I have a 2014 Kia Sorento with a 3.3l engine. There was a catastrophic blow of the head gasket that resulted in engine temperatures spiking while driving on the interstate. This led to excessive deceleration and stopping on the side of the interstate. After researching, this is an ongoing problem with this vehicle. It even has a nickname, "Soft Block", from KIA using substandard materials to build their engines. I submitted a complaint against Kia through the NHTSA website on November 10th. Since that time, I have come to realize that Kia has issued a warranty extension for 2016-2017 Kia Sorento's with the 3.3l Lambda engine for cooling leaking and head gasket issues. What would be the process for expanding your open investigation (NHTSA Action Number: PE23019) to include the 2014 and 2015 model years of the Kia Sorento with the 3.3l engine? This is the exact same engine, and these exact same issues are prevalent in these years as well.

- Amelia Court House, VA, USA

Engine seized again after the last recall and engine replacement leaving me stranded in an intersection and $416 in towing expenses transported to the mechanic and back home when told engine is seized

- Osterburg, PA, USA

Replaced engine 1/31/23 had open recall per 21v331was not repaired even though they wasn-??t suppose to return vehicle according to recall. They said It would be safe to drive.Said they had no remedy to fix they would call me. Few days car stalls alternator was hanging had to replace. They didn-??t replace properly. With in a month cars brakes were acting weird took in for diagnostic back brakes no remedy. Call Kia still no parts for recall. Sept 11,23 was pulling off expressway during 5 o'clock traffic my brakes locked up I had no control. Towed to Kia they wanted 75. to look at it then 2700. to fix the brakes. And stated I had no brake fluid. Which was just checked. They said recall did not cover the repairs Neither the engine recall nor the brake, hecu, abs, stability control recall. I contacted Kia they told me they would get back to me. As of Oct.31,23 they had not done any repairs or response from Kia. So I traded my car back to Kia so I would have a vehicle for school and work. I-??ve tried to get reimbursement from Kia. For rental car etc. And keep getting the run around. I have towing, rental, and repairs that they are refusing to reimburse me. I drove the recalled vehicle for 9 months and could have been killed myself, my daughter, as well as others. Kia could care less! I traded vehicle 10/31 the recall was cleared on my 2014 Sorento on 11/4 according to Nhtsa.gov 3 days they clear it so they could sell it. I m really disgusted with Kia. I-??m out thousands of dollars for their neglect. They couldn-??t repair the recall for longer than 9 months for me. But as soon as I trade it to them it-??s repaired or they are lying just so they can sell it. Just like when they sold it to me with 2 open recalls without telling me it had them. What do I need to do" Suggestions" I do have more receipts and documents

- Bayside , TX, USA

Engine fire, no warning, vehicle was parked outside and off when it caught fire

- Columbus, OH, USA

The contact owns a 2014 Kia Sorento. The contact stated while driving at approximately 25 MPH and making a turn, the engine seized. There were no warning lights illuminated. The vehicle was towed to the local dealer, where it was diagnosed that there was an internal engine failure, connecting rod damage, and that the engine needed to be replaced. The vehicle was not repaired. The manufacturer was contacted and opened a case, but no additional assistance was provided. The contact stated that the failure was related to NHTSA Campaign Number: 17V224000 (Engine and Engine Cooling). The failure mileage was approximately 75,000.

- Hagerstown, MD, USA

Engine continues to leak oil. Cannot be driven. 2014 Kia Sorento SUV which is under recall for engine fires yet they state her particular vin is not under the recall.

- Jackson, GA, USA

The engine on my 2014 Kia Sorento has failed. I brought the vehicle in to Bob Sight Kia to have them diagnose the problem. They claimed that when they drained the oil, they only found 3/4 of a quart of oil and for that reason, Kia was denying the claim for a new engine. I find it hard to believe that there was only 3/4 of a quart of oil in the car as we conducted regular maintenance on the vehicle and provided all service records. When I contacted Kia, they stated that they had not received any documentation from Bob Sight Kia, and specifically no technical details why the engine had failed, or provide an estimate for repair costs. In the last three weeks that our Sorento has been at Bob Sight Kia (brought to dealer on 9-9-23), when I call to speak with the service center point of contact, I get his voicemail or someone says he is away from his desk or on leave and nobody responds to my voicemails or emails, even though I have volunteered to provide more information if necessary. There is a Facebook page with 976 followers stating why Kia has denied their claims for replacement of failed defective engines. Fortunately, in my case, I was able to drive the car to the dealership before the engine stopped working but in many cases the engines failed while people were in busy traffic, exposing them to dangerous situations. In my case specifically the engine light started flashing and the vehicle was being very sluggish, struggled to make it up hills and would occasionally stall.

- Kansas City , MO, USA

Car was traveling from Atlanta and the speed odometer on the car showed it was dropping then knock noise pull over then I made to exit and check oil Guage the sensor lights never showed when I had picked up the person house I took to said it was crank sensor and started it heard knocking sound and I call NHTSA reported incident and was giving a claim number haven't heard anything since I no its recall on engine cause I had received paperwork that it was and also saw report on news

- Warner Robins, GA, USA

Engine was replaced in 2021 due to oil consumption issues. After copays and having a rental car for 2 months while waiting for repairs I shelled out about 7k. Now catalytic converter has failed, about one week after last oil change. Extended coverage is just over by mileage according to dealership and unsure if Kia will cover, awaiting response. After researching this issue with my vehicle, I found other owners who had the same issue and suggested it should have been replaced with engine as there was a past recall for this. Others stated that Kia is not covering even though there was a recall. Even if they covered the parts that would help substantially. Car currently at service center at Kia dealership awaiting to see if Kia will assist at good will or cover under the recall.

- Orlando, FL, USA

We bought the car 6 months ago from a dealership and since then the breaks are bad the engine makes this strange noise it always smells like oil is burning. The seat belts don't stay latch and I hr suspension is all over the place.

- Santa Paula , CA, USA

After work, a severe dust storm hit. I drove to the grocery store and then home (30 miles) in the dust storm. The next morning, as I was driving to work, I heard a weird knocking noise, but no engine lights came on. My car would not start during my lunch break, nor when I got off work. My boyfriend tried to jump it off. When that didn-??t work, we traded the battery out since it was still under warranty. That did not work. We went back the next day and checked my oil levels and other fluids - all were good. My boyfriend then hooked up his small code reader which didn-??t read any problems. The next day my mom started the car by putting the spare key up to the start button. She took it to Gene Messer Kia about 5 miles away. She said no engine lights came on, but the engine was knocking. Once she turned it off the mechanics were not able to start the car again. They looked over it and said they could not find any reason for my engine to have died. I asked them if it could have been the dust storm. They said no; the engine was well sealed, block was not cracked, oil levels were good, etc. They quoted me $11,521 for a new engine. However, I did not want to pay that because my car was only worth $5,500-7,000 (trade-in verse private sale) according to Kelly Blue Book. I called my insurance and had an inspector come look at it hoping he would be able to say the storm caused the issue and total my car so I could pay off my loan. However, they also could not find a cause for what happened to my engine. We sold it to Peddle.com.

- Abernathy, TX, USA

Car recently hit 103,000 miles and was taken in for its scheduled oil change. Mechanic discovered that only a single quart of oil was left in the engine during the oil change despite regular maintenance. Metal flakes were found in the oil that was removed which points to a similar recall with the engine bearings identified in 2017. However, the VIN of this vehicle is not showing up in the recall list. Mechanic is recommending the engine be replaced in the vehicle.

- Delaware City, DE, USA

In May of 2021 my 2014 Kia Sorrento had major engine problems. I brought it to Myrtle Beach Kia immediately and after 5 months of back and forth and paying for rental vehicles, I was told that they would not cover any repairs due to the Recall! I then paid $8, $663.63 for a repair that was never fully completed. Immediately after receiving vehicle back, check engine light was on. Numerous call to the dealership and I was told dont worry it just needs to cycle through. My vehicle has NEVER been properly serviced by them. I have kept up will all oil changes and maintenance in the meantime. I was told the check engine light codes were PO335 & PO 0018. I have had the Camshaft Bank Sensor and Crankshaft sensor replaced on [XXX] and this vehicle STILL has same check engine light on and is not receiving proper power while driving. I looked up recalls and found that currently recall 21 V331000 is in effect, this recall is a major safety issue especially being that I have 3 children that I drive around in and there may be a fire! I called Myrtle Beach Kia and the earliest they can get me in to service is a month from now, on [XXX]!! I feel that especially after everything I have been put through with this vehicle and the amount of money I have put out, that a loaner car would be offered to me to drive while waiting for them to fix the safety recall. Please contact me at [XXX] or [XXX] and please contact kia to allow a loaner vehicle to be used while waiting almost 1 month for the service. Thank You in advance for hopefully your concern and remedy to this. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

- Georgetown , SC, USA

The contact owns a 2014 Kia Sorento. The contact stated that after an oil change and driving approximately 1,200 miles, there was no oil in the engine. The contact stated that there was no visible oil leak. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The manufacturer was not made aware of the failure. The failure mileage was approximately 153,000.

- Jarrell, TX, USA

iT APPEARS MY CAR IS BURNING OIL, THERE IS NO LEAKAGE. I KEEP OIL CHANGES ON A REGULAR BASIS AND NOW CHECKING OIL LEVELS DAILY. IT IS USING 1-1.5 QTS EVERY 2 WEEKS. THIS PROBLEM WAS FOUND WITH LAST OIL CHANGE. MY CAR NOW SEEMS TO SEIZE WHEN TAKING OFF INCONSISTENTLY. I DON'T KNOW IF TWO PROBLEMS ARE CONNECTED. THERE ARE NO WARNING LIGHTS COMING ON. I CONTACTED CARTOWN KIA ABOUT 3 TIMES BY PHONE, LEAVING MESSAGES, AND ONLINE BUT NO RESPONSE.

- Lexington, KY, USA

The contact owns a 2014 Kia Sorento. The contact stated while driving 50 MPH, the vehicle lost motive power, stalled, and shut off. There was no warning light illuminated. The contact was able to safely pull over on the side of roadway. The contact was able to restart the vehicle; however, the vehicle restarted rough, but then started operating normally. The vehicle was taken to the dealer for diagnosis, but no cause for the failure was found. The manufacturer was not contacted. The failure mileage was 41,000. The contact went to the dealer who was going to charge 1hr out of 3hrs, if they found anything wrong with the vehicle. They didn't find anything and released the vehicle to the contact stating they would not take off immobilizer, now and go do what u have to do. The contact stated because of this the vehicle was traded in.

- Jenkintown, PA, USA

My son was driving the vehicle and was luckily stopped in traffic at a stop light. All of a sudden the RPM's dropped and the engine shut off. The car would not start and had to be pushed to the side of the road in heavy traffic. While waiting for a tow truck, we noticed the engine oil was completely dry. There had been no warning such as oil lights, engine lights, burning oil smells or leaking oil. The oil had just disappeared without warning. After the vehicle was towed to the local KIA dealer, we were told that the engine had seized. This vehicle has been maintained consistently since the day it was bought brand new. We have records from all maintenance that has been done on this vehicle. The local dealer told us it would cost $11,000 to replace the engine. Unfortunately, that was an expense that we could not afford so the car sits in non working order.

- Idaho Falls, ID, USA

Engine seized. No check engine lights on. Was driving and it made an awful noise and that was it. We have not drove it since. Took it to our local auto mechanic he refused to touch it. Told us it needed a new engine. We are an hour and half a way from a kia dealership. We can't afford to have ot towed that far. I am making payments on a car that i can not drive. I have called kia many times to see what to do. They said to have it towed to a dealership. We live on a limited income. I keep checking to see if my car is on the recall list it is not but should be. It has done what all the other engines that have been recalled have done.

- Frazee, MN, USA

Kia Corporate Complaint No. [XXX] We bought a used but Kia certified 2014 Kia Sorento with 29K mileage in Jul 2017. Ran great but check engine light came on 3 times. Well before 100K mileage, we took it to dealer service department and we-??re advised it was an -??electrical problem-?? that reported a false code. Each time the check engine light was reset. Car ran great except for the false trouble lights. We were told that if the light did not blink, not really a problem. At 120K mileage, we got a code and took car to local garage. Mechanic changed 6 plugs but advised that No. 6 coil may need to be replaced. At 122K miles, 3 weeks ago, we got a solid check engine light but with a serious female voice and pop up screen advising we get to Kia dealer. This time code was run by our local mechanic for clogged catalytic converter. We drove to Kia dealer and they ran code for fouled fuel injector for cost of $1,000. We left car parked at dealer and called Kia USA Corporate in CA. We got a complaint number with assurance Kia would contact us. Nothing in 3 weeks. Local dealer says no recalls of V6 engine but we see reports on line of a known fire problem. We fear driving car should the catalytic converter catch fire. Help! [XXX] INFORMATION Redacted PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).

- Louisa, VA, USA

Engine control module when it fails vehicle will lose power and drops engine compression causing a danger to other traffic. I was on I-10 on Sunday morning at 60 mi. when all of a sudden it slowed down to 20mi causing other drivers too maneuver around me to avoid from colliding into my SUV. Had engine control module checked out and was advised me to take in to dealer to have it reprogramed or replaced. Either will be an expense I just cant afford replacing it would cost me over $2000 and reprograming any where from 200 to 500. If Im not wrong a recall for software added to engine control module was done around 2020 didnt that up.

- El Paso, TX, USA