Technical Service Bulletins (TSBs) for the 2001 Ram 3500 are official communications between Dodge & their dealerships that describe processes for troubleshooting or fixing certain common problems.
All vehicle manufacturers are required by U.S. law to make their TSBs available to the public.
SOME CUSTOMERS MAY EXPERIENCE A SITUATION IN WHICH THE REAR OF THE VEHICLE SITS TOO HIGH TO ATTACH THEIR FIFTH WHEEL OR GOOSE NECK TRAILER TO THE TRAILER HITCH TURNABLE. *JB Read More »
VEHICLES BUILT BETWEEN APRIL 19, 2000 AND JUNE 26, 2000 WERE BUILT WITH A FRONT BRAKE CALIPER ANTI-RATTLE CLIP RETAINER. THIS TECHNICAL SERVICE BULLETIN PROVIDES THE INSTALLATION PROCEDURES FOR THE RETAINER. Read More »
Cummins Equipped Vehicles ONLY - The replacement oil pan gasket can be a four piece gasket rather than a single piece gasket. This applies to Cummins 5.9L and 6.7L engines only. Read More »
Service - Four Piece Oil Pan Gasket All Cummins Equipped Vehicles ONLY - The replacement oil pan gasket can be a four piece gasket rather than a single piece gasket. This applies to Cummins 5.9L and 6.7L engines only. Installation: 1. Read More »
68069384A$, R8069384A$, 68086182A$, R8027067A$, RL002012A$ - Gasket, Cylinder Head Cover Before replacing injectors for Diagnostic Trouble Codes P0201, P0202, P0203, P0204, P0205, and/or P0206, please make sure that the wiring loom ... Read More »
EMISSIONS RECALL E07-CANISTER PURGE HOSES. THE CANISTER PURGE HOSES ON ABOUT 7,800 OF THE ABOVE VEHICLES MAY DEVELOP CRACKS OVER TIME AND RELEASE EVAPORATIVE HYDROCARBON (HC) WHICH COULD EXCEED FEDERAL EMISSION STANDARDS. Read More »
GENERIC CUMMINS ENGINE CONTROL MODULE (PCM) PROCEDURE. *TT THIS BULLETIN REPLACED 18-030-03. *TT THIS BULLETIN REPLACED 18-030-03A DATED 10/17/03. TO ALSO INCLUDE 2005 RAM TRUCK. *TT Read More »
ADVANCE SERVICE INFORMATION REGARDING THE ADDITION OF THE LEAK DETECTION PUMP SYSTEM ON ALL FEDERAL AND CALIFORNIA VEHICLES EQUIPPED WITH GASOLINE ENGINES. OTHER CHANGES INCLUDE THE INTRODUCTION OF THE HIGH OUTPUT 5. Read More »
CUSTOMER MAY COMPLAIN OF POOR DRIVEABILITY WHEN WINTER FUEL IS USED TO POWER THE ENGINE. OR, THE CUSTOMER MAY COMPLAIN OF A HARD OR NO-START CONDITION, WHILE THE ENGINE IS AT NORMAL OPERATING TEMPERATURES, WHEN USING ANY TYPE OF GOOD ... Read More »
CUSTOMERS MAY COMPLAIN OF POOR DRIVEABILITY WHEN WINTER FUEL IS USED TO POWER THE ENGINE AND / OR A NO START HOT ENGINE RESTART CONDITION WHEN USING ANY TYPE OF GOOD QUALITY DIESEL FUEL. *TT Read More »
ADVANCE SERVICE INFORMATION REGARDING THE LOW FUEL OUTPUT FROM THE TRANSFER PUMP CAUSING A HARD START AND / OR A NO-START CONDITION AFTER APPROXIMATELY 9,000 MILES OF ENGINE OPERATION. Read More »
FUEL SYSTEM, GASOLINE:DELIVERY:HOSES, LINES/PIPING, AND FITTINGS
Charging System, Battery Diagnostic Tools and Warranty This information only bulletin discusses using the correct test equipment for testing batteries and charging systems, and also warranty reimbursement when battery replacements are ... Read More »
56045489A$ - Neutral Safety Switch - Trans Assy 06036369AA Screw and Washer is now available as a service part , 2 required to attach Neutral Start Switch Read More »
68069384A$, R8069384A$, 68086182A$, R8027067A$, RL002012A$ - Gasket, Cylinder Head Cover Before replacing injectors for Diagnostic Trouble Codes P0201, P0202, P0203, P0204, P0205, and/or P0206, please make sure that the wiring loom ... Read More »
56045489A$ - Neutral Safety Switch - Trans Assy 06036369AA Screw and Washer is now available as a service part , 2 required to attach Neutral Start Switch Read More »
KEY, Master If replacing the key/FOBIK on a WJ, KJ, TJ, or PT Cruiser, use the "AC" NIC level part number. The "AB" NIC level will not program to these platforms. Read More »
KEY, Master If replacing the key/FOBIK on a WJ, KJ, TJ, or PT Cruiser, use the "AC" NIC level part number. The "AB" NIC level will not program to these platforms. Read More »
56045489A$ - Neutral Safety Switch - Trans Assy 06036369AA Screw and Washer is now available as a service part , 2 required to attach Neutral Start Switch Read More »
Repair Parts Used For Structural Repairs This bulletin involves discussing FCA US LLC position with regard to structural repair parts usage. Read More »
Use of Aftermarket Parts This bulletin involves discussing FCA US LLC position with regard to collision repair industry awareness regarding the use of aftermarket parts. Read More »
Repair Parts Used For Structural Repairs This bulletin involves discussing FCA US LLC position with regard to structural repair parts usage. Read More »
Use of Aftermarket Parts This bulletin involves discussing FCA US LLC position with regard to collision repair industry awareness regarding the use of aftermarket parts. Read More »
Use of Salvage/Recycled Parts This bulletin involves discussing FCA US LLC position with regard to collision repair industry awareness regarding the use of recycled or salvage parts. Read More »
Part Description: Insulator in Lever Assembly - Valve Body - Trans Issue Description: The manual valve insulator, attaching rivet and an instruction sheet are now available as a kit. Read More »
Part Description: Insulator on Lever Assy Manual Valve - Valve Body - RWD Transmission Issue Description: The manual valve insulator, attaching rivet and instruction sheet are now available as a kit. Read More »
A CONDITION MAY EXIST WITH THE DOOR LOCKS INTERMITTENTLY LOCKING AND / OR UNLOCKING WITHOUT ANY ACTIVATION OF THE POWER DOOR LOCK SWITCH OR A CLICKING SOUND HEARD COMING FROM THE POWER DOOR LOCKS (REPEATED LOCKING OR REPEATED UNLOCKING). Read More »
Charging System, Battery Diagnostic Tools and Warranty This information only bulletin discusses using the correct test equipment for testing batteries and charging systems, and also warranty reimbursement when battery replacements are ... Read More »
Use of Salvage/Recycled Parts This bulletin involves discussing FCA US LLC position with regard to collision repair industry awareness regarding the use of recycled or salvage parts. Read More »
Use of Aftermarket Parts This bulletin involves discussing FCA US LLC position with regard to collision repair industry awareness regarding the use of aftermarket parts. Read More »
Repair Parts Used For Structural Repairs This bulletin involves discussing FCA US LLC position with regard to structural repair parts usage. Read More »
Part Description: Insulator in Lever Assembly - Valve Body - Trans Issue Description: The manual valve insulator, attaching rivet and an instruction sheet are now available as a kit. Read More »
Part Description: Insulator on Lever Assy Manual Valve - Valve Body - RWD Transmission Issue Description: The manual valve insulator, attaching rivet and instruction sheet are now available as a kit. Read More »
68069384A$, R8069384A$, 68086182A$, R8027067A$, RL002012A$ - Gasket, Cylinder Head Cover Before replacing injectors for Diagnostic Trouble Codes P0201, P0202, P0203, P0204, P0205, and/or P0206, please make sure that the wiring loom ... Read More »
SUBJECT REGARDING GENERIC SCAN TOOL (GST), PUBLICATION NO. 81-170-00008 PROVIDED WITH THIS TECHNICAL SERVICE BULLETIN TO PROVIDE REFERENCE INFORMATION WHEN USING GENERIC SCAN TOOL ON OBDII VEHICLES. Read More »
82212076, 82203694 - Fabric Cleaner This "fabric cleaner" is not intended for sale in California, the otc states (Connecticut, Delaware, Massachusetts, Maine, New Hampshire, New Jersey, New York, Pennsylvania, Virginia, and Washington ... Read More »
REVISION OF FLASH PROCESS FOR NEW ENGINE CONTROL MODULE (ECM) FROM CUMMINS. *SLC THIS BULLETIN SUPERSEDES BULLETIN 18-019-02 DATED JUNE 17, 2002. *TT Read More »
CUSTOMER WILL EXPERIENCE MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATION. THIS BULLETIN INVOLVES SELECTIVELY ERASING AND REPROGRAMMING THE POWERTRAIN CONTROL MODULE (PCM) WITH NEW SOFTWARE. Read More »
SOME CUSTOMERS MAY COMPLAIN OF A MALFUNCTION INDICATOR LAMP ILLUMINATION DUE TO DIAGNOSTIC TROUBLE CODE P1740 - TCC OR OD SOLENOID PERFORMANCE. *TT Read More »
