Technical Service Bulletins (TSBs) for the 1998 Ram 3500 are official communications between Dodge & their dealerships that describe processes for troubleshooting or fixing certain common problems.
All vehicle manufacturers are required by U.S. law to make their TSBs available to the public.
SOME CUSTOMERS MAY EXPERIENCE A SITUATION IN WHICH THE REAR OF THE VEHICLE SITS TOO HIGH TO ATTACH THEIR FIFTH WHEEL OR GOOSE NECK TRAILER TO THE TRAILER HITCH TURNABLE. *JB Read More »
This SKU is a front upper ball joint. The Customer communication requested return of unsold inventory to inspect for ball studs with excessive rotational friction in the ball joint assembly. Read More »
ON SOME VEHICLES THE FRONT WHEEL BEARINGS MAY INCORRECTLY BE DIAGNOSED AS FAULTY DUE TO THE EVIDENCE OF WHEEL BEARING GREASE ON THE BEARING SEAL AREAS. *TT Read More »
VEHICLES LISTED ON THIS BULLETIN ARE EQIPPED WITH REAR HEIGHT SENSING PROPORTIONING VALVE THAT ADJUST BRAKE PRESSURE TO THE REAR BRAKES BASED UPON DISTANCE BETWEEN FRAME AND REAR AXLE. *AK Read More »
Cummins Equipped Vehicles ONLY - The replacement oil pan gasket can be a four piece gasket rather than a single piece gasket. This applies to Cummins 5.9L and 6.7L engines only. Read More »
Service - Four Piece Oil Pan Gasket All Cummins Equipped Vehicles ONLY - The replacement oil pan gasket can be a four piece gasket rather than a single piece gasket. This applies to Cummins 5.9L and 6.7L engines only. Installation: 1. Read More »
68069384A$, R8069384A$, 68086182A$, R8027067A$, RL002012A$ - Gasket, Cylinder Head Cover Before replacing injectors for Diagnostic Trouble Codes P0201, P0202, P0203, P0204, P0205, and/or P0206, please make sure that the wiring loom ... Read More »
GENERIC CUMMINS ENGINE CONTROL MODULE (PCM) PROCEDURE. *TT THIS BULLETIN REPLACED 18-030-03. *TT THIS BULLETIN REPLACED 18-030-03A DATED 10/17/03. TO ALSO INCLUDE 2005 RAM TRUCK. *TT Read More »
SOME AFTER MARKET EXHAUST BRAKE INSTALLATIONS, ESPECIALLY THOSE WITH SWITCHES THAT CONNECT TO THE THROTTLE PEDAL, CAN CAUSE MIL ILLUMINATION WITH TSC PO121- ACCEL POSITION SENSOR VOLTS DO NOT AGREE W/IDLE VALIDATION SIG. Read More »
CUSTOMER MAY COMPLAIN OF POOR DRIVEABILITY WHEN WINTER FUEL IS USED TO POWER THE ENGINE. OR, THE CUSTOMER MAY COMPLAIN OF A HARD OR NO-START CONDITION, WHILE THE ENGINE IS AT NORMAL OPERATING TEMPERATURES, WHEN USING ANY TYPE OF GOOD ... Read More »
ILLUMINATED MIL AS THE RESULT OF A DIAGNOSTIC TROUBLE CODE (DTC) P0420 - CATALYST EFFICIENCY, OR MAY HAVE FAILED A CALIFORNIA SMOG OR STATE I/M TEST BUT WITHOUT AN ILLUMINATED MIL, OR A RATTLING SOUND FROM THE UNDERSIDE OF THE VEHICLE. Read More »
EMISSIONS RECALL NO. 817 REGARDING THE POWERTRAIN CONTROL MODULE NOT ILLUMINATING THE MAINTENANCE REQUIRED LIGHT AS SPECIFIED BY FEDERAL REGULATIONS. *TT Read More »
NOX EMISSION LEVELS MAY EXCEEDCALIFORNIA AIR RESOURCES BOARD (CARB) EMISSION STANDARDS. TO CORRECT THIS CONDITION,PCV AND BRAKE BOOSTER HOSES MUST BE REPLACED AND REROUTED. *AK Read More »
WITH INTRODUCTION OF CUMMINS 24 VALVE ELECTRONICALL INJECTED ENGINE, A NEW FUEL INJECTION PUMP WAS INTRODUCED. FUEL INJECTION PUMP REQUIRES FINER FUEL FILTRATION DUE TOTIGHTER TOLERANCE WITHIN PUMP. Read More »
INFORMATION REGARDING 5.9L CUMMINS ELECTRONICALLY INJECTED 24 VALVE ENCORE DIESEL/IT HAS BEEN FOUND THAT INTERFERENCE FIT BETWEEN HIGH PRESSURE FUEL LINE AND INJECTOR CONNECTOR TUBE WILL ONLY SEAL PROPERLY THE FIRST TIME IT IS TORQUED TO ... Read More »
This SKU is an Automatic Transmission Oil Cooler Line. The Customer communication requested return of unsold inventory to inspect for improperly crimped hose fittings. Read More »
POWER TRAIN:CLUTCH ASSEMBLY:PEDAL/HAND LEVER(MOTORCYCLE)
WHEN SERVICING THE RELEASE FORK IT IS NECESSSARY TO INSURE THAT THE FORK IS INSTALLED PROPERLY. FAILURE TO DO SO, CAN CAUSE A LOW GROWLING SOUND TO COME THROUGH THE CLUTCH PEDAL WHEN THE PEDAL IS DEPRESSED. Read More »
Charging System, Battery Diagnostic Tools and Warranty This information only bulletin discusses using the correct test equipment for testing batteries and charging systems, and also warranty reimbursement when battery replacements are ... Read More »
68069384A$, R8069384A$, 68086182A$, R8027067A$, RL002012A$ - Gasket, Cylinder Head Cover Before replacing injectors for Diagnostic Trouble Codes P0201, P0202, P0203, P0204, P0205, and/or P0206, please make sure that the wiring loom ... Read More »
KEY, Master If replacing the key/FOBIK on a WJ, KJ, TJ, or PT Cruiser, use the "AC" NIC level part number. The "AB" NIC level will not program to these platforms. Read More »
KEY, Master If replacing the key/FOBIK on a WJ, KJ, TJ, or PT Cruiser, use the "AC" NIC level part number. The "AB" NIC level will not program to these platforms. Read More »
Repair Parts Used For Structural Repairs This bulletin involves discussing FCA US LLC position with regard to structural repair parts usage. Read More »
Use of Aftermarket Parts This bulletin involves discussing FCA US LLC position with regard to collision repair industry awareness regarding the use of aftermarket parts. Read More »
Repair Parts Used For Structural Repairs This bulletin involves discussing FCA US LLC position with regard to structural repair parts usage. Read More »
Use of Salvage/Recycled Parts This bulletin involves discussing FCA US LLC position with regard to collision repair industry awareness regarding the use of recycled or salvage parts. Read More »
Use of Aftermarket Parts This bulletin involves discussing FCA US LLC position with regard to collision repair industry awareness regarding the use of aftermarket parts. Read More »
Part Description: Insulator on Lever Assy Manual Valve - Valve Body - RWD Transmission Issue Description: The manual valve insulator, attaching rivet and instruction sheet are now available as a kit. Read More »
VEHICLES EQUIPPED WITH SPLASH GUARDS MAY EXPERIENCE DISCOLORATION/ OR DISTORTION ALONG THE EDGE OF THE PASSENGER'S SIDE REAR SPLASH GUARD DUE TO THE PROXIMITY TO THE TAILPIPE. *AK Read More »
WHEN REMOVING DOOR TRIM PANEL FROM THE DOOR, IT IS EXTREMELY IMPORTANT THAT EACH INDIVIDUAL PLASTIC RETAINER CLIP IS SEPARATED FROM DOOR BY USING ATRIM PANEL REMOVAL TOO, SUCH AS SNAP ON TOOL A161B/DOOR PANELS SHOULD NEVER BE REMOVED BY ... Read More »
SOME CUSTOMERS MAY COMPLAIN THAT THEIR VEHICLE SPEED COTNROL SYSTEM MAY BE TOO BUSY OR DRIFT MORE THAN 2 MPH BELOW OR ABOVE THE INITIAL VEHICLE SET SPEED. *TT Read More »
VEHICLE MAY BUCK/JERK WHILE UNDER LIGHT ACCELERATION OR WHILE DRIVING AT STEADY STATE SPEED DUE TO THE SENSITIVITY OF THROTTLE LINKAGE TO DRIVE RINPUT. *AK Read More »
Charging System, Battery Diagnostic Tools and Warranty This information only bulletin discusses using the correct test equipment for testing batteries and charging systems, and also warranty reimbursement when battery replacements are ... Read More »
Use of Salvage/Recycled Parts This bulletin involves discussing FCA US LLC position with regard to collision repair industry awareness regarding the use of recycled or salvage parts. Read More »
Use of Aftermarket Parts This bulletin involves discussing FCA US LLC position with regard to collision repair industry awareness regarding the use of aftermarket parts. Read More »
Repair Parts Used For Structural Repairs This bulletin involves discussing FCA US LLC position with regard to structural repair parts usage. Read More »
Part Description: Insulator on Lever Assy Manual Valve - Valve Body - RWD Transmission Issue Description: The manual valve insulator, attaching rivet and instruction sheet are now available as a kit. Read More »
68069384A$, R8069384A$, 68086182A$, R8027067A$, RL002012A$ - Gasket, Cylinder Head Cover Before replacing injectors for Diagnostic Trouble Codes P0201, P0202, P0203, P0204, P0205, and/or P0206, please make sure that the wiring loom ... Read More »
SUBJECT REGARDING GENERIC SCAN TOOL (GST), PUBLICATION NO. 81-170-00008 PROVIDED WITH THIS TECHNICAL SERVICE BULLETIN TO PROVIDE REFERENCE INFORMATION WHEN USING GENERIC SCAN TOOL ON OBDII VEHICLES. Read More »
REVISION OF FLASH PROCESS FOR NEW ENGINE CONTROL MODULE (ECM) FROM CUMMINS. *SLC THIS BULLETIN SUPERSEDES BULLETIN 18-019-02 DATED JUNE 17, 2002. *TT Read More »
