1994 Dodge Ram Van 3500
119 Technical Service Bulletins (TSBs)
TSB List for the 1994 Dodge Ram Van 3500
Technical Service Bulletins (TSBs) for the 1994 Ram Van 3500 are official communications between Dodge & their dealerships that describe processes for troubleshooting or fixing certain common problems. All vehicle manufacturers are required by U.S. law to make their TSBs available to the public.
STEERING
-
TSB #190399
CONDITIONS WITH STEERING SLOW TO RETURN TO CENTER. *TT Read More »
-
TSB #191097
CUSTOMER MAY COMPLAIN OF STEERING WANDER. *NLM Read More »
-
TSB #CH190495
UNKNOWN Read More »
STEERING: STEERING WHEEL/HANDLE BAR
-
TSB #191397
THIS BULLETIN INVOLVES LOWER STEERING COLUMN NOISE AND/OR MINO LOWER STEERING COLUMN MOVEMENT. *NLM Read More »
-
TSB #190295
CLUNK OR RATTLE FELT IN STEERING WHEEL/COLUMN WHEN DRIVING OVER ROUGH SURFACES. *TW Read More »
SUSPENSION
-
TSB #0200101
SOME CUSTOMERS MAY EXPERIENCE A SITUATION IN WHICH THE REAR OF THE VEHICLE SITS TOO HIGH TO ATTACH THEIR FIFTH WHEEL OR GOOSE NECK TRAILER TO THE TRAILER HITCH TURNABLE. *JB Read More »
-
TSB #020699A
THIS BULLETIN MENTIONS THAT THE FRONT WHEEL BEARING GREASE IS EVIDENT ON THE BEARING SEAL AREA. *TT Read More »
-
TSB #020397
REAR OF VEHICLE IS TO LOW. *YC Read More »
SUSPENSION:FRONT
-
TSB #020595
RATTLING/CLUNK TYPE NOISE FROM FRONT OF VEHICLE. *TW Read More »
SUSPENSION:FRONT:WHEEL BEARING
-
TSB #020699
SUBJECT ON THE FRONT WHEEL BEARING GREASE IS EVIDENT ON THE BEARING SEAL AREA. *TT Read More »
-
TSB #020699
ON SOME VEHICLES THE FRONT WHEEL BEARINGS MAY INCORRECTLY BE DIAGNOSED AS FAULTY DUE TO THE EVIDENCE OF WHEEL BEARING GREASE ON THE BEARING SEAL AREAS. *TT Read More »
SUSPENSION:REAR
-
TSB #020397A
SUBJECT REGARDING REAR OF VEHICLE SITTING TOO LOW. *NLM Read More »
-
TSB #CH030395
UNKNOWN Read More »
SUSPENSION:REAR:SPRINGS:LEAF SPRING ASSEMBLY
-
TSB #020400
SOME CUSTOMERS MAY COMMENT ON A SQUEAKING / CLICKING NOISE FROM REAR LEAF SPRINGS. *TT Read More »
-
TSB #020400
SOME CUSTOMERS MAY COMMENT ON A SQUEAKING / CLICKING NOISE FROM REAR LEAF SPRINGS. *TT Read More »
-
TSB #021399
EXPERIENCING SQUEAKING NOISE FROM REAR LEAF SPRINGS. *TT Read More »
-
TSB #021399
EXPERIENCING SQUEAKING NOISE FROM REAR LEAF SPRINGS. *TT Read More »
SERVICE BRAKES, HYDRAULIC:POWER ASSIST:VACUUM
-
TSB #051199
INFORMATION REGARDING A REVISED POWER BRAKE BOOSTER CHECK VALVE. *TT Read More »
SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS
-
TSB #050699
INFORMATION REGARDING ACCELERATED BRAKE LINING WEAR, FRONT VERSUS REAR. *TT Read More »
-
TSB #050397
BRAKES - CHASSIS DYNAMICS DIAGNOSIS. *TW Read More »
SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DRUM:SHOES/LININGS
-
TSB #050597
CONCERNS WITH ACCELERATED BRAKE LINING WEAR, FRONT VERSUS REAR. *NLM Read More »
SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DISC:PADS
-
TSB #050295
FRONT DISC BRAKE NOISE. *TW Read More »
SERVICE BRAKES, AIR:DRUM:SHOES/LININGS
-
TSB #050497
FRONT BRAKE LINING WEAR PREMATURELY WHEN COMPARED TO THE WEAR EXPERIENCED ON THE REAR BRAKE LININGS. *YC Read More »
ENGINE AND ENGINE COOLING
-
TSB #R2118796A
Valve Body. These may cause over drive cycling. Read More »
-
TSB #9002688
68069384A$, R8069384A$, 68086182A$, R8027067A$, RL002012A$ - Gasket, Cylinder Head Cover Before replacing injectors for Diagnostic Trouble Codes P0201, P0202, P0203, P0204, P0205, and/or P0206, please make sure that the wiring loom ... Read More »
-
TSB #070597
CONCERNS WITH HIGH COOLANT TAMPERATURES OR OVERHEATING WITH SNOWPLOW ATTACHED. *NLM Read More »
-
TSB #070397
CONCERNS WITH ENGINE COOLANT USAGE. *NLM Read More »
ENGINE AND ENGINE COOLING:ENGINE
-
TSB #090500
EXPERIENCING SPARK KNOCK AND ENGINE OIL CONSUMPTION DUE TO INTAKE MANIFOLD PAN GASKET OIL LEAK. *TT Read More »
-
TSB #090500
EXPERIENCING SPARK KNOCK AND ENGINE OIL CONSUMPTION DUE TO INTAKE MANIFOLD PAN GASKET OIL LEAK. *TT Read More »
-
TSB #180798
CUSTOMER MAY BE CONCERN OF INCORRECT IDLE ADJUSTMENTS. *YC Read More »
-
TSB #180698
COMPLAINTS OF HARD OR NO START CONDITONS. *YC Read More »
-
TSB #98736
THE CRANKCASE VENTILATION ORIFICE ON SOME VEHICLES WAS IMPROPERLY INSTALLED INTO THE RIGHT VALVE COVER INSTEAD OF THE LEFT VALVE COVER DURING THE ENGINE REMANUFACTING PROCESS. *YC Read More »
-
TSB #090797
TIMING CHAIN NOISE. *TW Read More »
-
TSB #090497
THIS BULLETIN INVOLVES MOANING NOISE COMING FROM THE ACCESSORY DRIVE. *NLM Read More »
-
TSB #090495
EXCESSIVE OIL DRAINAGE FROM DRAFT TUBE. *TW Read More »
-
TSB #181095
WHISTLING NOISE AT IDLE AND/OR HIGHER THAN NORMAL IDLE. *TW Read More »
-
TSB #090994R
OIL LEAK DIAGNOSIS OF THE REAR MAIN BEARING AREA. *TW Read More »
ENGINE AND ENGINE COOLING:ENGINE:GASOLINE
-
TSB #0900401
CUSTOMER MAY COMPLAIN OF HIGH OIL CONSUMPTION, GREY OIL SMOKE COMING OUT OF THE EXHAUST OR BREATHER TUBE, OR MECHANICAL KNOCKING. *TT Read More »
-
TSB #090699
SUBJECT REGARDING SPARK KNOCK AND ENGINE OIL CONSUMPTION DUE TO INTAKE MANIFOLD PAN GASKET OIL LEAK. *TT Read More »
-
TSB #090699
SUBJECT REGARDING SPARK KNOCK AND ENGINE OIL CONSUMPTION DUE TO INTAKE MANIFOLD PAN GASKET OIL LEAK. *TT Read More »
-
TSB #082197
WHEN VEHICLES IN THE START POSITION, ENGINE WILL NOT CRANK OVER. *YC Read More »
-
TSB #CH090895
UNKNOWN Read More »
-
TSB #180695
ENGINE RUNS POORLY, LACKS POWER, IDLES ROUGH AND/OR BLOWS BLACK SMOKE. *TW Read More »
ENGINE AND ENGINE COOLING:ENGINE:GASOLINE:BELTS AND ASSOCIATED PULLEYS
-
TSB #090498
SOME VEHICLES MAY EXHIBIT A CONDITION WHERE THE ACCESORY DRIVE BELT BECOMES DAMAGED ON THE INBOARD EDGE. *YC Read More »
ENGINE AND ENGINE COOLING:ENGINE:GASOLINE:TURBO/SUPERCHARGER
-
TSB #110898
A NEW KIT HAS BEEN RELEASED THAT WILL ALLOW TECHNICIANS TO REPAIR TURBOCHARGERS WITH FAILED WASTEGATE ACTUATORS. *AK Read More »
ENGINE AND ENGINE COOLING:COOLING SYSTEM
-
TSB #070597
CONCERNS OF HIGH COOLANT TEMPERATURES OR OVERHEATING WITH SNOWPLOW ATTACHED. *YC Read More »
-
TSB #070397
VARIOUS CAR OWNER'S HAVE EXPRESSED INTEREST IN USING ENGINE COOLANTS MADE WITH PROPYLENE GLYCOL INSTEAD OF ETHYLENE GLYCOL. *YC Read More »
ENGINE AND ENGINE COOLING:COOLING SYSTEM:HOSES/LINES/PIPING/FITTINGS
-
TSB #CH070195
UNKNOWN Read More »
ENGINE AND ENGINE COOLING:EXHAUST SYSTEM
-
TSB #110898
A NEW KIT HAS BEEN RELEASED THAT WILL ALLOW TECHNICIANS TO REPAIR TURBOCHARGERS WITH FAILED WASTEGATE ACTUATORS. *AK Read More »
-
TSB #180698
COMPLAINTS OF HARD OR NO START CONDITONS. *YC Read More »
-
TSB #250197
HISSING/SUCTION NOISE COMING FROM THE INLET AIR TUBE OF THE INJECTION PUMP FILTER. *TW Read More »
-
TSB #182894
FLUTTER NOISE FROM ENGINE COMPARTMENT. *TW Read More »
ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL
-
TSB #7631/7632
INFORMATION CONCERNING EMISSIONS RECALLS 7631 AND 7632--VAPOR CANISTER AND PURGE SOLENOID. *AK Read More »
-
TSB #250397
CONDITIONS ON FUEL DOO AND/OR FUEL DISCHARGING FROM THE EVAPORATIVE EMISSIONS CANISTER. *NLM Read More »
ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:MANIFOLD/HEADER/MUFFLER/TAIL PIPE
-
TSB #110197
CONCERNS WITH WHINE OR WOWL WHILE DRIVING AT HIGNWAY SPEEDS. *NLM Read More »
FUEL SYSTEM, GASOLINE
-
TSB #140797
INFORMATION ON DIESEL FUEL INJECTION PUMP TAMPERING. *NLM Read More »
FUEL SYSTEM, GASOLINE:FUEL INJECTION SYSTEM
-
TSB #180698
COMPLAINTS OF HARD OR NO START CONDITONS. *YC Read More »
-
TSB #970718140797
INFORMATION APPLIES TO INLINE INJECTION PUMPS. *YC Read More »
FUEL SYSTEM, GASOLINE:CARBURETOR SYSTEM
-
TSB #090700
SUBJECT PERTAINING TO AIR FILTER SERVICE. *TT Read More »
POWER TRAIN:MANUAL TRANSMISSION
-
TSB #210797
INFORMATION ON TRANSMISSION COOLER REVERSE FLUSHING WITH COOLER BYPASS KIT INSTALLED. *NLM Read More »
POWER TRAIN:AUTOMATIC TRANSMISSION
-
TSB #2100601
AUTOMATIC TRANSMISSION FLUID USAGE ATF+4. *TT *MJ Read More »
-
TSB #2100601
AUTOMATIC TRANSMISSION FLUID USAGE ATF+4. *TT *MJ Read More »
-
TSB #211098
CONDITIONS WITH LOSS OF FIFTH GEAR. *YC Read More »
-
TSB #211098
TRANSMISSION OPERTES NORMALLY THROUGH ALL RANGES EXCEPT FIFTH GEAR. *YC Read More »
-
TSB #CH210595
DELAYED TRANSMISSION ENGAGEMENT OF 2 TO 8 SECONDS. *TW Read More »
-
TSB #CH210495
VIBRATION OR PERCEIVED ENGINE MISS. *TW Read More »
-
TSB #CH210395
RWD AUTOMATIC TRANSMISSION COLD TEMPERATURE COOLER BYPASS KIT. *TW Read More »
-
TSB #080695
TRANSMISSION TEMPERATURE SENSOR - FAULT CODE. *TW Read More »
POWER TRAIN:AUTOMATIC TRANSMISSION:TORQUE CONVERTER
-
TSB #182494
TORQUE CONVERTER LOCKUP. *TW Read More »
POWER TRAIN:DRIVELINE
-
TSB #212194
NEW FRONT OUTPUT SEAL AND OIL SLINGER FOR TRANSFER CASE. *TW Read More »
POWER TRAIN:DRIVELINE:DRIVESHAFT
-
TSB #CH160195
UNKNOWN Read More »
POWER TRAIN:AXLE ASSEMBLY
-
TSB #212594
HIGH EFFORT WHEN SHIFTING FROM 2WD HIGH TO 4WD HIGH IN COLD AMBIENT TEMPERATURES. *TW Read More »
ELECTRICAL SYSTEM
-
TSB #0800600REV
SUBJECT REGARDING WIRE SPLICE REPAIRS. *SB Read More »
-
TSB #0800600REV
SUBJECT REGARDING WIRE SPLICE REPAIRS. *SB Read More »
-
TSB #0832097
INFORMATION REGARDING NHTSA AUTHORIZED AIRBAG DEACTIVATION FOR MEDICAL NECESSITY. *NLM Read More »
ELECTRICAL SYSTEM:WIRING
-
TSB #9002688
68069384A$, R8069384A$, 68086182A$, R8027067A$, RL002012A$ - Gasket, Cylinder Head Cover Before replacing injectors for Diagnostic Trouble Codes P0201, P0202, P0203, P0204, P0205, and/or P0206, please make sure that the wiring loom ... Read More »
-
TSB #080600
THIS BULLETIN PROVIDES A REVISED WIRE SPLICE PROCEDURE AND RELATED PARTS. *TT Read More »
-
TSB #080600
THIS BULLETIN PROVIDES A REVISED WIRE SPLICE PROCEDURE AND RELATED PARTS. *TT Read More »
ELECTRICAL SYSTEM:IGNITION
-
TSB #184898
SUBJECT REGARDING IGNITION SYSTEM CROSS FIRE/ SECONDARY IGNITION WIRE INDUCTION. *AK Read More »
-
TSB #082197
INFORMATION REGARDING NO START - ENGIN FAILED TO CRANK. *NLM Read More »
-
TSB #082197
INFORMATION REGARDING NO START - ENGIN FAILED TO CRANK. *NLM Read More »
-
TSB #CH180995A
ENGINE MISS AND/OR ROUGH IDLE. *TW Read More »
-
TSB #180995
ENGINE MISS AND/OR ROUGH IDLE. *TW Read More »
ELECTRICAL SYSTEM:IGNITION:MODULE
-
TSB #182197
COLD SAG/HESITATION. *TW Read More »
-
TSB #CH181195
SURGE BETWEEN 41 AND 54 MPH. *TW Read More »
-
TSB #241794
PCM NOT PROPERLY DISENGAGING A/C CLUTCH VIA THE RELAY ALSO THE PCM MAY NOT ENERGIZE THE A/C CLUTCH RELAY. *TW Read More »
EXTERIOR LIGHTING:HEADLIGHTS
-
TSB #9829
HEADLAMP HOUSING AND BRACKET SERVICE AVAILABLE TO CORRECT WATER/MOISTURE IN THE HEADLAMPS. *AK Read More »
VISIBILITY
-
TSB #232297
THIS BULLETIN INVOLVES DRIVER'S SIDE WIPER BLADE CONTRACTS A -PILLAR. *NLM Read More »
VISIBILITY:POWER WINDOW DEVICES AND CONTROLS
-
TSB #233997
DRIVER SIDE POWER MIRROR VIBRATES WHILE DRIVING. *TW Read More »
-
TSB #086494
POWER MIRROR WITH VIBRATION OR BLURRED IMAGES. *TW Read More »
VISIBILITY:DEFROSTER/DEFOGGER/HVAC SYSTEM
-
TSB #CH231995
UNKNOWN Read More »
-
TSB #CH231995
REPLACEMENT HEATER - A/C CONTROL KNOBS HAVE BEEN RELEASED. Read More »
AIR BAGS
-
TSB #970919083297
AUTHORIZED AIRBAG DEACTIVATION FOR MEDICAL NECESSITY. *YC Read More »
STRUCTURE:FRAME AND MEMBERS
-
TSB #230397
DIFFICULT TO CLEAN LIGHT COLORED "CHALKY" RESIDUE FROM PLASTIC BODY COMPONENTS THAT ARE MOLDED IN BLACK. *TW Read More »
STRUCTURE:BODY
-
TSB #233599REVA
SUBJECT ON THE CHILD SEAT TETHER ANCHORS. *MJS Read More »
-
TSB #233599REVA
SUBJECT ON THE CHILD SEAT TETHER ANCHORS. *MJS Read More »
-
TSB #234398
THIS BULLETIN IS INTENDED TO ASSIST IN IDENTIFYING WATER LEAK ENTRY POINTS PAST THE DUAL CARGO DOOR SEALS BY HIGHLIGHTING AREAS WHERE LEAKS ARE LIKELY TO OCCUR BASED ON THE EXPERIENCE GAINED DURING THE DEVELOPMENT OF THE VEHICLE. Read More »
-
TSB #231798
CENTER ARM REST UPPER INERTIA LATCH COVER ON DRIVER'S SIDE BROKE. *AK Read More »
-
TSB #236197
THIS BULLETIN INVOLVES OIL CANNING NOISE COMING FROM BOX AREA. *NLM Read More »
STRUCTURE:BODY:DOOR
-
TSB #233598
WHEN REMOVING DOOR TRIM PANEL FROM THE DOOR, IT IS EXTREMELY IMPORTANT THAT EACH INDIVIDUAL PLASTIC RETAINER CLIP IS SEPARATED FROM DOOR BY USING ATRIM PANEL REMOVAL TOO, SUCH AS SNAP ON TOOL A161B/DOOR PANELS SHOULD NEVER BE REMOVED BY ... Read More »
LATCHES/LOCKS/LINKAGES:TAILGATE:LATCH
-
TSB #239894
PICK UP BOX TAILGATE HARD TO LATCH IN COLD TEMPERATURES. *TW Read More »
VEHICLE SPEED CONTROL
-
TSB #180698
COMPLAINTS OF HARD OR NO START CONDITONS. *YC Read More »
VEHICLE SPEED CONTROL:ACCELERATOR PEDAL
-
TSB #180698
COMPLAINTS OF HARD OR NO START CONDITONS. *YC Read More »
VEHICLE SPEED CONTROL:CRUISE CONTROL
-
TSB #180798
CUSTOMER MAY BE CONCERN OF INCORRECT IDLE ADJUSTMENTS. *YC Read More »
TIRES
-
TSB #220197
INFORMATION ON TIRE AND WHEEL RUNOUT. *NLM Read More »
SEATS
-
TSB #2300800B
SUBJECT REGARDING CHILD SEAT TETHER ANCHORS. *TT Read More »
-
TSB #2300800B
SUBJECT REGARDING CHILD SEAT TETHER ANCHORS. *TT Read More »
-
TSB #230800
SUBJECT REGARDING CHILD SEAT TETHER ANCHORS. *TT Read More »
-
TSB #233599
INFORMATION ON CHILD SEAT TETHER ANCHORS. *TT Read More »
-
TSB #233599
INFORMATION ON CHILD SEAT TETHER ANCHORS. *TT Read More »
EQUIPMENT
-
TSB #9002688
68069384A$, R8069384A$, 68086182A$, R8027067A$, RL002012A$ - Gasket, Cylinder Head Cover Before replacing injectors for Diagnostic Trouble Codes P0201, P0202, P0203, P0204, P0205, and/or P0206, please make sure that the wiring loom ... Read More »
EQUIPMENT:ELECTRICAL:RADIO/TAPE DECK/CD ETC.
-
TSB #081600
CONCERNS WITH A BUZZ NOISE COMING FROM THE FRONT DOOR SPEAKER(S). *TT Read More »
-
TSB #081698
INFORMATION ON INSTALLATION OF RADIO TRANSMITTING EQUIPMENT. *AK Read More »
EQUIPMENT:APPLIANCE:AIR CONDITIONER
-
TSB #241197
CONCERNS WITH A/C EVAPORATOR ODOR. *NLM Read More »
-
TSB #CH240695A
UNKNOWN Read More »
-
TSB #CH240895
UNKNOWN Read More »
UNKNOWN OR OTHER
-
TSB #1802002
FLASH PROGRAMMING FAILURE RECOVERY. *SLC Read More »
-
TSB #230899
EXHIBITING CREAKS OR SQUEAKS NEAR THE LEFT AND / OR RIGHT SIDE OF THE INSTRUMENT PANEL. *TT Read More »
-
TSB #232797
CONCERN WITH WATER LEAKING THROUGH REAR WINDOW. *NLM Read More »