Technical Service Bulletins (TSBs) for the 2007 X5 are official communications between BMW & their dealerships that describe processes for troubleshooting or fixing certain common problems.
All vehicle manufacturers are required by U.S. law to make their TSBs available to the public.
CRACKING NOISES FROM THE FRONT AXLE AREA WHILE TURNING THE WHEELS, WHEN STATIONARY OR PARKING: Cracking noises are heard from the front axle area while maneuvering at low speeds (e.g. Read More »
This Service Information bulletin supersedes SI B07 03 14 dated October 2015. Diagnosing Stored Fault Codes to Help Avoid Repeat Repair Visits. Read More »
"Squeaking Noises from Steering Wheel While Turning. There is a squeaking noise from the steering column when the steering wheel is turned. Read More »
Cracking noises are heard from the front axle area while maneuvering at low speeds (e.g., parking lot maneuvers) or when turning the steering wheel while stationary. Read More »
CRACKING NOISES FROM THE FRONTAXLE AREA WHILE TURNING THE WHEELS, WHEN STATION: Cracking noises are heard from the front axle area while maneuvering at low speeds (e.g. Read More »
Clicking Noise from Front Axle. Clicking noises are heard from the front axle area while maneuvering at low speeds (e.g., parking lot maneuvers). Read More »
"Squeaking Noises from Steering Wheel While Turning. There is a squeaking noise from the steering column when the steering wheel is turned. Read More »
CLICKING NOISE FROM FRONT AXLE This Service Information bulletin supersedes SI 31 01 12 dated June 2015. Clicking noises are heard from the front axle area while maneuvering at low speeds (e.g., parking lot maneuvers). Read More »
"REPAIRING TRANSFER CASE ACTUATOR (VTG SERVO-MOTOR). The Anti-lock Brakes (ABS), Brakes and Dynamic Stability Control (DSC) warnings are on and there may also be a ""Drivetrain Malfunction"" warning on in the Control Display. Read More »
"PARKING BRAKE DOES NOT WORK. Parking brake (EMF) sporadically or permanently fails to engage. Check Control Message (CCM) ""Parking brake failed"" is displayed. Read More »
This bulletin outlines the procedure for checking the engine timing chains for wear, and should be completed in conjunction with SI B11 06 14, "N63 Customer Care Package. Read More »
"Power Reduction, FC 2A82 Intake VANOS and/or FC 2A87 Exhaust VANOS Camshaft Faults are Stored in DME. The ""Service Engine Soon"" (MIL) lamp is illuminated and engine power reduction is perceived. Read More »
N63 ENGINE: OIL CONSUMPTION CLASS ACTION SETTLEMENT DIAGNOSIS AND REPAIR PROCEDURES. While engine oil consumption may create a customer inconvenience in the short term it should not cause any drivability problems that would prevent normal ... Read More »
N63 AND N63T ENGINE: ENGINE OIL CONSUMPTION, ENGINE OIL TOP-UPS AND REFILL CAPACITY. Customers with one of the vehicles above may complain that the engine's oil consumption is "too high," resulting in engine oil top-ups and workshop ... Read More »
"?N63, N63TU, N63R, S63 AND S63TU ENGINES: UPPER OIL PAN REMOVAL AND INSTALLATION REPAIR INSTRUCTIONS This Service Information bulletin supersedes SI B11 17 15 dated October 2016. . Read More »
"? DIESEL PARTICULATE FILTER (DPF) CLEANING . The following performance issues may be noticed by the customer: CC-Message ""Drive faulty"" Engine jerking or a lack of power over the whole engine speed range Malfunction indicator lamp ... Read More »
"? NO REGENERATION OF THE DIESEL PARTICULATE FILTER (DPF) This Service Information bulletin supersedes SI B18 03 10 dated November 2010. . The Service Engine Soon lamp is illuminated. Read More »
Service Action: S63 Engine - Check and Replace High- Pressure Injectors This Service Information bulletin supersedes SI B13 08 15 dated January 2016. Read More »
N51, N52, N52K and N52T Engines: Various Eccentric Shaft Sensor Faults stored in the DME - Diagnostic Hints This Service Information bulletin and attachment supersedes SI B11 06 16 dated April 2016.. Read More »
"N63, N63TU and N63R Engines: Upper Oil Pan Removal and Installation Repair Instructions This Service Information bulletin supersedes SI B11 17 15 dated August 2015.. Read More »
This Service Information bulletin supersedes SI B07 03 14 dated October 2015. Diagnosing Stored Fault Codes to Help Avoid Repeat Repair Visits. Read More »
SUBJECT DME Internal and Valvetronic Faults Set at Cold Ambient Temperatures. The Service Engine Soon light (MIL) can be illuminated with the erroneous internal and Valvetronic faults stored in the DME. Read More »
"SUBJECT N62TU: ISTA Service Function for DME ""RAM Backup"". The ISTA Service Function test plan should be performed to clear stored values in the DME RAM memory after repairs are completed, in the following situations: z VANOS or ... Read More »
"SUBJECT N63: CBS Oil Service Conversion in ISTA/P. The CBS oil service conversion being performed for the N63 Customer Car Package and timing chain check (SI B11 16 14) does not work correctly. Read More »
Engine Damage Due to Debris in Oil Passages. After performing extensive engine repairs (e.g., cylinder head removal), the engine begins to knock and may lose power. Read More »
N52T / N55 with 8HP45: Delay in Engine Response. A customer may complain of a delay in engine response after decelerating at low road speeds and then reaccelerating. Read More »
N63 and S63 Engine: High-pressure Fuel Injector Replacement Procedures. The customer complains that one of the following scenarios has been encountered while operating the vehicle: * During a cold start in the morning, the engine runs ... Read More »
A customer may complain of a delay in engine response after decelerating at low road speeds and then reaccelerating. This can occur when the transmission remains in a high gear due to a delay in the transmission downshifting. Read More »
N63 and S63 Engine: High-pressure Fuel Injector Replacement Procedures. The customer complains that one of the following scenarios has been encountered while operating the vehicle: * During a cold start in the morning, the engine runs ... Read More »
Intermittent Hydraulic Valve Adjuster (HVA) Noise. An occasional ticking or rattling noise from the camshaft hydraulic valve lifters (HVA) may occur during cold engine starts, due to frequent short-distance driving, or the noise may occur ... Read More »
N55 Engine Failsafe - FC 120308 Boost Pressure Control, Plausibility: Pressure Too Low Stored in DME Fault Memory. INFORMATION The customer complains the SES is illuminated and the engine has reduced power (engine failsafe mode). Read More »
N63 and S63 Engine: High-pressure Fuel Injector Replacement Procedures. The customer complains that one of the following scenarios has been encountered while operating the vehicle: * During a cold start in the morning, the engine runs ... Read More »
N55 - Delayed Throttle Response When Driving Off. Delayed throttle response when driving off with a high engine load This problem occurs mainly under the following conditions: * High ambient outside temperatures * The air conditioning is ... Read More »
BMW: WHILE DRIVING VEHICLE, AT TIMES WOULD BE ROUGH RUNNING; WHITE OR BLUE SMOKE SEEN EXITING EXHAUST SYSTEM AND THE ENGINE OIL IS CONSUMED ABOVE SPECIFICATIONS. *PE UPDATED 1/11/13. *PE Read More »
BMW: FUEL GAUGE SHOWS 3/4 FULL AFTER REFUELING DUE TO INTERNAL MECHANISMS OF FUEL LEVEL SENSORS, WITH A HIGH PROPORTION OF ETHANOL, SWELLING AND INHIBIT, ONE OR BOTH, MOVEMENT OF FUEL LEVEL SENSORS. MODEL 2007-2009 E70, E71. Read More »
BMW: DUE TO DAMAGED SEAL RING, DURING ASSEMBLY, ENGINE OIL IS LEAKING FROM ENGINE OIL PUMP VOLUME CONTROL VALVE GASKET SEAL RING. MODELS E70, E71, F01, F02, F04, F07, F10, F12, F13. NO MODEL YEARS LISTED. Read More »
Coolant is leaking from under the car which is equipped with the S63 engine. A low coolant warning might also be displayed (CC Message ID166). Read More »
This bulletin outlines the procedure for checking the engine timing chains for wear, and should be completed in conjunction with SI B11 06 14, "N63 Customer Care Package. Read More »
CLASS ACTION SETTLEMENT: N54/N54T/N55 ELECTRIC ENGINE COOLANT PUMP . With the court's FINAL approval, BMW of North America, LLC (BMW NA) has entered a nationwide settlement with the plaintiffs in the following class action: Oliver, et al v. Read More »
CLASS ACTION SETTLEMENT: N54/N54T/N55 ELECTRIC ENGINE COOLANT PUMP . With the court's FINAL approval, BMW of North America, LLC (BMW NA) has entered a nationwide settlement with the plaintiffs in the following class action: Oliver, et al v. Read More »
Power Reduction, FC2A82 Intake VANOS and/or FC2A87 Exhaust VANOS Camshaft Fault: The ?Service Engine Soon? (MIL) lamp is illuminated and engine power reduction is perceived. Read More »
N63 Engine: Oil Consumption and/or Rough Running Complaints. The vehicle may consume engine oil above the permissible specification, and may run rough at times. White or blue smoke may also be seen exiting the exhaust system. Read More »
N20, N26, N55, N63TU, S63TU and S55 Engines: Bosch Injector ETK Part Number Error What's New: ? Procedure change: indentifying injector type using an ISTA test plan. . Read More »
N63 and S63 Engine: High-pressure Fuel Injector Replacement Procedures. The customer complains that one of the following scenarios has been encountered while operating the vehicle: ? During a cold start in the morning, the engine runs ... Read More »
External Engine Oil Leaks and Repairs. During the vehicle's operational life, normal engine oil seepage or sweating, in addition to accumulated road dust, dirt and grime in the engine compartment can cause the appearance of a more severe ... Read More »
N63T Engine: New Test Plan to Check Engine Oil Level with ISTA/D 3.39.21. INFORMATION With the release of ISTA/D 3.39.21, a new test plan is available for checking the engine oil level in some vehicles with the N63T engine. Read More »
MService Action: Replace the Coolant Pump. Coolant is leaking from the coolant pump. CAUSE The coolant pump may develop cracks in the plastic housing. These cracks may result in a coolant leak. Read More »
BMW VEHICLE: THE SERVICE ENGINE SOON (MIL) LAMP IS ILLUMINATED AND A POWER REDUCTION IS CLEARLY PERCEPTIBLE. THIS SITUATION MAY OCCUR AFTER DRIVING FOR SOME TIME WITH THE ENGINE ALREADY AT FULL OPERATING TEMPERATURE. Read More »
BMW: COMPLAINT OF A DELAYED ENGAGEMENT AND A HARSH JOLT WHEN ACCELERATING FROM A STOP. THE SITUATION OCCURS ONLY DURING THE ENGINE WARM UP PHASE (COLD ENGINE), AND CANNOT BE REPRODUCED IN THE SPORT MODE. Read More »
BMW VEHICLE: WATER HAS ENTERED ELECTRONICS BOX BECAUSE THE LID IS NOT PROPERLY FITTED. ONCE IT IS VERIFIED THAT WATER HAS INDEED ENTERED THE ELECTRONICS BOX, IT WILL BE NECESSARY TO REPLACE BOTH THE LOWER PART OF THE ELECTRONICS BOX AND ... Read More »
BMW: SIX DIFFERENT MODELS EQUIPPED WITH THE M54 ENGINE COULD HAVE VALVE COVERS BREAK IN COLD WEATHER AND RUIN THE ENGINE. THIS IS DUE TO MOISTURE ACCUMULATION. *RM Read More »
BMW: THERE IS A ROUGH ENGINE IDLE AND "SERVICE ENGINE SOON LIGHT" WHEN DRIVING DOWNHILL IN HIGH ALTITUDES DURING COLD WEATHER. THERE MAY BE SIX DIFFERENT FAULT CODES. *RM Read More »
BMW: A SERVICE ENGINE SOON LIGHT COMES ON. THE ENGINE WILL ONLY OPERATE TO 1500 RPMS AND LACKS POWER. THERE IS A SOFTWARE APPLICATION ERROR. *RM Read More »
BMW VEHICLES: EDK THROTTLE POTENTIOMETER FAULTS-DIAGNOSIS. MODELS E60, E63, E64, E65, E66, AND E70. THE SERVICE ENGINE SOON AND DSC/DTC WARNING LAMPS ARE ILLUMINATED. THE ENGINE ENTERS THE POWER REDUCTION (FAIL SAFE) MODE. Read More »
BMW VEHICLES: SERVICE ENGINE SOON LAMP OR CHECK GAS CAP WARNING ILLUMINATED WHILE DRIVING. SOFTWARE ERROR IN THE DME FOR THE TANK LEAK DIAGNOSTIC SYSTEM. Read More »
BMW VEHICLE: FC 2EF4 CHARACTERISTIC MAP THERMOSTAT. COMPLAINTS THAT THE SERVICE ENGINE SOON LAMP IS ILLUMINATED. FAULT CODE 2EF4 CHARACTERISTIC MAP THERMOSTAT IS STORED IN DME FAULT MEMORY. Read More »
ENGINE AND ENGINE COOLING:ENGINE:GASOLINE:TURBO/SUPERCHARGER
BMW VEHICLES: N63 TURBOCHARGER AUXILIARY WATER PUMP FAULTS. THE SERVICE ENGINE SOON LAMP IS ILLUMINATED WITH THE FOLLOWING FAULT CODES STORED IN THE DME CONTROL MODULE. Read More »
BMW: OIL LEAKS FROM THE AIR HOSE ON TURBOCHARGER. THIS IS DESIGNATED FOR E70, AND E90 MODELS WITH M57Y DIESEL ENGINES. SERVICE ENGINE SOON LAMP MAY BE ILLUMINATED. *KB Read More »
BMW VEHICLE: THE SERVICE ENGINE SOON (MIL) LAMP IS ILLUMINATED AND A POWER REDUCTION IS CLEARLY PERCEPTIBLE. THIS SITUATION MAY OCCUR AFTER DRIVING FOR SOME TIME WITH THE ENGINE ALREADY AT FULL OPERATING TEMPERATURE. Read More »
BMW: COMPLAINT OF A DELAYED ENGAGEMENT AND A HARSH JOLT WHEN ACCELERATING FROM A STOP. THE SITUATION OCCURS ONLY DURING THE ENGINE WARM UP PHASE (COLD ENGINE), AND CANNOT BE REPRODUCED IN THE SPORT MODE. Read More »
BMW VEHICLE: WATER HAS ENTERED ELECTRONICS BOX BECAUSE THE LID IS NOT PROPERLY FITTED. ONCE IT IS VERIFIED THAT WATER HAS INDEED ENTERED THE ELECTRONICS BOX, IT WILL BE NECESSARY TO REPLACE BOTH THE LOWER PART OF THE ELECTRONICS BOX AND ... Read More »
BMW: WARNING MESSAGE ON ABOUT LOW DIESEL EXHAUST FUEL LEVEL AND THAT THE ENGINE WILL NOT RESTART WITHIN 999 MILES. THE LIGHT COMES ON A FEW THOUSAND MILES EARLIER THAN A RECOMMENDED OIL CHANGE. *RM Read More »
BMW VEHICLES: DIAGNOSIS FOR LOW PRESSURE FUEL SUPPLY FAULTS. THE SERVICE ENGINE SOON LAMP IS ILLUMINATED (A FUEL PUMP MALFUCTION MESSAGE IS DISPLAYED IN THE CC), AND A COMBINATION OF THE FOLLOWING FAULT CODES MAY BE STORED IN THE DDE ... Read More »
BMW VEHICLES: EDK THROTTLE POTENTIOMETER FAULTS-DIAGNOSIS. MODELS E60, E63, E64, E65, E66, AND E70. THE SERVICE ENGINE SOON AND DSC/DTC WARNING LAMPS ARE ILLUMINATED. THE ENGINE ENTERS THE POWER REDUCTION (FAIL SAFE) MODE. Read More »
ENGINE AND ENGINE COOLING:ENGINE:OTHER FUEL TYPES:TURBO/SUPERCHARGER
BMW VEHICLES: N63 TURBOCHARGER AUXILIARY WATER PUMP FAULTS. THE SERVICE ENGINE SOON LAMP IS ILLUMINATED WITH THE FOLLOWING FAULT CODES STORED IN THE DME CONTROL MODULE. Read More »
BMW VEHICLE: DRIVEABILITY COMPLAINTS DUE TO COOLING FAN RELAY FAILURE. THE CUSTOMER MAY COMPLAIN OF INTERMITTENT DRIVEABILITY PROBLEMS, DESCRIBED AS-ENGINE IS LACKING POWER WHEN ACCELERATING UPHILL; TRANSMISSION WILL NOT UPSHIFT UNDER ... Read More »
"? DIESEL PARTICULATE FILTER (DPF) CLEANING . The following performance issues may be noticed by the customer: CC-Message ""Drive faulty"" Engine jerking or a lack of power over the whole engine speed range Malfunction indicator lamp ... Read More »
"? NO REGENERATION OF THE DIESEL PARTICULATE FILTER (DPF) This Service Information bulletin supersedes SI B18 03 10 dated November 2010. . The Service Engine Soon lamp is illuminated. Read More »
"SUBJECT N62TU: ISTA Service Function for DME ""RAM Backup"". The ISTA Service Function test plan should be performed to clear stored values in the DME RAM memory after repairs are completed, in the following situations: z VANOS or ... Read More »
ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL
BMW: SEE DOCUMENT SEARCH BUTTON FOR OWNER LETTER. THE REPLACING AND/OR CHECKING OF EMISSIONS MONITORING COMPONENTS TO INCREASE EMISSIONS STABILITY, HIGH PRESSURE (HP) EGR VALVE RESTRICTION OF EXCESSIVE SOOT AND IMPROVED DIESEL EXHAUST ... Read More »
ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL:CRANKCASE (PCV)
BMW: SEE DOCUMENT SEARCH BUTTON FOR OWNER LETTER. THE REPLACING AND/OR CHECKING OF EMISSIONS MONITORING COMPONENTS TO INCREASE EMISSIONS STABILITY, HIGH PRESSURE (HP) EGR VALVE RESTRICTION OF EXCESSIVE SOOT AND IMPROVED DIESEL EXHAUST ... Read More »
CLASS ACTION SETTLEMENT: N54/N54T/N55 ELECTRIC ENGINE COOLANT PUMP . With the court's FINAL approval, BMW of North America, LLC (BMW NA) has entered a nationwide settlement with the plaintiffs in the following class action: Oliver, et al v. Read More »
CLASS ACTION SETTLEMENT: N54/N54T/N55 ELECTRIC ENGINE COOLANT PUMP . With the court's FINAL approval, BMW of North America, LLC (BMW NA) has entered a nationwide settlement with the plaintiffs in the following class action: Oliver, et al v. Read More »
SURFACE RUST ON NEW AIR BAG INFLATORS: The technician finds that the new air bag inflator (aka: gas generator) may have surface rust on the metalhousing . Read More »
INCORRECT TORQUE SPECIFICATION FOR THE HIGH-PRESSURE PUMP IN ISTA: The current version of ISTA states the incorrect tightening torque for the High-Pressure pump M6 mounting bolts to the cylinder head cover. Read More »
Service Action: N63 Replace High-Pressure Fuel Pumps. The high-pressure pump may fail, resulting in an engine malfunction warning and reduced engine output. Read More »
N63 and S63 Engine: High-pressure Fuel Injector Replacement Procedures. The customer complains that one of the following scenarios has been encountered while operating the vehicle: * During a cold start in the morning, the engine runs ... Read More »
N63 and S63 Engine: High-pressure Fuel Injector Replacement Procedures. The customer complains that one of the following scenarios has been encountered while operating the vehicle: * During a cold start in the morning, the engine runs ... Read More »
N63 and S63 Engine: High-pressure Fuel Injector Replacement Procedures. The customer complains that one of the following scenarios has been encountered while operating the vehicle: * During a cold start in the morning, the engine runs ... Read More »
N63 and S63 Engine: High-pressure Fuel Injector Replacement Procedures. The customer complains that one of the following scenarios has been encountered while operating the vehicle: * During a cold start in the morning, the engine runs ... Read More »
N63 and S63 Engine: High-pressure Fuel Injector Replacement Procedures. The customer complains that one of the following scenarios has been encountered while operating the vehicle: * During a cold start in the morning, the engine runs ... Read More »
N63 and S63 Engine: High-pressure Fuel Injector Replacement Procedures. The customer complains that one of the following scenarios has been encountered while operating the vehicle: * During a cold start in the morning, the engine runs ... Read More »
BMW: SERVICE ACTION: REPLACE THE LEFT AND RIGHT FUEL LEVEL SENSOR. DUE TO HIGH PROPORTION OF ETHANOL IN THE FUEL, THE INTERNAL MECHANISMS OF THE FUEL LEVEL SENSORS MAY SWELL. Read More »
?BMW has become aware of a potential problem with the durability of the Tank Leak Diagnostic Module (DMTL) pump on MY 2007, 2008 and 2009 BMW X5 vehicles equipped with the N52K engine. Read More »
"N63 and N74 Engine: ISTA/D 2.33 Diagnostic Error in the Low-pressure Fuel Supply Sensor Value. INFORMATION When diagnosing the low-pressure fuel supply sensor with one of the following test plans and ISTA/D 2. Read More »
BMW VEHICLE: TEILECLEARING FOR DIAGNOSTIC MODULE TANK LEAKAGE (DMTL) SYSTEM. TEILECLEARING PROCESS HAS BEEN DEVELOPED TO HELP IDENTIFY THE ROOT CAUSES OF CUSTOMER COMPLAINTS RELATING TO THE DMTL SYSTEM (E.G. Read More »
BMW: SERVICE ENGINE SOON LAMP OR THE CHECK GAS CAP WARNINGS ARE ILLUMINATED WHILE DRIVING. WHEN DIAGNOSED, THE DME HAS STORED FAULTS FOR SMALL LEAK, MICRO LEAK, SUPER FINE LEAK, OR LARGE LEAK IN RELATION TO THE TANK VENTILATION OR ... Read More »
BMW VEHICLES: SERVICE ENGINE SOON LAMP OR CHECK GAS CAP WARNING ILLUMINATED WHILE DRIVING. SOFTWARE ERROR IN THE DME FOR THE TANK LEAK DIAGNOSTIC SYSTEM. Read More »
BMW: TSB CONTAINS AN OWNER'S NOTIFICATION LETTER. SELECT DOCUMENT SEARCH BUTTON BELOW. INFORMATION PROVIDED REGARDING THE EXTENSION OF LIMITED WARRANTY ON THE IN TANK FUEL (PUMP) DELIVERY MODULE OF 10 YEARS WITHOUT MILEAGE LIMITATION, ... Read More »
"?SI B13 02 15July 2015 Fuel SystemsTechnical Service This Service Information bulletin supersedes SI B13 02 15 dated May 2015. designates changes to this revision SUBJECT Service Action: N63 Replace High-Pressure Fuel Pumps. Read More »
BMW SERVICE CAMPAIGN: SEE DOCUMENT SEARCH BUTTON FOR OWNER LETTER. THERE MAY BE A PROBLEM WITH THE FUEL PUMP WHICH COULD NOT MEET EMISSIONS REQUIREMENTS. THERE MAY BE A LONG CRANK AND A SERVICE ENGINE SOON LIGHT. Read More »
BMW VEHICLES: FUEL LEVEL SENSOR REPAIRS. WHERE IT IS NECESSARY TO REPLACE THE RIGHT OR THE LEFT SIDE FUEL LEVEL SENSOR DUE TO A FAILURE, THE ENTIRE PUMP AND HOUSING OR DELIVERY UNIT (SUCTION JET ASSEMBLY) DO NOT NEED TO BE REPLACED AS ... Read More »
N63 and S63 Engine: High-pressure Fuel Injector Replacement Procedures. The customer complains that one of the following scenarios has been encountered while operating the vehicle: * During a cold start in the morning, the engine runs ... Read More »
Service Action: S63 Engine - Check and Replace High- Pressure Injectors This Service Information bulletin supersedes SI B13 08 15 dated January 2016. Read More »
N63 and S63 Engine: High-pressure Fuel Injector Replacement Procedures. The customer complains that one of the following scenarios has been encountered while operating the vehicle: * During a cold start in the morning, the engine runs ... Read More »
N63 and S63 Engine: High-pressure Fuel Injector Replacement Procedures. The customer complains that one of the following scenarios has been encountered while operating the vehicle: * During a cold start in the morning, the engine runs ... Read More »
BMW: WARNING MESSAGE ON ABOUT LOW DIESEL EXHAUST FUEL LEVEL AND THAT THE ENGINE WILL NOT RESTART WITHIN 999 MILES. THE LIGHT COMES ON A FEW THOUSAND MILES EARLIER THAN A RECOMMENDED OIL CHANGE. *RM Read More »
BMW: DIESEL: DIAGNOSIS FOR LOW PRESSURE FUEL SUPPLY FAULTS. SERVICE ENGINE SOON LAMP IS ILLUMINATED (A FUEL PUMP MALFUNCTION MESSAGE IS DISPLAYED IN THE CC) AND A COMBINATION OF THE FOLLOWING FAULT CODES MAY BE STORED IN THE DDE CONTROL ... Read More »
Service Action: Replace the Left and Right Fuel Level Sensor. After refueling, the fuel gauge will display an incorrect fuel level. When this occurs, the fuel gauge shows the fuel level as 3/4 full. Read More »
Service Action: Replace the Left and Right Fuel Level Sensor. After refueling, the fuel gauge will display an incorrect fuel level. When this occurs, the fuel gauge shows the fuel level as 3/4 full. Read More »
BMW: SERVICE ENGINE SOON LAMP OR THE CHECK GAS CAP WARNINGS ARE ILLUMINATED WHILE DRIVING. WHEN DIAGNOSED, THE DME HAS STORED FAULTS FOR SMALL LEAK, MICRO LEAK, SUPER FINE LEAK, OR LARGE LEAK IN RELATION TO THE TANK VENTILATION OR ... Read More »
BMW: FUEL GAUGE SHOWS 3/4 FULL AFTER REFUELING DUE TO INTERNAL MECHANISMS OF FUEL LEVEL SENSORS, WITH A HIGH PROPORTION OF ETHANOL, SWELLING AND INHIBIT, ONE OR BOTH, MOVEMENT OF FUEL LEVEL SENSORS. MODEL 2007-2009 E70, E71. Read More »
BMW SERVICE CAMPAIGN: SEE DOCUMENT SEARCH BUTTON FOR OWNER LETTER. THERE MAY BE A PROBLEM WITH THE FUEL PUMP WHICH COULD NOT MEET EMISSIONS REQUIREMENTS. THERE MAY BE A LONG CRANK AND A SERVICE ENGINE SOON LIGHT. Read More »
Power Reduction FC2A82 Intake VANOS and/or FC2 A87 Exhaust VANOS Camshaft Fault: The "Service Engine Soon" (MIL) lamp is illuminated and engine power reduction is perceived. Read More »
N63, N63TU, S63 and S63TU Engines: Oil Leak from the Rear of the Engine and Transmission Bell Housing. Customer complains that engine oil is leaking from the center of the vehicle. Read More »
Vibration or Shudder from Driveline when Accelerating from a Stop. Chassis stabilization warning is displayed. Vehicle may exhibit a shudder or vibration when taking off from a stop. Read More »
"Intelligent Battery Sensor Diagnosis Hints. The vehicle enters the workshop with one or more of the following complaints: * Check Control Message related to battery discharge * No-start condition * Consumer power reduction (reduced ... Read More »
N52T / N55 with 8HP45: Delay in Engine Response. A customer may complain of a delay in engine response after decelerating at low road speeds and then reaccelerating. Read More »
A customer may complain of a delay in engine response after decelerating at low road speeds and then reaccelerating. This can occur when the transmission remains in a high gear due to a delay in the transmission downshifting. Read More »
"The warning lamps for DSC, ABS and brake warning are illuminated. There may also be a warning in the control display for ""Chassis Control System failure. Read More »
N55 Engine Failsafe - FC 120308 Boost Pressure Control, Plausibility: Pressure Too Low Stored in DME Fault Memory. INFORMATION The customer complains the SES is illuminated and the engine has reduced power (engine failsafe mode). Read More »
Oil Leak from Transfer Case. Oil is leaking from the transmission area, or oil seepage is noticed from the transmission/transfer case area during a service. Read More »
Clicking Noise from Front Axle. Clicking noises are heard from the front axle area while maneuvering at low speeds (e.g., parking lot maneuvers). Read More »
N63, N63TU, S63 and S63TU Engines: Oil Leak from the Rear of the Engine and Transmission Bell Housing. Customer complains that engine oil is leaking from the center of the vehicle. Read More »
BMW: THE EMERGENCY PARK RELEASE CABLE HAS BEEN REMOVED IN THESE MODELS AND THERE IS A PROCEDURE TO DISENGAGE THE PARK LOCK. 2011 E70/E71. UPDATED ON 06/08/2011. *KB UPDATED ON 06/21/2011. *RM Read More »
BMW: DELAYED ENGAGEMENT AND HARSH JOLT WHEN ACCELERATING FROM A STOP. HARSH 1-2 UPSHIFT OR JOLT FELT DURNG THE 3-2 DOWNSHIFT OWN DECELERATION. MODEL E70 (X5 3.0I) *PE UPDATED 06/08/11. *PE Read More »
BMW VEHICLE: TRANSMISSION WARNING LIGHT IS ILLUMINATED AND THE TRANSMISSION ENTERS FAILSAFE MODE. FAULT CODE 4F81 (RATIO MONITORING, CLUTCH A), IN SOME CASES COMBINED WITH THE SUBSEQUENT FAULTS 507B/507C (PARKING GEAR SENSOR IMPLAUSIBLE ... Read More »
"REPAIRING TRANSFER CASE ACTUATOR (VTG SERVO-MOTOR). The Anti-lock Brakes (ABS), Brakes and Dynamic Stability Control (DSC) warnings are on and there may also be a ""Drivetrain Malfunction"" warning on in the Control Display. Read More »
Shudder from the Driveline on Vehicles with xDrive. There is a shudder or vibration from the driveline when taking off from a stop, or when accelerating at highway speeds. Read More »
BMW: REPLACEMENT OF FRONT OUTER CV JOINT. COMPLAINTS OF CLICKING OR GRINDING NOISES COMING FROM THE FRONT AXLE AREA WHEN MAKING A TURN. THE FRONT OUTER CONSTANT VELOCITY JOINT BOOT IS SPLIT OPEN AND THE JOINT IS ALREADY DAMAGED. Read More »
CRACKING NOISES FROM THE FRONT AXLE AREA WHILE TURNING THE WHEELS, WHEN STATIONARY OR PARKING: Cracking noises are heard from the front axle area while maneuvering at low speeds (e.g. Read More »
CLICKING NOISE FROM FRONT AXLE This Service Information bulletin supersedes SI 31 01 12 dated June 2015. Clicking noises are heard from the front axle area while maneuvering at low speeds (e.g., parking lot maneuvers). Read More »
BMW: REPLACEMENT OF FRONT OUTER CV JOINT. COMPLAINTS OF CLICKING OR GRINDING NOISES COMING FROM THE FRONT AXLE AREA WHEN MAKING A TURN. THE FRONT OUTER CONSTANT VELOCITY JOINT BOOT IS SPLIT OPEN AND THE JOINT IS ALREADY DAMAGED. Read More »
The electrical system of BMW vehicles has been subject to an ongoing development process over the last few years. This has led to increased demands being placed on the battery. Read More »
The electrical system of BMW vehicles has been subject to an ongoing development process over the last few years. This has led to increased demands being placed on the battery. Read More »
The electrical system of BMW vehicles has been subject to an ongoing development process over the last few years. This has led to increased demands being placed on the battery. Read More »
Customer is unable to power up or charge accessories through a plug adapter inserted in the front 12-volt power socket plug. Alternatively, it will only operate when constant downward hand pressure is maintained. Read More »
Vehicle cannot be opened or closed using comfort access, engine start is not possible, and the vehicle may not start when placing the key against the steering column. Read More »
Discharged Battery Energy Diagnosis Must Be Performed: The electrical system of BMW vehicles has been subject to an ongoing development process over the last few years. This has led to increased demands being placed on the battery. Read More »
Discharged Battery Energy Diagnosis Must Be Performed: The electrical system of BMW vehicles has been subject to an ongoing development process over the last few years. This has led to increased demands being placed on the battery. Read More »
Discharged Battery Energy Diagnosis Must Be Performed: The electrical system of BMW vehicles has been subject to an ongoing development process over the last few years. This has led to increased demands being placed on the battery. Read More »
Power Reduction FC2A82 Intake VANOS and/or FC2 A87 Exhaust VANOS Camshaft Fault: The "Service Engine Soon" (MIL) lamp is illuminated and engine power reduction is perceived. Read More »
"Outside Door Mirror Moves when Locking or Unlocking the Vehicle. The door mirror tilts immediately after unlocking or locking. The mirror position does not correspond to the memory position preset by the customer. Read More »
"Erroneous CC Message "Remote control! Do not switch off the engine" is Displayed. An erroneous CC message, "Remote control!" " Do not switch off the engine" is displayed in the Central Information Display (CID). Read More »
For the above-referenced vehicles with driver?s side airbag modules, BMW of North America, LLC (?BMW NA?) will provide a Customer Support Program as outlined in the Takata Settlement Customer Support Program Overview attachment. Read More »
For the above-referenced vehicles with passenger?s side airbag modules, BMW of North America, LLC (?BMW NA?) will provide a Customer Support Program as outlined in the Takata Settlement Customer Support Program Overview attachment. Read More »
SERVICE ACTION: GSM COMBOX DEACTIVATION / DISCONTINUATION WITH 4 YEAR ASSIST SERVICE. What's New: ? Model: Option code removed to prevent confusion about affected vehicles ? Situation: Information added about Bluetooth functionality that ... Read More »
Diagnosing Stored Fault Codes to Help Avoid Repeat Repair Visits This Service Information bulletin supersedes SI B07 03 14 dated October 2015.. Read More »
"USB DEVICE IS NOT DETECTED BY CHAMP2 HEAD UNIT. Media connected to the USB connector is not recognized by the audio system. Playback of files from the media is not possible. Read More »
"N52K Tank Leak Diagnostic Module (DMTL) Pump: Limited Warranty Extension to 10 Years/120,000 Miles. INFORMATION For the above-referenced vehicles, BMW of North America, LLC (""BMW NA"") is extending the limited warranty for the tank leak ... Read More »
ISTA/P Cannot Program an E-Series N55 Replacement DME. ISTA/P fails when attempting to program a replacement DME (MEVD172) on BN2000 E-Series vehicles with the Continental HPP. Part number: 12 14 8 618 483. Read More »
This Service Information bulletin supersedes SI B07 03 14 dated October 2015. Diagnosing Stored Fault Codes to Help Avoid Repeat Repair Visits. Read More »
SUBJECT Audio System Speaker Testing. For audio system speaker testing there is a NED (Non Electrical Diagnosis) Test Plan available. CAUSE We previously recommended use of the Audio Test CD (ATC) from BMW. This CD has been discontinued. Read More »
SI B84 03 14 February 2016 Communication Systems Technical Service This Service Information bulletin supersedes SI B84 03 14 dated October 2014. SUBJECT Bluetooth Connection Failures. Read More »
Diagnosing Stored Fault Codes to Help Avoid Repeat Repair Visits. Analysis of FASTA data and repeat repair visit reports indicates that there are many fault codes that are stored in the above vehicles, but they are not diagnosed to ... Read More »
"SI B12 10 15 Engine Electrical Systems March 2015 Technical Service This Service Information bulletin supersedes SI B12 10 15 dated January 2015. designates changes to this revision SUBJECT N63: CBS Oil Service Conversion in ISTA/P. Read More »
This Service Information bulletin supersedes SI B07 03 14 dated February 2015. designates changes to this revision SUBJECT Diagnosing Stored Fault Codes to Help Avoid Repeat Repair Visits. Read More »
SUBJECT DME Internal and Valvetronic Faults Set at Cold Ambient Temperatures. The Service Engine Soon light (MIL) can be illuminated with the erroneous internal and Valvetronic faults stored in the DME. Read More »
N62TU: EDK Throttle Potentiometer Faults - Diagnostic. The "Service Engine Soon" and DSC/DTC warning lights are illuminated. Engine enters the power reduction ("fail-safe") mode. Read More »
iPhone 6, 6 Plus, 5, 5S, 5C, 4S, 4, and 3GS with iOS 8.x Information. INFORMATION There is one major difference in functionality since iOS 8.0 was released. Scenario: z The customer leaves the vehicle and turns his or her phone off. Read More »
Check Control Messages Related to Battery Charge During Cold Ambient Temperatures. On cold days with an outside ambient temperature of less than 15F, customers may notice a check control message related to the battery that is displayed on ... Read More »
"Intelligent Battery Sensor Diagnosis Hints. The vehicle enters the workshop with one or more of the following complaints: * Check Control Message related to battery discharge * No-start condition * Consumer power reduction (reduced ... Read More »
Previously assigned radio channels to the satellite radio "Presets" list have been erased and radio channels selected from the list "All channels" menu cannot be stored in the "Presets" list. Read More »
Check Control Messages Related to Battery Charge During Cold Ambient Temperatures. On cold days with an outside ambient temperature of less than 15?F, customers may notice a check control message related to the battery that is displayed ... Read More »
Check Control Messages Related to Battery Charge During Cold Ambient Temperatures. On cold days with an outside ambient temperature of less than 15F, customers may notice a check control message related to the battery that is displayed on ... Read More »
"ConnectedDrive/BMW ASSIST Features Are Inoperative. ConnectedDrive features are partially or completely inoperative. * No traffic information (RTTI / ARTTI) * BMW ASSIST ""My Info"" service doesn't work. Read More »
"Outside Door Mirror Moves when Locking or Unlocking the Vehicle. The door mirror tilts immediately after unlocking or locking. The mirror position does not correspond to the memory position preset by the customer. Read More »
"The warning lamps for DSC, ABS and brake warning are illuminated. There may also be a warning in the control display for ""Chassis Control System failure. Read More »
BMW: BATTER DISCHARGED BECAUSE OF UNFAVORABLE DRIVING PROFILE. THIS IS CAUSED ON SHORT TRIPS (LESS THAN 3 MILES) OR WHEN THE TELEPHONE OR ENTERTAINMENT SYSTEM IS USED FOR UP TO 30 MINUTES WHILE VEHICLE IS STATIONARY. Read More »
Battery Discharged Because of Unfavorable Driving Profile. In certain situations, the battery may become discharged when the vehicle is driven frequently on short trips (less than 3 miles per trip), or when the telephone or entertainment ... Read More »
Various Faults Concerning the Automatic Tailgate Operation. Complaints of sporadic or permanent faults may exist with the automatic tailgate function. Read More »
N55 - Delayed Throttle Response When Driving Off. Delayed throttle response when driving off with a high engine load This problem occurs mainly under the following conditions: * High ambient outside temperatures * The air conditioning is ... Read More »
"Discharged Battery: Energy Diagnosis Must Be Performed. The electrical system of BMW vehicles has been subject to an ongoing development process over the last few years. This has led to increased demands being placed on the battery. Read More »
BMW VEHICLES: N63 TURBOCHARGER AUXILIARY WATER PUMP FAULTS. THE SERVICE ENGINE SOON LAMP IS ILLUMINATED WITH THE FOLLOWING FAULT CODES STORED IN THE DME CONTROL MODULE. Read More »
BMW: ELCTRONICALLY DISCONNECTING THE JUNCTION BOX WITHOUT DISCONNECTING THE BATTERY WILL CAUSE DAMAGE TO THE REAR POWER DISTRIBUTION BOX. *RM Read More »
BMW VEHICLES: VARIOUS ELECTRICAL PROBLEMS ARE POSSIBLE ON THE VEHICLE: WARNING LAMPS ILLUMINATED IN THE INSTRUMENT CLUSTER; CHECK CONTROL MESSAGES; SYSTEMS INOPERATIVE; FUSE BLOWN; WIPERS IN DEFAULT MODE (PERMANENTLY ON); AND FAULT CODES ... Read More »
BMW: VARIOUS ELECTRICAL PROBLEMS. ON THE VEHICLE, VARIOUS ELECTRICAL PROBLEMS ARE POSSIBLE. WARNING LAMPS ILLUMINATED IN THE INSTRUMENT CLUSTER; CHECK CONTROL MESSAGES; SYSTEMS INOPERATIVE; FUSE BLOWN; WIPERS IN DEFAULT MODE (PERMANENTLY ... Read More »
BMW VEHICLES: DSC WARNING LAMP ILLUMINATED. THE DSC (DYNAMIC STABILITY CONTROL) WARNING LAMP IS ILLUMINATED AND SOME OR ALL OF THE FOLLOWING FAULT CODES ARE STORED: 6E58; 6E04; 53BA; D36F; 55C3; 6ECA; AND THE WIPERS MAY ALSO BE ... Read More »
BMW: THE TELEMATICS CONTROL UNIT (TCU) IN VEHICLES MAY NOT HAVE BEEN PROPERLY ACTIVATED. THIS CAUSES THE MANUAL AND AUTOMATIC EMERGENCY CALL AND ROADSIDE CALL (BMW ASSIST) NOT TO FUNCTION. MODELS E53, E60, E90, E83 ARE AFFECTED. Read More »
BMW VEHICLE: DRIVEABILITY COMPLAINTS DUE TO COOLING FAN RELAY FAILURE. THE CUSTOMER MAY COMPLAIN OF INTERMITTENT DRIVEABILITY PROBLEMS, DESCRIBED AS-ENGINE IS LACKING POWER WHEN ACCELERATING UPHILL; TRANSMISSION WILL NOT UPSHIFT UNDER ... Read More »
BMW VEHICLE: MISSING CLIP ON POWER CABLE CAUSES VARIOUS ELECTRICAL COMPLAINTS. VEHICLE WILL NOT START. INSTRUMENT CLUSTER OR DISPLAYS ARE FLICKERING. REMOTE CONTROL WILL NOT UNLOCK VEHICLE. Read More »
BMW VEHICLE: ELECTRONIC MALFUNCTION CC MESSAGE CAUSED BY SHORTED WIRING. THE ELECTRONIC MALFUNCTION CHECK CONTROL MESSAGE MAY BE DISPLAYED; THE SOUNDS SYSTEM EMITS A STATIC NOISE FROM THE SPEAKERS; THE RFK (REAR VIEW CAMERA) DOES NOT ... Read More »
USB CABLE: BATTERY DISCHARGE/AUDIO FAILURE/RADIO RECEPTION. No sound from the radio, telephone, gong signal and or PDC. Poor radio reception and failure of the telematics systems. Read More »
BMW: BATTER DISCHARGED BECAUSE OF UNFAVORABLE DRIVING PROFILE. THIS IS CAUSED ON SHORT TRIPS (LESS THAN 3 MILES) OR WHEN THE TELEPHONE OR ENTERTAINMENT SYSTEM IS USED FOR UP TO 30 MINUTES WHILE VEHICLE IS STATIONARY. Read More »
BMW: BATTERY HAS AN INCREASED DEMAND DUE TO DEVELOPEMENTAL PROCESS OF THE ELECTRICAL SYSTEM. THIS IS CAUSING THE BATTER TO NEED TO UNDERGO AN ENERGY DIAGNOSIS. *KB Read More »
BMW VEHICLE: WATER HAS ENTERED ELECTRONICS BOX BECAUSE THE LID IS NOT PROPERLY FITTED. ONCE IT IS VERIFIED THAT WATER HAS INDEED ENTERED THE ELECTRONICS BOX, IT WILL BE NECESSARY TO REPLACE BOTH THE LOWER PART OF THE ELECTRONICS BOX AND ... Read More »
BMW: ELCTRONICALLY DISCONNECTING THE JUNCTION BOX WITHOUT DISCONNECTING THE BATTERY WILL CAUSE DAMAGE TO THE REAR POWER DISTRIBUTION BOX. *RM Read More »
BMW: VARIOUS ELECTRICAL PROBLEMS. ON THE VEHICLE, VARIOUS ELECTRICAL PROBLEMS ARE POSSIBLE. WARNING LAMPS ILLUMINATED IN THE INSTRUMENT CLUSTER; CHECK CONTROL MESSAGES; SYSTEMS INOPERATIVE; FUSE BLOWN; WIPERS IN DEFAULT MODE (PERMANENTLY ... Read More »
BMW VEHICLES: DSC WARNING LAMP ILLUMINATED. THE DSC (DYNAMIC STABILITY CONTROL) WARNING LAMP IS ILLUMINATED AND SOME OR ALL OF THE FOLLOWING FAULT CODES ARE STORED: 6E58; 6E04; 53BA; D36F; 55C3; 6ECA; AND THE WIPERS MAY ALSO BE ... Read More »
BMW: FAILURE OF REMOTE CONTROL LOCKING. INTERMITTENTLY OR PERMANENTLY, THE REMOTE CONTROL LOCKING IS INOPERATIVE. BOTH REMOTE KEYS ARE AFFECTED. Read More »
BMW VEHICLE: ELECTRONIC MALFUNCTION CC MESSAGE CAUSED BY SHORTED WIRING. THE ELECTRONIC MALFUNCTION CHECK CONTROL MESSAGE MAY BE DISPLAYED; THE SOUNDS SYSTEM EMITS A STATIC NOISE FROM THE SPEAKERS; THE RFK (REAR VIEW CAMERA) DOES NOT ... Read More »
BMW VEHICLES: VARIOUS ELECTRICAL PROBLEMS ARE POSSIBLE ON THE VEHICLE: WARNING LAMPS ILLUMINATED IN THE INSTRUMENT CLUSTER; CHECK CONTROL MESSAGES; SYSTEMS INOPERATIVE; FUSE BLOWN; WIPERS IN DEFAULT MODE (PERMANENTLY ON); AND FAULT CODES ... Read More »
iPhone 6, 6 Plus, 5, 5S, 5C, 4S, 4, and 3GS with iOS 8.x Information. INFORMATION There is one major difference in functionality since iOS 8.0 was released. Scenario: z The customer leaves the vehicle and turns his or her phone off. Read More »
BMW: COMPLAINT OF A DELAYED ENGAGEMENT AND A HARSH JOLT WHEN ACCELERATING FROM A STOP. THE SITUATION OCCURS ONLY DURING THE ENGINE WARM UP PHASE (COLD ENGINE), AND CANNOT BE REPRODUCED IN THE SPORT MODE. Read More »
BMW: A SERVICE ENGINE SOON LIGHT COMES ON. THE ENGINE WILL ONLY OPERATE TO 1500 RPMS AND LACKS POWER. THERE IS A SOFTWARE APPLICATION ERROR. *RM Read More »
BMW VEHICLE: FC 2EF4 CHARACTERISTIC MAP THERMOSTAT. COMPLAINTS THAT THE SERVICE ENGINE SOON LAMP IS ILLUMINATED. FAULT CODE 2EF4 CHARACTERISTIC MAP THERMOSTAT IS STORED IN DME FAULT MEMORY. Read More »
BMW VEHICLE: ELECTRONIC MALFUNCTION CC MESSAGE CAUSED BY SHORTED WIRING. THE ELECTRONIC MALFUNCTION CHECK CONTROL MESSAGE MAY BE DISPLAYED; THE SOUNDS SYSTEM EMITS A STATIC NOISE FROM THE SPEAKERS; THE RFK (REAR VIEW CAMERA) DOES NOT ... Read More »
Delay in Automatic Driving Light Switching On/Off. When driving out of a tunnel or exiting underground parking, the automatic driving light remains switched on for two minutes, even in daylight. Read More »
BMW: SOME VEHICLES, WITH 552 OPTION, ARE EXPERIENCING A MALFUNCTION OF LED HEADLIGHT ON ONE WHERE IT FLICKERS ON AN DOFF DURING DRIVING AND THE CONTROL CHECK MESSAGE IS INDICATING DEFECTIVE DRIVING LIGHT OR PARKING LIGHT. Read More »
BMW: ON CERTAIN VEHICLES, THE XENON HEADLAMP OFTEN HAVE NO TROUBLE FOUND WHEN RETURNED AND TESTED THRU WARRANTY PARTS SYSTEM. THE ROOT CAUSE IS NOT POSSIBLE TO BE IDENTIFY. *PE Read More »
BMW: HEADLAMP MOISTURE: FAULT DIAGNOSTICS. WATER OR CONDENSATION IN ONE OR BOTH HEADLAMPS. MODELS 5 SERIES, 6 SERIES, 7 SERIES, X5, X6, 1 SERIES, AND 3 SERIES. MODEL YEARS 2000-20008. *PE Read More »
BMW: WATER LEAKS INTO THE TAILGATE LAMP CAUSING CORROSION AND CAN LEAD TO ELECTRICAL FAILURE OF THE LAMP. THERE WILL ALSO BE A WARNING LIGHT IN THE INSTRUMENT CLUSTER. E70. *RM Read More »
BMW: THE BRAKE LIGHT FAILS AND THE BULB HOLDER IS DEFORMED DUE TO HIGH TEMPERATURES AND THE COMPOSITION OF THE HOLDER. *RM UPDATED ON 4/25/2013. *KB Read More »
"Outside Door Mirror Moves when Locking or Unlocking the Vehicle. The door mirror tilts immediately after unlocking or locking. The mirror position does not correspond to the memory position preset by the customer. Read More »
"Outside Door Mirror Moves when Locking or Unlocking the Vehicle. The door mirror tilts immediately after unlocking or locking. The mirror position does not correspond to the memory position preset by the customer. Read More »
Water Leak from the Front of the Sunroof. During extended periods of heavy rain, water may enter the vehicle from the area around the front of the sunroof cassette, the Roof Control Panel (FZD), the map lights, or the A-pillars. Read More »
"Panoramic Sunroof Repair Instructions. INFORMATION Sunroof Repair Instructions: The panoramic sunroof contains several ""mechanism sets"" which can be repaired and/or replaced independently in the event of a mechanical failure. Read More »
Front or Rear Windshield Wipers Fail to Operate. INFORMATION The following troubleshooting hints are based on known areas that can cause the situations described above to occur. 1. Read More »
"Outside Door Mirror Moves when Locking or Unlocking the Vehicle. The door mirror tilts immediately after unlocking or locking. The mirror position does not correspond to the memory position preset by the customer. Read More »
"?Panoramic Sunroof Repair Instructions. INFORMATION Sunroof Repair Instructions: The panoramic sunroof contains several ""mechanism sets"" which can be repaired and/or replaced independently in the event of a mechanical failure. Read More »
"Outside Door Mirror Moves when Locking or Unlocking the Vehicle. The door mirror tilts immediately after unlocking or locking. The mirror position does not correspond to the memory position preset by the customer. Read More »
BMW VEHICLES: DSC WARNING LAMP ILLUMINATED. THE DSC (DYNAMIC STABILITY CONTROL) WARNING LAMP IS ILLUMINATED AND SOME OR ALL OF THE FOLLOWING FAULT CODES ARE STORED: 6E58; 6E04; 53BA; D36F; 55C3; 6ECA; AND THE WIPERS MAY ALSO BE ... Read More »
Grating Noise from Side Window Defroster Vent. The customer may notice a grating or creaking noise coming from the instrument panel at the extreme left or right side. It is only heard when the vehicle is in motion. Read More »
SURFACE RUST ON NEW AIR BAG INFLATORS: The technician finds that the new air bag inflator (aka: gas generator) may have surface rust on the metalhousing . Read More »
TAKATA AIR BAG RECALL-RELATED SHORT-TERM ALTERNATE TRANSPORTATION AND CONSEQUENTIAL REPAIRS This Service Information bulletin supersedes SI B01 31 18 dated October 2018. Read More »
TAKATA AIR BAG RECALL-RELATED SHORT-TERM ALTERNATE TRANSPORTATION AND CONSEQUENTIAL REPAIRS This Service Information bulletin supersedes SI B01 31 18 dated October 2018. Read More »
For the above-referenced vehicles with driver?s side airbag modules, BMW of North America, LLC (?BMW NA?) will provide a Customer Support Program as outlined in the Takata Settlement Customer Support Program Overview attachment. Read More »
For the above-referenced vehicles with passenger?s side airbag modules, BMW of North America, LLC (?BMW NA?) will provide a Customer Support Program as outlined in the Takata Settlement Customer Support Program Overview attachment. Read More »
In an effort to improve the completion rate on Takata air bag recall affected vehicles; BMW NA has expanded the BMW Ultimate Rewards platform to include a new Recall Support page. Read More »
DSC Warning Light is On. The warning lamps for DSC, ABS and brake warning are illuminated. There may also be a warning in the control display for 'Chassis Control System failure' One or more of the following fault codes are stored: F25, ... Read More »
BMW VEHICLE: AIRBAG WARNING ILLUMINATED, FC 93D2. THE AIRBAG WARNING LAMP IS ILLUMINATED (PERMANENTLY OR INTERMITTENTLY) AND FAULT CODE 93D2 (PASSENGER AIRBAG OFF LIGHT [POL]) IS STORED IN THE ACSM (ADVANCED CRASH SAFETY MODULE). Read More »
"Outside Door Mirror Moves when Locking or Unlocking the Vehicle. The door mirror tilts immediately after unlocking or locking. The mirror position does not correspond to the memory position preset by the customer. Read More »
Rear Bumper Trim Warped / Distorted. The center of the rear bumper trim is warped upward and may interfere with opening of the tailgate. No outside damage or customer influence can be detected. Read More »
DOOR CANNOT BE OPENED WITH COMFORT ACCESS: One or more doors are unable to be opened from the outside of the vehicle using the Comfort Access System. Read More »
Valve Stem Replacement with Wheel Electronics. INFORMATION The valve stems are single-use only, and must be replaced every time the wheel electronics are replaced. If you loosen the nut (1), you must replace the valve stem. Read More »
Shudder from the Driveline on Vehicles with xDrive. There is a shudder or vibration from the driveline when taking off from a stop, or when accelerating at highway speeds. Read More »
Valve Stem Replacement with Wheel Electronics. INFORMATION The valve stems are single-use only, and must be replaced every time the wheel electronics are replaced. If you loosen the nut (1), you must replace the valve stem. Read More »
Second seat row blocking access to third seat row, program seat modules. Visible stitching on first row sport seat. Third seat row backrest Bowden cable routing and length change. Read More »
When returning the 2nd row seat 60% (left) side from Easy-Entry: The seat stops moving before reaching the final home position, a check control message (CCM) appears alerting the customer that the seat back is unlocked. Read More »
When returning the 2nd row seat 40% (right) side from Easy-Entry: The seat stops moving before reaching the final home position, a check control message (CCM) appears alerting the customer that the seat back is unlocked. Read More »
The passenger's side (right rear) of the 60/40 split 2nd row seat may intermittently not fully latch into position on one side (inner rail). Read More »
Rattle Noise from Rear Seat Backrest. A rattle noise can be heard from the rear seat area when the vehicle is driven. CAUSE The left and right rear seat backrest locks have insufficient lubrication. Read More »
BMW VEHICLES: DSC WARNING LAMP ILLUMINATED. THE DSC (DYNAMIC STABILITY CONTROL) WARNING LAMP IS ILLUMINATED AND SOME OR ALL OF THE FOLLOWING FAULT CODES ARE STORED: 6E58; 6E04; 53BA; D36F; 55C3; 6ECA; AND THE WIPERS MAY ALSO BE ... Read More »
"REPAIRING TRANSFER CASE ACTUATOR (VTG SERVO-MOTOR). The Anti-lock Brakes (ABS), Brakes and Dynamic Stability Control (DSC) warnings are on and there may also be a ""Drivetrain Malfunction"" warning on in the Control Display. Read More »
CLICKING NOISE FROM FRONT AXLE This Service Information bulletin supersedes SI 31 01 12 dated June 2015. Clicking noises are heard from the front axle area while maneuvering at low speeds (e.g., parking lot maneuvers). Read More »
Side View Camera Does Not Display Picture. The side view camera does not display a picture: z After engaging reverse gear z Activating the side view camera via the switch on the center console near the gear shift CAUSE z Water (moisture) ... Read More »
Vehicle cannot be opened or closed using comfort access, engine start is not possible, and the vehicle may not start when placing the key against the steering column. Read More »
SURFACE RUST ON NEW AIR BAG INFLATORS: The technician finds that the new air bag inflator (aka: gas generator) may have surface rust on the metalhousing . Read More »
INCORRECT TORQUE SPECIFICATION FOR THE HIGH-PRESSURE PUMP IN ISTA: The current version of ISTA states the incorrect tightening torque for the High-Pressure pump M6 mounting bolts to the cylinder head cover. Read More »
Discharged Battery Energy Diagnosis Must Be Performed: The electrical system of BMW vehicles has been subject to an ongoing development process over the last few years. This has led to increased demands being placed on the battery. Read More »
Discharged Battery Energy Diagnosis Must Be Performed: The electrical system of BMW vehicles has been subject to an ongoing development process over the last few years. This has led to increased demands being placed on the battery. Read More »
Discharged Battery Energy Diagnosis Must Be Performed: The electrical system of BMW vehicles has been subject to an ongoing development process over the last few years. This has led to increased demands being placed on the battery. Read More »
Rear Bumper Trim Warped / Distorted. The center of the rear bumper trim is warped upward and may interfere with opening of the tailgate. No outside damage or customer influence can be detected. Read More »
"Power Reduction, FC 2A82 Intake VANOS and/or FC 2A87 Exhaust VANOS Camshaft Faults are Stored in DME. The ""Service Engine Soon"" (MIL) lamp is illuminated and engine power reduction is perceived. Read More »
N63 ENGINE: OIL CONSUMPTION CLASS ACTION SETTLEMENT DIAGNOSIS AND REPAIR PROCEDURES. While engine oil consumption may create a customer inconvenience in the short term it should not cause any drivability problems that would prevent normal ... Read More »
ConnectedDrive/BMW Assist System Diagnosis Information This Service Information bulletin replaces SI B84 02 14 dated July 2014 What's New: Model - Removed models which no longer support BMW Assist functionality and added new models. Read More »
"?Telematics Device Spares Replacement Part Activation via DCSnet for BMW Assist What's New: ? Model: All models added along with 6AC option code ? Situation: All information added ? Information: Deleted CDMA related information and added ... Read More »
"?N63, N63TU, N63R, S63 AND S63TU ENGINES: UPPER OIL PAN REMOVAL AND INSTALLATION REPAIR INSTRUCTIONS This Service Information bulletin supersedes SI B11 17 15 dated October 2016. . Read More »
"USB DEVICE IS NOT DETECTED BY CHAMP2 HEAD UNIT. Media connected to the USB connector is not recognized by the audio system. Playback of files from the media is not possible. Read More »
USB CABLE: BATTERY DISCHARGE/AUDIO FAILURE/RADIO RECEPTION. No sound from the radio, telephone, gong signal and or PDC. Poor radio reception and failure of the telematics systems. Read More »
CLICKING NOISE FROM FRONT AXLE This Service Information bulletin supersedes SI 31 01 12 dated June 2015. Clicking noises are heard from the front axle area while maneuvering at low speeds (e.g., parking lot maneuvers). Read More »
HeadUp Display does not Show Full Street Names. INFORMATION Design of the HUD has limited display area. (It can only show a certain number of text characters). Read More »
N51, N52, N52K and N52T Engines: Various Eccentric Shaft Sensor Faults stored in the DME - Diagnostic Hints This Service Information bulletin and attachment supersedes SI B11 06 16 dated April 2016.. Read More »
"N63, N63TU and N63R Engines: Upper Oil Pan Removal and Installation Repair Instructions This Service Information bulletin supersedes SI B11 17 15 dated August 2015.. Read More »
Bluetooth Connection Failures. There are various connectivity failures with the following devices: Apple iPhones Samsung S6 and the S6 Edge. Connectivity failure examples are: Call disconnection - Call is transferred back to the handset. Read More »
ISTA/P Cannot Program an E-Series N55 Replacement DME. ISTA/P fails when attempting to program a replacement DME (MEVD172) on BN2000 E-Series vehicles with the Continental HPP. Part number: 12 14 8 618 483. Read More »
This Service Information bulletin supersedes SI B07 03 14 dated October 2015. Diagnosing Stored Fault Codes to Help Avoid Repeat Repair Visits. Read More »
This Service Information bulletin supersedes SI B07 03 14 dated May 2015. designates changes to this revision SUBJECT Diagnosing Stored Fault Codes to Help Avoid Repeat Repair Visits. Read More »
"SI B12 10 15 Engine Electrical Systems March 2015 Technical Service This Service Information bulletin supersedes SI B12 10 15 dated January 2015. designates changes to this revision SUBJECT N63: CBS Oil Service Conversion in ISTA/P. Read More »
"SUBJECT N63: CBS Oil Service Conversion in ISTA/P. The CBS oil service conversion being performed for the N63 Customer Car Package and timing chain check (SI B11 16 14) does not work correctly. Read More »
This Service Information bulletin supersedes SI B65 05 09 dated July 2009. designates changes to this revision SUBJECT CIC Headunit: Navigation System Road Map Usage. Read More »
Diagnosing Stored Fault Codes to Help Avoid Repeat Repair Visits. Analysis of FASTA data and repeat repair visit reports indicates that there are many fault codes that are stored in the above vehicles, but they are not diagnosed to ... Read More »
Check Control Messages Related to Battery Charge During Cold Ambient Temperatures. On cold days with an outside ambient temperature of less than 15F, customers may notice a check control message related to the battery that is displayed on ... Read More »
"?Panoramic Sunroof Repair Instructions. INFORMATION Sunroof Repair Instructions: The panoramic sunroof contains several ""mechanism sets"" which can be repaired and/or replaced independently in the event of a mechanical failure. Read More »
"CCC - ""Please Insert Navigation DVD"" Appears on CID. The navigation map DVD cannot be read or detected. The message ""Please insert navigation DVD"" appears in the CID (Central Information Display). The navigation system is inoperative. Read More »
Service Action: CIC - Install Navigation Road Map Database 2013. The Car Information Computer (CIC) road map database 2013 must be installed onto the CIC internal Hard Disc Drive (HDD). Read More »
"Service Action: CIC - Install Navigation Road Map Database 2013. Before delivering affected vehicles to the customer, the Car Information Computer (CIC) road map database 2013 must be installed onto the CIC internal Hard Disc Drive (HDD). Read More »
Vehicle cannot be opened or closed using comfort access, engine start is not possible, and the vehicle may not start when placing the key against the steering column. Read More »
HeadUp Display does not Show Full Street Names. INFORMATION Design of the HUD has limited display area. (It can only show a certain number of text characters). Read More »
Bluetooth Connection Failures. There are various connectivity failures with the following devices: Apple iPhones Samsung S6 and the S6 Edge. Connectivity failure examples are: Call disconnection - Call is transferred back to the handset. Read More »
"SI B12 10 15 Engine Electrical Systems March 2015 Technical Service This Service Information bulletin supersedes SI B12 10 15 dated January 2015. designates changes to this revision SUBJECT N63: CBS Oil Service Conversion in ISTA/P. Read More »
BMW: ELCTRONICALLY DISCONNECTING THE JUNCTION BOX WITHOUT DISCONNECTING THE BATTERY WILL CAUSE DAMAGE TO THE REAR POWER DISTRIBUTION BOX. *RM Read More »
BMW: THE TELEMATICS CONTROL UNIT (TCU) IN VEHICLES MAY NOT HAVE BEEN PROPERLY ACTIVATED. THIS CAUSES THE MANUAL AND AUTOMATIC EMERGENCY CALL AND ROADSIDE CALL (BMW ASSIST) NOT TO FUNCTION. MODELS E53, E60, E90, E83 ARE AFFECTED. Read More »
BMW VEHICLE: FC 2EF4 CHARACTERISTIC MAP THERMOSTAT. COMPLAINTS THAT THE SERVICE ENGINE SOON LAMP IS ILLUMINATED. FAULT CODE 2EF4 CHARACTERISTIC MAP THERMOSTAT IS STORED IN DME FAULT MEMORY. Read More »
BMW VEHICLE: ELECTRONIC MALFUNCTION CC MESSAGE CAUSED BY SHORTED WIRING. THE ELECTRONIC MALFUNCTION CHECK CONTROL MESSAGE MAY BE DISPLAYED; THE SOUNDS SYSTEM EMITS A STATIC NOISE FROM THE SPEAKERS; THE RFK (REAR VIEW CAMERA) DOES NOT ... Read More »
Previously assigned radio channels to the satellite radio "Presets" list have been erased and radio channels selected from the list "All channels" menu cannot be stored in the "Presets" list. Read More »
Service Action: CIC - Install Navigation Road Map Database 2013. Before delivering affected vehicles to the customer, the Car Information Computer (CIC) road map database 2013 must be installed onto the CIC internal Hard Disc Drive (HDD). Read More »
NAVIGATION SYSTEM: REPORTING MISSING OR INCORRECT ROAD MAP DATA: The route guidance is inaccurate and therefore irritating to the customer; or it is not possible to locate certain addresses, for ... Read More »
NAVIGATION SYSTEM: REPORTING MISSING OR INCORRECT ROAD MAP DATA: The route guidance is inaccurate and therefore irritating to the customer; or it is not possible to locate certain addresses, for ... Read More »
This Service Information bulletin supersedes SI B65 05 09 dated July 2009. designates changes to this revision SUBJECT CIC Headunit: Navigation System Road Map Usage. Read More »
This Service Information bulletin supersedes SI B65 10 09 dated March 2013. designates changes to this revision SUBJECT CIC head unit: Vehicle Position Is Missing or Incorrect on Navigation Map. Read More »
Traffic Information Is Inoperative. The traffic information is intermittently or permanently inoperative. * Traffic flow is not displayed on the navigation map. * The traffic list is empty. 1. Read More »
BMW: THE TELEMATICS CONTROL UNIT (TCU) IN VEHICLES MAY NOT HAVE BEEN PROPERLY ACTIVATED. THIS CAUSES THE MANUAL AND AUTOMATIC EMERGENCY CALL AND ROADSIDE CALL (BMW ASSIST) NOT TO FUNCTION. MODELS E53, E60, E90, E83 ARE AFFECTED. Read More »
"?Panoramic Sunroof Repair Instructions. INFORMATION Sunroof Repair Instructions: The panoramic sunroof contains several ""mechanism sets"" which can be repaired and/or replaced independently in the event of a mechanical failure. Read More »
BMW VEHICLES: N63 TURBOCHARGER AUXILIARY WATER PUMP FAULTS. THE SERVICE ENGINE SOON LAMP IS ILLUMINATED WITH THE FOLLOWING FAULT CODES STORED IN THE DME CONTROL MODULE. Read More »
BMW: REPLACE THE CHAIN TENSIONING RAIL BEARING BOLT THAT COULD COME LOOSE AND CAUSE DAMAGE TO THE ENGINE. MODELS E60 (5 SERIES), E70 (X5 SERIES), E83 (X3 SERIES), E9X (3 SERIES). *PE Read More »
Discharged Battery Energy Diagnosis Must Be Performed: The electrical system of BMW vehicles has been subject to an ongoing development process over the last few years. This has led to increased demands being placed on the battery. Read More »
Discharged Battery Energy Diagnosis Must Be Performed: The electrical system of BMW vehicles has been subject to an ongoing development process over the last few years. This has led to increased demands being placed on the battery. Read More »
Discharged Battery Energy Diagnosis Must Be Performed: The electrical system of BMW vehicles has been subject to an ongoing development process over the last few years. This has led to increased demands being placed on the battery. Read More »
"USB DEVICE IS NOT DETECTED BY CHAMP2 HEAD UNIT. Media connected to the USB connector is not recognized by the audio system. Playback of files from the media is not possible. Read More »
SUBJECT Audio System Speaker Testing. For audio system speaker testing there is a NED (Non Electrical Diagnosis) Test Plan available. CAUSE We previously recommended use of the Audio Test CD (ATC) from BMW. This CD has been discontinued. Read More »
SI B84 03 14 February 2016 Communication Systems Technical Service This Service Information bulletin supersedes SI B84 03 14 dated October 2014. SUBJECT Bluetooth Connection Failures. Read More »
iPhone 6, 6 Plus, 5, 5S, 5C, 4S, 4, and 3GS with iOS 8.x Information. INFORMATION There is one major difference in functionality since iOS 8.0 was released. Scenario: z The customer leaves the vehicle and turns his or her phone off. Read More »
Check Control Messages Related to Battery Charge During Cold Ambient Temperatures. On cold days with an outside ambient temperature of less than 15F, customers may notice a check control message related to the battery that is displayed on ... Read More »
Whistling Noise Coming from the Center Vent - A/C is Off . A very high pitched whistling or beeping noise is heard coming from the center vents. The flow of refrigerant through the expansion valve at certain temperature differentials. Read More »
Window Guide Is Pushed up and Distorted. The customer may notice the front window seal looks deformed or distorted in the uppermost area of the window. Read More »
