This data is from the NHTSA — the US gov't agency tasked with vehicle safety. Complaints are spread across multiple & redundant categories, & are not organized by problem.
So how do you find out what problems are occurring? For this NHTSA complaint data, the only way is to read through the comments below. Any duplicates or errors? It's not us.
The engine stopped while driving with no warning and provided no opportunity to exit the travel lane of the road. No warning lights were illuminated on the dashboard and all gauges appeared normal leading up to the event. This event is extremely frustrating, but I am thankful that it didn't happen on the interstate as there is no telling what the outcome may have been......... Leading up to the event, I had been driving on the interstate around 70mph for about 180 miles since the last restart. I exited the interstate and made it about 3/4 miles on a secondary road and the engine died without warning and the truck came to a quick stop in the lane of travel. No abnormal sounds were observed, just a sudden unwelcome deacceleration that did not provide enough time to exit the lane of travel. It was like stepping on the brakes. I attempted to restart the truck and the starter would not crank the engine and briefly pulled enough voltage to kill all the electronics. I attempted starting it again with a jump box attached and met the same result. The computers freaking out from the low voltage during the starting attempts wouldn't allow me to put the truck in neutral to move it out of the lane of travel. A police officer called for the tow truck on rotation since I was stuck in a live travel lane. The truck was towed to the Dealer on 8/19/2024 after the service department had closed and still would not turn over when removed from the tow truck. There were no signs of any fluids leaking from the truck after the event........ The next day the Service Advisor called and advised there were only 3 codes stored related to low voltage. Truck is waiting for a tech to become available to further investigate.
My truck experienced a total transmission failure while at Highway Speed towing a 5th wheel camper on Interstate I95. This transmission failure is a known issue and has a TSB 21-002-23. A k1 clutch clip becomes dislodged and the transmission will not function. Being stranded and unable to move on a busy highway is unsafe and terrifying. Aisin Transmission and RAM are well aware of this failure however I was never notified about the potential failure nor has a recall been issued. The failure occurred instantly with no warning in a vehicle with 16,000 miles and less than 2 years old. My vehicle has been repaired and the failure was confirmed as the K1 clutch clip failure. There should be an immediate recall for this known failure to be repaired prior to being stranded on the side of the highway, 400 miles from home with my wife and kids. It's shameful RAM has ignored this problem!
The transmission wont shift gears. We were stranded at a campsite. The problem has been confirmed by Santa Rosa Ram. Inspection by RAM directly is unknown. Loud clanking noises were heard many days before the final failure.
While towing a camper 5 hours from home. Traveling approx 5-10 MPH in slow moving traffic the 2022 Ram 3500 HO with Aisin Transmission made a loud and sudden pop. It lost all forward power as if it went into neutral. Barely using momentum to limp the truck off the side of a busy highway during rush hour with my family on board.
On June 5th, 2024 while pulling a travel trailer on vacation, we stopped for a short break and left the truck running. When we went to get back on the highway, I put the truck in gear and nothing happened. Truck would only shift into reverse with a violent bang. Would not go forward. Unhooked my trailer and shifted into REVERSE a few times and finally got the truck to inch forward at HIGH RPM. Towed to a Ram dealer and they confirmed a snap ring failure caused the forward clutches to go out. Truck is still awaiting repairs 445 miles from home.
I was driving coming to a stop for a red light and it turns green. As I go to press on the gas my dashboard lights up with error codes stating a 4WD System error of some kind. As I go to press on the gas the truck loses power and acceleration and starts making a horrible clunking noise. I took it to the dealer because it seems like a transmission issue. This is a 2022 Ram 3500 with 9300 miles at time of failure. I would hate to see what happens if I was towing a large load to lose power all of a sudden risking my life and others around me. Based on what I have researched it seems like a K1 Snap Ring issue to the T. Waiting on the "official" diagnosis from the dealer.
When pulling onto the interstate on ramp (45 mph) the truck attempted to shift up when all transmission power failed. The engine ran fine, just no power. I was able to safely pull to the shoulder and park. s Shifting from drive to neutral to park and back to drive still did not resolve the issue. I put the truck in park and shut off the engine. The transmission fluid temp, color and level was ok. I restarted the truck and shifted to reverse with no problem then to neutral and drive. It felt that the transmission engaged and I slowly crept forward. I slowly accelerated and was able to resume speed. No subsequent loss of power has been encountered, BUT the truck now has slippage from 1st to 2nd gear and occasionally 3rd. Had I been on the interstate this has a potential for serious accident incident. This is the first time this has happened. I had bought the truck used and certified from the dealer in Pennsylvania. There is currently 28k miles on the truck. There were and still no warning or codes to indicate a problem This occurred [XXX] 2024. No dealer, tech or shop has looked at this issue. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
This vehicle left me stranded due to Aisen transmission failure with only 2000 miles on the vehicle. Has been at dealer for 3 months awaiting rebuild due to faulty clip. Why is nothing being done" Why am I not getting a new transmission" or better yet forced buy back
Transmission went out. Lost 1-4th gear. It was the K1 snap ring in the transmission. Lost power going up a mountain in a National Park exhaust brake either to slow vehicle. Check engine light came
The dealer and manufacture have not been able to fix emissions issue. It has cause severe fuel saturation in oil and has cause severe motor damage. No one cares and they brush it off as no big deal.
K1 Clutch Snap Ring failure in the AS69RC Aisin transmission. I loss all forward motion on [XXX] in Iowa City. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
My trucks transmission experienced a complete failure, it is currently at the dealership awaiting parts and repair The failure renders the truck without any forward power almost immediately with only reverse left functioning, we were fortunate that it broke down in a residential neighborhood and not the freeway. The truck was towed to the local dealership, they tore down the transmission and confirmed a K1 snap ring failure and that it would be covered under wtty. I got a malfunction indicator light a few days prior then a message on the dash "4 wheel drive system temporarily unavailable" about 10 miles before complete failure. CSN 71A appears to have been issued and sent to some truck owners to advise snap ring replacement as a preventative measure, however my truck was not included in the CSN campaign, not sure why
1, The Aisin AS68RC transmission failed. The dealership had to ship the defective complete back to Aisin. 2. On [XXX] with only 2,886K miles while on Interstate [XXX] in Boston Massachusetts. I just entered the highway and was getting into the middle lane getting up to high way speed. The Tachometer shot up in rpm-??s and there was no more forward gear. I was doing about 50-60mph. I had to cost from the middle lane to the brake down lane with my 20-?? trailer in tow in heavy traffic. Once in the brake down lane I was able to go in reverse but couldn-??t go forward. Loud clunking when put into gear and trying to move forward. 3. The vehicle was towed to the dealership from [XXX] that night to Herb Chambers Millbury Ram and confirmed transmission failure. 4. Aisin sent a complete transmission assembly to the dealership for installation. So the dealership inspected it. 4. There were NO warning lights before transmission failure. I did notice the truck felt Rough over 40 mph before transmission failure since I picked it up brand new from the dealer. Absolutely NO warning light/ indicator prior to Transmission failure!!!! INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
I am very concerned that my trucks Aisin transmission may fail while towing heavy loads at highway speeds as this seems to be an issue with my model year and month it was built.
Concerned that my truck may be affected by the Aisin K1 snap ring failure problem currently being investigated by NHTSA. I have no way of knowing whether or not my transmission is reliable long term, nor can I prove to a future buyer that it is safe and reliable. Not only does this issue affect my trust in using the truck, but it also has a significant negative impact on the resale value of the truck. Buyers are aware that 2022 Aisin trucks have issues and this makes the vehicle harder to sell.
Driving south on [XXX] just south of Greenville, SC. With no warning the truck wouldn't go, upon quickly diagnosing I determined I had no transmission. Luckily was able to make it to the emergency lane and come to a safe stop. Also was pulling a fifth wheel camper at the time. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
February 19,2024. Towing a bumper pull toy hauler approximately 10,000 pounds, just merged onto a two lane highway when the check engine light came on and truck jerked a couple times, I pulled to side of highway where there is not much of a shoulder. I placed it in park, sat a few seconds then into drive when I noticed no forward motion in drive. I turned truck off a few minutes, restarted, check engine light still on, no movement in drive mode. I did have reverse functioning. This was very dangerous situation, high speed two lane highway, small shoulder, many large RVs and 18 wheeler trucks flying by. 5 weeks truck is at dealer, they say it-??s done, they attempt to bring it to me at the shop, then tell me check engine light on, throwing multiple codes. They still have truck, tell me they will find out issue asap.
Sudden loss of forward gears. Failure happened on highway at highway speeds. Had to carefully maneuver the truck off the road. Failure in both towing and unloaded operation. Truck will not shift in or out of drive (1-4) but reverse is still functional. Diagnostic trouble code P0731-00 and P0734 "Gear 1 and 4 Shift Incorrect Ratio". Both the dealer and RAM confirm this transmission failure. RAM has realeased a TSB which covers this failure but hasn-??t released a recall.
A D V E R T I S E M E N T S
- Paris, KY, USA