Technical Service Bulletins (TSBs) for the 2009 335d are official communications between BMW & their dealerships that describe processes for troubleshooting or fixing certain common problems.
All vehicle manufacturers are required by U.S. law to make their TSBs available to the public.
SPL Parts, Inc. manufacturers and distributes aftermarket lower control arms for dedicated competition vehicles and "track day" cars some of which may be used on both track and highway. Read More »
BMW: IMMEDIATELY AFTER A COLD START IF ELECTRONIC COMPONENTS ARE TURNED ON SUCH AS HEATED SEATS IT MAY SWITCH OFF AFTER 5-10 SECONDS BECAUSE OF A VOLTAGE LEVEL DIP. *RM Read More »
SPL Parts, Inc. manufacturers and distributes aftermarket lower control arms for dedicated competition vehicles and "track day" cars some of which may be used on both track and highway. Read More »
BMW: A GRINDING NOISE IS COMING FROM THE DIFFERENTIAL DURING SLOW CORNERING. WHEN TURNING A SLIP/STICK EFFECT IS CREATED ON THE LINING AND STEEL DISCS INCORPORATED IN THE DIFFERENTIAL CLUTCH CAUSES A GRINDING NOISE. Read More »
BMW VEHICLES: REAR AXLE CARRIER (SUB FRAME) SUPPORT PROPOSED CLASS ACTION SETTLEMENT. UNDER CERTAIN CIRCUMSTANCES, A FRACTURE IN THE STEEL BODY STRUCTURE COULD FORM IN THE AREA AROUND ONE OF THE REAR AXLE CARRIER MOUNTING POINTS. Read More »
BMW: WARNING LAMPS ARE ILLUMINATED FOR THE DSC, ABS AND BRAKE AND A POSSIBLE WARNING IN CONTROL DISPLAY FOR CHASSIS CONTROL SYSTEM FAILURE. MODELS 2012 F25, 30, 01, 02, 07, 10, 12, 13, E70, 71, 84. Read More »
BMW: WARNING LAMPS ARE ILLUMINATED FOR THE DSC, ABS AND BRAKE AND A POSSIBLE WARNING IN CONTROL DISPLAY FOR CHASSIS CONTROL SYSTEM FAILURE. MODELS 2012 F25, 30, 01, 02, 07, 10, 12, 13, E70, 71, 84. Read More »
BMW: SELECTIVE CATALYST REDUCTION MODULE (SCR) HAS A STORED FAULT, PRESSURE BUILD UP IS LOW, CAUSING SERVICE ENGINE SOON LIGHT TO ILLUMINATE. * Read More »
BMW: THERE MAY BE EXCESSIVE CRANKING BEFORE THE VEHICLE STARTS. THE SERVICE ENGINE SOON LIGHT MAY ALSO BE ON WITH A LACK OF ENGINE POWER. *RM Read More »
BMW: ON LOW MILEAGE VEHICLES THE ENGINE RUNS ROUGH, MIFIRES, OR FAILS TO CRANK. THIS IS CAUSED BY MULTIPLE SHORT START-UPS WITHOUT THE ENGINE PROPERLY GOING THROUGH A WARM-UP PHASE. *RM Read More »
BMW: SERVICE ENGINE AND ENGINE MALFUNCTION LIGHT ILLUMINATES. VEHICLE MAY HAVE REDUCED POWER OUTPUT. FAULT CODE MAY NOT CLEAR FROM DME FAULT MEMORY. *KB UPDATED ON 11/8/2013. *KB UPDATED 2/21/2014 *JS UPDATED 3/11/14. Read More »
BMW VEHICLE: THE SERVICE ENGINE SOON (MIL) LAMP IS ILLUMINATED AND A POWER REDUCTION IS CLEARLY PERCEPTIBLE. THIS SITUATION MAY OCCUR AFTER DRIVING FOR SOME TIME WITH THE ENGINE ALREADY AT FULL OPERATING TEMPERATURE. Read More »
BMW: COMPLAINT OF A DELAYED ENGAGEMENT AND A HARSH JOLT WHEN ACCELERATING FROM A STOP. THE SITUATION OCCURS ONLY DURING THE ENGINE WARM UP PHASE (COLD ENGINE), AND CANNOT BE REPRODUCED IN THE SPORT MODE. Read More »
BMW: SIX DIFFERENT MODELS EQUIPPED WITH THE M54 ENGINE COULD HAVE VALVE COVERS BREAK IN COLD WEATHER AND RUIN THE ENGINE. THIS IS DUE TO MOISTURE ACCUMULATION. *RM Read More »
BMW: THERE IS A ROUGH ENGINE IDLE AND "SERVICE ENGINE SOON LIGHT" WHEN DRIVING DOWNHILL IN HIGH ALTITUDES DURING COLD WEATHER. THERE MAY BE SIX DIFFERENT FAULT CODES. *RM Read More »
BMW: A SERVICE ENGINE SOON LIGHT COMES ON. THE ENGINE WILL ONLY OPERATE TO 1500 RPMS AND LACKS POWER. THERE IS A SOFTWARE APPLICATION ERROR. *RM Read More »
BMW VEHICLE: N54 TURBOCHARGER WASTE GATE CONTROL NOISES AND OPERATION. AFTER TURNING OFF ENGINE, A SLIGHT RATTLE NOISE IS HEARD FROM THE ENGINE COMPARTMENT. THIS NOISE IS SIMILAR TO A MECHANICAL TYPEWRITER. Read More »
BMW: THERE IS A CLANKING NOISE FROM THE ENGINE OR EXHAUST AREA. WASTEGATE VALVE IS NOT COMPLETELY CLOSING AND CLANKING. *RM UPDATED 7/17/12. *PE Read More »
BMW VEHICLE: N54 TURBOCHARGER WASTE GATE CONTROL NOISES AND OPERATION. AFTER TURNING OFF ENGINE, A SLIGHT RATTLE NOISE IS HEARD FROM THE ENGINE COMPARTMENT. THIS NOISE IS SIMILAR TO A MECHANICAL TYPEWRITER. Read More »
BMW VEHICLE: THE SERVICE ENGINE SOON (MIL) LAMP IS ILLUMINATED AND A POWER REDUCTION IS CLEARLY PERCEPTIBLE. THIS SITUATION MAY OCCUR AFTER DRIVING FOR SOME TIME WITH THE ENGINE ALREADY AT FULL OPERATING TEMPERATURE. Read More »
BMW: COMPLAINT OF A DELAYED ENGAGEMENT AND A HARSH JOLT WHEN ACCELERATING FROM A STOP. THE SITUATION OCCURS ONLY DURING THE ENGINE WARM UP PHASE (COLD ENGINE), AND CANNOT BE REPRODUCED IN THE SPORT MODE. Read More »
BMW: WARNING MESSAGE ON ABOUT LOW DIESEL EXHAUST FUEL LEVEL AND THAT THE ENGINE WILL NOT RESTART WITHIN 999 MILES. THE LIGHT COMES ON A FEW THOUSAND MILES EARLIER THAN A RECOMMENDED OIL CHANGE. *RM Read More »
BMW: PROGRAM CONTROL UNITS. VEHICLES WITH M57Y DIESEL ENGINE. SERVICE ENGINE SOON LAMP (MIL) IS ILLUMINATED ERRONEOUSLY. DDE SOFTWARE ERROR. *PE Read More »
ENGINE AND ENGINE COOLING:ENGINE:OTHER FUEL TYPES:TURBO/SUPERCHARGER
BMW: THERE IS A CLANKING NOISE FROM THE ENGINE OR EXHAUST AREA. WASTEGATE VALVE IS NOT COMPLETELY CLOSING AND CLANKING. *RM UPDATED 7/17/12. *PE Read More »
BMW VEHICLE: N54 TURBOCHARGER WASTE GATE CONTROL NOISES AND OPERATION. AFTER TURNING OFF ENGINE, A SLIGHT RATTLE NOISE IS HEARD FROM THE ENGINE COMPARTMENT. THIS NOISE IS SIMILAR TO A MECHANICAL TYPEWRITER. Read More »
BMW: SEE DOCUMENT SEARCH BUTTON FOR OWNER LETTER. THE REPLACING AND/OR CHECKING OF EMISSIONS MONITORING COMPONENTS TO INCREASE EMISSIONS STABILITY, HIGH PRESSURE (HP) EGR VALVE RESTRICTION OF EXCESSIVE SOOT AND IMPROVED DIESEL EXHAUST ... Read More »
BMW: A FAILURE OF THE TURBOCHARGER WASTEGATES, CAUSED BY A DEFECT, HAS AN EMISSIONS EXTENDED WARRANTY, 8 YEARS OR 82,000 MILES, WHICHEVER COMES FIRST, NOT OTHERWISE FALLING WITHIN COVERAGE EXCLUSION. Read More »
BMW: ON SOME VEHICLES, THE HIGH PRESSURE FUEL PUMP HAS AN INTERNAL COMPONENT THAT MAY FAIL AND CAUSING DRIVABILITY SYMPTOMS SUCH AS ERRATIC ENGINE OPERATION AND LONGER STARTING TIMES. *PE Read More »
ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL:CRANKCASE (PCV)
BMW: SEE DOCUMENT SEARCH BUTTON FOR OWNER LETTER. THE REPLACING AND/OR CHECKING OF EMISSIONS MONITORING COMPONENTS TO INCREASE EMISSIONS STABILITY, HIGH PRESSURE (HP) EGR VALVE RESTRICTION OF EXCESSIVE SOOT AND IMPROVED DIESEL EXHAUST ... Read More »
BMW VEHICLE: TEILECLEARING FOR DIAGNOSTIC MODULE TANK LEAKAGE (DMTL) SYSTEM. TEILECLEARING PROCESS HAS BEEN DEVELOPED TO HELP IDENTIFY THE ROOT CAUSES OF CUSTOMER COMPLAINTS RELATING TO THE DMTL SYSTEM (E.G. Read More »
BMW SERVICE CAMPAIGN: SEE DOCUMENT SEARCH BUTTON FOR OWNER LETTER. THERE MAY BE A PROBLEM WITH THE FUEL PUMP WHICH COULD NOT MEET EMISSIONS REQUIREMENTS. THERE MAY BE A LONG CRANK AND A SERVICE ENGINE SOON LIGHT. Read More »
BMW VEHICLES: FUEL LEVEL SENSOR REPAIRS. WHERE IT IS NECESSARY TO REPLACE THE RIGHT OR THE LEFT SIDE FUEL LEVEL SENSOR DUE TO A FAILURE, THE ENTIRE PUMP AND HOUSING OR DELIVERY UNIT (SUCTION JET ASSEMBLY) DO NOT NEED TO BE REPLACED AS ... Read More »
BMW: FUEL LEVEL SENSOR REPAIR PROCEDURE. THE CASE WHERE IT IS NECESSARY TO REPLACE THE RIGHT SIDE FUEL LEVEL SENSOR DUE TO A FAILURE, THE ENTIRE PUMP AND HOUSING DOES NOT NEED TO BE REPLACED. NO MODEL YEARS LISTED. Read More »
BMW: WARNING MESSAGE ON ABOUT LOW DIESEL EXHAUST FUEL LEVEL AND THAT THE ENGINE WILL NOT RESTART WITHIN 999 MILES. THE LIGHT COMES ON A FEW THOUSAND MILES EARLIER THAN A RECOMMENDED OIL CHANGE. *RM Read More »
BMW: FUEL LEVEL SENSOR REPAIR PROCEDURE. THE CASE WHERE IT IS NECESSARY TO REPLACE THE RIGHT SIDE FUEL LEVEL SENSOR DUE TO A FAILURE, THE ENTIRE PUMP AND HOUSING DOES NOT NEED TO BE REPLACED. NO MODEL YEARS LISTED. Read More »
BMW VEHICLES: ENGINE CRANKS BUT DOES NOT START; FUEL LEVEL GAUGE DISPLAYS A SUFFICIENT AMOUNT OF FUEL, ALTHOUGH THE FUEL TANK IS EMPTY; FAULT CODE 2A1C (FUEL LEVEL PLAUSIBILITY) IS STORED IN MSV80. Read More »
BMW SERVICE CAMPAIGN: SEE DOCUMENT SEARCH BUTTON FOR OWNER LETTER. THERE MAY BE A PROBLEM WITH THE FUEL PUMP WHICH COULD NOT MEET EMISSIONS REQUIREMENTS. THERE MAY BE A LONG CRANK AND A SERVICE ENGINE SOON LIGHT. Read More »
BMW: FUEL LEVEL SENSOR REPAIR PROCEDURE. THE CASE WHERE IT IS NECESSARY TO REPLACE THE RIGHT SIDE FUEL LEVEL SENSOR DUE TO A FAILURE, THE ENTIRE PUMP AND HOUSING DOES NOT NEED TO BE REPLACED. NO MODEL YEARS LISTED. Read More »
BMW: THERE IS A SOFTWARE PROBLEM WITH THE DUAL CLUTCH TRANSMISSION MODULE. DATA CAN'T BE READ FROM THE MODULE'S MEMORY. *RM UPDATED 8/10/11. *PE Read More »
BMW VEHICLES: DSC DISABLING FUNCTION. DSC OFF FUNCTION HAS BEEN IMPLEMENTED IN M5 AND M6 VEHICLES EQUIPPED WITH THE OPTIONAL 6 SPEED MANUAL TRANSMISSIONS. NO MODEL YEARS LISTED. *PE Read More »
BMW: DSC WARNING LIGHT IS ON. THE WARNING LAMPS FOR DSC, ABS AND BRAKE WARNING ILLUMINATED. THERE MAY ALSO BE A WARNING IN THE CONTROL DISPLAY FOR CHASSIS CONTROL SYSTEM FAILURE. *JS Read More »
BMW: THERE IS A SOFTWARE PROBLEM WITH THE DUAL CLUTCH TRANSMISSION MODULE. DATA CAN'T BE READ FROM THE MODULE'S MEMORY. *RM UPDATED 8/10/11. *PE Read More »
BMW VEHICLE: TRANSMISSION WARNING LIGHT IS ILLUMINATED AND THE TRANSMISSION ENTERS FAILSAFE MODE. FAULT CODE 4F81 (RATIO MONITORING, CLUTCH A), IN SOME CASES COMBINED WITH THE SUBSEQUENT FAULTS 507B/507C (PARKING GEAR SENSOR IMPLAUSIBLE ... Read More »
The electrical system of BMW vehicles has been subject to an ongoing development process over the last few years. This has led to increased demands being placed on the battery. Read More »
Discharged Battery Energy Diagnosis Must Be Performed: The electrical system of BMW vehicles has been subject to an ongoing development process over the last few years. This has led to increased demands being placed on the battery. Read More »
BMW: VARIOUS FUNCTIONS IN THE VEHICLE ARE NOT WORKING INCLUDING: INSTRUMENTS, DOOR LOCKS, WIPERS, AND OTHER ELECTRICAL FUNCTIONS. THERE MAY ALSO BE WARNING LIGHTS ON. K-CAN WIRING IN THE VEHICLE SHORTED. *RM UPDATED 10/5/11. Read More »
BMW: THE VEHICLE ELECTRICAL SYSTEM FAILS AND THE VEHICLE FAILS TO START. THE CENTRAL LOCKING SYSTEM FAILS TO OPERATE WITH THE REMOTE KEY. THE KEY CANNOT BE INSERTED INTO THE KEY SLOT. COMMUNICATION TO THE VEHICLE IS NOT POSSIBLE. Read More »
BMW VEHICLES: VARIOUS SIMULTANEOUS ELECTRICAL PROBLEMS. THERE IS A SOFTWARE ERROR IN THE JBBFE-3R CONTROL MODULE. VERY INTERMITTENTLY, THE JBBFE-3R WAKES UP IN BOOTLOADER ODE INSTEAD OF APPLICATION MODE. Read More »
BMW: BATTERY HAS AN INCREASED DEMAND DUE TO DEVELOPEMENTAL PROCESS OF THE ELECTRICAL SYSTEM. THIS IS CAUSING THE BATTER TO NEED TO UNDERGO AN ENERGY DIAGNOSIS. *KB Read More »
BMW: THE HIGH-VOLTAGE (HV) BATTERY CELLS COULD BE DAMAGED IF THE VEHICLE IS PREVENTED FROM ENTERING SLEEP MODE FOR AN EXTENDED PERIOD OF TIME. UPDATED 03/11/2013 *JS Read More »
BMW: VARIOUS FUNCTIONS IN THE VEHICLE ARE NOT WORKING INCLUDING: INSTRUMENTS, DOOR LOCKS, WIPERS, AND OTHER ELECTRICAL FUNCTIONS. THERE MAY ALSO BE WARNING LIGHTS ON. K-CAN WIRING IN THE VEHICLE SHORTED. *RM UPDATED 10/5/11. Read More »
BMW: THE SERVICE ENGINE SOON LIGHT MAY BE ON WITH THE VEHICLE RUNNING ROUGH AND INTERNAL MISFIRE CODES. THIS IS AN IGNITION COIL PROBLEM. *RM Read More »
BMW: POOR ELECTRICAL CONNECTIONS ARE CAUSING THE INSTRUMENT CLUSTER TO SHOW THE DOORS ARE OPEN WHILE DRIVING EVEN THOUGH THEY ARE CLOSED. *RM Read More »
BMW: WHEN USING IPHONE, VARIOUS CONNECTIVITY FAILURES OCCUR, SUCH AS DISCONNECTION OF CALL, LIST OF CONTACTS INCOMPLETE, DUE TO THE VARIANTS AND SOFTWARE USED. MODEL 2008-2014. Read More »
BMW: COMPLAINT OF A DELAYED ENGAGEMENT AND A HARSH JOLT WHEN ACCELERATING FROM A STOP. THE SITUATION OCCURS ONLY DURING THE ENGINE WARM UP PHASE (COLD ENGINE), AND CANNOT BE REPRODUCED IN THE SPORT MODE. Read More »
BMW: A SERVICE ENGINE SOON LIGHT COMES ON. THE ENGINE WILL ONLY OPERATE TO 1500 RPMS AND LACKS POWER. THERE IS A SOFTWARE APPLICATION ERROR. *RM Read More »
BMW VEHICLES: VARIOUS SIMULTANEOUS ELECTRICAL PROBLEMS. THERE IS A SOFTWARE ERROR IN THE JBBFE-3R CONTROL MODULE. VERY INTERMITTENTLY, THE JBBFE-3R WAKES UP IN BOOTLOADER ODE INSTEAD OF APPLICATION MODE. Read More »
BMW: WIRING ON THE HEADLIGHTS MAY HAVE DETERIORATED DUE TO ENVIRONMENTAL CONDITIONS AND THE COVER NOT BEING SECURED PROPERLY. E60/E92. *RM UPDATED 9/30/11. *PE Read More »
BMW: ON SOME VEHICLES, WHEN STARTING, LOW BEAM, WITH 0552 OPTION, WOULD BRIEFLY FLASHES, DUE TO A FAULTY LED MAIN LIGHT MODULE THAT NEEDS REPLACING. MODEL 2008-14 F01, F02, F06, F07, F10, F12, F13, F25. Read More »
BMW: LEDS IN REAR LAMP INOPERATIVE. THE LEDS (LIGHT EMITTING DIODES) IN THE OUTER LEFT OR OUTER RIGHT REAR LAMP ARE INOPERATIVE. AFFECTED ARE THE LEDS FOR THE PARKING LAMP/TAIL LAMP OR THE TURN SIGNALS. Read More »
BMW: LEDS IN REAR LAMP INOPERATIVE. THE LEDS (LIGHT EMITTING DIODES) IN THE OUTER LEFT OR OUTER RIGHT REAR LAMP ARE INOPERATIVE. AFFECTED ARE THE LEDS FOR THE PARKING LAMP/TAIL LAMP OR THE TURN SIGNALS. Read More »
BMW: WARNING LAMPS ARE ILLUMINATED FOR THE DSC, ABS AND BRAKE AND A POSSIBLE WARNING IN CONTROL DISPLAY FOR CHASSIS CONTROL SYSTEM FAILURE. MODELS 2012 F25, 30, 01, 02, 07, 10, 12, 13, E70, 71, 84. Read More »
BMW: E92. THE SEAT BELT EXTENDER ON THE FRONT DRIVER?S OR PASSENGER SIDE FAILED TO DELIVER THE BELT. THE SAFETY BELT EXTENDER EXTENDS BUT THE BELT SLIPS OFF. THE ?HAND? ON THE EXTENDER FAILS. THE SAFETY BELT IS TWISTED. Read More »
BMW: E92. THE SEAT BELT EXTENDER ON THE FRONT DRIVER?S OR PASSENGER SIDE FAILED TO DELIVER THE BELT. THE SAFETY BELT EXTENDER EXTENDS BUT THE BELT SLIPS OFF. THE ?HAND? ON THE EXTENDER FAILS. THE SAFETY BELT IS TWISTED. Read More »
BMW: ON SOME E92 MODELS THE SAFETY BELT EXTENDER IS NOT EXTENDING THE BELT OR IS NOISY. THIS CAN BE A FAULT OF THE EXTENDER OR THE BELT IS CONTORTED. *RM Read More »
BMW VEHICLE: FRONT SAFETY BELT DOES NOT RETRACT SMOOTHLY OR JAMS. THE UPPER PART OF THE DRIVER'S OR PASSENGER'S FRONT SAFETY BELT DOES NOT ROLL UP FULLY OR ROLLS UP SLOWLY. Read More »
BMW: ON SOME E92 MODELS THE SAFETY BELT EXTENDER IS NOT EXTENDING THE BELT OR IS NOISY. THIS CAN BE A FAULT OF THE EXTENDER OR THE BELT IS CONTORTED. *RM Read More »
BMW VEHICLE: FRONT SAFETY BELT DOES NOT RETRACT SMOOTHLY OR JAMS. THE UPPER PART OF THE DRIVER'S OR PASSENGER'S FRONT SAFETY BELT DOES NOT ROLL UP FULLY OR ROLLS UP SLOWLY. Read More »
BMW VEHICLES: REAR AXLE CARRIER (SUB FRAME) SUPPORT PROPOSED CLASS ACTION SETTLEMENT. UNDER CERTAIN CIRCUMSTANCES, A FRACTURE IN THE STEEL BODY STRUCTURE COULD FORM IN THE AREA AROUND ONE OF THE REAR AXLE CARRIER MOUNTING POINTS. Read More »
BMW VEHICLES: REAR AXLE CARRIER (SUB FRAME) SUPPORT PROPOSED CLASS ACTION SETTLEMENT. UNDER CERTAIN CIRCUMSTANCES, A FRACTURE IN THE STEEL BODY STRUCTURE COULD FORM IN THE AREA AROUND ONE OF THE REAR AXLE CARRIER MOUNTING POINTS. Read More »
BMW: POOR ELECTRICAL CONNECTIONS ARE CAUSING THE INSTRUMENT CLUSTER TO SHOW THE DOORS ARE OPEN WHILE DRIVING EVEN THOUGH THEY ARE CLOSED. *RM Read More »
BMW: THE SEAL ON THE REAR LAMPS IN THE SIDE PANEL EMITS A GAS AND CAUSES DAMAGE TO THE ELECTRICAL CONNECTORS ON THE LEDS INSIDE THE LAMP. E91. *RM Read More »
BMW: WHEN USING IPHONE, VARIOUS CONNECTIVITY FAILURES OCCUR, SUCH AS DISCONNECTION OF CALL, LIST OF CONTACTS INCOMPLETE, DUE TO THE VARIANTS AND SOFTWARE USED. MODEL 2008-2014. Read More »
SPL Parts, Inc. manufacturers and distributes aftermarket lower control arms for dedicated competition vehicles and "track day" cars some of which may be used on both track and highway. Read More »
Discharged Battery Energy Diagnosis Must Be Performed: The electrical system of BMW vehicles has been subject to an ongoing development process over the last few years. This has led to increased demands being placed on the battery. Read More »
Discharged Battery Energy Diagnosis Must Be Performed: The electrical system of BMW vehicles has been subject to an ongoing development process over the last few years. This has led to increased demands being placed on the battery. Read More »
