STEERING

• TSB #RTJ-19994

  Date Announced:

  JUL 01, 2009

  NHTSA ID:

  #10032645

  VOLVO: ANTI SKID SERVICE REQUIRED MESSAGE, SWM-0201, BCM-0109, EPS-0080. NEW SWM SOFTWARE HAS BEEN IMPLEMENTED INTO PRODUCTION AFTER THE CHASSIS RANGE IN THE HEADER. *PE Read More »

STEERING:ELECTRIC POWER ASSIST SYSTEM

• TSB #RTJ-19994

  Date Announced:

  JUL 01, 2009

  NHTSA ID:

  #10032645

  VOLVO: ANTI SKID SERVICE REQUIRED MESSAGE, SWM-0201, BCM-0109, EPS-0080. NEW SWM SOFTWARE HAS BEEN IMPLEMENTED INTO PRODUCTION AFTER THE CHASSIS RANGE IN THE HEADER. *PE Read More »

SUSPENSION:FRONT:SPRINGS:COIL SPRINGS

• TSB #TJ-18381-7

  Date Announced:

  DEC 21, 2010

  NHTSA ID:

  #10037821

  VOLVO: WHEN GOING OVER BUMPS OR ON AN UNEVEN ROAD THERE MAY BE A KNOCKING OR RATTLING NOISE FROM THE FRONT STRUTS. THERE MAY BE A DEFECTIVE TOP BEARING OR A COIL SPRING IN CONFLICT WITH THE BODY STRUT TOWER. Read More »

SUSPENSION:FRONT:CONTROL ARM

• TSB #TL-20109

  Date Announced:

  SEP 02, 2010

  NHTSA ID:

  #10034507

  VOLVO: KNOCKING NOISE FROM FRONT CONTROL ARM, REAR BUSHING. A KNOCKING OR RATTLING METALLIC NOISE FROM THE FRONT SUSPENSION AT START AND STOP, AND IN COME CASES PULLING OR A MISALIGNED STEERING WHEEL. Read More »

SUSPENSION:FRONT:WHEEL BEARING

• TSB #RTJ-14669

  Date Announced:

  JUL 16, 2009

  NHTSA ID:

  #10030930

  VOLVO: FRONT WHEEL HUB AND DRIVER SHAFT, BEARING NOISE. AT TIMES A BEARING (BUZZING) NOISE CAN BE HEARD FROM THE FRONT OF THE VEHICLE DURING NORMAL DRIVING. THE NOISE WILL GET HIGHER IN PITCH AS VEHICLE SPEED INCREASES. Read More »

SERVICE BRAKES, HYDRAULIC:POWER ASSIST:VACUUM

• TSB #RTJ-20293

  Date Announced:

  APR 27, 2009

  NHTSA ID:

  #10030425

  A SERVICE KIT HAS BEEN DEVELOPED TO REDUCE THE CURRENT THROUGH THE VACUUM SWITCH FOR THE BRAKE VACUUM PUMP. *PE UPDATED 12/30/09. *PE Read More »

SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP:CONTROL UNIT/MODULE

• TSB #RTJ-17583

  Date Announced:

  OCT 27, 2009

  NHTSA ID:

  #10032910

  VOLVO: BRAKE CONTROL MODULE (BCM), NOT IN PROG MODE AFTER REPLACEMENT OF BCM. VIDA MAY GIVE THE ERROR BCM NOT IN PROG MODE WHEN TRYING TO PERFORM A BCM RELOAD. WORK IS ONGOING TO RESOLVE THE ISSUE. THE ISSUE IS NOT VEHICLE RELATED. Read More »

SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP:ABS WARNING LIGHT

• TSB #TJ-10438-8

  Date Announced:

  OCT 27, 2010

  NHTSA ID:

  #10037240

  VOLVO: THE ABS LIGHT IS ON WITH FOUR POSSIBLE TORUBLE CODES. *RM Read More »

• TSB #RTJ-10438

  Date Announced:

  JAN 13, 2010

  NHTSA ID:

  #10030360

  VOLVO: COMPLAINTS REGARDING AN ILLUMINATED ABS WARNING LAMP IN THE DIM (DRIVER INFORMATION MODULE). *PE UPDATED 8/27/10. *PE Read More »

SERVICE BRAKES, AIR:ANTILOCK

• TSB #TJ-5931

  Date Announced:

  MAY 14, 2010

  NHTSA ID:

  #10033816

  VOLVO: UNNECESSARY BRAKE CONTROL MODULE (BCM) REPLACEMENTS. WHEN DIAGNOSING DIAGNOSTIC TROUBLE CODES (DTC'S) FOR BRAKE CONTROL SYSTEM, TECHNICIAN MUST ALWAYS FOLLOW COMPLETE DIAGNOSTIC FAULT TRACING PATH IN VIDA. Read More »

SERVICE BRAKES, AIR:ANTILOCK:CONTROL UNIT/MODULE

• TSB #RTJ-19994

  Date Announced:

  JUL 01, 2009

  NHTSA ID:

  #10032645

  VOLVO: ANTI SKID SERVICE REQUIRED MESSAGE, SWM-0201, BCM-0109, EPS-0080. NEW SWM SOFTWARE HAS BEEN IMPLEMENTED INTO PRODUCTION AFTER THE CHASSIS RANGE IN THE HEADER. *PE Read More »

SERVICE BRAKES, AIR:ANTILOCK:WHEEL SPEED SENSOR

• TSB #3742

  Date Announced:

  AUG 24, 2007

  NHTSA ID:

  #10022613

  FRONT WHEEL SPEED SENSOR CABLE REPAIR METHOD. *KB Read More »

SERVICE BRAKES, AIR:ANTILOCK:ABS WARNING LIGHT

• TSB #TJ-10438-8

  Date Announced:

  OCT 27, 2010

  NHTSA ID:

  #10037240

  VOLVO: THE ABS LIGHT IS ON WITH FOUR POSSIBLE TORUBLE CODES. *RM Read More »

PARKING BRAKE

• TSB #TJ-3871

  Date Announced:

  MAY 05, 2010

  NHTSA ID:

  #10033807

  VOLVO: PARK ASSIST DOES NOT WORK; NOT POSSIBLE TO READ DTC FROM PAM VIA VIDA. A NEW PAM (PARKING ASSISTANCE MODULE) WAS INTRODUCED 2009W23, BUT DUE TO PAM WARRANTY REPLACEMENTS OR ACCESSORY INSTALLATIONS, IT CAN ALSO BE FITTED IN OLDER ... Read More »

• TSB #55159

  Date Announced:

  AUG 15, 2006

  NHTSA ID:

  #10020423

  PARKING BRAKE OWNER'S MANUAL SUPPLEMENT/ADJUSTMENT. VOLVO. *KB Read More »

ENGINE AND ENGINE COOLING:ENGINE

• TSB #SMB-28-200

  Date Announced:

  AUG 27, 2008

  NHTSA ID:

  #10026145

  VOLVO: EXTENDED WARRANTY COVERAGE FOR THE ENGINE MANAGEMENT SOFTWARE (EMS) ON SOME MODEL YEAR 2003-2008 MODELS. P-54 CSC LETTER WAS RECEIVED. *PE Read More »

• TSB #S-M-B-28-200

  Date Announced:

  AUG 27, 2008

  NHTSA ID:

  #10026147

  VOLVO: EXTENDED WARRANTY COVERAGE FOR THE ENGINE MANAGEMENT SOFTWARE (EMS) ON SOME MODEL YEAR 2003-2008 MODELS. P-76 CSC LETTER WAS RECEIVED. *PE Read More »

• TSB #2871

  Date Announced:

  JUN 01, 2006

  NHTSA ID:

  #10020264

  LONG CRANK OR STUMBLING IDLE WHEN MAKING A COLD START. *TT Read More »

FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY

• TSB #RTJ-16629

  Date Announced:

  MAY 15, 2009

  NHTSA ID:

  #10030359

  VOLVO: LEAKAGE DETECTION DIAGNOSTICS IMPROVEMENTS TO REMEDY DTC'S. ALL MODELS FROM MODEL YEARS 2003-2008. Read More »

• TSB #28-74

  Date Announced:

  JAN 03, 2008

  NHTSA ID:

  #10022612

  LEAKAGE DIAGNOSTIC FUNCTION IMPROVEMENTS TO REMEDY DTC'S. *KB UPDATED 1/22/08. *NJ UPDATED 4/7/08. *NJ Read More »

FUEL SYSTEM, GASOLINE:STORAGE:AUXILLARY TANK

• TSB #28-74

  Date Announced:

  JAN 03, 2008

  NHTSA ID:

  #10022612

  LEAKAGE DIAGNOSTIC FUNCTION IMPROVEMENTS TO REMEDY DTC'S. *KB UPDATED 1/22/08. *NJ UPDATED 4/7/08. *NJ Read More »

FUEL SYSTEM, GASOLINE:DELIVERY:FUEL PUMP

• TSB #SMB 23-037

  Date Announced:

  JAN 17, 2012

  NHTSA ID:

  #10043544

  PUMP ELECTRONIC MODULES (PEM) TO PRIOR APPROVAL. *KB Read More »

POWER TRAIN:AUTOMATIC TRANSMISSION

• TSB #RTJ-21324

  Date Announced:

  JUL 10, 2009

  NHTSA ID:

  #10032425

  VOLVO: THE 5 SPEED AUTOMATIC TRANSMISSION, AW55-50/51, HAS A BOLT ON TOP THAT ANCHORS THE B4 BAND, WHICH APPLIES 3RD GEAR. IF THAT BOLT IS REMOVED, THE BAND WILL BE DISENGAGED AND 3RD GEAR WILL BE INOPERATIVE. Read More »

POWER TRAIN:AUTOMATIC TRANSMISSION:CONTROL MODULE (TCM/PCM/TECM)

• TSB #4002

  Date Announced:

  JUL 07, 2006

  NHTSA ID:

  #10016434

  TRANSMISSION CONTROL MODULE (TCM) UPGRADES AVAILABLE TO CORRECT COMPLAINTS/SYMPTOMS. *TT Read More »

ELECTRICAL SYSTEM

• TSB #3740

  Date Announced:

  OCT 25, 2007

  NHTSA ID:

  #10022375

  INTERMITTENT ELECTRICAL DOOR FUNCTIONS. *KB UPDATED ON 12/7/07. *NJ Read More »

ELECTRICAL SYSTEM:12V/24V/48V BATTERY

• TSB #SPJ3070120160419

  Date Announced:

  APR 19, 2016

  NHTSA ID:

  #10087107

  THIS IS A SERVICE PRODUCT JOURNAL : THE PREVIOUSLY REPORTED ISSUE WITH VIDA 2015 AND BATTERY TESTING HAS BEEN RESOLVED. VIDA 2015 BATTERY TESTING IS THE ONLY APPROVED METHOD FOR PRODUCING BATTERY TEST CODES. Read More »

ELECTRICAL SYSTEM:WIRING: REAR COMPARTMENT/TRUNK

• TSB #83163

  Date Announced:

  NOV 08, 2006

  NHTSA ID:

  #10022213

  TRUNK LID WIRE HARNESS PROTECTION. *KB Read More »

ELECTRICAL SYSTEM:SOFTWARE

• TSB #TJ31543

  Date Announced:

  OCT 21, 2016

  NHTSA ID:

  #10088666

  THIS IS A TECHNICAL JOURNAL: THIS JOURNAL IS A GUIDE FOR PERFORMING SOFTWARE DOWNLOADS. SERVICE: *SEE GUIDE UPDATED OCT. 12, 2016 FOR RELEVANT P5/SPA SOFTWARE DOWNLOAD INFORMATION: P5_SPA_SW_GUIDE. Read More »

• TSB #RTJ-19994

  Date Announced:

  JUL 01, 2009

  NHTSA ID:

  #10032645

  VOLVO: ANTI SKID SERVICE REQUIRED MESSAGE, SWM-0201, BCM-0109, EPS-0080. NEW SWM SOFTWARE HAS BEEN IMPLEMENTED INTO PRODUCTION AFTER THE CHASSIS RANGE IN THE HEADER. *PE Read More »

• TSB #RTJ-16629

  Date Announced:

  MAY 15, 2009

  NHTSA ID:

  #10030359

  VOLVO: LEAKAGE DETECTION DIAGNOSTICS IMPROVEMENTS TO REMEDY DTC'S. ALL MODELS FROM MODEL YEARS 2003-2008. Read More »

EXTERIOR LIGHTING:HEADLIGHTS

• TSB #35-15

  Date Announced:

  MAY 02, 2008

  NHTSA ID:

  #10024832

  HEADLAMP CONDENSATION - SEAL TEST. *NJ UPDATED 07/11/2008. *PE Read More »

AIR BAGS

• TSB #RTJ-19139

  Date Announced:

  OCT 17, 2008

  NHTSA ID:

  #10027424

  VOLVO VEHICLES: PAD LAMP, LOGIC CHANGED WITH SRS SW UPGRADE. THE PAD (PASSENGER AIRBAG DISABLED) LAMP ILLUMINATES WHEN THE FRONT PASSENGER SEAT IS UNOCCUPIED. Read More »

• TSB #88-48

  Date Announced:

  MAY 21, 2008

  NHTSA ID:

  #10025021

  PAD PASSENGER AIRBAG DISABLED LIGHT LOGIC CHANGED WITH SRS SOFWARE UPGRADE. *PE Read More »

AIR BAGS:FRONTAL

• TSB #RTJ-19139

  Date Announced:

  OCT 17, 2008

  NHTSA ID:

  #10027424

  VOLVO VEHICLES: PAD LAMP, LOGIC CHANGED WITH SRS SW UPGRADE. THE PAD (PASSENGER AIRBAG DISABLED) LAMP ILLUMINATES WHEN THE FRONT PASSENGER SEAT IS UNOCCUPIED. Read More »

AIR BAGS:FRONTAL:SENSOR/CONTROL MODULE

• TSB #RTJ-19139

  Date Announced:

  OCT 17, 2008

  NHTSA ID:

  #10027424

  VOLVO VEHICLES: PAD LAMP, LOGIC CHANGED WITH SRS SW UPGRADE. THE PAD (PASSENGER AIRBAG DISABLED) LAMP ILLUMINATES WHEN THE FRONT PASSENGER SEAT IS UNOCCUPIED. Read More »

• TSB #8845

  Date Announced:

  FEB 08, 2007

  NHTSA ID:

  #10021204

  PASSENGER AIRBAG OFF INDICATION WITH BELTED ADULT PASSENGER. *KB Read More »

SEAT BELTS:FRONT

• TSB #SMB-88-001A

  Date Announced:

  OCT 13, 2011

  NHTSA ID:

  #10041668

  VOLVO: FOR OWNERS WHO REQUIRE FRONT SEAT BELT EXTENDERS WHICH ARE AVAILABLE. *PE Read More »

STRUCTURE:BODY:TRUNK LID

• TSB #175

  Date Announced:

  JUL 16, 2007

  NHTSA ID:

  #10022534

  RETRACTABLE HARD TOP MECHANISM WILL BE INSPECTED / REPLACED IF NECESSARY. REROUTING OF THE WIRING HARNESS IN THE HARD TOP MECHANISM. TRUNK LID SEAL WILL BE REPLACED. SRS CONTROL UNIT WILL BE INSPECTED / REPLACED IF NEEDED. Read More »

STRUCTURE:BODY:ROOF AND PILLARS

• TSB #SA-211B

  Date Announced:

  MAR 27, 2009

  NHTSA ID:

  #10028847

  VOLVO: RETRACTABLE HARD TOP *RHT): SEAL CARRIER TICKING/SNAPPING NOISE. A TICKING/SNAPPING NOISE FROM THE FRONT AND CENTER ROOF PANELS OF THE RHT CAN BE HEARD WHEN IN USE. *PE Read More »

• TSB #SA-211A

  Date Announced:

  MAR 02, 2009

  NHTSA ID:

  #10028845

  VOLVO: RETRACTABLE HARD TOP (RHT):HEADLINING CLIP NOISE. A RATTLING NOISE FROM THE FRONT AND MIDDLE OF THE HEADLINING AREA OF THE RHT CAN BE HEARD WHEN IN USE. *PE Read More »

TIRES

• TSB #US15309.4.1

  Date Announced:

  APR 23, 2012

  NHTSA ID:

  #10044085

  VOLVO: EXCESSIVELY NEGATIVE REAR CAMBER MAY CAUSE UNEVEN TIRE WEAR AND THIS MAY BE ACCOMPANIED BY ABNORMAL ROAD NOISE OR RIDE. REFER TO THE CAMBER ANGLE SPECIFICATION IN RTJ 19674. ALSO INCLUDED MODELS S40,C30, AND V50 MODEL YEAR 2012. Read More »

TIRES:PRESSURE MONITORING AND REGULATING SYSTEMS

• TSB #00211

  Date Announced:

  JUL 15, 2007

  NHTSA ID:

  #10022699

  NEW TECHNICAL COURSES AVAILABLE. INTRODUCTION TO TIRE PRESSURE MONITORING SYSTEMS - CLASSES NOW AVAILABLE. THIS COURSE IS INTENDED TO FAMILIARIZE TECHNICIANS AND WORKSHOP FOREMEN WITH VOLVO'S TIRE PRESSURE MONITORING SYSTEMS. Read More »

EQUIPMENT

• TSB #SMB17-2017A

  Date Announced:

  OCT 08, 2016

  NHTSA ID:

  #10088566

  VOLVO CARS SERVICE AND PARTS BUSINESS SERVICE MANAGER BULLETIN TITLE : RETAIL CAR DELIVERY PROCESS ALL MY 2016 S60 , V60 , XC60 , XC70 AND S80 GROUP : NO:ISSUING DEPARTMENT : CAR MARKET : UNITED STATES AND CANADA 17 2016A SERVICE ... Read More »

• TSB #ST21520160422

  Date Announced:

  APR 22, 2016

  NHTSA ID:

  #10087143

  THIS IS A SPECIAL TOOL : NEWSLETTER 69 Read More »

EQUIPMENT:ELECTRICAL

• TSB #TJ-21297-2

  Date Announced:

  DEC 07, 2010

  NHTSA ID:

  #10037819

  VOLVO: WHEN A TRAILER IS ATTACHED THAT HAS LED LIGHTS THERE MAY BE A LIGHTING PROBLEM. *RM Read More »

EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

• TSB #SMB17-2017A

  Date Announced:

  OCT 08, 2016

  NHTSA ID:

  #10088566

  VOLVO CARS SERVICE AND PARTS BUSINESS SERVICE MANAGER BULLETIN TITLE : RETAIL CAR DELIVERY PROCESS ALL MY 2016 S60 , V60 , XC60 , XC70 AND S80 GROUP : NO:ISSUING DEPARTMENT : CAR MARKET : UNITED STATES AND CANADA 17 2016A SERVICE ... Read More »

• TSB #SMB00-354

  Date Announced:

  OCT 07, 2016

  NHTSA ID:

  #10088374

  WARRANTY, CUSTOMER PAY AND/OR INTERNAL REPAIRS PERFORMED MUST BE VERIFIED BY A PUNCHED TIME FLAG ON THE BACK OF THE REPAIR ORDER HARD COPY. Read More »

UNKNOWN OR OTHER

• TSB #183

  Date Announced:

  DEC 03, 2007

  NHTSA ID:

  #10023674

  VOLVO SERVICE CAMPAIGN: SEE DOCUMENT SEARCH BUTTON FOR OWNER LETTER. PROTECTIVE TAPE AND A NEWLY DESIGNED RETAINING SPRING WILL BE INSTALLED ON MODEL YEAR 2006 & 2007 C70 TO PREVENT COMPONENTS FROM SCRATCHING THE PAINT DURING OPERATION OF ... Read More »

• TSB #167

  Date Announced:

  NOV 01, 2007

  NHTSA ID:

  #10021662

  VOLVO SERVICE CAMPAIGN: SEE DOCUMENT SEARCH BUTTON FOR OWNER LETTER. NEW SOFTWARE CREATED TO HELP IMPROVE BATTERY LIFE, ALARM FUNCTION, CLIMATE CONTROL, AND CUSTOMER SATISFACTION OF THE VEHICLE. *KB UPDATED 01/17/08. Read More »

• TSB #175

  Date Announced:

  JUL 16, 2007

  NHTSA ID:

  #10022534

  RETRACTABLE HARD TOP MECHANISM WILL BE INSPECTED / REPLACED IF NECESSARY. REROUTING OF THE WIRING HARNESS IN THE HARD TOP MECHANISM. TRUNK LID SEAL WILL BE REPLACED. SRS CONTROL UNIT WILL BE INSPECTED / REPLACED IF NEEDED. Read More »

• TSB #00163

  Date Announced:

  NOV 08, 2006

  NHTSA ID:

  #10020656

  NEW SOFTWARE AND COMPONENTS TO HELP ENSURE CUSTOMER SATISFACTION. VOLVO. *KB Read More »

• TSB #163

  Date Announced:

  NOV 08, 2006

  NHTSA ID:

  #10020771

  NEW SOFTWARE AND COMPONENTS TO ENSURE CUSTOMER SATISFACTION. *KB Read More »

• TSB #8844

  Date Announced:

  AUG 21, 2006

  NHTSA ID:

  #10021005

  OCCUPANT WEIGHT SENSOR (OWS) INSTALLATION. *KB Read More »

Browse Other C70 Years