On October 12, 2021 the above described car had a catastrophic failure of the power system. All functions ceased and the car was dead towed on a flatbed truck. Because the tow mode could not be engaged due to loss of all power the vehicle was dragged onto the flatbed. The repair indicated the cause was a The Battery Energy Control Module (BECM). This is noted in recall R10078. This car was sent for service in April where a request for a software update was made. At that service, no recall was noted and no update was given for this condition. There has been no attempt to recall this vehicle for this problem and it is not noted as a recall for this vehicle. The failure of the energy module caused a complete loss of all power and an inability to move the car.

- Loveland, OH, USA

The 2021 XC 40 vehicle will periodically not restart - may be something to do with the safety key or some other electrical malfunction. The dashboard shows the battery symbol when the car will not restart as if the vehicle is dead (no electrical connection). Also, when the start button is depressed the dashboard illuminates with the dead battery signal, but otherwise, it seems the button is not connected to the vehicle in that the engine does not respond. Also, we had an issue where the vehicle, while we were beginning to stop at a stop sign, went dead and was not responsive. The -??Start/Stop-?? function, although engaged in the center console, is often not operational and will show in the dashboard that it is not operational, but then, randomly (not consistent with the reasons itemized in the Volvo manual for why the start/stop function may not work), will work on a few stops for that particular drive and then revert back to not being operational on the next trip, although it is engaged to be -??on-?? in the center console. Again, this appears to be a sign or symptom of some sort of electrical malfunction. Now, most recently, my wife and daughter were driving the vehicle, and it lost power and shut off in the middle of the road, horrifying these two individuals and greatly upsetting me that a vehicle sold by Volvo would perform so poorly and create a significant hazard to driver and passengers of the vehicle (not to mention others on the roadway). Again, and clearly, there appears to be some sort of electrical malfunction. Clearly, what we first reported to Volvo on or about May 17, 2021 was an electrical problem that Volvo had an idea or knowledge (knew or should have known) that was or may be similar to the problem they had already issued a recall for on the XC 40 recharge.

- Birmingham, AL, USA