The contact owns a 2016 Hyundai Veloster. The contact stated while driving 40 MPH, the engine started knocking. The contact stated that several days later the knocking sound became louder, and the vehicle became inoperable. The vehicle was towed back to the residence. No warning light was illuminated. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The manufacturer was made aware of the failure and confirmed that the vehicle was not included in a recall. The failure mileage was approximately 109,852.

- Saint George, UT, USA

My vehicle started making knocking noise in front end. Took it to my mechanic and he told me to take to dealership and see if there is a recall for my car. I've done so much research on vehicle for recall and it says that its the rod knocking which should be covered as the recall I found but Hyundai is giving me problems with it. Vehicle is a 2016 Hyundai Veloster Turbo

- St. George, UT, USA

The engine is stalling. Check engine light is flashing. Car is in limp mode. Dealership say it not a matter of it but when the engine blows up. Have seen where some of these cars blow up and catch on fire. Hyundai want help me or thousands of other people with this problem

- Sanford, NC, USA

When my car 2016 Hyundai Veloster reached almost 95000 mileage the oil starts to dissipate much faster so started to do oil change much often. Recently and my care already at 97000 mileage. We are driving going up a hill and it started to make some noise kind of like a motorcycle noise and I know there is something wrong but no light warnings or anything. I was trying to push it to get to a safer side of the road because I have my 86 year old mother with me but the car did nor make it and heard something snap really loud and the car just stopped and saw a little bit of smoke. Had to stop immediately on the side of the road and it was a bad spot against the rail and that blocked the 2 doors on the right side. the car only have 3 doors so now my mother is stuck and had to figure out how to have her crawl out to get out the driver side of the vehicle. If the car was on fire that would have been really dangerous. Took it to the mechanic and my insurance inspector already saw the car and determined that there was some kind of rod that came off and that the engine is blown an that it is with a hole. it is beyond repair or if I do it will cost $5000-$6000. I bought it on 2018 with only 5000 miles on it. I kept up with yearly maintenance. I think it is insane that it will break that fast and we are traumatize with the danger. I am not ready financially for this.

- La Mesa, CA, USA

Engine is consuming oil. Catalytic converter becomes restricted, and motor will stop running while driving. After restart motor will not have enough performance to exit traffic. Catalytic converter was replaced and now problem is recurring.

- Cave Creek, AZ, USA

Car started making a loud rattling sound. Took car to get diagnosed, issue was with the connecting rod bearings inside the engine. Asked about current NHSTA campaign id # 20V746000 but was denied because my engine is not part of the recall. My car recently had a maintenance check up at the dealer and was marked as fine, no issues. Engine light blinked once for about two seconds, no other warnings. I am very upset as this could have lead to serious issues and now I have to pay out of pocket to replace entire engine. Open campaign recall is for 2015-2016 Hyundai Veloster, my car is a 2016 Hyundai Veloster. Why is my engine not covered in recall?

- West Covina , CA, USA

The contact owns a 2016 Hyundai Veloster. The contact stated that while his son was driving at an undisclosed speed, the vehicle lost motive power with the oil pressure warning light illuminated. The vehicle was taken to an independent mechanic, who inspected the engine oil and noticed there were metal shavings inside the engine oil. The vehicle was later towed to the dealer, where it was diagnosed that there were metal shavings inside the engine and that the engine needed to be replaced. The vehicle was not repaired. The manufacturer was not made aware of the failure. The contact related the failure to NHTSA Campaign Number: 20V746000 (Engine); however, the VIN was not included in the recall. The failure mileage was approximately 48,000.

- Port Richey, FL, USA

The contact owns a 2016 Hyundai Veloster. The contact stated while starting the vehicle, the check engine warning light illuminated. The vehicle was taken to the dealer and the catalytic converter was replaced. On another occasion while driving 40 MPH, the vehicle lost motive power. The contact was able to pull over on the side of the road and shifted into neutral and was able to restart the vehicle and the vehicle operated normally. The vehicle was not diagnosed. The manufacturer was not contacted. The failure mileage was 147,400.

- Wilmington, DE, USA

The contact owns a 2016 Hyundai Veloster. The contact stated that the vehicle was taken to the local dealer for trade-in and the contact was informed that the dipstick was burned and that the engine was defective. The vehicle was repaired. The manufacturer had been informed of the failure. The failure mileage was approximately 73,400.

- Blanchester, OH, USA

Driving on highway at night coming around curve my car was still on which electrical was okay but my car started gliding like it was in neutral and could not accelerate. My car engine cuts off on highway. I'm luckily, a lot of cars were not on the highway at the time, letting me use my steering wheel to mauver to side of the highway. I tried turning the car off and turning back on would not crack but lights would come on. I had to get a car towed to my house. Appointments book until first week of May so been without a car sense April 11th. I was made aware of the 2016 Hyundai Recall on premature connecting bearing rods vehicle that could lead to crashes because Veloster's are shutting down on the highway like mines did. I'm sending my car to dealership on May 2, 2023, to Thorton Rd Hyundai dealership to perform the steps the dealership recommended me to do to see if my car qualifies to get extended warranty to fix my engine. All complaints read on 2016 HYUNDAI VELOSTER 3C FWD | NHTSA reads to me that my car was underling and part of the effect it's just that I'm more fortune than others that my engine lasted longer due to the care that I gave to my car. I had no warning lights of this incident was near future going to happen to me. All warning lights presented itself when car shut down on highway while costing over to, emergency lane. I love my little bug and want my car to be fixed so we can joy ride again.

- Atl, GA, USA

I got an inspection on my car and was told to take it to dealership due to a recall The engine would sometimes stall while I was driving The last time I used it, it no longer turned on at all But a check engine light never turned on or anything of the sort The car hasn-??t been inspected by anyone

- Dallas, TX, USA

The contact owns a 2016 Hyundai Veloster. The contact stated while driving at various speeds, the engine made knocking sounds, with a burning odor coming from the vehicle and the vehicle then stalled. The failure occurred intermittently and while idling. The check engine warning light was illuminated. The vehicle became inoperable. The contact had spoken to the dealer who confirmed that the vehicle was not included in NHTSA Campaign Number: 20V7460000 (Engine) despite exhibiting the same failure. The vehicle had not been diagnosed or repaired. The manufacturer was made aware of the failure. The approximate failure mileage was 120,000.

- Port Deposit, MD, USA

Late Spring 2021-?"notified of recall due to connecting rod/bearing issue. Hyundai dealer does engine inspection on 4/27/2021 & clears it. Also installed software update to monitor the problem. April 27, 2022-?"Car dies multiple times while driving on highway. Starts back up each time, but making clacking noise with Check engine & oil light on. Pulled over and had towed to mechanic. Couldn-??t get diagnostic code, but told based on the incident, believe the issue related to recall & told to take it to dealer. Had car towed to Hyundai. Ran simple diagnostic. Got no codes. Manager drives & says some hesitation not unusual with Veloster. Did not stall. Recommends fuel additive. Early May 2022-Check engine light comes on & stays. Check at Autozone, Firestone, & dealer-?" told only catalytic converter code & car is drivable. Oil light starts flickering intermittently about every two weeks. Start scheduling earlier oil changes. Continues to flicker. Start adding oil between changes. August/September 2022?-?"Receive Hyundai letter stating warranty extended on my engine due to connecting rod recall. Warranty now 15 years/150,000 miles. December 20, 2022-?"Check engine light starts flashing. December 27, 2022-?"Dealer says can-??t look at for 4 months, take to Firestone. Tech gets code 1326-returns no info in system but research & believe related to recall requiring Dealer fix. Connect with Dealer service & am able to get it looked at in a week. January 9, 2023-?"tech says excessive oil burnt at top of pistons & oil leaking into cylinders, due to internal seal failure. Recommend replacing engine, but not related to recall. Research finds recall due to faulty piston seals/oil leaks on 2019-2021 Velosters & plenty of complaints about oil seal problems & excessive oil burning problems with earlier Velosters as well. Car unsafe to drive on highway due to lagging acceleration & hesitation. 2/3/2023-?"call Hyundai America about safety concerns. 2/7/2023-?"Hyundai denies claim.

- Savannah, GA, USA

The engine overheated with no lights on the dash and the engine block cracked

- Georgetown , IN, USA

While driving down the highway the engine began to knock loudly. When the engine stalled. The vehicle stalled while traveling on a congested highway at a speed of approximately 70MPH. The vehicle was pulled to the side of the road where I waited for a tow truck via AAA for 5 Hours. The vehicle was towed to an independent service center that diagnosed it with a worn rod bearing, which in turn is causing the knocking. The vehicle has been maintained and oil changed regularly. Vehicle is unusable in current state as it is at risk for complete engine failure and risk of fire. No warning lamps or messages were present at time of incident. Vehicle is available for inspection upon request.

- Tavares , FL, USA

The contact owns a 2016 Hyundai Veloster. The contact stated while driving 70 MPH, the vehicle began to stall. The contact stated no warning light was illuminated. The contact was able to park on the side of the road. The vehicle was not drivable. The contact towed the vehicle to her residence. The contact towed the vehicle to the local dealer, where it was diagnosed and determined that the catalytic converter needed to be replaced; and the vehicle was repaired under NHTSA Campaign Number: 20V746000 (Engine). The dealer replaced the catalytic converter but then informed the contact that the VIN was not included in NHTSA Campaign Number: 20V746000 (Engine). The vehicle was not serviced under the recall. The manufacturer had been informed of the failure. The failure mileage was approximately 81,000.

- Poteet, TX, USA

I was driving my 2016 Hyundai Veloster Turbo when I started to hear a loud knocking sound coming from the engine. At this time I also noticed a decline in power and the check engine light came on. I made an appointment to bring the car to my local Hyundai dealership to have the car looked at. While en route to the dealership, the car suddenly made a loud bang and a profusion of smoke came out of the engine and engulfed the car, inside & out, making it impossible for not only me to see but also limited visibility for the person following me, which was extremely dangerous. I couldn't see or breathe and had to rapidly exit the car on the side of a busy road with no shoulder. The engine completely failed and the car was not drivable. I had the car towed to the Hyundai dealership where they told me the engine had seized and needed to be completely replaced. Although my VIN is not yet included in engine recall 20V746000, my car has the 1.6 liter GDI Gamma engine included in that recall. In addition, the exact chain of events that I experienced have been described by others whose cars are included in the recall which describes connecting rod bearings inside the engine wearing prematurely (creating a knocking sound and reduced engine power), causing engine damage. I am requesting an investigation into this incident as I feel that my car should be included in the recall. It was a very dangerous incident and I don't want others to needlessly experience this same problem, possibly with more harmful consequences.

- Larkspur, CO, USA

The contact owns a 2016 Hyundai Veloster. The contact stated that an abnormal rumbling noise was coming from the vehicle at start-up. The check engine warning light was illuminated. The contact then received notification of NHTSA Campaign Number: 20V746000 (Engine). The vehicle was taken to a dealer where a software update was performed; however, the failure persisted. The vehicle was then taken to an independent mechanic who diagnosed the vehicle with engine failure. The vehicle was also taken to AutoNation Hyundai Hilton Head (255 Drivers Way Suite B, Hardeeville, SC 29927) where a temporary repair was performed; however, the failure recurred. The manufacturer was not notified of the failure. The vehicle was not repaired. The failure mileage was approximately 109,000.

- Savannah, GA, USA

The contact owns a 2016 Hyundai Veloster. The contact stated that while driving 70 MPH, the engine misfired and the vehicle stalled. The check engine warning light illuminated. The vehicle was towed to the dealer where it was diagnosed that the engine failed and needed to be replaced. The vehicle was not repaired. The contact referenced NHTSA Campaign Number: 20V746000 (Engine). The manufacturer was notified of the failure and the contact was provided a case number. The failure mileage was approximately 98,000.

- Carrollton, TX, USA

Oil pressure light began coming on around 7/1/2022. By 7/5/2022 car would accelerate past 40mph unless put into manual drive. Dealership pulled camshaft codes but said they couldn't find the code in manual for car. Now estimated $800 for repairs with airbag light also

- Strasburg, CO, USA