Technical Service Bulletins (TSBs) for the 2001 320 are official communications between BMW & their dealerships that describe processes for troubleshooting or fixing certain common problems.
All vehicle manufacturers are required by U.S. law to make their TSBs available to the public.
BMW VEHICLES: REAR AXLE CARRIER (SUB FRAME) SUPPORT PROPOSED CLASS ACTION SETTLEMENT. UNDER CERTAIN CIRCUMSTANCES, A FRACTURE IN THE STEEL BODY STRUCTURE COULD FORM IN THE AREA AROUND ONE OF THE REAR AXLE CARRIER MOUNTING POINTS. Read More »
BMW VEHICLES: TEILECLEARING FOR DYNAMIC STABILITY CONTROL (DSC). A PART REPLACEMENT AUTHORIZATION MUST BE OBTAINED BY SUBMITTING A TC CASE IN PUMA BEFORE ANY OF THE FOLLOWING DSC COMPONENTS ARE REPLACED UNDER WARRANTY FOR THE VEHICLES ... Read More »
SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:HOSES, LINES/PIPING, AND FITTINGS
BMW VEHICLES: TEILECLEARING FOR DYNAMIC STABILITY CONTROL (DSC). A PART REPLACEMENT AUTHORIZATION MUST BE OBTAINED BY SUBMITTING A TC CASE IN PUMA BEFORE ANY OF THE FOLLOWING DSC COMPONENTS ARE REPLACED UNDER WARRANTY FOR THE VEHICLES ... Read More »
BMW VEHICLE: THE SERVICE ENGINE SOON (MIL) LAMP IS ILLUMINATED AND A POWER REDUCTION IS CLEARLY PERCEPTIBLE. THIS SITUATION MAY OCCUR AFTER DRIVING FOR SOME TIME WITH THE ENGINE ALREADY AT FULL OPERATING TEMPERATURE. Read More »
BMW: SIX DIFFERENT MODELS EQUIPPED WITH THE M54 ENGINE COULD HAVE VALVE COVERS BREAK IN COLD WEATHER AND RUIN THE ENGINE. THIS IS DUE TO MOISTURE ACCUMULATION. *RM Read More »
BMW: THERE IS A ROUGH ENGINE IDLE AND "SERVICE ENGINE SOON LIGHT" WHEN DRIVING DOWNHILL IN HIGH ALTITUDES DURING COLD WEATHER. THERE MAY BE SIX DIFFERENT FAULT CODES. *RM Read More »
BMW: A SERVICE ENGINE SOON LIGHT COMES ON. THE ENGINE WILL ONLY OPERATE TO 1500 RPMS AND LACKS POWER. THERE IS A SOFTWARE APPLICATION ERROR. *RM Read More »
BMW: SERVICE ENGINE LAMP IS ILLUMINATED. DME FC 2A15 MINOR LEAK AND 2A16 SUPERFINE LEAK IN EVAPORATION SYSTEM. TANK VENTILATION CORRUGATED HOSE MAY CONTACT THE LOW SIDE AIR CONDITIONING PRESSURE LINE ALUMINUM FERREL. Read More »
N54 RATTLE NOISE FROM TURBOCHARGER AREA. MODELS E90, E92 AND E93 (3 SERIES) 335I AND 335XI; E60 AND E61 (5 SERIES) 535I AND 535XI, ALL WITH N54 ENGINE FROM THE START OF PRODUCTION TO JANUARY 17, 2008 PRODUCTION. Read More »
N52 EDK THROTTLE JAMMING FAULTS 2D09, 2CED AND 2CEC. MODEL E90 AND E91 (3 SERIES) AND E60 AND E61 (5 SERIES), ALL MODELS UP TO 11/2005 WITH N52 ENGINE. *PE Read More »
BMW VEHICLE: N54 TURBOCHARGER WASTE GATE CONTROL NOISES AND OPERATION. AFTER TURNING OFF ENGINE, A SLIGHT RATTLE NOISE IS HEARD FROM THE ENGINE COMPARTMENT. THIS NOISE IS SIMILAR TO A MECHANICAL TYPEWRITER. Read More »
BMW VEHICLE: M54/M56-MIXTURE TOO LEAN-FAULT CODES 2882/2883 ARE STORED IN THE DME. COMPLAINTS THAT SERVICE ENGINE SOON LIGHT IS ILLUMINATED. THE FAULT CODES 2882/2883-FUEL TRIM, MIXTURE TOO LEAN ARE STORED IN THE DME. Read More »
N54 RATTLE NOISE FROM TURBOCHARGER AREA. MODELS E90, E92 AND E93 (3 SERIES) 335I AND 335XI; E60 AND E61 (5 SERIES) 535I AND 535XI, ALL WITH N54 ENGINE FROM THE START OF PRODUCTION TO JANUARY 17, 2008 PRODUCTION. Read More »
BMW VEHICLE: N54 TURBOCHARGER WASTE GATE CONTROL NOISES AND OPERATION. AFTER TURNING OFF ENGINE, A SLIGHT RATTLE NOISE IS HEARD FROM THE ENGINE COMPARTMENT. THIS NOISE IS SIMILAR TO A MECHANICAL TYPEWRITER. Read More »
BMW VEHICLE: THE SERVICE ENGINE SOON (MIL) LAMP IS ILLUMINATED AND A POWER REDUCTION IS CLEARLY PERCEPTIBLE. THIS SITUATION MAY OCCUR AFTER DRIVING FOR SOME TIME WITH THE ENGINE ALREADY AT FULL OPERATING TEMPERATURE. Read More »
BMW: WARNING MESSAGE ON ABOUT LOW DIESEL EXHAUST FUEL LEVEL AND THAT THE ENGINE WILL NOT RESTART WITHIN 999 MILES. THE LIGHT COMES ON A FEW THOUSAND MILES EARLIER THAN A RECOMMENDED OIL CHANGE. *RM Read More »
N54 RATTLE NOISE FROM TURBOCHARGER AREA. MODELS E90, E92 AND E93 (3 SERIES) 335I AND 335XI; E60 AND E61 (5 SERIES) 535I AND 535XI, ALL WITH N54 ENGINE FROM THE START OF PRODUCTION TO JANUARY 17, 2008 PRODUCTION. Read More »
BMW VEHICLE: N54 TURBOCHARGER WASTE GATE CONTROL NOISES AND OPERATION. AFTER TURNING OFF ENGINE, A SLIGHT RATTLE NOISE IS HEARD FROM THE ENGINE COMPARTMENT. THIS NOISE IS SIMILAR TO A MECHANICAL TYPEWRITER. Read More »
ENGINE AND ENGINE COOLING:COOLING SYSTEM:HOSES/LINES/PIPING/FITTINGS
BMW: SERVICE ENGINE LAMP IS ILLUMINATED. DME FC 2A15 MINOR LEAK AND 2A16 SUPERFINE LEAK IN EVAPORATION SYSTEM. TANK VENTILATION CORRUGATED HOSE MAY CONTACT THE LOW SIDE AIR CONDITIONING PRESSURE LINE ALUMINUM FERREL. Read More »
ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL:CATALYTIC CONVERTOR
BMW VEHICLE: S54-CATALYST PROTECTION MODE WHILE THE VEHICLE IS LOW ON FUEL. COMPLAINTS THAT THE VEHICLE HAS NO POWER DURING HEAVY ACCELERATION. Read More »
BMW VEHICLE: S54-CATALYST PROTECTION MODE WHILE THE VEHICLE IS LOW ON FUEL. COMPLAINTS THAT THE VEHICLE HAS NO POWER DURING HEAVY ACCELERATION. Read More »
BMW VEHICLE: S54-CATALYST PROTECTION MODE WHILE THE VEHICLE IS LOW ON FUEL. COMPLAINTS THAT THE VEHICLE HAS NO POWER DURING HEAVY ACCELERATION. Read More »
BMW VEHICLES: FUEL LEVEL SENSOR REPAIRS. WHERE IT IS NECESSARY TO REPLACE THE RIGHT OR THE LEFT SIDE FUEL LEVEL SENSOR DUE TO A FAILURE, THE ENTIRE PUMP AND HOUSING OR DELIVERY UNIT (SUCTION JET ASSEMBLY) DO NOT NEED TO BE REPLACED AS ... Read More »
BMW VEHICLES: FUEL LEVEL SENSOR REPAIRS. WHERE IT IS NECESSARY TO REPLACE THE RIGHT OR THE LEFT SIDE FUEL LEVEL SENSOR DUE TO A FAILURE, THE ENTIRE PUMP AND HOUSING OR DELIVERY UNIT (SUCTION JET ASSEMBLY) DO NOT NEED TO BE REPLACED AS ... Read More »
BMW VEHICLES: FUEL LEVEL SENSOR REPAIRS. WHERE IT IS NECESSARY TO REPLACE THE RIGHT OR THE LEFT SIDE FUEL LEVEL SENSOR DUE TO A FAILURE, THE ENTIRE PUMP AND HOUSING OR DELIVERY UNIT (SUCTION JET ASSEMBLY) DO NOT NEED TO BE REPLACED AS ... Read More »
BMW VEHICLES: FUEL LEVEL SENSOR REPAIRS. WHERE IT IS NECESSARY TO REPLACE THE RIGHT OR THE LEFT SIDE FUEL LEVEL SENSOR DUE TO A FAILURE, THE ENTIRE PUMP AND HOUSING OR DELIVERY UNIT (SUCTION JET ASSEMBLY) DO NOT NEED TO BE REPLACED AS ... Read More »
BMW: FUEL LEVEL SENSOR REPAIR PROCEDURE. THE CASE WHERE IT IS NECESSARY TO REPLACE THE RIGHT SIDE FUEL LEVEL SENSOR DUE TO A FAILURE, THE ENTIRE PUMP AND HOUSING DOES NOT NEED TO BE REPLACED. NO MODEL YEARS LISTED. Read More »
BMW: WARNING MESSAGE ON ABOUT LOW DIESEL EXHAUST FUEL LEVEL AND THAT THE ENGINE WILL NOT RESTART WITHIN 999 MILES. THE LIGHT COMES ON A FEW THOUSAND MILES EARLIER THAN A RECOMMENDED OIL CHANGE. *RM Read More »
BMW: FUEL LEVEL SENSOR REPAIR PROCEDURE. THE CASE WHERE IT IS NECESSARY TO REPLACE THE RIGHT SIDE FUEL LEVEL SENSOR DUE TO A FAILURE, THE ENTIRE PUMP AND HOUSING DOES NOT NEED TO BE REPLACED. NO MODEL YEARS LISTED. Read More »
BMW VEHICLES: ENGINE CRANKS BUT DOES NOT START; FUEL LEVEL GAUGE DISPLAYS A SUFFICIENT AMOUNT OF FUEL, ALTHOUGH THE FUEL TANK IS EMPTY; FAULT CODE 2A1C (FUEL LEVEL PLAUSIBILITY) IS STORED IN MSV80. Read More »
BMW: FUEL LEVEL SENSOR REPAIR PROCEDURE. THE CASE WHERE IT IS NECESSARY TO REPLACE THE RIGHT SIDE FUEL LEVEL SENSOR DUE TO A FAILURE, THE ENTIRE PUMP AND HOUSING DOES NOT NEED TO BE REPLACED. NO MODEL YEARS LISTED. Read More »
BMW VEHICLE: M54/M56-MIXTURE TOO LEAN-FAULT CODES 2882/2883 ARE STORED IN THE DME. COMPLAINTS THAT SERVICE ENGINE SOON LIGHT IS ILLUMINATED. THE FAULT CODES 2882/2883-FUEL TRIM, MIXTURE TOO LEAN ARE STORED IN THE DME. Read More »
BMW VEHICLES: DSC DISABLING FUNCTION. DSC OFF FUNCTION HAS BEEN IMPLEMENTED IN M5 AND M6 VEHICLES EQUIPPED WITH THE OPTIONAL 6 SPEED MANUAL TRANSMISSIONS. NO MODEL YEARS LISTED. *PE Read More »
BMW: DSC WARNING LIGHT IS ON. THE WARNING LAMPS FOR DSC, ABS AND BRAKE WARNING ILLUMINATED. THERE MAY ALSO BE A WARNING IN THE CONTROL DISPLAY FOR CHASSIS CONTROL SYSTEM FAILURE. *JS Read More »
BMW: VARIOUS FUNCTIONS IN THE VEHICLE ARE NOT WORKING INCLUDING: INSTRUMENTS, DOOR LOCKS, WIPERS, AND OTHER ELECTRICAL FUNCTIONS. THERE MAY ALSO BE WARNING LIGHTS ON. K-CAN WIRING IN THE VEHICLE SHORTED. *RM UPDATED 10/5/11. Read More »
BMW: THE HIGH-VOLTAGE (HV) BATTERY CELLS COULD BE DAMAGED IF THE VEHICLE IS PREVENTED FROM ENTERING SLEEP MODE FOR AN EXTENDED PERIOD OF TIME. UPDATED 03/11/2013 *JS Read More »
BMW: VARIOUS FUNCTIONS IN THE VEHICLE ARE NOT WORKING INCLUDING: INSTRUMENTS, DOOR LOCKS, WIPERS, AND OTHER ELECTRICAL FUNCTIONS. THERE MAY ALSO BE WARNING LIGHTS ON. K-CAN WIRING IN THE VEHICLE SHORTED. *RM UPDATED 10/5/11. Read More »
BMW: A SOFTWARE PROBLEM IS CAUSING ONE OR BOTH OF THE SEAT BELT ASSISTANTS TO NOT EXTEND FULLY OR MAY NOT EXTEND AT ALL. THE POSITION AT WHICH THE ASSISTANT COMES TO REST VARIES. E92. *RM Read More »
BMW: A SERVICE ENGINE SOON LIGHT COMES ON. THE ENGINE WILL ONLY OPERATE TO 1500 RPMS AND LACKS POWER. THERE IS A SOFTWARE APPLICATION ERROR. *RM Read More »
BMW: WIRING ON THE HEADLIGHTS MAY HAVE DETERIORATED DUE TO ENVIRONMENTAL CONDITIONS AND THE COVER NOT BEING SECURED PROPERLY. E60/E92. *RM UPDATED 9/30/11. *PE Read More »
BMW: HEADLAMP MOISTURE: FAULT DIAGNOSTICS. WATER OR CONDENSATION IN ONE OR BOTH HEADLAMPS. MODELS 5 SERIES, 6 SERIES, 7 SERIES, X5, X6, 1 SERIES, AND 3 SERIES. MODEL YEARS 2000-20008. *PE Read More »
REAR BULB FAILURE. MODEL E92 (3 SERIES COUPE) VEHICLES PRODUCED UP TO JANUARY 21, 2008 ARE AFFECTED. THE BULB OUT WARNING SHOWS IN THE INSTRUMENT CLUSTER. *PE Read More »
BMW SERVICE CAMPAIGN: SEE DOCUMENT SEARCH BUTTON FOR OWNER LETTER. THE AIRBAG WARNING LAMP (AWL) IS ILLUMINATED, TOGETHER WITH THE PASSENGER AIRBAG STATUS LAMP (POL). THE PROBLEM MAY BE INTERMITTENT. MICROCRACKS IN THE OC3 SEAT MAT. Read More »
BMW: SOME AIRBAGS, DRIVER AND FRONT PASSENGER, ARE IMPROPERLY DEPLOYING DUE TO A POSSIBLE INFLATOR NOT PRODUCED TO SPECIFICATIONS. MODEL 2001-2006 E46 (3 SERIES). *PE UPDATED 9/4/14. *PE Read More »
BMW: E92. THE SEAT BELT EXTENDER ON THE FRONT DRIVER?S OR PASSENGER SIDE FAILED TO DELIVER THE BELT. THE SAFETY BELT EXTENDER EXTENDS BUT THE BELT SLIPS OFF. THE ?HAND? ON THE EXTENDER FAILS. THE SAFETY BELT IS TWISTED. Read More »
BMW: A SOFTWARE PROBLEM IS CAUSING ONE OR BOTH OF THE SEAT BELT ASSISTANTS TO NOT EXTEND FULLY OR MAY NOT EXTEND AT ALL. THE POSITION AT WHICH THE ASSISTANT COMES TO REST VARIES. E92. *RM Read More »
BMW: E92. THE SEAT BELT EXTENDER ON THE FRONT DRIVER?S OR PASSENGER SIDE FAILED TO DELIVER THE BELT. THE SAFETY BELT EXTENDER EXTENDS BUT THE BELT SLIPS OFF. THE ?HAND? ON THE EXTENDER FAILS. THE SAFETY BELT IS TWISTED. Read More »
BMW VEHICLE: FRONT SAFETY BELT DOES NOT RETRACT SMOOTHLY OR JAMS. THE UPPER PART OF THE DRIVER'S OR PASSENGER'S FRONT SAFETY BELT DOES NOT ROLL UP FULLY OR ROLLS UP SLOWLY. Read More »
BMW VEHICLE: FRONT SAFETY BELT DOES NOT RETRACT SMOOTHLY OR JAMS. THE UPPER PART OF THE DRIVER'S OR PASSENGER'S FRONT SAFETY BELT DOES NOT ROLL UP FULLY OR ROLLS UP SLOWLY. Read More »
BMW VEHICLES: REAR AXLE CARRIER (SUB FRAME) SUPPORT PROPOSED CLASS ACTION SETTLEMENT. UNDER CERTAIN CIRCUMSTANCES, A FRACTURE IN THE STEEL BODY STRUCTURE COULD FORM IN THE AREA AROUND ONE OF THE REAR AXLE CARRIER MOUNTING POINTS. Read More »
BMW VEHICLES: REAR AXLE CARRIER (SUB FRAME) SUPPORT PROPOSED CLASS ACTION SETTLEMENT. UNDER CERTAIN CIRCUMSTANCES, A FRACTURE IN THE STEEL BODY STRUCTURE COULD FORM IN THE AREA AROUND ONE OF THE REAR AXLE CARRIER MOUNTING POINTS. Read More »
SUBJECT REGARDING INTERMITTENT ACCELERATOR PEDAL FEEL PROBLEM - REVISED WITH SIMPLIFIED ORDERING PROCEDURE FOR CERTAIN MODELS INCLUDING E65/E66 SINCE SERIES INTRODUCTION UP TO 06/02. *TT Read More »
CUSTOMER MAY COMPLAIN OF THE ACCELERATOR PEDAL FEELINGNOTCHY OR NOT MOVING SMOOTHLY WHEN DEPRESSED IN SMALL INCREMENTS ON CERTAIN MODELS INCLUDING E52, E53 AND E65/E66 VEHICLES FROM SERIES INTRODUCTION UP TO 06/02. Read More »
BMW: SEAT FRAME DESIGN CHANGED FOR 392 (3 SERIES COUPE) PRODUCED UP TO MAY 2007. ON EARLY PRODUCTION E92S, THE SOCKET WHICH SECURES THE SEAT BACKREST RELEASE CABLE TO THE RELEASE MECHANISM COULD PULL FREE FROM THE RELEASE MECHANISM. Read More »
