Technical Service Bulletins (TSBs) for the 1999 Expedition are official communications between Ford & their dealerships that describe processes for troubleshooting or fixing certain common problems.
All vehicle manufacturers are required by U.S. law to make their TSBs available to the public.
SUBJECT REGARDING VEHICLES WITH FOUR WHEEL AIR SUSPENSION MAY REQUIRE A RIDE HEIGHT ADJUSTMENT PROCEDURE PERFORMED BEFORE SETTING ALIGNMENT. *TT Read More »
SOME VEHICLES EQUIPPED WITH FOUR WHEEL AIR SUSPENSION MAY REQUIRE A RIDE HEIGHT ADJUSTMENT PROCEDURE BE PERFORMED BEFORE SETTING ALIGNMENT. *TT Read More »
EXPEDITION AND NAVIGATORS EQUIPPED WITH FOUR WHEEL AIR SUSPENSION MAY REQUIRE A RIDE HEIGHT ADJUSTMENT PROCEDURE BE PERFORMED, BEFORE SETTING ALIGNMENT. Read More »
SOME VEHICLES EQUIPPED WITH AIR SUSPENSION MAY EXHIBIT AN INTERMITTENT CHECK SUSPENSION LAMP ON AND DIAGNOSTIC TROUBLE CODE (DTC) C1770 AND/OR C1845 ILLUMINATED. *YC Read More »
THIS BULLETIN MENTIONS THAT FOR ALL VEHICLES WITH ANTILOCK BRAKE MODULE CONCERNS THAT REQUIRE A MODULE REPLACEMENT, THE TECHNICIAN MUST CALL FOR APPROVAL BEFORE REMOVING AND / OR REPLACING THE MODULE. Read More »
SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP:ABS WARNING LIGHT
SOME 1997-2008 VEHICLES EQUIPPED WITH A 4.6L 2V, 5.4L 2V, OR 6.8L 2V ENGINE--SPARK PLUG THREAD REPAIR PROCEDURE--NOT COVERED UNDER NEW VEHICLE LIMITED WARRANTY. *NJ THIS INCLUDES F-53 MOTORHOME CHASSIS. UPDATED 2/23/10. Read More »
ENGINE MISFIRE OR RUNNING - COIL ON PLUG (COP) IGNITION SYSTEMS - WDS COP KIT DIAGNOSTIC TIPS. TO INCLUDE VARIOUS 2005 MODELS. * AR THIS ARTICLE 04161 SUPERSEDES TSB 03-14-04. Read More »
ENGINE MISFIRE OR ROUGH RUNNING CONDITION WITH COIL ON PLUG (COP) IGNITION SYSTEMS MAY BE MORE ACCURATELY DIAGNOSED USING THE OPTIONAL WORLDWIDE DIAGNOSTIC SYSTEM (WDS) COIL ON PLUG (COP) KIT. 2003 SUPER DUTY F SERIES INCLUDED. Read More »
SOME VEHICLES BUILT 7/1998 TO 6/1999 EQUIPPED WITH A 4.6 / 5.4L WINSOR BUILT ENGINES MAY EXHIBIT AN OIL LEAK FROM THE CYLINDER HEAT GASKET AREA. *TT Read More »
SOME VEHICLES BUILT 7/1998 TO 6/1999 EQUIPPED WITH A 4.6 / 5.4L WINDSOR BUILT ENGINE MAY EXHIBIT AN OIL LEAK FROM THE CYLINDER HEAD GASKET AREA. *TT Read More »
SOME VEHICLES BUILT 7/1998 TO 6/1999 EQUIPPED WITH A 4.6 / 5.4L WINDSOR BUILT ENGINES MAY EXHIBIT AN OIL LEAK FROM THE CYLINDER HEAD GASKET AREA. *TT Read More »
SOME VEHICLES EQUIPPED WITH THE 5.4L 2V ENGINE MAY EXHIBIT A WHISTLING NOISE FROMTHE FORMED NYLON TUBE INTHE IDLE-AIR BYPASS FLOW CIRCUIT. *TT Read More »
SOME ENGINE ASSEMBLIES WITH ALUMINUM CYLINDER HEADS REPAIRED IN-VEHILE HAVE BEEN FOUND TO LEAK COOLANT AND/OR OIL FROM THE CYLINDER HEAD GASKET AREA. *TT Read More »
SOME VEHICLES EQUIPPED WITH THE ROMEO BUILT 4.6L 2V ENGINE MAY EXHIBIT AN ENGINE OIL LEAK OR OIL WEEPAGE FROM THE CYLINDER HEAD GASKET AT THE RIGHT HAND REAR OR THE LEFT HAND FRONT OF THE ENGINE. Read More »
SOME VEHICLES MAY EXHIBIT VACUUM OR AIR LEAKS IN THE INTAKE MANIFOLD AND / OR ENGINE SYSTEM CAUSING DIAGNOSTIC TROUBLE CODES P0171 AND OR P0174. *TT Read More »
SOME VEHICLES WITH 4.6L, OR 6.8L ENGINES MAY EXHIBIT A ROLLER FINGER FOLLOWER COMING OFF DURING ENGINE CRANKING IN COLD TEMPERATURES BELOW ZERO DEGREES F. Read More »
SOME VEHICLES EQUIPPED WITH A 4.6L ENGINE MAY EXHIBIT A HESITATION / STUMBLE AFTER INITIAL VEHICLE START-UP DURING ACCELERATOR TIP-IN, WITH A COLD ENGINE. *TT Read More »
SOME VEHICLES MAY DEVELOP A COOLANT LEAK AT THE WORM GEAR CLAMP LOCATED AT THE JOINT BETWEEN THE METAL INTAKE COOLANT TUBE AND THE COIL RESULTING IN ENGINE MISFIRE WITH DIAGNOSTIC TROUBLE CODE P0304 AND / OR ROUGH IDLE. Read More »
SOME VEHICLES MAY DEVELOP A COOLANT LEAK AT THE WORM GEAR CLAMP LOCATED AT THE JOINT BETWEEN THE METAL INTAKE COOLANT TUBE AND THE FLEXIBLE RUBBER COOLANT HOSE. *TT Read More »
DRIVEABILITY-IDLE-HIGH IDLE SPEEDS-THROTTLE STICKS AFTER STEADY STATE DRIVING IN EXTREME COLD AMBIENT TEMPERATURES-VEHICLES BUILT THROUGH 12/31/01 EQUIPPED WITH 4.6L ENGINE. *MJ Read More »
INOPERATIVE OR INACCURATE SPEEDOMETER AS WELL AS 4X4 LIGHT INOPERATIVE AND / OR DIAGNOSTIC TROUBLE CODE P1635 AND / OR P1639 AFTER A POWERTRAIN CONTROL MODULE (PCM) HAS BEEN REPLACED. *TT Read More »
INOPERATIVE OR INACCURATE SPEEDOMETER, 4X4 LAMP ILLUMINATED AND / OR DIAGNOSTIC TROUBLE CODES (DTCS) P1635 OR P1639 PRESENT AFTER A POWERTRAIN CONTROL MODULE (PCM) OR INSTRUMENT CLUSTER REPLACEMENT. Read More »
SOME VEHICLES EQUIPPED WITH 4 WHEEL DRIVE MAY EXHIBIT A NOTCHY OR STICKING FEELING IN SLOW SPEED TURNS WITH NO EFFECT ON STEERING EFFORTS OR ASSIST WHILE IN THE AUTOMATIC 4X4 POSITION. *TT Read More »
SOME VEHICLES MAY EXHIBIT A CONDITION OF NO 4X4 LOW RANGE ENGAGEMENT OR A STUCK IN 4X4 LOW RANGE, WITH NO DIAGNOSTIC TROUBLE CODES STORED IN THE GEM MODULE. *TT Read More »
SOME VEHICLES WITH 4R100 TRANSMISSION MAY EXHIBIT A FLASHING TCIL WITH DIAGNOSTIC TROUBLE CODE (DTC) 1728 IN MEMORY.DTC 1728 IS DEFINED AS INTERNAL TRANSMISSION ELEMENT SLIPPAGE. Read More »
THIS BULLETIN STATES THAT ON SOME VEHICLES (INCLUDING 2002 BLACKWOOD) A BATTERY DISCONNECT OR PARAMETER RESET IS REQUIRED DURING POWERTRAIN CONTROL MODULE (PCM) OR INSTRUMENT CLUSTER (VIC / HEC / ICM) REPLACEMENT. Read More »
INFORMATION ON USING THE SERVICE BAY TECHNICAL SYSTEM (SBTS) AND NEW GENERATION STAR (NGS) TESTER, AND TO UPDATE THE POWERTRAIN CONTROL MODULE (PCM) INFORMATION CHARTS. *TT Read More »
SUBJECT REGARDING ALL VEHICLES REQUIRES A PARAMETER RESET TO BE PERFORMED ON THE PASSIVE ANTI-THEFT SYSTEM MODULE (PATS / VIC / HEC) WHEN THE POWERTRAIN CONTROL MODULE (PCM) IS REPLACED. *TT Read More »
ALL 4X4 VEHICLES WITH ELECTRONIC SHIFT ONTHE FLY TRANSFER CASES WILL DISPLAY CONTACT PLATE PIDS OPPOSITE OF THE 1999 OR EARLIER WORKSHOP MANUAL INDICATES WHEN USING NGS WITH 15.0 LEVEL OR LATER SOFTWARE. Read More »
SUBJECT REGARDING CONTAMINATION FROM PRIOR TRANSMISSION CONCERNS OR EXCESS WEAR MAY BE TRAPPED IN THE TRANSMISSION FLUID COOLING SYSTEM. *TT Read More »
VEHICLES MAY EXPERIENCE SOLID PARTICLE CONTAMINANTS FROM PRIOR TRANSMISSION CONCERNS OR EXCESS WEAR, MAY BE TRAPPED IN THE TRANSMISSION FLUID COOLING SYSTEM IS NOT PROPERLY FLUSHED, FLUID IN-LINE FILTER KIT. Read More »
VEHICLES EQUIPPED WITH THE 5.4L ENGINE, 4R100 TRANSMISSION AND AN AUXILIARY TRANSMISSION OIL COOLER MAY EXHIBIT A COASTDOWN MOAN CONCERN. *TT Read More »
SOME VEHICLES EQUIPPED WITH THE 5.4L ENGINE, 4R100 TRANSMISSION AND AN AUXILIARY TRANSMISSION OIL COOLER MAY EXHIBIT A COASTDOWN MOAN CONCERN. *TT Read More »
SOME VEHICLES EQUIPPED WITH THE 5.4L ENGINE, 4R100 TRANSMISSION AN AUXILIARY TRANSMISSION OIL COOLER MAY EXHIBIT A COASTDOWN MOANING NOISE. *TT Read More »
SOME VEHICLES EQUIPPED WITH 4R100 TRANSMISSION MAY EXHIBIT A DIAGNOSTIC TROUBLE CODE (DTC) P1744 (TORQUE CONVERTER CLUTCH SLIPPAGE DETECTED). *TT Read More »
SOME VEHICLES EQUIPPED WITH 4R100 TRANSMISSION MAY EXHIBIT A DIAGNOSTIC TROUBLE CODE P1744 (TORQUE CONVERTER CLUTCH SLIPPAGE DETECTED). *TT Read More »
POWER TRAIN:AUTOMATIC TRANSMISSION:PARK/NEUTRAL START INTERLOCK SWITCH
SOME VEHICLES MAY EXHIBIT INADVERTENT 4X4 HI OR LOW SHIFT EVENTS, 4X4 AND / OR LOW RANGE INDICATOR FLASHING OR SOLID OR VEHICLE STUCK IN 4L AFTER UNCOMMANDED SHIFT. *TT Read More »
SOME 4X4 VEHICLES BUILT WITH CENTER DISCONNECT FRONT AXLES MAY EXHIBIT A MOANING NOISE FROM THE FRONT DIFFERENTIAL WHILE OPERATING IN 4X2 MODE. *TT Read More »
SOME VEHICLES BUILT AFTER 2/1/1999 EQUIPPED WITH 5.4L-2V ENGINES AND 4R100 TRANSMISSIONS MAY EXHIBIT A DRIVELINE CLUNK / JERK DURING TIP-IN FROM CLOSED THROTTLE AT VEHICLE SPEEDS ABOVE 43 MPH IN 4TH GEAR GEAR AND NORMAL TRANSMISSION ... Read More »
SOME VEHICLES MAY EXPERIENCE AXLE WIND UP AND / OR CLUNKING, POPPING, RATCHETING TYPE NOISES WHEN MAKING CORNERING MANEUVERS ON VEHICLES EQUIPPED WITH A FOUR WHEEL DRIVE HI OR LOW RANGE MODE. *TT Read More »
ADDRESSING CONCERNS OF A LOW SPEED (UNDER 35 MPH) CLICKING NOISE CAUSED BY A CAGE NUT ROCKING ON THE COTTER PIN FOR THE FRONT AXLE HALF SHAFT SPINDLE. *TT Read More »
VEHICLES WITH KEYLESS ENTRY PAD MAY EXHIBIT DEAD BATTERY, NO START, INTERIOR LAMP/HEADLAMP SELF-ACTIVATION, OR INOPERATIVE KEYLESS ENTRY PAD. *TT Read More »
SOME VEHICLES MAY EXHIBIT AN INOPERATIVE COURTESY, GLOVE COMPARTMENT, UNDERHOOD, RUNNING BOARD LAMPS, POWER WINDOWS, RADIO AND REAR WIPER IN THE MORNING OR AFTER VEHICLE IS LEFT UNATTENDED FOR 45 MINUTES. Read More »
CONCERNS WITH COURTESY, GLOVE COMPARTMENT, UNDERHOOD, RUNNING BOARD LAMPS; POWER WINDOWS; RADIO; AND REAR WIPER ALL INOPERATIVE IN THE MORNING OR AFTER VEHICLE IS LEFT UNATTENDED FOR 45 MINUTES. Read More »
FORD MOTOR COMPANY HAS RELEASED A NEW ELECTRICAL GREASE ( F8AZ - 19G208-AA ) TO REDUCE THE POSSIBILITY OF MOISTURE CORROSION AT THE TERMINALS. *YC Read More »
FOR ALL VEHICLES WITH GENERIC ELECTRONIC MODULE (GEM) CONCERNS THAT REQUIRE A MODULE REPLACEMENT, THE TECHNICIAN MUST CALL FOR APPROVAL BEFORE REMOVING AND / OR REPLACING THE MODULE. *TT Read More »
THIS ONLINE BULLETIN MENTIONS THAT VEHICLES BUILT ON OR AFTER 6/25/99 NO LONGER ARE EQUIPPED WITH A MEGA FUSE BRACKET COVER (XL34-14A099-F). THE MEGA FUSE BRACKET IS LOCATED ON THE PASSENGER SIDE OF THE COWL, UNDER THE HOOD. Read More »
SOME IGNITION SWITCH LOCK CYLINDER ASSEMBLIES MAY EXHIBIT ROUGNESS AND / OR EXCESS EFFORT IN TURNING, KEY DOES NOT FULLY RETURN FROM START, A MALFUNCTION INDICATOR LAMP MAY ILLUMINATE WITH P0500, P1502 AND U1039 STORED IN POWERTRIAN ... Read More »
SOME VEHICLES MAY EXHIBIT INTERIOR LIGHTS, POWER WINDOWS AND / OR INOPERATIVE RUNNING BOARD LIGHTS FOR A SHORT PERIOD OF TIME IN THE MORNING. *TT Read More »
DRIVEABILITY-IDLE-HIGH IDLE SPEEDS-THROTTLE STICKS AFTER STEADY STATE DRIVING IN EXTREME COLD AMBIENT TEMPERATURES-VEHICLES BUILT THROUGH 12/31/01 EQUIPPED WITH 4.6L ENGINE. *MJ Read More »
A CONDITION MAY EXIST, WHERE THROTTLE STICKING MAY OCCUR ON A FEW VEHICLES IN VERY COLD AMBIENT TEMPERATURES AFTE OPERATING AT STEADY SPEED OR EXTENDED IDLE FOR A PERIOD OF TIME. *TT Read More »
EXPERIENCING A WHINE / BUZZ TYPE NOISE IN THE SPEAKERS OF THE ENTERTAINMENT RADIO OR TWO-WAY RADIO ON VEHICLES WITH AN IN-TANK ELECTRIC FUEL PUMP. *TT Read More »
SOME VEHICLES EQUIPPED WITH A DUAL MEDIA (AM / FM / CASSETTE / CD) OR AM / FM CASSETTE RADIO MAY EXHIBIT AN INTERMITTENT OR INOPERATIVE REAR SPEAKER. *TT Read More »
VEHICLES MAY EXPERIENCE AIR CONDITIONING INACCURATE AMBIENT TEMPERATURE DISPLAYED- VEHICLES EQUIPPED WITH EATC- CONTINENTAL AND LS BUILT THROUGH 10/15/99, ALL OTHERS BUILT THROUGH 8/31/99. *MJS Read More »
VEHICLES EQUIPPED WITH ELECTRONIC AUTOMATIC TEMPERATURE CONTROL (EATC) , MAY EXERIENCE THE BLOWER MOTOR STAYING ON HIGH AFTER DESIRED TEMPERATURE IS REACHED AND/ OR THE SYSTEM DOES NOT MAINTAIN SET TEMPERATURE. Read More »
INFORMATION ON IDENTIFYING NON-APPROVED / ALTERNATE REFRIGERANTS WHICH COULD CAUSE SAFETY, AND PERFORMANCE CONCERNS IF INSTALLED IN FORD A/C SYSTEMS. *TT Read More »
SOME VEHICLES MAY EXHIBIT DRIVEABILITY CONDITIONS AND / OR CHECK ENGINE LAMP ILLUMINATED WITH A DIAGNOSTIC TROUBLE P0455 (GROSS LEAK DETECTED). *TT Read More »
SOME VEHICLES MAY EXHIBIT DRIVEABILTY CONDITIONS AND/OR CHECK ENGINE LAMP ILLUMINATED WITH A DIAGNOSTIC TROUBLE CODE P0455 (GROSS LEAK DETECTED). *TT Read More »
SOME VEHICLES MAY EXHIBIT A CHECK SUSPENSION LAMP ON WITH DIAGNOSTIC TROUBLE CODES B2140 OR C2140 EVEN AFTER THE AIR SUSPENSION SWITCH IN THE UPPER RH KICK PANEL HAS BEEN TURNED ON. Read More »
CONCERNS WITH VEHICLES EXHIBITING THE OIL PRESSURE GAUGE REGISTERING LOW OR NO OIL PRESSURE USUALLY ON INITIAL START-UP AFTER SEVERAL HOURS OF COLD SOAK. *TT Read More »
A CONDITION MAY EXIST WHERE THE MALFUNCTION INDICATOR LAMP IS ON WITH DIAGNOSTIC TROUBLE CODE P0340 (CAMSHAFT POSITION (CMP) SENSOR A CIRCUIT) STORED, ACCOMPANIED WITH A DRIVEABILITY CONCERN. Read More »
ALL VEHICLES MAY EXHIBIT AN INOPERATIVE OR INACCURATE SPEEDOMETER, 4X4 LIGHT INOPERATIVE AND/OR DTC P1635 AFTER A PCM HAS BEEN REPLACED. *MJS Read More »
INFORMATION ON DIAGNOSING A VEHICLE WITH MALFUNCTION INDICATOR LAMP ILLUMINATED AND DIAGNOSTIC TROUBLE CODES P0442 AND P0455 STORED IN CONTINUOUS MEMORY. *TT Read More »
VEHICLES BUILT BETWEEN 3/15/1997 AND 12/31/1998 AND WITH 4R70W TRANSMISSIONS MAY EXPERIENCE DELAYED OR NO 2-3 UPSHIFT, TRANSMISSION CONTROL INDICATOR LAMP ILLUMINATED WITH DIAGNOSTIC TROUBLE CODE P0782 STORED IN MEMORY. Read More »
SOME VINYL COVERED ITEMS SUCH AS DASH PANELS, DOOR TRIM PANELS, CONSOLES, ETC., MAY EXHIBIT A SMALL DENT, SCUFF, ABRASION AND/ OR DISCOLORATION RESULTING FROM ASSEMBLY, TRANSIT, DEALER PREP AND/OR CUSTOMER USAGE. Read More »
VEHICLES WITH OHV/SOHC, 5.0L 4.6L, 5.4L MAY EXHIBIT A (MIL) ON WITH EVAP SYSTEM DTC'S P1450,PO455,PO466. THE DECEMBER SBDS RELEASE WILL INCLUDED NEW AUTOMATED STATIC LEAK TEST FOR DIANOSING THESE CONCERNS. Read More »
THIS BULLETIN MENTIONS THAT THE INSTRUCTIONS FOR THE OPERATION OF THE KEYLESS ENTRY SYSTEM FOR CERTAIN VEHICLES WERE OMITTED FROM THE OWNERS GUIDE. *TT Read More »
INFORMATION REGARDING THE 1999 SCHEDULED MAINTENANCE GUIDE FOR ANY LIGHT TRUCK, SPORT UTILITY OR VAN EQUIPPED WITH A 4R100 TRANSMISSION NORMAL MAINTENANCE SCHEDULE, IS NOT CORRECT. *MJS Read More »
