Technical Service Bulletins (TSBs) for the 2005 120d are official communications between BMW & their dealerships that describe processes for troubleshooting or fixing certain common problems.
All vehicle manufacturers are required by U.S. law to make their TSBs available to the public.
BMW VEHICLES: TEILECLEARING FOR DYNAMIC STABILITY CONTROL (DSC). A PART REPLACEMENT AUTHORIZATION MUST BE OBTAINED BY SUBMITTING A TC CASE IN PUMA BEFORE ANY OF THE FOLLOWING DSC COMPONENTS ARE REPLACED UNDER WARRANTY FOR THE VEHICLES ... Read More »
BMW VEHICLES: TEILECLEARING FOR DYNAMIC STABILITY CONTROL (DSC). A PART REPLACEMENT AUTHORIZATION MUST BE OBTAINED BY SUBMITTING A TC CASE IN PUMA BEFORE ANY OF THE FOLLOWING DSC COMPONENTS ARE REPLACED UNDER WARRANTY FOR THE VEHICLES ... Read More »
BMW: THERE MAY BE EXCESSIVE CRANKING BEFORE THE VEHICLE STARTS. THE SERVICE ENGINE SOON LIGHT MAY ALSO BE ON WITH A LACK OF ENGINE POWER. *RM Read More »
BMW: COMPLAINTS THAT THE ENGINE MANAGEMENT SYSTEM HAS ENTERED THE ENGINE FAILSAFE MODE AND THAT THE TURBOCHARGER BOOST IS REDUCED. E82, E88, E90, E92, E93, E60, E61, AND E71. ALL MODELS WITH NAY ENGINES. NO MODEL YEARS LISTED. Read More »
BMW: COMPLAINTS THAT THE ENGINE MANAGEMENT SYSTEM HAS ENTERED THE ENGINE FAILSAFE MODE AND THAT THE TURBOCHARGER BOOST IS REDUCED. E82, E88, E90, E92, E93, E60, E61, AND E71. ALL MODELS WITH NAY ENGINES. NO MODEL YEARS LISTED. Read More »
BMW: OIL LEAKS FROM THE AIR HOSE ON TURBOCHARGER. THIS IS DESIGNATED FOR E70, AND E90 MODELS WITH M57Y DIESEL ENGINES. SERVICE ENGINE SOON LAMP MAY BE ILLUMINATED. *KB Read More »
BMW: ON SOME VEHICLES, THE HIGH PRESSURE FUEL PUMP HAS AN INTERNAL COMPONENT THAT MAY FAIL AND CAUSING DRIVABILITY SYMPTOMS SUCH AS ERRATIC ENGINE OPERATION AND LONGER STARTING TIMES. *PE Read More »
BMW VEHICLES: FUEL LEVEL SENSOR REPAIRS. WHERE IT IS NECESSARY TO REPLACE THE RIGHT OR THE LEFT SIDE FUEL LEVEL SENSOR DUE TO A FAILURE, THE ENTIRE PUMP AND HOUSING OR DELIVERY UNIT (SUCTION JET ASSEMBLY) DO NOT NEED TO BE REPLACED AS ... Read More »
BMW VEHICLES: ENGINE CRANKS BUT DOES NOT START; FUEL LEVEL GAUGE DISPLAYS A SUFFICIENT AMOUNT OF FUEL, ALTHOUGH THE FUEL TANK IS EMPTY; FAULT CODE 2A1C (FUEL LEVEL PLAUSIBILITY) IS STORED IN MSV80. Read More »
BMW: WATER PENETRATES THE PASSENGER COMPARTMENT DUE TO OPENINGS IN SERVICE TRANSMISSION TUNNEL WITH INSUFFICIENT SEALING, CAUSING CARPET TO BE WET IN CENTER TUNNEL AREA. *PE Read More »
BMW: WATER PENETRATES THE PASSENGER COMPARTMENT DUE TO OPENINGS IN SERVICE TRANSMISSION TUNNEL WITH INSUFFICIENT SEALING, CAUSING CARPET TO BE WET IN CENTER TUNNEL AREA. *PE Read More »
The electrical system of BMW vehicles has been subject to an ongoing development process over the last few years. This has led to increased demands being placed on the battery. Read More »
Discharged Battery Energy Diagnosis Must Be Performed: The electrical system of BMW vehicles has been subject to an ongoing development process over the last few years. This has led to increased demands being placed on the battery. Read More »
DURING THE SCHEDULED 3 MONTH/ 5,000 MILE SERVICE IT COULD POSSIBLY BE DETERMINED THAT SOME OF THE CONTACT PROTECTIVE SLEEVE S IN THE CHARGING SOCKET MAY BE MISSING. BMW MODEL E28E. *KB Read More »
BMW: INFORMATION ON MAINTENANCE TO E MOTOR GREASING WHERE THE EME/E MOTOR ASSEMBLY IS REMOVED. THE CABLES, EME HIGH VOLTAGE, SHOULD BE REINSTALLED IN ORIGINAL FACTORY POSITION TO AVOID CONTACT WITH EXPOSED FASTENERS IN REAR RIGHT WHEEL ... Read More »
BMW: BATTERY HAS AN INCREASED DEMAND DUE TO DEVELOPEMENTAL PROCESS OF THE ELECTRICAL SYSTEM. THIS IS CAUSING THE BATTER TO NEED TO UNDERGO AN ENERGY DIAGNOSIS. *KB Read More »
BMW: INFORMATION ON MAINTENANCE TO E MOTOR GREASING WHERE THE EME/E MOTOR ASSEMBLY IS REMOVED. THE CABLES, EME HIGH VOLTAGE, SHOULD BE REINSTALLED IN ORIGINAL FACTORY POSITION TO AVOID CONTACT WITH EXPOSED FASTENERS IN REAR RIGHT WHEEL ... Read More »
BMW: HEADLAMP MOISTURE: FAULT DIAGNOSTICS. WATER OR CONDENSATION IN ONE OR BOTH HEADLAMPS. MODELS 5 SERIES, 6 SERIES, 7 SERIES, X5, X6, 1 SERIES, AND 3 SERIES. MODEL YEARS 2000-20008. *PE Read More »
BMW: MOUNTING TENSION OR THE CUTOUT AREA OF THE TRUNK FOR THE LIGHT IS CAUSING THE THIRD BRAKE LIGHT LENS TO CRACK. THIS IS ALLOWING WATER TO LEAK IN. *RM UPDATED 1/06/12. *PE Read More »
BMW: REPLACEMENT OF THE OC3 SENSOR SEAT MAT ON THE PASSENGER SEAT. MODELS E82, E88, E90, E91, E92, E93. MODEL YEARS UNKNOWN. *KB UPDATED 12/6/13. *PE Read More »
BMW VEHICLE: AFTER RAINFALL, VARYING AMOUNTS OF WATER MAY BE PRESENT IN THE LUGGAGE COMPARTMENT OF THE VEHICLE. THIS WATER MAY BE PRESENT IN EITHER SIDE AREA, OR IN THE WHEEL WELL AREA. NO MODEL YEARS LISTED. Read More »
BMW VEHICLE: AFTER RAINFALL, VARYING AMOUNTS OF WATER MAY BE PRESENT IN THE LUGGAGE COMPARTMENT OF THE VEHICLE. THIS WATER MAY BE PRESENT IN EITHER SIDE AREA, OR IN THE WHEEL WELL AREA. NO MODEL YEARS LISTED. Read More »
ASC (AUTOMATIC STABILITY CONTROL) OPERATION TO SENSITIVE. CRUISE CONTROL ACTION FUNCTION CAN OCCASIONALLY ACTIVATE AND DEACTIVATE DUE TO THE ASC IMPLAUSABILITY WHEN THE DSC WARNING LAMP IS FLASHING ON THE INSTRUMENT CLUSTER. BMW. Read More »
Discharged Battery Energy Diagnosis Must Be Performed: The electrical system of BMW vehicles has been subject to an ongoing development process over the last few years. This has led to increased demands being placed on the battery. Read More »
Discharged Battery Energy Diagnosis Must Be Performed: The electrical system of BMW vehicles has been subject to an ongoing development process over the last few years. This has led to increased demands being placed on the battery. Read More »
BMW: WATER LEAKS INTO EITHER THE DRIVER'S SIDE OR PASSENGER'S SIDE FOOTWELL DURING FAST CORNERING. INSUFFICIENT SEALING AT THE POINT OF CONTACT BETWEEN THE AIR CONDITIONING SYSTEM AND THE CONDENSATION DRAIN HOSE. Read More »
