This data is from the NHTSA — the US gov't agency tasked with vehicle safety. Complaints are spread across multiple & redundant categories, & are not organized by problem.
So how do you find out what problems are occurring? For this NHTSA complaint data, the only way is to read through the comments below. Any duplicates or errors? It's not us.
There has been many reports of electronic steering issue where it would just swerve you off the road and loose full control while driving for years 2013-2015 cars but 2016 years are also being effected. A dealership confirmed it was an electronic steering rack causing the issue. No warning lamps had went off either
The contact owns a 2016 Ford Explorer. The contact stated while driving approximately 45 MPH, the steering wheel became very firm. The contact stated that the "Steering Assist Failure" message was displayed, and the Traction Control Warning light was illuminated. The vehicle was taken to the residence. The vehicle was not diagnosed or repaired. The manufacturer was notified of the failure. The failure mileage was 108,000.
Our 2016 Ford Explorer suddenly the steering started making a loud grinding noise while rotating the steering wheel. The noise is anytime you move the steering wheel left or right parked or moving. The steering wheel locks up without warning while driving making it momentarily impossible to move and dangerous while driving. The explorer was diagnosed as a faulty steering rack and pinion assembly with is electronic assisted. No warning lights are illuminated on the dash.
The contact owns a 2016 Ford Explorer. The contact stated that while driving at undisclosed speeds, the steering wheel was making an abnormal grinding sound. The ABS, air bags, and check engine warning lights were illuminated. The contact called the local dealer and was informed that the parts were not available to repair the vehicle. The vehicle was not diagnosed or repaired. The manufacturer was contacted, but no assistance was provided. The approximate failure mileage was 14,000.
Grinding banging noise when turning steering wheel driving and parked. Milage had just reached 100,000. Contacted Ford for inspection was told my steering gear needed replaced, car not drivable. Cost almost $3000 to repair. At the time there was already a recall on my model for this issue but my VIN didn't match and they would not repair it cost free.
- Modesto, CA, USA
Search CarComplaints.com for these popular complaint phrases...
The rack and pinion steering has gone bad. This is causing the vehicle to be hard to drive as it is very difficult to turn the wheel and control the vehicle. This is making it dangerous to drive as you are unable to turn the wheel very well.
My steering wheel completely locked up and we couldn't turn it or anything. After repetitively trying to move it the steering wheel finally came loose. I was able to take it to a mechanic and he said its the steering rack but since it completely locked up and was unable to move the steering wheel I needed to contact you. Ford does have a recall for the steering rack but it does not include my year of Explorer.
went to drive my vehicle and when i turned exiting my driveway, my steering was stiff, hard to turn. shutting off vehicle and restarting sometimes helps, but now it is always no power assist. No warning lights, messages or check engine lights at all. just lost power assist. I figure it is another rack n pinion steering assy by all i read online. This should deffinately be a recall. 2011-2013 had the same issue and was issued a recall. Why is this not? it is so dangerous. Get on the ball and do something. 2016 explorer xlt
The contact owns a 2016 Ford Explorer. The contact stated while driving 40 MPH, the vehicle lost power steering functionality. The service stability track, traction control, and the loss of power steering warning lights were illuminated. The contact stated that he used physical strength to steer the vehicle after the power steering assist failure to the residence. The vehicle was taken to a local mechanic who diagnosed that the angle sensor was defective and there was a loss of communication. The contact was informed that due to the failure and the loss of communication, the power steering assist, hill assist, and traction control features were disabled. The vehicle was not repaired due to a needed part being on backorder since November 2023. The manufacturer was notified of the failure and a complaint was filed. The failure mileage was approximately 69,000.
I am writing to you as I just read an article about my Explorer being recalled for a different issue, pieces of trim flying off (which happened to us several years ago). I took to the dealership then, they replaced and it immediately cracked again. They were blaming my door as being off and causing the damage. I took to a repair shop (non-Ford) to look at and they told me that they had seen this alot and Ford knew there was a problem and it wasn't my door. It made me extremely upset as it almost caused an accident while we were on the freeway. This complaint is for a completely different safety issue and is recent. I am mentioning the above incident as my car this time was taken to a different repair shop. Their response was very similar to the above repair shop that Ford knows there is a problem as the part is on a national backorder. After a recent snowstorm, my husband went to drive his car to work. The storm had passed, but roads were still dangerous. As he was pulling out of the garage, multiple alarms showed up on the dashboard. "Hill Start Assist Not Available", Service AdvanceTrac, "Steering Assist Fault Service Required". He didn't fully know what any of these meant and had just driven the car the day before with no issues. As soon as he pulled out on the roads, he realized the power steering was out. He is lucky that he didn't crash as the roads were still icy and snow covered. Up until these alarms, there was NO warning. What if it happened while in the middle of driving? I drive that car every day w my kids and my husband took it that Sunday as it is better in snow. I can't even imagine what would have happened if I was driving as there is NO WAY I could have steered that car. Somehow we got the last replacement part (repair was over $3000!) and I only have 68,000 miles on my car. How can a part that is on an older Ford be on national backorder if there isn't a major problem! The rack and pinion w computer module was replaced.
Complete failure of steering rack, causing the car to be completely undriveable. Poses a massive safety risk which could have resulted in injury or death had it occured at the wrong time or place.
Grinding/knocking noise when driving and turning front wheel either right or left. Was told need new steering gear. Only 115K miles on car. NUMEROUS complaints online from other 2016 Ford Explorer owners with SAME issue. This is a safety issue as the car is not safe to drive, yet this is my only means of transportation. No warning lights. Verified problem with Ford dealership - but part is NOT available. Now what?! THIS SHOULD BE A RECALL FROM FORD.
The electronic steering went out while driving making stearing very difficult and dangerous. I found out this is an issue that many ha e had and they have not recalled this dangerous part.
The contact owns a 2016 Ford Explorer. The contact stated while driving approximately 45 MPH and turning to the right following a bend in the highway, the contact attempted to turn the steering wheel back to center and the steering wheel became difficult to turn. The contact stated no warning light was illuminated. The contact pulled over and turned off and restarted the vehicle and the steering functionality returned. The contact stated that the steering assist failed again, and the vehicle was parked at the residence. The contact had not taken the vehicle to a local dealer or independent mechanic. The vehicle was diagnosed but was not repaired. The manufacturer was informed of the failure. The failure mileage was approximately 184,000.
2016 Ford Explorer at 81,000 miles the steering rack is considered bad. Prior to getting this checked by the dealer there were major steering issues with the vehicle that suddenly would not work. My wife and daughter were in the car at the time of the incident and had to pull over to avoid major collison. The steering went to manual. No error codes or error message prior to this. Just happened out of no where. The ford dealership determined it's was the steering rack that nees to be replaced. Confirmed by dealer.
I [XXX] went with my mom [XXX] to buy a vehicle off of [XXX]. It was a 2016 ford explorer. I payed 13,000. The began to lose control when driving on a bumpy road and while braking I took the car to a Ford dealer and had some repairs, but they didn-??t find the problem. I used the car sparingly and within two weeks it got much worse. Very unsafe to drive I brought it to another Ford dealership and I paid for substantial repairs for the suspension. The first time I drove it on a bumpy the car lost control again. I managed to regain control and drive it to the side of the road and had someone pick up the car. I went to trade the car in and learned the vehicle had been in two accidents and was reported as a total loss. Per the Carfax report. We were never told it was a salvaged vehicle or we would never purchased it for our family vehicle. The vehicle is too unsafe to put back on the road. I bought a 2017 Ford Explorer at a dealership and traded in the 2016 Ford Explorer at a significant loss. The vehicle was in my possession for approx. two months where it spent most of the time in different Ford repaid shops INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
The steering rack failed while operating the vehicle at approximately 40 mph resulting in a near total loss of steering. It required extreme force to turn the steering wheel to avoid oncoming traffic on a bend in the road before finally moving out of the roadway. The warning message displayed at the time of the fault was "Steering Assist Fault Service Required." The component had to be replaced when it was evaluated by the Ford dealer
The contact owns a 2016 Ford Explorer. The contact stated that while the vehicle was pulled over on the side of the road, the steering wheel became firm. The power steering assist warning light was illuminated. The vehicle was towed to a dealer to be diagnosed. The contact was informed that the electronic steering unit was faulty and needed to be replaced. The vehicle had not been repaired. The manufacturer was made aware of the failure and determined that the vehicle was not under warranty. The failure mileage 30,476.
The vehicle starting making a clunking noise while doing turns. While making a right hand turn, the steering wheel stuck and I had to yank it back (left) which caused a loud popping noise. Took it straight to the auto shop and next day was notified it was the steering rack and pinion.
Tires damaged due to a rear toe link not having proper alignment adjustments. I was told to buy aftermarket products because the two ASE certified shops could not align my rear suspension. I've chewed through two pairs of brand new tires in less than 4 months.
A D V E R T I S E M E N T S
- Grand Forks, MN, USA