Technical Service Bulletins (TSBs) for the 2010 F-150 are official communications between Ford & their dealerships that describe processes for troubleshooting or fixing certain common problems.
All vehicle manufacturers are required by U.S. law to make their TSBs available to the public.
FORD 2009-2014 F150: SERVICE INFORMATION REGARDING , DAMAGED 4X4 FRONT PINION BEARING DAMAGE IS NOTED DURING THE REPAIR OF THE FRONT AXLE ON 2009-2014 F150 VEHICLES UNITS OPERATED IN SEVERE COLD CLIMATES. Read More »
FORD: ON SOME VEHICLES, FLUID IS PRESENT ON SHOCK ABSORBER SHAFT TO BODY INTERFACE OR THERE IS WETNESS AT REAR RESERVOIR SNAP RING AND NO REPLACEMENT SHOULD OCCUR, SINCE SHOCK WEEPAGE IS NORMAL. MODEL 2010-2014 F-150 RAPTOR. Read More »
FORD: ON SOME TRUCKS, THERE IS NOISE (CHIRP, CLUNK, BOOM) COMING FROM RIGHT FRONT REAR SHOCK ABSORBER, WHEN TRAVELING OVER SHARP, SMALL BUMPS (POTHOLES, FROST HEAVES OR EXPANSION JOINTS, AND MORE APPARENT DURING COLD TEMPERATURES. Read More »
FORD: ON SOME VEHICLES, FLUID IS PRESENT ON SHOCK ABSORBER SHAFT TO BODY INTERFACE OR THERE IS WETNESS AT REAR RESERVOIR SNAP RING AND NO REPLACEMENT SHOULD OCCUR, SINCE SHOCK WEEPAGE IS NORMAL. MODEL 2010-2014 F-150 RAPTOR. Read More »
FORD: THE SHOCK ABSORBER HAS FLUID OR WETNESS AT REAR RESERVOIR SNAP RING AND WEEPAGE OR LEAKAGE IS NORMAL AND WILL NOT HAVE A DETRIMENTAL EFFECT TO LIFT OF SHOCK ABSORBERS OR SUSPENSION. MODEL 2010-2013 F-150. Read More »
FORD F-150 2009-2012 : SOME TRUCKS WITH A 9.75 TRACTION LOK REAR AXLE ASSEMBLY MAY EXHIBIT, DURING TIGHT SLOW TURNS, VIBRATION, CHATTER OR A SHUDDER. *LJ Read More »
FORD: DUE TO TRACTION CONTROL FLASHING OR ILLUMINATING INDICATOR, DIAGNOSTIC CODES (DTC) C1963, C1278, C1280, C1282 ARE STORED IN ANTI LOCK BRAKE SYSTEM (ABS), DURING LOW SPEED MANEUVERS . MODELS 2009-2012 F-150. Read More »
FORD: 2009-2011 F150. TRACTION CONTROL LIGHT MAY BE ILLUMINATED WITH TROUBLE CODES STORED. THE ELECTRONIC STABILITY CONTROL MAY ALSO ACTIVATE INTERMITTENTLY WHILE TOWING A TRAILER. *RM Read More »
FORD: THE TRACTION CONTROL LIGHT IS FLASHING WITH MULTIPLE STORED TROUBLE CODES. THE STABILITY LIGHT MAY ALSO BE ON WHILE TOWING A TRAILER AT LOW SPEED. 2009-2010 F-150. *RM Read More »
FORD: THE COMPLETE CALIPER ASSEMBLY, BRACKET (ANCHOR PLATE), BRAKE PADS, ROTORS AND CLIPS NEEDS TO BE REPLACED DUE TO STICKING OR BINDING OF FRONT BRAKE CALIPER. *PE Read More »
SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP
FORD: THE COMPLETE CALIPER ASSEMBLY, BRACKET (ANCHOR PLATE), BRAKE PADS, ROTORS AND CLIPS NEEDS TO BE REPLACED DUE TO STICKING OR BINDING OF FRONT BRAKE CALIPER. *PE Read More »
FORD: ON SOME VEHICLES, DURING A PROGRAMMABLE MODULE INSTALLATION (PMI) OF ANTI LOCK BRAKE (ABS) MODULE AN IDS ERROR MESSAGE APPEARS, IF IDS SESSION STARTED WITH NEW ABS MODULE CONNECT. MODELS 2010-2013 F-150. Read More »
FORD: SOME F150 SVT RAPTOR VEHICLES MAY EXHIBIT HILL DECENT CONTROL FAULT WITH ABS DTC C116A. ON VEHICLES BUILT BEFORE 2/26/10 ONLY, INSPECT THE HIGH MOUNTED STOP LAMP FOR EVIDENCE OF WATER INTRUSION. Read More »
LINCOLN/FORD: WHEN DRIVING FROM IDLE UP TO 1200 RPM, THERE MAY BE AN INTERMITTENT RATTLE NOISE COMING FROM ENGINE. 2004-2013 F-150, F-250, F-350, EXPEDITION, MARK LT, NAVIGATOR. Read More »
FORD/LINCOLN: SOME TRUCKS ARE EXPERIENCING DIAGNOSTIC TROUBLE CODES (DTC) P2270 OR P2272, MALFUNCTION INDICATOR LAMP (MIL) COMES ON. MODEL 2010-2011 RANGER, 2010-2012 E SERIES, EXPEDITION, F-150, F-SUPER DUTY, NAVIGATOR. Read More »
FORD: SOME EXPEDITION, F-150, AND NAVIGATOR MODELS MAY EXPERIENCE A DELAYED FORWARD OR REVERSE TRANSMISSION ENGAGEMENT. USUALLY HAPPENS ON COLD START IN COLD CLIMATES. *RM Read More »
FORD: WHEN ACCELERATING AFTER A COLD START THERE MAY BE LACK OF POWER OR ROUGH RUNNING. NORMAL CONDITION. 2009-2010 EXPEDITION/NAVIGATOR/F150. *RM Read More »
FORD: LACK OF POWER WIDE OPEN THROTTLE ONLY. SOME VEHICLES MAY EXHIBIT A LACK OF POWER DURING WIDE OPEN THROTTLE ONLY. NO DTCS WILL BE PRESENT AND ENGINE PERFORMANCE DURING NORMAL DRIVING WILL NOT BE AFFECTED. Read More »
ENGINE AND ENGINE COOLING:ENGINE:GASOLINE:TURBO/SUPERCHARGER
SOME 2004-2014 F-150 AND 2006-2008 MARK LT VEHICLES EQUIPPED WITH FOUR-WHEEL DRIVE (4WD) MAY EXHIBIT NOISY OR ENGAGED FRONT HUBS WHEN OPERATING IN TWO-WHEEL DRIVE (2WD) MODE. FOLLOW THE SERVICE PROCEDURE STEPS TO CORRECT THE CONDITION. Read More »
4R75E TRANSMISSION - GRINDING/WHINE/VIBRATION/GEAR SLIPPAGE - SERVICE KIT AVAILABLE ISSUE A service kit has been released to assist with proper repair of the 4R75E transmission in 2008 Mark LT, 2008-2010 F-150, 2008-2010 / 2013-2014 ... Read More »
2009-2017 VEHICLES EQUIPPED WITH A 6R80, 6R100, 6R140 AUTOMATIC TRANSMISSION HAVE AN UPDATED MAIN CONTROL VALVE BODY OVERHAUL PROCEDURE. REFER TO WORKSHOP MANUAL (WSM), SECTION 307-01 FOR MAIN CONTROL VALVE BODY (7A100) OVERHAUL PROCEDURES. Read More »
FORD/LINCOLN/MERCURY: FAILURE OF PLANETARY GEAR ASSEMBLY IS DUE TO TRANSMISSION, ON CERTAIN VEHICLES, EXHIBITING GRINDING, GEAR SLIPPAGE, WHINE TYPE NOISE, VIBRATION, WHILE DRIVING OR LOSS OF REVERSE. Read More »
FORD/LINCOLN/MERCURY: THE INDICATOR MAY ILLUMINATE OVERDRIVE OFF AND/OR SLIPPING IN 3RD OR NO 4TH GEAR, DUE TO DIRECT CLUTCH FAILURE AND DIAGNOSTIC TROUBLE CODE (DTC) P0733 AND/OR P0734. Read More »
LINCOLN/MERCURY/FORD: THERE IS FLUID LEAKING AROUND THE TRANSMISSION BULKHEAD CONNECTOR SLEEVE, FROM THE TRANSMISSION. MODEL 2009-10 EXPEDITION, EXPLORER, EXPLORER SPORT TRAC, F-150, NAVIGATOR, MOUNTAINEER. Read More »
FORD: SOME EXPEDITION, F-150, AND NAVIGATOR MODELS MAY EXPERIENCE A DELAYED FORWARD OR REVERSE TRANSMISSION ENGAGEMENT. USUALLY HAPPENS ON COLD START IN COLD CLIMATES. *RM Read More »
FORD: THERE MAY BE A LOSS OF POWER, HESITATION, SURGE, OR LACK OF THROTTLE RESPONSE WHILE DRIVING. THE BRAKE OVER ACCELERATOR FEATURE MAY BE ACTIVATING. *RM Read More »
POWER TRAIN:AUTOMATIC TRANSMISSION:GEAR POSITION INDICATION (PRNDL)
FORD/LINCOLN: SOME TRUCKS ARE EXPERIENCING DIAGNOSTIC TROUBLE CODES (DTC) P2270 OR P2272, MALFUNCTION INDICATOR LAMP (MIL) COMES ON. MODEL 2010-2011 RANGER, 2010-2012 E SERIES, EXPEDITION, F-150, F-SUPER DUTY, NAVIGATOR. Read More »
FORD: 2009-2011 F150. TRACTION CONTROL LIGHT MAY BE ILLUMINATED WITH TROUBLE CODES STORED. THE ELECTRONIC STABILITY CONTROL MAY ALSO ACTIVATE INTERMITTENTLY WHILE TOWING A TRAILER. *RM Read More »
FORD: DUE TO AN OPEN HEADLIGHT SWITCH, THE HEADLAMPS, PARK LAMPS OR LAMPS ARE INOPERATIVE AND HEADLAMPS WILL REMAIN ON BECAUSE OF AFTERMARKET OR GENUINE FORD ACCESSORIES (GFA), INSTALLED INCORRECTLY. CAUSING POSSIBLE DAMAGE TO SWITCH. Read More »
FORD: NO SERVICE ACTION IS RECOMMENDED FOR THIS CONDITION. PLEASE USE AT YOUR DISCRETION. VARIOUS 2010-2015 VEHICLES MAY EXPERIENCE A TURBULENCE NOISE, SIMILAR TO AN HELICOPTER NOISE, AT HIGHWAY SPEEDS WHEN THE REAR DOOR WINDOW(S) OR ... Read More »
FORD: A POWER SLIDING REAR WINDOW, ON SOME VEHICLES, MAY EXPERIENCE A POSSIBLE INOPERATIVE REAR WINDOW DEFROST. MODELS 2010-2013 F-150. *PE Read More »
SOME 2009-2014 F-150 VEHICLES THAT REQUIRE REPLACEMENT OF THE LOWER ROCKER PANEL AND/OR CAB CORNERS NO LONGER NEED THE ENTIRE DOOR FRAME/OPENING PANEL (211A10/1) REPLACED. Read More »
FORD: TAILGATE APPLIQUE SEPARATION. SOME PLATINUM TRUCKS MAY EXHIBIT TAILGATE APPLIQUE SEPARATION FROM THE SHEET METAL. FOLLOW THE SERVICE PROCEDURE STEPS TO CORRECT THE CONDITION. *PE Read More »
FORD: SOME VEHICLES MAY EXHIBIT A CONDITION WHERE ONE OR MORE REAR DOORS ARE DIFFICULT TO LOCK OR UNLOCK USING THE DOOR LOCK ROD. THIS MAY BE DUE TO DUST BUILDUP IN THE DOOR LATCH. ALSO INCLUDED MODEL F150 MODEL YEARS 2009-2011. Read More »
FORD: THERE IS A NOISE COMING FROM THE FRONT HUB INTEGRATED WHEEL END (IWE) AREAS AND WHEN SHIFTED INTO 4X4 MODE, THE NOISE WILL CEASE. MODELS 2008-2013 F-150, EXPEDITION, NAVIGATOR, MARK LT. Read More »
SOME 2009-2010 F-150 AND 2011-2016 EXPLORER VEHICLES MAY HAVE A SEAT CUSHION COVER THAT APPEARS LOOSE NEAR THE FRONT OF THE SEAT. THIS MAY BE CAUSED BY THE SEAT CUSHION COVER J-RETAINER BECOMING DISENGAGED FROM THE SEAT CUSHION PAN FLANGE. Read More »
LINCOLN/FORD: ON SOME VEHICLES AND TRUCKS, THERE IS A POPPING, SQUEALING, BINDING OR GRINDING NOISE COME FROM POWER SEATS WHEN MOVING BACKWARDS OR FORWARD. MODEL 2009-2015 F-150, TAURUS, FLEX, MKT, MKS, F-SUPER DUTY, EXPLORER. Read More »
FORD: ON SOME TRUCKS, TRACTION CONTROL INDICATOR FLASHES OR ILLUMINATES AND AT LOW SPEED MANEUVERING TURNS, ELECTRONIC STABILITY CONTROL (ESC) IS AN INTERMITTENT NUISANCE ACTIVATION. *PE Read More »
SOME 2009-2014 F-150 VEHICLES THAT REQUIRE REPLACEMENT OF THE LOWER ROCKER PANEL AND/OR CAB CORNERS NO LONGER NEED THE ENTIRE DOOR FRAME/OPENING PANEL (211A10/1) REPLACED. Read More »
FORD: THE TORCA*CLAMP, THAT SECURES TWO CATALYST PIPES, REQUIRES REPLACEMENT DUE TO REPEATED STRETCHING AND NO LONGER PROVIDE NECESSARY CLAMPING FORCE SEALING EXHAUST JOINT. MODEL 2010-2014 F-150. Read More »
FORD/LINCOLN: THERE WILL BE 2 NEW PIECE RECEIVER DRYER DESICCANT BAG THAT WILL REPLACE 1 PIECE RECEIVER DRY CARTRIDGE, WHICH ARE INTERCHANGABLE, FULLY, DO NOT AFFECT FORM, FIT, OR FUNCTION. Read More »
FORD: WHILE REPAIRING THE FRONT AXLE, DAMAGE TO PINION BEARING IS NOTED AFTER OPERATING IN SEVERE COLD CLIMATES. MODEL 2009-2014 F-150. *PE Read More »
FORD: THE TORCA*CLAMP, THAT SECURES TWO CATALYST PIPES, REQUIRES REPLACEMENT DUE TO REPEATED STRETCHING AND NO LONGER PROVIDE NECESSARY CLAMPING FORCE SEALING EXHAUST JOINT. MODEL 2010-2014 F-150. Read More »
