Print this page

1995 Chevrolet Monte Carlo

42 Technical Service Bulletins (TSBs)

TSB List for the 1995 Chevrolet Monte Carlo

Technical Service Bulletins (TSBs) for the 1995 Monte Carlo are official communications between Chevrolet & their dealerships that describe processes for troubleshooting or fixing certain common problems. All vehicle manufacturers are required by U.S. law to make their TSBs available to the public.

  • STEERING: STEERING WHEEL/HANDLE BAR
  • SUSPENSION
  • SUSPENSION:FRONT:CONTROL ARM:LOWER ARM
  • SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP
  • ENGINE AND ENGINE COOLING:ENGINE
  • ENGINE AND ENGINE COOLING:ENGINE:GASOLINE
  • ENGINE AND ENGINE COOLING:COOLING SYSTEM
  • ENGINE AND ENGINE COOLING:EXHAUST SYSTEM
  • ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL:GAS RECIRCULATION VALVE (EGR VALVE)
  • ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:MANIFOLD/HEADER/MUFFLER/TAIL PIPE
  • FUEL SYSTEM, GASOLINE
  • FUEL SYSTEM, GASOLINE:FUEL INJECTION SYSTEM
  • FUEL SYSTEM, GASOLINE:FUEL INJECTION SYSTEM:INJECTORS
  • POWER TRAIN:AUTOMATIC TRANSMISSION
  • POWER TRAIN:DRIVELINE
  • POWER TRAIN:DRIVELINE:DRIVESHAFT
  • ELECTRICAL SYSTEM:IGNITION:MODULE
  • EXTERIOR LIGHTING:TURN SIGNAL:SWITCH
  • VISIBILITY:WINDSHIELD
  • SEAT BELTS
  • STRUCTURE:FRAME AND MEMBERS
  • STRUCTURE:BODY:DOOR
  • LATCHES/LOCKS/LINKAGES:DOORS:LATCH
  • VEHICLE SPEED CONTROL
  • VEHICLE SPEED CONTROL:CABLES
  • SEATS:MID/REAR ASSEMBLY
  • EQUIPMENT:ELECTRICAL:RADIO/TAPE DECK/CD ETC.
  • UNKNOWN OR OTHER

    • STEERING: STEERING WHEEL/HANDLE BAR

    • TSB #9709013202B

      Date Announced:
      SEP 01, 1997
      NHTSA ID:
      #54328

      EXPERIENCING INTERMITTENT STEERING COLUMN SNAP OR CLICK NOISE WHEN TURNING. *YC Read More »

    SUSPENSION

    • TSB #533307B

      Date Announced:
      JUL 01, 1998
      NHTSA ID:
      #615074

      SOME VEHICLES MAY EXHIBIT FRONT SUSPENSION SCRUNCH / POPPING TYPE NOISE COMING FROM THE FRONT OF VEHICLE THAT IS APPARENT DURING LOW SPEED TURNING MANEUVERS. *TT Read More »

    SUSPENSION:FRONT:CONTROL ARM:LOWER ARM

    • TSB #94267

      Date Announced:
      DEC 01, 1994
      NHTSA ID:
      #39282

      PRODUCT CAMPAIGN 95-C-12 - CERTAIN 1995 LUMINA AND MONTE CARLO MODEL VEHICLES HAVE A RIGHT HAND LOWER CONTROL ARM TAPERED BALL JOINT MOUNTING HOLE THAT WAS INCORRECTLY MACHINED. Read More »

    SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP

    • TSB #970801735026

      Date Announced:
      AUG 01, 1997
      NHTSA ID:
      #54419

      COMMENT THAT THE ABS LIGHT IS ON WITH DIAGNOSTIC TROUBLE CODES (DTC'S) 46 AND 86 SET AS CURRENT OR HISTORY. *YC Read More »

    ENGINE AND ENGINE COOLING:ENGINE

    • TSB #010601002A

      Date Announced:
      DEC 01, 2002
      NHTSA ID:
      #10000782

      REVISED PISTON PIN REMOVAL / INSTALLATION PROCEDURE. *TT Read More »

    • TSB #576124

      Date Announced:
      AUG 01, 1995
      NHTSA ID:
      #45815

      COLD ENGINE TICK OR RATTLE AFTER START-UP (REPLACE PISTON/PIN ASSEMBLY). *SD Read More »

    • TSB #436604

      Date Announced:
      JAN 01, 1995
      NHTSA ID:
      #39083

      EXHAUST MANIFOLD SEAL SQUEAK. *TW Read More »

    • TSB #476135

      Date Announced:
      OCT 01, 1994
      NHTSA ID:
      #39725

      OIL LEAK AT THE ROCKER COVER. *TW Read More »

    ENGINE AND ENGINE COOLING:ENGINE:GASOLINE

    • TSB #990604005A

      Date Announced:
      APR 01, 2001
      NHTSA ID:
      #619360

      SOME OWNERS MAY COMMENT ON DRIVEABILITY SYMPTONS OF LONG OR HARD STARTS, CHUGGLE, ROUGH IDLE AND LIGHT OR INTERMITTENT MISFIRE DUE TO CLOGGED FUEL INJECTORS. *TT Read More »

    • TSB #990604005

      Date Announced:
      FEB 01, 1999
      NHTSA ID:
      #604343

      SOME OWNERS MAY EXPERIENCE A DRIVEABILITY SYMPTOM OF LONG OR HARD STARTS, CHUGGLE, ROUGH IDLE AND LIGHT OR INTERMITTENT MISFIRE. *TT Read More »

    • TSB #876002A

      Date Announced:
      JUL 01, 1998
      NHTSA ID:
      #615073

      SOME V6 ENGINES MAY, ON A VERY INFREQUENT BASIS, HAVE AN OIL ODOR CONDITION THAT IS GENERALLY ENCOUNTERED AFTER THE ENGINE'S OIL HAS BEEN CHANGED. Read More »

    • TSB #98576124A

      Date Announced:
      JUN 01, 1998
      NHTSA ID:
      #601915

      COMMENTS ON A TICKING TYPE NOISE THAT BEGINS SHORTLY AFTER COLD ENGINE START-UP AND GRADUALLY DIMINISHES AS THE ENGINE WARMS UP. *YC Read More »

    ENGINE AND ENGINE COOLING:COOLING SYSTEM

    • TSB #576201

      Date Announced:
      JUN 01, 1995
      NHTSA ID:
      #45851

      COOLANT LEAK AT THE FRONT COVER OUTLET TO HEATER INLET NIPPLE (NEW TORQUE SPECIFICATION). *SD Read More »

    ENGINE AND ENGINE COOLING:EXHAUST SYSTEM

    ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL:GAS RECIRCULATION VALVE (EGR VALVE)

    • TSB #676001

      Date Announced:
      FEB 01, 1997
      NHTSA ID:
      #51353

      EXCESSIVE OIL CONSUMPTION (REPLACE PCV HARNESS). *TW Read More »

    ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:MANIFOLD/HEADER/MUFFLER/TAIL PIPE

    FUEL SYSTEM, GASOLINE

    • TSB #736313

      Date Announced:
      JUN 01, 1997
      NHTSA ID:
      #52563

      REDUCED ENGINE PERFORMANCE, RESTRICTED FUEL FLOW (CLEAN FUEL TANK, REPLACE IN-LINE FUEL FILTER AND FUEL PUMP STRAINER). *TW Read More »

    FUEL SYSTEM, GASOLINE:FUEL INJECTION SYSTEM

    • TSB #971101776304

      Date Announced:
      NOV 01, 1997
      NHTSA ID:
      #54066

      SUBJECT PERTAINING TO DRIVEABILITY SYMPTOMS DUE TO FUEL INJECTOR DEPOSITS. *YC Read More »

    FUEL SYSTEM, GASOLINE:FUEL INJECTION SYSTEM:INJECTORS

    • TSB #98776304A

      Date Announced:
      FEB 01, 1998
      NHTSA ID:
      #600282

      SOME VEHICLES MAY EXPERIENCE A DRIVEABILITY SYMPTOM OF LONG OR HARD STARTS, CHUGGLE, ROUGH IDLE AND LIGHT OR INTERMITTENT MISFIRE. *YC Read More »

    • TSB #476520

      Date Announced:
      DEC 01, 1994
      NHTSA ID:
      #37943

      CRANK NO START/RUNS ROUGH AFTER EXTREME COLD WEATHER SOAK. *TW Read More »

    POWER TRAIN:AUTOMATIC TRANSMISSION

    POWER TRAIN:DRIVELINE

    • TSB #CAMP95C40

      Date Announced:
      JUN 01, 1995
      NHTSA ID:
      #45841

      CAMPAIGN BULLETIN ANNOUNCES A RECALL FOR CERTAIN 1995 LUMINA AND MONTE CARLO VEHICLES, THAT MAY HAVE BEEN BUILT WITH A PARTIALLY OR FULLY BLOCKED VACUUM DISTRIBUTION BLOCK. Read More »

    POWER TRAIN:DRIVELINE:DRIVESHAFT

    • TSB #577106A

      Date Announced:
      FEB 01, 1997
      NHTSA ID:
      #51497

      COLD START RATTLE NOISE (DIAGNOSIS/SERVICE PROCEDURE). *TW Read More »

    ELECTRICAL SYSTEM:IGNITION:MODULE

    • TSB #576405

      Date Announced:
      SEP 01, 1995
      NHTSA ID:
      #45803

      NO START, BATTERY FULLY DISCHARGED (REPLACE PRIMARY COOLING FAN RELAY INSTALL NEW PROM) *SD Read More »

    EXTERIOR LIGHTING:TURN SIGNAL:SWITCH

    • TSB #97003

      Date Announced:
      MAR 01, 1997
      NHTSA ID:
      #51272

      RECALL 97V-017 - PIVOT AND (PULSE/DIMMER) WINDSHIELD WASHER SWITCH - GENERAL MOTORS HAS DECIDED THAT A DEFECT WHICH RELATES TO MOTOR VEHICLE SAFETY EXISTS IN CERTAIN 1994 PONTIAC GRAND PRIX, 1994-95 BUICK REGAL, OLDSMOBILE CUTLASS SUPREME ... Read More »

    • TSB #433205A

      Date Announced:
      DEC 01, 1994
      NHTSA ID:
      #38074

      TURN SIGNAL LEVER WILL NOT STAY IN DETENT POSITION. *TW Read More »

    VISIBILITY:WINDSHIELD

    SEAT BELTS

    • TSB #97023A

      Date Announced:
      DEC 01, 1998
      NHTSA ID:
      #615105

      RECALL CAMPAIGN INVOLVING REPLACING THE REAR SEAT BELT ANCHOR PLATE. *TT Read More »

    STRUCTURE:FRAME AND MEMBERS

    • TSB #GM532001

      Date Announced:
      APR 01, 1995
      NHTSA ID:
      #41083

      POPPING NOISE FROM LEFT SIDE OF VEHICLE DURING MODERATE BRAKING OR ACCELERATION (FABRICATE AND INSTALL SHIM). *TW Read More »

    STRUCTURE:BODY:DOOR

    LATCHES/LOCKS/LINKAGES:DOORS:LATCH

    VEHICLE SPEED CONTROL

    • TSB #050604058

      Date Announced:
      SEP 01, 2005
      NHTSA ID:
      #10017568

      INTERMITTENT CHUGGLE OR FISHBITE ON LIGHT ACCELERATION OR A HIGHWAY SPEEDS WITH NO DIAGNOSTIC TROUBLE CODES (DTCS). *TT Read More »

    • TSB #970801676305

      Date Announced:
      AUG 01, 1997
      NHTSA ID:
      #54418

      SOME VEHICLES EXPERIENCE DIFFICULTIES TO DEPRESS ACCELERATOR PEDAL AND/OR AN ACCELERATOR CABLE SEPARATION. *YC Read More »

    • TSB #576305

      Date Announced:
      MAY 01, 1995
      NHTSA ID:
      #43032

      UNKNOWN Read More »

    VEHICLE SPEED CONTROL:CABLES

    • TSB #676305

      Date Announced:
      MAR 01, 1997
      NHTSA ID:
      #52580

      DIFFICULT TO DEPRESS ACCELERATOR PEDAL AND/OR ACCELERATOR CABLE SEPARATION (INSTALL ACCELERATOR CABLE AND CLIP). *TW Read More »

    SEATS:MID/REAR ASSEMBLY

    • TSB #97023A

      Date Announced:
      APR 09, 1999
      NHTSA ID:
      #605952

      SUBJECT REGARDING PRODUCT SAFETY CAMPAIGN - REAR SEAT BELT ANCHOR PLATE. *TT Read More »

    EQUIPMENT:ELECTRICAL:RADIO/TAPE DECK/CD ETC.

    • TSB #549001A

      Date Announced:
      MAR 01, 1997
      NHTSA ID:
      #52600

      CLN INDICATOR APPEARS ON RADIO DISPLAY AND DOES NOT TURN OFF (RESET CLN INDICATOR WITH THE EJECT BUTTON ON TAPE). *TW Read More »

    UNKNOWN OR OTHER

    • TSB #431110

      Date Announced:
      FEB 01, 1995
      NHTSA ID:
      #39280

      CENTER DEFROSTER GRILL LOOSE RIGHT SIDE. *TW Read More »

    Browse Other Monte Carlo Years