Technical Service Bulletins (TSBs) for the 2017 Challenger are official communications between Dodge & their dealerships that describe processes for troubleshooting or fixing certain common problems.
All vehicle manufacturers are required by U.S. law to make their TSBs available to the public.
Electric Power Steering Gear For LA, LD and LX Models ONLY; Before this part is replaced for: A) Electrical, Communication or DTC issue please contact: Terry Gavit @ cell (248) 882-6108 terry.gavit@fcagroup. Read More »
Electric Power Steering Gear For LA, LD and LX Models ONLY; Before this part is replaced for: A) Electrical, Communication or DTC issue please contact: Terry Gavit @ cell (248) 882-6108 terry.gavit@fcagroup. Read More »
LIFTER, Hydraulic Roller Deactivating Please do not replace MDS lifters because the disconnecting pin is not lined up, this is normal and not a defect. Read More »
Air Suspension Components Star Parts Catalog has been updated to show individual service parts for the compressor assembly. This will allow service technicians to repair the root cause without over repairing the system. Read More »
A/C Pressure Transducer A/C inoperative and diagnosis leads to pressure transducer. Call Steve Rice at cell (248) 867-0061 before replacing the pressure transducer. If no response in 15 minutes, please proceed with repair. Read More »
Rotor - Front 2 Piece For LA, LD SRT vehicles with the 2-piece Front Rotor (BR7 sales code), do NOT replace the rotor for a clicking noise occurring while turning at low parking lot speeds. Read More »
ADAPTER, Engine Oil Filter (Pentastar V6) For all 2014MY replace the Oil Filter Adapter (OFA). For any other MY review and follow instructions from the latest STAR Online S1809000007 available on Dealer Connect. Read More »
ADAPTER, Engine Oil Filter (Pentastar V6) For all 2014MY replace the Oil Filter Adapter (OFA). For any other MY review and follow instructions from the latest STAR Online S1809000007 available on Dealer Connect. Read More »
ADAPTER, Engine Oil Filter (Pentastar V6) For all 2014MY replace the Oil Filter Adapter (OFA). For any other MY (with mileage above 30,000) review and follow instructions from STAR Online S1809000007 REV. C available on Dealer Connect. Read More »
If a Mopar oil filter is not available, use a filter that meets or exceeds USCAR36 specification and is compatible with semi and full synthetic oils. Read More »
Front Click Noise at Low Speed Turns This bulletin involves installing a friction disc kit on both front hub bearing surfaces between the hub and rotor. Read More »
Issue involves overheating, running hot, coolant leaks and related symptoms after a Mopar replacement engine has been installed in the vehicle. Read More »
Issue involves overheating, running hot, coolant leaks and related symptoms after a Mopar replacement engine has been installed in the vehicle. Read More »
Transmission Oil Pan, Heater (TMU), Tube or O-ring Applies to vehicles equipped with 8 speed transmissions only; if you have a leak that appears to be at the pan the use of proper leak detection is recommended. Read More »
Transmission Oil Pan, Heater (TMU), Tube or O-ring Applies to vehicles equipped with 8 speed transmissions only; if you have a leak that appears to be at the pan the use of proper leak detection is recommended. Read More »
CORE, Heater (with tubes) When replacing the heater core for LA, LX, and LD vehicles, make sure to return not only the heater core but also the connecting tubes, seals and retainers. For any questions contact FCA Redacted Content. Read More »
Rotor - Front 2 Piece For LA, LD SRT vehicles with the 2-piece Front Rotor (BR7 sales code), do NOT replace the rotor for a clicking noise occurring while turning at low parking lot speeds. Read More »
Pentastar Oil Filter Adapter All vehicles equipped with a 3.2L or 3.6L engine; If replacing the Oil Filter Adapter (OFA) due to a leak detected between OFA and block, an O-ring kit (68191356AA) is now available to repair OFA/Block ... Read More »
Pentastar Oil Filter Adapter All vehicles equipped with a 3.2L or 3.6L engine; If replacing the Oil Filter Adapter (OFA) due to a leak detected between OFA and block, an O-ring kit (68191356AA) is now available to repair OFA/Block ... Read More »
Oil Pump Assembly If error code P06DD present on any Pentastar V6 application, please inspect oil pump for relief valve failure. See photo attached. If valve is found out of place please call Bob Jackson (248) 944-0466 bob. Read More »
Intake Manifold Gasket Intake Manifold Gaskets on Pentastar Upgrade (Sales Code ERC/ERF) are reusable provided they are not cut, torn or melted. Read More »
5.7L Cold End Exhaust RH Side (Resonator & Muffler) Engineering is currently investigating an issue where the back-end exhaust system (resonator and muffler right hand assembly) cracks at or around the weld near the muffler with Model ... Read More »
ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL
Transmission Oil Pan, Heater (TMU), Tube or O-ring Applies to vehicles equipped with 8 speed transmissions only; if you have a leak that appears to be at the pan the use of proper leak detection is recommended. Read More »
Oil Pump Assembly If error code P06DD present on any Pentastar V6 application, please inspect oil pump for relief valve failure. See photo attached. If valve is found out of place please call Bob Jackson (248) 944-0466 bob. Read More »
Front Click Noise at Low Speed Turns This bulletin involves installing a friction disc kit on both front hub bearing surfaces between the hub and rotor. Read More »
Front Click Noise at Low Speed Turns This bulletin involves installing a friction disc kit on both front hub bearing surfaces between the hub and rotor. Read More »
Transmission Kit with Torque Converter 1. All Promaster (VF) 3.6L/62TE equipped vehicles. If the transmission bracket to the transmission case fasteners are removed during servicing, the fasteners (Part Number 06511385A$) are one-time ... Read More »
Flash: Powertrain Control Module (PCM) Updates This bulletin involves reprogramming the PCM with updated software. Customers may experience a Malfunction Indicator Lamp (MIL) illumination. Read More »
Flash: Powertrain Control Module (PCM) Updates This bulletin involves reprogramming the PCM with updated software. Customers may experience a Malfunction Indicator Lamp (MIL) illumination. Read More »
Transmission Oil Pan, Heater (TMU), Tube or O-ring Applies to vehicles equipped with 8 speed transmissions only; if you have a leak that appears to be at the pan the use of proper leak detection is recommended. Read More »
Transmission Oil Pan, Heater (TMU), Tube or O-ring Applies to vehicles equipped with 8 speed transmissions only; if you have a leak that appears to be at the pan the use of proper leak detection is recommended. Read More »
Transmission Oil Pan, Heater (TMU), Tube or O-ring Applies to vehicles equipped with 8 speed transmissions only; if you have a leak that appears to be at the pan the use of proper leak detection is recommended. Read More »
Transfer case seal, Transmission Output Seal If vehicle has a fluid leak between the transfer case and the transmission on an AWD vehicle and it has been determined that the transfer case is leaking from the vent hole, don't replace the ... Read More »
Flash: Transmission Diagnostic and Shift Enhancements This bulletin involves reprogramming the Transmission Control Module (TCM) with the latest available software. Customers may experience a Malfunction Indicator Lamp (MIL) illumination. Read More »
Flash: Transmission Diagnostic and Shift Enhancements This bulletin involves reprogramming the Transmission Control Module (TCM) with the latest available software. Read More »
Flash: Transmission Diagnostic and Shift Enhancements This bulletin involves reprogramming the Transmission Control Module (TCM) with the latest available software. Read More »
Flash: Powertrain Diagnostic and System Improvements This bulletin involves reprogramming the Powertrain Control Module (PCM) with the latest available software. Read More »
Flash: Powertrain Diagnostic and System Improvements This bulletin involves reprogramming the Powertrain Control Module (PCM) with the latest available software. Read More »
Flash: Transmission Diagnostic and Shift Enhancements This bulletin involves reprogramming the Transmission Control Module (TCM) with the latest available software. Read More »
Flash: Powertrain Diagnostic and System Improvements This bulletin involves reprogramming the Powertrain Control Module (PCM) with the latest available software. Read More »
Flash: Transmission Diagnostic and Shift Enhancements This bulletin involves reprogramming the Transmission Control Module (TCM) with the latest available software. Read More »
Flash: Powertrain Diagnostic And System Enhancements This bulletin involves reprogramming the Powertrain Control Module (PCM) with the latest available software. Read More »
Flash: Transmission Diagnostic And Shift Enhancements This bulletin involves reprogramming the Transmission Control Module (TCM) with the latest available software. Read More »
Flash: Powertrain Diagnostic And System Enhancements This bulletin involves reprogramming the Powertrain Control Module (PCM) with the latest available software. Read More »
Flash: Transmission Diagnostic And Shift Enhancements This bulletin involves reprogramming the Transmission Control Module (TCM) with the latest available software. Read More »
Electric Power Steering Gear For LA, LD and LX Models ONLY; Before this part is replaced for: A) Electrical, Communication or DTC issue please contact: Terry Gavit @ cell (248) 882-6108 terry.gavit@fcagroup. Read More »
Oil Filter If a Mopar Oil Filter is not available, use a filter that meets or exceeds USCAR36 specification and is compatible with semi and full synthetic oils. Read More »
Incorrect Serpentine Belt This bulletin involves inspecting and replacing the serpentine belt if necessary. The customer may experience serpentine drive belt squeal and reduced drive belt life expectancy. Read More »
Front Click Noise at Low Speed Turns This bulletin involves installing a friction disc kit on both front hub bearing surfaces between the hub and rotor. Read More »
Connector kit Before ordering this connector repair kit 68018957A$, check it in the Mopar Connector Repair Kit Website to confirm part number and applicability. Read More »
Start Stop Charging Warning Lamp Illuminated On, Intelligent Battery Sensor (IBS) State of Charge (SOC) Inaccurate, Battery Charging Message, Presence of IBS related Diagnostic Trouble Codes (DTCs), or Battery Warning Lamp ... Read More »
Front Click Noise at Low Speed Turns This bulletin involves installing a friction disc kit on both front hub bearing surfaces between the hub and rotor. Read More »
Front Click Noise at Low Speed Turns This bulletin involves installing a friction disc kit on both front hub bearing surfaces between the hub and rotor. Read More »
Front Click Noise at Low Speed Turns This bulletin involves installing a friction disc kit on both front hub bearing surfaces between the hub and rotor. Read More »
Flash: Powertrain Control Module (PCM) Updates This bulletin involves reprogramming the PCM with updated software. Customers may experience a Malfunction Indicator Lamp (MIL) illumination. Read More »
Flash: Powertrain Control Module (PCM) Updates This bulletin involves reprogramming the PCM with updated software. Customers may experience a Malfunction Indicator Lamp (MIL) illumination. Read More »
Driver Window Short Drop Feature Does Not Drop The Window When The Door Is Open, Window Short Up Feature Does Raise The Window When The Door Is Closed Read More »
Driver Window Short Drop Feature Does Not Drop The Window When The Door Is Open, Window Short Up Feature Does Raise The Window When The Door Is Closed Read More »
Charging System, Battery Diagnostic Tools and Warranty This information only bulletin discusses using the correct test equipment for testing batteries and charging systems, and also warranty reimbursement when battery replacements are ... Read More »
Flash: Transmission Diagnostic and Shift Enhancements This bulletin involves reprogramming the Transmission Control Module (TCM) with the latest available software. Customers may experience a Malfunction Indicator Lamp (MIL) illumination. Read More »
Flash: Transmission Diagnostic and Shift Enhancements This bulletin involves reprogramming the Transmission Control Module (TCM) with the latest available software. Read More »
Flash: Transmission Diagnostic and Shift Enhancements This bulletin involves reprogramming the Transmission Control Module (TCM) with the latest available software. Read More »
Flash: Powertrain Diagnostic and System Improvements This bulletin involves reprogramming the Powertrain Control Module (PCM) with the latest available software. Read More »
Flash: Transmission Diagnostic and Shift Enhancements This bulletin involves reprogramming the Transmission Control Module (TCM) with the latest available software. Read More »
Flash: Transmission Diagnostic And Shift Enhancements This bulletin involves reprogramming the Transmission Control Module (TCM) with the latest available software. Read More »
Flash: Transmission Diagnostic And Shift Enhancements This bulletin involves reprogramming the Transmission Control Module (TCM) with the latest available software. Read More »
Electric Power Steering Gear For LA, LD and LX Models ONLY; Before this part is replaced for: A) Electrical, Communication or DTC issue please contact: Terry Gavit @ cell (248) 882-6108 terry.gavit@fcagroup. Read More »
Electric Power Steering Gear For LA, LD and LX Models ONLY; Before this part is replaced for: A) Electrical, Communication or DTC issue please contact: Terry Gavit @ cell (248) 882-6108 terry.gavit@fcagroup. Read More »
Start Stop Charging Warning Lamp Illuminated On, Intelligent Battery Sensor (IBS) State of Charge (SOC) Inaccurate, Battery Charging Message, Presence of IBS related Diagnostic Trouble Codes (DTCs), or Battery Warning Lamp ... Read More »
Connector kit Before ordering this connector repair kit 68018957A$, check it in the Mopar Connector Repair Kit Website to confirm part number and applicability. Read More »
WIRING, Body Before replacing this harness, please contact FCA Redacted Content to see if a repair kit is available for your application. If no response in 15 minutes, proceed with repair. Read More »
ELECTRICAL SYSTEM:WIRING:CONNECTORS/PLUGS:ACCESORY POWER OUTLET/JACK/PORT/USB/SAE/CIGARETTE LIGHTER
RADIO, MULTI Media ALERT: Radio replacement will lead loss of connectivity. Please do NOT replace the head unit if the customer has or plans to have a connectivity service plan. New software will be released to fix this later. Read More »
UCQ UAQ UAS Radio Enhancements Software Updated to 16.2 Customers may experience one or more of the following: ? Vehicle has lost connectivity after radio swap or battery disconnect. Read More »
Flash: HVAC System Enhancement This bulletin involves reprogramming the Heating Ventilation Air Conditioning (HVAC)Module with new software. Read More »
UAS, UCQ, UDQ, UJQ and UAQ Radio Enhancements This bulletin involves inspecting and if required, updating the radio software. Customers may experience one or more of the following: Excessive weather alerts. Read More »
UAS, UCQ, UDQ, UJQ and UAQ Radio Enhancements This bulletin involves inspecting and if required, updating the radio software. Customers may experience one or more of the following:Vehicle Finder feature on Sirius? Guardian inoperable. Read More »
UCQ UAQ UAS Radio Enhancements Software Updated to 16.2 Customers may experience one or more of the following: ? Vehicle has lost connectivity after radio swap or battery disconnect. Read More »
UDQ Radio Enhancements This bulletin involves inspecting and if required, updating the radio to software: 16.11. Customers may experience one or more of the following: Vehicle Finder feature on Sirius? Guardian inop. Read More »
UAS, UCQ, UDQ, UJQ and UAQ Radio Enhancements This bulletin involves inspecting and if required, updating the radio software. Customers may experience one or more of the following: Excessive weather alerts. Read More »
UAS, UCQ, UDQ, UJQ and UAQ Radio Enhancements This bulletin involves inspecting and if required, updating the radio software. Customers may experience one or more of the following:Vehicle Finder feature on Sirius? Guardian inoperable. Read More »
Flash: Transmission Diagnostic and Shift Enhancements This bulletin involves reprogramming the Transmission Control Module (TCM) with the latest available software. Customers may experience a Malfunction Indicator Lamp (MIL) illumination. Read More »
Front Click Noise at Low Speed Turns This bulletin involves installing a friction disc kit on both front hub bearing surfaces between the hub and rotor. Read More »
Front Click Noise at Low Speed Turns This bulletin involves installing a friction disc kit on both front hub bearing surfaces between the hub and rotor. Read More »
Driver Window Short Drop Feature Does Not Drop The Window When The Door Is Open, Window Short Up Feature Does Raise The Window When The Door Is Closed Read More »
Authentic Mopar? Glass Replacement This bulletin involves discussing FCA US LLC position with regard to collision repair industry awareness regarding the recommended usage of Authentic Mopar? Glass. Read More »
Authentic Mopar? Glass Replacement This bulletin involves discussing FCA US LLC position with regard to collision repair industry awareness regarding the recommended usage of Authentic Mopar? Glass. Read More »
Washer Fluid Level Sensor Prior to replacing this part due to "Low Washer Fluid" tell tale light on the dash and the washer fluid bottle is full, please perform the this inspection. Read More »
Driver Window Short Drop Feature Does Not Drop The Window When The Door Is Open, Window Short Up Feature Does Raise The Window When The Door Is Closed Read More »
Driver Window Short Drop Feature Does Not Drop The Window When The Door Is Open, Window Short Up Feature Does Raise The Window When The Door Is Closed Read More »
Washer Fluid Level Sensor Prior to replacing this part due to "Low Washer Fluid" tell tale light on the dash and the washer fluid bottle is full, please perform this inspection: Check if float sensor is rotated off location from the ... Read More »
Washer Fluid Level Sensor Prior to replacing this part due to "Low Washer Fluid" tell tale light on the dash and the washer fluid bottle is full, please perform this inspection: Check if float sensor is rotated off location from the ... Read More »
A/C Pressure Transducer A/C inoperative and diagnosis leads to pressure transducer. Call Steve Rice at cell (248) 867-0061 before replacing the pressure transducer. If no response in 15 minutes, please proceed with repair. Read More »
Transmission Oil Pan, Heater (TMU), Tube or O-ring Applies to vehicles equipped with 8 speed transmissions only; if you have a leak that appears to be at the pan the use of proper leak detection is recommended. Read More »
Restraints Remove I-Sheet from packaging. Correct information sheet (I-Sheet) has been added to Star Parts. Print I-Sheet for technician use. Read More »
Aluminum Body Panel Corrosion Repair Aluminum corrosion or bubbling along the leading edge of hood, hinges or other exterior surface areas of the hinges, doors, fenders, swing gates or liftgates. Read More »
Aluminum Body Panel Corrosion Repair Aluminum corrosion or bubbling along the leading edge of hood, hinges or other exterior surface areas of the hinges, doors, fenders, swing gates or liftgates. Read More »
Aluminum Body Panel Corrosion Repair Aluminum corrosion or bubbling along the leading edge of hood, hinges or other exterior surface areas of the hinges, doors, fenders, swing gates or liftgates. Read More »
Approved Use of Weld Through Primers This bulletin documents the FCA US LLC position regarding the use of weld through primer when using Squeeze Type Resistance Spot Welding (STRSW) and Gas Metal Arc Welding (GMAW) processes when ... Read More »
Approved Use of Weld Through Primers This bulletin documents the FCA US LLC position regarding the use of weld through primer when using Squeeze Type Resistance Spot Welding (STRSW) and Gas Metal Arc Welding (GMAW) processes when ... Read More »
Approved Use of Weld Through Primers This bulletin documents the FCA US LLC position regarding the use of weld through primer when using Squeeze Type Resistance Spot Welding (STRSW) and Gas Metal Arc Welding (GMAW) processes when ... Read More »
Aluminum Body Panel Corrosion Repair This bulletin involves inspecting and if necessary removing corrosion and refinishingthe suspect aluminum panels on the vehicle, hood, door, fenders, hinges, swing gates or liftgate panels. Read More »
Aluminum Body Panel Corrosion Repair This bulletin involves inspecting and if necessary removing corrosion and refinishingthe suspect aluminum panels on the vehicle, hood, door, fenders, hinges, swing gates or liftgate panels. Read More »
Driver Window Short Drop Feature Does Not Drop The Window When The Door Is Open, Window Short Up Feature Does Raise The Window When The Door Is Closed Read More »
Repair Parts Used For Structural Repairs This bulletin involves discussing FCA US LLC position with regard to structural repair parts usage. Read More »
Use of Aftermarket Parts This bulletin involves discussing FCA US LLC position with regard to collision repair industry awareness regarding the use of aftermarket parts. Read More »
Repair Parts Used For Structural Repairs This bulletin involves discussing FCA US LLC position with regard to structural repair parts usage. Read More »
Use of Aftermarket Parts This bulletin involves discussing FCA US LLC position with regard to collision repair industry awareness regarding the use of aftermarket parts. Read More »
Use of Salvage/Recycled Parts This bulletin involves discussing FCA US LLC position with regard to collision repair industry awareness regarding the use of recycled or salvage parts. Read More »
Door Hinge Assembly Side door hinge noisy. Only replace the door hinge with the integral check device. Do not replace the simple hinge if it is not damaged it is not the source of the noise. Replacing it unnecessary and is an over-repair. Read More »
Door Hinge Assembly Side door hinge noisy. Only replace the door hinge with the integral check device. Do not replace the simple hinge if it is not damaged it is not the source of the noise. Read More »
Hood Seal Torn or Deformed This bulletin involves replacing the hood seals due to damage and/or being torn. The customer may experience the hood seal drooping due to cracks and tears on the hood seal. Read More »
Hood Seal Torn or Deformed This bulletin involves replacing the hood seals due to damage and/or being torn. The customer may experience the hood seal drooping due to cracks and tears on the hood seal. Read More »
Approved Use of Weld Through Primers This bulletin documents the FCA US LLC position regarding the use of weld through primer when using Squeeze Type Resistance Spot Welding (STRSW) and Gas Metal Arc Welding (GMAW) processes when ... Read More »
Accelerator Pedal Before replacing accelerator pedal, be sure to follow fault code diagnostic procedures in service manual. Make sure to check wiring and connectors. Read More »
Accelerator Pedal Before replacing accelerator pedal, be sure to follow fault code diagnostic procedures in service manual. Make sure to check wiring and connectors. Read More »
UDQ Radio Enhancements This bulletin involves inspecting and if required, updating the radio to software: 16.11. Customers may experience one or more of the following: Vehicle Finder feature on Sirius? Guardian inop. Read More »
UAS, UCQ, UDQ, UJQ and UAQ Radio Enhancements This bulletin involves inspecting and if required, updating the radio software. Customers may experience one or more of the following: Excessive weather alerts. Read More »
UAS, UCQ, UDQ, UJQ and UAQ Radio Enhancements This bulletin involves inspecting and if required, updating the radio software. Customers may experience one or more of the following:Vehicle Finder feature on Sirius? Guardian inoperable. Read More »
Rotor - Front 2 Piece For LA, LD SRT vehicles with the 2-piece Front Rotor (BR7 sales code), do NOT replace the rotor for a clicking noise occurring while turning at low parking lot speeds. Read More »
Dynamic Sensor Prior to replacing this part, please ensure all the pre-diagnostic & diagnostic procedures have been completed with emphasis on wiring and connector integrity. Read More »
Transmission Oil Pan, Heater (TMU), Tube or O-ring Applies to vehicles equipped with 8 speed transmissions only; if you have a leak that appears to be at the pan the use of proper leak detection is recommended. Read More »
UAS, UCQ, UDQ, UJQ and UAQ Radio Enhancements This bulletin involves inspecting and if required, updating the radio software. Customers may experience one or more of the following: Excessive weather alerts. Read More »
ADAPTER, Engine Oil Filter (Pentastar V6) For all 2014MY replace the Oil Filter Adapter (OFA). For any other MY (with mileage above 30,000) review and follow instructions from STAR Online S1809000007 REV. C available on Dealer Connect. Read More »
UDQ Radio Enhancements This bulletin involves inspecting and if required, updating the radio to software: 16.11. Customers may experience one or more of the following: Vehicle Finder feature on Sirius? Guardian inop. Read More »
Front Click Noise at Low Speed Turns This bulletin involves installing a friction disc kit on both front hub bearing surfaces between the hub and rotor. Read More »
Front Click Noise at Low Speed Turns This bulletin involves installing a friction disc kit on both front hub bearing surfaces between the hub and rotor. Read More »
Transmission Oil Pan, Heater (TMU), Tube or O-ring Applies to vehicles equipped with 8 speed transmissions only; if you have a leak that appears to be at the pan the use of proper leak detection is recommended. Read More »
UAS, UCQ, UDQ, UJQ and UAQ Radio Enhancements This bulletin involves inspecting and if required, updating the radio software. Customers may experience one or more of the following: Excessive weather alerts. Read More »
UAS, UCQ, UDQ, UJQ and UAQ Radio Enhancements This bulletin involves inspecting and if required, updating the radio software. Customers may experience one or more of the following:Vehicle Finder feature on Sirius? Guardian inoperable. Read More »
UAQ Radio Enhancements This bulletin involves inspecting and if required, updating the radio software. Customers may experience the following:Navigation will not load when selected on the radio screen. Read More »
Rotor - Front 2 Piece For LA, LD SRT vehicles with the 2-piece Front Rotor (BR7 sales code), do NOT replace the rotor for a clicking noise occurring while turning at low parking lot speeds. Read More »
Flash: Powertrain Diagnostic And System Enhancements This bulletin involves reprogramming the Powertrain Control Module (PCM) with the latest available software. Read More »
Flash: Powertrain Diagnostic and System Improvements This bulletin involves reprogramming the Powertrain Control Module (PCM) with the latest available software. Read More »
Dynamic Sensor Prior to replacing this part, please ensure all the pre-diagnostic & diagnostic procedures have been completed with emphasis on wiring and connector integrity. Read More »
If a Mopar oil filter is not available, use a filter that meets or exceeds USCAR36 specification and is compatible with semi and full synthetic oils. Read More »
Front Click Noise at Low Speed Turns This bulletin involves installing a friction disc kit on both front hub bearing surfaces between the hub and rotor. Read More »
Flash: Powertrain Control Module (PCM) Updates This bulletin involves reprogramming the PCM with updated software. Customers may experience a Malfunction Indicator Lamp (MIL) illumination. Read More »
USB PORT, Media Hub For Android Auto and Apple Carplay issues, do not replace this part. Android Auto and Apple Carplay applications may not operate with the vehicle if an aftermarket cable is being used. Read More »
Transmission Oil Pan, Heater (TMU), Tube or O-ring Applies to vehicles equipped with 8 speed transmissions only; if you have a leak that appears to be at the pan the use of proper leak detection is recommended. Read More »
Charging System, Battery Diagnostic Tools and Warranty This information only bulletin discusses using the correct test equipment for testing batteries and charging systems, and also warranty reimbursement when battery replacements are ... Read More »
CORE, Heater (with tubes) When replacing the heater core for LA, LX, and LD vehicles, make sure to return not only the heater core but also the connecting tubes, seals and retainers. For any questions contact FCA Redacted Content. Read More »
Use of Salvage/Recycled Parts This bulletin involves discussing FCA US LLC position with regard to collision repair industry awareness regarding the use of recycled or salvage parts. Read More »
Use of Aftermarket Parts This bulletin involves discussing FCA US LLC position with regard to collision repair industry awareness regarding the use of aftermarket parts. Read More »
Repair Parts Used For Structural Repairs This bulletin involves discussing FCA US LLC position with regard to structural repair parts usage. Read More »
RADIO, MULTI Media For RA3 and RA4 8.4? radio concern of reoccurring update request pop-up on each key cycle after a radio FOTA (Firmware Update Over the Air) has been completed, please DO NOT replace the radio. Read More »
RADIO [RES] - New and/or Service Exchange For RES radio concerns. Use the wiTECH 2.0 and inspect the radio part number and serial number under the Radio/ECU Details tab. Read More »
ACTUATOR, A/C and Heater Before replacing HVAC actuator, please contact either Thomas Conway (248) 635-7090 or Paul Aquino (248) 854-4819. Engineering is looking to gather infomation on fail mode and customer concern. Read More »
Amplifier Vehicles needing amplifier replacement, please call Rayyan Mohammed at Cell (248) 954-0790 prior to repair. If no response in 15 minutes, proceed with the repair. Read More »
Electric Power Steering Gear For LA, LD and LX Models ONLY; Before this part is replaced for: A) Electrical, Communication or DTC issue please contact: Terry Gavit @ cell (248) 882-6108 terry.gavit@fcagroup. Read More »
USB PORT, Media Hub For Android Auto and Apple Carplay issues, do not replace this part. Android Auto and Apple Carplay applications may not operate with the vehicle if an aftermarket cable is being used. Read More »
CORE, Heater (with tubes) When replacing the heater core for LA, LX, and LD vehicles, make sure to return not only the heater core but also the connecting tubes, seals and retainers. For any questions contact FCA Redacted Content. Read More »
UCQ UAQ UAS Radio Enhancements Software Updated to 16.2 Customers may experience one or more of the following: ? Vehicle has lost connectivity after radio swap or battery disconnect. Read More »
RADIO [RES] - New and/or Service Exchange For RES radio concerns. Use the wiTECH 2.0 and inspect the radio part number and serial number under the Radio/ECU Details tab. Read More »
UAS, UCQ, UDQ, UJQ and UAQ Radio Enhancements This bulletin involves inspecting and if required, updating the radio software. Customers may experience one or more of the following: Excessive weather alerts. Read More »
Amplifier Vehicles needing amplifier replacement, please call Rayyan Mohammed at Cell (248) 954-0790 prior to repair. If no response in 15 minutes, proceed with the repair. Read More »
RA2 Radio 5" Uconnect Before replacing this radio, make sure you can reproduce the customer issue. If the radio is locked up, has a blank screen, or no sound, please perform a vehicle battery reset. Read More »
UAS, UCQ, UDQ, UJQ and UAQ Radio Enhancements This bulletin involves inspecting and if required, updating the radio software. Customers may experience one or more of the following: Excessive weather alerts. Read More »
UAQ Radio Enhancements This bulletin involves inspecting and if required, updating the radio software. Customers may experience the following:Navigation will not load when selected on the radio screen. Read More »
USB PORT, Media Hub For Android Auto and Apple Carplay issues, do not replace this part. Android Auto and Apple Carplay applications may not operate with the vehicle if an aftermarket cable is being used. Read More »
UAS, UCQ, UDQ, UJQ and UAQ Radio Enhancements Customers may experience one or more of the following:Radio freezes and resets after start-up. Vehicle Finder feature on Sirius? Guardian inoperable. Read More »
UAS, UCQ, UDQ, UJQ and UAQ Radio Enhancements Customers may experience one or more of the following:Radio freezes and resets after start-up. Vehicle Finder feature on Sirius? Guardian inoperable. Read More »
UAS, UCQ, UDQ, UJQ and UAQ Radio Enhancements Customers may experience one or more of the following:Radio freezes and resets after start-up. Vehicle Finder feature on Sirius? Guardian inoperable. Read More »
Lubrication and Maintenance Fluids If MOPAR fluids and chemicals are not readily available, please review Service Library for specifications so a suitable alternative can be used Read More »
82212076, 82203694 - Fabric Cleaner This "fabric cleaner" is not intended for sale in California, the otc states (Connecticut, Delaware, Massachusetts, Maine, New Hampshire, New Jersey, New York, Pennsylvania, Virginia, and Washington ... Read More »
Transmission Oil Pan, Heater (TMU), Tube or O-ring Applies to vehicles equipped with 8 speed transmissions only; if you have a leak that appears to be at the pan the use of proper leak detection is recommended. Read More »
HEADLAMP After performing the headlamp condensation clearing service procedure, If the WK Headlamp is being replaced for Moisture / Condensation issue, please e-mail pictures of the Moisture / Condensation issue to FCA Redacted Content ... Read More »
UAS, UCQ, UDQ, UJQ and UAQ Radio Enhancements This bulletin involves inspecting and if required, updating the radio software. Customers may experience one or more of the following: Excessive weather alerts. Read More »
Flash: HVAC System Enhancement This bulletin involves reprogramming the Heating Ventilation Air Conditioning (HVAC)Module with new software. Read More »
ACTUATOR, A/C and Heater Before replacing HVAC actuator, please contact either Thomas Conway (248) 635-7090 or Paul Aquino (248) 854-4819. Engineering is looking to gather infomation on fail mode and customer concern. Read More »
A/C Pressure Transducer A/C inoperative and diagnosis leads to pressure transducer. Call Steve Rice at cell (248) 867-0061 before replacing the pressure transducer. If no response in 15 minutes, please proceed with repair. Read More »
UCQ UAQ UAS Radio Enhancements Software Updated to 16.2 Customers may experience one or more of the following: ? Vehicle has lost connectivity after radio swap or battery disconnect. Read More »
Approved Use of Weld Through Primers This bulletin documents the FCA US LLC position regarding the use of weld through primer when using Squeeze Type Resistance Spot Welding (STRSW) and Gas Metal Arc Welding (GMAW) processes when ... Read More »
