Technical Service Bulletins (TSBs) for the 2005 A4 are official communications between Audi & their dealerships that describe processes for troubleshooting or fixing certain common problems.
All vehicle manufacturers are required by U.S. law to make their TSBs available to the public.
AUDI: ENGINE, ON SOME VEHICLES, WOULD RUN IRREGULARLY OR HAVE MALFUNCTION INDICATOR LAMP (MIL) ON OR POSSIBLE FILTER ELEMENT FOR CAMSHAFT ADJUSTMENT VALVE CAN LOOSEN AND IN OIL CIRCUIT, THERE IS NO DAMAGE FROM LOOSENED PARTICLES. Read More »
AUDI: 01 MIL ON P1545, P0121, P0123, P0221, OR P0222 STORED IN ECM. A NUMBER OF INCIDENT MEMORY ENTRIES WITH REGARD TO THROTTLE VALVE ARE STORED IN THE ECM. IN MOST CASES, THE ENTRIES ARE SPORADIC. Read More »
SPORADICALLY AFTER COLD START, ENGINE MAY RUN SLIGHTLY ROUGH FOR A FEW SECONDS AND THE MALFUNCTION INDICATOR LAMP MAY ILLUMINATE WITH ONLY MISFIRE DIAGNOSTIC TROUBLE CODES (DTC) (P0300, P0301, P0302, P0303, P0304) STORED IN DTC MEMORY. Read More »
AUDI: 01 MIL ON (P1297, P2187, P2279), OIL LEAKS, PRESSURE LOSS, SYSTEM TOO LEAN AT IDLE SPEED, AND INTAKE AIR SYSTEM LEAK. THERE MAY BE WHISTLE NOISE/AIR RUSHING NOISE FROM THE ENGINE. ALSO INCLUDED MODEL AUDI TTS MODEL YEARS 2010-2011. Read More »
AUDI: ENGINE HAS REDUCED ENGINE PERFORMANCE WITHOUT LOSS OF POWER OR STALLING; CIRCUIT GROUNDS; FUEL QUALITY POOR; MIL IS CONSTANTLY ILLUMINATED OR FLASHING; ROUGH IDLE; IGNITION COILS INCORRECTLY INSTALLED; ELECTRICAL CONNECTIONS LOOSE ... Read More »
AUDI: SOME VEHICLES MAY EXPERIENCE SEVERAL MALFUNCTIONS REGARDING THE INTAKE FLAP MOTOR OR INTAKE MANIFOLD RUNNER POSITION SENSOR THAT MAY BE INOPERATIVE. *PE Read More »
AUDI: ONE OR MORE OF THE FOLLOWING DTCS ARE STORED WITHIN FIRST 60 SECONDS, WHEN COOLANT TEMPERATURE IS BETWEEN 10-39%C ACCORDING TO FREEZE FRAME DATA: DTC P0300 (RANDOM/MULTIPLE CYLINDER MISFIRE DETECTED); DTC P0301-P0306 (CYL. Read More »
AUDI: MIL ON AND ONE OR MORE OF THE FOLLOWING DTCS ARE STORED IN THE ECM DATA MEMORY-P310B (LOW PRESSURE FUEL SYSTEM REGULATION, FUEL PRESSURE OUTSIDE TOLERANCE); P129F OR P008B (LOW PRESSURE FUEL SYSTEM, PRESSURE TOO HIGH); P129E OR ... Read More »
AUDI: MIL ON, ENGINE SPEED SENSOR SPACER NOT REQUIRED (DTC P0300, P0335, P0336, P0321, P0322). MULTIPLE MISFIRES DETECTED ON ONE OR MORE CYLINDERS; MALFUNCTION INDICATOR LIGHT (MIL) MAY BE ON OR FLASHING. Read More »
AUDI: OIL LEAKS. ONE OR MORE OF THE FOLLOWING CONDITIONS MAY BE PRESENT-MIL ON, AND ONE OR MORE OF FOLLOWING DTCS ARE STORED IN ECM DATA MEMORY-P1297 (CONNECTION CHARGER THROTTLE VALVE, PRESSURE LOSS), P2187 (FUEL TRIM BANK 1, SYSTEM ... Read More »
AUDI: GASOLINE ENGINE VEHICLES; INSPECT, AND IF NECESSARY, REPLACE IGNITION COILS. VEHICLES AFFECTED BY THIS ACTION MAY HAVE IGNITION COILS THAT COULD MALFUNCTION UNDER CERTAIN CONDITIONS. ADDED FINAL MAILING PHASE-8/10 VIN INFORMATION. Read More »
AUDI: EMISSIONS SERVICE ACTION CIRCULAR. GASOLINE ENGINE VEHICLES INSPECT, AND IF NECESSARY, REPLACE IGNITION COILS. VEHICLES AFFECTED BY THIS ACTION MAY HAVE IGNITION COILS THAT COULD MALFUNCTION UNDER CERTAIN CONDITIONS. Read More »
AUDI: OIL LEAKS. ONE OR MORE OF THE FOLLOWING CONDITIONS MAY BE PRESENT-MIL ON, AND ONE OR MORE OF FOLLOWING DTCS ARE STORED IN ECM DATA MEMORY-P1297 (CONNECTION CHARGER THROTTLE VALVE, PRESSURE LOSS), P2187 (FUEL TRIM BANK 1, SYSTEM ... Read More »
ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:MANIFOLD/HEADER/MUFFLER/TAIL PIPE
AUDI: MIL LIGHT ON AND DTC P2294 (FUEL PRESSURE REGULATOR 2 CONTROL CIRCUIT), P2295 (FUEL PRESSURE REGULATOR 2 CONTROL CIRCUIT LOW), P2296 (FUEL PRESSURE REGULATOR 2 CONTROL CIRCUIT HIGH) IN FAULT MEMORY DRIVABILITY IS NOT AFFECTED. Read More »
AUDI: MIL ON (DTC P2293, P0087 IN ECM). THE FOLLOWING DTC IS STORED IN THE ECM DATA MEMORY: P2293 (FUEL PRESSURE REGULATOR 2 PERFORMANCE); P0087 (RAIL FUEL PRESSURE TOO LOW); P1093 (FUEL TRIM 2, BANK 1 MALFUNCTION). Read More »
AUDI: MIL ON (DTC P2293, P0087 IN ECM). THE FOLLOWING DTC IS STORED IN THE ECM DATA MEMORY: P2293 (FUEL PRESSURE REGULATOR 2 PERFORMANCE); P0087 (RAIL FUEL PRESSURE TOO LOW); P1093 (FUEL TRIM 2, BANK 1 MALFUNCTION). Read More »
AUDI: DUE TO FUEL INTRUSION INTO THE LOW-PRESSURE SYSTEM FUEL PRESSURE SENSOR (G410), A FALSE SIGNAL MAY BE SENT TO THE CONTROLLER RESULTING IN A READING THAT IS OUT OF TOLERANCE. *PE Read More »
AUDI: MIL ON AND ONE OR MORE OF THE FOLLOWING DTCS ARE STORED IN THE ECM DATA MEMORY-P310B (LOW PRESSURE FUEL SYSTEM REGULATION, FUEL PRESSURE OUTSIDE TOLERANCE); P129F OR P008B (LOW PRESSURE FUEL SYSTEM, PRESSURE TOO HIGH); P129E OR ... Read More »
AUDI: UNABLE TO FILL THE FUEL TANK BECAUSE THE FUEL PUMP NOZZLE SHUTS OFF PREMATURELY WHILE REFILLING THE FUEL TANK. THE CANISTER FILTER ELEMENT MAY BE PARTIALLY OR COMPLETELY CLOGGED BY PARTICLES. Read More »
AUDI: BULLETIN INFORMATION PERTAINING TO CERTAIN VEHICLES REGARDING THE FUEL SYSTEM PRESSURE IS EITHER TOO LOW OR TOO HIGH AND PROVIDING A FALSE SIGNAL. *PE UPDATED ON 5/2/2012. *KB Read More »
AUDI: 24T4 UPDATE FUEL PRESSURE SENDER (WARR_EXT) IT IS POSSIBLE THAT THE FUEL PRESSURE SENDER FOR LOW-PRESSURE MAY FAIL ON AUDI VEHICLES WITH 2.0L TFSI ENGINES BUILT WITHIN A SPECIFIC PERIOD. *JS Read More »
AUDI: ON SOME VEHICLES, THE FUEL PRESSURE SENSOR, IMRC MOTOR, OR PRESSURE VALVE MAY FAIL ON TFSI ENGINES, MANUFACTURED WITHIN SPECIFIC PERIOD. *PE Read More »
AUDI: DUE TO FUEL INTRUSION INTO THE LOW PRESSURE SYSTEM FUEL PRESSURE SENSOR (G410), A FALSE SIGNAL MAY BE SENT TO THE CONTROLLER, RESULTING IN A READING THAT IS OUT OF TOLERANCE. Read More »
AUDI: DUE TO FUEL INTRUSION INTO THE LOW-PRESSURE SYSTEM FUEL PRESSURE SENSOR (G410), A FALSE SIGNAL MAY BE SENT TO THE CONTROLLER RESULTING IN A READING THAT IS OUT OF TOLERANCE. *PE Read More »
VOLKSWAGEN SERVICE CAMPAIGN: SEE DOCUMENT SEARCH BUTTON FOR OWNER LETTER. PRODUCTION ISSUES MAY CAUSE PREMATURE WEAR ON THE INTAKE CAMSHAFT AND CAMSHAFT FOLLOWER. MALFUNCTION LIGHT WILL ILLUMINATE. Read More »
AUDI: MIL LIGHT ON AND DTC P2294 (FUEL PRESSURE REGULATOR 2 CONTROL CIRCUIT), P2295 (FUEL PRESSURE REGULATOR 2 CONTROL CIRCUIT LOW), P2296 (FUEL PRESSURE REGULATOR 2 CONTROL CIRCUIT HIGH) IN FAULT MEMORY DRIVABILITY IS NOT AFFECTED. Read More »
AUDI: MIL ON (DTC P2293, P0087 IN ECM). THE FOLLOWING DTC IS STORED IN THE ECM DATA MEMORY: P2293 (FUEL PRESSURE REGULATOR 2 PERFORMANCE); P0087 (RAIL FUEL PRESSURE TOO LOW); P1093 (FUEL TRIM 2, BANK 1 MALFUNCTION). Read More »
VOLKSWAGEN: THERE IS NO DRIVE OR A DELAYED DRIVE WHEN SELECTING REVERSE OR DRIVE. THERE IS A POSSIBLE TROUBLE CODE STORED. THERE ARE SOME DAMAGED TRANSMISSION SEALS FROM PRODUCTION THAT MAY BE LEAKING. Read More »
AUDI: ENGINE HAS REDUCED ENGINE PERFORMANCE WITHOUT LOSS OF POWER OR STALLING; CIRCUIT GROUNDS; FUEL QUALITY POOR; MIL IS CONSTANTLY ILLUMINATED OR FLASHING; ROUGH IDLE; IGNITION COILS INCORRECTLY INSTALLED; ELECTRICAL CONNECTIONS LOOSE ... Read More »
LIGHT SENSOR WARNING LIGHT ON INTERMITTENTLY AND CUSTOMER CONCERN ABOUT AUTOMATIC HEADLIGHT INSTRUMENT CLUSTER WARNING LIGHT ILLUMINATING FOR 1 SECOND ACCOMPANIED WITH A SHORT BEEP. *TT Read More »
MALFUNCTION INDICATOR LAMP (MIL) MAY BE ILLUMINATED. DIAGNOSTIC TROUBLE CODE (DTC) P2106 (18538) THROTTLE ACTUATOR CONTROL SYSTEM - FORCED LIMITED POWER MAY BE PRESENT. *TT Read More »
AUDI: MIL LIGHT ON AND DTC P2294 (FUEL PRESSURE REGULATOR 2 CONTROL CIRCUIT), P2295 (FUEL PRESSURE REGULATOR 2 CONTROL CIRCUIT LOW), P2296 (FUEL PRESSURE REGULATOR 2 CONTROL CIRCUIT HIGH) IN FAULT MEMORY DRIVABILITY IS NOT AFFECTED. Read More »
AUDI: GASOLINE ENGINE VEHICLES INSPECT, AND IF NECESSARY, REPLACE IGNITION COILS. VEHICLES AFFECTED BY THIS ACTION MAY HAVE IGNITION COILS THAT COULD MALFUNCTION UNDER CERTAIN CONDITIONS. (ADDED PHASE 7-APRIL 10 VIN INFORMATION). Read More »
AUDI: FOR INTERIM CLAIMS FOR 28F2/J1 VEHICLES CAMPAIGN ONLY. APPLICABLE VEHICLES MUST FALL WITHIN VIN RANGES NOTED. ENGINES 2.8L ARE NOT AFFECTED IN THIS SCOPE. COILS OF SCREW DOWN DESIGN (NON PENCIL TYPE) ARE ALSO NOT AFFECTED. Read More »
AUDI: EMISSIONS SERVICE ACTION CIRCULAR. GASOLINE ENGINE VEHICLES INSPECT, AND IF NECESSARY, REPLACE IGNITION COILS. VEHICLES AFFECTED BY THIS ACTION MAY HAVE IGNITION COILS THAT COULD MALFUNCTION UNDER CERTAIN CONDITIONS. Read More »
AUDI: SOFTWARE VERSION MANAGEMENT (SVM) OPERATING INSTRUCTIONS. DETAILING THE GENERAL PROCESS FOR CARRYING OUT A SOFTWARE VERSION MANAGEMENT (SVM) SOFTWARE UPDATE FOR ANY TSB OR REQUIRED VEHICLE UPDATE (RVU). Read More »
AUDI: SOFTWARE VERSION MANAGEMENT (SVM), OPERATING INSTRUCTIONS. SVM IS A PROCESS TO UPDATE THE PROGRAMMING IN FLASHABLE (RE-PROGRAMMABLE) CONTROL MODULES AND/OR TO DOCUMENT CHANGES IN SOFTWARE LEVELS IN AUDI VEHICLES. Read More »
AUDI: SOFTWARE VERSION MANAGEMENT(SVM) OPERATING INSTRUCTIONS. ITS A PROCESS TO UPDATE THE PROGRAMMING IN FLASHABLE (REPROGRAMMABLE) CONTROL MODULES AND/OR TO DOCUMENT CHANGES IN SOFTWARE LEVELS IN ALL AUDI VEHICLES. Read More »
AUDI: RVU-SOFTWARE UPDATE FOR MULTITRONIC GEARBOX (IU). THIS RVU HAS BEEN PROACTIVELY RELEASED TO PREVENT THE FOLLOWING CONDITION FROM OCCURRING IN THE VEHICLE: SHUDDER DURING ACCELERATION. *PE Read More »
AUDI: HEADLIGHT, LOW BEAM MAY NOT WORK. THERE ARE TWO SEPARATE CONDITIONS THAT BOTH OCCUR IN VEHICLES WITH BI XENON, WITH OR WITHOUT ADAPTIVE LIGHTING(AFS). ONE XENON LIGHT ON EITHER SIDE SPORADICALLY FLICKERS OR FLASHES AND GOES OUT. Read More »
AUDI: DAYTIME RUNNING LIGHTS DO NOT WORK. DAYTIME RUNNING LIGHTS DO NOT WORK ON VEHICLES WITH XENON HEADLIGHTS. THE THUMB WHEEL OR OPTION FOR DAYTIME RUNNING LIGHTS IS TURNED OFF BY MISTAKE. *PE Read More »
AUDI: THERE ARE TWO SEPARATE CONDITIONS THAT BOTH OCCUR IN VEHICLES WITH BI-XENON, WITH OR WITHOUT ADAPTIVE LIGHTING (AFS): ONE XENON LIGHT ON EITHER SIDE SPORADICALLY FLICKERS OR FLASHES AND GOES OUT. Read More »
AUDI: HEADLIGHT, LOW BEAM MAY NOT WORK. THERE ARE TWO SEPARATE CONDITIONS THAT BOTH OCCUR IN VEHICLES WITH BI XENON, WITH OR WITHOUT ADAPTIVE LIGHTING(AFS). ONE XENON LIGHT ON EITHER SIDE SPORADICALLY FLICKERS OR FLASHES AND GOES OUT. Read More »
AUDI: HEADLIGHT VIBRATION, A4 AND A4 CABRIOLET. UNDER CERTAIN OPERATING CONDITIONS, SUCH AS AT IDLE, VIBRATIONS OR RESONANCES IN THE FRONT OF THE VEHICLE CAN CAUSE THE HEADLIGHTS TO VIBRARTE. *PE Read More »
AUDI: ADAPTIVE LIGHTING, HEADLIGHT RANGE CONTROL WARNING. HEADLIGHT RANGE CONTROL WARNING IS ON IN THE DRIVER INFORMATION DISPLAY. AFTER CYCLING THE IGNITION WARNING SYMBOL IS OFF AGAIN. Read More »
AUDI: AUTOMATIC HEADLIGHT SWITCHES ON AND OFF WITHOUT REASON. HEADLIGHT TURNS ON OR OFF EARLY OR LATE WHEN THE LIGHT WITCH IS IN THE AUTO POSITION; AFTER REPLACING THE RAIN LIGHT SENSOR G397 OR AFTER REPLACING THE WINDSHIELD, THE ... Read More »
AUDI: AUTOMATIC HEADLIGHT SWITCHES ON AND OFF WITHOUT REASON. AUTOMATIC HEADLIGHT SWITCHES ON TOO EARLY OR TOO LATE, SWITCHES OFF TOO LATE OR COMES ON TOO LATE WHEN THE SUN SHINES BRIGHTLY. Read More »
AUDI: THERE ARE TWO SEPARATE CONDITIONS THAT BOTH OCCUR IN VEHICLES WITH BI-XENON, WITH OR WITHOUT ADAPTIVE LIGHTING (AFS). ONE XENON LIGHT ON EITHER SIDE SPORADICALLY FLICKERS OR FLASHES AND GOES OUT. Read More »
AUDI: THERE ARE TWO SEPARATE CONDITIONS THAT BOTH OCCUR IN VEHICLES WITH BI-XENON, WITH OR WITHOUT ADAPTIVE LIGHTING (AFS): ONE XENON LIGHT ON EITHER SIDE SPORADICALLY FLICKERS OR FLASHES AND GOES OUT. Read More »
AUDI: THE CONNECTOR BETWEEN AIRBAG AND SEAT HARNESS HAS A SPORADIC HIGH RESISTANCE DUE TO AIRBAG WARNING LAMP BEING ILLUMINATED IN INSTRUMENT CLUSTER, EVEN THOUGH SIDE AIRBAG SYSTEM IS FUNCTIONING NORMALLY. Read More »
AUDI: WHEEL BOLTS REQUIRE TORQUE ADJUSTMENT. TORQUE STICKS AND TORQUE EXTENSION BARS ARE NOT APPROVED BY AUDI OF AMERICA, INC. AND SHOULD NOT BE USED TO APPLY TORQUE TO WHEEL BOLTS. ALL AUDI MODELS INCLUDED. Read More »
AUDI: DUE TO FUEL INTRUSION IN LOW PRESSURE SYSTEM FUEL PRESSURE SENSOR, A FALSE SIGNAL IS BEING SENT TO CONTROLLER, RESULTING IN AN OUT OF TOLERANCE READING FOR G410. MODEL 2005-08 A4, 2007-08 A4 CABRIOLET, A3, 2007 TT. Read More »
AUDI: ENGINE OIL PRESSURE IS BELOW SPECIFIED VALUE. OIL PRESSURE WARNING LIGHT MIGHT BE ILLUMINATED OR ILLUMINATED INTERMITTENTLY. REPAIRS INCLUDE REPLACING THE OIL PUMP MODULE. *PE Read More »
AUDI: ON CERTAIN VEHICLES, USE CALIBRATED TORQUE WRENCH AND NOT TORQUE STICKS, TORQUE EXTENSION BARS AND IMPACT GUNS/WRENCHES NOT APPROVED FOR USAGE ON WHEEL BOLTS BY MANUFACTURER, THAT CAN CAUSE DAMAGE TO BRAKE, STEERING WHEEL, HUB. Read More »
AUDI: ADAPTIVE LIGHTING, HEADLIGHT RANGE CONTROL WARNING. HEADLIGHT RANGE CONTROL WARNING IS ON IN THE DRIVER INFORMATION DISPLAY. AFTER CYCLING THE IGNITION WARNING SYMBOL IS OFF AGAIN. Read More »
AUDI: ENGINE OIL PRESSURE IS BELOW SPECIFIED VALUE. OIL PRESSURE WARNING LIGHT MIGHT BE ILLUMINATED OR ILLUMINATED INTERMITTENTLY. REPAIRS INCLUDE REPLACING THE OIL PUMP MODULE. *PE Read More »
