSION RECALL FOR VEHICLES THAT WERE BUILT WITH A FUEL FILLER-VALVE WHICH COULD LEAK WHILE THE VEHICLE IS BEING OPERATED WHICH CAN EXCEED EVAPORATIVE EMISSIONS STANDARDS. *TT Read More »
JERR-DAN: ANTI STALL FEATURE FOR FORD F SERIES LIGHT DUTY CHASSIS WITH V10 GAS ENGINE AND AN ENGINE DRIVE CLUTCH PUMP. MODEL YEARS UNKNOWN. *PE Read More »
FORD MOTOR COMPANY HAS RELEASED A NEW ELECTRICAL GREASE ( F8AZ - 19G208-AA ) TO REDUCE THE POSSIBILITY OF MOISTURE CORROSION AT THE TERMINALS. *YC Read More »
FOR ALL VEHICLES WITH GENERIC ELECTRONIC MODULE (GEM) CONCERNS THAT REQUIRE A MODULE REPLACEMENT, THE TECHNICIAN MUST CALL FOR APPROVAL BEFORE REMOVING AND / OR REPLACING THE MODULE. *TT Read More »
SOME VEHICLES EQUIPPED WITH 7.3L DI ENGINE MAY EXHIBIT FALSE DIAGNOSTIC TROUBLE CODES P1105, P1106 (UPPER AND LOWER ALTERNATOR FAULTS). *TT Read More »
INFORMATION REGARDING A NEW SERVICE PART THAT HAS BEEN RELEASED FOR THE LICENSE PLATE LIGHT CIRCIUT WHICH WILL REDUCE THE COST OF REPAIR. *MJS Read More »
VEHICLE EQUIPED WITH EITHER MANUAL OR ELECTRONIC SHIFT 4X4 SYSTEM MAY EXHIBIT A VIBRATION OR A RATCHETING NOISE FROM THE FRONT OF THE VEHICLE. ANOTHER SYMPTOM MAY BE DESCRIBED AS FRONT HUBLOCKS NOT RELEASING. Read More »
INFORMATION ON IDENTIFYING NON-APPROVED / ALTERNATE REFRIGERANTS WHICH COULD CAUSE SAFETY, AND PERFORMANCE CONCERNS IF INSTALLED IN FORD A/C SYSTEMS. *TT Read More »
SOME VEHICLES MAY EXHIBIT DRIVEABILITY CONDITIONS AND / OR CHECK ENGINE LAMP ILLUMINATED WITH A DIAGNOSTIC TROUBLE P0455 (GROSS LEAK DETECTED). *TT Read More »
SOME VEHICLES MAY EXHIBIT DRIVEABILTY CONDITIONS AND/OR CHECK ENGINE LAMP ILLUMINATED WITH A DIAGNOSTIC TROUBLE CODE P0455 (GROSS LEAK DETECTED). *TT Read More »
SOME VEHICLES MAY RETREIEVE MALFUNCTION INDICATOR LAMP (MIL) WITH DIAGNOSTIC TROUBLE CODE (DTC) P0351 AND / OR P0357 (COIL PRIMARY CIRCUIT MALFUNCTION). *TT Read More »
ON SOME SUPER DUTY VEHICLES, THE CUPHOLDER MAY NOT FULLY RETRACT INTO THE CUPHOLDER INSTRUMENT PANEL OPENING, NOT ALLOWING THE CUPHOLDER FINISH PANEL TO FIT FLUSH WITH THE INSTRUMENT PANEL. Read More »
