This data is from the NHTSA — the US gov't agency tasked with vehicle safety. Complaints are spread across multiple & redundant categories, & are not organized by problem.
So how do you find out what problems are occurring? For this NHTSA complaint data, the only way is to read through the comments below. Any duplicates or errors? It's not us.
Truck fails to properly accelerate when pulling out into traffic. There is a massive delay from pedal push to the truck moving. It is such a common issue there are devices that go between the pedal and computer to solve it. It voids the warranty though. I have almost been hit 4 times due the acceleration hesitation.
Brand new 2022 ram 3500 dually, 2300 miles 330 into towing trailer 18k trailer transmission blew. Loud clunk will only move in reverse. Left me and family stranded on side of busy freeway. No tow truck could handle truck and trailer.
K1 snap ring failure in the transmission. Lost gears 1-4. Truck was stuck in the middle of the road unable to move, blocking traffic and causing safety concerns. Vehicle is currently at the dealer awaiting replacement parts. There was no warning. The check engine light and service 4wd light came on as soon as the failure occurred.
Transmission failure at 2145miles while driving with check engine light truck inspected by ram dealer service and confirmed that it was the transmission that failed and they had multiple Vehicles with the same issue in the 2022 model
The contact owns a 2022 Ram 3500. The contact received notifications of NHTSA Campaign Numbers: 23V060000 (Electrical System) and 22V835000 (Power Train) however, the parts to do the recall repairs were not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was made aware of the issue and confirmed that parts were not yet available. The manufacturer was made aware of the issue and confirmed that parts were not yet available. The contact had not experienced a failure. Parts distribution disconnect.
- Priest River, ID, USA
Search CarComplaints.com for these popular complaint phrases...
At 2,702 miles on the odometer. Vehicle lost all forward gears while driving. No indication of problem before catastrophic transmission failure. Vehicle has been inspected by dealer and transmission failure has been confirmed. Dealer states failure is related to Ram TSB 21-002-23 SUBJECT: K1 Clutch Snap Ring Repair OVERVIEW: This bulletin involves replacing the K1 clutch drum snap ring and possibly the K1 input shaft drum sub-assembly. MODELS: 2022 - 2023 (DD) RAM 3500 Cab Chassis 2022 - 2023 (D2) RAM 3500 Pickup 2022 - 2023 (DP) RAM 4500/5500 Cab Chassis
I purchased this 2022 Ram 3500 mentioned above with 10 miles on it. I drove it 159 miles and the transmission went completely out and would not move. The dealership I took it to mentioned they had two other trucks there with the same problem that's been there for over a month... and didn't have any timeframe on when it could be fixed or a resolution for this problem. I'm hoping there's a lemon law I can address and will have to be on the hunt for a new truck once again, as it's part of my livelihood! is there anyway this should be a recall item or repaired by the dealer. Please advise on the best course of action I should take. Thank you
On 4/6/2023 at around 3:15 PM, our 2022 Ram 3500 HO 6.7 Cummins coupled with the Aisin AS69RC Transmission which failed at between 40 to 50 MPH while towing a 40' travel trailer. It was sudden when we heard two very loud clunks with jerking that coincided with each. Fortunately I was able to quickly pull onto a wide area of the shoulder from the center lane and not block or impact traffic. This could have had a high impact on traffic and the safety of others during this incident. We do not know how it could have impacted vehicle control. All forward gears were inoperative after the failure. We were stranded there for more than 3 hours waiting for two wreckers. One for the truck and one for the trailer. This was more than just an inconvenience and huge added expense that flowed into the following day when you realize what technology you rely on built into the truck. We use both vehicles for working remotely for long periods of time in a large 4 state area on the west coast. The longer this takes to remedy, impacts our ability to use the trailer. The biggest concern was the impact to our safety and to the public had we not been able to make it to the shoulder of the freeway. Truck has been inspected by a Ram Dealer. They have indicated that parts have been ordered. Ram Care has been contacted twice and a case good case number (85915865) has been created. We know of more than 160 other owners with the same story of the transmission failure with and without towing. Some have not made it home from the purchase of their vehicle. There is a group on Facebook that is capturing incidences of this with other Ram HO-6.7 Cummins-Aisin AS69RC transmission trucks. Dealer indicated they already have another vehicle on the lot (two weeks) with the same issue. There was zero warning. Failure was instantaneous.
Transmission failure while towing a travel trailer on a busy street on a slight incline. While traveling about 45 mph felt a jolt and truck lost power and would not accelerate. Felt like truck was in neutral. Truck would not engage Drive and was completely disabled in the number one lane. Tried to re engage the transmission and had success at engaging a higher gear with slow speed and high RPMs causing the engine and transmission to overheat and possibly start a fire. Safely moved across lanes to shoulder and stopped. The street is 55mph. Cars were slamming on their brakes to avoid colliding into my truck or trailer. This happened on March 30, 2023 and has been at the dealership for repairs since and has not been even inspected yet yet. No indicator or warning lamps prior to failure.
Bought 1/16/23, Failed 4/1/23 Transmission failed at 1,421mi. While towing a light trailer utilizing the tow/haul mode through the mountains of VA traffic. Stepped on the fuel pedal and an audible -??Clunk-?? was heard. Immediately after, we lost all forward momentum and we-??re able to slowly creep off the highway. Safety of all was put at risk as a dead vehicle was now blocking traffic on the highway. Check -??engine-?? lamp came on immediately after audible sound. Gears 1-4 were inoperable with only 5-6 and reverse functioning. After further review, a TSB was published and sent to dealerships 1/11/23 stating the potential issue of a faulty part within the transmission of 2022 Ram 3500 6.7L models.
The contact owns a 2022 Ram 3500. The contact stated that while driving at an undisclosed speed, the transmission inadvertently shifted to neutral, and the vehicle stalled. The vehicle was turned off and restarted; however, the contact stated he had to shift into 4WD for the vehicle to operate as needed. The check engine warning light was illuminated. The vehicle was taken to a local dealer, where it remained awaiting diagnostic tests and repair. The manufacturer was made aware of the failure and a case was opened. The approximate failure mileage was 28,000.
The contact owns a 2022 Ram 3500. The contact stated that while driving at an undisclosed speed, the accelerator pedal was depressed and the RPM became elevated; however, the vehicle failed to accelerate. The contact stated that the cruise control and tow haul mode failed to operate as needed. The vehicle was not diagnosed nor repaired by an independent mechanic or dealer. The manufacturer was not made aware of the failure. The failure mileage was approximately 9,000.
Transmission failed on road while driving and pulling up to a stop light. There were no warning lights prior to fault. RAM is currently looking for a transmission, but have said it could be several months. This is a wide spread problem with RAM 3500's with this transmission. It sounds like RAM has been trying to down play the problem and cover it up. Checking the RAM forums this if wife does with thousands of veggies waiting for me transmission. RAM continues to build new trucks, rather than divert transmissions from the factory to replace failed transmission that are in the dealer repair centers.
Sudden loss of all forward movement. Occurred without warning. I was towing a 40 foot camper on a very busy highway. This has been discussed on forums relating to vehicles with the AISIN transmission. The problem appears to be an internal component breakage in the transmission. The only message that appeared is the 4 wheel drive was inoperative. I was fortunate and was able to maneuver to the side of the highway.
I was pulling into a parking lot when my transmission failed and was only able to go in reverse. This was from a main road and the truck went from drivable to undriveable with no prior notice or issue. The truck was towed by Ram Roadside assistance to the nearest Ram dealer and the dealer confirmed that the transmission failed. They removed the transmission and diagnosed the issue as follows: The K1 clutch snap ring has failed. The part is on national backorder and your vehicle is #361 on the list of applicable trucks with a similar issue. There were no warning lamps, messages, or other symptoms prior to the transmission failure.
Transmission quit working without notice and left me stranded in the roadway with my children in the vehicle. The dealership will not replace with a new transmission because of problems with the new same transmission, instead requesting to rebuild with some updated parts. As far as I know the dealership is the only place to check the issue. Check engine light illuminated only once the transmission stopped working.
Transmission failed at stop light, No power to move forward for 1-2 minutes, when it moved it was jerky and erratic. Drove approximately 1 mile to RAM dealership for diagnostic and service. After it was parked it would no longer drive forward.
The K1 clutch snap ring failed causing a sudden loss of all forward motion while towing. Vehicle is currently at dealership service center. The loss of all forward motion caused a breakdown while towing, placing me and my family at risk while stranded and blocking road. With the vehicle (and towed fifth wheel) blocking the road, it also put other drivers at risk of crash. The problem has been reproduced and confirmed by dealer. The component has not been inspected to my knowledge. Several seconds before the losing forward motion I saw the MIL lamp come on along with message of "4 wheel drive not available". It also dropped me out of tow/haul mode, I believe.
K1 snap ring failure at 2,950 miles. Vehicle currently in dealer possession. Available for inspection. Safety risk as vehicle was towing during failure causing loss of forward gears, and potential loss of control of vehicle being towed. Especially hazardous to other unsuspecting motorists around vehicle when loss of forward gears happened traveling on highway. Dealer has completed diagnostic. States clutch and other components were destroyed at time of failure. Vehicle has not gone under any inspection other than dealer. No prior warnings, or symptoms to indicate such a failure was to occur.
The contact's son owns a 2022 Ram 3500. The contact stated while her son was driving at highway speeds, an abnormal noise started coming from the vehicle, and the vehicle lost motive power and stalled without warning. Due to the failure, the vehicle was towed to a dealer where it was diagnosed with transmission failure. The vehicle remained in the dealer's possession for two months before the repair was completed. Soon after the vehicle was returned, the failure recurred while driving at highway speeds. The vehicle was towed to an unknown dealer where it remained. The manufacturer was notified of the failure. The vehicle was not repaired. The failure mileage was approximately 5,000.
A D V E R T I S E M E N T S
- Livingston, TX, USA