This data is from the NHTSA — the US gov't agency tasked with vehicle safety. Complaints are spread across multiple & redundant categories, & are not organized by problem.
So how do you find out what problems are occurring? For this NHTSA complaint data, the only way is to read through the comments below. Any duplicates or errors? It's not us.
Problem with 2020 Ford escape door hinge. It happened about 1,000 miles after warranty ended. Repair shop took pictures and sent to Ford. Ford said it was out of warranty. Since then window will not go down and door is harder and harder to close and lock. 10/9/23 took to be serviced because check engine light would come on and off intermittently along with other messages. They found multiple codes for lost communication. They reprogrammed them. Ford also recommended to reprogram instrument panel. They told me because of door I may still get messages. I still get message about low windshield washer fluid. This is intermittently too. 1/22/24 took car to be inspected. They are concerned about the door. Got call they are trying to replace a part in door but having problems. Car is still at garage.
My vehicle is one of the 2020 Ford Escapes with the broken spot welds on the door control arm. I can no longer operate the driver-side window and Ford wants $2500 to replace the door.
- Detroit, MI, USA
Search CarComplaints.com for these popular complaint phrases...
The driver side door of my 2020 Ford Escape is making a popping noise as the door opens and closes. I have researched that this may be caused by cracks or broken spot welds in the left front door at the check arm attachment point in the door assembly.
The door hinge on the driver side of my 2020 Ford escape snapped causing damage to my window. The spot welds broke. Even though Ford is aware that this is an ongoing problem with this make and model and I pay for an extended warranty. They refused to cover this and are telling me I have to pay for it out of pocket. This door hinge broke about a month ago and I called Ford and they told me that they would not cover it at all. I even called corporate office for Ford and they told me they would not cover it upon bringing my vehicle to formula Ford in Rutland Vermont to have inspected. They refuse to inspect my car, took it to a body shop to have an estimate provided to me and said that they might be able to have Ford cover it upon getting the estimate and contacting ford They refused to pay for it repair and will not inspect my car. I feel that this is unfair since it-??s nothing I did to break this door. It-??s just really crappy craftsmanship.
Approximately 1/4/2024 The front drivers side door is broken. The bolts broke off on the inside.I had no prior warning, I went to open my door and a huge clunk sound happened and it was difficult to open, there was friction, opening it all the way is causing friction and I don-??t want the door to fall off. Also it-??s causing the automatic window not to work now, that only is opening half way. I took it to the dealer to assess the problem and it-??s the left door asy, I looked this up online and it-??s stating Ford is aware of this problem but still hasn-??t issued a recall. I do not want my door to fall off, especially if I-??m driving and this happened. This is also a huge financial burden on anyone, please can you help with this situation. Thank you
Opened the driver's door and heard a crunching sound and the door could not be opened all the way. Along with that the rear back window would not close and the driver's window went up slowly. Went to the dealership and they say it is a known problem, but they don't have any recalls about them so out of pocket it would cost me upwards of 2000 for the window regulators and 5,000 to replace the door which is a known problem.
Door check bracket is popping/clicking as I close & open my drivers side door. Also the window can only roll down 25% of the way now because of the bracket failure
Yesterday when I opened my driver side door there was a grinding/popping noise. I looked on-line and saw that it is the door check defect on the 2020 and 2021 escapes that is an issue with the welding. I called the dealership today and they said because it is over the milage for the warranty that it will not be covered. Ford issued a Technical Service Bulletin TSB-SSM 50150 but there is not a recall and there are several class action lawsuits regarding the issues. I was told to file a report with your agency.
The AWD module (LX6Z 7P238 AANP MODULE) went out on my 2020 Ford Escape. One day when starting my car several warnings popped up on the screen. The warnings were -??AWD off-??, -??Pre-collision assist not available-??, -??Service Advanced Trac-??, -??AWD fault service required-??, -??Up hill assist not available-?? -??Traction control system fault or not available?-?? and the wrench on the dashboard lit up. After googling the issue I found other 2020 Escape owners with the same problem. They all had to have the AWD MODULE replaced. Ford even recalled a select few 2020 Escapes for this issue, even though many more are having the same issue with not many miles on them. Called Ford to get in for a diagnostic and informed them what warnings were flashing. They confirmed it was the AWD MODULE causing the issue and replaced it. The cost was $835.14. Since AWD and traction control were disabled it made the vehicle dangerous to drive in slippery conditions. With the uphill assist disabled, that also made it more dangerous. The safety feature, Pre-collision assist, being disabled put my family and others in danger. Since replacing the Module all the warnings have stopped and everything seems to be back to normal. Ford is aware of this issue and is not taking responsibility for installing faulty AWD modules.
The Spot Weld on the Driver side door is broke. based on information read this is an issue on this vehicle where the hinge breaks where the spot weld is suppose to hold. Has to be replaced and cost is $2400. Dealership said they have repaired a lot of these doors/Hinges. Asking to pay $2400 on an issue that Ford knows. They have a notice 50150 fro NHTSA that it is a known issue. Looking to help in reimbursing. per the site--- the spot welds' failure in the door's arm. In interviews with owners, NHTSA learned of 25 "minor injuries" and 1 report of "minor property damage." Some people have reported a popping noise when the door comes open and say that the door can be unable to latch when closed or can suddenly come open when it had been closed. According to the safety agency's investigation document, the problem is believed to be faulty spot welds in the check arm attachment points on the doors.As one example, an owner reported to NHTSA that "The driver side front door made a creaking sound, could not be opened, and the window would not go down. The internal weld to the door failed."
While driving the car on a busy fast-flowing road the message "Stop Safely Now" appeared on the dashboard. The car lost power and could only be driven at 20 mph and would not speed up. I pulled over and when I stopped but did not power off, the car would not start moving again. After turning the car off for five minutes it drove again properly with no issue. This is the second time this has happened in two months.
Driver's side front door: hinges are not working properly. Initially, the door made three cracking noises when I opened the door on Tuesday, December 12, 2023. I called my Ford dealer (AutonationFord, Scottsdale, AZ) on Wednesday to speak to my Ford Service Advisor Kevin Morgan. He was not at work Wednesday or Thursday but I obtained an appointment for Monday, 12/18/23 at 9:30 AM. On Saturday, 12/16, I rolled the driver's side window down, it took me 5 minutes to get it back up. Of course I had to leave my car on Monday. But my Ford dealer does not offer "loaners" or offer to pay for a rental car. So I borrowed a car from a friend. On Tuesday 12/19, I received a call from Kevin that they could not fix the hinge(s) because they were improperly welded at the factory. Furthermore, they returned my car to my home with instructions to take it to Bell Ford (Phoenix) Body Shop. On Wednesday 12/20, I drove my car to Bell Ford, and they made an appointment for me to drop it off on Wednesday 12/27. They provided me with a loaner car. I thought I would be picking my car up Friday 12/29. I received a call from Will Jones, Mgr. of the Body Shop on Thursday 12/27 that window regulators had been discontinued by Ford but they had found another one and would get it Wednesday, 1/03. So I should get my Ford Escape back on Thursday 1/04, I hope. Now the problem is Ford has not recalled this problem and it's not just my car but other 2020 and 2021 Escapes have the same problem with the driver's side door. I don't know about the window but obviously it "broke" because of the broken hinges. Help! Please get Ford to recall cars with door problems. I should not have to pay for this repair. Thank you for your help!!!! [XXX] (mileage 35,750 but 3 years was up August 2023. To me, this is not a warranty issue.) INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Cracked broken well spots on front left door (driver door) at the check arm attach attachment points in door assembly. Prevent driver window from opening or closing.
The dashboard and main touch screen would not light up in the middle of driving - this would occur every 5 minutes. "System off to save battery please turn ignition off or start engine" pop up would come on main screen while the entire system was done. Another pop up "auto hold system fault" warning would come up as well. Vehicle has been inspected twice by a ford service center and unable to identify the issue. This issue puts the driver at risk for accidents by not knowing the speed at which he/she is driving, fuel capacity, other information that is available on the dashboard if there are issues when it is completely off.
Drivers side door spot welds for the door check bracket broke off the door having me to unable to close the door as I was out Christmas shopping at the Mall. I had to drive back home where I could park the car in a safe location and figure out what happened. Upon inspecting the drivers side door and watching videos of the same issue that other Ford Escape drivers have experienced I used a 6" wheel grinder to cut of the door check bracket in order to be able to close the door. It was dark at this time other wise I would have taken the door panel out and removed the complete bracket and door check. Ford is aware of this situation and has no recall on this. Not buying anymore Ford Products!
A D V E R T I S E M E N T S
- Danville , PA, USA