Defective drive train - on March 11, 2019 my drive train malfunction and which damage my engine. This is an safety concern because my car stop on the freeway while I was driving. BMW mfg knew about the defective drive train prior to me purchasing car from fields BMW on July 2013. BMW North America offer to pay 21,000 for the engine replacement and they want me to pay $6,000 and I feel BMW know about the faulty design in 2012 and did not inform the consumer. When I purchase the car, it had 18,000 miles on it and I put 62,000.00

- Wimauma, FL, USA

Last week I was on the NJ turnpike when all of a sudden my car stall and lost power, I barley got off the turnpike when the car came to a completely stop. No warning messages or noises just stopped. Fortunately no accident occurred due to this but could have been an ugly one. The car would not start and was towed to the BMW dealer. The car was inspected, oil was clean, no water damage, however they tell me I need a new engine (13K) has the engine seized without telling me what caused it.the car has 83K miles. I've been a BMW owner for 19 years. I now have mixed feelings about BMW and the way I feel now I will nevery buy another BMW as I'm not getting the attention I thin I deserve. Any advice is greatly appreicated!

- Bayonne, NJ, USA

I was driving down the highway and my 'low oil pressure' light came on so I pulled over to the side of the road immediately and shut the car off. I had the car towed to a certified BMW repair shop global imports. The BMW service center confirmed the failure was the drive chain causing the engine to seize and needing to be replaced. As I researched the issue I found thousands of similar internet stories elaborating on the design flaws in the engine that uses plastic flywheels for the drive chain/oil pump chain. BMW extended the warranty for this issue beyond their normal 4 year 48,000 miles to 7 years and 70,000 miles. I am at 76,000 miles just out of warranty. It is odd they extended the warranty years by 3 but only extended the warranty miles an additional 22,000 miles or an average of 7,333 miles per year. Who only drives 7,333 miles a year. BMW's other extended warranties usually offer an average of 12,000 miles per year on the additional years it is extended. The other extended warranties for this engine were extended 10 years and 120,000 miles. I was diligent in changing the oil long before the recommended change intervals issued by BMW. There is no reason an engine would seize at 76,000 miles when the regular maintenance was followed unless there was a major engine design flaw. BMW has already acknowledged the engine design issues by extending the warranty on the 'timing chain and oil pump drive chain', 'engine oil feedline' to the turbo charger and the 'fuel tank leak diagnostic module (nvld)'. with this being a known design flaw and the number of issues there should be a recall on this engine so the fly wheels can be replaced with a better part or at very least BMW should be forced to extend the warranty and miles as they do with other warranty extensions. This design flaw caused the engine to stop in the middle of the highway which is very dangerous.

- Woodstock, GA, USA

The car front and rear tires were of different size and I noticed when I got the car from dealer next day as the car would drift towards one side. It gave "drivetrain error" since its all wheel drive with power not being equally distributed due to different RPM on front and rear. This wasn't the case when I test drove the day before. I kept thinking its a transmission issue but it was tire that was causing it. At high speed (40-60mph) when I take off from gas the car would drift to one side and would stall. This is serious safety issue and could have caused not only passenger life but also major transmission and drivetrain breakdown. The dealer swapped the tires because with mismatched tires the car would have been non-drivable at the time I bought. This AWD is very sensitive to tires tread differences. After calling dealer he is denying and saying its "as-is" and not responsible for anything.

- Corpus Christi, TX, USA

Turbo charger system is affected due to the engine oil filter housing failing which caused oil to transfer through out the turbo system into the coolant reservoir resulting in black sludge that caused my car to stall and not run and have to be towed. Every since this recall issue my car gives the drive-train malfunction warning which when diagnosed indicates low turbo boost pressure which I'm certain has to do with the black sludge that ran through the turbo system and coolant system because of the engine oil filter housing failing. A software update was recommended that BMW is not willing to pay for or I need to pay $3660 to replace the turbo charger which I truly believe is the result of the oil filter housing fail and oil leaking into the turbo system and the coolant system.

- Waynesboro, VA, USA

Takata recall. The contact owns a 2012 BMW 5-series. The contact received notification of NHTSA campaign numbers: 17V020000 (air bags) and 17V138000 (power train). The part for the recall repair was unavailable. The contact spoke with the dealer, BMW of columbus, Georgia, and was informed that parts were ordered for NHTSA campaign number: 17V020000 (air bags); however, VIN tool confirms remedy not yet available for the recall. The contact stated that the manufacturer exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available and parts distribution disconnect.

- Upatoi, GA, USA

I was driving at about 65 mph on a highway uphill, engine completely stalled, no power, got a message "drive-train malfunction, no maximum output, drive moderately". I was surrounded by cars/semi trucks, very dangerous situation. Managed to pull over on the should. Could not restart car, got a message "automatic start/stop deactivated: Engine will not start automatically. Press the start/stop button to start the engine." About 30 mins after engine stalled, I finally restarted the car. Continued to drive on the highway for about 10 miles @ 60-65 mph. At a local street, as I slowed down to approach a traffic light, engine stalled again, no power, car stopped in the middle of road, got the two same messages, could not start car. About 30 mins after engine stalled, I finally started the car.

- Blacksburg, VA, USA

The contact owns a 2012 BMW 528I. While driving 20 mph, the vehicle lost power. The coolant fluid, transmission malfunction, and please have car serviced lights were illuminated. The vehicle was towed to the dealer where it was diagnosed that the engine oil filter housing needed to be changed. The vehicle was not repaired. The manufacturer was notifed of the failure. The vehicle was not included in a recall, but there was a manufacturer communication. The failure mileage was 34,000.

- Staten Island, NY, USA

Vehicle bought in July 2014 with ~24K miles; still under factory warranty. Maintenance maintained. 9-12 months later, a "drive train malfunction" light came on. I had just left the dealership so I called them and they told me to bring it back immediately; I did. Many tests later, was told my "motherboard died" (dme unit); after a month in the shop...repaired. Now, 4/2016, less than 60K and fresh out of warranty...I was driving home with my son on the interstate, about to get off of my exit and another "drive train malfunction and low engine pressure" light comes on and then all of a sudden my car stopped on the 4 lane off-ramp. After waiting for an hour for the tow truck to arrive and trying to put my car into neutral and about 30 min with the tow truck driver trying to put the car in neutral, I called the BMW dealership and I found out that because my car is all electric it cannot be put into neutral; a week at the dealership and still there as I type'diagnosis: Timing chain broke into the engine and now the car needs a new engine which I was quoted to be $21,000. The car is only 4 years old!!!!! needless to say, it was by the grace of god that my son and I were not injured or killed when the engine just shut off in the middle of traffic. And on top of that, it is absurd that the consumer cannot manually put this vehicle into neutral to move it out of harm's way if it's possible to do so. The only way to put the car in neutral when inoperable is to take it to the dealership. Unsat! and for a car company that is supposed to have a great reputation and high standards, it's absurd that a new engine is needed for a car that is barely 4 years old. I have seen the same issues with other BMW owners all over the internet. Love BMW and have owned 3 of them and it's unfortunate that this one will be my last because I do not feel safe in this vehicle anymore.

- Arlington, VA, USA

In Oct. 2015 I pulled out of my street into traffic and lost all power. " drivetrain malfunction" displayed on dash, the car loses all power and goes into "limp" mode, goes like 5 mph max. Thankfully I got it off the street without being hit, turned it off and restarted it, display was gone and I was able to drive it normally. After my heartrate slowed and I got to the office I called and made an appt. To have it looked at. It had 48K miles at the time of the first incident and still under warranty. After leaving it with the dealer for over a week, they told me that they reprogrammed the car to the latest software and should be fine. Now fast-forward to Jan 2016, 54K miles, my wife was driving it along and same thing happened, "powertrain malfunction" displayed on dash car went into limp mode, there was no where to pull over in morning rush hour, had to put hazards on until she could get to a safe location to pull over. Turned it off, restarted and was able to drive again. She was very scared and shaken. Called the dealer from which we bought it new and am taking it in today. Thus, after researching this issue it seems to be a common occurrence which has been going on with BMW's. before someone gets hurt or killed something needs to be done to make sure this does not happen. From what I've read I am not the only BMW owner who has experienced this problem!

- St. Louis, MO, USA

Last month my car was approximately 52,200 miles (out of warranty) and leaking oil all over my driveway and under the hood. It cost me $1570 to fix by replacing the fiter casing. Luckily that the oil leak was in my driveway. What if I was on the freeway? this is totally unsafe car to drive. The local shop told me that the filter housing (2012 version) was made of plastic and the current BMW one 2014 is made of metal. The local shop told me to call BMW if there is any recall for this. So before fixing it local shop, I did call the crevier BMW in santa ana, ca and the service advisor told me that there is no recall for the filter housing and my car was out of warranty. I told the BMW advisor that I cannot believe that a 2012 BMW 528I with 52K miles on it and leaking oil all over the place. The BMW advisor told me that I drove too much. What kind of service is that? and BMW will not cover it. So BMW cannot be driven over 50K miles. I also did call BMW corporate and someone from BMW corporate called me back that and said nothing BMW can do about this. Now I found out because of the oil leak, the alternator is having problem. I want to report this incident so that BMW should be responsible to similar cases of their unsafe cars. [xxx] 'information redacted pursuant to the Freedom Of Information Act (FOIA), 5 U.S.C. 552(B)(6).

- Huntington Beach, CA, USA

Driving in the hov at approximately 9pm when an alert message "drivetrain malfunction, drive moderately" displays. Car engine immediately cuts out and we have no propulsion. We are unable to move to a safe location and wind up on a narrow shoulder of the lie in NY. Police come and close down 2 lanes to prevent collision (extremely dangerous road conditions). We were unable to start the car or shift it into neutral. Car was towed. BMW notifies us that fuel sensors malfunctioned resulting in us running out of gas even thought the indicator showed we had 1/2 tank. However because we were over the 50,000 mile warranty we would be responsible for replacing.. BMW is looking for us to pay $3,100 to have the fuel sensors replaced. I researched this and found that BMW had issued a recall on its 2011 5 series sedans and 2012 5 series GT for a fuel sensor malfunction that mirrors exactly what happened to us. We purchased our BMW Nov 2011. We strongly believe this fuel sensor defect both in design and functionality is the reason behind what happened to us. Put my family and 6 police patrol men in harms way. Notified BMW that they need to extend their recall to other 2012 5 series sedans given our experience. Felt compelled to notify you as there may be other drivers who will be put in harms way if this problem is not reconciled on all 2012 5 series sedans. We were lucky we were not injured. Someone else might not be.

- Bay Shore, NY, USA

The contact owns a 2012 BMW 550ix equipped with Goodyear Eagle P245/40/R19. The contact stated that while driving 45 mph an alert on his dashboard illuminated instructing him that the vehicle should not be driven more than 50 miles as the tire was going flat. Thirty miles later the vehicle was stopped and the front driver side tire had developed a bubble on the sidewall, which caused the tire to shred. The vehicle dealer was notified but offered no assistance. The manufacturer of the vehicle was notified but offered no assistance. The tires had not been replaced. Updated 12/14/12 the consumer replaced all four tires with Michelin tires. The consumer stated two of the original four tires developed bubbles on the sidewall. On two occasions, the drive train malfunctioned. The video screen flashed a message instructing the consumer to return the vehicle to the dealer. In the process, the vehicle lost a considerable amount of power output and shook violently when driven over 30 mph. Updated 07/09/13

- Upper Saddle River, NJ, USA