Technical Service Bulletins (TSBs) for the 2000 F-250 are official communications between Ford & their dealerships that describe processes for troubleshooting or fixing certain common problems.
All vehicle manufacturers are required by U.S. law to make their TSBs available to the public.
SOME VEHICLES MAY REQUIRE ADJUSTMENT TO THE FRONT END ALIGNMENT SETTINGS TO ADDRESS TIRE-WEAR OR VEHICLE DIRECTIONAL SENSITIVITY CONCERNS. *TT Read More »
A SLOW RELEASE OF THE HUBS, AT TIMES, WHICH MAY BE REGARDED A NOT NORMAL BY THE OPERATOR. SLOW RELEASE OF THE HUBLOCKS IS NOT CONSIDERED ABNORMAL FOR THIS SYSTEM. Read More »
CLEAR GEL-LIKE SUBSTANCE IN THE HYDRAULIC BRAKE MASTER CYLINDER RESERVOIR. THIS SUBSTANCE IS A SILICONE BASE LUBRICANT USED DURING ASSEMBLY OF THE MASTER CYLINDER. *TT Read More »
VACUUM PUMP INOPERATIVE OR RUNS CONTINUOUSLY - CLIMATE CONTROL DEFAULTS TO DEFROST. OASIS. TO ALSO INCLUDE 2005 SUPER DUTY F-SERIES, EXCURSION, AND F650/750. *TT Read More »
JERR-DAN: ANTI STALL FEATURE FOR FORD F SERIES LIGHT DUTY CHASSIS WITH V10 GAS ENGINE AND AN ENGINE DRIVE CLUTCH PUMP. MODEL YEARS UNKNOWN. *PE Read More »
SOME VEHICLES MAY EXHIBIT VARIOUS DRIVEABILITY CONDITIONS INCLUDING LACKS POWER, HESITATES, HARD TO START, AND/OR MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATED AND PRODUCE POSSIBLE DIAGNOSTIC TROUBLE CODES P0103, P0172 AND P0175. Read More »
SOME VEHICLES WITH 4.6L, OR 6.8L ENGINES MAY EXHIBIT A ROLLER FINGER FOLLOWER COMING OFF DURING ENGINE CRANKING IN COLD TEMPERATURES BELOW ZERO DEGREES F. Read More »
ENGINE AND ENGINE COOLING:ENGINE:GASOLINE:BELTS AND ASSOCIATED PULLEYS
FORD: CERTAIN 1999-2001 MODEL YEAR VEHICLES UP TO 6000 LB GVWR REGISTERED IN NEW YORK AND CERTAIN 2001 VEHICLES UP TO 6000 LB GVWR REGISTERED IN THE STATE OF MAINE, CERTIFIED FOR SALE IN CALIFORNIA-FEDERAL EMISSION WARRANTY REFUND. Read More »
FORD: CERTAIN 1999-2001 MODEL YEAR VEHICLES UP TO 6000 LB GVWR REGISTERED IN NEW YORK AND CERTAIN 2001 VEHICLES UP TO 6000 LB GVWR REGISTERED IN THE STATE OF MAINE, CERTIFIED FOR SALE IN CALIFORNIA-FEDERAL EMISSION WARRANTY REFUND. Read More »
ENGINEERING IS CURRENTLY INVESTIGATING A CONDITION WHERE POPPING / CRACKING SOUNDS CAN BE HEARD FROM THE CATALYTIC CONVERTER DURING HIGHER AMBIENT TEMPERATURES. *TT Read More »
MULTIPLE VEHICLES - FUEL LEVEL INDICATION CONCERNS - SERVICE TIP. VARIOUS MODELS INCLUDING 2005 SUPER DUTY F-SERIES, EXCURSION, EXPEDITION, EXPLORER, MOUNTAINEER AND AVIATOR. *TT Read More »
INOPERATIVE OR INACCURATE SPEEDOMETER AS WELL AS 4X4 LIGHT INOPERATIVE AND / OR DIAGNOSTIC TROUBLE CODE P1635 AND / OR P1639 AFTER A POWERTRAIN CONTROL MODULE (PCM) HAS BEEN REPLACED. *TT Read More »
INOPERATIVE OR INACCURATE SPEEDOMETER, 4X4 LAMP ILLUMINATED AND / OR DIAGNOSTIC TROUBLE CODES (DTCS) P1635 OR P1639 PRESENT AFTER A POWERTRAIN CONTROL MODULE (PCM) OR INSTRUMENT CLUSTER REPLACEMENT. Read More »
SOME VEHICLES MAY EXHIBIT A CONDITION OF NO 4X4 LOW RANGE ENGAGEMENT OR A STUCK IN 4X4 LOW RANGE, WITH NO DIAGNOSTIC TROUBLE CODES STORED IN THE GEM MODULE. *TT Read More »
SOME VEHICLES MAY EXHIBIT A CONDITION OF NO 4X4 LOW RANGE ENGAGEMENT OR A STUCK IN 4X4 LOW RANGE, WITH NO (DTC) DIAGNOSTIC TROUBLE CODE STORED IN THE GEM. *TT Read More »
POWER TRAIN:AUTOMATIC TRANSMISSION:CONTROL MODULE (TCM/PCM/TECM)
SOME BI-FUEL VEHICLES MAY REQUIRE POWERTRAIN CONTROL MODULE (PCM) REPLACEMENT DURING SERVICE AND MAY NOT RUN ON CNG OR LPG., RECALIBRATION OF THE PCM/REPLACEMENT. *MJS Read More »
POWER TRAIN:AUTOMATIC TRANSMISSION:COOLING UNIT AND LINES
SUBJECT REGARDING CONTAMINATION FROM PRIOR TRANSMISSION CONCERNS OR EXCESS WEAR MAY BE TRAPPED IN THE TRANSMISSION FLUID COOLING SYSTEM. *TT Read More »
VEHICLES MAY EXPERIENCE SOLID PARTICLE CONTAMINANTS FROM PRIOR TRANSMISSION CONCERNS OR EXCESS WEAR, MAY BE TRAPPED IN THE TRANSMISSION FLUID COOLING SYSTEM IS NOT PROPERLY FLUSHED, FLUID IN-LINE FILTER KIT. Read More »
A CONDITION MAY EXIST WHERE A DRIVELINE VIBRATION AND / OR A TRANSMISSION FLUID LEAK FROM THE EXTENSION HOUSING SEAL AREA MAY OCCUR ON SOME VEHICLES. Read More »
SOME VEHICLES EQUIPPED WITH 10.50-INCH RING GEAR, FULL-FLOATING REAR AXLES MAY EXHIBIT A LEAK AT THE OUTBOARD END OF THE AXLE SHAFT(S). *TT Read More »
JERR-DAN: ANTI STALL FEATURE FOR FORD F SERIES LIGHT DUTY CHASSIS WITH V10 GAS ENGINE AND AN ENGINE DRIVE CLUTCH PUMP. MODEL YEARS UNKNOWN. *PE Read More »
MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATED - SYSTEM LEAN DIAGNOSTIC TROUBLE CODES (DTC'S) - SERVICE TIPS. VARIOUS MODELS INCLUDING 2004 F-SERIES. *TT Read More »
MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATED - SYSTEM LEAN DIAGNOSTIC TROUBLE CODES (DTC'S) - SERVICE TIPS. VARIOUS MODELS INCLUDING 2004 F-SERIES. *TT Read More »
A CONDITION MAY EXIST WITH POSSIBLE ELECTRONC DAMAGE OCCURING TO THE COMPUVALVE FROM VOLTAGE SPIKES BETWEEN THE COMPUVALVE CONNECTIONS WHEN CONNECTING OR DISCONNECTING THE MAIN COMPUVALVE HARNESS C4025. Read More »
SOME VEHICLES MAY EXHIBIT AN INOPERATIVE COURTESY, GLOVE COMPARTMENT, UNDERHOOD, RUNNING BOARD LAMPS, POWER WINDOWS, RADIO AND REAR WIPER IN THE MORNING OR AFTER VEHICLE IS LEFT UNATTENDED FOR 45 MINUTES. Read More »
CONCERNS WITH COURTESY, GLOVE COMPARTMENT, UNDERHOOD, RUNNING BOARD LAMPS; POWER WINDOWS; RADIO; AND REAR WIPER ALL INOPERATIVE IN THE MORNING OR AFTER VEHICLE IS LEFT UNATTENDED FOR 45 MINUTES. Read More »
SOME VEHICLES EQUIPPED WITH EITHER THE TRAILER TOWING PACKAGE OR CHASSIS CAB MAY EXHIBIT VARIOUS TRAILER RELATED ELECTRICAL CONDITIONS. INSTRUCTIONS ON INSTALLING THE TRAILER TOWING RELAYS AND FUSES ARE PROVIDED IN THE TRAILER TOWING KIT. Read More »
VEHICLES BUILT AFTER 7/31/99 WILL NO LONGER BE EQUIPPED WITH A SHIELD COVERING THE STARTER RELAY AND C120 / C172 ELECTRICAL CONNECTORS LOCATED ON THE PASSENGER SIDE OF THE ENGINE COMPARTMENT. Read More »
SOME VEHICLES EQUIPPED WITH EITHER THE TRAILER TOWING PACKAGE OR CHASSIS CAB MAY EXHIBIT VARIOUS TRAILER RELATED ELECTRICAL CONDITIONS SUCH AS: BACKUP LIGHTS INOPERATIVE, TRAILER BATTERY FEED INOPERATIVE OR ELECTRIC BRAKE POWER ... Read More »
SOME VEHICLES EQUIPPED WITH 7.3L DI ENGINE MAY EXHIBIT FALSE DIAGNOSTIC TROUBLE CODES P1105, P1106 (UPPER AND LOWER ALTERNATOR FAULTS). *TT Read More »
SOME VEHICLES MAY EXHIBIT INTERIOR LIGHTS, POWER WINDOWS AND / OR INOPERATIVE RUNNING BOARD LIGHTS FOR A SHORT PERIOD OF TIME IN THE MORNING. *TT Read More »
SOME SUPERCREWS AND SPORT-TRAC VEHICLES EQUIPPED WITH THE OPTIONAL BED EXTENDER MAY EXHIBIT BROKEN LOCKING PIN(S). THIS MAY BE CAUSED BY THE HOLES NOT BEING COMPLETELY ALIGNED BEFORE INSERTING THE LOCKING PIN. Read More »
THE PURPOSE OF THIS MESSAGE IS TO CLARIFY THE MODEL APPLICATION AND WARRANTY STATUS FOR TSB000104. PRODUCTION WILL BE IMPLEMENTING THIS SPLASH SHIELD. Read More »
VEHICLE EQUIPED WITH EITHER MANUAL OR ELECTRONIC SHIFT 4X4 SYSTEM MAY EXHIBIT A VIBRATION OR A RATCHETING NOISE FROM THE FRONT OF THE VEHICLE. ANOTHER SYMPTOM MAY BE DESCRIBED AS FRONT HUBLOCKS NOT RELEASING. Read More »
THE VEHICLE EXHIBIT SHIF ON THE FLY ENGAGEMENT/DISENGAGEMENT ISSUES OR HEATER/AC ONLY BLOWING OUT OF THE DEFROST MODE. THESE CONDITIONS MAY BE CAUSED BY THE VACUUM PUMP. Read More »
INFORMATION ON IDENTIFYING NON-APPROVED / ALTERNATE REFRIGERANTS WHICH COULD CAUSE SAFETY, AND PERFORMANCE CONCERNS IF INSTALLED IN FORD A/C SYSTEMS. *TT Read More »
INFORMATION ON IDENTIFYING NON-APPROVED / ALTERNATE REFRIGERANTS WHICH COULD CAUSE SAFETY, AND PERFORMANCE CONCERNS IF INSTALLED IN FORD A/C SYSTEMS. *TT Read More »
SOME VEHICLES MAY EXHIBIT DRIVEABILITY CONDITIONS AND / OR CHECK ENGINE LAMP ILLUMINATED WITH A DIAGNOSTIC TROUBLE P0455 (GROSS LEAK DETECTED). *TT Read More »
SOME VEHICLES MAY EXHIBIT DRIVEABILTY CONDITIONS AND/OR CHECK ENGINE LAMP ILLUMINATED WITH A DIAGNOSTIC TROUBLE CODE P0455 (GROSS LEAK DETECTED). *TT Read More »
SOME VEHILCES EQUIPPED WITH 4.6L ROMEO ENGINE AND MANUAL TRANSMISSION ONLY, MAY EXHIBIT A CHECK ENGINE LIGHT ON AND DIAGNOSTIC TROUBLE COE P0172 / P0175 STORED IN MEMORY WITH POSSIBLE DRIVEABLTILITY CONDITIONS SUCH AS HESITATION / STUMBLE. Read More »
ALL VEHICLES MAY EXHIBIT AN INOPERATIVE OR INACCURATE SPEEDOMETER, 4X4 LIGHT INOPERATIVE AND/OR DTC P1635 AFTER A PCM HAS BEEN REPLACED. *MJS Read More »
INFORMATION ON DIAGNOSING A VEHICLE WITH MALFUNCTION INDICATOR LAMP ILLUMINATED AND DIAGNOSTIC TROUBLE CODES P0442 AND P0455 STORED IN CONTINUOUS MEMORY. *TT Read More »
THIS ONLINE SERVICE BULLETIN MENTIONS THAT LATE BUILT REGULAR CABS WILL NOT OFFER A TOOL BOX TRAY LOCATED BEHIND THE SEAT, THE TOOL BOX TRAY IS DISCONTINUED AND IS NO LONGER AVAILABLE AS AN OPTION. Read More »
