Technical Service Bulletins (TSBs) for the 2015 200 are official communications between Chrysler & their dealerships that describe processes for troubleshooting or fixing certain common problems.
All vehicle manufacturers are required by U.S. law to make their TSBs available to the public.
Steering System Inspection After a Collision This bulletin documents the FCA US LLC position regarding conditions under which replacement or repair of steering system components are required. Read More »
Flash: Powertrain Diagnostic and System Improvements This bulletin involves reprogramming the Powertrain Control Module (PCM) with the latest available software. Read More »
LIFTER, Hydraulic Roller Deactivating Please do not replace MDS lifters because the disconnecting pin is not lined up, this is normal and not a defect. Read More »
Air Suspension Components Star Parts Catalog has been updated to show individual service parts for the compressor assembly. This will allow service technicians to repair the root cause without over repairing the system. Read More »
Rear trailing arm/link. Customer noise issue due to loose trailing link If a trailing link is damaged or noisy, please call Steve Lin at Cell 909-569-5117 prior to removing the part. Read More »
Rear trailing arm/link. Customer noise issue due to loose trailing link If a trailing link is damaged or noisy, please call Steve Lin at Cell 909-569-5117 prior to removing the part. Read More »
2.4L Excessive Oil Consumption XB1 Warranty Extension The customer may describe one or more of the following: Oil pressure low indicator lamp illumination between oil changes. Excessive oil consumption. Read More »
Flash: 2.4L Powertrain Diagnostic and System Improvements This bulletin involves reprogramming the Powertrain Control Module (PCM) with the latest available software. Read More »
Rear Brake Squeal Noise In Reverse This bulletin involves replacing the rear brake pads. The customer may describe a squeal noise from the rear brakes. Noise is only present during the first few brake applies in reverse. Read More »
Flash: 2.4L Powertrain Diagnostic and System Improvements This bulletin involves reprogramming the Powertrain Control Module (PCM) with the latest available software. Read More »
Flash: 2.4L Powertrain Diagnostic and System Improvements This bulletin involves reprogramming the Powertrain Control Module (PCM) with the latest available software. Read More »
Flash: 2.4L Powertrain Diagnostic and System Improvements This bulletin involves reprogramming the Powertrain Control Module (PCM) with the latest available software. Read More »
Flash: 2.4L Powertrain Diagnostic and System Improvements This bulletin involves reprogramming the Powertrain Control Module (PCM) with the latest available software. Read More »
Front Brake Moan Noise While Stopping In Reverse. This bulletin involves replacing the front rotors and brake caliper adaptor bolts to correct a brake moan condition. Read More »
Rear Brake Squeal Noise In Reverse This bulletin involves replacing the rear brake pads. The customer may describe a squeal noise from the rear brakes. Noise is only present during the first few brake applies in reverse. Read More »
SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP
FLASH: ABS Module Enhancements This bulletin involves updating the ABS Module software. New software is available to optimize Advanced Brake Assist (ABA) performance in low tractions situations. Read More »
SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP:ABS WARNING LIGHT
Rear Brake Squeal Noise In Reverse This bulletin involves replacing the rear brake pads. The customer may describe a squeal noise from the rear brakes. Noise is only present during the first few brake applies in reverse. Read More »
FLASH: ABS Module Enhancements This bulletin involves updating the ABS Module software. New software is available to optimize Advanced Brake Assist (ABA) performance in low tractions situations. Read More »
Rear trailing arm/link. Customer noise issue due to loose trailing link If a trailing link is damaged or noisy, please call Steve Lin at Cell 909-569-5117 prior to removing the part. Read More »
Flash: Electronic Parking Brake Module Enhancement This bulletin involves updating the Electronic Parking Brake (EPB) module software. The customer may describe the EPB does not engage with the ?Auto Apply? feature selected. Read More »
Flash: Electronic Parking Brake Module Enhancement This bulletin involves updating the Electronic Parking Brake (EPB) module software. The customer may describe the EPB does not engage with the ?Auto Apply? feature selected. Read More »
CONDENSER, Air Conditioning If it is determined that the A/C compressor does not engage due to a refrigerant leak at the receiver/drier plug on the A/C condenser, order the receiver/drier plug kit P/N 68447796A$ and follow the repair ... Read More »
Flash: 2.4L Powertrain Diagnostic and System Improvements This bulletin involves reprogramming the Powertrain Control Module (PCM) with the latest available software. Read More »
Flash: Extended Engine Crank Time And Transmission Quick Learn Enable This bulletin involves selectively erasing and reprogramming the Powertrain Control Module (PCM) with new software. Read More »
Part Description: Engine Cover Issue Description: The Chrysler 200 LX (Model UFCE41) is the only model in the 200 Family built without an engine cover. Please do not order this part as a shortage and error on this model. Read More »
ADAPTER, Engine Oil Filter (Pentastar V6) For all 2014MY replace the Oil Filter Adapter (OFA). For any other MY review and follow instructions from the latest STAR Online S1809000007 available on Dealer Connect. Read More »
ADAPTER, Engine Oil Filter (Pentastar V6) For all 2014MY replace the Oil Filter Adapter (OFA). For any other MY review and follow instructions from the latest STAR Online S1809000007 available on Dealer Connect. Read More »
ADAPTER, Engine Oil Filter (Pentastar V6) For all 2014MY replace the Oil Filter Adapter (OFA). For any other MY (with mileage above 30,000) review and follow instructions from STAR Online S1809000007 REV. C available on Dealer Connect. Read More »
If a Mopar oil filter is not available, use a filter that meets or exceeds USCAR36 specification and is compatible with semi and full synthetic oils. Read More »
Issue involves overheating, running hot, coolant leaks and related symptoms after a Mopar replacement engine has been installed in the vehicle. Read More »
Issue involves overheating, running hot, coolant leaks and related symptoms after a Mopar replacement engine has been installed in the vehicle. Read More »
ADAPTER, Engine Oil Filter (Pentastar V6) All vehicles equipped with a 3.2L or 3.6L except for model year 2014 vehicles with leak concern: 1) Ensure the Oil Filter Adapter (OFA) Cap O-ring is seated in the proper groove in the cap and ... Read More »
CONDENSER, Air Conditioning If it is determined that the A/C compressor does not engage due to a refrigerant leak at the receiver/drier plug on the A/C condenser, order the receiver/drier plug kit P/N 68447796A$ and follow the repair ... Read More »
3.2L - 3.6L Cylinder Head Assy Multiple cylinder head replacement. If a cylinder head is replaced on a vehicle more than 1 time for any reason, please call any of the following people. First: Joe Lovell - Cell (734) 309-6467 joe. Read More »
Cover Kit Please note that if you are attempting to get the cover kit and it is not available the gasket is available as a separate part number in the kit which is 04753095AB. Read More »
Flash: Powertrain Diagnostic and System Improvements This bulletin involves reprogramming the Powertrain Control Module (PCM) with the latest available software. Read More »
Flash: Powertrain Diagnostic and System Improvements This bulletin involves reprogramming the Powertrain Control Module (PCM) with the latest available software. Read More »
Oil Pump Assembly If error code P06DD present on any Pentastar V6 application, please inspect oil pump for relief valve failure. See photo attached. If valve is found out of place please call Bob Jackson (248) 944-0466 bob. Read More »
Replace Purge Control Valve Hose This bulletin involves replacing the purge control valve hose assembly. The customer may describe a slight noise coming from the engine compartment at the purge control valve area on the engine. Read More »
Flash: 2.4L Powertrain Diagnostic and System Improvements This bulletin involves reprogramming the Powertrain Control Module (PCM) with the latest available software. Read More »
Flash: 2.4L Powertrain Diagnostic and System Improvements This bulletin involves reprogramming the Powertrain Control Module (PCM) with the latest available software. Read More »
Flash: 2.4L Powertrain Diagnostic and System Improvements This bulletin involves reprogramming the Powertrain Control Module (PCM) with the latest available software. Read More »
Multi-Air Actuator Assembly For 2.4 Tigershark Engine ONLY: When attempting to diagnose P Codes related to the MultiAir Unit, please note that there are multiple causes listed for each in the diagnostic procedure. Read More »
Multi-Air Actuator Assembly For 2.4 Tigershark Engine ONLY: When attempting to diagnose P Codes related to the MultiAir Unit, please note that there are multiple causes listed for each in the diagnostic procedure. Read More »
Multi-Air Actuator Assembly For 2.4 Tigershark Engine ONLY: When attempting to diagnose P Codes related to the MultiAir Unit, please note that there are multiple causes listed for each in the diagnostic procedure. Read More »
3.2L - 3.6L Cylinder Head Assy Multiple cylinder head replacement. If cylinder head is replaced on a vehicle more than 1 time for any reason, please call any of the following people.~ First: Ron Dallison ? Cell (248) 292-9510 Ron. Read More »
A/C Compressor This applies to 2015 and 2016 KL, UF and PF. Before replacing the AC compressor for noise, leaks , or for an inop condition:~ After these questions have been answered please call one of the individuals below. Read More »
Flash: 2.4L Powertrain Diagnostic and System Improvements This bulletin involves reprogramming the Powertrain Control Module (PCM) with the latest available software. Read More »
Flash: 2.4L Powertrain Diagnostic and System Improvements This bulletin involves reprogramming the Powertrain Control Module (PCM) with the latest available software. Read More »
Flash: 2.4L Powertrain Diagnostic and System Improvements This bulletin involves reprogramming the Powertrain Control Module (PCM) with the latest available software. Read More »
Flash: 2.4L Powertrain Diagnostic and System Improvements This bulletin involves reprogramming the Powertrain Control Module (PCM) with the latest available software. Read More »
Pentastar Oil Filter Adapter: Before replacing this part, please call any one of the following people. Engineering is seeking information regarding this part.~ Dye must be used to determine where the leak is coming from before replacing. Read More »
Flash: 2.4L Powertrain Diagnostic and System Improvements This bulletin involves reprogramming the Powertrain Control Module (PCM) with the latest available software. Read More »
Flash: 2.4L Powertrain Diagnostic and System Improvements This bulletin involves reprogramming the Powertrain Control Module (PCM) with the latest available software. Read More »
3.2L - 3.6L Cylinder Head Assy Multiple cylinder head replacement. If cylinder head is replaced on a vehicle more than 1 time for any reason, please call any of the following people.~ First: Ron Dallison ? Cell (248) 292-9510 Ron. Read More »
Flash: 2.4L Powertrain Diagnostic and System Improvements This bulletin involves reprogramming the Powertrain Control Module (PCM) with the latest available software. Read More »
NAG1 (5A580) Valve Body As per Warranty Bulletin D-13-22, please use R2108213A$ valve body for all Warranty (W), Mopar (M) and Mopar Vehicle Protection (F) claims.~ Assembly also includes Filter (52108325AA) and Gasket (52108332AA). Read More »
Flash: PTU Motor Position Enhancements This bulletin involves updating the software in the Power Transfer Unit (PTU), Rear Driveline Module (RDM) and Drivetrain Control Module (DTCM). Read More »
Flash: PTU Motor Position Enhancements This bulletin involves updating the software in the Power Transfer Unit (PTU), Rear Driveline Module (RDM) and Drivetrain Control Module (DTCM). Read More »
Flash: 2.4L Powertrain Diagnostic and System Improvements This bulletin involves reprogramming the Powertrain Control Module (PCM) with the latest available software. Read More »
Before replacing this part for debris issue faults, please call the following people;~ Engineering is seeking information regarding this part.~ Bob Smith ? Cell (248) 202-9458 - Robert.M.Smith@fcagroup. Read More »
Flash: 2.4L Powertrain Diagnostic and System Improvements This bulletin involves reprogramming the Powertrain Control Module (PCM) with the latest available software. Read More »
Flash: 2.4L Powertrain Diagnostic and System Improvements This bulletin involves reprogramming the Powertrain Control Module (PCM) with the latest available software. Read More »
Flash: 2.4L Powertrain Diagnostic and System Improvements This bulletin involves reprogramming the Powertrain Control Module (PCM) with the latest available software. Read More »
Flash: Extended Engine Crank Time And Transmission Quick Learn Enable This bulletin involves selectively erasing and reprogramming the Powertrain Control Module (PCM) with new software. Read More »
2.4L Excessive Oil Consumption XB1 Warranty Extension The customer may describe one or more of the following: ? Oil pressure low indicator lamp illumination between oil changes. ? Excessive oil consumption. Read More »
Cam Phasers, Oil Control Valve For Malfunction Indicator Light (MIL) issues related to 2012-2017 3.6L Pentastar engines, please note that there is a new diagnostic procedure available in DealerCONNECT for P-codes in relationship to cam ... Read More »
ENGINE AND ENGINE COOLING:ENGINE:OIL/LUBRICATION:FILTER/SCREEN
Pentastar Oil Filter Adapter All vehicles equipped with a 3.2L or 3.6L engine; If replacing the Oil Filter Adapter (OFA) due to a leak detected between OFA and block. Ensure the torque on the 5 (OFA) bolts are torqued to 12nm. Read More »
Pentastar Oil Filter Adapter: Before replacing this part, please call any one of the following people. Engineering is seeking information regarding this part.~ Dye must be used to determine where the leak is coming from before replacing. Read More »
ENGINE AND ENGINE COOLING:ENGINE:OIL/LUBRICATION:SEALS/GASKETS
Cover Kit Please note that if you are attempting to get the cover kit and it is not available the gasket is available as a separate part number in the kit which is 04753095AB. Read More »
ENGINE AND ENGINE COOLING:ENGINE:OIL/LUBRICATION:OIL COOLER
2.4L Engine Oil Consumption Test The customer may comment that the vehicles engine oil level is low or they need to add oil between oil change intervals and no visible signs of oil leaking from the engine. Read More »
ENGINE AND ENGINE COOLING:ENGINE:ENGINE CONTROL MODULE (ECU/ECM)
Part Description: Belly Pan Issue Description: Please do not replace the entire assembly for a broken oil drain door or broken oil filter access door. Instead, replace the respective parts: Oil Drain Door = 68248175AA. Read More »
ENGINE AND ENGINE COOLING:COOLING SYSTEM:RADIATOR ASSEMBLY
Customer Satisfaction Notification T12 VECI Label The Vehicle Emission Control Information (VECI) label on about 120,000 of the above vehicles may be missing emission control information. Read More »
ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL:CATALYTIC CONVERTOR
Oil Pump Assembly If error code P06DD present on any Pentastar V6 application, please inspect oil pump for relief valve failure. See photo attached. If valve is found out of place please call Bob Jackson (248) 944-0466 bob. Read More »
Replace Purge Control Valve Hose This bulletin involves replacing the purge control valve hose assembly. The customer may describe a slight noise coming from the engine compartment at the purge control valve area on the engine. Read More »
Oil Filter If a Mopar Oil Filter is not available, use a filter that meets or exceeds USCAR36 specification and is compatible with semi and full synthetic oils. Read More »
Oil Filter If a Mopar Oil Filter is not available, use a filter that meets or exceeds USCAR36 specification and is compatible with semi and full synthetic oils. Read More »
Oil Filter If a Mopar Oil Filter is not available, use a filter that meets or exceeds USCAR36 specification and is compatible with semi and full synthetic oils. Read More »
Transmission Kit with Torque Converter 1. All Promaster (VF) 3.6L/62TE equipped vehicles. If the transmission bracket to the transmission case fasteners are removed during servicing, the fasteners (Part Number 06511385A$) are one-time ... Read More »
Nine-Speed Automatic Transmission (X80 Warranty Extension) This bulletin involves extending the warranty on the nine-speed automatic transmissions. Read More »
Flash: Transmission Diagnostic and Shift Enhancements This bulletin involves reprogramming the Transmission Control Module (TCM) withthe latest available software. Read More »
Flash: Powertrain Diagnostic and System Improvements This bulletin involves reprogramming the Powertrain Control Module (PCM) with the latest available software. Read More »
948TE 9 Speed Transmission Quick Learn Procedure This bulletin provides information on how to perform the new scan tool based transmission Quick Learn procedure. Read More »
Flash: Transmission Diagnostic And Shift Enhancements This bulletin involves reprogramming the Transmission Control Module (TCM) with the latest available software. Read More »
FLASH: 2.4L POWERTRAIN DIAGNOSTIC AND SYSTEM IMPROVEMENTS. BULLETIN INVOLVES REPROGRAMMING THE POWERTRAIN CONTROL MODULE (PCM) WITH THE LATEST AVAILABLE SOFTWARE. Read More »
Drivetrain Control Module (DTCM) This bulletin involves replacing and reconfiguring the Drivetrain Control Module (DTCM) with the latest available software. Read More »
Flash: 2.4L Powertrain Diagnostic and System Improvements This bulletin involves reprogramming the Powertrain Control Module (PCM) with the latest available software. Read More »
Flash: 2.4L Powertrain Diagnostic and System Improvements This bulletin involves reprogramming the Powertrain Control Module (PCM) with the latest available software. Read More »
9-spd Transmission: FOR NAFTA Market Only: If you are ordering this transmission please follow all wiTECH pop ups and Warranty Payment Guidelines. Read More »
9-spd Transmission: FOR NAFTA Market Only: If you are ordering this transmission please follow all wiTECH pop ups and Warranty Payment Guidelines. Read More »
9-spd Transmission: FOR NAFTA Market Only: If you are ordering this transmission please follow all wiTECH pop ups and Warranty Payment Guidelines. Read More »
Flash: Transmission Diagnostic And Shift Enhancements. This bulletin involves reprogramming the Transmission Control Module (TCM) with the latest available software. Read More »
Flash: Transmission Diagnostic And Shift Enhancements This bulletin involves reprogramming the Transmission Control Module (TCM) with the latest available software. Read More »
948TE 9 Speed Transmission Quick Learn Procedure This bulletin provides information on how to perform the new scan tool based transmission Quick Learn procedure. Read More »
948TE 9 Speed Transmission Quick Learn Procedure This bulletin provides information on how to perform the new scan tool based transmission Quick Learn procedure. Read More »
948TE 9 Speed Transmission Quick Learn Procedure This bulletin provides information on how to perform the new scan tool based transmission Quick Learn procedure. Read More »
Flash: PTU Motor Position Enhancements This bulletin involves updating the software in the Power Transfer Unit (PTU), Rear Driveline Module (RDM) and Drivetrain Control Module (DTCM). Read More »
Flash: PTU Motor Position Enhancements This bulletin involves updating the software in the Power Transfer Unit (PTU), Rear Driveline Module (RDM) and Drivetrain Control Module (DTCM). Read More »
Flash: 2.4L Powertrain Diagnostic and System Improvements This bulletin involves reprogramming the Powertrain Control Module (PCM) with the latest available software. Read More »
Flash: 2.4L Powertrain Diagnostic and System Improvements This bulletin involves reprogramming the Powertrain Control Module (PCM) with the latest available software. Read More »
948TE 9 Speed Transmission Quick Learn Procedure This bulletin provides information on how to perform the new scan tool based transmission Quick Learn procedure. Read More »
948TE 9 Speed Transmission Quick Learn Procedure This bulletin provides information on how to perform the new scan tool based transmission Quick Learn procedure. Read More »
948TE 9 Speed Transmission Quick Learn Procedure This bulletin provides information on how to perform the new scan tool based transmission Quick Learn procedure. Read More »
Flash: Transmission Diagnostic And Shift Enhancements This bulletin involves reprogramming the Transmission Control Module (TCM) with the latest available software. Read More »
Flash: Transmission Diagnostic And Shift Enhancements This bulletin involves reprogramming the Transmission Control Module (TCM) with the latest available software. Read More »
Flash: Transmission Diagnostic And Shift Enhancements This bulletin involves reprogramming the Transmission Control Module (TCM) with the latest available software. Read More »
Flash: Transmission Diagnostic And Shift Enhancements This bulletin involves reprogramming the Transmission Control Module (TCM) with the latest available software. Read More »
Flash: 2.4L Powertrain Diagnostic and System Improvements This bulletin involves reprogramming the Powertrain Control Module (PCM) with the latest available software. Read More »
Flash: Transmission Diagnostic And Shift Enhancements This bulletin involves reprogramming the Transmission Control Module (TCM) with the latest available software. Read More »
Flash: Transmission Diagnostic And Shift Enhancements This bulletin involves reprogramming the Transmission Control Module (TCM) with the latest available software. Read More »
Incorrect Bolt Length Used For Fastening Transmission To Engine This bulletin involves replacing 2 bolts used to fasten the transmission to the engine. Read More »
Flash: C1499-92-RDM Motor Position C1496-92-PTU Motor Position This bulletin involves updating the software in the Power Transfer Unit (PTU), Rear Driveline Module (RDM) and Drivetrain Control Module (DTCM). Read More »
Flash: Transmission Diagnostic And Shift Enhancements This bulletin involves reprogramming the Transmission Control Module (TCM) with new software. Read More »
Flash: C1499-92-RDM Motor Position C1496-92-PTU Motor Position This bulletin involves updating the software in the Power Transfer Unit (PTU), Rear Driveline Module (RDM) and Drivetrain Control Module (DTCM). Read More »
Flash: 2.4L Powertrain Diagnostic and System Improvements This bulletin involves reprogramming the Powertrain Control Module (PCM) with the latest available software. Read More »
Transmission Shift Quality C-Clutch Snap Ring This bulletin involves removing the transmission, disassembling, and replacing the C-Clutch snap ring. Read More »
Transmission Shift Quality C-Clutch Snap Ring This bulletin involves removing the transmission, disassembling, and replacing the C-Clutch snap ring. Read More »
Transmission Shift Quality C-Clutch Snap Ring This bulletin involves removing the transmission, disassembling, and replacing the C-Clutch snap ring. Read More »
Transmission Shift Quality C-Clutch Snap Ring This bulletin involves removing the transmission, disassembling, and replacing the C-Clutch snap ring. Read More »
Flash: 948TE Transmission C-Clutch Snap Ring Durability This bulletin involves reprogramming the Transmission Control Module (TCM) and Powertrain Control Module (PCM) with the latest available software. Read More »
Flash: 2.4L Powertrain Diagnostic and System Improvements This bulletin involves reprogramming the Powertrain Control Module (PCM) with the latest available software. Read More »
Flash: 2.4L Powertrain Diagnostic and System Improvements This bulletin involves reprogramming the Powertrain Control Module (PCM) with the latest available software. Read More »
Flash: 948TE 9 Speed Shift Enhancements And Quick Learn Enable. This bulletin involves selectively erasing and reprogramming the Transmission Control Module (TCM) with new software. Read More »
Flash: 948TE 9 Speed Shift Enhancements And Quick Learn Enable This bulletin involves selectively erasing and reprogramming the Transmission Control Module (TCM) with new software. Read More »
Flash: Extended Engine Crank Time And Transmission Quick Learn Enable This bulletin involves selectively erasing and reprogramming the Powertrain Control Module (PCM) with new software. Read More »
Flash: Extended Engine Crank Time And Transmission Quick Learn Enable This bulletin involves selectively erasing and reprogramming the Powertrain Control Module (PCM) with new software. Read More »
Flash: 948TE 9 Speed Shift Enhancements And Quick Learn Enable This bulletin involves selectively erasing and reprogramming the Transmission Control Module (TCM) with new software. Read More »
Flash: 948TE 9 Speed Shift Enhancements And Quick Learn Enable This bulletin involves selectively erasing and reprogramming the Transmission Control Module (TCM) with new software. Read More »
Flash: 948TE 9 Speed Shift Enhancements And Quick Learn Enable This bulletin involves selectively erasing and reprogramming the Transmission Control Module (TCM) with new software. Read More »
948TE 9 Speed Transmission Quick Learn Procedure This bulletin provides information on how to perform the new scan tool based transmission Quick Learn procedure. Read More »
Flash: 948TE 9 Speed Shift Enhancements And Quick Learn Enable This bulletin involves selectively erasing and reprogramming the Transmission Control Module (TCM) with new software. Read More »
948TE 9 Speed Transmission Quick Learn Procedure This bulletin provides information on how to perform the new scan tool based transmission Quick Learn procedure. Read More »
Flash: Extended Engine Crank Time And Transmission Quick Learn Enable This bulletin involves selectively erasing and reprogramming the Powertrain Control Module (PCM) with new software. Read More »
Flash: Extended Engine Crank Time And Transmission Quick Learn Enable This bulletin involves selectively erasing and reprogramming the Powertrain Control Module (PCM) with new software. Read More »
948TE 9 Speed Transmission Quick Learn Procedure This bulletin provides information on how to perform the new scan tool based transmission Quick Learn procedure. Read More »
Flash: 948TE 9 Speed Shift Enhancements And Quick Learn Enable. This bulletin involves selectively erasing and reprogramming the Transmission Control Module (TCM) with new software. Read More »
948TE 9 Speed Transmission Quick Learn Procedure This bulletin provides information on how to perform the new scan tool based transmission Quick Learn procedure. Read More »
Flash: 948TE 9 Speed Shift Enhancements And Quick Learn Enable This bulletin involves selectively erasing and reprogramming the Transmission Control Module (TCM) with new software. Read More »
Flash: Diagnostic and System Improvements This bulletin involves selectively erasing and reprogramming the Powertrain Control Module (PCM) with new software. Read More »
Flash: Transmission Control Module - Shift Quality Improvements When Using Paddle Shifter Or When Shifting From Park To Drive Or Reverse This bulletin involves flash reprogramming of the Transmission Control Module (TCM) with new software. Read More »
Flash:Extended Crank Time, Long Crank This bulletin involves selectively erasing and reprogramming the Powertrain Control Module (PCM) with new software. Read More »
9 Speed Transmission Shift Enhancements - Adaptation Learn Procedure This bulletin involves performing a subjectivity shift quality rating and performing the transmission adaptation learn procedure if required. Read More »
Flash: MIL Illumination For P1DCF, P1DD0, P1DB8 This bulletin involves selectively erasing and reprogramming the Transmission Control Module (TCM) with new software. Read More »
Flash: MIL Illumination For P1DCF, P1DD0, P1DB8 This bulletin involves selectively erasing and reprogramming the Transmission Control Module (TCM) with new software. Read More »
Flash: Electronic Shift Module (ESM) Enhancement This bulletin involves updating the software in the Electronic Shift Module. The customer may experience an intermittent inability to shift into any gear range. Read More »
Flash: Electronic Shift Module (ESM) Enhancement This bulletin involves updating the software in the Electronic Shift Module. The customer may experience an intermittent inability to shift into any gear range. Read More »
Flash: Transmission Control Module - Quicker Shifts When Using Paddle Shifter and Shift Quality Improvement for Garage Shifts This bulletin involves flash reprogramming of the Transmission Control Module (TCM) with new software. Read More »
Transmission Shift Quality C-Clutch Snap Ring This bulletin involves removing the transmission, disassembling, and replacing the C-Clutch snap ring. Read More »
POWER TRAIN:CLUTCH ASSEMBLY:PEDAL/HAND LEVER(MOTORCYCLE)
JEEP/CHRYSLER: INFORMATION REGARDING AN ISSUE, ON SOME VEHICLES, WHEREBY DURING 5-4 DOWNSHIFTING, IS LESS THAN DESIRED AND MALFUNCTION INDICATOR LAMP (MIL) WILL ILLUMINATE AND REMOVING, DISASSEMBLING AND REPLACING THE C-CLUTCH SNAP RING ... Read More »
Nine-Speed Automatic Transmission (X80 Warranty Extension) This bulletin involves extending the warranty on the nine-speed automatic transmissions. Read More »
"DRIVETRAIN CONTROL MODULE (DTCM) THIS BULLETIN INVOLVES REPLACING AND RECONFIGURING THE DRIVETRAIN CONTROL MODULE (DTCM) WITH THE LATEST AVAILABLE SOFTWARE. Read More »
2015 JEEP CHEROKEE; CHRYSLER 200; JEEP RENEGADE; RAM PROMASTER CITY; 2016 FIAT 500X: ERRATIC TRANSMISSION SHIFT QUALITY MAY BE INDICATED *CN Read More »
Transmission Shift Quality C-Clutch Snap Ring This bulletin involves removing the transmission, disassembling, and replacing the C-Clutch snap ring. Read More »
Transmission Shift Quality C-Clutch Snap Ring This bulletin involves removing the transmission, disassembling, and replacing the C-Clutch snap ring. Read More »
CHRYSLER/JEEP: TSB CONTAINS AN OWNER NOTIFICATION LETTER. SELECT DOCUMENT SEARCH BUTTON BELOW. TO PREVENT C-CLUTCH SNAP FROM DISLODGING, A NEW SOFTWARE ENHANCEMENT IS RELEASED TO CHANGE THE CHARACTERISTICS OF CLUTCH APPLICATION BY ... Read More »
Transmission Shift And Drivability Enhancements For P0901-00. This bulletin involves performing transmission harness replacement per S55 recall. Read More »
CHRYSLER 2015 JEEP CHEROKEE, CHRYSLER 200: INVOLVING UPDATED SOFTWARE AND REPROGRAMMING THE TRANSMISSION CONTROL MODULE DUE TO MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATING. *LJ UPDATED 9/10/15. *PE UPDATED 9/18/15. Read More »
Flash: 2.4L Powertrain Diagnostic and System Improvements This bulletin involves reprogramming the Powertrain Control Module (PCM) with the latest available software. Read More »
Flash: Extended Engine Crank Time And Transmission Quick Learn Enable This bulletin involves selectively erasing and reprogramming the Powertrain Control Module (PCM) with new software. Read More »
Flash: 2.4L Powertrain Diagnostic and System Improvements This bulletin involves reprogramming the Powertrain Control Module (PCM) with the latest available software. Read More »
Flash: 2.4L Powertrain Diagnostic and System Improvements This bulletin involves reprogramming the Powertrain Control Module (PCM) with the latest available software. Read More »
Flash: 2.4L Powertrain Diagnostic and System Improvements This bulletin involves reprogramming the Powertrain Control Module (PCM) with the latest available software. Read More »
CHRYSLER/JEEP: TSB CONTAINS AN OWNER NOTIFICATION LETTER. SELECT DOCUMENT SEARCH BUTTON BELOW. TO PREVENT C-CLUTCH SNAP FROM DISLODGING, A NEW SOFTWARE ENHANCEMENT IS RELEASED TO CHANGE THE CHARACTERISTICS OF CLUTCH APPLICATION BY ... Read More »
Flash: 2.4L Powertrain Diagnostic and System Improvements This bulletin involves reprogramming the Powertrain Control Module (PCM) with the latest available software. Read More »
Flash: 2.4L Powertrain Diagnostic and System Improvements This bulletin involves reprogramming the Powertrain Control Module (PCM) with the latest available software. Read More »
Flash: 2.4L Powertrain Diagnostic and System Improvements This bulletin involves reprogramming the Powertrain Control Module (PCM) with the latest available software. Read More »
POWER TRAIN:AUTOMATIC TRANSMISSION:FLUID/LUBRICANT:SEALS/GASKETS
Service Bulletin/RRT 21-001-15/15-003 Superseded By Customer Satisfaction Notification (CSN) R01 Refer to service procedures outlined in CSN R01. Read More »
"REAR DIFFERENTIAL OR REAR DIFFERENTIAL ACTUATION MOTOR IF YOU ARE ATTEMPTING TO REPAIR A WHISTLING/HIGH PITCHED NOISE FROM THE REAR DIFFERENTIAL AREA FCA HAS RELEASED TSB 03-003-16 JUNE 21 TO ADDRESS THIS ... Read More »
Rear Differential or Rear Differential Actuation Motor If you are attempting to repair a whistling/high pitched noise from the rear differential area FCA is currently working on a fix for the concern. Read More »
Connector kit Before ordering this connector repair kit 68018957A$, check it in the Mopar Connector Repair Kit Website to confirm part number and applicability. Read More »
Start Stop Charging Warning Lamp Illuminated On, Intelligent Battery Sensor (IBS) State of Charge (SOC) Inaccurate, Battery Charging Message, Presence of IBS related Diagnostic Trouble Codes (DTCs), or Battery Warning Lamp ... Read More »
CONDENSER, Air Conditioning CONDITION 1: If it is determined that the A/C compressor does not engage due to a refrigerant leak at the receiver/drier plug on the A/C condenser, order the receiver/drier plug kit P/N 68447796A$ and follow ... Read More »
CONDENSER, Air Conditioning CONDITION 1: If it is determined that the A/C compressor does not engage due to a refrigerant leak at the receiver/drier plug on the A/C condenser, order the receiver/drier plug kit P/N 68447796A$ and follow ... Read More »
CONDENSER, Air Conditioning CONDITION 1: If it is determined that the A/C compressor does not engage due to a refrigerant leak at the receiver/drier plug on the A/C condenser, order the receiver/drier plug kit P/N 68447796A$ and follow ... Read More »
Charging System, Battery Diagnostic Tools and Warranty This information only bulletin discusses using the correct test equipment for testing batteries and charging systems, and also warranty reimbursement when battery replacements are ... Read More »
2.4L Ignition Coil Boot Replacement This bulletin involves replacing all four ignition coil insulating boots. Customers may experience a Malfunction Indicator Lamp (MIL) illumination. Read More »
2.4L Ignition Coil Boot Replacement This bulletin involves replacing all four ignition coil insulating boots. Customers may experience a Malfunction Indicator Lamp (MIL) illumination. Read More »
CONDENSER, Air Conditioning If it is determined that the A/C compressor does not engage due to a refrigerant leak at the receiver/drier plug on the A/C condenser, order the receiver/drier plug kit P/N 68447796A$ and follow the repair ... Read More »
Flash Over The Air (FOTA) Software Update RA3 and RA4 Radio This bulletin provides information regarding the latest Flash Over The Air (FOTA) update and provides the service technician an overview of the steps a customer will need to ... Read More »
Flash: Transmission Diagnostic and Shift Enhancements This bulletin involves reprogramming the Transmission Control Module (TCM) withthe latest available software. Read More »
Occupant Restraint Controller (ORC) For PF, KL or UF Vehicles ONLY: Prior to replacing ORC part numbers, please contact FCA engineering if ANY of the following Diagnostic trouble codes are Stored or Active in the ORC module: DTC: ... Read More »
Flash: Powertrain Diagnostic and System Improvements This bulletin involves reprogramming the Powertrain Control Module (PCM) with the latest available software. Read More »
Flash: Powertrain Diagnostic and System Improvements This bulletin involves reprogramming the Powertrain Control Module (PCM) with the latest available software. Read More »
Occupant Restraint Controller (ORC) For PF, KL or UF Vehicles ONLY:~ Prior to replacing ORC part numbers, please contact FCA engineering if the following Diagnostic trouble codes are Stored or Active in the ORC module:~ DTC: B223D-00 ... Read More »
Inspect and Return: Solenoid Module - Transmission You have been identified as either having stock, or have stock in transit to your dealership. Please return suspect stock of follow ing part numbers:52120000AA, 52119435AF, 05078709AB. Read More »
Occupant Restraint Controller (ORC) For PF, KL or UF Vehicles ONLY:~ Prior to replacing ORC part numbers, please contact FCA engineering if the following Diagnostic trouble codes are Stored or Active in the ORC module:~ DTC: B223D-00 ... Read More »
Occupant Restraint Controller (ORC) For PF, KL or UF Vehicles ONLY:~ Prior to replacing ORC part numbers, please contact FCA engineering if the following Diagnostic trouble codes are Stored or Active in the ORC module:~ DTC: B223D-00 - ... Read More »
P/N CBSZR068AA: Inspect & Return: Module Kit - Occupant Restraint You have been identified as either having stock, or have stock in transit to your dealership. Please return part number CBSZR068AA as per the QIR attached. Read More »
Flash: 2.4L Powertrain Diagnostic and System Improvements This bulletin involves reprogramming the Powertrain Control Module (PCM) with the latest available software. Read More »
Flash: 2.4L Powertrain Diagnostic and System Improvements This bulletin involves reprogramming the Powertrain Control Module (PCM) with the latest available software. Read More »
Flash: 2.4L Powertrain Diagnostic and System Improvements This bulletin involves reprogramming the Powertrain Control Module (PCM) with the latest available software. Read More »
Drivetrain Control Module (DTCM) This bulletin involves replacing and reconfiguring the Drivetrain Control Module (DTCM) with the latest available software. Read More »
Flash: 2.4L Powertrain Diagnostic and System Improvements This bulletin involves reprogramming the Powertrain Control Module (PCM) with the latest available software. Read More »
Drivetrain Control Module (DTCM) This bulletin involves replacing and reconfiguring the Drivetrain Control Module (DTCM) with the latest available software. Read More »
Flash: 2.4L Powertrain Diagnostic and System Improvements This bulletin involves reprogramming the Powertrain Control Module (PCM) with the latest available software. Read More »
"PENTASTAR OIL FILTER ADAPTER BEFORE REPLACING THIS PART, PLEASE CALL ANY ONE OF THE FOLLOWING PEOPLE. ENGINEERING IS SEEKING INFORMATION REGARDING THIS PART.~ DYE MUST BE USED TO DETERMINE WHERE THE LEAK IS COMING FROM BEFORE REPLACING. Read More »
Flash: 2.4L Powertrain Diagnostic and System Improvements This bulletin involves reprogramming the Powertrain Control Module (PCM) with the latest available software. Read More »
Flash: 2.4L Powertrain Diagnostic and System Improvements This bulletin involves reprogramming the Powertrain Control Module (PCM) with the latest available software. Read More »
Flash: 2.4L Powertrain Diagnostic and System Improvements This bulletin involves reprogramming the Powertrain Control Module (PCM) with the latest available software. Read More »
Flash: 2.4L Powertrain Diagnostic and System Improvements This bulletin involves reprogramming the Powertrain Control Module (PCM) with the latest available software. Read More »
Flash: 2.4L Powertrain Diagnostic and System Improvements This bulletin involves reprogramming the Powertrain Control Module (PCM) with the latest available software. Read More »
RES / RHA / REB radio that supports Bluetooth and Hands-Free For issues with Bluetooth, Hands-Free Calling, and/or Voice Commands, DO NOT replace the radio. Diagnose the Hands-Free Module system (also called the Telematics Module). Read More »
RES / RHA / REB radio that supports Bluetooth and Hands-Free For issues with Bluetooth, Hands-Free Calling, and/or Voice Commands, DO NOT replace the radio. Diagnose the Hands-Free Module system (also called the Telematics Module). Read More »
Flash: Transmission Diagnostic And Shift Enhancements. This bulletin involves reprogramming the Transmission Control Module (TCM) with the latest available software. Read More »
Flash: Transmission Diagnostic And Shift Enhancements This bulletin involves reprogramming the Transmission Control Module (TCM) with the latest available software. Read More »
Flash: Electronic Parking Brake Module Enhancement This bulletin involves updating the Electronic Parking Brake (EPB) module software. The customer may describe the EPB does not engage with the ?Auto Apply? feature selected. Read More »
Flash: Electronic Parking Brake Module Enhancement This bulletin involves updating the Electronic Parking Brake (EPB) module software. The customer may describe the EPB does not engage with the ?Auto Apply? feature selected. Read More »
Flash: PTU Motor Position Enhancements This bulletin involves updating the software in the Power Transfer Unit (PTU), Rear Driveline Module (RDM) and Drivetrain Control Module (DTCM). Read More »
Flash: PTU Motor Position Enhancements This bulletin involves updating the software in the Power Transfer Unit (PTU), Rear Driveline Module (RDM) and Drivetrain Control Module (DTCM). Read More »
Flash: 2.4L Powertrain Diagnostic and System Improvements This bulletin involves reprogramming the Powertrain Control Module (PCM) with the latest available software. Read More »
Flash: 2.4L Powertrain Diagnostic and System Improvements This bulletin involves reprogramming the Powertrain Control Module (PCM) with the latest available software. Read More »
2014-2015 (KL)JEEP CHEROKEE AND 2015 (UF)CHRYSLER 200: THIS BULLETIN DEALS WITH LATEST SOFTWARE AVAILABLE TO OPTIMIZE ADVANCED BRAKE ASSIST PERFORMANCE IN LOW TRACTION SITUATIONS *CN Read More »
FLASH: ABS Module Enhancements This bulletin involves updating the ABS Module software. New software is available to optimize Advanced Brake Assist (ABA) performance in low tractions situations. Read More »
FLASH: ABS Module Enhancements This bulletin involves updating the ABS Module software. New software is available to optimize Advanced Brake Assist (ABA) performance in low tractions situations. Read More »
Flash: Transmission Diagnostic And Shift Enhancements This bulletin involves reprogramming the Transmission Control Module (TCM) with the latest available software. Read More »
Flash: Transmission Diagnostic And Shift Enhancements This bulletin involves reprogramming the Transmission Control Module (TCM) with the latest available software. Read More »
Flash: 2.4L Powertrain Diagnostic and System Improvements This bulletin involves reprogramming the Powertrain Control Module (PCM) with the latest available software. Read More »
RA2 Radio Software Enhancements This bulletin involves updating the radio's software or replacing the radio if required. A customer may notice one or more of the following: ? Radio display screen intermittently may go blank. Read More »
Flash: Transmission Diagnostic And Shift Enhancements This bulletin involves reprogramming the Transmission Control Module (TCM) with the latest available software. Read More »
Flash: Transmission Diagnostic And Shift Enhancements This bulletin involves reprogramming the Transmission Control Module (TCM) with the latest available software. Read More »
Flash: C1499-92-RDM Motor Position C1496-92-PTU Motor Position This bulletin involves updating the software in the Power Transfer Unit (PTU), Rear Driveline Module (RDM) and Drivetrain Control Module (DTCM). Read More »
RA2 Radio Software Enhancements This bulletin involves updating the radio's software or replacing the radio if required. A customer may notice one or more of the following: ? Radio display screen may be locked. Read More »
Flash: 2.4L Powertrain Diagnostic and System Improvements This bulletin involves reprogramming the Powertrain Control Module (PCM) with the latest available software. Read More »
Flash: 2.4L Powertrain Diagnostic and System Improvements This bulletin involves reprogramming the Powertrain Control Module (PCM) with the latest available software. Read More »
Transmission Shift Quality C-Clutch Snap Ring This bulletin involves removing the transmission, disassembling, and replacing the C-Clutch snap ring. Read More »
Transmission Shift Quality C-Clutch Snap Ring This bulletin involves removing the transmission, disassembling, and replacing the C-Clutch snap ring. Read More »
Transmission Shift Quality C-Clutch Snap Ring This bulletin involves removing the transmission, disassembling, and replacing the C-Clutch snap ring. Read More »
Flash: 2.4L Powertrain Diagnostic and System Improvements This bulletin involves reprogramming the Powertrain Control Module (PCM) with the latest available software. Read More »
Flash: 2.4L Powertrain Diagnostic and System Improvements This bulletin involves reprogramming the Powertrain Control Module (PCM) with the latest available software. Read More »
Flash: 948TE Transmission C-Clutch Snap Ring Durability This bulletin involves reprogramming the Transmission Control Module (TCM) and Powertrain Control Module (PCM) with the latest available software. Read More »
Flash: 2.4L Powertrain Diagnostic and System Improvements This bulletin involves reprogramming the Powertrain Control Module (PCM) with the latest available software. Read More »
Flash: 2.4L Powertrain Diagnostic and System Improvements This bulletin involves reprogramming the Powertrain Control Module (PCM) with the latest available software. Read More »
RA2 Radio Software Enhancements This bulletin involves updating the radio's software or replacing the radio if required. A customer may notice one of more of the following: Radio display screen may be locked. Read More »
Flash: 948TE 9 Speed Shift Enhancements And Quick Learn Enable This bulletin involves selectively erasing and reprogramming the Transmission Control Module (TCM) with new software. Read More »
Flash: Extended Engine Crank Time And Transmission Quick Learn Enable This bulletin involves selectively erasing and reprogramming the Powertrain Control Module (PCM) with new software. Read More »
Flash: 948TE 9 Speed Shift Enhancements And Quick Learn Enable This bulletin involves selectively erasing and reprogramming the Transmission Control Module (TCM) with new software. Read More »
Flash: 948TE 9 Speed Shift Enhancements And Quick Learn Enable This bulletin involves selectively erasing and reprogramming the Transmission Control Module (TCM) with new software. Read More »
Flash: Extended Engine Crank Time And Transmission Quick Learn Enable This bulletin involves selectively erasing and reprogramming the Powertrain Control Module (PCM) with new software. Read More »
Flash: 948TE 9 Speed Shift Enhancements And Quick Learn Enable. This bulletin involves selectively erasing and reprogramming the Transmission Control Module (TCM) with new software. Read More »
Flash: Transmission Control Module - Shift Quality Improvements When Using Paddle Shifter Or When Shifting From Park To Drive Or Reverse This bulletin involves flash reprogramming of the Transmission Control Module (TCM) with new software. Read More »
Flash: MIL Illumination For P1DCF, P1DD0, P1DB8 This bulletin involves selectively erasing and reprogramming the Transmission Control Module (TCM) with new software. Read More »
Flash: MIL Illumination For P1DCF, P1DD0, P1DB8 This bulletin involves selectively erasing and reprogramming the Transmission Control Module (TCM) with new software. Read More »
Flash: Electronic Shift Module (ESM) Enhancement This bulletin involves updating the software in the Electronic Shift Module. The customer may experience an intermittent inability to shift into any gear range. Read More »
Flash: Electronic Shift Module (ESM) Enhancement This bulletin involves updating the software in the Electronic Shift Module. The customer may experience an intermittent inability to shift into any gear range. Read More »
MIL Illumination DTC U11E9 After Fascia Removal This bulletin involves confirming that the Active Grille Shutter (AGS) electrical harness connector is properly connected. Read More »
MIL Illumination DTC U11E9 After Fascia Removal This bulletin involves confirming that the Active Grille Shutter (AGS) electrical harness connector is properly connected. Read More »
Flash: Transmission Control Module - Quicker Shifts When Using Paddle Shifter and Shift Quality Improvement for Garage Shifts This bulletin involves flash reprogramming of the Transmission Control Module (TCM) with new software. Read More »
Start Stop Charging Warning Lamp Illuminated On, Intelligent Battery Sensor (IBS) State of Charge (SOC) Inaccurate, Battery Charging Message, Presence of IBS related Diagnostic Trouble Codes (DTCs), or Battery Warning Lamp ... Read More »
Connector kit Before ordering this connector repair kit 68018957A$, check it in the Mopar Connector Repair Kit Website to confirm part number and applicability. Read More »
WIRING, Body Before replacing this harness, please contact FCA Redacted Content to see if a repair kit is available for your application. If no response in 15 minutes, proceed with repair. Read More »
Return: Wiring Assy - Engine You have been identified as either having stock, or have stock in transit to your dealership. Please return stock packaged before 2016/07/31 (31 July, 2016)of follow ing part numbers:68176457AF, 68176459AF. Read More »
ELECTRICAL SYSTEM:WIRING:POWER DISTRIBUTION MODULE/IPDM
2.4L Ignition Coil Boot Replacement This bulletin involves replacing all four ignition coil insulating boots. Customers may experience a Malfunction Indicator Lamp (MIL) illumination. Read More »
1NT30XDVAC - Inspect and Return: Panel - Instrument Panel You have been identified as either having stock, or have stock in transit to your dealership. Please return suspect stock of part number 1N T30XDVAC. Read More »
Flash: Cruise Control Set Speed Shows Incorrectly On Cluster This bulletin involves reprogramming the Instrument Panel Cluster (IPC) with updated software. Read More »
Flash: Cruise Control Set Speed Shows Incorrectly On Cluster This bulletin involves reprogramming the Instrument Panel Cluster (IPC) with updated software. Read More »
Hood Latch Release Cable Hangs Down Too Low Under Instrument Panel This bulletin involves routing and securing the hood latch release cable. Read More »
RA3 and RA4 Radio Over The Air Software Updates This bulletin provides information regarding the latest Flash Over The Air (FOTA) update and provides the service technician an overview of the steps a customer will need to take to ... Read More »
RES / RHA / REB Radios That Supports Bluetooth and Hands-Free For issues with Bluetooth, Hands-Free Calling, and/or Voice Commands, DO NOT replace the radio. Diagnose the Hands-Free Module system (also called the Telematics Module). Read More »
FLASH: 2.4L POWERTRAIN DIAGNOSTIC AND SYSTEM IMPROVEMENTS. BULLETIN INVOLVES REPROGRAMMING THE POWERTRAIN CONTROL MODULE (PCM) WITH THE LATEST AVAILABLE SOFTWARE. Read More »
Flash: Extended Engine Crank Time And Transmission Quick Learn Enable This bulletin involves selectively erasing and reprogramming the Powertrain Control Module (PCM) with new software. Read More »
CHRYSLER: ON CERTAIN VEHICLES, THERE ARE VARIOUS ISSUES INVOLVING THE RADIO AND NAVIGATIONAL SYSTEM FAILS TO WORK PROPERLY AND THE SOFTWARE NEEDS TO BE UPDATED. MODEL 2015 CHRYSLER 200. Read More »
Flash: 2.4L Powertrain Diagnostic and System Improvements This bulletin involves reprogramming the Powertrain Control Module (PCM) with the latest available software. Read More »
CHRYSLER JEEP CHEROKEE 2014-2015, CHRYSLER 200: BULLETIN INFORMATION INVOLVING UPDATING THE SOFTWARE IN THE POWER TRANSFER UNIT, REAR, DRIVELINE MODULE & DRIVETRAIN CONTROL MODULE. *LJ Read More »
CHRYSLER/JEEP: TSB CONTAINS AN OWNER NOTIFICATION LETTER. SELECT DOCUMENT SEARCH BUTTON BELOW. TO PREVENT C-CLUTCH SNAP FROM DISLODGING, A NEW SOFTWARE ENHANCEMENT IS RELEASED TO CHANGE THE CHARACTERISTICS OF CLUTCH APPLICATION BY ... Read More »
DODGE: CHRYSLER200, DODGE DART 2015: THIS BULLETIN IS AN OVERVIEW OF NEW SOFTWARE THAT ERASES AND REPROGRAM THE POWER CONTROL MODULE. *LJ UPDATED 06/22/15*LJ Read More »
RA2 Radio Software Enhancements This bulletin involves updating the radio's software or replacing the radio if required. A customer may notice one of more of the following: Radio display screen may be locked. Read More »
Flash: Diagnostic and System Improvements This bulletin involves selectively erasing and reprogramming the Powertrain Control Module (PCM) with new software. Read More »
CHRYSLER: 2014-2015 JEEP CHEROKEE, CHRYSLER 200 TRANSMISSION MAY NOT ALLOW THE TRANSAXLE TO SHIFT GEAR DUE TO TRANSMISSION CONTROL MODULE SOFTWARE. Read More »
2.4L Excessive Oil Consumption XB1 Warranty Extension The customer may describe one or more of the following: Oil pressure low indicator lamp illumination between oil changes. Excessive oil consumption. Read More »
Cam Phasers, Oil Control Valve For Malfunction Indicator Light (MIL) issues related to 2012-2017 3.6L Pentastar engines, please note that there is a new diagnostic procedure available in DealerCONNECT for P-codes in relationship to cam ... Read More »
Flash: Powertrain Diagnostic and System Improvements This bulletin involves reprogramming the Powertrain Control Module (PCM) with the latest available software. Read More »
Flash: 2.4L Powertrain Diagnostic and System Improvements This bulletin involves reprogramming the Powertrain Control Module (PCM) with the latest available software. Read More »
Flash: 2.4L Powertrain Diagnostic and System Improvements This bulletin involves reprogramming the Powertrain Control Module (PCM) with the latest available software. Read More »
Flash: 2.4L Powertrain Diagnostic and System Improvements This bulletin involves reprogramming the Powertrain Control Module (PCM) with the latest available software. Read More »
Flash: 2.4L Powertrain Diagnostic and System Improvements This bulletin involves reprogramming the Powertrain Control Module (PCM) with the latest available software. Read More »
Flash: 2.4L Powertrain Diagnostic and System Improvements This bulletin involves reprogramming the Powertrain Control Module (PCM) with the latest available software. Read More »
Flash: 2.4L Powertrain Diagnostic and System Improvements This bulletin involves reprogramming the Powertrain Control Module (PCM) with the latest available software. Read More »
Flash: Transmission Diagnostic And Shift Enhancements. This bulletin involves reprogramming the Transmission Control Module (TCM) with the latest available software. Read More »
Flash: 2.4L Powertrain Diagnostic and System Improvements This bulletin involves reprogramming the Powertrain Control Module (PCM) with the latest available software. Read More »
Flash: Transmission Diagnostic And Shift Enhancements This bulletin involves reprogramming the Transmission Control Module (TCM) with the latest available software. Read More »
Flash: Transmission Diagnostic And Shift Enhancements This bulletin involves reprogramming the Transmission Control Module (TCM) with the latest available software. Read More »
Flash: 2.4L Powertrain Diagnostic and System Improvements This bulletin involves reprogramming the Powertrain Control Module (PCM) with the latest available software. Read More »
Transmission Shift Quality C-Clutch Snap Ring This bulletin involves removing the transmission, disassembling, and replacing the C-Clutch snap ring. Read More »
Transmission Shift Quality C-Clutch Snap Ring This bulletin involves removing the transmission, disassembling, and replacing the C-Clutch snap ring. Read More »
Transmission Shift Quality C-Clutch Snap Ring This bulletin involves removing the transmission, disassembling, and replacing the C-Clutch snap ring. Read More »
Flash: 2.4L Powertrain Diagnostic and System Improvements This bulletin involves reprogramming the Powertrain Control Module (PCM) with the latest available software. Read More »
05182535AD - Lamp Assy ?Tail Light LT You have been identified as either having stock, or have stock in transit to your dealership. Please return suspect stock of part number 05182535AD . See attachments for identifying suspect stock. Read More »
Part Description: Heated Backlight Issue Description: By design, the upper 12 inches of the backlight does not defrost on vehicles built prior to MDH 121500. Read More »
Part Description: Heated Backlight Issue Description: By design, the upper 12 inches of the backlight does not defrost on vehicles built prior to MDH 121500. Read More »
Authentic Mopar? Glass Replacement This bulletin involves discussing FCA US LLC position with regard to collision repair industry awareness regarding the recommended usage of Authentic Mopar? Glass. Read More »
Authentic Mopar? Glass Replacement This bulletin involves discussing FCA US LLC position with regard to collision repair industry awareness regarding the recommended usage of Authentic Mopar? Glass. Read More »
Inside Rear View Mirror Without Assist And 911 Buttons This bulletin involves inspecting the inside rear view mirror for Assist and 911 buttons and replacing the mirror if the buttons are not there. Read More »
Washer Fluid Level Sensor Prior to replacing this part due to "Low Washer Fluid" tell tale light on the dash and the washer fluid bottle is full, please perform the this inspection. Read More »
Part Description: Motor, Sunroof Issue Description: If looking to replace the sunroof motor and these conditions are occurring:~ 1) Vent switch does not work. Read More »
Wind Noise Dual Pane Sunroof This bulletin involves inserting a foam stuffer into the sunroof bulb seal. The customer may describe a wind noise or whistle sound coming from the sunroof. Read More »
Washer Fluid Level Sensor Prior to replacing this part due to "Low Washer Fluid" tell tale light on the dash and the washer fluid bottle is full, please perform this inspection: Check if float sensor is rotated off location from the ... Read More »
SENSOR-WASHER FLUID LEVEL Please call Chuck Hood cell (248) 613-7591 to describe issue. Prior to replacing this part due to "Low Washer Fluid" message on the dash when the washer fluid bottle is full, please verify I101 48-way black ... Read More »
CONDENSER, Air Conditioning CONDITION 1: If it is determined that the A/C compressor does not engage due to a refrigerant leak at the receiver/drier plug on the A/C condenser, order the receiver/drier plug kit P/N 68447796A$ and follow ... Read More »
Compressor, A/C lines, A/C Condenser This issue pertains to PF, UF, and KL only.~ During service of the AC lines, Compressor or Condenser, do not stow any AC lines in proximity to any heat sources, or sharp edges. Read More »
Actuator- A/C Heater Before replacing this actuator call Matt Sasina at cell (248) 464-4982. If no response in 15 minutes, continue with repair. Read More »
Occupant Restraint Controller (ORC) For PF, KL or UF Vehicles ONLY: Prior to replacing ORC part numbers, please contact FCA engineering if ANY of the following Diagnostic trouble codes are Stored or Active in the ORC module: DTC: ... Read More »
Flash: Electronic Shift Module (ESM) Enhancement This bulletin involves updating the software in the Electronic Shift Module. The customer may experience an intermittent inability to shift into any gear range. Read More »
Restraints Remove I-Sheet from packaging. Correct information sheet (I-Sheet) has been added to Star Parts. Print I-Sheet for technician use. Read More »
Restraints Remove I-Sheet from packaging. Correct information sheet (I-Sheet) has been added to Star Parts. Print I-Sheet for technician use. Read More »
Occupant Restraint Controller (ORC) For PF, KL or UF Vehicles ONLY:~ Prior to replacing ORC part numbers, please contact FCA engineering if ANY of the following Diagnostic trouble codes are Stored or Active in the ORC module:~ DTC: ... Read More »
Occupant Restraint Controller (ORC) For PF, KL or UF Vehicles ONLY:~ Prior to replacing ORC part numbers, please contact FCA engineering if the following Diagnostic trouble codes are Stored or Active in the ORC module:~ DTC: B223D-00 ... Read More »
Occupant Restraint Controller (ORC) For PF, KL or UF Vehicles ONLY:~ Prior to replacing ORC part numbers, please contact FCA engineering if the following Diagnostic trouble codes are Stored or Active in the ORC module:~ DTC: B223D-00 - ... Read More »
Key Codes Recorded Incorrectly This bulletin involves replacing the lock cylinders. The dealer is unable to obtain the proper key code for the vehicle. Read More »
STAR Center News No. 78 - Jan/Feb 2013: Instead of limiting the use of the tether anchor to 48 pounds (child weight) the new guideline states that the tether anchor can be used with a seatbelt to install a child restraint up to the ... Read More »
STAR Center News No. 78 - Jan/Feb 2013: Instead of limiting the use of the tether anchor to 48 pounds (child weight) the new guideline states that the tether anchor can be used with a seatbelt to install a child restraint up to the ... Read More »
Intermittent Seat Belt Chime And Seat Belt Indicator Lamp On This bulletin involves replacing both right and left front seatbelt buckle covers. Read More »
Belt Tensioner Noise During Cold Start This bulletin involves replacing the belt tensioner. The customer may describe a loud high frequency noise that happens within 20 seconds of engine startup and lasts about 90 seconds ... Read More »
Aluminum Body Panel Corrosion Repair Aluminum corrosion or bubbling along the leading edge of hood, hinges or other exterior surface areas of the hinges, doors, fenders, swing gates or liftgates. Read More »
Aluminum Body Panel Corrosion Repair Aluminum corrosion or bubbling along the leading edge of hood, hinges or other exterior surface areas of the hinges, doors, fenders, swing gates or liftgates. Read More »
Aluminum Body Panel Corrosion Repair Aluminum corrosion or bubbling along the leading edge of hood, hinges or other exterior surface areas of the hinges, doors, fenders, swing gates or liftgates. Read More »
Approved Use of Weld Through Primers This bulletin documents the FCA US LLC position regarding the use of weld through primer when using Squeeze Type Resistance Spot Welding (STRSW) and Gas Metal Arc Welding (GMAW) processes when ... Read More »
Approved Use of Weld Through Primers This bulletin documents the FCA US LLC position regarding the use of weld through primer when using Squeeze Type Resistance Spot Welding (STRSW) and Gas Metal Arc Welding (GMAW) processes when ... Read More »
Approved Use of Weld Through Primers This bulletin documents the FCA US LLC position regarding the use of weld through primer when using Squeeze Type Resistance Spot Welding (STRSW) and Gas Metal Arc Welding (GMAW) processes when ... Read More »
Aluminum Body Panel Corrosion Repair This bulletin involves inspecting and if necessary removing corrosion and refinishingthe suspect aluminum panels on the vehicle, hood, door, fenders, hinges, swing gates or liftgate panels. Read More »
Aluminum Body Panel Corrosion Repair This bulletin involves inspecting and if necessary removing corrosion and refinishingthe suspect aluminum panels on the vehicle, hood, door, fenders, hinges, swing gates or liftgate panels. Read More »
Repair Parts Used For Structural Repairs This bulletin involves discussing FCA US LLC position with regard to structural repair parts usage. Read More »
Use of Aftermarket Parts This bulletin involves discussing FCA US LLC position with regard to collision repair industry awareness regarding the use of aftermarket parts. Read More »
Repair Parts Used For Structural Repairs This bulletin involves discussing FCA US LLC position with regard to structural repair parts usage. Read More »
Use of Aftermarket Parts This bulletin involves discussing FCA US LLC position with regard to collision repair industry awareness regarding the use of aftermarket parts. Read More »
Use of Salvage/Recycled Parts This bulletin involves discussing FCA US LLC position with regard to collision repair industry awareness regarding the use of recycled or salvage parts. Read More »
Flash: Powertrain Diagnostic and System Improvements This bulletin involves reprogramming the Powertrain Control Module (PCM) with the latest available software. Read More »
Water In Either Left Or Right Front Floor Footwells This bulletin involves correcting a sealant void between the cowl plenum lower panel and dash crossmember. Read More »
Flash: 2.4L Powertrain Diagnostic and System Improvements This bulletin involves reprogramming the Powertrain Control Module (PCM) with the latest available software. Read More »
Flash: 2.4L Powertrain Diagnostic and System Improvements This bulletin involves reprogramming the Powertrain Control Module (PCM) with the latest available software. Read More »
Flash: 2.4L Powertrain Diagnostic and System Improvements This bulletin involves reprogramming the Powertrain Control Module (PCM) with the latest available software. Read More »
Flash: 2.4L Powertrain Diagnostic and System Improvements This bulletin involves reprogramming the Powertrain Control Module (PCM) with the latest available software. Read More »
Flash: 2.4L Powertrain Diagnostic and System Improvements This bulletin involves reprogramming the Powertrain Control Module (PCM) with the latest available software. Read More »
Active Grill Shutter (AGS): This GPOP applies to all 2014 - 2016 KL & 2015 - 2016 UF vehicles. Prior to replacing an Active Grille Shutter (AGS) for DTC code U11E9 (Loss of Communication), please contact Tom Hallahan at cell (248) 494 ... Read More »
Flash: 2.4L Powertrain Diagnostic and System Improvements This bulletin involves reprogramming the Powertrain Control Module (PCM) with the latest available software. Read More »
Active Grill Shutter (AGS) This GPOP applies to all 2014 - 2016 KL & 2015 - 2016 UF vehicles. Prior to replacing an Active Grille Shutter (AGS) for DTC code U11E9 (Loss of Communication), please contact Stephen Koch at cell (248) ... Read More »
Flash: 2.4L Powertrain Diagnostic and System Improvements This bulletin involves reprogramming the Powertrain Control Module (PCM) with the latest available software. Read More »
Flash: 2.4L Powertrain Diagnostic and System Improvements This bulletin involves reprogramming the Powertrain Control Module (PCM) with the latest available software. Read More »
Flash: Extended Engine Crank Time And Transmission Quick Learn Enable This bulletin involves selectively erasing and reprogramming the Powertrain Control Module (PCM) with new software. Read More »
Active Grill Shutter (AGS): This GPOP applies to all 2014 - 2016 KL & 2015 - 2016 UF vehicles. Prior to replacing an Active Grille Shutter (AGS) for DTC code U11E9 (Loss of Communication), please contact Tom Hallahan at cell (248) 494 ... Read More »
Active Grill Shutter (AGS): This GPOP applies to all 2014 - 2016 KL & 2015 - 2016 UF vehicles. Prior to replacing an Active Grille Shutter (AGS) for DTC code U11E9 (Loss of Communication), please contact Tom Hallahan at cell (248) 494 ... Read More »
Door Hinge Assembly Side door hinge noisy. Only replace the door hinge with the integral check device. Do not replace the simple hinge if it is not damaged it is not the source of the noise. Replacing it unnecessary and is an over-repair. Read More »
Door Hinge Assembly Side door hinge noisy. Only replace the door hinge with the integral check device. Do not replace the simple hinge if it is not damaged it is not the source of the noise. Read More »
Approved Use of Weld Through Primers This bulletin documents the FCA US LLC position regarding the use of weld through primer when using Squeeze Type Resistance Spot Welding (STRSW) and Gas Metal Arc Welding (GMAW) processes when ... Read More »
Part Description: Accelerator Pedal Issue Description: Vehicle has accelerator pedal fault code. Before replacing accelerator pedal, be sure to follow fault code diagnostic procedures in service manual. Read More »
Part Description: Belly Pan Issue Description: Please do not replace the entire assembly for a broken oil drain door or broken oil filter access door. Instead, replace the respective parts: Oil Drain Door = 68248175AA. Read More »
Part Description: Belly Pan Issue Description: Please do not replace the entire assembly for a broken oil drain door or broken oil filter access door. Instead, replace the respective parts: Oil Drain Door = 68248175AA. Read More »
RA3 RA4 Radio Update To Improve Back Up Camera Display, Remote Audio Device Distortion, And WiFi Connectivity This bulletin involves inspecting and, if required, updating the radio software. Read More »
Accelerator Pedal Before replacing accelerator pedal, be sure to follow fault code diagnostic procedures in service manual. Make sure to check wiring and connectors. Read More »
Accelerator Pedal Before replacing accelerator pedal, be sure to follow fault code diagnostic procedures in service manual. Make sure to check wiring and connectors. Read More »
Part Description: Accelerator Pedal Issue Description: Vehicle has accelerator pedal fault code. Before replacing accelerator pedal, be sure to follow fault code diagnostic procedures in service manual. Read More »
Adaptive Cruise Control Sensor 1) If you are replacing this part due to the cluster displaying Clean Radar Sensor in Front of Vehicle or DTC C1266 ACC Sensor Blinded, please verify that there is no blockage in front of the sensor. Read More »
Tire Noise Or Vibration On Smooth Road Surface. This bulletin provides information regarding inspecting the tire DOT range and mold numbers. Read More »
Pentastar Oil Filter Adapter All vehicles equipped with a 3.2L or 3.6L engine; If replacing the Oil Filter Adapter (OFA) due to a leak detected between OFA and block. Ensure the torque on the 5 (OFA) bolts are torqued to 12nm. Read More »
Oil Filter If a Mopar Oil Filter is not available, use a filter that meets or exceeds USCAR36 specification and is compatible with semi and full synthetic oils. Read More »
Airbag Warning Lamp (AWL) Illuminated B0028-13 and B0020-13 This bulletin involves inspecting and installing a jumper harness in the front seats if needed. Customers may experience a AWL illumination. Read More »
Airbag Warning Lamp (AWL) Illuminated B0028-13 and B0020-13 This bulletin involves inspecting and installing a jumper harness in the front seats if needed. Customers may experience a AWL illumination. Read More »
Occupant Restraint Controller (ORC) For PF, KL or UF Vehicles ONLY:~ Prior to replacing ORC part numbers, please contact FCA engineering if the following Diagnostic trouble codes are Stored or Active in the ORC module:~ DTC: B223D-00 ... Read More »
"FRONT SEAT BOTTOM CUSHION HARD OR LUMPY SPOT THIS BULLETIN INVOLVES REPLACING THE SEAT CUSHION, HEATED PADS, HEATED SEAT MODULE, VENTILATED SEAT PAD AND OCCUPANT CLASSIFICATION MODULE. Read More »
Front Seat Bottom Cushion Hard Or Lumpy Spot This bulletin involves replacing both seat cushion heated pads and heated seat module then reconfiguring the vehicle. Read More »
Front Seat Bottom Cushion Hard Or Lumpy Spot This bulletin involves replacing both seat cushion heated pads and heated seat module then reconfiguring the vehicle. Read More »
Start Stop Charging Warning Lamp Illuminated On, Intelligent Battery Sensor (IBS) State of Charge (SOC) Inaccurate, Battery Charging Message, Presence of IBS related Diagnostic Trouble Codes (DTCs), or Battery Warning Lamp ... Read More »
Airbag Warning Lamp (AWL) Illuminated B0028-13 and B0020-13 This bulletin involves inspecting and installing a jumper harness in the front seats if needed. Customers may experience a AWL illumination. Read More »
ADAPTER, Engine Oil Filter (Pentastar V6) For all 2014MY replace the Oil Filter Adapter (OFA). For any other MY (with mileage above 30,000) review and follow instructions from STAR Online S1809000007 REV. C available on Dealer Connect. Read More »
Start Stop Charging Warning Lamp Illuminated On, Intelligent Battery Sensor (IBS) State of Charge (SOC) Inaccurate, Battery Charging Message, Presence of IBS related Diagnostic Trouble Codes (DTCs), or Battery Warning Lamp ... Read More »
Valve Cover and Gasket, Left and Right Pertains to vehicles equipped with a 3.6L V6 V.V.T. Engine only: Oil leaking from the valve cover onto the O2 sensor causing faults codes P0140, P2096, P0137, P0157. Read More »
Flash: Transmission Diagnostic and Shift Enhancements This bulletin involves reprogramming the Transmission Control Module (TCM) withthe latest available software. Read More »
Flash: Powertrain Diagnostic and System Improvements This bulletin involves reprogramming the Powertrain Control Module (PCM) with the latest available software. Read More »
Flash: 2.4L Powertrain Diagnostic and System Improvements This bulletin involves reprogramming the Powertrain Control Module (PCM) with the latest available software. Read More »
Flash: 2.4L Powertrain Diagnostic and System Improvements This bulletin involves reprogramming the Powertrain Control Module (PCM) with the latest available software. Read More »
Flash: 2.4L Powertrain Diagnostic and System Improvements This bulletin involves reprogramming the Powertrain Control Module (PCM) with the latest available software. Read More »
Flash: 2.4L Powertrain Diagnostic and System Improvements This bulletin involves reprogramming the Powertrain Control Module (PCM) with the latest available software. Read More »
Flash: 2.4L Powertrain Diagnostic and System Improvements This bulletin involves reprogramming the Powertrain Control Module (PCM) with the latest available software. Read More »
Flash: 2.4L Powertrain Diagnostic and System Improvements This bulletin involves reprogramming the Powertrain Control Module (PCM) with the latest available software. Read More »
Flash: Transmission Diagnostic And Shift Enhancements. This bulletin involves reprogramming the Transmission Control Module (TCM) with the latest available software. Read More »
Flash: 2.4L Powertrain Diagnostic and System Improvements This bulletin involves reprogramming the Powertrain Control Module (PCM) with the latest available software. Read More »
Flash: Transmission Diagnostic And Shift Enhancements This bulletin involves reprogramming the Transmission Control Module (TCM) with the latest available software. Read More »
Flash: Transmission Diagnostic And Shift Enhancements This bulletin involves reprogramming the Transmission Control Module (TCM) with the latest available software. Read More »
Rear Brake Squeal Noise In Reverse This bulletin involves replacing the rear brake pads. The customer may describe a squeal noise from the rear brakes. Noise is only present during the first few brake applies in reverse. Read More »
Rear Brake Squeal Noise In Reverse This bulletin involves replacing the rear brake pads. The customer may describe a squeal noise from the rear brakes. Noise is only present during the first few brake applies in reverse. Read More »
RA3 RA4 Radio Update To Improve Back Up Camera Display, Remote Audio Device Distortion, And WiFi Connectivity This bulletin involves inspecting and, if required, updating the radio software. Read More »
If a Mopar oil filter is not available, use a filter that meets or exceeds USCAR36 specification and is compatible with semi and full synthetic oils. Read More »
Airbag Warning Lamp (AWL) Illuminated B0028-13 and B0020-13 This bulletin involves inspecting and installing a jumper harness in the front seats if needed. Customers may experience a AWL illumination. Read More »
Charging System, Battery Diagnostic Tools and Warranty This information only bulletin discusses using the correct test equipment for testing batteries and charging systems, and also warranty reimbursement when battery replacements are ... Read More »
2.4L Ignition Coil Boot Replacement This bulletin involves replacing all four ignition coil insulating boots. Customers may experience a Malfunction Indicator Lamp (MIL) illumination. Read More »
2.4L Ignition Coil Boot Replacement This bulletin involves replacing all four ignition coil insulating boots. Customers may experience a Malfunction Indicator Lamp (MIL) illumination. Read More »
Use of Salvage/Recycled Parts This bulletin involves discussing FCA US LLC position with regard to collision repair industry awareness regarding the use of recycled or salvage parts. Read More »
Use of Aftermarket Parts This bulletin involves discussing FCA US LLC position with regard to collision repair industry awareness regarding the use of aftermarket parts. Read More »
Repair Parts Used For Structural Repairs This bulletin involves discussing FCA US LLC position with regard to structural repair parts usage. Read More »
RADIO, MULTI Media For RA3 and RA4 8.4? radio concern of reoccurring update request pop-up on each key cycle after a radio FOTA (Firmware Update Over the Air) has been completed, please DO NOT replace the radio. Read More »
Flash Over The Air (FOTA) Software Update RA3 and RA4 Radio This bulletin provides information regarding the latest Flash Over The Air (FOTA) update and provides the service technician an overview of the steps a customer will need to ... Read More »
RADIO [RES] - New and/or Service Exchange For RES radio concerns. Use the wiTECH 2.0 and inspect the radio part number and serial number under the Radio/ECU Details tab. Read More »
RA3 and RA4 Radio Over The Air Software Updates This bulletin provides information regarding the latest Flash Over The Air (FOTA) update and provides the service technician an overview of the steps a customer will need to take to ... Read More »
RA3 And RA4 Radio Over The Air Software Updates This bulletin provides information regarding the latest Flash Over The Air update (FOTA) and provides a service technician an overview of the steps a customer will need to take to complete ... Read More »
Inspect and Return: Trim Cover Assy - A-Pillar Rt/Lt You have been identified as either having stock, or have stock in transit to your dealership. Please return suspect stock of part numbers: 1ZA04DX9AE, 1ZA05DX9AE. Read More »
05182535AD - Lamp Assy ?Tail Light LT You have been identified as either having stock, or have stock in transit to your dealership. Please return suspect stock of part number 05182535AD . See attachments for identifying suspect stock. Read More »
CBXDP361AA Return: Spacer Kit - Visor You have been identified as either having stock, or have stock in transit to your dealership. Please return stock of part number CBXDP361AA. Read More »
Occupant Restraint Controller (ORC) For PF, KL or UF Vehicles ONLY:~ Prior to replacing ORC part numbers, please contact FCA engineering if the following Diagnostic trouble codes are Stored or Active in the ORC module:~ DTC: B223D-00 - ... Read More »
Pentastar Oil Filter Adapter: Before replacing this part, please call any one of the following people. Engineering is seeking information regarding this part.~ Dye must be used to determine where the leak is coming from before replacing. Read More »
Rear trailing arm/link. Customer noise issue due to loose trailing link If a trailing link is damaged or noisy, please call Steve Lin at Cell 909-569-5117 prior to removing the part. Read More »
RES / RHA / REB radio that supports Bluetooth and Hands-Free For issues with Bluetooth, Hands-Free Calling, and/or Voice Commands, DO NOT replace the radio. Diagnose the Hands-Free Module system (also called the Telematics Module). Read More »
RES / RHA / REB radio that supports Bluetooth and Hands-Free For issues with Bluetooth, Hands-Free Calling, and/or Voice Commands, DO NOT replace the radio. Diagnose the Hands-Free Module system (also called the Telematics Module). Read More »
A/C Compressor This applies to 2015 and 2016 UF models ONLY. Before replacing the AC compressor for noise or in-op:~ 1) Check all AC plumbing connection for leaks with UV light. Read More »
Part Description: Motor, Sunroof Issue Description: If looking to replace the sunroof motor and these conditions are occurring:~ 1) Vent switch does not work. Read More »
FLASH: ABS Module Enhancements This bulletin involves updating the ABS Module software. New software is available to optimize Advanced Brake Assist (ABA) performance in low tractions situations. Read More »
948TE 9 Speed Transmission Quick Learn Procedure This bulletin provides information on how to perform the new scan tool based transmission Quick Learn procedure. Read More »
Flash: Transmission Diagnostic And Shift Enhancements This bulletin involves reprogramming the Transmission Control Module (TCM) with the latest available software. Read More »
Inside Rear View Mirror Without Assist And 911 Buttons This bulletin involves inspecting the inside rear view mirror for Assist and 911 buttons and replacing the mirror if the buttons are not there. Read More »
Unable To Register With Uconnect This bulletin involves retrieving MDN and MEID numbers from the radio. Creating a Star case and recording the MDN and MEID with in the Star Case. Read More »
CUSTOMERS MAY EXPERIENCE A MALFUNCTION INDICATOR LAMP ILLUMINATION. POWER CONTROL MODULE REQUIRES REPROGRAMMING WITH LATEST SOFTWARE AVAILABLE *CN UPDATED 12/21/15 *CN Read More »
Flash: 2.4L Powertrain Diagnostic and System Improvements This bulletin involves reprogramming the Powertrain Control Module (PCM) with the latest available software. Read More »
RA2 Radio Software Enhancements This bulletin involves updating the radio's software or replacing the radio if required. A customer may notice one or more of the following: ? Radio may reset if muted after vehicle is started. Read More »
RA3 RA4 Radio Enhancements This bulletin involves inspecting and if required, updating the radio software. A customers may experience one or more of the following: ? Rearview Camera image appears jittery. Read More »
Key Codes Recorded Incorrectly This bulletin involves replacing the lock cylinders. The dealer is unable to obtain the proper key code for the vehicle. Read More »
Incorrect Bolt Length Used For Fastening Transmission To Engine This bulletin involves replacing 2 bolts used to fasten the transmission to the engine. Read More »
RA2 Radio Software Enhancements This bulletin involves updating the radio's software or replacing the radio if required. A customer may notice one or more of the following: ? Radio display screen may be locked. Read More »
Flash: 2.4L Powertrain Diagnostic and System Improvements This bulletin involves reprogramming the Powertrain Control Module (PCM) with the latest available software. Read More »
Part Description: Belly Pan Issue Description: Please do not replace the entire assembly for a broken oil drain door or broken oil filter access door. Instead, replace the respective parts: Oil Drain Door = 68248175AA. Read More »
RA3 RA4 Radio Enhancements This bulletin involves inspecting and, if required, updating the radio software. A customers may experience one or more of the following: Rearview Camera image appears jittery. Read More »
Part Description: Engine Cover Issue Description: The Chrysler 200 LX (Model UFCE41) is the only model in the 200 Family built without an engine cover. Please do not order this part as a shortage and error on this model. Read More »
RA3 RA4 Radio Update To Improve Back Up Camera Display, Remote Audio Device Distortion, And WiFi Connectivity This bulletin involves inspecting and, if required, updating the radio software. Read More »
STAR Center News No. 78 - Jan/Feb 2013: Instead of limiting the use of the tether anchor to 48 pounds (child weight) the new guideline states that the tether anchor can be used with a seatbelt to install a child restraint up to the ... Read More »
This bulletin provides information regarding the latest Flash Over The Air update (FOTA) and provides a service technician an overview of the steps a customer will need to take to complete the update. Read More »
RES / RHA / REB radio that supports Bluetooth and Hands-Free For issues with Bluetooth, Hands-Free Calling, and/or Voice Commands, DO NOT replace the radio. Diagnose the Hands-Free Module system (also called the Telematics Module). Read More »
RES / RHA / REB radio that supports Bluetooth and Hands-Free For issues with Bluetooth, Hands-Free Calling, and/or Voice Commands, DO NOT replace the radio. Diagnose the Hands-Free Module system (also called the Telematics Module). Read More »
Unable To Register With Uconnect This bulletin involves retrieving MDN and MEID numbers from the radio. Creating a Star case and recording the MDN and MEID with in the Star Case. Read More »
Proxi Issue After Mopar Accessory Remote Start Has Been Installed Technician may experiences a proxi issue after a Mopar accessory remote start has been installed. Read More »
Part Description: Heated Backlight Issue Description: By design, the upper 12 inches of the backlight does not defrost on vehicles built prior to MDH 121500. Read More »
Part Description: Heated Backlight Issue Description: By design, the upper 12 inches of the backlight does not defrost on vehicles built prior to MDH 121500. Read More »
RADIO [RES] - New and/or Service Exchange For RES radio concerns. Use the wiTECH 2.0 and inspect the radio part number and serial number under the Radio/ECU Details tab. Read More »
RA3 and RA4 Radio Over The Air Software Updates This bulletin provides information regarding the latest Flash Over The Air (FOTA) update and provides the service technician an overview of the steps a customer will need to take to ... Read More »
RA3 And RA4 Radio Over The Air Software Updates This bulletin provides information regarding the latest Flash Over The Air update (FOTA) and provides a service technician an overview of the steps a customer will need to take to complete ... Read More »
RES / RHA / REB radio that supports Bluetooth and Hands-Free For issues with Bluetooth, Hands-Free Calling, and/or Voice Commands, DO NOT replace the radio. Diagnose the Hands-Free Module system (also called the Telematics Module). Read More »
Unable To Register With Uconnect This bulletin involves retrieving MDN and MEID numbers from the radio. Creating a Star case and recording the MDN and MEID with in the Star Case. Read More »
CHRYSLER: ON CERTAIN VEHICLES, THERE ARE VARIOUS ISSUES INVOLVING THE RADIO AND NAVIGATIONAL SYSTEM FAILS TO WORK PROPERLY AND THE SOFTWARE NEEDS TO BE UPDATED. MODEL 2015 CHRYSLER 200. Read More »
RA3 RA4 Radio Enhancements This bulletin involves inspecting and if required, updating the radio software. A customers may experience one or more of the following: ? Rearview Camera image appears jittery. Read More »
RA3 RA4 Radio Enhancements This bulletin involves inspecting and, if required, updating the radio software. A customers may experience one or more of the following: Rearview Camera image appears jittery. Read More »
RA2 Radio Software Enhancements This bulletin involves updating the radio's software or replacing the radio if required. A customer may notice one of more of the following: Radio display screen may be locked. Read More »
RES / RHA / REB radio that supports Bluetooth and Hands-Free For issues with Bluetooth, Hands-Free Calling, and/or Voice Commands, DO NOT replace the radio. Diagnose the Hands-Free Module system (also called the Telematics Module). Read More »
Missing Navigation Feature This bulletin involves activating the navigation feature on an RA3 radio. NOTE: The customers or the dealers will not be charged for activating the navigation feature. Read More »
CHRYSLER: ON CERTAIN VEHICLES, THERE ARE VARIOUS ISSUES INVOLVING THE RADIO AND NAVIGATIONAL SYSTEM FAILS TO WORK PROPERLY AND THE SOFTWARE NEEDS TO BE UPDATED. MODEL 2015 CHRYSLER 200. Read More »
RES / RHA / REB Radios That Support Bluetooth and Hands-Free 1. For issues with Bluetooth, Hands-Free Calling, and/or Voice Commands; DO NOT replace the radio. Diagnose the Hands-Free Module system (also called the Telematics Module). Read More »
RA3 RA4 Radio Enhancements This bulletin involves inspecting and, if required, updating the radio software. A customers may experience one or more of the following: Rearview Camera image appears jittery. Read More »
RA3 RA4 Radio Enhancements This bulletin involves inspecting and, if required, updating the radio software. A customers may experience one or more of the following: Rearview Camera image appears jittery. Read More »
RES / RHA / REB Radios That Support Bluetooth and Hands-Free 1. For issues with Bluetooth, Hands-Free Calling, and/or Voice Commands; DO NOT replace the radio. Diagnose the Hands-Free Module system (also called the Telematics Module). Read More »
Replace Vehicle Emission Certification Information Label This bulletin involves replacing the Vehicle Emission Certification Information (VECI) Label. Read More »
Lubrication and Maintenance Fluids If MOPAR fluids and chemicals are not readily available, please review Service Library for specifications so a suitable alternative can be used Read More »
Electronic Shift Module If DTC's U11C3, U0074 are present Stored or Active, please contact Pemi Sabageh at cell (519) 300-0629 or David Dysarz at (248) 944-0310. Read More »
Replace Vehicle Emission Certification Information Label This bulletin involves replacing the Vehicle Emission Certification Information (VECI) Label. Read More »
948TE 9 Speed Transmission Quick Learn Procedure This bulletin provides information on how to perform the new scan tool based transmission Quick Learn procedure. Read More »
"PENTASTAR OIL FILTER ADAPTER BEFORE REPLACING THIS PART, PLEASE CALL ANY ONE OF THE FOLLOWING PEOPLE. ENGINEERING IS SEEKING INFORMATION REGARDING THIS PART.~ DYE MUST BE USED TO DETERMINE WHERE THE LEAK IS COMING FROM BEFORE REPLACING. Read More »
Flash: Transmission Diagnostic And Shift Enhancements This bulletin involves reprogramming the Transmission Control Module (TCM) with new software. Read More »
Service Bulletin/RRT 21-001-15/15-003 Superseded By Customer Satisfaction Notification (CSN) R01 Refer to service procedures outlined in CSN R01. Read More »
Service Bulletin/RRT 21-001-15/15-003 Superseded By Customer Satisfaction Notification (CSN) R01 Refer to service procedures outlined in CSN R01. Read More »
Service Bulletin/RRT 21-001-15/15-003 Superseded By Customer Satisfaction Notification (CSN) R01 Refer to service procedures outlined in CSN R01. Read More »
Service Bulletin/RRT 21-029-14/14-076 Superseded By Customer Satisfaction Notification (CSN) P56 Refer to service procedures outlined in CSN P56. Read More »
82212076, 82203694 - Fabric Cleaner This "fabric cleaner" is not intended for sale in California, the otc states (Connecticut, Delaware, Massachusetts, Maine, New Hampshire, New Jersey, New York, Pennsylvania, Virginia, and Washington ... Read More »
Airbag Warning Lamp (AWL) Illuminated B0028-13 and B0020-13 This bulletin involves inspecting and installing a jumper harness in the front seats if needed. Customers may experience a AWL illumination. Read More »
Part Description: Motor, Sunroof Issue Description: If looking to replace the sunroof motor and these conditions are occurring:~ 1) Vent switch does not work. Read More »
948TE 9 Speed Transmission Quick Learn Procedure This bulletin provides information on how to perform the new scan tool based transmission Quick Learn procedure. Read More »
Flash: Transmission Diagnostic And Shift Enhancements This bulletin involves reprogramming the Transmission Control Module (TCM) with the latest available software. Read More »
Incorrect Bolt Length Used For Fastening Transmission To Engine This bulletin involves replacing 2 bolts used to fasten the transmission to the engine. Read More »
RA2 Radio Software Enhancements This bulletin involves updating the radio's software or replacing the radio if required. A customer may notice one or more of the following: ? Radio display screen may be locked. Read More »
Part Description: Belly Pan Issue Description: Please do not replace the entire assembly for a broken oil drain door or broken oil filter access door. Instead, replace the respective parts: Oil Drain Door = 68248175AA. Read More »
Steering System Inspection After a Collision This bulletin documents the FCA US LLC position regarding conditions under which replacement or repair of steering system components are required. Read More »
CONDENSER, Air Conditioning CONDITION 1: If it is determined that the A/C compressor does not engage due to a refrigerant leak at the receiver/drier plug on the A/C condenser, order the receiver/drier plug kit P/N 68447796A$ and follow ... Read More »
Actuator- A/C Heater Before replacing this actuator call Matt Sasina at cell (248) 464-4982. If no response in 15 minutes, continue with repair. Read More »
Flash: 2.4L Powertrain Diagnostic and System Improvements This bulletin involves reprogramming the Powertrain Control Module (PCM) with the latest available software. Read More »
STAR Center News No. 78 - Jan/Feb 2013: Instead of limiting the use of the tether anchor to 48 pounds (child weight) the new guideline states that the tether anchor can be used with a seatbelt to install a child restraint up to the ... Read More »
2.4L Excessive Oil Consumption XB1 Warranty Extension The customer may describe one or more of the following: ? Oil pressure low indicator lamp illumination between oil changes. ? Excessive oil consumption. Read More »
Approved Use of Weld Through Primers This bulletin documents the FCA US LLC position regarding the use of weld through primer when using Squeeze Type Resistance Spot Welding (STRSW) and Gas Metal Arc Welding (GMAW) processes when ... Read More »
