Technical Service Bulletins (TSBs) for the 2000 Expedition are official communications between Ford & their dealerships that describe processes for troubleshooting or fixing certain common problems.
All vehicle manufacturers are required by U.S. law to make their TSBs available to the public.
SOME4X2 VEHICLES (BASE AND AIR SUSPENSION UNITS) EQUIPPED WITH GENERAL / CONTINENTAL ALL WEATHER LOW PROFILE TIRES, MAY EXHIBIT A STEERING DRIFT / PULL CONDITION. *TT Read More »
SOME VEHICLES (BASE AND AIR SUSPENSION UNITS) EQUIPPED WITH GENERAL / CONTINENTAL ALL WEATHER LOW PROFILE TIRES, MAY EXHIBIT A STEERING DRIFT / PULL CONDITION. *TT Read More »
EXPEDITION AND NAVIGATORS EQUIPPED WITH FOUR WHEEL AIR SUSPENSION MAY REQUIRE A RIDE HEIGHT ADJUSTMENT PROCEDURE BE PERFORMED, BEFORE SETTING ALIGNMENT. Read More »
SOME 1997-2008 VEHICLES EQUIPPED WITH A 4.6L 2V, 5.4L 2V, OR 6.8L 2V ENGINE--SPARK PLUG THREAD REPAIR PROCEDURE--NOT COVERED UNDER NEW VEHICLE LIMITED WARRANTY. *NJ THIS INCLUDES F-53 MOTORHOME CHASSIS. UPDATED 2/23/10. Read More »
ENGINE MISFIRE OR RUNNING - COIL ON PLUG (COP) IGNITION SYSTEMS - WDS COP KIT DIAGNOSTIC TIPS. TO INCLUDE VARIOUS 2005 MODELS. * AR THIS ARTICLE 04161 SUPERSEDES TSB 03-14-04. Read More »
ENGINE MISFIRE OR ROUGH RUNNING CONDITION WITH COIL ON PLUG (COP) IGNITION SYSTEMS MAY BE MORE ACCURATELY DIAGNOSED USING THE OPTIONAL WORLDWIDE DIAGNOSTIC SYSTEM (WDS) COIL ON PLUG (COP) KIT. 2003 SUPER DUTY F SERIES INCLUDED. Read More »
SOME VEHICLES EQUIPPED WITH THE 5.4L 2V ENGINE MAY EXHIBIT A WHISTLING NOISE FROMTHE FORMED NYLON TUBE INTHE IDLE-AIR BYPASS FLOW CIRCUIT. *TT Read More »
SOME ENGINE ASSEMBLIES WITH ALUMINUM CYLINDER HEADS REPAIRED IN-VEHILE HAVE BEEN FOUND TO LEAK COOLANT AND/OR OIL FROM THE CYLINDER HEAD GASKET AREA. *TT Read More »
SOME VEHICLES EQUIPPED WITH THE ROMEO BUILT 4.6L 2V ENGINE MAY EXHIBIT AN ENGINE OIL LEAK OR OIL WEEPAGE FROM THE CYLINDER HEAD GASKET AT THE RIGHT HAND REAR OR THE LEFT HAND FRONT OF THE ENGINE. Read More »
SOME VEHICLES MAY EXHIBIT VACUUM OR AIR LEAKS IN THE INTAKE MANIFOLD AND / OR ENGINE SYSTEM CAUSING DIAGNOSTIC TROUBLE CODES P0171 AND OR P0174. *TT Read More »
SOME VEHICLES MAY EXHIBIT ANY OF P0350 THROUGH P0358 COIL DIAGNOSTIC TROUBLE CODES, CHECK ENGINE LIGHT ON AND ROUGH IDLE UNDER COLD START CONDITIONS. *TT Read More »
SOME VEHICLES WITH 4.6L, OR 6.8L ENGINES MAY EXHIBIT A ROLLER FINGER FOLLOWER COMING OFF DURING ENGINE CRANKING IN COLD TEMPERATURES BELOW ZERO DEGREES F. Read More »
ENGINE AND ENGINE COOLING:ENGINE:GASOLINE:BELTS AND ASSOCIATED PULLEYS
DRIVEABILITY-IDLE-HIGH IDLE SPEEDS-THROTTLE STICKS AFTER STEADY STATE DRIVING IN EXTREME COLD AMBIENT TEMPERATURES-VEHICLES BUILT THROUGH 12/31/01 EQUIPPED WITH 4.6L ENGINE. *MJ Read More »
CONCERNS WITH THE INTAKE MANIFOLD LEAKING OR WEEPING COOLANT FROM PASSENGER SIDE GASKET AT RIGHT REAR CORNER OF HEAD-TO-MANIFOLD JOINT. *JB Read More »
MULTIPLE VEHICLES - FUEL LEVEL INDICATION CONCERNS - SERVICE TIP. VARIOUS MODELS INCLUDING 2005 SUPER DUTY F-SERIES, EXCURSION, EXPEDITION, EXPLORER, MOUNTAINEER AND AVIATOR. *TT Read More »
INOPERATIVE OR INACCURATE SPEEDOMETER AS WELL AS 4X4 LIGHT INOPERATIVE AND / OR DIAGNOSTIC TROUBLE CODE P1635 AND / OR P1639 AFTER A POWERTRAIN CONTROL MODULE (PCM) HAS BEEN REPLACED. *TT Read More »
INOPERATIVE OR INACCURATE SPEEDOMETER, 4X4 LAMP ILLUMINATED AND / OR DIAGNOSTIC TROUBLE CODES (DTCS) P1635 OR P1639 PRESENT AFTER A POWERTRAIN CONTROL MODULE (PCM) OR INSTRUMENT CLUSTER REPLACEMENT. Read More »
SOME VEHICLES EQUIPPED WITH 4 WHEEL DRIVE MAY EXHIBIT A NOTCHY OR STICKING FEELING IN SLOW SPEED TURNS WITH NO EFFECT ON STEERING EFFORTS OR ASSIST WHILE IN THE AUTOMATIC 4X4 POSITION. *TT Read More »
SOME VEHICLES MAY EXHIBIT A CONDITION OF NO 4X4 LOW RANGE ENGAGEMENT OR A STUCK IN 4X4 LOW RANGE, WITH NO DIAGNOSTIC TROUBLE CODES STORED IN THE GEM MODULE. *TT Read More »
THIS BULLETIN STATES THAT ON SOME VEHICLES (INCLUDING 2002 BLACKWOOD) A BATTERY DISCONNECT OR PARAMETER RESET IS REQUIRED DURING POWERTRAIN CONTROL MODULE (PCM) OR INSTRUMENT CLUSTER (VIC / HEC / ICM) REPLACEMENT. Read More »
POWER TRAIN:AUTOMATIC TRANSMISSION:LEVER AND LINKAGE:COLUMN SHIFT
SUBJECT REGARDING CONTAMINATION FROM PRIOR TRANSMISSION CONCERNS OR EXCESS WEAR MAY BE TRAPPED IN THE TRANSMISSION FLUID COOLING SYSTEM. *TT Read More »
VEHICLES MAY EXPERIENCE SOLID PARTICLE CONTAMINANTS FROM PRIOR TRANSMISSION CONCERNS OR EXCESS WEAR, MAY BE TRAPPED IN THE TRANSMISSION FLUID COOLING SYSTEM IS NOT PROPERLY FLUSHED, FLUID IN-LINE FILTER KIT. Read More »
POWER TRAIN:AUTOMATIC TRANSMISSION:PARK/NEUTRAL START INTERLOCK SWITCH
SOME VEHICLES MAY EXHIBIT INADVERTENT 4X4 HI OR LOW SHIFT EVENTS, 4X4 AND / OR LOW RANGE INDICATOR FLASHING OR SOLID OR VEHICLE STUCK IN 4L AFTER UNCOMMANDED SHIFT. *TT Read More »
WARNING INDICATORS-PARKING AID-REVERSE SENSING SYSTEM (RSS) AND FORWARD SENSING SYSTEM (FSS)-FALSE ACTIVATION OF WARNING TONE-SERVICE TIPS. *MJ UPDATE. *TT Read More »
MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATED - SYSTEM LEAN DIAGNOSTIC TROUBLE CODES (DTC'S) - SERVICE TIPS. VARIOUS MODELS INCLUDING 2004 F-SERIES. *TT Read More »
VEHICLES WITH KEYLESS ENTRY PAD MAY EXHIBIT DEAD BATTERY, NO START, INTERIOR LAMP/HEADLAMP SELF-ACTIVATION, OR INOPERATIVE KEYLESS ENTRY PAD. *TT Read More »
SOME VEHICLES MAY EXHIBIT AN INOPERATIVE COURTESY, GLOVE COMPARTMENT, UNDERHOOD, RUNNING BOARD LAMPS, POWER WINDOWS, RADIO AND REAR WIPER IN THE MORNING OR AFTER VEHICLE IS LEFT UNATTENDED FOR 45 MINUTES. Read More »
CONCERNS WITH COURTESY, GLOVE COMPARTMENT, UNDERHOOD, RUNNING BOARD LAMPS; POWER WINDOWS; RADIO; AND REAR WIPER ALL INOPERATIVE IN THE MORNING OR AFTER VEHICLE IS LEFT UNATTENDED FOR 45 MINUTES. Read More »
SOME IGNITION SWITCH LOCK CYLINDER ASSEMBLIES MAY EXHIBIT ROUGNESS AND / OR EXCESS EFFORT IN TURNING, KEY DOES NOT FULLY RETURN FROM START, A MALFUNCTION INDICATOR LAMP MAY ILLUMINATE WITH P0500, P1502 AND U1039 STORED IN POWERTRIAN ... Read More »
SOME VEHICLES NOT EQUIPPED WITH SIDE AIR BAGS MAY EXHIBIT DIAGNOSTIC TROUBLE CODE B1998 (PASSENGER SIDE AIR BAG CIRCUIT RESISTANCE HIGH) IN THE RESTRAINTS CONTROL MODULE. *TT Read More »
SOME VEHICLES MAY EXHIBIT INTERIOR LIGHTS, POWER WINDOWS AND / OR INOPERATIVE RUNNING BOARD LIGHTS FOR A SHORT PERIOD OF TIME IN THE MORNING. *TT Read More »
CERTAIN SUPERCREWS AND SOME VEHICLES MAY EXHIBIT A WIND NOISE / BOOM WHEN DRIVEN AT HIGH SPEEDS ABOVE 55 MPH WITH THE MOON ROOF FULLY OPEN, DUE TO THE MOON ROOF WIND DEFLECTOR NOT DEPLOYED HIGH ENOUGH ABOVE THE ROOF LINE. Read More »
SOME VEHICLES NOT EQUIPPED WITH SIDE AIR BAGS, MAY EXHIBIT A DIAGNOSTIC TROUBLE CODE (DTC) B1998 (PASSENGER SIDE AIR BAG CIRCUIT RESISTANCE HIGH) IN THE RESTRAINTS CONTROL MODULE. *TT Read More »
SOME VEHICLES NOT EQUIPPED WITH SIDE AIR BAGS, MAY EXHIBIT A DIAGNOSTIC TROUBLE CODE (DTC) B1998 (PASSENGER SIDE AIR BAG CIRCUIT RESISTANCE HIGH) IN THE RESTRAINTS CONTROL MODULE. *TT Read More »
DRIVEABILITY-IDLE-HIGH IDLE SPEEDS-THROTTLE STICKS AFTER STEADY STATE DRIVING IN EXTREME COLD AMBIENT TEMPERATURES-VEHICLES BUILT THROUGH 12/31/01 EQUIPPED WITH 4.6L ENGINE. *MJ Read More »
A CONDITION MAY EXIST, WHERE THROTTLE STICKING MAY OCCUR ON A FEW VEHICLES IN VERY COLD AMBIENT TEMPERATURES AFTER OPERATING AT STEADY SPEED OR EXTENDED IDLE FOR A PERIOD OF TIME. *TT Read More »
SOME VEHICLES BUILT BETWEEN JANUARY 2000 AND JULY 2000 MAY EXHIBIT A RADIO RECEPTION CONDITION OF TWO STATIONS RECEIVED AT ONCE IN THE AM BAND. *TT Read More »
EXPEDITIONS AND NAVIGATORS BUILT AFTER 8/16/99 AND ORDERED WITH A COMPACT DISC PLAYRES WILL BE EQUIPPED WITH A REDESIGNED COMPACT DISC PLAYRES. Read More »
SOME VEHICLES MAY BE DELIVERED WITH A B-PILLAR TRIM PANEL, THAT HAS A YELLOW STICKER, WHICH STATES THAT IT IS SIDE AIRBAG COMPATIBLE. THIS DOES NOT MEAN THAT THE UNIT IS EQUIPPED WITH SIDE AIRBAGS. Read More »
VEHICLES MAY EXPERIENCE AIR CONDITIONING INACCURATE AMBIENT TEMPERATURE DISPLAYED- VEHICLES EQUIPPED WITH EATC- CONTINENTAL AND LS BUILT THROUGH 10/15/99, ALL OTHERS BUILT THROUGH 8/31/99. *MJS Read More »
VEHICLES EQUIPPED WITH ELECTRONIC AUTOMATIC TEMPERATURE CONTROL (EATC) , MAY EXERIENCE THE BLOWER MOTOR STAYING ON HIGH AFTER DESIRED TEMPERATURE IS REACHED AND/ OR THE SYSTEM DOES NOT MAINTAIN SET TEMPERATURE. Read More »
INFORMATION ON IDENTIFYING NON-APPROVED / ALTERNATE REFRIGERANTS WHICH COULD CAUSE SAFETY, AND PERFORMANCE CONCERNS IF INSTALLED IN FORD A/C SYSTEMS. *TT Read More »
SOME VEHICLES MAY EXHIBIT DRIVEABILITY CONDITIONS AND / OR CHECK ENGINE LAMP ILLUMINATED WITH A DIAGNOSTIC TROUBLE P0455 (GROSS LEAK DETECTED). *TT Read More »
SOME VEHICLES MAY EXHIBIT DRIVEABILTY CONDITIONS AND/OR CHECK ENGINE LAMP ILLUMINATED WITH A DIAGNOSTIC TROUBLE CODE P0455 (GROSS LEAK DETECTED). *TT Read More »
SOME VEHICLES MAY EXHIBIT A CHECK SUSPENSION LAMP ON WITH DIAGNOSTIC TROUBLE CODES B2140 OR C2140 EVEN AFTER THE AIR SUSPENSION SWITCH IN THE UPPER RH KICK PANEL HAS BEEN TURNED ON. Read More »
CONCERNS WITH VEHICLES EXHIBITING THE OIL PRESSURE GAUGE REGISTERING LOW OR NO OIL PRESSURE USUALLY ON INITIAL START-UP AFTER SEVERAL HOURS OF COLD SOAK. *TT Read More »
SOME VEHICLES MAY PRODUCE A MALFUNCTION INDICATOR LAMP ILLUMINATED, ROUGH IDLE, A CHECK ENGINE LIGHT, AND DIAGNOSTIC TROUBLE CODES (DTCS) P0350 - P0360 STORED IN MEMORY. *TT Read More »
ALL VEHICLES MAY EXHIBIT AN INOPERATIVE OR INACCURATE SPEEDOMETER, 4X4 LIGHT INOPERATIVE AND/OR DTC P1635 AFTER A PCM HAS BEEN REPLACED. *MJS Read More »
INFORMATION ON DIAGNOSING A VEHICLE WITH MALFUNCTION INDICATOR LAMP ILLUMINATED AND DIAGNOSTIC TROUBLE CODES P0442 AND P0455 STORED IN CONTINUOUS MEMORY. *TT Read More »
